0 West th Avenue, Chico CA, Phone: (0) -0 Fax: (0) - Website: www.thomaswelding.com Email: info@thomaswelding.com parts@thomaswelding.com
NUT BANKOUT SERIAL NUMBER:
TABLE OF CONTENTS Safety First... Purpose of this Manual... Important Ordering Information... Cab Assemblies Primary Cab Assemblies... Cab Top Assembly... Cab Door Assembly... Dash Panel Controls & Components... Old Style Dash Panel Controls & Components... Steering Column Assembly... Hydraulic Control Levers & Cables... Brake Pedal Assembly... Brake Master Cylinder Assembly... Air Conditioning Configurations by Year... 0-Current Air Conditioning Unit... 0-Current Control Inlet Assembly 00-0 Control Inlet Assembly.. 0-0 Cab Air Filter Assembly... Pre-0 Evaporator Assembly. Pre-0 Cab Air Filter Assembly.... Bin Assemblies Bin Assembly Breakdown... Front Gate Assembly... Engine Air Intake Snorkel Tube Assembly... Auger Assemblies... Auger Motor Assembly Hoses & Fittings... Bin Extension Assembly... Bin Undercarriage Components & Rear Air Screens... Chassis Assemblies Chassis Components Breakdown... Cummins Engine, Pump & Drive Components... Cummins Engine Assembly Bolt-On Components... Bolt-On Components Reference Table... Cummins Engine Assembly Piping & Hoses... Radiator Package Breakdown... Oil Cooler Assembly... Condenser Mounting... Donaldson Engine Air Filter... Air Filter Vacuum Kit.. Driveline Assembly. Hydrostat Pump & Motor Assembly.. Hydraulic Pump & Priority Block Assembly Bump/ Coast Valve Assembly. Hydraulic Control Valve Assembly Extension Hitch. Auxiliary Hoist Pump & Cylinder Assembly Hoist Cylinder Assembly. Diesel Fuel Tank IV 0 0 0 0
TABLE OF CONTENTS Hydraulic Oil Tank Front & Rear Bumper Components. Front Axle Assemblies Front Axle Breakdown... Front Axle Third Member & Spider Gear Assembly Front Axle Brake Components Front Axle Spindle, Brake & Hub Assembly.. Front Axle Brake Assembly.. Front Axle Driver Side Knuckle Assembly.. Front Axle Passenger Side Knuckle Assembly. Front Axle Shaft Assembly Front Axle Ball Style Axle Shaft Assembly.. Rear Axle Assemblies Rear Axle Breakdown Rear Axle King Pin Assembly Rear Axle Spindle, Brake & Hub Assembly Rear Axle Brake Assembly. Steering Assemblies Drag Link Pivot Assembly.. Tie Rods & Drag Links.. Steering Cylinder Assembly. Steering Cylinder Plumbing. Technical Information Hydraulic System Schematic.. Hydraulic Schematic Reference Table. Brake System Schematic Air Conditioning Schematic & Components by Year... Wiring Harness Schematic... Bankout Dimensions. V 0 0
SAFETY FIRST PAGE The owner, each operator, maintenance personnel and others within the operating area of a Nut Bankout must read and understand all of the information contained within both the Safety manual as well as the Maintenance manual before operating this equipment. Whenever you see this safety symbol It has the meaning of WARNING, DANGER, or CAUTION. You will see this symbol used in various locations on Thomas Ag Equipment wherever a safety hazard warning exists. DANGER Means the most serious hazard is present. Exposure will likely lead to injury or death. WARNING Means a lesser hazard exists. Risk of injury or death exists here. CAUTION Is a reminder to follow safety instructions and points out less serious hazards. NEVER perform any maintenance on a Nut Bankout until the engine is turned off, the wheels have been blocked, the parking brake is firmly applied and any other company Lockout/Tagout procedures have been followed. Do not perform any service, repair, or inspections under a raised cargo bin unless the safety strut is properly in place. BE ALERT TO SAFETY HAZARDS!! CA PROP
PAGE PURPOSE OF THIS MANUAL The intention of this manual is to aid the owner, operator, and maintenance personnel with ordering replacement parts for required routine maintenance and repair. All replaceable parts can be found in their appropriate sections. Page numbers can be found on the table of contents and are listed in the index located on the last page of this manual. Thomas manufacturing s robust products are built to last and we have continued to progress our designs to build the best products. We are here to help with ordering the correct replacement parts for older machines or specialty parts, and a service representative can assist as needed. Proper use and routine maintenance performed by informed people will ensure that your Thomas Bankout continues as a safe and efficient tool for your agricultural operation. The Warranty Document for this equipment appears with your copy of the Purchase-Order which you received at the time of purchase. It is essential to cite the chassis serial number in all correspondence and repair parts order to ensure correct replacment parts are shipped for the appropriate machine. IMPORTANT ORDERING INFORMATION The drawings in this catalog represent Bankout manufactured from 00 to present. Bankout made prior to 00 may not be accurately represented by the drawings in this catalog. To ensure you recieve the correct parts, it is essential to include the year of manufacture and serial number when ordering. The manufacture year of your Bankout can be found on the original sales invoice, the serial number and the plaque on the front of the cab as shown below. BATTERY BOX YEAR OF MANUFACTURE SERIAL NUMBER OF MACHINE SERIAL NUMBER WELDED ON FRAME TUBE BEHIND BATTERY BOX FIRST TWO DIGITS REPRESENT THE YEAR OR MANUFACTURE
PRIMARY CAB ASSEMBLIES PAGE 0 PART QTY CATALOG PAGE B00-00 DASH PANEL CONTROLS AND COMPONENTS, B0-00 BANKOUT SEAT - B0-000A CONTROL INLET ASSEMBLY B0-000A A/C HOUSING ASSEMBLY B0-000 BRAKE COMPONENTS 0 B0-000 THROTTLE PEDAL ASSEMBLY - B0-000A E-BRAKE HANDLE ASSEMBLY B0-000 STEERING COLUMN ASSEMBLY B-000A LIMB GAURD - 0 B0-000A CAB DOOR ASSEMBLY B0-000 CAB TOP ASSEMBLY B0-00 BRAKE MASTER CYLINDER & BOOSTER B0-00 BRAKE FLUID RESERVOIR AF0-000 SYKLONE AIR FILTER ASSEMBLY
CAB TOP ASSEMBLY PAGE 0 *NOTE: CAB TOP GLASS IS ONLY AVAILABLE FOR MODELS MADE IN 0 OR LATER PART B0-000 COMPLETE CAB TOP ASSEMBLY WITH GLASS B0-0 PASSENGER SIDE CAB GLASS PANE B0-0 REAR CAB GLASS PANE B0-0 FRONT CAB GLASS PANE B0-0 DRIVER SIDE REAR CAB GLASS PANE B0-0 DRIVER SIDE FRONT GLASS PANE B0-0 PASSENGER SIDE GLASS TRIM SEAL B0-0 REAR GLASS TRIM SEAL B0-0 DRIVER SIDE FRONT GLASS TRIM SEAL 0 B0-0 DRIVER SIDE REAR GLASS TRIM SEAL B0-0 FRONT GLASS TRIM SEAL B-000A CAB BRUSH GUARD - " X " HEX BOLT - " SAE FLAT WASHER - " NYLOCK NUT QTY.
CAB DOOR ASSEMBLY PAGE WINDOW TRIM REPLACEMENT KIT (S -,, & 0) PART B0-00 0 0 DOOR LATCH STRIKER MOUNTS TO DOOR JAM OF LOWER CAB BY DASH PART QTY. B0-000A COMPLETE CAB DOOR ASSEMBLY B0-00 WINDOW TRACK STOP BLOCK B0-0 WINDOW VELVET - FRONT B0-0 WINDOW VELVET - LONG B0-0 WINDOW VELVET - SHORT B0-0 WINDOW VELVET - TOP-BOTTOM B0-0 CAB DOOR GLASS PANE B0-0 STAINLESS FELT SEAL B0-0 VERTICAL GLASS SEAL 0 B0-0 SLIDER WINDOW HANDLE B0-00 INSIDE DOOR HANDLE B0-0A DOOR TRIMLOCK SEAL B0-00 WINDOW TRIM KIT (EXCLUDES GLASS) B0-00 DOOR LATCH ASSEMBLY B0-0 DOOR LATCH STRIKER B0-00 CAB DOOR HINGE - " HEX JAM NUT - " X " BUTTON HEAD BOLT - X " PHILLIPS HEAD SCREW 0 - NYLOCK NUT HINGE ASSEMBLY WELDED TO DOOR, BOLTS TO THE CAB
DASH PANEL CONTROLS & COMPONENTS PAGE 0 E-BRAKE BUZZER AND FLASHER RELAY ATTACHED TO DASH PANEL HARNESS UNDER DASH A/C RELAYS MOUNT TO SIDE OF CAB 0 COMPUTER IS YEAR SPECIFIC, SITS IN HOUSING CHANNEL ON SIDE OF CAB PART QTY. B00-00 NBO MCU COMPUTER B00-0 LIGHT SWITCH B00-0A LIGHT SWITCH COVER B00-0 HORN SWITCH B00-0A HORN SWITCH COVER B00-0 BIN FULL LIGHT B00-0 TUBE FUSE - AMP B00-0A AMP TUBE FUSE HOLDER B00-0 0 AMP CIRCUIT BREAKER 0 B00-0 0 AMP CIRCUIT BREAKER B00-0 0 AMP CIRCUIT BREAKER B00- ELECTRONIC FLASHER RELAY* B00-0 COMPUTER LCD DISPLAY SCREEN B0-00 PASS. SIDE DASH PANEL ASSEMBLY PART QTY. AC00-00 FAN SWITCH AC00-00 AIR VENT AC00-00 THERMOSTAT SWITCH ECR-00 A/C RELAY* ECG-00 FUEL LEVEL GAUGE 0 ECM-00 E-BRAKE BUZZER* ECS-00 IGNITION SWITCH - CUP HOLDER
OLD STYLE DASH PANEL CONTROLS & COMPONENTS PAGE 0 PART B00-0 LIGHT SWITCH B00-0A LIGHT SWITCH COVER B00-0 HORN SWITCH B00-0A HORN SWITCH COVER B00-0 BIN FULL LIGHT B00-0 0 AMP CIRCUIT BREAKER B00-0 0 AMP CIRCUIT BREAKER B00-0 0 AMP CIRCUIT BREAKER B0-00Y OLD STYLE A/C VENT PANEL 0 ECG-00 FUEL LEVEL GAUGE ECG-00 WATER TEMPERATURE GAUGE ECG-00 OIL TEMPERATURE GAUGE ECG-00 OIL PRESSURE GAUGE ECG-00 HOUR GAUGE ECG-00 VOLT GAUGE ECS-00 IGNITION SWITCH ECS-00 BLACK BUTTON SWITCH QTY.
