Washer-Extractor Pocket Hardmount UWPV Parts P U SH U0C Part No. F06R April 999
Table of Contents Title Page Parts Ordering Information... Nameplate Location... Model Identification... Control Module Assembly (New Style)... Control Module Assembly (Old Style)... 6 AC Drive Box Assembly... AC Drive, Balance Switch and Control Transformer Assembly... 0 Door Box Assembly (New Style)... Door Box Assembly (Old Style)... Door Assembly... 6 Basket Assembly (Old Style)... Basket Assembly (New Style)... 0 Soap Dispenser Assembly (Old Style)... Soap Dispenser Assembly (New Style)... Spray and Fill Plumbing Assembly (For / inch Fill Valves)... 6 Spray and Fill Plumbing Assembly (For / inch Fill Valves)... Spray and Fill Plumbing Assembly (For / inch Fill Valves)... 0 Drain Valve Assembly... Drain Valve and Hose Assembly... Ball Drain Assembly ( inch Drain, for F0600)... 6 Ball Drain Assembly ( inch Drain, for F06)... Motor and Belt Assembly... 0 Cover Panels (Old Style)... Cover Panels (New Style)... Auxiliary Steam Heat Assembly... 6 Direct Steam Heat Assembly... Parts Index... Copyright 999, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. F06
Parts Ordering Information Alliance Laundry Systems is not responsible for personal injury or property damage resulting from improper service. Review all service information before beginning repairs. If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (90) -90 for the name of the nearest authorized parts distributor. For technical assistance, call any of the following numbers: (0) -0 (0) -06 Marianna, Florida (90) - Ripon, Wisconsin Nameplate Location When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on nameplate(s) as shown. UW0PVQU000 Model No. 90 Serial No. 00-0 9 Voltage Amps 0 Required Circuit Breaker Amps. 0-60 Hz Wire Phase 0 0 LB Max. Load KG Max. Speed RPM Elec. Heating Steam Press PSI BAR KW Product No. 000 Date Code 09 P U SH U0M F06
Model Identification Information in this manual is applicable to this washer-extractor: UWPV F06
Notes
Control Module Assembly (New Style) 6 9 0 6 9 0 6 9 0 6 P0PEA F06
Control Module Assembly (New Style) REF PART # DESCRIPTION COMMENTS F0 Switch F0 Decal Emergency Stop F006 Emergency Stop Pushbutton F0 Decal F0-0 WE-6 Microcomputer Kit 6 F00 Contactor 0 Amp F0 Interface Board F0 RC Network Filter 9 F0 Solid State Fuse/Relay Board 0 F0 Tubing Sold per foot F00 Union /6 Connector F0 Water Level Switch F60 Water Level Switch Bracket F0000 Buzzer 0 Volt F0 Terminal Strip 6 F06 Decal F06 Keymode Switch/Run F0 Feed-thru Connector Gray 9 F06 Feed-thru Connector Blue 0 F0 Circuit Breaker Amp F06 Input Power Terminal Block F06 Decal F0 Connector F096 Screw F0 Plug 6 F009 Connector F0909 Bushing F000 Connector 9 F0 Ground Lug 0 F -way Supply Valve 0 Volt, Elbi F0 -way Supply Valve 0 Volt, Mueller F06 Decal F0 Terminal Strip F09 Screw F0 Fuse Amp F0 Fuseholder Dual 6 F00 Pushbutton Mounting Base F09 Contact Block Switch F0 Decal F06
Control Module Assembly (Old Style) 9 6 0 6 9 0 0 9 6 6 P09PEB 6 F06
