Miniature General Purpose Solvent Proof 5 C Temperature The series capacitors are designed for general purpose use with an operating temperature range for most of these capacitors from 55 C to 5 C. The series is a miniaturized version of the KME series with a load life of,000 hours at 5 C with the rated ripple current applied. The series capacitors below 350 volts were developed to withstand HCC cleaning agents for five minutes by ultrasonic, vapor or immersion. This solvent proof design allows all circuit board components to be cleaned together, at the same time, without resorting to more expensive epoxy end-sealed capacitors. Refer to the Mini-Glossary for recommended cleaning conditions. Radial lead terminals. range: to 22,000µ. range: 6.3 to 450VDC. Operating temperature range: 55 C to 36 United Chemi-Con, Inc. 980 W. Higgins Road, Rosemont, IL 6008 Tel 847-696-2000 ax 847-696-9278 www.chemi-con.com
Specifications Item Characteristics Range 6.3 to 0VDC 60 to 400VDC Operating Temperature Range 55 to 5 C 40 to 5 C Range to 22,000 Tolerance 20% (M) at 20 C, 20Hz Leakage Current At 20 C 450VDC 25 to 5 C Dissipation actor (Tan ) Low Temperature Characteristics DC 6.3-0V 60-450V Test Time After minute After minute After 5 minutes Leakage Current ( A) I 0.03CV or 4 A, whichever is greater. CV,000: I CV 40 CV >,000: I 0.04CV 0 CV,000: I 0.03CV 5 CV >,000: I 0.02CV 25 Where I = Leakage current ( A), C = capacitance ( ) and V= voltage (V) At 20 C, 20Hz (V) Tan (D) 6.3 0.34 0.24 6 0.20 25 6 35 4 50 2 63 0. 0 0.08 60-250 0.20 When nominal capacitance exceeds,000, add 0.02 to the values above for each,000 increase. 350-450 0.24 At 20Hz, impedance (Z) ratio between the 25 C or 40 C value and 20 C value shall not exceed the values given below. MINIATURE -5 C (V) 6.3 6 25 35 50-0 60-250 350-400 450 Z( 25 C)/Z( 20 C) 5 4 3 2 2 2 3 6 6 Z( 40 C)/Z( 20 C) 2 8 5 4 3 4 6 Multipliers Refer to Section 4 of the Mini-Glossary for explanation of Multipliers. Ambient Temperature ( C) 85 C 5 C.75 requency (Hz) ( ) 50Hz 20Hz 300Hz khz khz 0kHz 3.3 0.65.35.75 2.30 2.50 4.7-33 0.75.25.50.75.80 47-00 0.80.5.30.40.50 2200 0.85.03.05.08.08 Load Life Shelf Life Others The following specifications shall be satisfied when the capacitors are restored to 20 C after subjecting them to the DC rated voltage for the specified test time at 5 C with the rated ripple current applied. The sum of DC voltage and peak AC voltage must not exceed the full rated voltage of the capacitors. Case Diameter Test Time Ø5-Ømm,000 hours for 6.3-450V Ø2.5- Ø8mm,000 hours for 6.3-0V 2,000 hours for 60-450V change: 20% of initial measured value Tan (D) : 200% of initial specified value Leakage current : initial specified value The