STEERING COLUMN ASSEMBLY PAGE LINE REPRESENTS DASH PANEL RIGHT TURN SUPPLY LEFT TURN SUPPLY RETURN TO VALVE PRESSURE FROM BRAKES PART QTY. B0-00 STEERING WHEEL B0-00 STEERING COLUMN B0-00 TURN SIGNAL INDICATOR B0-00 STEERING COLUMN SPACER B0-00 STEERING ORBITAL - O-RING TO JIC ELL (0-) - " X " HEX BOLT - " LOCK WASHER
HYDRAULIC CONTROL LEVERS & CABLES PAGE LEVER MOUNTS AND CABLE BULKHEAD WELDED IN PLACE IN CAB FRONT OF BANKOUT 0 HOIST HITCH GATE AUGER PART B0-00 CONTROL LEVER SHAFT B0-00 BRASS LEVER BUSHING* B0-00 CONTROL LEVER KNOB B0-00 HITCH LEVER ASSEMBLY B0-00 GATE LEVER ASSEMBLY B0-00 HOIST LEVER ASSEMBLY B0-00 AUGER LEVER ASSEMBLY MC-0 " MORSE CABLE** - LEVER SIDE CABLE END - " X " CLEVIS 0 - VALVE SIDE CABLE END - " X " CLEVIS QTY *BUSHINGS INCLUDED WITH ALL CONTROL LEVERS ( PER LEVER) **ALL LEVERS USE SAME CABLE
OLD STYLE BRAKE CONFIGURATION PAGE 0 BRAKE PIVOT TUBE ASSEMBLY IS WELDED IN PLACE ON CAB RESERVOIR MOUNTED TO INSIDE AIR BOX ON REAR OF CAB - PRE-0 RESERVOIR MOUNTED FROM WELDED FITTING ON SIDE OF CAB PART QTY. B0-00 BRAKE SWITCH MOUNT B0-00 BRAKE PIVOT TUBE ASSEMBLY B0-0 BRAKE PIVOT TUBE BUSHING B0-00 BRAKE PEDAL ASSEMBLY B0-0 BRAKE PEDAL PAD B0-00 BRAKE ARM ASSEMBLY ECS-00 BRAKE LIGHT SWITCH B0-00 BRAKE ROD B0-00 UHMW BRAKE ROD MOUNT 0 B0-0 BRAKE MASTER CYLINDER B0-0 BRAKE BOOSTER B0-0 BRAKE BOOSTER BOOT - B0-00 COMPLETE BRAKE FLUID RESERVOIR B0-0 BRAKE FLUID RESERVOIR B0-0 BRAKE FLUID RESERVOIR CAP B0-0 BRAKE FLUID RESERVOIR INSERT B0-0 MASTER CYLINDER TO FRAME LINE B0-0 RESERVOIR TO MASTER BRAKE HOSE SC-0 /" SET COLLAR - O-RING TO JIC 0 ELL (0-0-) 0 - PIPE TO JIC 0 ELL (0--) - PIPE TO PIPE 0 ELL (0-) 0 0 BOOSTER MOUNTS TO REAR CAB MOUNT
NEW STYLE BRAKE CONFIGURATION PAGE MOUNTS TO PS CAB PANEL 0 0 MOUNTS TO PS CAB PANEL PART B0-000A BRAKE LIGHT SWITCH MOUNT B0-0A BRAKE ROD B0-00A BRAKE SHAFT B0-00A BRAKE PEDAL ASSEMBLY B0-0 BRAKE PEDAL PAD B0-0 MASTER CYLINDER B0-0 BRAKE BOOSTER B0-0 BRAKE BOOSTER BOOT BR-FL QTY. " FLANGE BEARING (STANDARD) 0 BR-FLA " FLANGE BEARING (TURNER) ECS-00 BRAKE LIGHT SWITCH - - - - - - - - 0 - - - - - " X " CLEVIS ASSEMBLY " UNF JAM NUT " X " HEX BOLT " LOCK WASHER " X " HEX BOLT " X HEX BOLT " FLAT WASHER " LOCK WASHER " HEX NUT " X " HEX BOLT " FLAT WASHER " LOCK WASHER " HEX NUT
AIR CONDITIONING CONFIGURATIONS BY YEAR PAGE 0-CURRENT AIR CONDITIONING PRE-0 AIR CONDITIONING 0-0 AIR CONDITIONING PART CATALOG PAGE B0-000Y DAYTON CHARGE BLOWER ASSEMBLY (PRE-0) B0-00 IN CAB RECIRCULATION FILTER (0-CURRENT) AF0-000 DONALDSON A/C FILTER ASSEMBLY (PRE-0) AF0-000 SYKLONE A/C FILTER ASSEMBLY AC0-00 SPAL CHARGE BLOWER (0-CURRENT) AC0-000 EVAPORATOR ASSEMBLY (PRE-0) AC-00 EVAPORATOR (0) *NOT SHOWN
0-CURRENT AIR CONDITIONING UNIT PAGE 0 0 PART B0-00A AC UNIT HOUSING B0-00A FILTER HOUSING B0-00A AC UNIT FRONT COVER B0-00 IN CAB RECIRCULATION FILTER B0-0A FRONT COVER END CAP B0-0 QTY. " HOSE SPACER B0-0 FRONT COVER SEAL B0-0 FRONT COVER TRIM AC0-00 SPAL CHARGE BLOWER 0 AC0-0 EVAPORATOR FRONT COVER AC-00 EVAPORATOR CORE AC-00 EXPANSION VALVE B0-00 - - - - - - 0 - - - " E-BRAKE SPACER " X " CARRAIGE BOLT " LOCK WASHER " HEX NUT " X " ALLEN BOLT " LOCK WASHER " HEX NUT " X " HEX BOLT " LOCK WASHER " HEX NUT - - X " SCREW - LOCK WASHER - - HEX NUT B0-000A A/C UNIT ASSEMBLY
0-CURRENT CONTROL PANEL ASSEMBLY PAGE 0 PART QTY. B0-00A CONTROL PANEL B0-00A CONTROL PANEL COVER B0-00 FWD-REV SHIFTER ASSEMBLY B0-0 SHIFTER MICRO-SWITCH B0-00 HI-LOW SHIFTER ASSEMBLY ECM-00 VOLT POWER OUTLET - " GROMMET - " SPEED NUT - " X " HEX BOLT 0 - " FLAT WASHER - " LOCK WASHER
00-0 CONTROL INLET ASSEMBLY PAGE 0 PART B0-00X FORMED CONTROLS INLET B0-00X CONTROL TUNNEL ACCESS PANEL B0-00 FWD-REV SHIFTER ASSEMBLY B0-0 JOYSTICK MICRO-SWITCH B0-00 HI-LOW SHIFTER ASSEMBLY AC00-00 THERMOSTAT SWITCH AC00-00 THERMOSTAT SWITCH KNOB AC00-00 A/C FAN SWITCH AC00-00 A/C FAN SWITCH KNOB 0 AC00-00 A/C SWITCH COVER QTY. AC00-00 AIR VENT - " X " HEX BOLT - " LOCK WASHER - " FLAT WASHER - " SPEED NUT
0-0 CAB AIR FILTER ASSEMBLY PAGE 0 PART QTY. B0-0 A/C LID LATCH B0-00X A/C BOX COVER ASSEMBLY B0-0X TOP COVER B0-0X A/C DUCT BOX AF0-000 SYKLONE AIR FILTER ASSEMBLY AF0-00 A/C FILTER CAP (SYKLONE FEFF00) AF0-00 RAIN CAP AF0-00 SEAL GROMMET AF0-00 BLOWER MOTOR (R0) 0 - " GROMMET - NYLOCK - " X " HEX BOLT - " FLAT WASHER - " LOCK WASHER - " HEX NUT - " X " CARRIAGE BOLT
PRE-0 EVAPORATOR ASSEMBLY PAGE 0 RETURN SUPPLY *NOTE: ALL MODELS MAY HAVE SINGLE SPEED (TWO WIRE) MOTORS, OR THREE SPEED (FOUR WIRE) MOTORS. PART QTY. AC0-000 COMPLETE EVAPORATOR ASSEMBLY AC0-00 EXPANSION VALVE AC0-0 TOP EVAPORATOR HOUSIING AC0-0 BOTTOM EVAPORATOR HOUSING AC0-0 HOUSING FACE PLATE AC0-0 EVAPORATOR MOTOR* AC0-0 SQUIRREL CAGE FAN AC0-0 RETAINER CLIP - X " PHILLIPS HEAD SCREW 0 0 - " X " COUNTER SUNK PHILLIPS
PRE-0 CAB AIR FILTER ASSEMBLY PAGE 0 PART 0 B0-0 A/C LID LATCH B0-0Y AIR BOX COVER PANEL B0-00Y UPPER BLOWER MANIFOLD B0-00Y LOWER MANIFOLD BASE PLATE B0-00Y AIR RECIRCULATION HOSE B0-00Y FILTER ELL HOSE AF00-00 PLASTIC A/C PRE-CLEANER AF0-00 P0 FILTER ELEMENT AF0-00 INSIDE FILTER CAP 0 AF0-00 DONALDSON FILTER HOUSING CAP AF0-00 DONALDSON HOUSING CLAMP AF0-00 DONALDSON FILTER MOUNTING STRAP AF0-000 DONALDSON A/C FILTER ASSEMBLY AF0-00 PRE-CLEANER REDUCER AC0-00 DAYTON CHARGE BLOWER AC0-000 EVAPORATOR ASSEMBLY QTY. - " HOSE CLAMP - in HOSE CLAMP - " LOCK WASHER 0 - " HEX NUT - " X " HEX BOLT - " X " HEX BOLT 0
BIN ASSEMBLY BREAKDOWN PAGE PART QTY. CATALOG PAGE B00-0 BIN FRONT RUBBER SEAL - B0-000 FRONT GATE ASSEMBLY 0 B-000 REAR AIR SCREENS B-000 AUGER ASSEMBLIES B-000 BIN EXTENSION ASSEMBLY B0-000 ENGINE AIR INTAKE SNORKLE TUBE ASSEMBLY ECS-00 BIN FULL SWITCH - HYDTR-00 GATE HYDRAULIC CYLINDER -
FRONT GATE ASSEMBLY PAGE 0 0 PART B00-0 BIN FRONT RUBBER SEAL B0-00 GATE HINGE ROD B0-00 GATE LINKAGE BAR B0-00 TOP GATE TUBE ASSEMBLY B0-00 TOP GATE ASSEMBLY B0-00 BOTTOM GATE ASSEMBLY B0-0 CONTROL VALVE TO GATE BUTT HOSE B0-0 CONTROL VALVE TO GATE ROD HOSE HYDTR-00 GATE CYLINDER QTY. 0 - PIPE TO JIC 0 ELL (0--) - " X " HEX BOLT - " FLAT WASHER 0 - " LOCK WASHER - " NYLOCK NUT - " X " HEX BOLT - " X " COTTER PIN
