TYPICAL DIAGNOSTIC REFERENCE VALUES >
|
|
- Andrew Gallagher
- 5 years ago
- Views:
Transcription
1 ENGINE CONTROLS - REFERENCE VALUES - F250-F L (DIESEL ) TYPICAL DIAGSTIC REFERENCE VALUES > Footnotes are referenced throughout the Typical Diagnostic Reference Value Charts. A letter in parentheses next to a value indicates supplemental information is applicable. An attempt is made to provide as much information as possible; some vehicles may not display all input and output signals. Reference values may vary 20% depending on operating conditions, engine load, temperature, altitude, vehicle speed and other factors. RPM values are axle and tire dependent. Refer to PARAMETER IDENTIFICATION (), for descriptions. Values are taken at an altitude of approximately m (600 ft) above sea level. Refer to Introduction, ACRONYMS AND DEFINITIONS for technical terms applicable to Ford Motor Company products. For detailed transmission diagnostics, refer to the Workshop article. A. Value may vary 20% depending on altitude, operating conditions, weather, and other factors. B. Value is dependent upon ambient air temperature and may fall outside of range. C. Value is dependent on fuel tank level. Typical operating range is 15% (empty) to 85% (full). D. Value is not useful under this condition. 6.4L 4V F-SUPER DUTY > 1 tips Question: quit running /no start www1.prodemand.com/print/index?content=tabs&module=true&tab=true&terms=true&ymms=false 1/7
2 Fig 1: 96-Pin Engine Connector Courtesy of FORD MOTOR CO. Fig 2: 58-Pin Body Connector Courtesy of FORD MOTOR CO. SENSORS/INPUTS Sensors/Inputs PCM Pin/ only KOEO Measured/ Values Hot Idle 48 KM/H (30 MPH) 89 KM/H (55 MPH) Units Measured/ APP1 B DCV ACC_SW_1 B14 OFF OFF ACTIVE ACTIVE OFF/ACTIVE APP2 B DCV ACC_SW_2 B28 OFF OFF ACTIVE ACTIVE OFF/ACTIVE BOO B29 OFF OFF OFF OFF ON/OFF ACCS E36 OFF OFF OFF OFF ON/OFF AC_REQ E36 OFF OFF OFF OFF ON/OFF FRP E /0 1.2/ / /8240 DCV/PSI MAP E / / / /21.5 DCV/psi www1.prodemand.com/print/index?content=tabs&module=true&tab=true&terms=true&ymms=false 2/7
3 MAF_HZ E khz IAT E / / / /91.4 EOT E / / / /201 FRT E / / / /68 EGRTV_B E DCV ECT E / / / /196 EGRVP E DCV IAT2 E87 2.6/ / / /100 EGRTV_A E DCV 4X4L OFF OFF OFF OFF ON/OFF ACCLT_ALW YES YES YES YES YES/ ACC_CMD OFF OFF OFF OFF ON/OFF ACP / CLOSED ADPT_INJ APP % APP_MODE CT CT PT PT CT, PT, WOT AST 00: :01 57:43 MIN:SEC AXLE 4.88:1 4.88:1 4.88:1 4.88:1 RATIO BARO DCV/psi BPA OFF OFF OFF OFF ON/OFF CLRDIST Miles CLRWRMUP Numeric Value CMP_F / CPP OFF OFF OFF OFF ON/OFF CPP/PNP NEUTRAL NEUTRAL DRIVE DRIVE DRIVE/ NEUTRAL DECHOKE YES/ DPF psi www1.prodemand.com/print/index?content=tabs&module=true&tab=true&terms=true&ymms=false 3/7
4 DPF_STATUS INACTIVE INACTIVE ACTIVE ACTIVE INACTIVE/ ACTIVE DPF_TIM_L1 00:00 00:00 00:00 00:00 MIN:SEC DPF_TIM_L2 00:00 00:00 00:00 00:00 MIN:SEC DPF_TIM_L3 00:00 00:00 00:00 00:00 MIN:SEC DPF_V DCV DTCCNT Numeric Value EBP DCV EBP_A psi ECT_F / EGR EVAL YES YES/ EGRPCT % EGRT_A DEG (F) EGRT_B DEG (F) EGRVP DCV EGRVPA % EGR_ERR % EGR_F / EGT DEG (F) EGT11_V DCV EGT DEG (F) EGT12_V DCV EGT DEG (F) EGT13_V DCV FANSS RPM FANSSM LOW LOW LOW LOW LOW/HIGH FLI % GENFIL ON OFF OFF OFF ON/OFF GENMON % GENMON % www1.prodemand.com/print/index?content=tabs&module=true&tab=true&terms=true&ymms=false 4/7