following specifications shall be satisfied when the capacitors are restored to 20 C after exposing them for,000 hours at 5 C without voltage applied. The rated voltage shall be applied to the capacitors for a minimum of 30 minutes, at least 24 hours and not more than 48 hours before the measurements. change: 20% of initial measured value Tan (D) Leakage current Satisfies characteristic W of JIS C54 : 200% of initial specified value : initial specified value for 6.3-0V : 500% of initial specified value for 60-450V United Chemi-Con, Inc. 980 W. Higgins Road, Rosemont, IL 6008 Tel 847-696-2000 ax 847-696-9278 www.chemi-con.com 37
Diagram of Dimensions VB/Radial Lead Unit: mm PVC Sleeve d D' D Vent (Except 5) L L' 5 MIN. 4 MIN. 5~ 8 2.5~ 8 MINIATURE -5 C Gas escape end seal for all case diameters. or optional lead configurations and tape and ammo packaging, refer to the beginning of the Miniature section. ØD 5 6.3 8,2.5 6, 8 ØD'max. L'max. Ød 0.5 0.5 0.6 0.6 0.8 0.5 2.0 2.5 3.5 5.0 7.5 ing System for Series When ordering, always specify complete catalog number for Series. 400 VB 22R M 2X25 LL Lead Length: LL is Standard. Case Code: See Case Sizes in Tables. Tolerance: M = 20% Value: Expressed in Microfarads. The first two digits are significant figures, and the third digit indicates the number of zeros for capacitance of 0 or more. R indicates the decimal point for capacitance less than 0 (e.g. R22 =.22 ; 2R2 = 2.2 ; 22R=22 ; 22= 220 ; 222 = 2,200 ; 223 = 22,000 ). Lead Configuration: VB = Radial Lead Terminals. DC : Expressed in Volts (e.g. 400 = 400WVDC). Series Name: Indicates Basic Capacitor Design. (µ) ESR 5 C,20Hz 6.3 Volts 8 Volts Surge 220 6.3VB22M5XLL 5 2.562 40 330 6.3VB33M6XLL 6.3.708 90 470 6.3VB47M6XLL 6.3.99 230 680 6.3VB68M8XLL 8.5 0.829 3,000 6.3VB2M8XLL 8.5 0.564 380,500 6.3VB52MX6LL 6 0.376 540 2,200 6.3VB222MX20LL 20 0.27 7 3,300 6.3VB332MX20LL 20 9 840 4,700 6.3VB472M2X20LL 2.5 20 4,090 6,800 6.3VB682M2X25LL 2.5 25 0.7,350,000 6.3VB3M6X25LL 6 25 0.086,650 5,000 6.3VB53M6X35LL 6 35.5 0.069 2,0 22,000 6.3VB223M8X40LL 8 40 0.057 2,350 38 United Chemi-Con, Inc. 980 W. Higgins Road, Rosemont, IL 6008 Tel 847-696-2000 ax 847-696-9278 www.chemi-con.com
(µ) ESR 5 C,20Hz Volts 3 Volts Surge 6 Volts 20 Volts Surge 220 VB22M6XLL 6.3.808 70 330 VB33M6XLL 6.3.205 200 470 VB47M6XLL 6.3 0.846 250 680 VB68MX2LL 2.5 0.585 380,000 VB2MX2LL 2.5 0.398 460,500 VB52MX20LL 20 0.265 625 2,200 VB222MX20LL 20 96 760 3,300 VB332M2X20LL 2.5 20 4,000 4,700 VB472M2X25LL 2.5 25 0.6,260 6,800 VB682M6X25LL 6 25 0.083,570,000 VB3M6X35LL 6 35.5 0.07,890 5,000 VB53M8X35LL 8 35.5 0.057 2,80 0 6VBM5XLL 5 3.35 50 6VB5M6XLL 6.3 2.2 45 220 6VB22M6XLL 6.3.507 80 330 6VB33M8XLL 8.5 5 260 470 6VB47M8XLL 