Reference Voltage (VREF )
|
|
- Kerry McCoy
- 5 years ago
- Views:
Transcription
1 Page 1 of 25 Year = 2013 Model = F-150 Engine = 3.5L VIN = 1FTFW1ET2DFA96265 IDS Version = t Available Reference Voltage ( ) This pinpoint test is intended to diagnose the following: harness circuits: APP1, APP2, APPRTN1, APPRTN2, ETCREF, ETCRTN, SIGRTN and accelerator pedal position (APP) sensor (9F836) air conditioning pressure (ACP) transducer sensor (19D594) crankshaft position ( CKP) sensor (6C315) camshaft position ( CMP) sensor (6B288) EGR system module ( ESM) (9Y456) electronic throttle body throttle position sensor ( ETBTPS) (9E928) fuel pressure sensor (9F972) fuel rail pressure ( FRP) sensor (6B288) fuel rail pressure temperature ( FRPT) sensor (9G756) fuel tank pressure ( FTP) sensor (9C052) generator current sensor (14B357) manifold absolute pressure ( MAP) sensor (9F479) manifold absolute pressure ( MAP )/intake air temperature 2 ( IAT2) sensor (9F479) power steering pressure ( PSP) sensor (3N824) turbocharger boost pressure ( TCBP )/charge air cooler temperature ( CACT) sensor (9F479) turbocharger intake pressure and temperature ( TCIPT) sensor wastegate vacuum sensor (9F479) powertrain control module ( PCM) (12A650)
2 Page 2 of 25 Accelerator Pedal Position (APP) Sensor Connector APPRTN1 (Accelerator Pedal Position Return 1) 3 APPRTN2 (Accelerator Pedal Position Return 2) 4 APP1 (Accelerator Pedal Position Reference Voltage 1) 1 APP2 (Accelerator Pedal Position Reference Voltage 2) 6 Air Conditioning Pressure (ACP) Transducer Sensor Connector (Reference Voltage) 3 SIGRTN (Signal Return) 1 Camshaft Position 11 (CMP11) Sensor Connector
3 Page 3 of 25 SIGRTN (Signal Return) 2 Camshaft Position 12 (CMP12) Sensor Connector SIGRTN (Signal Return) 2 Crankshaft Position (CKP) Sensor Connector
4 Page 4 of 25 (Reference Voltage) 3 SIGRTN (Signal Return) 2 Clutch Pedal Position (CPP) Sensor Connector (Reference Voltage) 2 SIGRTN (Signal Return) 4 EGR System Module (ESM) Connector
5 Page 5 of 25 (Reference Voltage) 2 SIGRTN (Signal Return) 6 Fuel Rail Pressure (FRP) Sensor Connector (Reference Voltage) 1 SIGRTN (Signal Return) 3 Fuel Tank Pressure (FTP) Sensor Connector
6 Page 6 of 25 SIGRTN (Signal Return) 2 (Reference Voltage) 3 Generator Current Sensor Connector SIGRTN (Signal Return) 2 (Reference Voltage) 1 Manifold Absolute Pressure (MAP) Sensor Connector
7 Page 7 of 25 (Reference Voltage) 2 SIGRTN (Signal Return) 4 Manifold Absolute Pressure/Intake Air Temperature 2 (MAP/IAT2) Sensor Connector (Reference Voltage) 2 SIGRTN (Signal Return) 4 Power Steering Pressure (PSP) Sensor Connector
8 Page 8 of 25 SIGRTN (Signal Return) 1 (Reference Voltage) 2 Turbocharger Boost Pressure/Charge Air Cooler Temperature (TCBP/CACT) Sensor Connector (Reference Voltage) 2 SIGRTN (Signal Return) 4 Turbocharger Intake Pressure And Temperature (TCIPT) Sensor Connector
9 Page 9 of 25 (Reference Voltage) 3 SIGRTN (Signal Return) 1 Wastegate Vacuum Sensor Connector (Reference Voltage) 1 SIGRTN (Signal Return) 2 Powertrain Control Module (PCM) Connector - For PCM connector views or reference values, refer to Section 6.
10 Page 10 of 25 ETCREF (Electronic Throttle Control Reference Voltage) E7 APP1 (Accelerator Pedal Position Reference Voltage 1) B12 APP2 (Accelerator Pedal Position Reference Voltage 2) B10 (Reference Voltage) B11 (Reference Voltage) B13 (Reference Voltage) E8 ETCRTN (Electronic Throttle Control Return) E31 APPRTN1 (Accelerator Pedal Position Return 1) B36 APPRTN2 (Accelerator Pedal Position Return 2) B35 SIGRTN (Signal Return) B38 SIGRTN (Signal Return) B37 SIGRTN (Signal Return) B34 SIGRTN (Signal Return) B18 SIGRTN (Signal Return) B17 SIGRTN (Signal Return) B16 SIGRTN (Signal Return) E53 SIGRTN (Signal Return) E32 SIGRTN (Signal Return) E20 VPWR (Vehicle Power) B103 VPWR (Vehicle Power) B102 VPWR (Vehicle Power) B101 SENSORS CONNECTED TO REFERENCE VOLTAGE Applications APP ESM FTP ACP PSP Fuel Pressure Sensor or FRP or FRPT MAP or TCBP/ CACT or MAP/ IAT2 CKP or CMP WVS or TCIPT CPP Generator Current Sensor Mustang 5.8L X X X X X Escape 2.5L X X X X E-Series 4.6L X X X Focus 2.0L GDI X X X X X Escape 1.6L, Escape 2.0L, Focus 2.0L X X X X X X GTDI Edge 2.0L, Explorer 2.0L, F L X X X X X X X X E-Series 5.4L, E- Series 6.8L, Expedition, F L, F-650 / F-750, F- Series Super Duty 6.8L, Mustang 3.7L, Mustang 5.0L, Navigator X X X Transit Connect X X X X X Fiesta X X X F-Series Super Duty 6.2L X X X X
11 Page 11 of 25 Fusion 1.6L Manual Transmission X X X X X X X X Fusion 2.5L X X X X X Explorer 3.5L GTDI, Flex 3.5L GTDI, Fusion 1.6L Automatic Transmission, Fusion 2.0L, MKS 3.5L, MKT X X X X X X 2.0L, MKT 3.5L, MKZ 2.0L, Taurus 2.0L, Taurus 3.5L GTDI Edge 3.5L, Edge 3.7L, Explorer 3.5L TiVCT, Explorer 3.7L, F L, F L, Flex 3.5L TiVCT, MKS 3.7L, MKT 3.7L, MKX, MKZ 3.7L, Taurus 3.5L TiVCT, Taurus 3.7L X X X X
12 Page 12 of 25 Go to C27. Go to C2. C2 : CHECK THE REFERENCE VOLTAGE TO GROUND For ETCREF concerns ETBTPS Connector, ETCREF For APP concerns. APP Sensor Connector, APP1-1 APP2-6 For concerns Suspect Sensor Connector, Is the voltage between V? Go to C26. Go to C3.
