YA SURFACE AND FLUSH MOUNTED LIFT (000 SERIES) 000 lb. Capacity (6000 lbs. per axle) P A R T S B R E A K D O W N IMPORTANT: When ordering parts or requesting service always give exact model and power unit serial number. Model number is shown on nameplate attached to air lock release valve. Power unit serial number is located on side of power unit. OWNERS RECORD Complete information at right and keep in a safe place. Date Installed Installed in Bay # Power Unit Serial # Power Unit Model # Lift Serial # Lift Model # NOTE: For Replacement Parts - See Your Nearest Rotary Parts Distributor NOTE: For replacement parts -See your nearest Rotary Parts Distributor. January 00 by Rotary Lift. All rights reserved. CO. LP00 PB-- Rev. - /9/00 *PLP00 *
RIGHT HAND RUNWAY SEE PAGE RAMPS SEE PAGE LEFT HAND RUNWAY SEE PAGE ELECTRICAL CONTROL SEE PAGE 0 0 SEE PAGE 6 9 0 6 9 0 0 6 AIRLINE BRACKET DETAIL L RUNWAY LENGTH VERSION 6 6 9 9
0 /"-0NC x -/" Lg HHCS, GRD 00 /"-NC x -/" Lg HHCS, GRD 06 /"-0NC HEX NUT, PLTD 066 / x / COUPLING NUT 06 /"-0NC HEX FLGD WZLOCK NUT, PLTD 6 000 /"-NC HEX JAM NUT 09 /"-0NC HEX JAM NUT, PLTD 0 #0-NC HEX NYLON INSERT LOCKNUT 9 AP000 #0-NC x /" Lg. HEX SHCS 0 FA0- TUBE /" X 60' #PPB- FA0- / PARAFLEX HOSE-0' LG NA NA FA CARBON STEEL RADIUS GAUGE S00 STAINLESS STEEL RADIUS GAUGE FA-0 /" NPT LOCKNUT FA9-9 /" NPT STRAIN RELIEF 6 FC- PORTABLE WORK STEP FC-6 ADJUSTMENT SCREW ASSEMBLY (LONG) FC- MALE ELBOW 9 FC- MALE CONNECTOR 0 FC- RECOIL HOSE, /" FC0 WHEEL CHOCK FC- TUBING ASSEMBLY FC-6 UNION TEE FC-9 /" UNION FC-9 /" CONCRETE ANCHOR 6 FC RUBBER STOP FJ60 " PAD LIFT ADAPTER ASSEMBLY FJ6-6 NOTCHED SHIM 9 FJ0 /" X -/" CONCRETE ANCHOR 0 FJ69- FRONT SHIM RJ000 # ROLLING JACK FOR SM/SMO/AR/ARO S000 FILTER-REGULATOR-LUBRICATOR S09 AIRLINE RETAINER CABLE (EL VERSION) S00 AIRLINE RETAINER CABLE (L VERSION) S060 RECOIL HOSE, /" ' LENGTH (EL VERSION) FC- RECOIL HOSE, /" (L VERSION) SJ6000 6000 LB SWING AIR JACK 6 XS006 AIRLINE RETAINER CABLE Z0000 " x " x -/" TURN-TABLE INSERT KIT (SEE PAGE 6) Z00 ADJUSTMENT SCREW ASSEMBLY (SHORT) 9 Z09 BASEPLATE HOSE COVER 0 Z060 HOSE COVER 0 / -0NC x HHCS Z0 POSITION SENSOR GUARD
SEE PAGE 9 0 6 SEE PAGE 6 6 SEE DETAIL B 6 9 6 60 0 6 9 6 9 9 0 6 6 SEE PAGE 9 6 0 SEE PAGE 6 9 0 6 SEE PAGE 6 DETAIL B RIGHT RUNWAY
