Parts Breakdown Mobile Column Lift 4V DC Powered 4 Column Lift Capacity,000 lbs. Column Lift Capacity 10,000 lbs. 1,000 lbs. per column IMPORTANT: When ordering parts or requesting service always give exact model and power unit serial number. Model number is shown on nameplate attached to side of column. Power unit serial number is located on front of power unit. Date Installed Installed in Bay # OWNERS RECORD Complete information at right and keep in a safe place. Power Unit Serial # Power Unit Model # Lift Serial # Lift Model # NOTE: For replacement parts -See your nearest Forward Parts Distributor. June 01 by Vehicle Service Group Asia. All rights reserved. PB0119 Rev. A..01
Item Description Part No. 1 Control Panel Assembly M1100 Membrane Touchpad FA94 3 E-Stop Actuator FA9 4 Dual Push Button "Moeller" FA9- Dual Push Button "Sprecher + Schuh" Z1004 Switch N.O. "Moeller" M130091 Switch N.O. "Sprecher + Schuh" EXF0091100 Single Push Button "Moeller" FA9 Single Push Button "Sprecher + Schuh" M1301 Switch N.O. "Moeller" M130091 Switch N.O. "Sprecher + Schuh" EXF0091100 Audible Single Device FA94 Control Board FA9 1/" Hole Plug FA9-9 9 UI Board FA93 10 DC Disconnect Switch FA9-4 11 Cord Hook M1019 1 Upper Cover Assembly M11000 13 Cover Weldment M1013 14 Side Panel Assembly M11001 1 RP SMA Jack Bulkhead M1300 1 RF Antenma M13004 1 Modem Assembly M14003 1 Self Tapping Screw M13013 19 Left Hand Fork Lift Bracket Assembly M11009 0 Right Hand Fork Lift Bracket Assembly M110030 1 Charger Internal Power Cord M13011 1 3 4 1 1 1 1 1 13 9 1 14 10 11 19 0
Item Description Part No. 1 M x 1.0 x 0mm Lg. HHCS, PLTD 41413 M1 x 1. x 00mm Lg. HHCS Grade., PLTD 3 M0 x. x 0mm HHCS Full Thread Grade., PLTD 4143 M13019 4 M1 Flat Washer 410 M x 1 x 30mm Lg. HHCS 4139 M Flat Washer 414 M x 1 Hex Nylon Insert Locknut M1 x 1. Hex Nylon Insert Lock Nut PLTD 413 41 9 M x 1.0 Hex FLGD WZLock Nut 411 10 Caster Mounting Weldment M10049Y 11 Caster Clevis Weldment M100Y 1 Handle Weldment M100Y 13 Caster Retainer Plate M100Y 14 Spring Cap Weldment M100Y 1 Brake Weldment M1000Y 1 Link Arm M1004Y 1 Caster Spring M130010 1 Caster Wheel M130101Y 19 UHMW Bearing Sheet M130019Y 0 Brake Spring M13000Y 1 Center Handle Bearing M13001Y Linkage Bearing M1300Y 3 Outer Handle Bearing M1300Y 4 Flange Bearing M1300Y 1 0 4 3 1 1 1 1 Detail A 3 14 1 10 19 1 11 4 See Detail A 9 13 3
Item Description Part No. 1 /1" SAE Flat Washer, PLTD 40 1/" SAE Flat Washer 4090 3 1/" x 1" Lg. Cotter Pin 4100 4 M10 x 1. x 3mm Nylon Locking SOC. HD. CS., PLTD 411 Base Weldment M1013Y Wheel Bracket Weld M10144Y Pivot Shaft M1014Y Leg Wheel M10149Y 9 Floor Roller Shaft M1010Y 10 Leg Wheel Spring M1011Y 11 Flanged Bearing M130030Y 1 Tie Bar M1004Y 13 M1 Lock Washer 419 14 M1 x 1. x 30mm Lg. HHCS Grade., PLTD 414 1 Swivel Nut Elbow # M1300 1 9/1" Internal Tooth Lock Washer, PLTD 4099 1 Bulkhead Union Elbow # T14013 1 Cylinder Hydraulic Tube M130009 19 Adapter FJ3-3 0 Velocity Fuse M13001 1 Hydraulic Cylinder M130001Y Cylinder Seal Kit M130130 Roller M13000Y 3 Carriage Slider M13000Y 4 Slider FC90-4Y WEMU Fixed Fork Carriage Assembly M110049Y 3 1 13 4 14 11 3 9 4
1 1 1 1 19 0 1 1 10 4
P3FY Power Unit 3 1 11 13 1 1 19 4 3 1 1 14 1 14 1 4 9 0 10
P3FY Power Unit Item Description Part No. 1 Base Assy. M319,MOD. () W/P P3DY-1 P Assy. QM MDLR, DC, BRGS BLD RSV P-30-3 MOTOR, DC, 4 VOLT TERM P3DY- 4 SHAFT, INTERMEDIATE, MOD, SPCL DC P-30-4 BEARING, MOTOR TO BASE, M-SERIES P-30- SCREW, SHC, 1/4-0 x 3.0, BLK OX. P-30- TUBE, SUCTION, POLY TANK P30-14 FILTER ASSY. SUCTION, SHROUD P3DY-3 9 TUBE, RETURN P30-10 10 POLY RESERVOIR P30-19 11 4V RELAY M130090 1 SCREW, H.H. CAP, M-1. x P-30-1 13 WASHER, STAR LOCK, /1 P-30-13 14 COIL, 4VDC, #, HIRSCHMAN, LOW WT P-30-14 1 CARTRIDGE, W/P, NC, POPPET, # P30-1 CARTRIDGE, W/P, NC, POPPET, 4000 P30-1 VALVE, RELIEF, PILOT OP, 9-10 BAR P3DY-4 1 SCREW, H.H. CAP, M10-1.0 x P-30-1 19 WASHER, INTERNAL TOOTH LOCK, 3/ P-30-19 0 BREATHER-FILLER PLUG, POLY TANK P30-1 1 BRACKET, MTG PLT, 3. CNTR P-30-1 FITTING, ELBOW, 90 DEG, 3 DEG P-30-3 POPPET ASSY, P CMP FL, GPM. P-30-3 4 POPPET ASSY, P CMP FL, GPM 1. P-30-4 PLUG, SAE O-RING, 3/4-1, HEX SOC P-30- PLUG, SAE O-RING, /1-0 HEX, SO P-30- WORM CLAMP, POLY TANK P30-0
Item Description Part No. 1 4V DC Power Unit P3 Power Unit Hose M13009 Upper Cover Removed For Clarity Of View 1 3 4 3 String Pot Assembly M110009 4 Solenoid M13001 Latch Assembly Bracket M100Y Battery Strap M13003 Battery Tray M101Y Battery Charger FA9-4 9 Fuse 00A FA9-10 Fuse Holder FA9-10 9
9
NOTES:
Installer: Please return this booklet to literature package, and give to lift owner/operator. Thank You Trained Operators and Regular Maintenance Ensures Satisfactory Performance of Your Rotary Lift. Contact Your Nearest Authorized Rotary Parts Distributor for Genuine Rotary Replacement Parts. See Literature Package for Parts Breakdown. Rotary World Headquarters 00 Lanier Drive Madison,IN40,USA www.rotarylift.com Rotary Lift Consolidated (Haimen) Co.,Ltd No.13,East Xiushan Road,Haimen, Jiangsu Province,China,100 www.vsg-asia.com P:-13-11 Printed in China,All Rights Reserved. Unless otherwise indicated,rotary, and all other trademarks are property of Dover Corporation and its affiliates.