SP0375
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Œ &RS\ULJKW 9ROYR &DUV RI 1RUWK $PHULFD //&
Contents Engine Detail...3 Engine Air Intake...4 Exhaust-Driven Turbocharger...5 Exhaust System...6 Engine Cooling and Cabin Heating...7 Air Conditioning...8 Leakage Detection System... 9 Automatic Transmission... 10 Drive Train... 11 Drive Train - All Wheel Drive... 12 Power Steering... 13 Braking System... 14 ABS & Stability Traction Control (STC)... 15 Dynamic Stability Traction Control (DSTC)... 16 Front Suspension... 17 Rear Suspension... 18 Wheel Alignment and Tire Wear... 19 Supplemental Restraint System... 20 Starting and Charging... 21 Index... 22 2 of 22
Valve and Lifter Engine Detail Exhaust-Driven Turbocharger Upper Engine Mount Piston Head Gasket Manifold Gasket Oil Filter Timing Belt Dual Camshafts Water Pump 3 of 22
Engine Air Intake Air to Turbochargers Air Hoses to Turbochargers Intercooler Air Intake Engine Air Filter Housing Mass Airflow Sensor (MAF) 4 of 22
Exhaust-Driven Turbocharger Heated Oxygen Sensors Turbocharger Catalytic Converters Turbocharger 5 of 22
Exhaust System Resonator Heated Oxygen Sensor Muffler Catalytic Converter 6 of 22
Engine Cooling and Cabin Heating Coolant Expansion Tank and Filling Point Cabin Heater Core Radiator 7 of 22
Air Conditioning Expansion Valve Climate Controls Service Valve Pressure Sensor Compressor In-Car Temperature Sensor Evaporator Receiver Condenser 8 of 22
Leakage Detection System Purge Valve Evaporative Vent Container-Close Valve Oil Trap Pressure Sensor Evaporative Fuel Canister 9 of 22
Automatic Transmission Transmission Position Sensor Pressure Control Solenoid Shift Solenoids 10 of 22
Drive Train Drive Axle CV Joints and Boots Automatic Transmission Shifter Assembly Differential Transmission Oil Cooler Automatic Transmission 11 of 22
Drive Train - All Wheel Drive Drive Shaft AWD Differential AWD Angle Gear Drive Shaft AWD Coupling CV Joints and Boots Automatic Transmission Shifter Assembly Automatic Transmission 12 of 22
Power Steering Power Steering Pump Fluid Reservoir Pinion Boot Tie-Rod End Ball Joint Rack 13 of 22
Parking Brake Lever and Cables Braking System Hydraulic Brake Line Fluid Reservoir Booster Master Cylinder ABS Control Module/ Brake Control Module Disc (Rotor) Caliper Anti-Rattle Spring Pads 14 of 22
ABS & Stability Traction Control (STC) Engine Control Module ABS Control Module 15 of 22
Dynamic Stability Traction Control (DSTC) Engine Control Module DSTC Brake Booster Yaw Sensor Lateral Acceleration Sensor Yaw Sensor Brake Pressure Sensors DSTC Control Module Brake Pedal Position Sensor Steering Angle Sensor (SAS) SAS Control Module 16 of 22
Front Suspension Spring Strut/Shock Absorber Anti-Sway Bar and Upper End Link Wheel Hub and Bearing Assembly Lower Ball Joint Engine Subframe Lower Control Arm 17 of 22
Rear Suspension Upper Control Arm Shock Absorber Knuckle Coil Spring Lower Control Arm Wheel Hub and Bearing Assembly Trailing Arm Bushing Trailing Arm 18 of 22
Wheel Alignment and Tire Wear Wear Bars Overinflation Underinflation Negative Caster Positive Caster Excess Toe In or Out Toe Out Toe In Over or Under Cambered Negative Camber Positive Camber 19 19 of of 22 22
Supplemental Restraint System Convertible ROPS Rollover Protection Control Module Seat Belt Tensioner Inflatable Curtain Rollover Protection Cassette Side Crash Sensor Passenger s Front Airbag Driver s Front Airbag Frontal Crash Sensor Seat Frame Side Airbag Side Crash Sensor 20 of 22