13 Page 13 of 25 APP Sensor Connector, APP1-1 APP2-6 For concerns Suspect Sensor Connector, Is the voltage between V? Go to C8. Go to C4.
14 Page 14 of 25
15 Page 15 of 25 - E8 - E8 SIGRTN - E32 SIGRTN - E20 Measure the resistance between: PCM Connector, - B11 - B13 - E8 Are the resistances greater than 10K ohms? Go to C6. REPAIR the short circuit.
16 Page 16 of 25 Are the resistances greater than 10 kohm? Go to C7. REPAIR the short circuit. C7 : CHECK THE REFERENCE VOLTAGE CIRCUIT FOR A SHORT TO VOLTAGE For ETCREF concerns PCM Connector, ETCREF - E7 For APP concerns. PCM Connector, APP1 - B12 APP2 - B10 For concerns PCM Connector, - B11 - B13 - E8 Is any voltage present? REPAIR the short circuit. Go to C28.
17 Page 17 of 25 APP2-6 Are the voltages between 4.5 V V? Go to C9. INSTALL a new ETBTPS. REFER to the Workshop Manual Section , Fuel Charging and Controls or Section , Electronic Engine Controls. C9 : CHECK THE REFERENCE VOLTAGE WITH THE APP SENSOR CONNECTED NOTE: If this sensor was used for the measurement in C3, Go to C10 Ignition OFF. APP Sensor connector connected. ETBTPS Connector, ETCREF Go to C10. INSTALL a new APP sensor. REFER to the Workshop Manual Section , Acceleration Control.
18 Page 18 of 25 C11 : CHECK THE REFERENCE VOLTAGE WITH THE MAP SENSOR CONNECTED NOTE: If the vehicle is not equipped with a MAP sensor or if this sensor was used for the measurement in C3, Go to C12 Ignition OFF. MAP Sensor connector connected. Suspect Sensor Connector, Go to C12. INSTALL a new MAP sensor. REFER to the Workshop Manual Section , Electronic Engine Controls. C12 : CHECK THE REFERENCE VOLTAGE WITH THE TCBP/CACT SENSOR CONNECTED NOTE: If the vehicle is not equipped with a TCBP/CACT sensor or if this sensor was used for the measurement in C3, Go to C13 Ignition OFF. TCBP/CACT Sensor connector connected. Suspect Sensor Connector, Go to C13. INSTALL a new TCBP/CACT sensor. REFER to the Workshop Manual Section , Electronic Engine Controls.
19 Page 19 of 25 MAP/IAT2 Sensor connector connected. Suspect Sensor Connector, Go to C14. INSTALL a new MAP/IAT2 sensor. REFER to the Workshop Manual Section , Electronic Engine Controls. C14 : CHECK THE REFERENCE VOLTAGE WITH THE FRP SENSOR CONNECTED NOTE: If the vehicle is not equipped with a FRP sensor or if this sensor was used for the measurement in C3, Go to C15 Ignition OFF. FRP Sensor connector connected. Suspect Sensor Connector, Go to C15. INSTALL a new FRP sensor. REFER to the Workshop Manual Section , Electronic Engine Controls.
20 Page 20 of 25 Go to C16. INSTALL a new FRPT sensor. REFER to the Workshop Manual Section , Electronic Engine Controls. C16 : CHECK THE REFERENCE VOLTAGE WITH THE FTP SENSOR CONNECTED NOTE: If the vehicle is not equipped with a FTP sensor or if this sensor was used for the measurement in C3, Go to C17 Ignition OFF. FTP Sensor connector connected. Suspect Sensor Connector, Go to C17. INSTALL a new FTP sensor. REFER to the Workshop Manual Section , Evaporative Emissions.
21 Page 21 of 25 C18 : CHECK THE REFERENCE VOLTAGE WITH THE FUEL PRESSURE SENSOR CONNECTED NOTE: If the vehicle is not equipped with a fuel pressure sensor or if this sensor was used for the measurement in C3, Go to C19 Ignition OFF. Fuel Pressure Sensor connector connected. Suspect Sensor Connector, Go to C19. INSTALL a new Fuel Pressure Sensor. REFER to the Workshop Manual Section , Fuel Tank and Lines. C19 : CHECK THE REFERENCE VOLTAGE WITH THE CKP SENSOR CONNECTED NOTE: If the vehicle is not equipped with a CKP sensor or if this sensor was used for the measurement in C3, Go to C20 Ignition OFF. CKP Sensor connector connected. Suspect Sensor Connector, Go to C20. INSTALL a new CKP sensor. REFER to the Workshop Manual Section , Electronic Engine Controls.
