PUMP TYPES. Pump Sizing. Dose to Gravity. Pumping to Gravity Distribution. Systems that need a Lift. Distribution Box and Tiered Trenches.
|
|
- Archibald Newton
- 5 years ago
- Views:
Transcription
1 PUMP TYPES Sump Clean Water Only Systems that need a Lift Effluent Multi stage Single stage Sewage Grinder Pumping to Gravity Distribution When STA is at higher elevation than septic tank Pump Sizing TDH Set by Location Impacted by flow GPM gpm Dose to Gravity Distribution Box and Tiered Trenches Do not pump downhill Does not result in uniform distribution in laterals Can discharge to either parallel or sequential network. Think about this before installing..
2 Pressure Manifold Pressure Distribution Designed to distribute effluent uniformly over infiltrative surface of receiving component. Pumping to Pressure Distribution Pressure Distribution Uses a network of small diameter pipe [1-2 ] and small orifices [1/8-1/4 ] NSFC The Right Pump for Pressure Distribution TDH Set by GPM Elevation Flow Rate Pipe Diameter Distribution Set by Number of orifices [6-10 sqft per orifice] Orifice size Operating pressure System Curve Pump Curve System Curve How Pump Works Elevation Head Pipe Friction Manifold Loss Where it Operates Pump Efficiency tdh Pump & System Curves gpm hp Pump 1.0 hp Pump System Curve at El 0 System Curve at El +5
3 Pressure Distribution Design considerations May use flow-splitting devices to minimize pump size Pump Vault Pumping from the Source Outside: In the System The pump Sizing Location Maximum Volume The floats The Electrical The controls The Sump Venting Pump Applications Media Filter
4 Pump Tank What size tank? Capacity Dose volume PLUS Storage Or Two Pumps Replaces storage Every Pump Should Be: Accessible Replaceable Wired Properly Elevated Controlled Accessible Access from surface Under the manhole Manhole to the surface Quick disconnect Not Fernco Reachable Within 20 of the surface Control Panel Line of Site Nuisance Replaceable Removable Pump Floats Ability to lift the pump Reconnecting the pump Electrician? Reconnecting the controls Pump Wiring In & out of the Tank Conduit [1-2 ] Electrical components sealed and watertight? Safe in the Sewage environment, EXCEPT FOR SPLICES!! Electrical tape is not watertight
5 Venting Be careful All electrical should be sealed If necessary vent thru a filter for odors Electrical The right size wire Pump size [hp] Distance Separate Circuits Pump Alarm Wiring Pump should be: Be careful of the power Hard conduit around the tank Elevated off bottom Storage Covered with effluent Protection Pump Basin [Elevated] Controlled Demand Piggy back Floats Timed Make sure the floats do not rest on the basin lip
6 Demand Dosing Dose occurs when sufficient volume of effluent has been collected. Dosing frequency depends on how much wastewater is being generated. There is no control on how much effluent is being dosed daily. Demand Dosing Two or Three floats On level sets the volume Check valve holds effluent in the piping Off level above the pump Water Level Sensors Float Pressure The Floats [Controls] Activation angle Voltage Wet Float Switches Mercury Float Switch Mechanical Float Switch Sensor Attachment Sensor can be: Tethered to float tree Weighted tether from riser Attached to bracket on riser
7 Float Tree Dose Volume (DV) Maximum~ Daily flow = 150 gal Minimum~ 4 times piping volume* Example: 3 trenches w/40 of 1.5 pipe 3 x 40 x 0.10 gal/ft 12 gal x 4 = 48 gals * Some sources say 5X piping volume Drawdown and Dose Volume Drawdown (in) = Dose Volume (gallons) GPI (gallons per inch) of drawdown Where: GPI = Area of dosing tank or chamber (in square ft) x ft x 7.5 gal/ft 3 Note: 1 = ½ ft or ft Area = length X width (of dosing chamber or dose tank) Calculating Drawdown Surface Area Rectangle: 4 x 7 tank L x W = Area 4 x 7 = 28 ft 2 Circle: 4 diameter Radius is half of diameter 4 2 = 2 Π x [radius] 2 = 3.14 x r x r 3.14 x 2 x 2 = 12.5 ft 2 Width= 4 Length= 7 Diameter = 4 Radius = 2 Top View Gallons Per Inch Area x x 7.5 gal/ft 3 = gal/inch 28 ft 2 x x 7.5 gal/ft 3 = 17.5 gal/in 12.5 ft 2 x x 7.5 gal/ft 3 = 7.8 gal/in Dose Volume (DV) Drawdown (in) = Dose Vol. GPI Dose volume ~ 100 gal Drawdown = 100 gal 17.5 gal/in 5.7 Plan View
8 Typical Pipe Volume Table Water Content (per ft. pipe) Nominal Pipe Size (in) Volume Weight (lbs.) (cu. in) (gallons) 1/ / / / / / / Without a Check Valve 100 gal Pumped Volume= PV Must subtract the drain back Drain back = Volume of pipe Drain back = Volume/LF x LF of pipe Ex: 60 of 2 inch pipe Drain back = 60 ft x 0.17 gal/ft = 10.2 gal Dose Volume = PV Drain back DV = 100 gal 10.2 gal = 89.8 gal that reaches the STA Floats Float Switch or Pump Cover ~ Off = 20 Dose~ On = 25.7 Alarm = 28.7 Piggy back Low cost Controlled by volume only Easy wiring Timers Timed Dosing A timer controls the number of doses per day and the dose volume. Will allow only a certain amount of effluent to be dosed daily. Protects downstream components from overloading. Useful for controlling surges or big-flow days.