Control Module Assembly (Old Style) REF PART # DESCRIPTION COMMENTS F0 Switch 0 Volt F0 Decal Emergency Stop F006 Emergency Stop Pushbutton F0 Decal F0 Decal 6 F0-0 WE-6 Microcomputer Kit F00 Contactor 0 Amp F0 Interface Board 9 F0 RC Network Filter 0 F0 Relay Board F0 Hose Sold per foot F00 Union /6 Connector F0 Water Level Switch Tri-Level F60 Water Level Switch Bracket F0000 Buzzer 0 Volt 6 F0 Terminal Strip F06 Decal F06 Keymode Switch/Run 9 F0 Feed-thru Connector Gray 0 F06 Feed-thru Connector Blue F0 Circuit Breaker Amp F06 Input Power Block F06 Decal F0 Connector F096 Screw 6 F0 Plug F009 Connector F0 Ground Lug 9 F09 Screw 0 F09 Contact Block Switch F00 Pushbutton Mounting Base F06
AC Drive Box Assembly 9 0 6 0 Po96PEC F06
AC Drive Box Assembly REF PART # DESCRIPTION COMMENTS F0900 Filter Retainer Guard F0 Filter Mesh F096 Screw F0 Gasket Sold per foot F006 Muffin Fan 0 Volt 6 F0 Nut F00 Lockwasher F0 Inverter Drive 00 Volt F0 Inverter Drive 00 Volt 9 F00 Gasket Sold per foot 0 F0 Nut F9 Insulator Mount F06 9
AC Drive, Balance Switch and Control Transformer Assembly 6 9 Mylar 0 PPEB 0 F06
AC Drive, Balance Switch and Control Transformer Assembly REF PART # DESCRIPTION COMMENTS F006 Nut F0 Nut F0 Transformer Cover Mylar Cover F60 Control Transformer F00 Bolt 6 F00 Washer F00 Nut F00 Washer 9 F06 Retro Kit Q Voltage models, To A&B Drive F06 Retro Kit P and N Voltage models, A to AB Drive F06 Retro Kit P Voltage models, To A&B Drive F06 Retro Kit Q Voltage models, A to AB Drive 0 F0 Parameter Unit Z-Drive F09 Parameter Unit A-Drive F09 Parameter Unit AB-Drive F600 Balance Switch Bracket F0 Screw F009 Bolt F0906 Microswitch F06
Door Box Assembly (New Style) 6 PPEA F06
Door Box Assembly (New Style) REF PART # DESCRIPTION COMMENTS F6006 Door Box Left F0900 Door Hinge Microswitch F00 Door Unlock Solenoid 0Volt F0 RC Network Filter F099 Screw 6 F09 Extension Arm Microswitch F090 Door Handle Microswitch F600 Door Box Right F06
Door Box Assembly (Old Style) 6 9 6 0 P09PEC F06
Door Box Assembly (Old Style) REF PART # DESCRIPTION COMMENTS F6006 Door Box Left F0900 Door Hinge Microswitch F600 Door Lock Plunger F0 Nut F9000 Insulator 6 F09 Spring F6090 Door Lock Collar F00 Set Screw 9 F0 Cotter Pin 0 F09 Screw F000 Door Unlock Solenoid 0 Volt F090 Door Hinge Switch F600 Door Box Right F09 Screw F0 Gasket 6 F09 Switch Extension F000 Mounting Bracket F06
6 F06 Door Assembly P0PEB 6 9 9 9 0 9 0 9 0 0 9 9 6 9 6
Door Assembly REF PART # DESCRIPTION COMMENTS F06 Nut F00 Washer F0 Door Butt Hinge F00 Door Glass Retainer F0 Gasket Sold per foot 6 F900 Door Glass F06 Door Assembly Kit F06 Door Gasket 9 F090 Screw 0 F609 Door Box Strap F600 Latch Bracket Shim F00 Door Handle F Washer F06 Shoulder Bolt F600 Door Box Right 6 F600 Plate F00 Lower Latch Bracket F00 Nut 9 F09 Bolt 0 F600 Extension Arm Short F00 Bolt F066 Door Bumper F06 Door Bumper Bushing F600 Door Cam Adjusting Rod F0 Door Hinge Strap 6 F600 Door Cam Adjusting Nut F6006 Door Box Left F0 Retainer Ring 9 F600 Door Pin 0 F0 Nut F00 Lockwasher F0 Washer F06
Basket Assembly (Old Style) 6 P099Pea F06