22 Page 22 of 25 Suspect Sensor Connector, Go to C21. INSTALL a new CMP sensor. REFER to the Workshop Manual Section , Electronic Engine Controls. C21 : CHECK THE REFERENCE VOLTAGE WITH THE TCIPT SENSOR CONNECTED NOTE: If the vehicle is not equipped with a TCIPT sensor or if this sensor was used for the measurement in C3, Go to C22 NOTE: Only measure the circuits that apply to the vehicle being diagnosed Ignition OFF. TCIPT Sensor connector connected. Suspect Sensor Connector, Go to C22. INSTALL a new TCIPT sensor. REFER to the Workshop Manual Section , Electronic Engine Controls.
23 Page 23 of 25 Go to C23. INSTALL a new Wastegate Vacuum Sensor. REFER to the Workshop Manual Section , Electronic Engine Controls. C23 : CHECK THE REFERENCE VOLTAGE WITH THE CPP SENSOR CONNECTED NOTE: If the vehicle is not equipped with a CPP sensor or if this sensor was used for the measurement in C3, Go to C24 NOTE: Only measure the circuits that apply to the vehicle being diagnosed Ignition OFF. CPP Sensor connector connected. Suspect Sensor Connector, Go to C24. INSTALL a new CPP sensor. REFER to the Workshop Manual Section , Electronic Engine Controls.
24 Page 24 of 25 Go to C25. INSTALL a new Generator Current sensor. REFER to the Workshop Manual Section , Battery, Mounting and Cables. C25 : CHECK THE REFERENCE VOLTAGE WITH THE PSP SENSOR CONNECTED Ignition OFF. PSP Sensor connector connected. Suspect Sensor Connector, The concern is intermittent. GO to point Test Z. INSTALL a new PSP sensor. REFER to the Workshop Manual Section , Electronic Engine Controls.
25 Page 25 of 25 SIGRTN SIGRTN SIGRTN SIGRTN SIGRTN SIGRTN SIGRTN - B18 SIGRTN - B17 SIGRTN - B16 SIGRTN - E53 SIGRTN - E32 SIGRTN - E20 Is the resistance less than 5 Ohm? Go to C28. REPAIR the open circuit. C27 : CHECK THE SUSPECT SENSOR FOR AN INTERNAL SHORT Clear the KOEO, KOER, and continuous DTCs. Ignition OFF. Connect the suspect sensor. Carry out the PCM self-test. Is the concern still present? INSTALL a new sensor for the sensor in question. The concern is intermittent. GO to point Test Z. C28 : CHECK FOR CORRECT PCM OPERATION Disconnect all the PCM connectors. Visually inspect for: pushed out pins corrosion Connect all the PCM connectors and make sure they seat correctly. Carry out the PCM self-test. Verify the concern is still present. Is the concern still present? INSTALL a new PCM. REFER to Section 2, Flash Electrically Erasable Programmable Read Only Memory (EEPROM), Programming the VID Block for a Replacement PCM. The system is operating correctly at this time. The concern may have been caused by a loose or corroded connector.
7/2/2018 PPT DV: Throttle Body Assembly Electronic Throttle Control (ETC) - Gasoline Engines (Powertrain Diagnostics) 2014 Ford Escape Mot
2014 Escape 2015 PCED Gasoline Engines SECTION 5: Pinpoint Tests Report a problem with this article Procedure revision date: 07/30/2015 DV: Throttle Body Assembly Electronic Throttle Control (ETC) DV:
More informationDV: Throttle Body Assembly Electronic Throttle Control (ETC)
2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 05/25/2010 DV: Throttle Body Assembly Electronic Throttle Control (ETC) DV: Introduction DV1 CHECK FOR DIAGNOSTIC TROUBLE CODES
More informationIntake Air Temperature 2 (IAT2 ) Sensor
Page 1 of 6 Year = 2011 Model = Mustang Engine = 5.0L VIN = IDS Version = t Available Intake Air Temperature 2 ( ) Sensor This pinpoint test is intended to diagnose the following: sensor (12A697) harness
More information2/28/2018 PPT DR: Camshaft Position (CMP) Sensor - Gasoline Engines (Powertrain Diagnostics) 2008 Ford Explorer MotoLogic
Explorer Sport Trac 4.6L, F-150 5.4L, F-Super Duty 5.4L, Fusion, Mark LT, Milan, MKX, MKZ, Mountaineer 4.6L, Mustang 4.6L, Navigator, Sable, Taurus, and Taurus X, GO to DR25. For all others, GO to DR26.