9 Functions Off [Float] Turns timer off On Timer operates the pump Alarm Audible Visual Alarm Turns on the alarm Peak Enabler Changes the dosing frequency (PLC) Lateral Cleanouts Filter With ump Flushing Lateral PVC Lateral End w/ Clean-Out Valve Valve Types Box Orifice Shields To Soil Straight ends Threaded Pump Basin caps Ball valves Sweep 90 degree elbows (electrical sweeps are pressure rated) 2-45 degree 2" Sand elbows Leveling Layer Optional Lateral/Flushing Valve Connections Sand Backfill Sweep 2-45 Equipment Selection Don t let supplier select your equipment Better to talk to manufacturer Questions? DON T change components specified in design without consulting the designer; you are accepting liability
10 Low-Pressure Distribution Drainfield Shallow Narrow Drainfield Orifices in Laterals: Lay out and number the laterals Use a string line to mark pipe Pay attention to orientation and spacing Location of first/last orifice in each lateral may vary Drilling Orifices Pressure System Orifice Shields Use a new bit Use the correct size Keep media away from orifice Follow manufacturer recommendations Keep the drill vertical Don t wallow or it will be too large Orifice shape affects flow
11 Little to no slope Spacing and size of delivery devices Level sites: orifice size and spacing is typically the same in each lateral Spacing of delivery devices Sloping sites: spacing may vary to maximize uniformity CAUTION: if diameter varies, smaller orifices may clog more quickly Slope Balancing Unlevel Distribution Separate Pieces Goal: Splitting the flow equally Level ~Easy Problem Typically equal Separate pumps Alternating Splitter valves Hydro Splitter (ADV) Using Valves Balancing the pressure
12 Flow Regulating Valves Valve Boxes Adding one increases friction loss Globe valve is best but most expensive Gate valve is better Should NOT be a ball valve Design Questions? Orifice spacing and sizing Sprays to the same height Lower laterals Higher pressure Smaller holes Larger spacing
Washtenaw County DESIGN PROCEDURES AND ENGINEERING STANDARDS FOR PRESSURE DISTRIBUTION NETWORKS
Washtenaw County Department of Planning & Environment Development Services Division DESIGN PROCEDURES AND ENGINEERING STANDARDS FOR PRESSURE DISTRIBUTION NETWORKS 705 N. Zeeb Road Phone: (734) 222-3800
More informationFlood Dosed System Worksheet
Number of bedrooms Flood Dosed System Worksheet Septic tank size Minimum 1000 gallons Dosing tank size Minimum 800 gallons or 1 bedroom smaller than septic tank size whichever is larger Filter: gravity(in
More informationPressure Distribution. Western Canada Onsite Wastewater Management Association
Pressure Distribution EFFLUENT DISTRIBUTION Get even distribution Space the doses Layout the distribution system Make choices for: piping, orifices, volumes Use worksheets for calculations Dose or flush
More informationPressure Distribution Design
1 Pressure Distribution Design 2 Let s Start with Nonpressurized systems Historically the norm 3 Distribution Systems 4 Distribution Systems Non-pressurized Distribution Non-pressurized Distribution (cont.)