8.5 0.705 3 680 6VB68MX6LL 6 0.488 460,000 6VB2MX6LL 6 0.332 560,500 6VB52M2X20LL 2.5 20 0.22 760 2,200 6VB222M2X20LL 2.5 20 66 920 3,300 6VB332M2X25LL 2.5 25 2,70 4,700 6VB472M6X25LL 6 25 0.092,480 6,800 6VB682M6X3LL 6 3.5 0.073,780,000 6VB3M8X35LL 8 35.5 0.063 2,060 MINIATURE -5 C 25 Volts 32 Volts Surge 47 25VB47RM5XLL 5 5.643 80 68 25VB68RM5XLL 5 3.9 96 0 25VBM6XLL 6.3 2.652 30 50 25VB5M8XLL 8.5.768 60 220 25VB22M8XLL 8.5.205 230 330 25VB33M8XLL 8.5 0.804 3 470 25VB47MX2LL 2.5 0.564 380 680 25VB68MX20LL 20 0.39 560,000 25VB2MX20LL 20 0.265 680,500 25VB52M2X25LL 2.5 25 77 895 2,200 25VB222M2X25LL 2.5 25 36,090 3,300 25VB332M6X25LL 6 25,400 4,700 25VB472M6X3LL 6 3.5 0.078,7 6,800 25VB682M8X35LL 8 35.5 0.063 2,040 35 Volts 44 Volts Surge 47 35VB47RM5XLL 5 4.937 90 68 35VB68RM6XLL 6.3 3.43 20 0 35VBM6XLL 6.3 2.32 50 50 35VB5M8XLL 8.5.547 220 220 35VB22M8XLL 8.5.055 270 330 35VB33MX2LL 2.5 0.703 350 470 35VB47MX6LL 6 0.494 460 680 35VB68M2X20LL 2.5 20 0.34 665,000 35VB2M2X20LL 2.5 20 0.232 8,500 35VB52M6X25LL 6 25 55,030 2,200 35VB222M6X25LL 6 25 2,260 3,300 35VB332M6X35LL 6 35.5 0.09,6 4,700 35VB472M8X35LL 8 35.5 0.07,9 United Chemi-Con, Inc. 980 W. Higgins Road, Rosemont, IL 6008 Tel 847-696-2000 ax 847-696-9278 www.chemi-con.com 39
(µ) ESR 5 C,20Hz MINIATURE -5 C 50 Volts 63 Volts Surge 50VBRM5XLL 5,989.0.3 0.22 50VBR22M5XLL 5 904.09 2.9 0.33 50VBR33M5XLL 5 602.727 4.3 0.47 50VBR47M5XLL 5 423.9 6.2.0 50VBR0M5XLL 5 98.9 3 2.2 50VB2R2M5XLL 5 90.409 20 3.3 50VB3R3M5XLL 5 60.273 25 4.7 50VB4R7M5XLL 5 42.39 30 50VBRM5XLL 5 9.89 40 22 50VB22RM5XLL 5 9.04 65 33 50VB33RM5XLL 5 6.027 90 47 50VB47RM6XLL 6.3 4.232 68 50VB68RM8XLL 8.5 2.925 45 0 50VBM8XLL 8.5.989 80 50 50VB5MX2LL 2.5.326 245 220 50VB22MX2LL 2.5 0.904 300 330 50VB33MX6LL 6 0.603 4 470 50VB47MX20LL 20 0.423 530 680 50VB68M2X25LL 2.5 25 0.293 780,000 50VB2M2X25LL 2.5 25 99 950,500 50VB52M6X3LL 6 3.5 33,4 2,200 50VB222M6X35LL 6 35.5 0.5,470 3,300 50VB332M8X35LL 8 35.5 0.08,770 63 Volts 79 Volts Surge 63VBRM5XLL 5 6.575 46 22 63VB22RM5XLL 5 7.534 7 33 63VB33RM6XLL 6.3 5.023 0 47 63VB47RM6XLL 6.3 3.527 20 0 63VBMX2LL 2.5.658 25 220 63VB22MX6LL 6 0.753 335 330 63VB33MX20LL 20 0.502 5 470 63VB47M2X20LL 2.5 20 0.353 640,000 63VB2M6X25LL 6 25 66 930 0 Volts 25 Volts Surge 0.47 0VBR47M5XLL 5 282.28 7..0 0VBR0M5XLL 5 32.6 5 2.2 0VB2R2M5XLL 5 60.273 2 3.3 0VB3R3M5XLL 5 482 29 4.7 0VB4R7M5XLL 5 28.23 32 0VBRM6XLL 6.3 3.26 54 22 0VB22RM8XLL 8.5 6.027 93 33 0VB33RM8XLL 8.5 4.08 30 47 0VB47RMX2LL 2.5 2.82 65 0 0VBMX20LL 20.326 265 220 0VB22M2X25LL 2.5 25 0.603 440 330 0VB33M6X25LL 6 25 0.402 540 470 0VB47M6X3LL 6 3.5 0.282 75,000 0VB2M8X40LL 8 40 33 985 60 Volts 200 Volts Surge 3.3 60VB3R3M6XLL 6.3 0.455 28 4.7 60VB4R7M6XLL 6.3 70.532 34 60VBRMX2LL 2.5 33.5 67 22 60VB22RMX20LL 20 5.068 20 33 60VB33RMX20LL 20.045 45 47 60VB47RM2X20LL 2.5 20 7.053 95 0 60VBM6X25LL 6 25 3.35 335 220 60VB22M6X3LL 6 3.5.507 540 330 60VB33M8X35LL 8 35.5 5 705 40 United Chemi-Con, Inc. 980 W. Higgins Road, Rosemont, IL 6008 Tel 847-696-2000 ax 847-696-9278 www.chemi-con.com