5 GENMON_FS / GENMON_FS2 / GENMON_HZ Hz GENMON_HZ Hz GENMON_LS GENMON_LS2 / / GPL OFF OFF OFF OFF ON/OFF IAT_F / INJ1-8_OFF INJ1-8_ON OFF ON ON ON ON/OFF KAM FUSE YES/ KEYST RUN RUN RUN RUN Key state LOAD % MAF_F / MGP psi MIL OFF OFF OFF OFF ON/OFF MIL_DIS Miles MIL_TCMREQ YES/ MISFIRE YES/ MISF_EVAL YES/ PARK_BRK OFF OFF OFF OFF ON/OFF PATSENABL ENABLED ENABLED ENABLED ENABLED PNP NEUTRAL NEUTRAL DRIVE DRIVE ENABLED/ DISABLED NEUTRAL /DRIVE RPM RPM RPMDSD RPM START_ALW ON OFF OFF OFF ON/OFF www1.prodemand.com/print/index?content=tabs&module=true&tab=true&terms=true&ymms=false 5/7
6 STRT_RLY ENABLED DISABLED DISABLED DISABLED DISABLED/ ENABLED SYNC YES YES YES YES/ TORQUE 590 (D) N.m TP_F / TQ_CNTRL NE NE NE NE TQ_MOD YES/ VGT_F / VREF DCV VSS SPEED (MPH) WAC/ACCR OFF OFF OFF OFF ON/OFF WFS YES/ ACTUATORS/OUTPUTS Actuators/Outputs PCM Pin/ only KOEO Measured/ Values Hot Idle 48 KM/H (30 MPH) 89 KM/H (55 MPH) Units Measured/ F_VOL_REG E % GPC E % F_PRS_REG E % EBP_ DSD psi EGRTP % EGRVPDES % FANDC % FPL_CMD ON ON ON ON ON/OFF FRP_DSD psi FUELPW μs GENCMD % GENCMD % GENCMD_LF / / www1.prodemand.com/print/index?content=tabs&module=true&tab=true&terms=true&ymms=false 6/7
7 GENCMD_LF2 GENCOM % GENVDSD 12 (V) (V) 14 (V) 14 (V) DCV GENVDSD2 6 (V) 6 (V) 6 (V) 6 (V) DCV GPCTM SECONDS GPLTM SECONDS GP_LMP OFF ON OFF OFF ON/OFF INJ_TIM (-)2.26 (-).84 DEG MFDES MASS grams/stroke PTO OFF OFF OFF OFF ON/OFF SFT_CYL 1-8 % OTHER VGTDC % VGT_MES % Other PCM Pin/ only KOEO Measured/ Values Hot Idle 48 KM/H (30 MPH) 89 KM/H (55 MPH) Units Measured/ VPWR B1,B3,B DCV VREF B22, E DCV B DCV CLRTIME 34:00 29:00 2:12:00 2:08:00 HR:MIN:SEC ENG_MF_LF YES/ ENG_SD_LF YES/ FUEL_EVAL YES/ MILTIME 00:00 00:00 00:00 00:00 HRS:MIN:SEC NM COUNT PCM_RESET COUNT TIRESIZE 653RPM 653RPM 653RPM 653RPM www1.prodemand.com/print/index?content=tabs&module=true&tab=true&terms=true&ymms=false 7/7
Diesel Engine Performance Diagnosis. 51 Diesel Engine Performance FCS21133REF. Student Guide FCS REF. Course Code: 51S08T2 VERSION 2
Diesel Engine Performance Diagnosis 51 Diesel Engine Performance Student Guide FCS21133REF FCS 21133 REF Course Code: 51S08T2 VERSION 2 IMPORTANT SAFETY NOTICE NOTE: Ford Motor Company reserves the right
More informationPage 1 of 6 2008 Ford Pickup 6.4L Eng F250 Super Duty ENGINE CONTROLS - DESCRIPTION AND OPERATION - F250-F550 SUPER DUTY 6.4L (DIESEL ) FUEL SYSTEM The fuel system includes the following: low pressure
More information6.0L BUILT ON OR BEFORE 9/29/2003 DTCS P006A TSB OR P132B LACKS POWER, SURGE, OR FLUTTER AFTER FIELD SERVICE ACTION 06E17
6.0L BUILT ON OR BEFORE 9/29/2003 DTCS P006A TSB 06-24-6 OR P132B LACKS POWER, SURGE, OR FLUTTER AFTER FIELD SERVICE ACTION 06E17 FORD: 2003-2004 Excursion, F-Super Duty ISSUE 3. Using IDS datalogger,
More informationAlliant Power Technical Support p f alliantpower.com. Step 1: Visual Inspection of Engine Compartment OK Not Ok Comments
6.0 L Low Power/All Times Step 1: Visual Inspection of Engine Compartment OK Not Ok Comments Inspect the cooling hoses and connections Inspect the battery cables and connections Inspect the wiring harnesses
More informationOn Board Diagnostics II Diesel PCED
Page 1 of 6 1997 PCED On Board Diagnostics II Diesel SECTION 6C: Reference Values PCM Pin Descriptions and Expected Values 49 State Except Econoline Control System Diagnostic Sheet Reference Pin # Name
More informationDRIVEABILITY BI-FUEL PARAMETER IDENTIFICATION DATA (PID) INPUT AND OUTPUT INFORMATION VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY
DRIVEABILITY BI-FUEL PARAMETER Article No. IDENTIFICATION DATA (PID) INPUT AND OUTPUT 01-10-1 INFORMATION VEHICLES EQUIPPED WITH 5.4L OR 6.8L BI-FUEL ENGINE ONLY FORD: 1998-2001 E-250, E-350, F-150, F-250
More informationRX8 - Workshop Manual - Engine
