APPLICATION LIST. ALTRONIC EZRAIL MODULAR IGNITION RAIL SYSTEM FORM EZRail AL 7-08 GENERAL INFORMATION
|
|
- Colin Sherman
- 5 years ago
- Views:
Transcription
1 PPLICTION LIST GENERL INORMTION IT. DESCRIPTION PRT NO. LTRONIC EZRIL MODULR IGNITION RIL SYSTEM ORM EZRail L 7-08 EZ Rail ssembly ( or /bank) q = Ignition Type 5 or 7 = CPU-95; 6 or 8 = CPU-000 ab = No. Outputs 0 xy = Engine Mfr. z = Engine Series m = Engine Bank or B Bank, C = Rail w/o J-Box B Junction Box (/system) 593axx-xxx a = Ignition Type 4, 5 = CPU-95, DISN; 9 = CPU-000 Note: two options depending on the mounting location of the J-Box C Harness: Ignition to J-Box ( or ) L = 4, 36, 48, 60, 7, 96, 0, 44, L C Harness: J-Box to Rail ssembly (/bank) w/x90 and x80 connector L = 4, 36, 48, 60, 7, 96, 0, 44, 80 w/x90 connectors L = 4, 36, 48, 60, 7, 96, 0, 44, 80 *Use 7930-L up to 8 circuits (CPU-95) or 0 circuits (CPU-000) 7930-L 7930-L* C3 Harness: Rail to Rail L = 4, 36, 48, 60, 7, 96 (inches) 7930-L Required only on integral engines E G Shutdown Lead Cable (/system) w/80 connector L = 6 to 80 (inches) w/90 connector L = 6 to 80 (inches) w/x90 and x80 connector L =, 8, 4, 30, 36, 48, 60 (in.) *Use only with CPU-000 system with diagnostic module 905- Coil Primary Cable ( or /cylinder) Unshielded option Cut-to-length Shielded options L =, 8, 4, 30, 36, 48, 60 (in.) Spark Plug Lead Cable (/coil, see catalog, orm I-C) Unshielded for Unshielded Coil Unshielded for Shielded Coil lashguard Unshielded Leads 4" Ext. lashguard Unshielded Leads 9" Ext. Safe-T-Leads Shielded Leads " Connection Shielded Leads " Connection L = 3, 7, 8,, 4 (inches) L =, 6, 8, (inches) L =, 6, 8, 0, 4 (inches) L = 7, 9, 33, 35 (inches) L = 4, 8, (inches) L = 0, 3, 6, 8, 4 (inches) L = 0, 3, 6, 8, 4 (inches)) L L * KT L L See form I-C See form I-C See form I-C L L H Coil Mounting ssembly ( or /bank) Optional 5805ab-xyz ab = No. Outputs xy = Engine Mfr. z = Engine Series 0- I Mounting Kit (see listing for qty.) Optional 5500-KT
2 EZRIL SYSTEM COMPONENTS OR HIGH SPEED SHUTDOWN LED CBLE L L E C IGNITION TO J-BOX 7930-L B JUNCTION BOX 593axx-xxx J-BOX TO RIL 7930-L C 7930-L J-BOX TO RIL C 7930-L 7930-L NOTE: MOUNT EZRIL SSEMBLY OR BOTH BNKS WITH 9-PIN CONNECTOR T THE PPROPRITE END O THE. H COIL MOUNTING SSEMBLY 5805ab-xyz EZRIL SSEMBLY EZRIL SSEMBLY COIL PRIMRY CBLE KT COIL G SPRK PLUG SPRK PLUG LED CBLE ORM EZRail L 7-08
3 LTRONIC EZRIL MODULR IGNITION RIL SYSTEM PPLICTION CHRT CPU-95/DISN JX EZRail ssembly Part No. B J-Box at J-Box at end # end opposite of # C C s,g H Part No. DPC-300, C None None DPC-540, C None None DPC C None None , C None None C None None C None None CTERPILLR C None None C None None B B B B I Contact factory Contact factory G379 G B B Contact factory G CUMMINS G743, G C None None MEP MEP Contact factory MEP Contact factory MEP Contact factory MEP Contact factory SUPERIOR 6Gx85, 6GTLx Gx85, 8GTLx Gx85, GTLx G85, GT85 Endyn firing order B G85, 6GTLx G85, 6GTLx Endyn firing order B GT GT85 Endyn firing order B