Basket Assembly (Old Style) REF PART # DESCRIPTION COMMENTS F900 Shell Band Bolt Kit Includes reference numbers - F0 Nut F0 Washer F000 Bolt F6060 Shell Band F00 Gasket Sold per foot 6 F6066- Basket/Shaft Assembly Standard F606 Shell Assembly Standard F60- Frame Assembly F06 9
Basket Assembly (New Style) 6 P00Pea 0 F06
Basket Assembly (New Style) REF PART # DESCRIPTION COMMENTS F0 Nut F0 Washer F000 Bolt F6060 Shell Band F00 Gasket Sold per foot 6 F6066- Basket/Shaft Assembly Standard F60 Shell Assembly Standard F60 Frame Assembly F06
Soap Dispenser Assembly (Old Style) 6 6 6 0 9 LID LOCK DETAIL PP EA F06
Soap Dispenser Assembly (Old Style) REF PART # DESCRIPTION COMMENTS F6060 Supply Valve Manifold Assembly 0 Volt F000 U-Bolt # F600 Soap Dispenser Manifold F9 Hose Barb F000 Hose Sold per foot F609 Soap Dispenser Shelf 6 F60 Supply Dispenser Cup 6 ounce cup F060 Rubber Grommet F0 Spray Rinse Nozzle 9 F0 Rivet Post 0 F Washer #0 F609 Soap Dispenser Link Arm F00 Valve Solenoid 0 Volt F096 Screw F0606 Nut F Elbow 6 F99 Hose Barb F000 Clamp #6 F06
Soap Dispenser Assembly (New Style) 6 9 0 LID LOCK DETAIL PP EA F06
Soap Dispenser Assembly (New Style) REF PART # DESCRIPTION COMMENTS F000 Clamp #6 F0 Y Connector F000 Hose Sold per foot F0 -Way Valve Mueller F -Way Valve Elbi F60 Soap Dispenser Cup 6 F060 Grommet For Injection Nozzle F06 Injection Kit F0 Post Rivet 9 F Washer 0 F609 Soap Dispenser Link Arm F06
Spray and Fill Plumbing Assembly (For / inch Fill Valves) 0 9 6 6 P9P EA 6 F06
Spray and Fill Plumbing Assembly (For / inch Fill Valves) REF PART # DESCRIPTION COMMENTS F90 Hose Barb F000 Valve Gate F00 Nipple F000 Elbow F9 Nipple 6 F00 Tee F0 Valve 0 Volt, Hays F0 Nipple 9 F90 Hose Barb 0 F00 Elbow F00 Vacuum Breaker F000 U-Clamp # F0 Nipple F00 Hose F06
Spray and Fill Plumbing Assembly (For / inch Fill Valves) 6 0 9 9 9 6 PP EA F06
Spray and Fill Plumbing Assembly (For / inch Fill Valves) REF PART # DESCRIPTION COMMENTS F90 Hose Barb F000 Gate Valve F00 Nipple F000 Elbow F909 Hose Adapter 6 F00 Tee F00 Valve 0 Volt, Hays F0 Nipple 9 F00 Elbow 0 F6060 Top Fill Tube F000 Vacuum Breaker F000 U-Clamp Includes Hardware F00 Tee F00 Nipple F00 Elbow 6 F06 Tube Connector F606 Spray Rinse Assembly F06 9
Spray and Fill Plumbing Assembly (For / inch Fill Valves) 6 6 6 6 9 P6PEA 0 F06
Spray and Fill Plumbing Assembly (For / inch Fill Valves) REF PART # DESCRIPTION COMMENTS F90 Hose Barb F000 Valve F00 Nipple F00 Nipple F000 Elbow F90 Hose Adapter 6 F000 U-Bolt F606 Spray Rinse Assembly F6060 Fill Assembly Top 9 F006 Hose F06
Drain Valve Assembly 6 9 0 6 P0PEB F06
Drain Valve Assembly REF PART # DESCRIPTION COMMENTS F09 Drain Valve Motor 0 Volt, 60 Hertz F60 Drain Valve Motor Cover F0 Nut F0 Washer F00 Spring 6 F60 Drain Valve Lift Bar F0 Clevis Clip F60 Drain Valve Bracket 9 F9 Roll Pin 0 F60 Drain Valve Arm F60 Drain Valve Linkage F000 Clamp #6 F60 Chafe Strip F00 Screw F600 Drain Valve Lift Tube 6 F006 Hose Pinch F06
Drain Valve and Hose Assembly 6 6 9 0 6 9 0 P09PEB F06
Drain Valve and Hose Assembly REF PART # DESCRIPTION COMMENTS F900 Elbow F60 Pipe F60 Pipe F00 Clamp #0 F000 Hose Sold per foot 6 F0 Nipple F00 Tee F0 Nipple 9 F00 Elbow 0 F00 Coupling F000 Valve Drain Kit 0 Volt, Pinch, See page for component parts F600 Pipe F0 Tee F0 Nipple F06