More informationEQUAL DISTRIBUTION OF WASTEWATER USING LOW-PRESSURE DISTRIBUTION Larry D. Stephens, P.E. *
EQUAL DISTRIBUTION OF WASTEWATER USING LOW-PRESSURE DISTRIBUTION Larry D. Stephens, P.E. * INTRODUCTION Experience with onsite systems has proven that equal application of wastewater over the entire soil
More informationCOURSE # 343 UNIT 4: ADVANTEX WASTEWATER TREATMENT SYSTEM. What you will learn in this lesson
What you will learn in this lesson IN THIS LESSON, YOU WILL LEARN... Installation steps for an AdvanTex Treatment System Important inspection points for installation inspection UNIT 4-1 Installation Steps
More informationAMERICAN RECIRCULATING SAND FILTER SYSTEMS
American Manufacturing Company, Inc. P.O. Box 549, Manassas, VA 20108 1-800-345-3132 AMERICAN RECIRCULATING SAND FILTER SYSTEMS ENGINEERING DESIGN GUIDELINES FOR COMMUNITY AND COMMERCIAL SIZED TREATMENT
More informationWorksheet for pressure distribution system design Long form with instructions and tables Rev. August 2007
Job: Date: Designer: Design number: Option number: Worksheet for pressure distribution system design Long form with instructions and tables Rev. August 2007 This is an iterative process, so each step might
More informationPRESSURE DISTRIBUTION COMPONENT MANUAL FOR PRIVATE ONSITE WASTEWATER TREATMENT SYSTEMS (VERSION 2.0) January 30, 2001
PRESSURE DISTRIBUTION COMPONENT MANUAL FOR PRIVATE ONSITE WASTEWATER TREATMENT SYSTEMS (VERSION 2.0) January 30, 2001 State of Wisconsin Department of Commerce Division of Safety and Buildings SBD-10706-P
More informationRecirculating Media Filters OWNER'S MANUAL
3649 Cane Run Road Louisville, KY 40211-1961, USA 1-800-928-7867 1-502-778-2731 Fax: 1-502-774-3624 clarusenvironmental.com SECTION: C3.20.140 CL0064 0515 Supersedes 1011 Recirculating Media Filters Register
More informationOperation and Maintenance
E-Z Set Company requires regular inspection and maintenance of the E-Z Treat Re- Circulating Sand/Media Filter, as a condition of purchase and ongoing operation compliance. The mandatory service contract
More information5220 SERIES Z-Cell OWNER'S MANUAL
3649 Cane Run Road Louisville, KY 40211-1961, USA 1-800-928-7867 1-502-778-2731 Fax: 1-502-774-3624 clarusenvironmental.com CL0180 0817 Supersedes New 5220 SERIES Z-Cell OWNER'S MANUAL Register your Clarus
More informationME3H/ME3F SERIES. Automatic and manual models. Single phase power only 115 or 230 volt.
ME3H SUMP/EFFLUENT PUMP ME3F SUMP/EFFLUENT PUMP ME3H/ME3F SERIES SUBMERSIBLE SUMP AND EFFLUENT PUMPS INSTALLATION AND SERVICE MANUAL Automatic and manual models. Single phase power only 115 or 230 volt.
More informationOrenco Automatic Distributing Valve Assemblies
This article may describe design criteria that was in effect at the time the article was written. FOR CURRENT DESIGN CRITERIA, call Orenco Systems, Inc. at 1-800-348-9843. Orenco Automatic Distributing
More informationON-SITE WASTEWATER PRODUCTS
NOTICE TO INSTALLER: Instructions must remain with installation. Product information presented here reflects conditions at time of publication. Consult factory regarding discrepancies or inconsistencies.
More informationTurbine STEP System SIMPLEX OR DUPLEX
3649 Cane Run Road Louisville, KY 211-1961, USA 1-800-928-7867 1-502-778-2731 Fax: 1-502-774-3624 www.clarusenvironmental.com SECTION: C1.20.120 CL0019 0816 Supersedes 1212 Turbine STEP System SIMPLEX
More informationSeptic Tanks. Effluent Screen Cleaning. Effluent Screens. Surveying Abbreviations. Installation Keys. Septic Tanks, Holding Tanks & Pump Tanks
Septic Tanks Gravity treatment Separation Sludge sinks Scum floats Storage Septic Tanks, Holding Tanks & Pump Tanks Bacteria SCUM breakdown CLEAR ZONE Chemical SLUDGE WW Strength= Organic Load Effluent
More informationE-Z Treat Installation Guidelines
E-Z Treat Installation Guidelines E-Z Treat Company or its representative will conduct on-site training with each installer before they are certified to install E-Z Treat systems. The training will include
More informationPUMP VAULT S.T.E.P. SYSTEM
Installation and Service Manual PUMP VAULT S.T.E.P. SYSTEM NOTE! To the installer: Please make sure you provide this manual to the owner of the equip ment or to the responsible party who maintains the
More informationInstallation Manual. AdvanTex AX100 Treatment Systems. Commercial Applications
Installation Manual AdvanTex AX100 Treatment Systems Commercial Applications 1-800-348-9843 +1-541-459-4449 www.orenco.com How To Use This Manual....Page 2 Before You Begin....Page 3 Standard System Components...Page
More informationSEPTIC TANK PUMP VAULT FILTER SYSTEM PUMP VAULT INSTALLATION AND SERVICE MANUAL
SEPTIC TANK PUMP VAULT FILTER SYSTEM PUMP VAULT INSTALLATION AND SERVICE MANUAL NOTE! To the installer: Please make sure you provide this manual to the owner of the equip ment or to the responsible party
More informationInstallation Manual. AdvanTex -AX20-RT Treatment Systems. Residential Applications. An illustrated guide to installing an Orenco AdvanTex
Installation Manual AdvanTex -AX20-RT Treatment Systems Residential Applications An illustrated guide to installing an Orenco AdvanTex AX20-RT Treatment System. Rev. 1.0, 1/10 Orenco Systems, Inc. Orenco
More informationINSTALLATION INSTRUCTIONS RECOMMENDED MODELS
Notice to installing contractor: Instructions must remain with installation. Product information presented here reflects conditions at time of publication. Consult factory regarding discrepancies or inconsistencies.