4 LTRONIC EZRIL MODULR IGNITION RIL SYSTEM PPLICTION CHRT CPU-95/DISN SUPERIOR (continued) EZRail ssembly Part No. B J-Box at J-Box at end # end opposite of # C C s,g H Part No WUKESH VG B I VHP VHP VHP6 ( rail/bank) VHP6 ( rails/bank) B S * T T * Requires qty. harnesses C3 see page. 0 4 ORM EZRail L 7-08
5 EZRIL SYSTEM COMPONENTS OR INTEGRL CPU-000 DIGNOSTIC MODULE CPU-000 OUTPUT MODULE C IGNITION TO J-BOX 7930-L SHUTDOWN LED CBLE Note: If Diagnostic Module is not used, use cable L or L E B JUNCTION BOX 593axx-xxx J-BOX TO RIL 7930-L C 7930-L J-BOX TO RIL C 7930-L 7930-L EZRIL SSEMBLY EZRIL SSEMBLY C3 RIL TO RIL 7930-L EZRIL SSEMBLY EZRIL SSEMBLY SPRK PLUG G COIL PRIMRY CBLE KT SPRK PLUG LED CBLE H COIL MOUNTING SSEMBLY 5805ab-xyz COIL PRIMRY CBLE KT 5
6 LTRONIC EZRIL MODULR IGNITION RIL SYSTEM PPLICTION CHRT CPU-000 Note: Engine firing order must be submitted with purchase order EZRail ssembly Part No. B J-Box at J-Box at end # end opposite of # C3 Harness H Part No. CLRK HR Z HR Z HR Z TL Z TL-6/ Z TL-6/ Z TLC Z TL Z TLC Z TL-0/ Z TL-0/ Z TCV Z TCV Z TCV Z TCV Z COOPER-BESSEMER GMV-6 Series Z GMV-8 Series Z GMV-8 flat crank Z GMV-0 Series Z GMVH- flat crank Z GMW-6 Series Z GMW-8 Series Z GMW-0, GMWC-0 GMW Z Z GMW- Series Z V50, 6V75, 6W Z V50, 8V75, 8W Z V50,0V75,0W Z V50,V75,W Z V50,6V75,6W Z LS8G Z DE LVL HV Z HV Z HV Z I ORM EZRail L
7 LTRONIC EZRIL MODULR IGNITION RIL SYSTEM PPLICTION CHRT CPU-000 Note: Engine firing order must be submitted with purchase order EZRail ssembly Part No. B J-Box at J-Box at end # end opposite of # C3 Harness H Part No. INGERSOLL RND 36KVG, 6KVG Z KVG, 83KVG Z KVGR Z KVG Z KVS, 36KVS, 36KVSR Z KVS, 48KVSR Z KVG, 40KVG Z KVG Z I 40/50 KVG/KVGR (-cyl. crank) Z /50 KVS/KVSR (-cyl. crank) Z /5 KVG/KVGR/KVS/KVSR Z KVT, 38KVR Z KVT, 40KVR Z KVT, 5KVR Z KVT, 66KVR Z
Application List. Altronic EZRail Modular Ignition Rail System. Form EZRail AL 7-12
pplication List ltronic EZRail Modular Ignition Rail System Form EZRail L 7- GENERL INFORMTION ITEM DESCRIPTION PRT NO. EZ Rail ssembly ( or /bank) q = Ignition Type 5 or 7 = CPU-95; 6 or 8 = CPU-000 ab
More informationIgnition Accessories
Ignition Accessories Ignition Accessories CONTENTS Introduction... 3 Altronic EZRail Modular Ignition Rail System Features and Benefits... 4 System Components for High Speed Engines... 5 System Components
More informationAPPLICATION LIST REQUIRED ITEMS: A: CPU-95 IGNITION MODULE, 1 PER SYSTEM. 1
HOERBIGER Engine Solutions APPLICATION LIST CPU-95/CPU-95EVS DIGITAL IGNITION SYSTEMS MEDIUM ENGINES, 2 18 CYLINDERS FORM CPU-95/95EVS AL 9-14 REQUIRED ITEMS: A: CPU-95 IGNITION MODULE, 1 PER SYSTEM 791950-8
More informationIgnition Accessories
Ignition Accessories Ignition Accessories CONTENTS Introduction... 3 Altronic EZRail Modular Ignition Rail System Features and Benefits... 4 System Components for High Speed Engines... 5 System Components
More informationINSTALLATION INSTRUCTIONS
INSTALLATION INSTRUCTIONS WARNING: WARNING: www.altronicinc.com DEVIATION DEVIATION FROM THESE FROM INSTRUCTIONS THESE INSTRUCTIONS MAY LEAD MAY TO LEAD IMPROPER TO IMPROPER OP- ERATION OF ENGINE THE MACHINE