Ball Drain Assembly ( inch Drain, for F0600) ROUND SHAFT KEYED SHAFT P0PEB 6 F06
Ball Drain Assembly ( inch Drain, for F0600) REF PART # DESCRIPTION COMMENTS F0600 Drain Valve Assembly 0 Volt, 60 Hertz, inch F09 Main Drive Shaft and Seal Kit F09 Drain Valve Motor 0 Volt, 60 Hertz, Keyed Shaft F09 Drain Valve Motor 0 Volt, 60 Hertz, Round Shaft F06
Ball Drain Assembly ( inch Drain, for F06) PPEA F06
Ball Drain Assembly ( inch Drain, for F06) REF PART # DESCRIPTION COMMENTS F00 Clamp F0 Plug F09 Main Drive Kit Depend-O-Drain F06 Drain Valve F09 Motor Drain Valve F06 9
Motor and Belt Assembly (Single Motor) 6 9 0 P09PEA 0 F06
Motor and Belt Assembly (Single Motor) REF PART # DESCRIPTION COMMENTS F09 Motor Bearing 606-RS F000 Motor Bearing 60-Z F60 Key F09 Bushing Basket, Includes hardware F0 Belt BX0 F0 Pulley Basket F0 Bushing Motor, Includes hardware 6 F0 Pulley Motor F099 Bolt F00 Washer 9 F0 Motor 0 F000 Washer F00 Lockwasher F00 Nut F0 Key F06
Cover Panels (Old Style) 0 9 6 P06PEB F06
Cover Panels (Old Style) REF PART # DESCRIPTION COMMENTS F000 Trim Sold per foot F600 Cage Wrap Assembly F096 Screw F600 Expanded Metal Back Assembly F60 Side Panel Right 6 F0 Nut F00 Washer F609 Rub Rail 9 F60 Front Panel 0 F6099 Side Panel Left F06
Cover Panels (New Style) 0 6 9 P0PEB F06
Cover Panels (New Style) REF PART # DESCRIPTION COMMENTS F60 Side Panel Left F096 Screw F0606 Nut F000 Trim Sold per foot F600 Cage Wrap 6 F6099 Side Panel Right F0 Nut F00 Washer 9 F09 Screw 0 F609 Rub Rail F60 Front Panel F06
Auxiliary Steam Heat Assembly 6 0 9 0 9 P0PEB 6 F06
Auxiliary Steam Heat Assembly REF PART # DESCRIPTION COMMENTS F00 Filter F009 Plug F000 U-Bolt #, Includes hardware F606 Bracket F0 Washer 6 F0 Nut F0 Nut F000 Elbow 9 F00 Bushing 0 F60 Injection Tube Assembly F00 Hose Sold per foot F09 Screw F06
Direct Steam Heat Assembly P09PEB F06
Direct Steam Heat Assembly REF PART # DESCRIPTION COMMENTS F0 Elbow F000 U-Bolt Includes hardware F06 9
Parts Index B Balance Switch Bracket F600... Basket/Shaft Assembly F6066-... 9, Belt F0... Bolt F00... F00... F009... F000... 9, F09... F099... Bracket F606... Bushing F0909... F0... F09... F00... Buzzer F0000..., C Cage Wrap F600... Cage Wrap Assembly F600... Chafe Strip F60... Circuit Breaker F0..., Clamp F000... F000..., F00... F00... 9 Clevis Clip F0... Connector F009..., F0..., F000... Contact Block Switch F09..., Contactor F00... F00... Control Transformer F60... Cotter Pin F0... Coupling F00... D Decal F06... F06..., F06..., F0..., F0..., F0..., Door Assembly Kit F06... Door Box F6006...,, F600...,, Door Box Strap F609... Door Bumper F066... Door Bumper Bushing F06... Door Butt Hinge F0... Door Cam Adjusting Nut F600... Door Cam Adjusting Rod F600... Door Gasket F06... Door Glass F900... Door Glass Retainer F00... Door Handle F00... Door Handle Microswitch F090... Door Hinge Microswitch F0900..., Door Hinge Strap F0... Door Hinge Switch F090... Door Lock Collar F6090... Door Lock Plunger F600... Door Pin F600... Door Unlock Solenoid F000... F00... Drain Valve F06...9 Drain Valve Arm F60... Drain Valve Assembly F0600... Drain Valve Bracket F60... F06