More informationAccess Riser Fits PRO370 and PRO380 Series
Installation Manual 7171000D Access Riser Fits PRO370 and PRO380 Series Contents 1.) General Information 2.) Installation 3.) Optional 2 Installation Kits 4.) Typical Installation Diagram 5.) Junction
More information2460 / 2472 / Series Simplex Grinder Systems
Installation Manual 5651000I 2460 / 2472 / 2484 - Series Simplex Grinder Systems Features: LSG or LSGX Series 2HP Grinder Pump 24 dia. Basin available in 60, 72, or 84 depths Guide Rail System Preassembled
More informationInstallation Manual. D3600- Series Duplex Grinder Systems. Contents
Installation Manual 7353000E D3600- Series Duplex Grinder Systems Features: 36 Diameter Fiberglass Tank Available in 48, 60, 72, 84, and 96 heights LSG Single or LSGX 2 Stage 2HP Grinder Pumps Factory
More informationSPECIFICATIONS EFFLUENT/SUMP SIMPLEX SYSTEM ZOELLER SUBMERSIBLE DEWATERING OR EFFLUENT PUMPS
Product information presented here reflects conditions at time of publication. Consult factory regarding discrepancies or inconsistencies. MAIL TO: P.O. BOX 16347 Louisville, KY 40256-0347 SHIP TO: 3649
More informationSPD50H/100H. Performance Data SPD100H SPD50H. Wholesale Products Page: Section: Performance Data Dated: April 2002 Supersedes: January 2001
Performance SPD50H/100H RPM: 3450 Discharge: 2" Solids: 3/4" Wholesale Products Page: 6130-1 Section: Performance Dated: April 2002 Supersedes: January 2001 SPD50H SPD100H The curves reflect maximum performance
More informationSequencing Batch Reactor. Reference Manual. Only modules bearing the NSF logo and designated PS1-XX are certified to NSF/ANSI Standards 40 and 245
Sequencing Batch Reactor Reference Manual Only modules bearing the NSF logo and designated PS1-XX are certified to NSF/ANSI Standards 40 and 245 2017 Anua 12-2017 Table of Contents 1.0 What s in the Box?
More informationPRE-PLUMBED SEWAGE SYSTEM
PRE-PLUMBED SEWAGE SYSTEM Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. MODEL #1910-0009 Español p. 13 ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems,
More informationWSB clean: Installation Manual
WSB clean: Installation Manual Models: WSB 400 WSB 1250 WSB 500 WSB 1500 WSB 600 WSB 1600 WSB 750 WSB 1800 WSB 1000 TABLE OF CONTENTS 1 INTRODUCTION...3 2 SAFETY INFORMATION...3 3 WSB CLEAN SYSTEM OPERATION...4
More informationPrivate Wastewater System Catalog. DSG - La Crosse (800)
Private Wastewater System Catalog DSG - La Crosse (800) 279-2726 FOR ALL THE CALL RIGHT TODAY...(800) CONNECTIONS!! 279-2726 1 GOULDS EFFLUENT PUMPS Part # PE31P1 1/3 hp with float switch and 20 ft cord
More informationSEWAGE PUMP MODEL # Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. Español p. 14
SEWAGE PUMP Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. MODEL #1261-0001 Español p. 14 ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems, missing parts?
More informationGB-250. Submittal Specifications Installation Application Specific Details
GREASE INTERCEPTOR TECHNICAL DATA Submittal Specifications Installation Application Specific Details 68" (1,727 mm) 13½" (343 mm) 51½" (1,308 mm) 38" (965 mm) SUBMITTAL 33½" (851 mm) STANDARD: 4" plain
More informationHALLMARK INDUSTRIES INC
Performance Part No. HP. CONVERTIBLE JET PUMP USER S MANUAL GPH of Water @ Total Discharge Pressure of 40 psi Max. Pressure Max suction (shallow well) Max Suction (deep well) Max GPM (@0 head) Max Discharge
More informationSUBMERSIBLE SUMP PUMPS
SUBMERSIBLE SUMP PUMPS Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. MODEL #1099-0001 Español p. 11 ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems, missing
More informationSubmersible Sump / Effluent Pump
ME3F, ME3H Series Submersible Sump / Effluent Pump INSTALLATION, OPERATION, & PARTS MANUAL SAFETY INFORMATION Carefully read and follow all safety instructions in this manual or on pump. This is the safety
More informationInstallation & Operating Manual
Installation & Operating Manual VN Series Non-Clog Pumps Congratulations On Your Choice In Purchasing This Webtrol Pump 10/15 Edition Its Quality is unsurpassed in material and workmanship and has been
More informationInstallation Manual. Q Series Quadplex Grinder Systems. Contents
Installation Manual 7759000A Q4800 - Series Quadplex Grinder Systems Features: 48 Diameter Fiberglass Tank Available in 84, 96, and 120 heights LSG Single or LSGX 2 Stage 2 HP Grinder Pumps Factory Installed