More informationIntake Air Temperature (IAT) Sensor
Page 1 of 5 Year = 2011 Model = Mustang Engine = 5.0L VIN = IDS Version = t Available Intake Air Temperature (IAT) Sensor This pinpoint test is intended to diagnose the following: IAT sensor (12A697) integrated
More informationVisctronic Drive Fan (VDF )
Page 1 of 9 Year = 2006 Model = F-Super Duty Engine = VIN = IDS Version = t Available Visctronic Drive Fan (VDF ) WARNING: To avoid the possibility of personal injury or damage to the vehicle, do not operate
More informationA: No Start A: Introduction
2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 03/18/2009 A: Start A: Introduction A1 ATTEMPT TO CRANK THE ENGINE te: Verify the inertia fuel shutoff (IFS) switch is set
More informationDA: Intake Air Temperature (IAT) Sensor
2007 PCED On Board Diagnostics SECTION 5: Pinpoint Tests Procedure revision date: 03/29/2006 DA: Intake Air Temperature () Sensor DA: Introduction DA1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs
More informationPrintable View Page 1 of 18 11/26/2013 Year = 2011 Model = E
Page 1 of 18 Year = 2011 Model = Escape Engine = VIN = IDS Version = t Available Misfire Detection Monitor WARNING: Crown Victoria Police Interceptor vehicles equipped with fire suppression system, refer
More informationPage 1 of 10 Year = 2008 Model = F-150 Engine = VIN = IDS Version = t Available Variable Camshaft Timing (VCT) This pinpoint test is intended to diagnose the following: VCT solenoid (6L713) or (6B297)
More informationPage 1 of 7 2004 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 05/08/2007 DM: Manifold Absolute Pressure () and Thermal Manifold Absolute Pressure (T) Sensor DM: Introduction
More informationFA: AMBIENT AIR TEMPERATURE (AAT) SENSOR: PINPOINT TEST
2014 Ford Taurus FWD V6-35L Vehicle > Powertrain Management > Computers and Control Systems > Testing and Inspection > Pinpoint Tests FA: AMBIENT AIR TEMPERATURE (AAT) SENSOR: PINPOINT TEST FA: Ambient
More informationHV: Cooling Fan Clutch
2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 12/10/2008 HV: Cooling Fan Clutch HV: Introduction HV1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs P0480, P0483 or P0528
More informationDS: Air Conditioning Pressure (ACP) Transducer Sensor
2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 08/12/2009 DS: Air Conditioning Pressure () Transducer Sensor DS: Introduction DS1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS)
More informationDW: Heated Oxygen Sensor (HO2S)
2007 PCED On Board Diagnostics SECTION 5: Pinpoint Tests Procedure revision date: 03/29/2006 DW: Heated Oxygen Sensor (HO2S) DW: Introduction DW1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs P0040,
More informationCooling Fan (CF) Module Connector
Page 1 of 14 Year = 2006 Model = Town Car Engine = VIN = IDS Version = 92.01 (IDS-92.01) Variable Speed Electric Cooling Fan WARNING: Crown Victoria Police Interceptor vehicles equipped with fire suppression
More informationHD: Misfire Detection Monitor
2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 12/10/2008 HD: Misfire Detection Monitor HD: Introduction HD1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs P0300, P0301,
More informationVariable Geometry Turbocharger (VGT) Actuator Connector
Page 1 of 5 Year = 2006 Model = F-Super Duty Engine = VIN = IDS Version = 77A.05 (IDS-77A.05) Variable Geometry Turbocharger (VGT) Output Circuit Function The VGT actuator is a variable position valve
More informationDR: Camshaft Position (CMP) Sensor
2007 PCED On Board Diagnostics SECTION 5: Pinpoint Tests Procedure revision date: 03/29/2006 DR: Camshaft Position () Sensor DR: Introduction DR1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs P0340,
More informationNote: If DTCs P0670 and P0684 are present, carry out DTC P0670 diagnosis before diagnosing DTC P0684.
2008 F-250 2008 PCED 6.4L Diesel SECTION 5: Pinpoint Tests Report a problem with this article Procedure revision date: 03/09/2010 AF: Glow Plug System AF: Introduction AF1 PRELIMINARY DIAGNOSIS te: If
More informationPage 1 of 9 2004 Ford Pickup 5.4L Eng VIN L F250 Super Duty 1Search Print Date: P0720 Pinpoint Test F: Turbine Shaft Speed (TSS) And Output Shaft Speed () Sensors NOTE: Refer to the Output Shaft Speed
More informationPage 1 of 6 2008 Ford Pickup 6.4L Eng F250 Super Duty ENGINE CONTROLS - DESCRIPTION AND OPERATION - F250-F550 SUPER DUTY 6.4L (DIESEL ) FUEL SYSTEM The fuel system includes the following: low pressure
More informationFuel Pump (FP ) Relay
Page 1 of 12 Year = 2007 Model = F-150 Engine = VIN = IDS Version = t Available Fuel Pump (FP ) Relay This pinpoint test is intended to diagnose the following: fuel pump relay (9345) inertia fuel shutoff
More information2017 Ford Warranty addendum
2017 Ford Warranty addendum The chart on the following page replaces the chart with the title COVERAGE FOR 2017 MODEL VEHICLES UNDER LONG TERM DEFECTS WARRANTY found on Page 29 in The New Vehicle Limited
More information2003 Ford Explorer - Diagnostics > Diagnostic Routines > Powertrain > On Board Diagnostics > P... Page 1 of 18
2003 Ford Explorer - Diagnostics > Diagnostic Routines > Powertrain > On Board Diagnostics > P... Page 1 of 18 2003 Ford Explorer : Diagnostics > Diagnostic Routines > Powertrain > On Board Diagnostics
More informationDX: Engine Coolant Temperature (ECT) Sensor
2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 12/10/2008 DX: Engine Coolant Temperature (ECT) Sensor DX: Introduction DX1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs
More informationME: Fuel Pump Control - High Pressure Fuel Injection Pump
Page 1 of 6 2008 Ford F-250 Super Duty : Diagnostics > 6.4L Diesel > Pinpoint Tests > ME: Fuel Pump Control - High Pressure Fuel Injection Pump ME: Fuel Pump Control - High Pressure Fuel Injection Pump
More informationDP: Vehicle Speed Sensor (VSS)/Transfer Case Speed Sensor (TCSS) DP: Introduction
PPT DP: VEHICLE SPEED SENSOR... PPT DP: VEHICLE SPEED SENSOR ()/TRANSFER CASE SPEED SENSOR (TCSS) (GASOLINE ENGINES) 2005 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 03/30/2005
More informationP0340 REQUESTED INFORMATION. Pinpoint Test DR: Camshaft Position (CMP) Sensor Ford Pickup 5.4L Eng F150. 1Search.