ENGINE AIR INTAKE SNORKLE TUBE ASSEMBLY PAGE 0 UPPER CLAMP MOUNTS TO AUGER MOUNT LOWER CLAMP MOUNTS TO BIN PANEL 0 SECTION VIEW OF SNORKLE LOOKING FROM CENTER OF BIN 0 PART QTY. B0-000 COMPLETE ENGINE AIR SNORKLE ASSEMBLY B0-00 INTAKE SNORKLE CUP SEAL B0-00 LOWER MOUNT TAB B0-00 SNORKLE TUBE ASSEMBLY B0-00 UPPER CLAMP ASSEMBLY AF00-00 STAINLESS STEEL ENGINE PRE-CLEANER - " PIPE CLAMP - " HOSE CLAMP - " X " HEX BOLT 0 - " FLAT WASHER 0 - " LOCK WASHER - " HEX NUT 0 - " X " CARRIAGE BOLT - " X " HEX BOLT
AUGER ASSEMBLIES PAGE 0 AUGER ROTATION 0 PART B-000 RIGHT-HAND AUGER (PASSENGER SIDE) QTY. B-0 AUGER IDLER SPUD PER B-0 AUGER DRIVE BUSHING PER B-0 RIGHT-HAND AUGER MOTOR MOUNT B-000 LEFT-HAND AUGER (DRIVER SIDE) B-0 LEFT-HAND AUGER MOTOR MOUNT HYDM-TFO0 AUGER MOTOR (TFO 0) - HYDM-PSK AUGER MOTOR SEAL REBUILD KIT (PARKER SK0000) - BR-PB " PILLOW BLOCK BEARING - " X " HEX BOLT 0 - " SAE FLAT WASHER 0 - " NYLOCK HEX NUT - " LOCK WASHER - " X " HEX BOLT
AUGER MOTOR ASSEMBLY HOSES AND FITTINGS PAGE 0 PART HYDM-TFO0 AUGER MOTOR B0-00 AUGER SUPPLY PIPE ASSEMBLY B0-00 AUGER RETURN PIPE ASSEMBLY B0-00 AUGER PIPE TO FLOW DIVIDER HOSE B0-0 FLOW DIVIDER TO AUGER HOSE B0-0 DS AUGER TO RETURN PIPE HOSE B0-0 PS AUGER TO RETURN PIPE HOSE HYD-FD0 " FLOW DIVIDER - PIPE TO JIC 0 ELL (0-) 0 - PIPE TO JIC ADAPTER (0--) - JIC TO JIC ELL (00-) - O-RING TO JIC ADAPTER (00-0-) QTY. - PIPE TO JIC RUN TEE (0-) - " X " HEX BOLT - " FLAT WASHER - " NYLOCK NUT
BIN EXTENSION ASSEMBLY PAGE EXTENSION MOUNTING HARDWARE 0 0 0 BIN SIDE PANEL EXTENSION CROSS TUBE FRONT PANELS OVERLAP REAR PANELS *NOTE: BIN EXTENSION COVER ASSEMBLY IS AN OPTIONAL FEATURE, NOT INCLUDED IN **NOTE: BOLT PLATES ONLY USED WITH COVER ASSEMBLY PART QTY. B-00 BIN EXTENSION REAR PANEL B-00 BIN EXTENSION FRONT DS PANEL B-00 BIN EXTENSION FRONT PS PANEL B-00 CROSS TUBE SUPPORT ASSEMBLY B-00 EXTENSION COVER ASSEMBLY * B-0 EXTENSION COVER BOLT PLATES** B-000 COMPLETE BIN EXTENSION - " X " HEX BOLT - " SAE FLAT WASHER 0 - " NYLOCK NUT - " X " HEX BOLT COMPLETE BIN ASSEMBLY COVER SUPPORT MOUNTING HARDWARE 0
BIN UNDER-CARRIAGE COMPONENTS & REAR AIR SCREENS PAGE PART QTY. B0-00 BIN LIMIT STOP CABLE B-000 BIN REAR AIR SCREEN B-00 HINGE PIN B-00 BIN HINGE PIN COLLAR B-000 BIN SAFETY PROP B-000 UPPER HOIST PIN B0-00 ENGINE COMPARTMENT SEAL - " X " CARRIAGE BOLT - " FLAT WASHER 0 - " LOCK WASHER - " HEX NUT - " X " HEX BOLT - " FLAT WASHER - " NYLOCK HEX NUT 0
CUMMINS ENGINE, PUMP, & DRIVE COMPONENTS PAGE PART QTY. CATALOG PAGE B00-000 COMPLETE ENGINE ASSEMBLY -0 B0-000 DRIVELINE ASSEMBLY B-000 COAST VALVE ASSEMBLY HYDSTP-SD000 HYDROSTAT PUMP ASSEMBLY HYDP-MASPL HYDRAULIC PUMP HYDBC-CDM PRIORITY BLOCK HYDSTM-SD000 HYDROSTAT MOTOR ASSEMBLY C-0-0 FUEL WATER SEPARATOR -
CUMMINS ENGINE ASSEMBLY BOLT-ON COMPONENTS PAGE 0 CUMMINS COMPRESSOR UPDATE: FOR REPLACING CUMMINS COMPRESSORS WITH AN OPEN FACE CLUTCH TO NEW SEALED CLUTCH, INCLUDES S -0 & - 0 0
PART QTY. C-0-000 REAR ENGINE MOUNT (SIDE SPECIFIC) C-0-000 FRONT ENGINE MOUNT (SIDE SPECIFIC) ENG-C00 ENGINE ISOLATOR C-00-00 CUMMINS. STARTER C-00-00 STARTER SOLENOID C-00-00A STARTER SOLENOID MOUNT C-00-00 ALTERNATOR C-0-00 WATER PUMP - C-0-00 THERMOSTAT - C-0-00 WATER TEMPERATURE SENDING UNIT - C-0-00 LOW COOLANT SENSOR - C-0-00 FUEL RAIL PRESSURE SENSOR - C-0-00 OIL PRESSURE SENDING UNIT C-0-00 FUEL FILTER 0 C-0-00 OIL FILTER - C-0-0 FUEL-WATER SEPARATOR FILTER C-0-00 CUMMINS. FAN C-0-00 FAN SPACER C-0-00 CUMMINS. PUMP MOUNT PLATE C-0-00 CUMMINS. FLEX PLATE C-0-00 SERPENTINE BELT C-0-00 BELT TENSIONER C-0-00 UPPER IDLER PULLEY C-0-000 AC COMPRESSOR UPDATE KIT AC-000 A/C COMPRESSOR (INCLUDES 0) 0 AC-00 A/C COMPRESSOR CLUTCH C-0-00 A/C COMPRESSOR TOP MOUNT C-0-00 A/C COMPRESSOR BOTTOM MOUNT - C-00-0 CUMMINS ENGINE WIRE HARNESS - C-0-00 BAROMETRIC PRESSURE SENSOR - C-0-00 ENGINE SPEED SENSOR - C-0-00 ENGINE POSITION SENSOR - " HEX NUT - " LOCK WASHER - " X " GR. HEX BOLT - " SAE HEAVY FLAT WASHER - M X 0 FLATHEAD ALLEN BOLT - " X " PT BOLT - " X " HEX BOLT 0 - " FLAT WASHER - " LOCK WASHER - " SAE FLAT WASHER - " NYLOCK NUT - M0 X 0 HEX BOLT - M0 X 0 HEX BOLT - M0 LOCK WASHER - M X 0 HEX BOLT - M LOCK WASHER CUMMINS ENGINE ASSEMBLY BOLT-ON COMPONENTS CONT. PAGE
CUMMINS ENGINE ASSEMBLY PIPING & HOSES PAGE 0 0 FROM INTERCOOLER TO INTERCOOLER 0 FROM AIR FILTER PART DECRIPTION QTY. C-0-00 TURBO INTAKE PIPE C-0-00 INTAKE COUPLER - C-0-00 BOOST PRESSURE SENSOR (NOT SHOWN) C-0-00 " V-CLAMP C-0-0A EXHAUST DOWN PIPE C-0-0 " SUCTION PIPE C-0-0 " EXHAUST TAIL PIPE C-0-00 UPPER RADIATOR HOSE C-0-00 LOWER RADIATOR HOSE C-0-00 " OVERFLOW HOSE 0 C-0-00 " OVERFLOW HOSE C-0-00 SHORT INTERCOOLER PIPE C-0-00 LONG INTERCOOLER PIPE C-0-00 " RUBBER TUBE COUPLER (FULL) C-0-00 " RUBBER TUBE COUPLER (HALF) C-0-00 " T-CLAMP - " HOSE CLAMP - " PIPE CLAMP - " HOSE CLAMP - " HOSE CLAMP 0 - " HOSE CLAMP
RADIATOR PACKAGE BREAKDOWN PAGE PART QTY. CATALOG PAGE C-00-000 RADIATOR & INTERCOOLER ASSEMBLY - C-00-0 RADIATOR FAN GUARD - C-0-00 RADIATOR - C-0-00 RADIATOR CAP - C-0-00 INTERCOOLER UNIT - C-00-00 RADIATOR HOUSING ASSEMBLY - B0-00 AIR DEFLECTOR PAN - B0-00 UPPER RADIATOR TRIMLOCK - HYDOC-00 OIL COOLER ASSEMBLY 0 AC0-00 A/C CONDENSER ASSEMBLY B0-00 AIR FILTER VACUUM KIT 0
OIL COOLER ASSEMBLY PAGE UPPER MOUNT DETAIL PART QTY. HYDOC-00 OIL COOLER HYDOC-0 OIL COOLER MOUNT BUSHING B0-00 RADIATOR BIN SEAL MOUNT B0-00 UPPER RADIATOR TRIMLOCK SEAL B0-00 LOWER RADIATOR TRIMLOCK SEAL B0-00 LOWER OIL COOLER MOUNT TRIM B0-0 UPPER OIL COOLER MOUNT B0-0 LOWER OIL COOLER MOUNT B0-0 TUBE TO COOLER HOSE 0 B0-0 COOLER TO TUBE HOSE - O-RING TO JIC 0 ELL (0--) - " X " HEX BOLT - " LOCK WASHER - " HEX NUT - " FLAT WASHER - " X " HEX BOLT - " NYLOCK NUT 0
CONDENSER MOUNTING PAGE 0 PART AC0-00 A/C CONDENSER B0-0 DS VERTICAL CONDENSER MOUNT PLATE B0-0 PS HORIZONTAL CONDENSER MOUNT PLATE B0-0 CUMMINS STYLE CONDENSER MOUNT HAT - " X " THUMB SCREW - " HEX NUT - " ACORN NUT - " FLAT WASHER - " X " HEX BOLT 0 - " FLAT WASHER - " LOCK WASHER - " HEX NUT - X " PAN HEAD SCREW - NYLOCK NUT - B0-00A CUMMINS CONDENSER MOUNT KIT* - - B0-00B JOHN DEERE UPDATE MOUNT KIT* - QTY. *NOTE: TO REPLACE CONDENSER ON EARLY MODEL MACHINES WITH JOHN DEERE ENGINE YOU MUST USE THE UPDATED MOUNT KIT -MOUNT KITS INCLUDE ALL BRACKETS AND HARDWARE FOR MOUNTING ONE CONDENSER.