More informationInstallation Instructions
E/One Sewers TM Installation Instructions for Flexible Hose & Horizontal Slideface Read all instructions before proceeding with installation. 1 AMGP INSTALLATION LAYOUT SHEET 3 After Market Grinder Pump
More informationPump Specifications Series. Pre-assembled Duplex Sewage System 30 x 36, 110 Gallon
Pump Specifications 1100-Series Pre-assembled Duplex Sewage System 30 x 36, 110 Gallon 1100-P1 R2/19/2013 Copyright 2013 Liberty Pumps Inc. All rights reserved. Specifications subject to change without
More informationHYDROMATIC SPD50H/100H SUBMERSIBLE HIGH HEAD, DOUBLE SEAL EFFLUENT
PERFORMANCE DATA Wholesale Products Page: 6130-1 Supersedes: April 2002 RPM: 3450 Discharge: 2 Solids: ¾ SPD50H SPD100H HEAD-METERS 18 12 6 TOTAL HEAD IN FEET 60 40 20 0 0 Capacity-U.S. G.P.M. SPD50H SPD100H
More informationInstallation Manual. AdvanTex AX-RT Treatment Systems. Residential Applications
Installation Manual AdvanTex AX-RT Treatment Systems Residential Applications 1-800-348-9843 +1-541-459-4449 www.orenco.com How To Use This Manual... Page 2 Before You Begin... Page 3 Septic Tanks Used
More informationSUBMERSIBLE SUMP PUMPS
SUBMERSIBLE SUMP PUMPS Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. MODELS #1073-0001, 1075-0001 Español p. 9 ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems,
More informationINSTALLATION GUIDE. Model #GB1 20/25 GPM Grease Interceptor For Indoor Use. Contents
INSTALLATION GUIDE Model #GB1 20/25 GPM Grease For Indoor Use Contents Special Precautions............................................ 2 Getting to Know the GB1........................................
More informationWHR/WHRH and WHRE WASTE HANDLING SUMP PUMPS
WHR/WHRH and WHRE WASTE HANDLING SUMP PUMPS Installation and Servicing Instructions for Myers WHR/WHRH and WHRE Submersible Sump Pumps Single & Three Phase Power Single & Double Seal SINGLE SEAL PUMPS
More informationYour Premier Pump Choice!
Limited Warranty During the time periods and subject to the conditions hereinafter set forth, Keen Pump will repair or replace to the original user or consumer, any portion of your new Keen product which
More informationLane Reverse Q Pond Outlet Installation and Maintenance Guide
Lane Reverse Q Pond Outlet Installation and Maintenance Guide Introduction The Lane Reverse Q (RQ) Pond Outlet is a unique and extremely cost effective storm water Best Management Practices (BMP), which
More informationGB-35. Submittal Specifications Installation Application Specific Details. PART #: XX DWG BY: C. O'Boyle DATE: 10/08/2015 REV: 0 / /201_ ECO:
GREASE INTERCEPTOR TECHNICAL DATA Submittal Specifications Installation Application Specific Details 33" (83.8 cm) 10" (25.4 cm) (63.5 cm) 15" (38.1 cm) (63.5 cm) SUBMITTAL STANDARD: 3" plain end inlet/outlet
More informationAqua Green Utility Inc.
Aqua Green Utility Inc. Individual septic tank and pump tank requirements. Only configurations and equipment approved by Aqua Green Utility Inc. may be used. Not following these configurations shall be
More informationElectricity 1
1 Tom Fritts tom@residentialsewage.com 2 Minnesota code?? Why this class?? Troubleshooting Selling the system Know how to calculate usage cost for the homeowner Minimize the surprises You are responsible.
More informationPipe fittings MUST be installed by a certified welder only. +GF+ SIGNET will not assume liability of any kind for improper fitting installations.
+GF+ SIGNET 0 High Performance Flow Sensor (English) -0.090- F-/99 English SAFETY INSTRUCTIONS. Do not remove from pressurized lines.. Do not exceed maximum temperature/pressure specifications.. Do not
More informationPump ED 101. Variable, Fixed Speed Control - - Float Switch Activation. Introduction
Pump ED 11 Variable, Fixed Speed Control - - Float Switch Activation Joe Evans, Ph.D http://www.pumped11.com Introduction It has been said that there is more than one way to skin a cat. In fact, there
More informationVariable Speed Pumping
Variable Speed Pumping Jim Vukich Application Engineer ITT Corp. Malvern, PA Why Do It? Why Do It? Flow-Matching Minimize Starting & Stopping Flexibility Different Discharge Points, Flows Changing Conditions
More informationCHAPTER 7 PUMPING SYSTEM DESIGN
CHAPTER 7 PUMPING SYSTEM DESIGN 7-1. FORCE MAIN HYDRAULICS. a. General. The pipeline which receives waste-water from a pumping station, and conveys it to the point of discharge, is called a force main.