00 /"-0NC x /" Lg HHCS, GRD PLTD 00 /"-0NC x " Lg HHCS, GRD PLTD 0 /"-6NC x /" Lg. HEX FLGD WZLOCK CS, PLTD 00 /"-6NC x -/" Lg HHCS, GRD PLTD 00 /"-6NC x -/" Lg HHCS, GRD 6 00 /"-6NC x -/" Lg HHCS, GRD 00 /"-6NC x -/" Lg HHCS, GRD 06 /"-NC x " Lg. HEX FLGD WZLOCK CS, PLTD 9 06 /"-NC x -/" Lg HHCS, GRD PLTD 0 0 /"-NC x -/" Lg HHCS, GRD 09 /"-6NC x -/" Lg HHCS, GRD PLTD 06 /"-0NC HEX NYLON INSERT LOCKNUT 06 /"-6NC HEX NYLON INSERT LOCKNUT 066 /"-6NC HEX FLGD WZLOCK NUT, PLTD 000 /"-NC HEX JAM NUT 6 00 /"-NC HEX NYLON INSERT LOCKNUT 0 -/"-NC HEX JAM NUT 990 /6" WIDE x " LONG BLACK WIRE TIE 9 AP009 / SPIRAL WRAP 0 FA0- TUBE /" X 60' #PPB- FA0- / PARAFLEX HOSE-0' LG FC- SPRING NP6 LABEL C (NOT SHOWN) NP66 LABEL C (NOT SHOWN) NP9 KEEP CLEAR OF PINCH POINTS WARNING NAMEPLATE NP96 DO NOT USE ANCHOR HOLE WARNING NAMEPLATE 6 NP9 INTRINSICALLY SAFE NAMEPLATE (NOT SHOWN) Z000 LEFT RUNWAY ASSEMBLY (EL VERSION) (SEE PAGE 6) Z00 LEFT RUNWAY ASSEMBLY (L VERSION) (SEE PAGE 6) Z000 RIGHT RUNWAY ASSEMBLY (EL VERSION) (SEE PAGE 6) Z00 RIGHT RUNWAY ASSEMBLY (L VERSION) (SEE PAGE 6) Z000 LEFT LEG ASSEMBLY 9 Z000 RIGHT LEG ASSEMBLY 0 Z00 LIFT ARM ASSEMBLY Z00 LOCK CARRIAGE ASSEMBLY (SEE PAGE ) Z00 POSITION SENSOR ASSEMBLY (SEE PAGE 9) Z00 ARM ASSY - SENSOR Z00 REAR SLIP PLATE ASSEMBLY (SEE PAGE ) Z000 RUNWAY ENDPLATE WELD 6 Z00 RIGHT SLIDE BEAM WELD Z00 LEFT SLIDE BEAM WELD Z009 HYD CYLINDER ROD MOUNT WELD 9 Z00 LOCK DRAG LINK PIN WELD 0 Z00 LOCK SLIDER PIN WELD Z00 UPPER PIN WELD Z00 CENTER PIN WELD Z00 LEFT FRONT UPPER PIN WELD Z006 LOWER PIN WELD Z00 LEG REINFORCEMENT WELD 6 Z009 BASEPLATE WELD Z000 RIGHT FRONT UPPER PIN WELD Z00 LOCK DRAG LINK 9 Z00 CENTER PIN SPACER TUBE 0 Z00 FRONT UPPER PIN SPACER TUBE Z006 LEG SUPPORT PLATE Z009 FRONT WHEEL STOP Z0 HYD CYLINDER PIN Z000 SLIDERS Z000 HYD CYLINDER PIN RETAINER 6 Z006 HYDRAULIC HOSE Z00 VELOCITY FUSE Z00 HOSE CLAMP 9 Z00 SAE#6 ELBOW FITTING 60 Z009Y HYDRAULIC CYLINDER 6 Z00 LONG SLIDER 6 Z00 SENSOR HARNESS 6 Z000 -/ BEARING 6 Z000 -/ BEARING 6 Z000 SHORT -/ BEARING
NP NAMEPLATE NP FOOT WARNING DECAL NP9 ROTARY DECAL NP9 HAND CRUSH/FORCE FROM ABOVE WARNING LABEL Z000 RIGHT RUNWAY WELDMENT (EL VERSION) Z00 RIGHT RUNWAY WELDMENT (L VERSION) 9 SEE DETAIL A 0 09 /"-6NC x " Lg HHCS, GRD PLTD 00 /6"-NC x /" Lg. HEX FLGD WZLOCK CS, PLTD 069 /" HEX PLUG 0660 /"-6NC HEX NUT 0 /" EXT TOOTH LW, PLTD 6 FA0- / PARAFLEX HOSE-0' LG FA- MALE BRANCH TEE - /" NPT TO /" TUBE FC- FEMALE BULKHEAD 9 FC- MALE RUN TEE 0 FC- MALE BRANCH TEE FC- MALE ELBOW FC-9 RETAINER BRACKET NP9 HAND CRUSH/FORCE FROM ABOVE WARNING LABEL Z000 Z000 LEFT RUNWAY WELDMENT (EL VERSION) LEFT RUNWAY WELDMENT (L VERSION) Z00 RUNWAY GUIDE BAR 6
6 SEE DETAIL A 9 0 REAR SLIP PLATE 006 /-0NC X / FLAT HEAD SHCS, PLATED 006 /"-0NC x /" Lg. SLOTTED RHMS 06 /"-0NC HEX NYLON INSERT LOCKNUT 06 /" INT TOOTH LW, PLTD FC90- SLIP PLATE BALL 6 Z00 REAR SLIP PLATE LOCK PIN ASSY Z00 REAR SLIP PLATE WELD Z009 REAR SLIP PLATE BASE PLATE WELD 9 Z006- REAR SLIP PLATE BALL RETAINER - " RUNWAY 0 Z00 REAR SLIP PLATE RETAINER PLATE Z00 REAR SLIP PLATE RETAINER SPRING Z00 REAR SLIP PLATE REFURBISH KIT