2004 Ford Pickup 5.4L Eng F150 1Search P0340 REQUESTED INFORMATION Pinpoint Test DR: Camshaft Position () Sensor Introduction Question: Alternator testing for false P0340 NOTE: This pinpoint test is intended
More informationDZ: Universal Heated Oxygen Sensor (HO2S)
2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 02/23/2010 DZ: Universal Heated Oxygen Sensor (HO2S) DZ: Introduction DZ1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs
More informationOn Board Diagnostics II PCED
Page 1 of 5 1999 PCED On Board Diagnostics II SECTION 5: Pinpoint Tests HD: Misfire Detection Monitor HD: Introduction HD1 DTC P0301-P0310: CHECK FOR NO LOW FUEL te: Running out of fuel can turn on the
More informationDiagnostic Trouble Code (DTC) Descriptions
Diagnostic Subroutines 4-107 Code Short Description Off Running Continuous Memory B1213 Less than two keys See Note 1 programmed to the system B1342 ECU damaged See Note 2 (EEPROM in PCM not working, replace
More informationNote: Refer to the PCM connector pin numbers in the beginning of this pinpoint test.
2003 Focus 2003 PCED On Board Diagnostics SECTION 5: Pinpoint Tests Report a problem with this article Procedure revision date: 12/01/2004 DD: Fuel Rail Pressure (FRP) Sensor DD: Introduction DD1 DTC P0192:
More information技術通報. Technical Information. 1 AUTOLAND SCIENTECH Co., Ltd.
Date: 2015/06/08 From: AUTOLAND SCIENTECH Taiwan Page: 1/6 Version upgrade to 2015.06 1. Model Transit TDCi 2.2L, Year 2006, increase Fuel Injection Pump Learn 2. Model Transit TDCi 2.2L, Year 2006, increase
More informationInstallation Instructions JMS PedalMAX Kit P/N PX1114F Ford Drive-By-Wire Electronic Throttle Enhancement Device
Installation Instructions JMS PedalMAX Kit P/N PX1114F 2011-2018 Ford Drive-By-Wire Electronic Throttle Enhancement Device Included in the PedalMAX kit: (1) PedalMAX assembly (1) 4-pin RED de-sensitizing
More informationDiagnostic Trouble Code (DTC) Charts and Descriptions
Page 1 of 126 2006 PCED On Board s SECTION 4: Powertrain DTC Charts and Descriptions Procedure revision date: 04/06/2006 Trouble Code (DTC) Charts and Descriptions Note: Refer to the applicable Workshop
More information05/01/06 1er mai 2006 Cruise Control - Diagnostic Updates General Service Procedure Service Procedure Speed Control Diagnostic Tips Additional
05/01/06 1er mai 2006 General Service Procedure Service Procedure Speed Control Diagnostic Tips Additional Reference Information SPEED CONTROL DIAGNOSTICS - W/O SCP FORD: 2000-2003 Escort 2000-2004 Crown
More informationP0046 Turbo/Super Charger Boost Control Solenoid Circuit Range/Performance P0069 MAP/BARO Correlation P0096 Intake Air Temperature Sensor 2 Circuit
P0046 Turbo/Super Charger Boost Control Solenoid Circuit Range/Performance P0069 MAP/BARO Correlation P0096 Intake Air Temperature Sensor 2 Circuit Range/Performance P0097 Intake Air Temperature Sensor
More informationDTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency
Page 1 of 5 1997 Pontiac Grand Prix Grand Prix (VIN W) Service Manual Engine Engine Controls - 3.8L Diagnostic Information and Procedures Document ID: 106986 DTC P0102 Mass Air Flow (MAF) Sensor Circuit
More informationPage 1 of 5 2005 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 03/30/2005 KN: Variable Speed Electric Cooling Fan KN: Introduction KN1 KOEO DTC P0480: CHECK THE B+ AND GND CIRCUIT
More informationDiagnostic Trouble Code (DTC) List - Vehicle
Document ID# 850406 2002 Pontiac Firebird Diagnostic Trouble Code (DTC) List - Vehicle DTC DTC 021 and/or 031 DTC 022 and/or 032 DTC 023 or 033 DTC 24/34 DTC 025 and/or 035 DTC 041 DTC 042 DTC 043 DTC
More information2011 Flex Workshop Manual. REMOVAL AND INSTALLATION Procedure revision date: 05/10/2010
SECTION 303-14: Electronic Engine Controls REMOVAL AND INSTALLATION Procedure revision date: 05/10/2010 Knock Sensor (KS) - 3.5L GTDI NOTE: LH cylinder head removed from art for clarity. Item Part Number
More informationFuel Injector Control Module (FICM ) Low Voltage
Page 1 of 6 Year = 2006 Model = F-Super Duty Engine = VIN = Fuel Injector Control Module (FICM ) Low Voltage Circuit Function The FICM requires a 12-volt power source. The FICM receives power from the
More informationPage 1 of 8 SECTION 310-03: Speed Control 2001 Focus Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 04/22/2003 Speed Control Refer to Wiring Diagrams Section 310-03 for schematic and connector
More informationDTC P1415 Secondary Air Injection (AIR) System Bank 1
Page 1 of 5 2000 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 546887 DTC P1415 Secondary Air Injection (AIR) System Bank 1 Circuit Description
More informationENGINE 01 02A 1. Toc of SCT ON-BOARD DIAGNOSTIC [ENGINE. Toc of SCT 01 02A ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (ZM)] 01 02A
ENGINE 01 SECTION Toc of SCT ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (ZM)]...01-02A ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (FS)]...01-02B ON-BOARD DIAGNOSTIC [CRUISE CONTROL SYSTEM].......01-02C
More informationSECTION 4: Diagnostic Subroutines. Table of Contents
SECTION 4: Diagnostic Subroutines Table of Contents Contents PAGE Hard Start/No Start Diagnostic Procedures... 4-2 1. Visual Engine/Chassis Inspection... 4-4 2. Check Engine Oil Level... 4-5 3. Glow Plug
More information01 02B ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (FS)]
ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (FS)] CONTROL SYSTEM WIRING DIAGRAM [FS]............................ 2 CONTROL SYSTEM DEVICE AND CONTROL RELATIONSHIP CHART [FS]........ 4 Engine Control System............