(µ) ESR 5 C,20Hz 200 Volts 250 Volts Surge 250 Volts 300 Volts Surge 3.3 200VB3R3M6XLL 6.3 0.455 28 4.7 200VB4R7M8XLL 8.5 70.532 39 200VBRMX6LL 6 33.5 74 22 200VB22RMX20LL 20 5.068 20 33 200VB33RM2X20LL 2.5 20.045 60 47 200VB47RM2X20LL 2.5 20 7.053 95 0 200VBM6X25LL 6 25 3.35 335 220 200VB22M8X35LL 8 35.5.507 575 2.2 250VB2R2M6XLL 6.3 50.682 23 3.3 250VB3R3M8XLL 8.5 0.455 32 4.7 250VB4R7M8XLL 8.5 70.532 39 250VBRMX6LL 6 33.5 74 22 250VB22RM2X20LL 2.5 20 5.068 30 33 250VB33RM2X20LL 2.5 20.045 60 47 250VB47RM2X25LL 2.5 25 7.053 2 0 250VBM6X3LL 6 3.5 3.35 365 220 250VB22M8X40LL 8 40.507 585 MINIATURE -5 C 350 Volts 400 Volts Surge Not Solvent Proof 0.47 350VBR47M6XLL 6.3 846.383.0 350VBR0M6XLL 6.3 397.8 5 2.2 350VB2R2M8XLL 8.5 80.88 26 3.3 350VB3R3MX2LL 2.5 20.545 38 4.7 350VB4R7MX6LL 6 84.638 50 350VBRMX20LL 20 39.78 80 22 350VB22RM2X20LL 2.5 20 8.082 30 33 350VB33RM6X25LL 6 25 2.055 95 47 350VB47RM6X25LL 6 25 8.464 230 0 350VBM8X3LL 8 3.5 3.978 375 400 Volts 450 Volts Surge Not Solvent Proof 0.47 400VBR47M8XLL 8.5 846.383.0 400VBR0M6XLL 6.3 397.8 5 2.2 400VB2R2M8XLL 8.5 80.88 26 3.3 400VB3R3MX2LL 2.5 20.545 38 4.7 400VB4R7MX6LL 6 84.638 50 400VBRMX20LL 20 39.78 80 22 400VB22RM2X25LL 2.5 25 8.082 45 33 400VB33RM6X25LL 6 25 2.055 95 47 400VB47RM6X3LL 6 3.5 8.464 250 450 Volts 500 Volts Surge Not Solvent Proof 0.47 450VBR47MX2LL 2.5 846.383 9.0 450VBR0MX2LL 2.5 397.8 3 2.2 450VB2R2MX2LL 2.5 80.88 23 3.3 450VB3R3MX6LL 6 20.545 3 4.7 450VB4R7MX20LL 20 84.638 40 450VBRM2X20LL 2.5 20 39.78 65 22 450VB22RM6X25LL 6 25 8.082 5 33 450VB33RM6X3LL 6 3.5 2.055 55 47 450VB47RM6X35LL 6 35.5 8.464 85 United Chemi-Con, Inc. 980 W. Higgins Road, Rosemont, IL 6008 Tel 847-696-2000 ax 847-696-9278 www.chemi-con.com 4
Temperature Characteristics Temperature Characteristics 6VB22M6X 50VBRM5X MINIATURE -5 C Change (%) Dissipation actor (Tan ) 25VB22M8X (at 20Hz) 0 20 40 20 0 20 40 60 80 5 Change (%) Dissipation actor (Tan ) 50VB33MX6 (at 20Hz) 0 20 55 40 20 0 20 40 60 80 5 0.0 40 20 0 20 40 60 80 5 Temperature ( C) 0.0 55 40 20 0 20 40 60 80 5 Temperature ( C) Impedance requency Characteristics Impedance requency Characteristics 6VB22M6X 50VBRM5X Impedance (ohms) 0 25VB22M8X (at 20 C) Impedance (ohms) k 0 50VB33MX6 (at 20 C) 0 k k 0k requency (Hz) 0 k k 0k requency (Hz) 42 United Chemi-Con, Inc. 980 W. Higgins Road, Rosemont, IL 6008 Tel 847-696-2000 ax 847-696-9278 www.chemi-con.com