DONALDSON ENGINE AIR FILTER PAGE TO TURBO INLET PIPE 0 PART 0 AF0-00 INTERNAL MAIN FILTER (P0) AF0-00 PRE-FILTER (P00) AF0-00 AIR FILTER LID AF0-00 LID CLIP AF0-00 AIR FILTER DRAIN CONE AF0-00 DONALDSON AIR RESTRICTION INDICATOR B0-00 AIR FILTER MOUNT B0-00A AIR FILTER PER-CLEANER MANIFOLD C-0-00 MASS AIR FLOW TUBE 0 - " T-CLAMP - " T-CLAMP - " X " HEX BOLT - " LOCK WASHER - " SPEED NUT - " X " HEX BOLT - " HEX NUT - " LOCK WASHER - " FLAT WASHER - " X " HEX BOLT 0 AF0-000 COMPLETE DONALDSON AIR FILTER* QTY. *DOES NOT INCLUDE MOUNT, SNORKLE MANIFOLD, BOOT, OR INDICATOR
AIR FILTER VACUUM KIT PAGE FROM AIR FILTER DRAIN CONE TO FAN SHROUD NOTE: INDIVIDUAL PIECES NOT AVAILABLE FOR RESALE PART QTY. B0-00 COMPLETE AIR FILTER VACUUM KIT B0-0 LONG VACUUM PIPE B0-0 SHORT VACUUM PIPE B0-0 " 0 PVC COUPLER B0-0 AIR FILTER VACUUM HOSE - " GROMMET
DRIVELINE ASSEMBLY PAGE " B0-000X DRIVELINE ASSEMBLY JOHN DEERE MOUNTS TO COMPANION FLANGE ON HYDROSTAT DRIVE MOTOR " B0-000 DRIVELINE ASSEMBLY CUMMINS BOLTS TO REO AXLE DRIVE YOKE PART QTY. B0-000 CUMMINS DRIVELINE B0-000X JOHN DEERE DRIVELINE B0-00 DRIVELINE U-JOINT - " X " UNF HEX BOLT - " LOCK WASHER - " X " HEX BOLT - " HEX NUT
HYDROSTAT PUMP & MOTOR ASSEMBLY PAGE PART NOTE: HYDROSTAT MOTORS ARE AVAILABLE IN HIGH TORQUE AND LOW TORQUE MODELS. -COMPANION FLANGE VARIES WITH SIZE OF MOTOR RESPECTIVELY. QTY. HYDSTP-SD000 SAUER DANFOSS HYDROSTAT PUMP HYDSTP-SD00 HYDROSTAT PUMP FILTER HYDSTP-SD00 HYDROSTAT PUMP FWD-REV SOLENOID HYDSTP-SD00 HYDROSTAT PUMP CANISTER SEAL KIT HYDSTM-SD000 SAUER DANFOSS HYDROSTAT MOTOR (SEE NOTE) HYDSTM-SD00 HYDROSTAT MOTOR SHIFT SOLENDOID B0-00 COMPANION FLANGE (SEE NOTE) B-000 BUMP / COAST VALVE ASSEMBLY (SEE PAGE ) B0-00 TANK TO HYDROSTAT PUMP 0 B0-00 HYDROSTAT PUMP TO TANK B0-00 HYDROSTAT MOTOR TO TANK B0-00 HYDROSTAT PUMP TO MOTOR B0-0 BUMP CIRCUIT TO HYDROSTAT PUMP B0-0 HYDROSTAT PUMP TO BUMP CIRCUIT B0-0 COAST CIRCUIT TO HYDROSTAT PUMP B0-0 HYDROSTAT PUMP TO COAST CIRCUIT - O-RING TO JIC 0 ELL (0-) - O-RING TO JIC ADAPTER (00-) - SPLIT FLANGE TO JIC 0 ELL (FF0--S) 0 - O-RING TO JIC 0 ELL (0-0) - O-RING TO JIC 0 ELL (0-) - HYDROSTAT SPLIT FLANGE KIT (FC--) - O-RING TO JIC 0 ELL (0--) - " FLAT WASHER - " LOCK WASHER - " X " HEX BOLT - " - UNF HEX NUT GRADE - " LOCK WASHER - " X " UNF HEX BOLT GRADE 0 - " LOCK WASHER 0 - " X " HEX BOLT - " X " HEX BOLT GRADE - " FLAT WASHER 0 0 0 0
HYDRAULIC PUMP & PRIORITY BLOCK ASSEMBLY PAGE 0 PART HYDSTP-SD000 SAUER DANFOSS HYDROSTAT PUMP HYDP-MASPL METARIS RH HYDRAULIC PUMP HYDP-GSK0 HYDRAULIC PUMP GASKET HYDBC-CDM SYSTEM PRIORITY BLOCK B0-00 TANK TO METARIS HYDRAULIC PUMP B0-00 PRIORITY TO " VALVE PRESSURE TUBE B0-00 PRIORITY TO " BRAKE PRESSURE TUBE B0-0 PRIORITY TO HOIST PUMP RETURN - O-RING TO O-RING ADAPTER (00-) 0 - O-RING TO JIC ADAPTER (00-) - O-RING TO JIC 0 ELL (0-) O-RING TO JIC 0 ELL (0-0-) - O-RING TO JIC ADAPTER (00-0-) - - QTY. " X " HEX BOLT " LOCK WASHER
BUMP COAST VALVE ASSEMBLY PAGE 0 0 ALL O-RINGS NOT NOTED ARE INCLUDED WITH FITTINGS AND COMPONENTS COAST CIRCUT (SHORT RELIEF VALVE) PART QTY. B-00 BUMP/COAST VALVE MOUNTING BRACKET HYDBC-B00 BUMP/COAST VALVE BLOCK HYDBC-S0 BUMP/COAST SOLENOID CARTRIDGE HYDBC-S0 BUMP/COAST SOLENOID COIL HYDBC-PR00L BUMP/COAST RELIEF - LONG HYDBC-PR00S BUMP/COAST RELIEF - SHORT - COUPLER FITTING (00-) - O-RING TO JIC 0 ELL (0-) - " X " HEX BOLT 0 - " SAE FLAT WASHER - " NYLOCK NUT - M0,.cm X.cm FLANGE HEX BOLT B-000 COMPLETE BUMP/COAST VALVE ASSEMBLY BUMP CIRCUIT (LONG RELIEF VALVE)
HYDRAULIC CONTROL VALVE ASSEMBLY PAGE 0 SYSTEM SUPPLY OIL COOLER HOST CYLINDER SUPPLY 0 PART B-0 " TUBE - SYSTEM SUPPLY PRESSURE B-0 " TUBE - VALVE TO COOLER B-0 /" TUBE - HOIST CYLINDER SUPPLY HYDV-PDVA0 VALVE PRESSURE RELIEF B0-0 VALVE TO AUGER SUPPLY B0-0 AUGER RETURN PIPE TO VALVE B0-0 VALVE TO GATE CYLINDER BUTT END B0-0 VALVE TO GATE CYLINDER ROD END B0-0 VALVE TO HITCH CYLINDER BUTT END 0 B0-00 VALVE TO HITCH CYLINDER ROD END B0-0 ORBITROL RETURN TO VALVE B0-00 BIN LIMIT ARM B0-00 BIN LIMIT CABLE - O-RING TO JIC 0 ELL (0-) - O-RING TO JIC 0 ELL (0--) - O-RING TO JIC 0 ELL (0--) - O-RING TO O-RING ADAPTER (FF00--) - O-RING TO JIC 0 ELL (0-) - O-RING TO O-RING ADAPTER (FF00-0-) 0 - O-RING TO JIC 0 ELL (0-) - " X " HEX BOLT - " FLAT WASHER - " LOCK WASHER - " HEX NUT - HYDV-PSK00 PARKER VALVE SECTION SEAL KIT - HYDV-PSK00 PARKER VALVE SPOOL SEAL KIT QTY. 0 CABLE CONNECTS TO BIN TO PREVENT OVER EXTENSION OF HOIST CYLINDERS
EXTENSION HITCH PAGE 0 PART B0-000 EXTENSION HITCH TUBE ASSEMBLY B0-00 EXTENSION HITCH ASSEMBLY B0-0 UHMW WEAR PAD B0-00 EXTENSION HITCH TRANSPORT PIN B0-0 VALVE TO HITCH CYLINDER BUTT END B0-00 VALVE TO HITCH CYLINDER ROD END HYDTR-0 EXTENSION HITCH HYDRAULIC CYLINDER - PIPE TO JIC 0 ELL (0--) - " X " FLAT HEAD ALAN 0 - " NYLOCK NUT - " X " HEX BOLT - " NYLOCK NUT - " LOCK WASHER QTY.
AUXILIARY HOIST PUMP & CYLINDER ASSEMBLY PAGE 0 0 0 PART QTY. HYDAP-MI000 COMPLETE HOIST PUMP ASSEMBLY HYDAP-MI00 HOIST PUMP ELECTRIC SOLENOID HYDBC-S0 HOIST PUMP SOLENOID CARTRIDGE HYDBC-S0 HOIST PUMP SOLENOID COIL HYDBC-B00 SOLENOID VALVE BLOCK (00) HYDHC-00-000 COMPLETE HOIST CYLINDER B00-00 LOWER HOIST CYLINDER SHAFT B00-00 HOIST CYLINDER SPACER PIPE B-0 " TUBE - VALVE TO HOIST CYLINDERS 0 B0-00 HOIST PUMP RETURN TO TANK B0-0 PRIORITY TO HOIST PUMP RETURN B0-0 HOIST PUMP TO TUBE B0-0 HOIST PUMP RETURN B0-0 HOIST CYLINDER HOSE PART QTY. B0-0 TUBE TO HOIST CYLINDERS - PIPE TO JIC 0 ELL (0--) - O-RING TO JIC ADAPTER (00--) - O-RING TO O-RING COUPLER (00-) - O-RING TO JIC ADAPTER (00--) 0 - JIC SWIVEL RUN TEE (00-) - O-RING TO JIC BRANCH TEE (000-) - JIC BRANCH TEE (0-) - " FLAT WASHER - " LOCK WASHER - " X " HEX BOLT - " X " HEX BOLT - " LOCK WASHER - " HEX NUT
HOIST CYLINDER ASSEMBLY PAGE 0 PART QTY HYDHC-00-000 BANKOUT HOIST CYLINDER ASSEMBLY HYDHC-0-000 HOIST CYLINDER BODY HYDHC-0-000 HOIST CYLINDER HEAD NUT - HEAD NUT SET SCREW HYDHC-0-0 HEAD NUT O-RING HYDHC-0-0 " HEAD NUT SEAL GASKET HYDHC-0-0 " HEAD NUT WIPER GASKET HYDHC-0-00 CYLINDER TUBE - STAGE HYDHC-0-00 STAGE SPIRAL LOCK RING 0 HYDHC-0-0 " STAGE SEAL GASKET HYDHC-0-0 " STAGE WIPER GASKET HYDHC-0-0 STAGE GUIDE CLIP HYDHC-0-00 CYLINDER TUBE - STAGE HYDHC-0-00 STAGE SPIRAL LOCK RING HYDHC-0-0 " STAGE SEAL GASKET HYDHC-0-0 " STAGE WIPER GASKET HYDHC-0-0 STAGE GUIDE CLIP HYDHC-0-00 CYLINDER TUBE - STAGE HYDHC-0-0 STAGE GUIDE CLIP 0 HYDHC-0-000 UPPER HOIST CYLINDER BUSHING ASSEMBLY - " X " HEX BOLT - " HEX NUT HYDHC-00-00 COMPLETE HOIST CYLINDER SEAL KIT 0 HOIST CYLINDER SEAL REBUILD KIT INCLUDES ALL WIPER GASKETS, SEAL GASKETS & O-RING
DIESEL FUEL TANK PAGE 0 PART B0-000 DIESEL FUEL TANK B0-00 FUEL SENDING UNIT B0-0 " FUEL LINE - TANK TO FILTER B0-0 " FUEL LINE - FILTER TO ENGINE B0-0 " FUEL LINE - FUEL INJECTOR RETURN FTC-00 DIESEL FUEL TANK CAP FF-0 INLINE FUEL FILTER (NAPA GOLD 0) - 0 X " PANHEAD SCREW - " X " HEX BOLT 0 - " LOCK WASHER - " HEX NUT QTY.