More informationGAS P0344-CAMSHAFT POSITION SENSOR INTERMITTENT
2007 Chrysler Truck PT Cruiser L4-2.4L VIN X Vehicle > ALL Diagnostic Trouble Codes ( DTC ) > Testing and Inspection > P Code Charts > P0344 GAS P0344-CAMSHAFT POSITION SENSOR INTERMITTENT https://my.alldata.com/repair/#/repair/article/55125/component/3926/itype/423/nonstandard/1175627
More informationPPT RH: REDUCTANT HEATER (6.7L DIESEL) 2011 PCED 6.7L Diesel SECTION 5: Pinpoint Tests Procedure revision date: 02/25/2014
PPT RH: REDUCTANT HEATER (6.7... PPT RH: REDUCTANT HEATER (6.7L DIESEL) 2011 PCED 6.7L Diesel SECTION 5: Pinpoint Tests Procedure revision date: 02/25/2014 RH: Reductant Heater RH: Introduction RH1 PRELIMINARY
More information1 of 14 9/4/2016 4:05 PM
1 of 14 9/4/2016 4:05 PM P0068-MANIFOLD PRESSURE/THROTTLE POSITION CORRELATION P0068-Manifold Pressure/Throttle Position Correlation Theory of Operation This DTC sets when an unexpected high intake manifold
More informationDTC P0128: THERMOSTAT RATIONALITY
Page 1 of 5 2003 Dodge Neon 2.0L Eng SE DTC P0128: THERMOSTAT RATIONALITY WARNING: When the engine is operating, do not stand in a direct line with the fan. Do not put your hands near the pulleys, belts
More informationProcedure revision date: 09/16/2004 DR1 CONTINUOUS MEMORY DTCS P0340 AND P0345: CHECK IF THE ENGINE WILL START
11/4/2017 PPT DR: Camshaft Position () Sensor - On Board Diagnostics (Powertrain Diagnostics) 2004 Ford F-150 MotoLogic 2004 F-150 2004 PCED On Board Diagnostics SECTION 5: Pinpoint Tests Report a problem
More informationTelephone: Fax: VAT Registration No.:
Telephone: Fax: VAT Registration No.: Terminal side Wire side Component/circuit description ECM pin Signal Condition Typical value Oscilloscope setting (Suggested settings - Voltage/time per division)
More informationChapter 20 OBD-II Diesel Monitors
Light Vehicle Diesel Engines First Edition Chapter 20 OBD-II Diesel Monitors LEARNING OBJECTIVES (1 of 2) 20.1 Prepare for the Light Vehicle Diesel Engine (A9) ASE certification fuel system diagnosis and
More informationSymptom: P0068-MANIFOLD PRESSURE/THROTTLE POSITION CORRELA- TION - VACUUM LEAK DETECTED
Symptom: P0068-MANIFOLD PRESSURE/THROTTLE POSITION CORRELA- TION - VACUUM LEAK DETECTED When Monitored and Set Condition: VAC- UUM LEAK DETECTED When Monitored: During all drive modes. Set Condition: If
More informationService Bulletin. DTC Detection Item Associated Monitor
Service Bulletin 03-010 Applies To: All OBD II equipped models except SLX March 29, 2003 OBD II DTCs and Their Associated Monitors This is a list of all DTCs for all OBD II models. No one model has all
More informationPage 1 of 34 Print Date: 1994 ENGINE PERFORMANCE FORD MOTOR CO. - SYSTEM & COMPONENT TESTING - EEC-IV 5.0L INTRODUCTION 1994 Ford Mustang 5.0L Eng VIN T GT Before testing separate components or systems,
More informationOn Board Diagnostics II A PCED
Page 1 of 14 1998 PCED On Board Diagnostics II A SECTION 5A: Pinpoint Tests H: Fuel Control H: Introduction H20 PERFORM KOER SELF-TEST Key on, engine running and engine at operating temperature. Activate
More informationDIAGNOSTIC TROUBLE CODE (DTC) DEFINITIONS
DIAGNOSTIC TROUBLE CODE (DTC) DEFINITIONS NOTE: Use the following table to identify the DTC and find the correct test step for the type of DTC retrieved. DIAGNOSTIC TROUBLE CODE (DTC) DEFINITION Diagnostic
More information6.0L BUILT ON OR BEFORE 9/29/2003 DTCS P006A TSB OR P132B LACKS POWER, SURGE, OR FLUTTER AFTER FIELD SERVICE ACTION 06E17
6.0L BUILT ON OR BEFORE 9/29/2003 DTCS P006A TSB 06-24-6 OR P132B LACKS POWER, SURGE, OR FLUTTER AFTER FIELD SERVICE ACTION 06E17 FORD: 2003-2004 Excursion, F-Super Duty ISSUE 3. Using IDS datalogger,
More informationDTC P0341 Camshaft Position (CMP) Sensor Performance
Page 1 of 7 1997 Buick Riviera Aurora, Riviera (VIN G) Service Manual Document ID: 53298 DTC P0341 Camshaft Position (CMP) Sensor Performance Circuit Description The camshaft position PCM input is produced
More informationPowertrain DTC Summaries OBD II
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.5L and 3.0L 2002 Model Year Revised January, 2002: P0706, P0731, P0732, P0733, P0734, P0735, P0740, P1780 POSSIBLE CAUSES Revised
More information2000 Ford Mustang Diagnostic Trouble Code (DTC) Descriptions. DTC Description Possible Causes Diagnostic Aides
2000 Ford Mustang Diagnostic Trouble Code (DTC) Descriptions DTC Description Possible Causes Diagnostic Aides P0102 - Mass Air Flow The MAF sensor circuit MAF sensor A MAF V PID (MAF PID) (MAF) Circuit
More information1998 ENGINE PERFORMANCE. General Motors Corp. - Basic Diagnostic Procedures - 5.7L
INTRODUCTION 1998 ENGINE PERFORMANCE General Motors Corp. - Basic Diagnostic Procedures - 5.7L The following diagnostic steps will help prevent overlooking a simple problem. This is also where to begin
More informationDTC P1404 Exhaust Gas Recirculation (EGR) Closed Position Performance
Page 1 of 5 DTC P1404 Exhaust Gas Recirculation (EGR) Closed Position Performance Circuit Description The PCM monirs the EGR valve pintle position input ensure that the valve responds properly commands
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar S-TYPE V6, V8 N/A and V8 SC 2002.5 Model Year Refer to pages 2 9 for important information regarding the use of Powertrain DTC Summaries.