2004 RX-8 2004 - RX8 - Workshop Manual - Engine PCM INSPECTIONNot Using the WDS or Equivalent Report a problem with this article NOTE: The PCM terminal voltage can vary with conditions when measuring and
More informationDiagnostic Trouble Codes (continued) Ford Specific Codes
92 Ford Specific Codes P11XX Fuel and Air Metering P1000 OBD-II Monitor Drive Cycle Not Completed P1001 KOER Self-Test Not Completed, Test Aborted P1100 Mass Airflow MAF Sensor Intermittent P1101 Mass
More informationPage 1 of 9 2004 Ford Pickup 5.4L Eng VIN L F250 Super Duty 1Search Print Date: P0720 Pinpoint Test F: Turbine Shaft Speed (TSS) And Output Shaft Speed () Sensors NOTE: Refer to the Output Shaft Speed
More informationMULTIPORT FUEL SYSTEM (MFI) <2.4L ENGINE>
13A-1 GROUP 13A MULTIPORT FUEL SYSTEM (MFI) CONTENTS GENERAL DESCRIPTION......... 13A-2 FUEL INJECTION CONTROL...... 13A-5 THROTTLE VALVE OPENING ANGLE CONTROL..................... 13A-6
More informationDE: Exhaust Back Pressure (EBP) Sensor
2002 PCED OBDII-Diesel SECTION 5: Pinpoint Tests DE: Exhaust Back Pressure (EBP) Sensor DE: Introduction DE1 DIAGNOSTIC TROUBLE CODE (DTC) P0470 DTC P0470 indicates an EBP sensor malfunction was detected
More informationMaxxForce DT, 9, 10 (2010)
MaxxForce DT, 9, 10 (2010) Overview: Setup Setup TABLE OF CONTENTS General Overview: Setup... 1 Description and Operation... 1 Programmable Parameters... 1 Definitions/Acronyms... 3 Setup i General Overview:
More informationPage 1 of 18 2004 PCED On Board Diagnostics SECTION 5: Pinpoint Tests Procedure revision date: 10/26/2007 H: Fuel Control H: Introduction H1 PERFORM THE KOER SELF-TEST Engine at normal operating temperature.
More informationENGINE OUTLINE ENGINE ABBREVIATIONS ENGINE FEATURES [L8, LF]
ENGINE SECTION Toc of SCT OUTLINE -00 ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (L8, LF)] -0A ON-BOARD DIAGNOSTIC [MZR-CD (RF Turbo)] -0B MECHANICAL [L8, LF] -0A MECHANICAL [MZR-CD (RF Turbo)] -0B LUBRICATION
More informationNote PIDs for the following parts are not available on this model. Go to the appropriate part inspection page. CMP sensor Main relay
PCM INSPECTION [L8, LF, L5] Using M-MDS id014046802500 Note PIDs for the following parts are not available on this model. Go to the appropriate part inspection page. CMP sensor Main relay 1. Connect the
More informationhttp://www.prodemand.com/print/index?content=tabs&module=true&tab=true&terms=tr... Page of //0 00 Ford Pickup.0L Eng F0 Super Duty Service Manual: WIRING DIAGRAMS - F0 SUPER DUTY ENGINE PERFORMANCE >.0L
More informationDiagnostic Trouble Code (DTC) Charts and Descriptions
Page 1 of 126 2006 PCED On Board s SECTION 4: Powertrain DTC Charts and Descriptions Procedure revision date: 04/06/2006 Trouble Code (DTC) Charts and Descriptions Note: Refer to the applicable Workshop
More information2000 Ford Mustang Diagnostic Trouble Code (DTC) Descriptions. DTC Description Possible Causes Diagnostic Aides
2000 Ford Mustang Diagnostic Trouble Code (DTC) Descriptions DTC Description Possible Causes Diagnostic Aides P0102 - Mass Air Flow The MAF sensor circuit MAF sensor A MAF V PID (MAF PID) (MAF) Circuit
More informationSECTION 4: Diagnostic Subroutines. Table of Contents
SECTION 4: Diagnostic Subroutines Table of Contents Contents PAGE Hard Start/No Start Diagnostic Procedures... 4-2 1. Visual Engine/Chassis Inspection... 4-4 2. Check Engine Oil Level... 4-5 3. Glow Plug
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar S-TYPE V6, V8 N/A and V8 SC 2002.5 Model Year Refer to pages 2 9 for important information regarding the use of Powertrain DTC Summaries.