HYDRAULIC FLUID TANK PAGE 0 PART B-000 HYDRAULIC TANK ASSEMBLY HTC-00 HYDRAULIC TANK CAP HYDF-SE0 HYDRAULIC RETURN FILTER (w/ O-RING) HYDF-SE0A HYDRAULIC RETURN FILTER BODY HSS-0 " HYDRAULIC SUCTION FILTER HSS-00 " HYDRAULIC SUCTION FILTER B0-00 TANK TO MAIN HYDRAULIC PUMP B0-00 TANK TO HYDROSTAT PUMP B0-00 COOLER RETURN TO TANK 0 B0-00 HYDROSTAT PUMP TO TANK B0-00 HYDROSTAT MOTOR TO TANK B0-00 HOIST PUMP RETURN TO TANK - PIPE TO PIPE ADAPTER (0-0) - PIPE TO JIC ADAPTER (0-0-) - PIPE TO JIC 0 ELL (0-) QTY. - " X " NPT PIPE BUSHING - " X " HEX BOLT - " LOCK WASHER - " HEX NUT
PART ECL-00R ECL-00A ECL-00A AF0-00 ECM-00 ECM-00 ECS-00 ECB-00 B00-0 - - - - - - - - - 0 " X " ELEVATOR " FLAT WASHER " HEX NUT " LOCK WASHER " X " HEX BOLT " X " HEX BOLT " FLAT WASHER " LOCK WASHER " HEX NUT BOLT BIN RUBBER SUPPORT PAD BACK-UP CAMERA BLACK BUTTON SWITCH (BIN LIFT) BACK-UP ALARM HORN (INCLUDES MOUNTING BRACKET) LIGHT GROMMET HEADLIGHT AMBER TURN SIGNAL RED TAIL LIGHT QTY. FRONT & REAR BUMPER COMPONENTS PAGE
FRONT AXLE BREAKDOWN PAGE 0 PART QTY. PAGE B00-00 FRONT SPRING MOUNT PLATES - B00-00 OVERLOAD SPRING MOUNT PLATE - - B00-00F FRONT TIRE & WHEEL MOUNTED - B00-0F FRONT WHEEL - B00-0 TITAN TIRE - B0-00 FRONT AXLE HOUSING - B0-00 E-BRAKE ROTOR B0-0 SEAL RETAINER B0-0 AXLE SHAFT SEAL B0-000 THIRD MEMBER ASSEMBLY 0 - HUB COMPONENTS 0 B0-000 FRONT BRAKE ASSEMBLY B0-00 COMPLETE BOOT SEAL WITH CLAMPS B0-000 DRIVER SIDE KNUCKLE ASSEMBLY - B0-000 PASSENGER SIDE KNUCKLE ASSEMBLY B0-000L DRIVER SIDE AXLE SHAFT ASSEMBLY PART 0 QTY. PAGE - B0-000S PASSENGER SIDE AXLE SHAFT B0-000 FRONT TIE ROD ASSEMBLY B0-000 E-BRAKE CALIPER LS0-00F FRONT 0 PACK LEAF SPRING - LS0-0 LEAF SPRING BUSHING - LS0-0 " CENTER BOLT - 0 LS-00 OVERLOAD SPRING - LS-00 FRONT PACK LEAF SPRING - HYDSC-00-000 STEERING CYLINDER ASSEMBLY - " X " SHACKLE BOLT - - " NYLOCK NUT - - " X " HEX BOLT - - " X " HEX BOLT - - " SAE FLAT WASHER - - " HEX NUT -
FRONT AXLE THIRD MEMBER AND SPIDER GEAR ASSEMBLY PAGE 0 0 PART QTY B0-000 THIRD MEMBER ASSEMBLY B0-00 PINION DRIVE YOKE B0-00 PINION SEAL B0-00 PINION DRIVE YOKE WASHER B0-00 PINION DRIVE YOKE CASTLE NUT B0-00 PINION YOKE SPACER B0-0 THIRD MEMBER HOUSING B0-0 THIRD MEMBER TOP COVER B0-0 PINION SIDE COVER 0 B0-0 PINION SEAL HOUSING B0-0 THIRD MEMBER SIDE CAP B0-0 CARRIER HOUSING B0-0 CARRIER BEARING B0-0 CARRIER BEARING RACE B0-0 CARRIER BEARING NUT B0-0 THIRD MEMBER BULL GEAR B0-0 " X " BULL GEAR BOLT B0-0 " BULL GEAR CASTLE NUT B0-0 SPIDER GEAR SPINDLE 0 B0-0 SMALL SPIDER GEAR PART QTY B0-0 SPIDER GEAR SMALL WASHER B0-0 LARGE SPIDER GEAR B0-0 SPIDER GEAR LARGE WASHER - " X " HEX BOLT - " X " HEX BOLT - " LOCK WASHER - " X " HEX BOLT - " LOCK WASHER - " X " COTTER PIN
FRONT AXLE BRAKE SYSTEM COMPONENTS PAGE PART 0 0 QTY B0-000 E-BRAKE HANDLE ASSEMBLY B0-00 E-BRAKE CABLE PIN B0-00 E-BRAKE SWITCH MOUNT B0-00A E-BRAKE CABLE BULKHEAD (CAB) B0-0A E-BRAKE CABLE BULKHEAD MOUNT B0-00 FRONT AXLE BRAKE LINE MOUNT B0-00 E-BRAKE CABLE BULKHEAD (AXLE) B0-00 E-BRAKE ROTOR B0-000 E-BRAKE CALIPER - COMPLETE 0 B0-00 E-BRAKE LINING KIT ( PADS & CLIP) ECS-00 BLACK BUTTON SWITCH MC-0 " E-BRAKE MORSE CABLE B0-0 FRONT AXLE HARD BRAKE LINE B0-0 WHEEL CYLINDER BRAKE HOSE B0-0 WHEEL CYLINDER ADAPTER - INVERTED FLARE TO JIC ADAPTOR (0--) - JIC SWIVEL RUN TEE (0-) 0 - " X " CLEVIS (CALIPER END) - " X " CLEVIS (HANDLE END) 0 - " SET COLLAR - X X " BUTTON HEAD - X HEX NUT - LOCK WASHER - " X " HEX BOLT - " X " HEX BOLT - " LOCK WASHER - " HEX NUT - " X " HEX BOLT - " LOCK WASHER 0 - " NF HEX NUT - " NYLOCK NUT - " X " HEX BOLT - " LOCK WASHER - " HEX NUT
FRONT AXLE SPINDLE, BRAKE, AND HUB ASSEMBLY PAGE 0 0 0 QUANTITIES LISTED ARE PER HUB ASSEMBLY PART QTY B0-00 INNER HUB BEARING B0-00 OUTER HUB BEARING B0-00 BEARING RACE B0-00 SPINDLE JAM NUT B0-00 SPINDLE LOCK RING B0-00 SLINGER SEAL PART *NOTE: SPINDLE AVAILABLE AS ASSEMBLY WITH HUB SEAL AND AXLE SHAFT BUSHING, PART B0-00 QTY B0-0 HUB B0-0 BRAKE DRUM ADAPTER PLATE B0-0 " DRUM ADAPTER STUD 0 B0-0 BRAKE DRUM B0-0 WHEEL STUD B0-0 LUG NUT B0-0 FRONT AXLE SPINDLE* B0-0 SPINDLE BUSHING B0-0 HUB SEAL B0-0 HUB DRIVE CAP B0-0 HUB DRIVE CAP SEAL B0-000 FRONT BRAKE ASSEMBLY - " X " GRADE HEX BOLT 0 - " LOCK WASHER - " HEX NUT 0 - " LOCK WASHER - " HEX NUT
FRONT AXLE BRAKE ASSEMBLY PAGE 0 0 PART B0-000 REO AXLE BRAKE ASSEMBLY B0-00 WHEEL CYLINDER B0-00 WHEEL CYLINDER ROD B0-00 CYLINDER COVER B0-00 BRAKE SHOE B0-00 TENSION SPRING B0-00 LONG SHOULDER BOLT B0-00 SHORT SHOULDER BOLT B0-00 SPRING RETAINER 0 B0-00 SHOULDER BOLT SPRING QTY PART B0-0 SPRING CUP WASHER B0-0 LOWER SHOE ADJUSTER STUD B0-0 BRAKE SHOE RETAINER CLIP B0-0 " WASHER QTY B0-0 " CUP WASHER B0-0 " FIBER WASHER B0-0 WHEEL CYLINDER ADAPTER B0-0 BRAKE LINE COPPER WASHER - " LOCK WASHER 0 - " HEX NUT - " X " HEX BOLT - " LOCK WASHER - " LOCK WASHER - " HEX NUT
FRONT AXLE DRIVER SIDE KNUCKLE ASSEMBLY PAGE 0 PART QTY. B0-000 DRIVER SIDE KNUCKLE ASSEMBLY B0-00 DRIVER SIDE KNUCKLE BODY B0-00 FRONT AXLE KING PIN CAP PLATE B0-00 FRONT AXLE KING PIN SPACER WASHER B0-00 " X " SPINDLE STUD B0-0 TOP KING PIN SLEEVE PLATE B0-0 FRONT KING PIN BUSHING B0-0 BOTTOM KING PIN SLEEVE PLATE - B0-00 COMPLETE KNUCKLE BOOT KIT WITH CLAMPS AND HARDWARE B0-0 KNUCKLE BOOT SEAL 0 B0-0 SMALL BOOT CLAMP B0-0 LARGE BOOT CLAMP - " X " HEX BOLT - " LOCK WASHER - X " PANHEAD SCREW - HEX NUT
FRONT AXLE PASSENGER SIDE KNUCKLE ASSEMBLY PAGE 0 PART QTY. B0-000 PASSENGER SIDE KNUCKLE ASSEMBLY B0-00 PASSENGER SIDE KNUCKLE BODY B0-00 " X " KNUCKLE STUD B0-0 FRONT AXLE DRAG LINK ARM B0-0 CONE WASHER B0-00 FRONT AXLE KING PIN CAP PLATE B0-00 FRONT AXLE KING PIN SPACER WASHER B0-00 " X " SPINDLE STUD B0-0 TOP KING PIN SLEEVE PLATE 0 B0-0 FRONT AXLE KING PIN BUSHING B0-0 BOTTOM KING PIN SLEEVE PLATE - B0-00 COMPLETE KNUCKLE BOOT KIT WITH CLAMPS AND HARDWARE B0-0 KNUCKLE BOOT SEAL B0-0 SMALL BOOT CLAMP B0-0 LARGE BOOT CLAMP 0 - " X " HEX BOLT - " LOCK WASHER - " NYLOCK - X " PANHEAD SCREW - HEX NUT