More informationTROUBLE SHOOTING > SYMPTOM DIAGNOSIS > SOME OR ALL SHIFTS MISSING TROUBLE SHOOTING > SYMPTOM DIAGNOSIS > NO 1-2, 2-3 OR 3-4 UPSHIFT (AUTOMATIC)
AUTOMATIC TRANSMISSION - DIAGNOSIS - E4OD A/T TROUBLE SHOOTING 1997 Ford Pickup 7.3L Eng F350 Question: overdrive off light is on steady TROUBLE SHOOTING > SYMPTOM DIAGNOSIS Question: Repeat OD planetary
More informationOn Board Diagnostics II A PCED
Page 1 of 5 1998 PCED On Board Diagnostics II A SECTION 5A: Pinpoint Tests KE: Idle Air Control (IAC) Valve KE: Introduction KE1 IDLE CONCERNS OR STALLS: RUN KOER SELF-TEST AND OUTPUT CONTINUOUS MEMORY
More informationVOLKS CITY BEECH AVENUE CATTEDOWN PLYMOUTH PL4 0QQ
VOLKS CITY BEECH AVENUE CATTEDOWN PLYMOUTH PL4 0QQ Telephone: 01752 667007 Fax: 01752 663399 Email: mail@volkscity.com 1 Camshaft position (CMP) sensor 1 2 Camshaft position (CMP) sensor 2 3 Camshaft position
More informationDE: Exhaust Back Pressure (EBP) Sensor
2002 PCED OBDII-Diesel SECTION 5: Pinpoint Tests DE: Exhaust Back Pressure (EBP) Sensor DE: Introduction DE1 DIAGNOSTIC TROUBLE CODE (DTC) P0470 DTC P0470 indicates an EBP sensor malfunction was detected
More information4HK1-TC ENGINE -Engine Mechanical Features- -Engine Control System & Diagnosis-
FOR SERVICE TRAINING 4HK1-TC ENGINE -Engine Mechanical Features- -Engine Control System & Diagnosis- Applicable Model Model Year Vehicle Model Main Market 2005 NPR & NQR General Export (Euro 3 Regulation)
More informationhttp://www.prodemand.com/print/index?content=tabs&module=true&tab=true&terms=t... Page of // 0 Chevrolet Traverse.L Eng LT Service Manual: WIRING DIAGRAMS Print Date: // ENGINE PERFORMANCE >.L VIN D Fig
More informationFord Immo Function list
Ford Immo Function list FORD Immobiliser Bantam Africa BA Falcon BF Falcon C-Max -2010 2013-2014 Select from Type Courier 1993-1996 2001-2008 2008-2001-2008 Immobiliser 2008-1993-1996 2001-2008 2008-2001-2008
More information1999 Dodge Durango ENGINE PERFORMANCE' 'Self-Diagnostics - Durango
DTC P0320: NO CRANK REFERENCE SIGNAL AT PCM For connector terminal identification, see CONNECTOR IDENTIFICATION. For circuit identification and wiring diagram, see DURANGO wiring diagram in WIRING DIAGRAMS
More informationFor Troubleshooting of DTC related components, see chart on page INTAKE AIR BYPASS (IAB) HIGH CONTROL SOLENOID
Index For Troubleshooting of DTC related components, see chart on page 11-53. '96-99 models: EXHAUST GAS RECIRCULATION (EGR) and LIFT MANIFOLD ABSOLUTE PRESSURE (MAP) INTAKE AIR BYPASS (IAB) HIGH page
More informationPage 1 of 8 HW7 DTC P1443: CHECK THE VOLTAGE ON THE PURGE FLOW (PF) SENSOR CIRCUIT VOLTAGE WITH ENGINE RUNNING Continuous Memory Diagnostic Trouble Code (DTC) P1443 indicates an incorrect evaporative system
More informationEngine Control Components
2009 PCED Gasoline Engines SECTION 1: Description and Operation Procedure revision date: 05/27/2010 Engine Control Components Note: Transmission inputs which are not described in this section, are discussed
More informationPage 1 of 18 2004 PCED On Board Diagnostics SECTION 5: Pinpoint Tests Procedure revision date: 10/26/2007 H: Fuel Control H: Introduction H1 PERFORM THE KOER SELF-TEST Engine at normal operating temperature.