More information7/31/2017 TSB : MASS AIR FLOW (MAF) - SENSOR CONTAMINATION - SERVICE TIP 1999 Ford F-350 MotoLogic
1999 F-350 TSB 98-23-10 MASS AIR FLOW (MAF) - SENSOR CONTAMINATION - SERVICE TIP Report a problem with this article Publication Date: NOVEMBER 10, 1998 FORD: LINCOLN-MERCURY: LIGHT TRUCK: 1990-1997 THUNDERBIRD
More informationMaxxForce 11 and 13 (2010)
MaxxForce 11 and 13 (2010) Overview: Setup Setup TABLE OF CONTENTS General Overview: Setup... 1 Description and Operation... 1 mable Parameters... 1 Definitions/Acronyms... 3 Setup i General Overview:
More informationDIAGNOSTIC TROUBLE CODE (DTC) DEFINITIONS
DIAGNOSTIC TROUBLE CODE (DTC) DEFINITIONS NOTE: Use the following table to identify the DTC and find the correct test step for the type of DTC retrieved. DIAGNOSTIC TROUBLE CODE (DTC) DEFINITION Diagnostic
More information2011 FORD E-450 SUPER DUTY A+ 6.8 V10 (S) GAS Excellent
2011 FORD E-450 SUPER DUTY A+ 6.8 V10 (S) GAS Excellent Report Summary Report Name VehicleMRI KOEO Report Number 654 Report Time 03/20/2012 12:03 PM Performed By Erik Horn Company ID 55 Vehicle Information
More informationMaxxForce 11 and 13 ( )
MaxxForce 11 and 13 (2007-2009) Overview: Setup NAV_VS_022511 Setup TABLE OF CONTENTS General Overview: Setup... 1 Description and Operation... 1 mable Parameters... 1 Definitions/Acronyms... 4 NAV_VS_022511
More informationP2284 REQUESTED INFORMATION. Pinpoint Test Ao: Injector Control Pressure Too High. Print Ford Pickup 6.0L Eng F250 Super Duty.
Print 2004 Ford Pickup 6.0L Eng F250 Super Duty P2284 REQUESTED INFORMATION Pinpoint Test Ao: Injector Control Pressure Too High Introduction Signal Function The injector control pressure is determined
More information2002 Buick Rendezvous - AWD
2002 Buick Rendezvous - AWD DTC P0410 Description The control module activates the secondary air injection (AIR) system by grounding both the pump relay and the vacuum control solenoid control circuits.
More informationHD: Misfire Detection Monitor
2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 12/10/2008 HD: Misfire Detection Monitor HD: Introduction HD1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs P0300, P0301,
More informationM1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS)
TEST PROCEDURE M1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) 2011 Ford Pickup 6.7L Eng F250 Super Duty NOTE: Repair any fuel injector circuit related DTCs before entering this pinpoint test. Are any DTCs
More information2002 Chevrolet Silverado 1500
For the specific DTCs required for each system, see table. Systems such as fuel delivery, misfire, and comprehensive components may not be listed in a system status list. These tests run continuously on
More informationInternational A26 (2017)
International A26 (2017) Overview: Trip Reporting A26_TR_12202017 Trip Reporting TABLE OF CONTENTS General Overview: Trip Reporting... 1 and Operation... 1 Programmable Parameters... 1 Frequently Asked
More informationTABLE OF CONTENTS. Torque Charts Wiring Diagram Diagnostic Codes
6.4l dit appendix TABLE OF CONTENTS Torque Charts... 82-87 Wiring Diagram... 88-89 Diagnostic Codes... 90-101 81 special torque chart (reference only) Note: All torque specs are ±10% unless stated otherwise.
More informationMotronic September 1998
The Motronic 1.8 engine management system was introduced with the 1992 Volvo 960. The primary difference between this Motronic system and the previous generation of Volvo LH-Jetronic engine management
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.5L and 3.0L 2001.5 Model Year Revised January, 2002: P0706, P0731, P0732, P0733, P0734, P0735, P0740, P1780 POSSIBLE CAUSES Revised
More information2000 MY OBD System Operation Summary for 7.3L Diesel Engine
2000 MY OBD System Operation Summary for 7.3L Diesel Engine Table of Contents Introduction OBD-I and OBD-II... 2 OBD-II Systems...2 OBD-I Systems...2 Misfire Monitor... 3 Low Data Rate System...3 Misfire
More informationL (LU4, LJ3, L88) used in Saab 9-5 ENGINE DIAGNOSTIC PARAMETERS
Catalytic Converter Monitoring P0420 Front vs. Rear O2 sensor signal Evaluated data 1,75 times FTP std 80 (unitless) Coolant temp Throttle Delta load, positive Delta load, negative Engine speed, man. trans
More informationMULTIPORT FUEL SYSTEM (MFI) <3.8L ENGINE>
13B-1 GROUP 13B MULTIPORT FUEL SYSTEM (MFI) CONTENTS GENERAL DESCRIPTION......... 13B-2....................... 13B-5 ACTUATOR.................... 13B-5 FUEL INJECTION CONTROL...... 13B-7
More informationPowertrain DTC Summaries OBD II
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.5L and 3.0L 2002 Model Year Revised January, 2002: P0706, P0731, P0732, P0733, P0734, P0735, P0740, P1780 POSSIBLE CAUSES Revised
More informationPrintable View Page 1 of 18 11/26/2013 Year = 2011 Model = E
Page 1 of 18 Year = 2011 Model = Escape Engine = VIN = IDS Version = t Available Misfire Detection Monitor WARNING: Crown Victoria Police Interceptor vehicles equipped with fire suppression system, refer
More informationDTC P1404 Exhaust Gas Recirculation (EGR) Closed Position Performance
Page 1 of 5 DTC P1404 Exhaust Gas Recirculation (EGR) Closed Position Performance Circuit Description The PCM monirs the EGR valve pintle position input ensure that the valve responds properly commands
More informationOn Board Diagnostics II A PCED
1998 PCED On Board Diagnostics II A SECTION 5A: Pinpoint Tests HA: Natural Gas Fuel Control HA: Introduction HA30 DTCS P05, P0141, P0155 AND P0161: HO2S HEATER SIGNAL CIRCUIT IS OPEN, SHORTED TO GROUND,
More informationTelephone: Fax: VAT Registration No.:
Telephone: Fax: VAT Registration No.: Terminal side Wire side Component/circuit description ECM pin Signal Condition Typical value Oscilloscope setting (Suggested settings - Voltage/time per division)
More informationNote: Refer to the PCM connector pin numbers in the beginning of this pinpoint test.