Radius Gauge Rebuild Kits Stainless Steel: FA- Kits include: Delrin Balls Zinc Internal Lock Washers Carbon Springs Bearing Retainers Top Taper Screws Bottom Set Screws 0 9 6 LOCK CARRIAGE 0 /"-0NC x -/" Lg HHCS, GRD 06 /"-NF HEX JAM NUT 06 /"-0NC HEX NYLON INSERT LOCKNUT 06 /6"ID x /"OD x /6" THK WASHER, PLTD FC- SPRING 6 FC-90 MALE ELBOW CONNECTOR T006 AIR CYLINDER Z000 LOCK CARRIAGE WELD 9 Z00 LOCK DOG WELD 0 Z00 LOCK DOG PIN WELD
6 POSITION SENSOR 00 #0-NC x -/" Lg. HEX SHCS PLATED 0 #0 SAE FLAT WASHER, PLTD 0 #0-NC HEX NYLON INSERT LOCKNUT Z00 POS SEN ARM WELD Z006 POS SEN MOUNT WELD 6 Z0006 ROTARY POTENTIOMETER Z009 POS SENSOR BEARING Z00 POS SENSOR RETAINING RING 9
9 6 SEE PAGE 9 0 ELECTRICAL CONTROL 6 6 9 0 60 0 6 0 0
6 9 9 6 9
00 /"-0NC x /" Lg. SLOTTED PHMS 0 #6-NC x /" Lg. BHCS 06 /"-0NC HEX FLGD WZLOCK NUT, PLTD 6 #-0NC x /" Lg. HEX SHCS 66 # EXT TOOTH LW, PLTD 6 0 #- x /" Lg. HEX WHSFTS, PLTD 6 #- x /" Lg. HEX WHSFTS, PLTD #-0 NUT 9 ALI-ETL NAMEPLATE 0 AP009 / SPIRAL WRAP (NOT SHOWN) FA-6 MALE ELBOW CONNECTOR FA- LATCH AIR VALVE FA- IN-LINE REGULATOR - /" NPT FA6- /" FLEXIBLE NYLON TUBING x -/" LG. FA9- /" NPT BRASS FILTER 6 FA9-9 /" NPT STRAIN RELIEF FA9- /" NPT STRAIN RELIEF FA6 ZERO-SCISSOR BARRIER KIT 9 FA6 CONTACTOR 0 NA NA FA99 TRANSFORMER SECONDARY ADAPTER HARNESS (H6) FA9-0 /" HOLE PLUG FA9- /"NPT HOLE CORD GRIP FA9- CORD GRIP FA96 CONTROL BOARD 6 FA9 AUDIBLE SIGNAL DEVICE FA990 TRANSFORMER FC- FEMALE BULKHEAD 9 FC- MALE BRANCH TEE 0 FC- MALE CONNECTOR FC-90 MALE ELBOW CONNECTOR MC00 GROUND BAR NP DECAL - 000 LBS CAP NP9 ALI/WL00W LABEL NP0 ALI/WL00S LABEL 6 NP ALI/WL00C LABEL NP0 MOTOR LOCATION WARNING LABEL NP MULTIPLE POWER SOURCE LABEL 9 NP60 NAMEPLATE 0 NP69 NAMEPLATE NP6 C LABEL NP66 C LABEL NP9 P BUTTON LABEL NP6 NAMEPLATE NP99 NAMEPLATE 6 NP9 NAMEPLATE NP9 SINGLE PHASE ELECTRICAL SCHEMATIC NAMEPLATE NP9 NAMEPLATE 9 NP9 OIL FILTER REPLACEMENT NAMEPLATE 0 NP966 CALIBRATION LABEL NP90 NAMEPLATE
NP90 NAMEPLATE T00 FEMALE CONNECTOR XS009 WIRE TIE DOWN XS009 FEMALE THD STAND OFF #6- x -/ Lg. MMC #90A60 Z00 SINGLE PHASE POWER UNIT (SEE PAGE ) Z00 THREE PHASE POWER UNIT Z00 THREE PHASE POWER UNIT (V) 6 Z00 TRANSFORMER MOUNTING PLATE WELD Z00 POWER UNIT MOUNTING BRACKET Z006 -/6" HOLE PLUG 9 Z000 CONTROL CABINET 60 Z00 -POLE TERMINAL 6 Z00 ACTUATOR HARNESS (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) 6 Z00 VALVE HARNESS (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) 6 Z00 VALVE HARNESS (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) 