More information2002 Ford Explorer AUTOMATIC TRANSMISSIONS' '5R55W/S Diagnosis 2002 AUTOMATIC TRANSMISSIONS. 5R55W/S Diagnosis
2002 AUTOMATIC TRANSMISSIONS 5R55W/S Diagnosis APPLICATION WARNING: Vehicles are equipped with Supplemental Inflatable Restraint (SIR) system. When servicing vehicle, use care to avoid accidental air bag
More informationBASIC DIAGNOSTIC PROCEDURES
BASIC DIAGNOSTIC PROCEDURES 2001 Chevrolet Camaro 2001 ENGINE PERFORMANCE Basic Diagnostic Procedures - Cars Except Metro & Prizm MODEL IDENTIFICATION MODEL IDENTIFICATION Body Code (1) Model C... Park
More informationDTC P0341 Camshaft Position (CMP) Sensor Performance
Page 1 of 5 1999 Buick Century Century, Regal VIN W Service Manual Document ID: 345654 DTC P0341 Camshaft Position (CMP) Sensor Performance Circuit Description During cranking, the Ignition Control Module
More informationDiagnostic Trouble Code (DTC) memory, checking and erasing
Page 1 of 49 01-12 Diagnostic Trouble Code (DTC) memory, checking and erasing Check DTC Memory (function 02) - Connect VAS5051 tester Page 01-7 and select vehicle system "01 - Engine electronics". Engine
More informationOn Board Diagnostics II A PCED
1998 PCED On Board Diagnostics II A SECTION 5A: Pinpoint Tests HA: Natural Gas Fuel Control HA: Introduction HA30 DTCS P05, P0141, P0155 AND P0161: HO2S HEATER SIGNAL CIRCUIT IS OPEN, SHORTED TO GROUND,
More informationEngine Controls - MIL ON/Lean DTC Service Tips
Engine Controls - MIL ON/Lean DTC Service Tips TSB 04-17-4 09/06/04 MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS FORD: 2000 Contour 2000-2002
More informationDiagnostic Trouble Codes (continued) GM Specific Codes
85 GM Specific Codes P11XX Fuel and Air Metering P1106 MAP Sensor Circuit Intermittent High Voltage P1107 MAP Sensor Circuit Intermittent Low Voltage P1108 BARO to MAP Signal Comparison Too High P1111
More informationDiagnostic Trouble Code (DTC) Charts
SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/30/2009 Diagnostic Trouble Code (DTC) Charts DTC Chart **May also be
More informationFORD Africa Bantam Fiesta Figo Icon Transit Asia China Immobiliser Ecosport Focus Classic focus Auto search
FORD Africa Bantam 2002-2008 Figo Icon 2002-2008 Transit 2014- Asia China Ecosport Focus Classic focus Auto search Manual selection New focus (2011-) (2014-) Escort -2013 2013- Escape Mondeo S-Max Transit
More informationHard Start or No Start Diagnostic Procedures
Page 1 of 48 2006 PCED 6.0L Diesel SECTION 4: Diagnostic Subroutines Procedure revision date: 05/08/2015 E-Series or F-Super Duty Hard Start or No Start Diagnostic Procedures Printable view of this graphic
More informationP0016. P0016 Crankshaft Position-Camshaft Position Correlation(Bank I Sensor A) Component Location
3/10/2018 P0016 (ALL Diagnostic Trouble Codes ( DTC )) - ALLDATA 2006 Kia Truck Sorento 2WD V6-3.5L Vehicle > ALL Diagnostic Trouble Codes ( DTC ) > Testing and Inspection > P Code Charts P0016 P0016 Crankshaft
More informationHistorical Powertrain Diagnostic Trouble Codes (DTC) Overview and Summary
General Service Bulletin (GSB): Historical Powertrain Diagnostic Trouble Codes GSB Overview: This bulletin explains historical DTCs. NOTE: This information is not intended to replace or supersede any warranty,
More informationDiagnostic Trouble Code (DTC) table
Page 1 of 40 01-19 Diagnostic Trouble Code (DTC) table Note: When malfunctions occur in monitored sensors or components, Diagnostic Trouble Codes (DTCs) are stored in DTC memory with a description of the
More informationOn Board Diagnostics II Diesel PCED
Page 1 of 6 1997 PCED On Board Diagnostics II Diesel SECTION 6C: Reference Values PCM Pin Descriptions and Expected Values 49 State Except Econoline Control System Diagnostic Sheet Reference Pin # Name
More informationDTC P0341 Camshaft Position (CMP) Sensor Performance
Page 1 of 5 1998 Chevrolet Cavalier : Diagnostics > Diagnostic Routines > Powertrain > Engine Controls - 2.2L > DTC P0341 Camshaft Position (CMP) Sensor Performance DTC P0341 Camshaft Position (CMP) Sensor
More information2010 MaxxForce 11 and 13L Diagnostics
2010 MaxxForce 11 and 13L Diagnostics Study Guide TMT-121130 Study Guide 2010 MaxxForce 11 and 13L Diagnostics TMT-121130 2011 Navistar, Inc. 4201 Winfield Road, Warrenville, IL 60555. All rights reserved.
More informationFig.11 Powertrain Control Module (PCM)
2003 Dodge or Ram Truck Caravan V6-3.3L VIN R Vehicle > Powertrain Management > Relays and Modules - Powertrain Management > Relays and Modules - Computers and Control Systems > Engine Control Module >
More informationEngine Cranks But Does Not Run
Page 1 of 5 2000 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Engine Engine Controls - 4.8L, 5.3L, and 6.0L Diagnostic Information and Procedures Engine
More information8/18/2017 PPT AF: Glow Plug System - On Board Diagnostics 6.0L Diesel (Powertrain Diagnostics) 2004 Ford F-250 MotoLogic
2004 F-250 2004 PCED On Board Diagnostics 6.0L Diesel SECTION 5: Pinpoint Tests Report a problem with this article Procedure revision date: 02/19/2007 AF: Glow Plug System AF: Introduction AF1 PRELIMINARY
More informationTorque Converter Clutch (TCC) Solenoid
Torque Converter Clutch (TCC) Solenoid The torque converter clutch (TCC) solenoid provides torque converter clutch control by shifting the converter clutch control valve to apply or release the TCC. PINPOINT
More informationPOWERTRAIN CONTROL MODULE (PCM) - NGC
2011 Dodge or Ram Truck Grand Caravan V6-3.6L Vehicle > ALL Diagnostic Trouble Codes ( DTC ) > Testing and Inspection > P Code Charts > P0128 POWERTRAIN CONTROL MODULE (PCM) - NGC P0128-THERMOSTAT RATIONALITY
More information