More informationOSCAR- LOWeFLOW Treatment System Homeowner s Manual. January 2016
OSCAR- LOWeFLOW Treatment System Homeowner s Manual January 2016 US Patent number 8,889,007 Manufactured by: Lowridge Onsite Technologies PO Box 1179 Lake Stevens, WA 98258 O: 877 476-8823 info@lowridgetech.com
More informationInstallation Manual. AdvanTex AX20 Treatment Systems. Residential Applications
Installation Manual AdvanTex AX20 Treatment Systems Residential Applications 1-800-348-9843 +1-541-459-4449 www.orenco.com Orenco Installation Manual: AX20 Treatment Systems How To Use This Manual... Page
More informationINSTALLATION GUIDE. Model #GB2 35/50 GPM Grease Interceptor For Indoor Use. Contents
INSTALLATION GUIDE Model #GB2 35/50 GPM Grease For Indoor Use Contents Special Precautions............................................ 2 Getting to Know the GB2....................................... 3
More informationCSO/STORMWATER MANAGEMENT. HYDROVEX FluidHook Control Gate Valve
CSO/STORMWATER MANAGEMENT HYDROVEX FluidHook Control Gate Valve HYDROVEX FLUIDHOOK CONTROL GATE VALVE APPLICATION The flow regulation at storm overflows or retention facilities is usually performed with
More informationAdvanTex Operation and Preventive Maintenance
AdvanTex Operation and Preventive Maintenance Commercial Application 2/1/2011 #1 O&M is Important Because... It refines/optimizes process It ensures system longevity It establishes accountability It protects
More informationGRINDER PUMP MODEL # Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. Español p. 13
GRINDER PUMP Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. MODEL #2701-0005 Español p. 13 ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems, missing parts?
More informationOIL SMART PLUG AND PLAY SYSTEM, Model #OSS-100
OIL SMART PLUG AND PLAY SYSTEM, Model #OSS-100 The Oil Smart OSS-100 System, when combined with a manual sump pump, will automatically pump water without the risk of pumping oil into the environment. Additionally,
More informationONSITE WASTEWATER TREATMENT SYSTEM Property Transfer Certification Instructions and Inspection Report
ONSITE WASTEWATER TREATMENT SYSTEM Property Transfer Certification Instructions and Inspection Report These instructions are for homeowners and inspectors completing the onsite wastewater treatment system
More informationPipe fi ttings MUST be installed by a certifi ed welder only. Signet will not assume liability of any kind for improper fi tting installations.
Signet 50 High Performance Flow Sensor English *3-50.090* 3-50.090 C 05/06 English SAFETY INSTRUCTIONS 1. Do not remove from pressurized lines.. Do not exceed maximum temperature/pressure specifi cations.
More informationBioSTEP Screened Pumping System Installation & Service Manual
BioSTEP Screened Pumping System Installation & Service Manual FOR USE WITH BioSTEP 1618 BioSTEP Manual Bio-Microbics, Inc. Revised June 2013. BioSTEP is a registered trademark owned by Bio-Microbics, Inc.
More informationDEFENDER SERIES. 5 Gallon, Double Walled, Field Replaceable Spill Container Model Series INSTALLATION, OPERATION, & MAINTENANCE
DEFENDER SERIES 5 Gallon, Double Walled, Field Replaceable Spill Container Model 705-550 Series INSTALLATION, OPERATION, & MAINTENANCE Franklin Fueling Systems 3760 Marsh Rd. Madison, WI 53718 USA Tel:
More informationSKHS SERIES 2 HP 1-1/2 HP 1 HP 1/2 HP CAPACITY-U.S. G.P.M.
Performance RPM: 3450 Discharge: 2" Solids: 2" Wholesale Products Page: 6560-1 Section: Performance 80 70 2 HP TOTAL DYNAMIC HEAD-FEET 60 50 40 30 20 1 HP 1-1/2 HP 1/2 HP 10 0 0 32 64 96 128 160 192 CAPACITY-U.S.
More informationInst all a ti o n and Oper a tin g Instru c ti o n s
Inst all a ti o n and Oper a tin g Instru c ti o n s Congratulations, you are now the proud owner of an Aqua2use GWDD! INSTALLATION OF PUMP OPERATED AQUA2USE GWDD The Matala Aqua2use GWDD is specifically
More informationSignet 2517 Brass Paddlewheel Flow Sensor * *
Signet 2517 Brass Paddlewheel Flow Sensor -250.090 English -2517.090 Rev. F 11/06 English SAFETY INSTRUCTIONS 1. Do not remove from pressurized lines. 2. Do not exceed maximum temperature/pressure specifi
More informationIon Technologies SHR-HR Submersible Sewage Pump Single Seal, Single Phase, & Three Phase Power
Page 1 of 8 equipment and follow handling procedures per OSHA 29 CFR 1910.1030 when handling equipment after waste water source has been connected to system. WARNING: Risk of Asphyxiation. Installer(s)
More informationSeries: PFSWCPC75. 3/4 HP 1750 RPM 60 Hz Submersible Sewage Pump OWNER S MANUAL. Power-Flo Pumps & Systems PUMPS
OWNER S MANUAL Series: PFSWCPC75 3/4 HP 1750 RPM 60 Hz Submersible Sewage Pump ISP No: PFSWC75-8/1/15 General Safety Information Before installation, read the following instructions carefully. Failure
More informationCommercial Sewage & Waste Water Systems
Commercial Sewage & Waste Water Systems EDP-4 72 Gallon 24 x 36 Basin EDP-6 108 Gallon 30 x 36 Basin EDP-8 158 Gallon 36 x 36 Basin 1/2 HP pump 2 PVC Sch 80 discharge, 3 float switches and cover 2 NPT,
More informationBattery Backup Sump Pump System
Instruction Manual & Safety Warnings Table of Contents Important Safety Warnings and Instructions Electrical precautions 1 Battery preparation 1 Battery precautions 1 Introduction Items included in system
More informationCATALOGUE SEWAGE MANHOLES
CATALOGUE SC SEWAGE MANHOLES Table of contents TABLE OF CONTENTS Introduction 4 Inspection chamber, type 315 7 Inspection chamber, type 400 10 Inspection chamber, type 425 14 Assembly instruction 19 Catch
More informationRecold JW Series. Lenntech. Tel Fax ENGINEERING DATA AND SPECIFICATIONS
Lenntech info@lenntech.com Tel. +31-152-610-900 www.lenntech.com Fax. +31-152-616-289 ENGINEERING DATA AND SPECIFICATIONS Recold JW Series FLUI D COOLER Recold JW Series Fluid Cooler Contents 2 Construction...