FRONT AXLE SHAFT ASSEMBLY PAGE B0-000L DS AXLE SHAFT ASSEMBLY /" " B0-000S PS AXLE SHAFT ASSEMBLY 0 0 SEAL AND RETAINER (S 0,) PRESS FIT INTO AXLE HOUSING BEFORE INSERTING AXLE SHAFTS (SEAL FACING IN) *INDIVIDUAL SHAFTS (S -) NOT AVAILABLE FOR RESALE **U-JOINT COMPONENTS NOT AVAILABLE FOR RESALE PART QTY. B0-00 OUTER AXLE SHAFT* B0-00 DS INNER AXLE SHAFT* B0-00 PS INNER AXLE SHAFT* B0-00 THICK INNER THRUST WASHER B0-00 THIN OUTER THRUST WASHER - B0-00 AXLE SHAFT U-JOINT KIT B0-0 FRONT AXLE U-JOINT BODY** B0-0 U-JOINT BEARING CAP** B0-0 U-JOINT BEARING CAP SEAL** B0-0 U-JOINT RETAINING CLIP** 0 B0-0 AXLE SHAFT SEAL RETAINER B0-0 AXLE SHAFT SEAL - B0-000L DS AXLE SHAFT ASSEMBLY - B0-000S PS AXLE SHAFT ASSEMBLY
"BALL STYLE" AXLE SHAFT ASSEMBLIES PART QTY. B0-00X OUTER BALL STYLE AXLE SHAFT* EA. B0-00X DS INNER BALL STYLE SHAFT* B0-00X PS INNER BALL STYLE SHAFT* B0-00 INNER THRUST WASHER (THICK) EA. B0-00 OUTER THRUST WASHER (THIN) EA. B0-0X INNER BALL CENTER PIN* EA. B0-0X INNER JOINT BALL* EA. B0-0X OUTER JOINT BALL* EA. B0-0X BALL STYLE SEAL RETAINER EA 0 B0-0 INNER AXLE SHAFT SEAL EA B0-0X BALL STYLE SEAL RETAINER THRUST WASHER EA PAGE *NOTE: BALL STYLE AXLE SHAFTS ARE SHOWN FOR REFERENCE ONLY AND ARE NOT AVAILABLE FOR RESALE. TO REPLACE A BALL STYLE AXLE SHAFT YOU MUST ORDER THE STANDARD U-JOINT STYLE AXLE SHAFTS AS WELL AS THE CORRECT SEAL RETAINER. SEE PAGE. 0 SEAL AND RETAINER (S,0 & ) PRESS FIT INTO AXLE HOUSING BEFORE INSERTING AXLE SHAFTS (SEAL FACING IN) 0
REAR AXLE BREAKDOWN PAGE 0 PART QTY. CATALOG PAGE - B00-00R REAR WHEEL AND TIRE MOUNTED - B00-0R REAR WHEEL - B00-0 TITAN TIRE - B0-000 REAR AXLE BEAM ASSEMBLY - B0-000 DS REAR SPINDLE ASSEMBLY - B0-000 PS REAR SPINDLE ASSEMBLY B0-000 REAR TIE ROD ASSEMBLY B0-000 REAR BRAKE ASSEMBLY B0-00 REAR BRAKE DRUM B0-0 REAR AXLE HARD BRAKE LINE - B0-0 WHEEL CYLINDER BRAKE HOSE - 0 H0-00B -LUG HUB ASSEMBLY (DRILLED) HYDSC-00-000 STEERING CYLINDER ASSEMBLY PART QTY. LS0-00R 0-PACK LEAF SPRING LS0-0 LEAFSPRING BUSHING B0-00 REAR SPRING MOUNT PLATE LS0-0 " CENTER PIN - " X " SHACKLE BOLT - " NYLOCK NUT - " X " HEX BOLT - " LOCK WASHER 0 - " HEX NUT
REAR AXLE KING PIN ASSEMBLY PAGE PART B0-00 KING PIN SHAFT B0-00 KING PIN BUSHING B0-00 SPACER BEARING B0-00 SHIM WASHER B0-00 KING PIN O-RING B0-00 LOCKING KEY - " LOCK NUT - B0-000 KING PIN REBUILD KIT (INCLUDES S - ) QTY
REAR AXLE SPINDLE, BRAKE, AND HUB ASSEMBLY PAGE PART QTY B0-000 DRIVER SIDE SPINDLE ASSEMBLY - B0-000 PASSSENGER SIDE SPINDLE ASSEMBLY (NOT SHOWN) B0-000 REAR BRAKE ASSEMBLY (SPECIFY LEFT/RIGHT) B0-00 REAR BRAKE DRUM H0-0B ON HUB ASSEMBLY (DRILLED) H0-00 DUST SEAL H0-00 OUTER WHEEL BEARING H0-00 INNER WHEEL BEARING H0-00 SPINDLE WASHER H0-00 HUB CAP 0 H0-0 HUB H0-0 INNER BEARING RACE H0-0 OUTER BEARING RACE PART QTY - " CASTLE NUT - " X " COTTER PIN - " X " PRESS FIT STUD - " LUG NUT - " X " BOLT - " X " BOLT - " LOCK WASHER 0 - " HEX NUT
REAR AXLE BRAKE ASSEMBLY PAGE 0 *NOTE: BRAKE ASSEMBLY IS SIDE SPECIFIC PER WHEEL CYLINDER PART QTY B0-00 BRAKE BACKING PLATE B0-00 BRAKE SHOE B0-00P PASSENGER SIDE REAR WHEEL CYLINDER B0-00D DRIVER SIDE REAR WHEEL CYLINDER B0-00 SHOE ADJUSTER B0-00 BRAKE SHOE STUD B0-00 SHOE HOLD SPRING PIN B0-00 SHOE HOLD SPRING WASHER B0-00 SHOE HOLD SPRING 0 B0-00 LOWER SHOE SPRING B0-0 UPPER SHOE SPRING B0-0 BRAKE SHOE STUD WASHER B0-0 WHEEL CYLINDER ROD B0-00 REAR AXLE BRAKE SPRING KIT - " LOCK WASHER - " HEX NUT - " X " HEX BOLT - " LOCK WASHER B0-000 COMPLETE REAR BRAKE ASSEMBLY* X 0 X B0-00 REAR AXLE BRAKE SPRING KIT (INCLUDES S LISTED BELOW) X X X
DRAG LINK PIVOT ASSEMBLY PAGE 0 0 PS FRAME TUBE REAR DRAG LINK MOUNT PLATE WELDED TO PS FRAME RAIL NOTE: FOR UPDATES TO MACHINES USING OLD STYLE PIVOT, ORDER PART NUMBER B0-000 TO INCLUDE NEW MOUNT PLATE OR CALL FOR MORE INFORMATION PART QTY B0-00A DRAG LINK PIVOT SPINDLE B0-00 DRAG LINK PIVOT MOUNT H0-000 COMPLETE -LUG HUB ASSEMBLY H0-00 DUST SEAL H0-00 INNER WHEEL BEARING H0-00 OUTER WHEEL BEARING H0-00 WASHER H0-00 STAMPED LOCK RING H0-00 HUB CAP 0 H0-0 HUB H0-0 INNER BEARING RACE H0-0 OUTER BEARING RACE - " JAM NUT - " X " PRESS FIT STUD - " X " COTTER PIN - " LUG NUT FRONT DRAG LINK
TIE RODS AND DRAG LINKS PAGE B0-000 COMPLETE FRONT TIE ROD ASSEMBLY END CLAMPS WELDED TO TIE RODS B0-000 COMPLETE REAR TIE ROD ASSEMBLY B0-00 COMPLETE FRONT DRAG LINK ASSEMBLY PART 0 B0-00 COMPLETE REAR DRAG LINK ASSEMBLY B0-000 COMPLETE FRONT TIE ROD ASSEMBLY B0-00 FRONT TIE ROD TUBE ASSEMBLY B0-00R RIGHT HAND FRONT TIE ROD END B0-00L LEFT HAND FRONT TIE ROD END B0-000 COMPLETE REAR TIE ROD ASSEMBLY B0-00 REAR TIE ROD TUBE ASSEMBLY B0-00 COMPLETE FRONT DRAG LINK ASSEMBLY B0-0 FRONT DRAG LINK TUBE B0-00 COMPLETE REAR DRAG LINK ASSEMBLY 0 B0-0 REAR DRAG LINK TUBE B0-00R RIGHT HAND REAR TIE ROD END QTY B0-00L LEFT HAND REAR TIE ROD END - " NF HEX NUT INNER NUTS WELDED TO TUBE
STEERING CYLINDER ASSEMBLY PAGE 0 *NOTE: HYDSC-00-00 SEAL KIT INCLUDES S - PART HYDSC-00-000 COMPLETE STEERING CYLINDER HYDSC-00-00 CYLINDER THREADED CAP HYDSC-00-0 OUTER O-RING HYDSC-00-0 OUTER O-RING BACKER HYDSC-00-0 INNER O-RING HYDSC-00-0 INNER O-RING BACKER HYDSC-00-0 ROD WIPER SEAL HYDSC-0-000 " X " STEERING CYLINDER BODY HYDSC-0-00 QTY " X " CYLINDER ROD 0 HYDSC-0-00 STEERING CYLINDER HEAD HYDSC-0-00 " CYLINDER PISTON HYDSC-0-00 CYLINDER PISTON RING - - - " X " HEIM JOINT " NF JAM NUT " NF NYLOCK - HYDSC-00-00 STEERING CYLINDER SEAL KIT
STEERING CYLINDER ASSEMBLY PAGE 0 PART HYDSC-00-000 STEERING CYLINDER ASSEMBLY - PIPE TO JIC ELL (0--) - PIPE TO JIC 0 ELL (0--) B0-0 REAR STEERING CYLINDER BUTT END B0-0 REAR STEERING CYLINDER ROD END B0-0 FRONT STEERING CYLINDER BUTT END B0-0 FRONT STEERING CYLINDER ROD END B-0 /" TUBE - CAB RIGHT TURN SUPPLY B-0 /" TUBE - STEERING CYLINDER CONNECTION 0 B-0 /" TUBE - CAB LEFT TURN SUPPLY QTY.