Starting and Charging Alternator Ignition Switch Instrument Panel Charging System Light Engine Control Module Battery Alternator Drive Belt Starter Motor Fuses Engine Bay Battery + Connector for Jump Starting Fuses Under Dash Fuses and Rear Electrical Module 21 of 22
ABS Control Module... 14, 15 Air Hoses to Turbochargers... 4 Air Intake... 4 Air to Turbochargers... 4 Alternator Drive Belt... 21 Alternator... 21 Anti-Rattle Springs... 14 Anti-Sway Bar and Upper End Link... 17 Automatic Transmission Shifter Assembly... 11, 12 Automatic Transmission... 11, 12 AWD Angle Gear... 12 AWD Coupling... 12 AWD Differential... 12 Battery... 21 Battery+ Connector for Jump Starting... 21 Booster... 14 Boot... 13 Brake Pedal Position Sensor... 16 Brake Pressure Sensor... 16 Braking System... 14 Cabin Heater Core... 7 Caliper... 14 Catalytic Converter... 5, 6 Climate Control... 8 Coil Spring... 18 Compressor... 8 Condenser... 8 Container-Close Valve... 9 Convertible ROPS... 20 Coolant Expansion Tank and Filling Point... 7 CV Joints and Boots... 11, 12 Differential... 11 Disc (Rotor)... 14 Drive Axle... 11 Drive Shaft... 12 Driver s Front Airbag... 20 DSTC Brake Booster... 16 DSTC Control Module... 16 Dual Camshafts... 3 Engine Air Filter Housing... 4 Engine Control Module... 15, 16, 21 Engine Subframe... 17 Evaporative Fuel Canister... 9 Evaporative Vent... 9 Evaporator... 8 Excess Toe In or Out... 19 Exhaust-Driven Turbocharger... 3 Index Expansion Valve... 8 Fluid Reservoir... 13, 14 Front Suspension Lower Ball Joint... 17 Front Susupension Lower Control Arm... 17 Frontal Crash Sensor... 20 Fuses and Rear Electrical Module... 21 Fuses Engine Bay... 21 Fuses Under Dash... 21 Head Gasket... 3 Heated Oxygen Sensor... 5, 6 Hydraulic Brake Line... 14 Ignition Switch... 21 In-Car Temperature Sensor... 8 Inflatable Curtain... 20 Instrument Panel Charging System Light... 21 Intercooler... 4 Knuckle... 18 Lateral Acceleration Sensor... 16 Manifold Gasket... 3 Mass Airflow Sensor (MAF)... 4 Master Cylinder... 14 Muffler... 6 Negative Camber... 19 Negative Caster... 19 Oil Filter... 3 Oil Trap... 9 Over Inflation... 19 Over or Under Cambered... 19 Pads... 14 Parking Brake Lever and Cable... 14 Passenger s Front Airbag... 20 Pinion... 13 Piston... 3 Positive Camber... 19 Positive Caster... 19 Power Steering Pump... 13 Pressure Control Solenoids... 10 Pressure Sensor... 8, 9 Purge Valve... 9 Rack... 13 Radiator... 7 Rear Suspension Lower Control Arm... 18 Rear Suspension Upper Control Arm... 18 Receiver... 8 Resonator... 6 Rollover Protection Cassette... 20 Rollover Protection Control Module... 20 SAS Control Module... 16 Seat Belt Tensioner... 20 Seat Frame... 20 Service Valve... 8 Shift Solenoids... 10 Shock Absorber... 18 Side Airbag... 20 Side Crash Sensor... 20 Spring Strut/Shock Absorber... 17 Starter Motor... 21 Steering Angle Sensor (SAS)... 16 Tie-Rod End Ball Joint... 13 Timing Belt... 3 Toe In... 19 Toe Out... 19 Trailing Arm Bushing... 18 Trailing Arm... 18 Transmission Oil Cooler... 11 Transmission Position Sensor... 10 Turbocharger... 5 Under Inflation... 19 Upper Engine Mount... 3 Valve and Lifter... 3 Water Pump... 3 Wear Bars... 19 Wheel Alignment and Tire Wear... 19 Wheel Hub and Bearing Assembly... 17, 18 Yaw Sensor... 16 22 of 22