More informationSequencing Batch Reactor. Maintenance Manual. Only modules bearing the NSF logo and designated PS1-XX are certified to NSF/ANSI Standards 40 and 245
Sequencing Batch Reactor Maintenance Manual Only modules bearing the NSF logo and designated PS1-XX are certified to NSF/ANSI Standards 40 and 245 2017 Anua 12-2017 Table of Contents Maintenance Manual
More informationOne City Plaza, Suite B P.O. BOX 1287 Cabot, Arkansas Phone Revised: April 2, 2019
One City Plaza, Suite B P.O. BOX 1287 Cabot, Arkansas 72023 Phone 501-843-4654 Revised: April 2, 2019 Cabot WaterWorks Grinder Pump Procurement and Installation Guide Grinder Pumps are only permitted in
More informationInstallation Manual. Omnivore Grinder Pump Retrofit Unit LSG202-RE. LSGX202-RE 2Hp, V, 1 phase, Automatic LSG202-REX
Installation Manual 5672000E Omnivore Grinder Pump Retrofit Unit FOR E-ONE* GP200, GP2000 AND EXTREME SERIES Models to replace GP200 and GP2000: LSG202-RE 2Hp, 208/230V, 1 phase, Automatic LSGX202-RE 2Hp,
More informationSUBMERSIBLE SEWAGE PUMPS
S3W S3WR MODELS 1750 and 3450 RPM S3W, S3WR SERIES SUBMERSIBLE SEWAGE PUMPS INSTALLATION AND SERVICE MANUAL Single and dual seal. Single and three phase power. NOTE! To the installer: Please make sure
More informationSaniTEE Wastewater Screens Installation & Service Manual FOR USE WITH SNT416, SNT418, SNT818, SNT 838, SNT1618, and SNT1638
SaniTEE Wastewater Screens Installation & Service Manual FOR USE WITH SNT416, SNT418, SNT818, SNT 838, SNT1618, and SNT1638 SaniTEE Manual Bio-Microbics, Inc. Revised December 2009. SaniTEE is a registered
More informationWHR/WHRH and WHRE WASTE HANDLING SUMP PUMPS
WHR/WHRH and WHRE WASTE HANDLING SUMP PUMPS Installation and Servicing Instructions for Myers WHR/WHRH and WHRE Submersible Sump Pumps Single & Three Phase Power Single & Double Seal SINGLE SEAL PUMPS
More informationPump Specifications 405 Series Commercial Drain Pump (High-Temp)
Pump Specifications 405 Series Commercial Drain Pump (High-Temp) 405_P1 R8/22/2017 Copyright 2017 Liberty Pumps Inc. All rights reserved. Specifications subject to change without notice. 405-Series Dimensional
More informationPEDESTAL SUMP PUMP. MODEL # Español p. 11. Zoeller is a registered trademark of Zoeller Co. All Rights Reserved.