HYDRAULIC SYSTEM SCHEMATIC PAGE E M N B P D 0 Q Q J K C 0 F H G 0 A 0 0 P L R S R
HYDRAULIC HOSES PART B0-00 TANK TO MAIN HYDRAULIC PUMP B0-00 TANK TO HYDROSTAT PUMP B0-00 COOLER RETURN TUBE TO TANK B0-00 HYDROSTAT PUMP TO TANK B0-00 HYDROSTAT MOTOR TO TANK B0-00 HYDROSTAT PUMP TO MOTOR B0-00 HOIST PUMP RETURN TO TANK B0-00 PRIORITY TO " VALVE PRESSURE HOSE B0-00 PRIORITY TO " BRAKE PRESSURE HOSE 0 B0-0 PRIORITY TO HOIST PUMP RETURN B0-0 HOIST PUMP TO TUBE B0-0 HOIST PUMP RETURN B0-0 HOIST CYLINDER HOSE B0-0 TUBE TO HOIST CYLINDERS B0-0 REAR STEERING CYLINDER BUTT END B0-0 REAR STEERING CYLINDER ROD END B0-0 FRONT STEERING CYLINDER BUTT END B0-0 FRONT STEERING CYLINDER ROD END B0-00 AUGER PIPE TO FLOW DIVIDER HOSE 0 B0-0 FLOW DIVIDER TO AUGER HOSE B0-0 DS AUGER TO RETURN PIPE HOSE B0-0 PS AUGER TO RETURN PIPE HOSE B0-0 VALVE TO AUGER SUPPLY B0-0 AUGER RETURN TO VALVE B0-0 VALVE TO GATE CYLINDER BUTT END B0-0 VALVE TO GATE CYLINDER ROD END B0-0 VALVE TO HITCH CYLINDER BUTT END B0-00 VALVE TO HITCH CYLINDER ROD END B0-0 TUBE TO OIL COOLER HOSE 0 B0-0 OIL COOLER TO RETURN TUBE B0-0 BUMP HOSE TO HYDROSTAT PUMP B0-0 HYDROSTAT PUMP TO BUMP HOSE B0-0 COAST CIRCUIT TO HYDROSTAT PUMP B0-0 HYDROSTAT PUMP TO COAST CIRCUIT B0-0 ORBITROL RETURN TO VALVE B0-0 BRAKES BOOSTER TO ORBITROL HOSE B0-0 ORBIRTOL TO LEFT TURN HOSE B0-00 ORBITROL TO RIGHT TURN HOSE HYDRAULIC TUBES PART B-0 " TUBE - SYSTEM SUPPLY PRESSURE 0 B-0 " TUBE - VALVE TO COOLER B-0 " TUBE - COOLER TO TANK B-0 /" TUBE - HOIST CYLINDERS SUPPLY B-0 /" TUBE - CAB RIGHT TURN SUPPLY B-0 /" TUBE - PUMP TO BRAKES B-0 /" TUBE - STEERING CYLINDER CONNECTION B-0 /" TUBE - CAB LEFT TURN SUPPLY B-0 /" TUBE - BRAKES TO STEERING B0-00 /" TUBE - AUGER SUPPLY PIPE B0-00 /" TUBE - AUGER RETURN PIPE HYDRAULIC COMPONENTS PART A B-000 COAST VALVE ASSEMBLY B B-000 MAIN HYDRAULIC CONTROL VALVE ASSEMBLY C B-000 HYDRAULIC TANK ASSEMBLY D B0-00 BRAKE CYLINDER ASSEMBLY E B0-00 STEERING ORBITAL F HYDP-MASPL MAIN HYDRAULIC PUMP G HYDSTP-SD000 HYDROSTATIC PUMP H HYDBC-CDM SYSTEM PRIORITY BLOCK J HYDSTM-SD000 HYDROSTATIC DRIVE MOTOR K HYDAP-MI00 AUXILARY HOIST MOTOR L HYDOC-00 OIL COOLER ASSEMBLY M HYDTR-0 EXTENDO-HITCH HYDRAULIC CYLINDER N HYDTR-00 GATE CYLINDER P HYDSC-00-000 STEERING CYLINDER ASSEMBLY Q HYDHC-00-000 HOIST CYLINDER ASSEMBLY R HYDM-TFO0 AUGER MOTOR S HYDBC-FD0 HYDRAULIC FLOW DIVIDER (B00 -) HYDRAULICS SCHEMATIC CONT. PAGE
INDEX PART PAGE PART PAGE AC00-00 A/C THERMOSTAT SWITCH AC00-00 A/C THERMOSTAT SWITCH KNOB AC00-00 A/C FAN SWITCH, AC00-00 A/C FAN SWITCH KNOB AC00-00 A/C SWITCH COVER AC00-00 AIR VENT, AC00-00 A/C THERMOSTAT SWITCH AC0-00 DAYTON CHARGE BLOWER AC0-00 SPAL CHARGE BLOWER, AC0-000 -' YORK COMPRESSOR AC-000 -'0 DENSO COMPRESSOR AC-000 CUMMINS A/C COMPRESSOR,, AC-00 A/C COMPRESSOR CLUTCH, AC0-00 A/C CONDENSER, AC0-00 A/C RECIEVER/DRIER AC0-00 HI-LOW PRESSURE SWITCH AC0-000 -' EVAPORATOR ASSEMBLY,,, AC0-00 -' EVAPORATOR UNIT AC0-00 -' EXPANSION VALVE AC0-0 -' TOP EVAP HOUSING AC0-0 -' BOTTOM EVAP HOUSING AC0-0 -' EVAPORATOR FRONT COVER, AC0-0 - EVAP MOTOR AC0-0 - SQUIRREL CAGE FAN AC0-0 - RETAINER CLIP AC-00 EVAPORATOR UNIT,, AC-00 EXPANSION VALVE AC0-00 EVAP - COMP A/C HOSE AC0-00X 0- EVAP - COMP A/C HOSE AC0-00 COMP - COND A/C HOSE AC0-00 COND - REC/DRIER A/C HOSE AC0-00 REC/DRIER - COMP A/C HOSE AC0-00X 0- REC/DRIER - COMP A/C HOSE AC-00-0 EVAP - COMP A/C HOSE AC-00-0 COMP - COND A/C HOSE AC-00-0 COND - REC/DRIER A/C HOSE AC-00-0 REC/DRIER - EVAP A/C HOSE AF00-00 ENGINE AIR PRE-CLEANER AF00-00 PLASTIC A/C PRE-CLEANER AF0-00 P0 FILTER ELEMENT AF0-00 INSIDE FILTER CAP AF0-00 DONALDSON FILTER HOUSING CAP AF0-00 DONALDSON HOUSING CLAMP AF0-00 DONALDSON FILTER MOUNT STRAP AF0-000 DONALDSON A/C FILTER ASSEMBLY, AF0-00 PRE CLEANER REDUCER AF0-000 DONALDSON AIR FILTER AF0-00 P0 DONALDSON MAIN FILTER AF0-00 P00 DONALDSON PRE FILTER AF0-00 DONALDSON FILTER LID AF0-00 FILTER LID CLIP AF0-00 DONALDSON FILTER DRAIN CONE AF0-00 AIR RESTRICTION INDICATOR AF0-000 SYKLONE A/C FILTER ASSEMBLY,, AF0-00 SYKLONE FILTER ELEMENT CAP AF0-00 SYKLONE RAIN CAP AF0-00 A/C FILTER / TAIL LIGHT GROMMET, AF0-00 SYKLONE BLOWER MOTOR B00-00 LOWER HOIST CYLINDER SHAFT B00-00 HOIST CYLINDER SPACER PIPE B00-0 BIN RUBBER SUPPORT PAD B00-00F FRONT WHEEL AND TIRE B00-00R REAR WHEEL AND TIRE B00-0F FRONT WHEEL B00-0R REAR WHEEL B00-0 TITAN TIRE, B0-00 BIN LIMIT ARM 0 B0-00 BIN LIMIT CABLE 0, B0-000 EXT. HITCH TUBE ASSEMBLY, B0-00 EXT. HITCH ASSEMBLY B0-0 EXT. HITCH UHMW WEAR PAD B0-00 EXT. HITCH TRANSPORT PIN B0-000 DRAG LINK PIVOT UPDATE B0-00 DRAG LINK PIVOT MOUNT 0 B0-00A DRAG LINK PIVOT SPINDLE 0 B0-00 COMPLETE FRONT DRAG LINK B0-0 FRONT DRAG LINK TUBE B0-00 COMPLETE REAR DRAG LINK B0-0 REAR DRAG LINK TUBE B0-00L LH TIE ROD END B0-00R RH TIE ROD END B00-0 BIN FRONT RUBBER SEAL,0 B0-000 COMPLETE GATE ASSEMBLY B0-00 GATE HINGE ROD 0 B0-00 GATE LINKAGE BAR 0 B0-00 TOP GATE TUBE ASSEMBLY 0 B0-00 TOP GATE 0 B0-00 BOTTOM GATE 0 B-000 REAR AIR SCREEN, B-000 RH AUGER (PASS SIDE) B-0 AUGER IDLER SPUD B-0 AUGER DRIVE BUSHING B-0 RH AUGER MOTOR MOUNT B-000 LH AUGER (DRIVER SIDE) B-0 LH AUGER MOTOR MOUNT B-00 BIN HINGE PIN B-00 BIN HINGE PIN COLLAR B-000 BIN SAFETY PROP B-000 UPPER HOIST PIN B-000 BIN EXT. ASSEMBLY, B-00 BIN EXT. REAR PANEL B-00 BIN EXT. DS SIDE FRONT B-00 BIN EXT. PS SIDE FRONT PANEL B-00 BIN EXT. CROSS TUBE SUPPORT B-00 EXTENSION COVER B-0 EXTENSION COVER BOLT PLATES B0-00 ENGINE COMPARTMENT BIN SEAL B0-00 AUGER SUPPLY HYD PIPE,, B0-00 AUGER RETURN HYD PIPE,, B00-00 MCU COMPUTER, B00-00 DASH PANEL CONTROLS B00-0 PS DASH SUB PANEL B00-0 LIGHT SWITCH, B00-0A LIGHT SWITCH COVER, B00-0 HORN SWITCH, B00-0A HORN SWITCH COVER, B00-0 BIN FULL LIGHT, B00-0 AMP TUBE FUSE B00-0A TUBE FUSE HOLDER B00-0 0 AMP CIRCUIT BREAKER,