2003 Focus 2003 PCED On Board Diagnostics SECTION 5: Pinpoint Tests Report a problem with this article Procedure revision date: 12/01/2004 DD: Fuel Rail Pressure (FRP) Sensor DD: Introduction DD1 DTC P0192:
More informationReference Voltage (VREF )
Page 1 of 25 Year = 2013 Model = F-150 Engine = 3.5L VIN = 1FTFW1ET2DFA96265 IDS Version = t Available Reference Voltage ( ) This pinpoint test is intended to diagnose the following: harness circuits:
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.0 L 2002.25 Model Year Refer to page 2 for important information regarding the use of Powertrain DTC Summaries. Jaguar X-TYPE 2.0
More information1998 Ford F Diagnostics > Diagnostic Routines > Powertrain > Automatic Transmission > A... Page 1 of 63
1998 Ford F-150 - Diagnostics > Diagnostic Routines > Powertrain > Automatic Transmission > A... Page 1 of 63 1998 Ford F-150 : Diagnostics > Diagnostic Routines > Powertrain > Automatic Transmission >
More informationM: Fuel System M: Introduction
Page 1 of 7 2011 PCED 6.7L Diesel SECTION 5: Pinpoint Tests Procedure revision date: 12/14/2010 M: Fuel System M: Introduction M1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) te: Repair any fuel injector
More informationGL1800 FI "Fault Indicator" Dashboard Codes
GL1800 FI "Fault Indicator" Dashboard Codes If FI (Fault Indicator) light comes on pull over but DO NOT shut bike off. Put in neutral and put side stand down, RPM s below 1500. This signals the ECM to
More informationG - TESTS W/CODES - EEC-IV (4.0L)
Article Text Monday, November 16, 1998 10:39AM ARTICLE BEGINNING 1995 ENGINE PERFORMANCE Ford Motor Co. Self-Diagnostics - EEC-IV 4.0L Ford; Aerostar, Explorer INTRODUCTION Perform all steps in F - BASIC
More informationIgnition Switch [ COMPONENT TESTING ]
Page 1 of 25 2014 Ford Fusion 2.0L Eng SE Hybrid 1Search Print Date: START BUTTON Ignition Switch [ COMPONENT TESTING ] Schematic Fig 1: Ignition Switch Schematic Courtesy of FORD MOTOR CO. Page 2 of 25
More informationDX: Engine Coolant Temperature (ECT) Sensor
2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 12/10/2008 DX: Engine Coolant Temperature (ECT) Sensor DX: Introduction DX1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs
More informationDiagnostic Trouble Code (DTC) Charts
SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/30/2009 Diagnostic Trouble Code (DTC) Charts DTC Chart **May also be
More informationELECTRONIC DIESEL ENGINE DIAGNOSIS SPECIALIST TEST (L2) MEDIUM/HEAVY COMPOSITE VEHICLE TYPE 3 REFERENCE BOOKLET
ELECTRONIC DIESEL ENGINE DIAGNOSIS SPECIALIST TEST (L2) MEDIUM/HEAVY COMPOSITE VEHICLE TYPE 3 REFERENCE BOOKLET This booklet is intended only for reference when preparing for and taking the ASE Electronic
More informationPinpoint Test A: Shift Solenoid
Procedures 2004 Ford Freestar 3.9L Eng SES P0731 Pinpoint Test A: Shift Solenoid NOTE: Refer to TRANSAXLE INTERNAL HARNESS DIAGRAM for the transaxle internal harness diagram illustration. NOTE: Refer to
More informationDTC P0174 Fuel Trim System Lean Bank 2
2000 Chevrolet/Geo S10 Pickup - 4WD DTC P0174 Fuel Trim System Lean Bank 2 Circuit Description In order to provide the best possible combination of driveability, fuel economy, and emission control, the
More informationSCHEMATIC AND ROUTING DIAGRAMS
2004 ACCESSORIES & EQUIPMENT Tire Pressure Monitoring - Corvette SCHEMATIC AND ROUTING DIAGRAMS TIRE PRESSURE MONITORING SYSTEM SCHEMATICS Fig. 1: Tire Pressure Monitoring System Schematics Courtesy of
More informationDIAGNOSIS AND TESTING
307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Diagnostic Trouble Code Charts Diagnostic Trouble Code Chart P0102, MAF MAF concerns MAF system High/low EPC REFER to the P0103,
More informationMaxxForce DT, 9, 10 ( )
MaxxForce DT, 9, 10 (2007-2009) Overview: Idle Shutdown Timer (Non-CARB Certified Engines) NAV_IST_030711 Idle Shut Down Timer TABLE OF CONTENTS General Overview: Idle Shutdown Timer... 1 Description and
More informationInternational A26 (2017)
International A26 (2017) Overview: A26_DR_02172017 TABLE OF CONTENTS General Overview:... 1 Description and Operation... 1 Programmable Parameters... 2 Parameter Setup... 4 Frequently Asked Questions...