PEDESTAL SUMP PUMP Zoeller is a registered trademark of Zoeller Co. All Rights Reserved. MODEL #1084-0001 Español p. 11 ATTACH YOUR RECEIPT HERE Serial Number Purchase Date Questions, problems, missing
More informationFully Automatic Bilge Pump INSTRUCTION MANUAL
Fully Automatic Bilge Pump INSTRUCTION MANUAL Purpose of this manual The purpose of this manual is to provide necessary information for product installation, operation and maintenance. CAUTION: Read this
More informationLOWeFLOW -UV Treatment System O& M and Troubleshooting Manual January 2017
LOWeFLOW -UV Treatment System O& M and Troubleshooting Manual January 2017 US Patent 8,889,007 Manufactured by: Lowridge Onsite Technologies PO Box 1179 Lake Stevens, WA 98258 O: 877 476-8823, C: 425 750-4922
More informationARIES THINWALL DRIPLINE
N E T A F I M U S A ARIES THINWALL DRIPLINE TM REVOLUTIONARY TURBUNEXT TM TECHNOLOGY IN A NON-COMPENSATING SETS A NEW STANDARD FOR CLOG RESISTANCE AND ENHANCED PERFORMANCE ARIES TM THINWALL DRIPLINE Netafim
More informationSpiral Scraper Clarifier
Spiral Scraper Clarifier Key features & benefits Special design developed for faster sludge removal Best performance on 1:12 floor slope How we create value Low maintenance requirements Trouble-free installation
More informationPump Specifications. D3648LSG, D3648LSGX Series Omnivore 2HP Duplex Grinder Packages LITERS PER SECOND
Pump Specifications D3648LSG, D3648LSGX Series Omnivore 2HP Duplex Grinder Packages LITERS PER SECOND 200 0.0 0.5 1.0 1.5 2.0 2.5 3.0 3.5 60 190 180 170 160 LSGX - TWO STAGE 50 150 140 130 40 FT. OF HEAD
More informationGL0098P Beta+ Septic Tanks Installation & Operation Guidelines
000535 GL0098P Beta+ Septic Tanks Installation & Operation Guidelines Kingspan Environmental Service Contact Numbers: UK: 0844 846 0500 NI: 028 3025 4077 IRL: 048 3025 4077 Enclosed Documents DS1151P Beta+
More informationInstallation Manual. Engineered Pump Systems (EPS) Common Components: Manual Contents:
Installation Manual 7298000B Engineered Pump Systems (EPS) By definition, an EPS system is a custom product and some differences in materials, pumps, and design are unavoidable. This manual is intended
More informationABCD BFDC BEDA AB CDEFCC
ABCD BFDC BEDA AB CDEFCC ABCD BFDC BEDA AB CDEFCC AFC Oil/ Water Separator Specifications and Operation & Maintenance Schedule 1) Model of AFC Oil/ Water Separator: a)
More informationD-023 PN 16 / 25. Combination Air Valve for Wastewater PATENTED. Description. Applications. Operation. Main Features
PN 16 / 25 Wastewater Combination Air Valve for Wastewater PATENTED EuroC-D023SWG-15-2 Description The D-023 Combination Air Valve combines an air & vacuum component and an air release component in a single
More informationThe Pump Matic Range
The Below Ground packaged pumping Stations Ideal for - Sewage, Wastewater, Stormwater Pump Technology Ltd, manufactures its own pumping station tanks. We have complete control over the construction, quality
More informationInstallation, Operation and Maintenance Manual Stancor SSD & SL Series Pumps
Installation, Operation and Maintenance Manual Stancor SSD & SL Series Pumps EI-700-008 Rev -- Table of Contents Safety Guidelines 3 Caution 4 Wiring 4 Maintenance 4 Nameplate format 4 Prior to Operation
More informationMarathon 205 North St. Marathon, WI toll free (800) Gallon Septic Tank (Low Profile, 3-inch Floor)
Drawing #: CM-ST-650 Septic Tank Table of Contents Section A: Drawing #: CM-ST-650 CM-ST-750 CM-ST-1000 CM-ST-1000-LP CM-ST-1250 CM-ST-1650 CM-ST-1650-2COMP CM-ST-2COMP-5FL CM-HT-2000-W CM-ST-2000 CM-ST-2000-W
More informationSystem Startup Manual. SeptiTech Wastewater Pretreatment System Models:
System Startup Manual SeptiTech Wastewater Pretreatment System Models: M400 / M400D M550 / M550D M750 / M750D M1200 / M1200D M1500 / M1500D M3000 / M3000D SeptiTech, LLC. 69 Holland Street, Lewiston, ME
More informationW/D/V-A1. Submersible Sump Pump. Pump Installation and Service Manual W-A1 V-A1 D-A1
Pump Installation and Service Manual W/D/V-A1 Submersible Sump Pump W-A1 D-A1 V-A1 NOTE! To the installer: Please make sure you provide this manual to the owner of the pumping equipment or to the responsible
More informationHYDROMATIC SKHS SERIES SUBMERSIBLE NON-CLOG, SEWAGE EJECTOR
PERFORMANCE DATA Wholesale Products Page: 6560-1 RPM: 450 Discharge: 2 Solids: 2 80 70 2 HP 60 TOTAL DYNAMIC HEAD-FEET 50 40 0 1 HP 1-1/2 HP 1/2 HP 20 10 0 0 2 64 96 128 160 192 CAPACITY-U.S. G.P.M. The
More informationCSO/STORMWATER MANAGEMENT. Hydrovex VHV / SVHV Vertical Vortex Flow Regulator
CSO/STORMWATER MANAGEMENT Hydrovex VHV / SVHV Vertical Vortex Flow Regulator HYDROVEX VHV / SVHV VERTICAL VORTEX FLOW REGULATOR INTRODUCTION One of the major problems of urban wet weather flow management
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS EARTHSAFE D10 WASTEWATER TREATMENT SYSTEM A. PREPARING THE SITE INSTALLATION SUGGESTIONS See if you can site the tanks away from commonly used vehicular access, and also away
More information