Drain Valve Lift Bar F60... Drain Valve Lift Tube F600... Drain Valve Linkage Arm F60... Drain Valve Motor F09..., F09... Drain Valve Motor Cover F60... F00...9 Gate Valve F000...9, Grommet F060... Ground Lug F0... F0... H E Elbow F000..., 9,, F00... 9 F00... 9 F00... F00... F0... 9 F... F900... Emergency Stop Pushbutton F006..., Expanded Metal Back Assembly F600... Extension Arm F600... Extension Arm Microswitch F09... F Feed-thru Connector F0..., F06..., Fill Assembly F6060... Filter F00... Filter Mesh F0... 9 Filter Retainer Guard F0900... 9 Frame Assembly F60-... 9 F60... Front Panel F60..., Fuse F0... Fuseholder F0... G Gasket F0... F00... 9, F0... F0... 9 Hose F000... F000..., F006... F00... F006... F00... F0... Hose Adapter F90... F909...9 Hose Barb F99... F90..., 9, F9... F90... I Injection Kit F06... Injection Tube Assembly F60... Input Power Block F06... Input Power Terminal Block F06... Insulator F9000... Insulator Mount F9...9 Interface Board F0..., Inverter Drive F0...9 F0...9 K Key F0... F60... Keymode Switch/Run F06..., L Latch Bracket Shim F600... F06
Lockwasher F00... F00... 9, Lower Latch Bracket F00... M Main Drive Kit F09... 9 Main Drive Shaft and Seal Kit F09... Microswitch F0906... Motor F0... F09... 9 Motor Bearing F000... F09... Mounting Bracket F000... Muffin Fan F006... 9 N Nipple F00... 9, F00... F00... 9 F0... F0... F0... F0..., 9 F0... F9... F00... Nut P F00...,, F006... F0..., 9,,,, F0... 9,,,, F0... 9 F0606..., F06... Parameter Unit F0... F09... F09... Pipe F600... F60... F60... Plate F600... Plug F0..., F0... 9 F009... Post Rivet F0... Pulley F0... F0... Pushbutton Mounting Base F00..., R RC Network Filter F0...,, Relay Board F0... Retainer Ring F0... Retro Kit F06... F06... F06... F06... Rivet Post F0... Roll Pin F9... Rub Rail F609..., Rubber Grommet F060... S Screw F00... F0... F090... F09... F096..., 9 F09... F09... F09... F09..., F096...,, F099... v... Set Screw F00... Shell Assembly F606...9 F60... Shell Band F6060...9, Shell Band Bolt Kit F900...9 Shoulder Bolt F06... Side Panel F60..., F6099..., Soap Dispenser Cup F60... Soap Dispenser Link Arm F609..., F06
Soap Dispenser Manifold F600... Soap Dispenser Shelf F609... Solid State Fuse/Relay Board F0... Spray Rinse Assembly F606... 9, Spray Rinse Nozzle F0... Spring F00... F09... Supply Dispenser Cup F60... Supply Valve Manifold Assembly F6060... Switch F0..., Switch Extension F09... T Tee F00... 9 F00... 9 F00... F00... F0... Terminal Strip F0..., F0... Top Fill Tube F6060... 9 Transformer Cover F0... Trim F000..., Tube Connector F06... 9 Tubing F0... Valve F000... F00...9 F0... Valve Drain Kit F000... Valve Solenoid F00... W Washer F000... F00..., F00... F0..., 9,, F0... F00...,, F... F..., Water Level Switch F0..., Water Level Switch Bracket F60..., WE-6 Microcomputer Kit F0-0..., Numerics -way Supply Valve F0... F... -Way Valve F0... F... Symbols Y Connector F0... U U-Bolt F000...,, 9 F000... U-Clamp F000... 9 F000... Union F00..., V Vacuum Breaker F000... 9 F00... F06