More informationE150/ L PFI Bronco & "F" Series E250/350, F250/350 & "F" Super Duty
1 of 57 12/12/2014 11:46 AM E4OD ELECTRONIC CONTROLS 1992 Ford Pickup 7.3L Eng F350 APPLICATION E4OD APPLICATIONS Models Engine E150/250 4.9L PFI Bronco & "F" Series "E" Series Bronco & "F" Series E250/350,
More informationMaxxForce 11 and 13 ( )
MaxxForce 11 and 13 (2007-2009) Overview: TABLE OF CONTENTS General Overview:... 1 Description and Operation... 1 OPERATION...1 Programmable Parameters... 2 Parameter Setup... 3 Frequently Asked Questions...
More informationInspection/Maintenance Evaporative Emission System Set
Page 1 of 5 2001 Chevrolet S10 Pickup - 2WD Blazer, Bravada, Envoy, Jimmy, S10 Pickup, Sonoma VIN S/T Service Manual Engine Engine Controls - 2.2L L43 Diagnostic Information and Procedures Document ID:
More informationL (LL8) Engine Diagnostic Parameters
Cam Shaft Position Actuator Control VCP System Performance VCP = variable cam phaser VCP Crank/Cam Correlation Error P0013 P0014 P0016 DESCRIPTION Detects an open or shorted control circuit by monitoring
More informationTechnician Turbocharger Guide for the L Power Stroke Engine
Technician Turbocharger Guide for the 2003.25 6.0L Power Stroke Engine Vanes VGT Actuator Piston Turbine Wheel Shaft Seal Compressor Wheel VGT Control Valve TURBOCHARGER DESCRIPTION AND BASIC OPERATION
More informationcylinder cars / trucks (except Saturn S-series cars) ENGINE DIAGNOSTIC PARAMETERS
2001 4-cylinder cars / trucks (except Saturn S-series cars) ENGINE DIAGNOSTIC S SECONDARY S AND Manifold Pressure/Throttle Position Sensor Manifold Pressure/Throttle Position Sensor Manifold Pressure Too
More informationSECONDARY PARAMETERS AND ENABLE CONDITIONS
SECONDARY S AND Manifold Pressure Sensor Rationality Manifold Pressure Too Low Manifold Pressure Too High Intake Air Temperature Sensor Shorted Intake Air Temperature Sensor Open Coolant Temperature Sensor
More informationCruise Control Diagnosis
1999 Pontiac Firebird Cruise Control Diagnosis Circuit Description The Cruise Control system is a speed control system that maintains a desired vehicle speed under normal driving conditions. The cruise
More information2001 Chevrolet Corvette ACCESSORIES & EQUIPMENT Cruise Control Systems - Corvette
2001 ACCESSORIES & EQUIPMENT Cruise Control Systems - Corvette DESCRIPTION Cruise control is a speed control system that maintains a desired vehicle speed under normal driving conditions. Steep grades
More informationIntake Air Temperature (IAT) Sensor
Page 1 of 5 Year = 2011 Model = Mustang Engine = 5.0L VIN = IDS Version = t Available Intake Air Temperature (IAT) Sensor This pinpoint test is intended to diagnose the following: IAT sensor (12A697) integrated
More informationDTC P0420 or P0430. Circuit Description. DTC Descriptors. Conditions for Running the DTC
Page 1 of 5 2005 Cadillac STS STS (VIN D) Service Manual Engine Engine Controls - 4.6L (LH2) Diagnostic Information and Procedures DTC P0420 or P0430 Circuit Description A three-way catalytic converter
More informationINDEX: Eight Gauge Instrument Cluster: TM2 Code Page Description Number
Affects: All models with EPA 2010 Engines Related: Engine Electronics (129) Electronic Engine Display (PKX) Air Restriction Indicator (PVX) INDEX: Eight Gauge Instrument Cluster: TM2 Code 571016 Page Description
More information#97-T-20A: MIL (Service Engine Soon Telltale Lamp) On and EGR DTCs P0401, P0404, P0405, P1404 and/or P1406 in PCM Memory - (Jan 6, 2003)
#97-T-20A: MIL (Service Engine Soon Telltale Lamp) On and EGR DTCs P0401, P0404, P0405, P1404 and/or P1406 in PCM Memory - (Jan 6, 2003) Subject: Malfunction Indicator Lamp (SERVICE ENGINE SOON Telltale
More informationNew Stationary Elevated Idle Control for 2005 Model Year Light Trucks
SVE BULLETIN SPECIAL VEHICLE ENGINEERING BODY BUILDERS ADVISORY SERVICE Toll-free: (877) 840-4338 E-Mail: bbasqa@ford.com (preferred) Fax: (313) 594-2633 Website: www.fleet.ford.com/truckbbas Q-108 Date:
More informationMODEL YEAR(S): 2005 DATE: 09/08/2005 REVISION DATE: PAGE: 1 of 41 ADVISORY