INDEX PART PAGE PART PAGE B00-0 0 AMP CIRCUIT BREAKER, B00-0 0 AMP CIRCUIT BREAKER, B00- ELECTRONIC FLASHER RELAY B00-0 LCD DASH DISPLAY, B0-00 PS DASH PANEL ASSEMBLY B0-0 A/C LID LATCH, B0-00X A/C BOX COVER ASSEMBLY B0-0X TOP COVER B0-0Y A/C BOX COVER PANEL B0-0X A/C DUCT BOX B0-00 SEAT B0-00 CONTROL LEVER SHAFT B0-00 BRASS CONTROL LEVER BUSHING B0-00 CONTROL LEVER KNOB B0-00 HITCH LEVER B0-00 GATE LEVER B0-00 HOIST LEVER B0-00 AUGER LEVER B0-000A CONTROL PANEL ASSY. (0), B0-00A CONTROL INLET PANEL (0) B0-00X FORMED CONTROL INLET B0-00A CONTROL COVER PANEL (0) B0-00X CONTROL TUNNEL ACCESS PANEL B0-00Y OLD STYLE A/C VENT PANEL B0-00 FWD-REV SHIFTER ASSEMBLY, B0-0 SHIFTER MICRO SWITCH, B0-00 HI-LOW SHIFTER ASSEMBLY, B0-000A A/C UNIT ASSEMBLY (0), B0-000Y DAYTON CHARGE BLOWER ASSY. B0-00Y LOWER MANIFOLD BASE PLATE B0-00Y AIR RECIRCULATION HOSE B0-00A AC UNIT FRONT COVER (0) B0-00Y FILTER ELL HOSE B0-00 IN CAB RECIRCULATION FILTER, B0-0 ⅜" HOSE SPACER B0-0 FRONT COVER SEAL B0-0 FRONT COVER TRIM B0-00A AC UNIT HOUSING (0) B0-00Y UPPER BLOWER MANIFOLD B0-0X IN CAB RECIRCULATION FILTER B0-00A FILTER HOUSING (0) B0-0 DRAIN HOSE NIPPLE B0-000A BRAKE LIGHT SWITCH MOUNT (0) B0-00 BRAKE LIGHT SWITCH MOUNT 0 B0-00 BRAKE PIVOT TUBE ASSEMBLY 0 B0-0A BRAKE ROD (0) B0-0 BRAKE PIVOT TUBE BUSHING 0 B0-00 BRAKE PEDAL ASSEMBLY,0 B0-00A BRAKE SHAFT (0) B0-0 BRAKE PEDAL PAD 0, B0-00 BRAKE ARM 0 B0-00A BRAKE PEDAL ASSEMBLY (0) B0-000 THROTTLE PEDAL ASSEMBLY B0-000 E-BRAKE HANDLE ASSEMBLY, B0-00 E-BRAKE CABLE PIN B0-00 E-BRAKE SWITCH MOUNT B0-00 E-BRAKE SPACER, B0-00A CABLE BULKHEAD MOUNT (0) B0-000 STEERING COLUMN B0-00 STEERING WHEEL B0-00 STEERING COLUMN B0-00 TURN SIGNAL B0-00 STEERING SPACER B0-00 STEERING ORBITAL,, B-000A BRUSH GUARD, B0-000A COMPLETE CAB DOOR (0), B0-00 WINDOW TRACK STOP BLOCK B0-0 WINDOW VELVET FRONT B0-0 WINDOW VELVET LONG B0-0 WINDOW VELVET SHORT B0-0 WINDOW VELVET TOP & BOTTOM B0-0 CAB DOOR GLASS PANE B0-0 STAINLESS FELT SEAL B0-0 VERTICAL GLASS SEAL B0-0 SLIDING WINDOW HANDLE B0-00 INSIDE DOOR HANDLE B0-0A CAB DOOR TRIMLOCK SEAL (0) B0-00 DOOR WINDOW TRIM KIT B0-00 DOOR LATCH B0-0 DOOR LATCH STRIKER B0-00 CAB DOOR HINGE B0-000 COMPLETE CAB TOP, B0-0 PASS SIDE GLASS B0-0 REAR CAB GLASS B0-0 DRIVER SIDE FR GLASS B0-0 DRIVER SIDE RR GLASS B0-0 FRONT GLASS B0-0 PASS SIDE GLASS TRIM B0-0 REAR CAB GLASS TRIM B0-0 DRIVER SIDE FR GLASS TRIM B0-0 DRIVER SIDE RR GLASS TRIM B0-0 FRONT GLASS TRIM B00-000 COMPLETE REAR AXLE B0-000 REAR AXLE BEAM B0-00 REAR LEAF SPRING MOUNT PLATE B0-000 DRIVER SIDE REAR SPINDLE, B0-000 PASSENGER SIDE REAR SPINDLE, B0-000 COMPLETE REAR TIE ROD, B0-00 REAR TIE ROD TUBE B0-000 REAR KING PIN REBUILD KIT B0-00 REAR KING PIN SHAFT B0-00 REAR KING PIN BUSHING B0-00 REAR KING PIN SPACER BEARING B0-00 REAR KING PIN SHIM B0-00 REAR KING PIN O-RING B0-00 REAR KING PIN LOCKING KEY B0-000 REAR BRAKE ASSEMBLY,, B0-00 REAR BRAKE BACKING PLATE B0-00 REAR BRAKE DRUM B0-00 REAR BRAKE SHOE B0-00D DS REAR WHEEL CYLINDER B0-00P PS REAR WHEEL CYLINDER B0-00 REAR BRAKE SHOE ADJUSTER B0-00 REAR BRAKE SHOE MOUNT STUD B0-00 REAR BRAKE SHOE SPRING PIN B0-00 REAR BRAKE SHOE CUP WASHER B0-00 REAR BRAKE SHOE HOLD SPRING B0-00 REAR BRAKE LOWER SHOE SPRING B0-0 REAR BRAKE UPPER SHOE SPRING B0-0 SHOE MOUNT STUD WASHER
INDEX PART PAGE PART PAGE B0-0 REAR WHEEL CYLINDER ROD B0-00 REAR AXLE BRAKE SPRING KIT B00-000 CUMMINS ENGINE ASSY.,, B0-000 DIESEL FUEL TANK, B0-00 FUEL LEVEL SENDING UNIT B0-0 ⅜" FUEL LINE - TANK TO FILTER B0-0 ⅜" FUEL LINE - FILTER TO ENGINE B0-0 ¼" FUEL LINE - INJECTOR RETURN B0-000 RADIATOR & INTERCOOLER ASSY. B0-00 RADIATOR SEAL MOUNT B0-00 AIR DEFLECTOR PAN B0-00 UPPER RADIATOR TRIMLOCK, B0-00 LOWER RADIATOR TRIMLOCK B0-00 OIL COOLER MOUNT TRIM B0-00 OIL COOLER ASSY B0-0 UPPER OIL COOLER MOUNT B0-0 LOWER OIL COOLER MOUNT B0-00 A/C CONDENSOR ASSY B0-00A CUMMINS CONDENSER MOUNT KIT B0-00B JD CONDENSER MOUNT KIT B0-0 DS VERT. CONDENSER MOUNT B0-0 PS HORZ. CONDENSER MOUNT B0-0 CUMMINS CONDENSER MOUNT HAT B0-00 AIR FILTER VACUUM KIT, B0-0 LONG VACUUM PIPE B0-0 SHORT VACUUM PIPE B0-0 ¼" 0 PVC COUPLER B0-0 AIR FILTER VACUUM HOSE B0-000 ENGINE AIR FILTER ASSY. B0-00 AIR FILTER MOUNT B0-00 AIR FILTER SNORKLE MANIFOLD B0-000 COMPLETE INTAKE SNORKLE ASSY., B0-00 INTAKE SNORKLE CUP SEAL B0-00 LOWER MOUNT TAB B0-00 SNORKLE TUBE ASSY. B0-00 UPPER CLAMP ASSY. B0-000 CUMMINS DRIVELINE, B0-000X JOHN DEERE DRIVELINE B0-00 DRIVELINE U-JOINT ASSY. B0-00 COMPANION FLANGE B0-00 BRAKE ROD 0 B0-00 UHMW BRAKE ROD MOUNT 0 B0-00 BRAKE BOOSTER & MASTER CYL.,,, B0-0 BRAKE MASTER CYLINDER 0, B0-0 BRAKE BOOSTER 0, B0-0 BRAKE BOOSTER BOOT 0, B0-00 BRAKE FLUID RESERVOIR,0 B0-0 BRAKE FLUID RESERVOIR CAP 0 B0-0 BRAKE FLUID RESERVOIR INSERT 0 B0-0 MAST. CYL. - FRAME BRAKE LINE 0, B0-0 FRAME - FRONT AXLE BRAKE LINE B0-0 FRONT - REAR FRAME BRAKE LINE B0-0 FRONT AXLE BRAKE LINE, B0-0 REAR AXLE BRAKE LINE, B0-0 WHEEL CYLINDER BRAKE HOSE,, B0-0 RESERVOIR - MASTER BRAKE HOSE, B0-0 FRAME - FRONT AXLE BRAKE HOSE B0-000 HYDROSTAT DRIVE SYSTEM B-000 COAST VALVE ASSY.,,,, B-00 BUMP/COAST VALVE BRACKET B-000 HYDRAUILIC OIL TANK ASSEMBLY,,, B-000 CONTROL VALVE ASSEMBLY 0,, B-0 VALVE PRESSURE TUBE 0,, B-0 VALVE - COOLER TUBE 0,, B-0 COOLER - TANK TUBE, B-0 HOIST SUPPLY TUBE 0,,, B-0 CAB RIGHT TURN TUBE,, B-0 PRIORITY - BOOSTER TUBE, B-0 STEERING CYL. TUBE,, B-0 CAB LEFT TURN SUPPLY TUBE,, B-0 BOOSTER - STEERING TUBE, B0-00 TANK - METARIS PUMP HOSE,,, B0-00 TANK - HYDROSTAT HOSE,,, B0-00 COOLER RETURN - TANK HOSE,, B0-00 HYDROSTAT PUMP - TANK HOSE,,, B0-00 HYDROSTAT MOTOR - TANK HOSE,,, B0-00 HYDROSTAT PUMP - MOTOR HOSE,, B0-00 HOIST PUMP RETURN - TANK HOSE,,, B0-00 PRIORITY - VALVE PRESSURE HOSE,, B0-00 PRIORITY - BRK. PRESSURE HOSE,, B0-0 PRIORITY - HOIST RETURN HOSE,,, B0-0 HOIST PUMP - TUBE HOSE,, B0-0 HOIST PUMP RETURN HOSE,, B0-0 HOIST CYLINDER HOSE,, B0-0 TUBE - HOIST CYLINDER HOSE,, B0-0 REAR STEER CYL. BUTT HOSE,, B0-0 REAR STEER CYL. ROD HOSE,, B0-0 FRONT STEER CYL. BUTT HOSE,, B0-0 FRONT STEER CYL. ROD HOSE,, B0-00 AUGER PIPE - FLOW DIVIDER HOSE,, B0-0 FLOW DIVIDER - AUGER HOSE,, B0-0 DS AUGER - RETURN PIPE HOSE,, B0-0 PS AUGER - RETURN PIPE HOSE,, B0-0 VALVE - AUGER SUPPLY HOSE 0,, B0-0 AUGER RET. PIPE - VALVE HOSE 0,, B0-0 VALVE - GATE CYL. BUTT HOSE 0,0,, B0-0 VALVE - GATE CYL. ROD HOSE 0,0,, B0-0 VALVE - HITCH CYL. BUTT HOSE 0,,, B0-00 VALVE - HITCH CYL. ROD HOSE 0,,, B0-0 TUBE - OIL COOLER HOSE,, B0-0 COOLER - RETURN TUBE HOSE,, B0-0 BUMP - HYDROSTAT PUMP HOSE,, B0-0 HYDROSTAT PUMP - BUMP HOSE,, B0-0 COAST - HYDROSTAT PUMP HOSE,, B0-0 HYDROSTAT PUMP - COAST HOSE,, B0-0 ORBITROL RET. - VALVE HOSE 0,, B0-0 BRAKE BOOSTER - ORBITROL HOSE, B0-0 ORBITROL - LEFT TURN HOSE, B0-00 ORBITROL - RIGHT TURN HOSE, B00-000 COMPLETE FRONT AXLE B00-00 FRONT SPRING MOUNT PLATE B00-00 OVERLOAD SPRING MOUNT PLATE B0-00 FRONT AXLE HOUSING B0-00 FRONT AXLE BRAKE LINE MOUNT B0-00 E-BRAKE CABLE BULKHEAD MOUNT B0-00 E-BRAKE ROTOR, B0-0 AXLE SHAFT SEAL RETAINER, B0-0X BALL STYLE SEAL RETAINER B0-0 AXLE SHAFT SEAL,, B0-0X BALL STYLE RET. THRUST WASHER