6 Z006 TB HARNESS (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) 6 Z00 E-STOP BYPASS HARNESS (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) 66 Z009 V POWER HARNESS (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) 6 Z000 HI GROUND CABLE (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) 6 Z00 DISCONNECT-CONTACTOR HARNESS (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) 69 Z00 POWER HARNESS (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) Z006 THREE PHASE POWER HARNESS (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) 0 Z00 MOTOR CABLE (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) Z00 THREE PHASE MOTOR CABLE (NOT SHOWN - SEE ELECTRICAL SCHEMATIC) Z00 DUAL PUSH BUTTON Z00 ILLUMINATED SINGLE PUSH BUTTON Z009 6V LAMP Z000 AIRLINE TUBING Z00 DISCONNECT SWITCH W/HANDLE
0 09 /"-6NC x /" Lg. HEX FLGD WZLOCK CS, PLTD 0 /"-6NC x " Lg. HEX FLGD WZLOCK CS, PLTD 06 /"-NC x -/" Lg HHCS, GRD PLTD 09 /" HELICAL SPRING LW, PLTD FA9-9 /" NPT STRAIN RELIEF 6 FC6- MAGNET FJ ELBOW ADAPTER XS00 DRAIN PLUG 9 Z00 HYD TANK COVER WELD 0 Z009 HYD TANK WELD Z0009 POWER UNIT MANIFOLD Z000 POWER UNIT HYD PUMP Z00 PUMP COUPLING Z00 RETURN LINE Z00 PUMP/MANIFOLD HOSE 6 Z00 SUCTION TUBE Z009 SUCTION STRAINER Z00 CAP W/DIPSTICK 9 Z00 SAE# x / NPT FITTING 0 Z000 PUMP MOUNT ADAPTER Z00 MOTOR COUPLING Z00 COUPLING SPIDER Z00 MOUNT ADAPTER GASKET Z00 SINGLE PHASE MOTOR Z00 THREE PHASE MOTOR Z00 THREE PHASE MOTOR (V) Z00 SAE# O-RING x JIC FITTING 6 Z009 DEGREE ADAPTER Z00 FILTER 6 9 9 6 6 0 POWER UNIT
0 /" x " Lg COTTER PIN FC-99 HINGE PIN Z00 STANDARD RAMP WELD Z00 EXTENDED RAMP WELD Z000 ROLLER SHAFT Z00 RAMP ROLLER 06 /"-0NC HEX NYLON INSERT LOCKNUT 000 /"-0NC x /" Lg. HEX FLGD WZLOCK CS, PLTD FC- RAMP CHOCK SLIDE Z00 FLUSH RAMP WELD
6 " x " x -/" TURN-TABLE INSERT 00 /6"-NC x /" Lg. HEX FLGD WZLOCK CS, PLTD 06 /"-6NC x /" Lg. HEX FLGD WZLOCK CS, PLTD, GRD FC ROLL BACK FILLER Z006 RUNWAY FILLER WELD Z0069 TURN-TABLE INSERT WELD 6 Z0 TURN-TABLE GUIDE BAR Page 6 Rotary World Headquarters 00 Lanier Drive Madison, IN 0, USA www.rotarylift.com North America Contact Information Tech. Support: p 00.. f 00.. e userlink@rotarylift.com Sales: p 00.60. f 00.. e userlink@rotarylift.com Rotary, Printed in U.S.A., All Rights Reserved. Unless otherwise indicated, ROTARY, DOVER and all other trademarks are property of Dover Corporation and its affiliates. World Wide Contact Information World Headquarters/USA:...6 Canada:.90..990 European Headquarters/Germany: +9..9.0 United Kingdom: +... Australasia: +60..660.0 Latin America / Caribbean: +...60 Middle East / Northern Africa: +9..9.0