UI BULLETIN # 74 SUBJECT: PTO Procedure for Tilt Cab Trucks with (7.8L) LG4 Engine MODELS AFFECTED: T-Series Medium Duty Truck (F6/F7/F8) (Chevrolet, GMC & Isuzu) MODEL YEAR(S): 2005 DATE: 09/08/2005 REVISION
More informationG - TESTS W/CODES - 2.2L
G - TESTS W/CODES - 2.2L 1994 Toyota Celica 1994 ENGINE PERFORMANCE Toyota 2.2L Self-Diagnostics Celica INTRODUCTION If no faults were found while performing F - BASIC TESTING, proceed with self-diagnostics.
More informationP0340 REQUESTED INFORMATION. Pinpoint Test DR: Camshaft Position (CMP) Sensor Ford Pickup 5.4L Eng F150. 1Search.
2004 Ford Pickup 5.4L Eng F150 1Search P0340 REQUESTED INFORMATION Pinpoint Test DR: Camshaft Position () Sensor Introduction Question: Alternator testing for false P0340 NOTE: This pinpoint test is intended
More informationDRIVE CYCLES > JTEC > OBD-II Monitor Enabling Criteria RWD/4WD JTEC PCM Equipped Vehicles >
Print 2002 Jeep Grand Cherokee 4.7L Eng Limited OBD-II DRIVE CYCLES DRIVE CYCLES > 1995-02 JTEC > OBD-II Monitor Enabling Criteria RWD/4WD JTEC PCM Equipped Vehicles > The following procedure has been
More informationParameter Description Unit
DIACOM Diagnostic Status Report 07/07/2008 13:19:38 1. VEHICLE CONFIGURATION Engine Make: Mer Cruiser 5.0L MPI Engine Serial No: 0000000000 Model Year: 2005 System Type: Mer Cruiser PCM555 2. PERFORMANCE
More informationmessages displayed with extended idle operation
Congratulations on selecting the new Super Duty with one of the most advanced pieces of automotive technology -- the new 6.4L Power Stroke diesel engine. The 6.4L Power Stroke delivers all the horsepower
More informationP Fuel Volume Regulator Control Circuit P Fuel Volume Regulator Control Circuit Range/Performance P Fuel Volume Regulator Control
P0001 - Fuel Volume Regulator Control Circuit P0002 - Fuel Volume Regulator Control Circuit Range/Performance P0003 - Fuel Volume Regulator Control Circuit Low P0004 - Fuel Volume Regulator Control Circuit
More informationmessages displayed with extended idle operation
Congratulations on selecting the new Super Duty with one of the most advanced pieces of automotive technology -- the new 6.4L Power Stroke diesel engine. The 6.4L Power Stroke delivers all the horsepower
More information2002 Ford Explorer AUTOMATIC TRANSMISSIONS' '5R55W/S Diagnosis 2002 AUTOMATIC TRANSMISSIONS. 5R55W/S Diagnosis
2002 AUTOMATIC TRANSMISSIONS 5R55W/S Diagnosis APPLICATION WARNING: Vehicles are equipped with Supplemental Inflatable Restraint (SIR) system. When servicing vehicle, use care to avoid accidental air bag
More information1993 Ford Escort. G - TESTS W/CODES - EEC-IV (1.9L)' '1993 ENGINE PERFORMANCE Ford Motor Co. - Self-Diagnostics - EEC-IV
CIRCUIT TEST J - FUEL PUMP CIRCUIT (RELAY & INERTIA SWITCH) Diagnostic Aids When ignition switch is in the ON or START position, the PCM connects FUEL PUMP circuit (PCM terminal No. 22) to ground. The
More informationPowertrain Control Software
2007 PCED On Board Diagnostics SECTION 1: Description and Operation Procedure revision date: 03/29/2006 Powertrain Control Software Computer Controlled Shutdown The powertrain control module (PCM) controls
More informationmessages displayed with extended idle operation
Congratulations on selecting the new Super Duty with one of the most advanced pieces of automotive technology -- the new 6.4L Power Stroke diesel engine. The 6.4L Power Stroke delivers all the horsepower
More informationDiagnostic Trouble Code (DTC) List - Vehicle
Document ID# 850406 2002 Pontiac Firebird Diagnostic Trouble Code (DTC) List - Vehicle DTC DTC 021 and/or 031 DTC 022 and/or 032 DTC 023 or 033 DTC 24/34 DTC 025 and/or 035 DTC 041 DTC 042 DTC 043 DTC
More informationDW: Heated Oxygen Sensor (HO2S)
2007 PCED On Board Diagnostics SECTION 5: Pinpoint Tests Procedure revision date: 03/29/2006 DW: Heated Oxygen Sensor (HO2S) DW: Introduction DW1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs P0040,
More informationUIF Technology CO.,LTD.
CONTENTS 1. INTRODUCTION MEMOScanner is newly developed by UIF TECH, specially designed for car owners or DIYs. With an MEMOScanner, you may quickly find out trouble causes of electronically controlled
More information11/18/2017 Engine Controls (Powertrain Management) - ALLDATA
//0 Engine Controls (Powertrain Management) - ALLDATA 00 Ford Truck F 0 WD Super Duty V-.0L DSL Turbo VIN P Vehicle > Powertrain Management > Diagrams > Electrical - Interactive Color (Non OE) Engine Controls
More informationPage 1 of 34 Print Date: 1994 ENGINE PERFORMANCE FORD MOTOR CO. - SYSTEM & COMPONENT TESTING - EEC-IV 5.0L INTRODUCTION 1994 Ford Mustang 5.0L Eng VIN T GT Before testing separate components or systems,
More information2003 Ford Explorer - Diagnostics > Diagnostic Routines > Powertrain > On Board Diagnostics > P... Page 1 of 18
2003 Ford Explorer - Diagnostics > Diagnostic Routines > Powertrain > On Board Diagnostics > P... Page 1 of 18 2003 Ford Explorer : Diagnostics > Diagnostic Routines > Powertrain > On Board Diagnostics
More informationAUTO TRANS DIAGNOSIS - 4T65-E
AUTO TRANS DIAGNOSIS - 4T65-E 1998 Pontiac Bonneville 1997-98 AUTOMATIC TRANSMISSIONS General Motors - 4T65-E Electronic Controls Buick; LeSabre, Park Avenue, Regal, Riviera Chevrolet; Lumina, Monte Carlo
More informationTroubleshooting Self-diagnostic Procedures
Self-diagnostic Procedures I. When the Malfunction Indicator Lamp (MIL) has been reported on, do the following: 1. Connect the Service Check Connector terminals with a jumper wire as shown. (The 2P Service
More informationBASIC DIAGNOSTIC PROCEDURES
BASIC DIAGNOSTIC PROCEDURES 2001 Chevrolet Camaro 2001 ENGINE PERFORMANCE Basic Diagnostic Procedures - Cars Except Metro & Prizm MODEL IDENTIFICATION MODEL IDENTIFICATION Body Code (1) Model C... Park
More informationSCHEMATIC AND ROUTING DIAGRAMS
2004 ACCESSORIES & EQUIPMENT Cruise Control - Corvette SCHEMATIC AND ROUTING DIAGRAMS CRUISE CONTROL SCHEMATICS Fig. 1: Cruise Control Switch, Throttle Actuator Control Motor And Cruise Control Release
More informationEBP Sensor (Exhaust Back Pressure)
Page 1 of 8 EBP Sensor (Exhaust Back Pressure) DTC SPN FMI Condition 3341 1209 4 EBP signal out-of-range LOW 3342 1209 3 EBP signal out-of-range HIGH Page 2 of 8 Function diagram for the EBP sensor The
More informationAn ISO 9001:2008 Registered Company
Introduction An ISO 9001:2008 Registered Company 1939CM405-A J1939 Translator (for use with GTWY505/506/605, and HL510/550/610) 2005-2017 Ford E-Series & F250-F550 2014-2017 Ford Transit 2006-2017 Chevy
More informationTechnical Service Bulletin
Number 02-36-030 Subject OBD-II READINESS TEST DRIVE CYCLE FOR 1996-1998 SONATA Date Model DECEMBER, 2002 1996-1998 SONATA DESCRIPTION: This TSB describes Drive Cycles which may assist the vehicle s OBD-II
More informationDIAGNOSIS AND TESTING Procedure revision date: 09/23/2004
2002 Excursion Subarticles Report a problem with this article On-Board Diagnostics with Scan Tool Transmission Drive Cycle Test After On-Board Diagnostics Before Pinpoint Tests Diagnostic Trouble Code
More informationMaxxForce 11 and 13 (2010)
MaxxForce 11 and 13 (2010) Overview: Trip Reporting NAV_TR_030611 Trip Reporting TABLE OF CONTENTS General Overview: Trip Reporting... 1 and Operation... 1 Programmable Parameters... 1 Frequently Asked
More information