More informationSAN JOAQUIN VALLEY UNIFIED AIR POLLUTION CONTROL DISTRICT. Appendix F: EPA TSD for NOx SIP Call August 18, 2011 APPENDIX F
APPENDIX F EPA Stationary Reciprocating Internal Combustion Engines Technical Support Document For NOx SIP Call F - 1 This page intentionally blank. F - 2 Stationary Reciprocating Internal Combustion Engines
More informationIgnition Systems for Industrial Engines
Ignition Systems for Industrial Engines Altronic Ignition Systems CONTENTS Altronic Ignition Systems Overview and Guide Contents and Introduction... 2 Application Guide... 3 Solid-State/Mechanical Ignition
More informationKENCO ENGINEERING COMPANY P.O. BOX TULSA, OK PHONE: (918) FAX: (918)
KENCO ENGINEERING COMPANY P.O. BOX 470426 TULSA, OK 74147-0426 PHONE: (918) 663-4406 FAX: (918) 663-4480 www.kenco-eng.com e-mail: info@kenco-eng.com INSTALLATION INSTRUCTIONS FOR MODEL KLC OIL LEVEL CONTROLLERS
More informationKENCO ENGINEERING COMPANY P.O. BOX TULSA, OK PHONE(918) FAX: (918)
KENCO ENGINEERING COMPANY P.O. BOX 470426 TULSA, OK 74147-0426 PHONE(918) 663-4406 FAX: (918) 663-4480 www.kenco-eng.com e-mail:info@kenco-eng.com INSTALLATION INSTRUCTIONS FOR MODEL KLCM OIL LEVEL CONTROLLERS
More informationKENCO ENGINEERING COMPANY P.O. BOX TULSA, OK PHONE(918) FAX: (918)
KENCO ENGINEERING COMPANY P.O. BOX 470426 TULSA, OK 74147-0426 PHONE(918) 663-4406 FAX: (918) 663-4480 www.kenco-eng.com e-mail:info@kenco-eng.com INSTALLATION INSTRUCTIONS FOR MODEL KES OIL LEVEL SWITCHES
More informationKENCO ENGINEERING COMPANY P.O. BOX TULSA, OK PHONE(918) FAX: (918)
KENCO ENGINEERING COMPANY P.O. BOX 470426 TULSA, OK 74147-0426 PHONE(918) 663-4406 FAX: (918) 663-4480 www.kenco-eng.com e-mail:info@kenco-eng.com INSTALLATION INSTRUCTIONS FOR MODEL 512 OIL LEVEL CONTROLLERS
More informationChevrolet Avalanche, Silverado 1500, Suburban, Tahoe
Engine Oil Consumption on Aluminum Block/Iron Block Engines with Active Fuel Management (AFM) (Install AFM Oil Deflector and Clean Carbon from Cylinder) 2007-2010 Cadillac Escalade, Escalade ESV, Escalade
More informationIGNITION TOOLS & TEST EQUIPMENT
PRODUCT GUIDE 07 REV. 06/2013 IGNITION TOOLS & TEST EQUIPMENT Chapter 07 07/1 IGNITION TOOLS & TEST EQUIPMENT SparkView MOTORTECH HIGH VOLTAGE INDICATOR The SparkView is a handheld device developed by
More informationCPU-XL VariSpark ADVANCED DIGITAL IGNITION SYSTEM FOR LARGE GAS ENGINES
CPU-XL VariSpark ADVANCED DIGITAL IGNITION SYSTEM FOR LARGE GAS ENGINES n State-of-the-art, crankshaft-referenced digital ignition system for natural-gas fueled integral compressor engines n Innovative
More informationOIL LEVEL CONTROLLERS AND OIL LEVEL SWITCHES
OIL LEVEL CONTROLLERS AND OIL LEVEL SWITCHES FEATURES: Reduces maintenance by maintaining a constant oil level Protects against lubrication failure Controller mechanism fully removable without draining
More informationGen III HEMI Harness PN or
Gen III HEMI Harness PN 558-106 or 558-107 This wiring harness interfaces a Holley EFI ECU to a Gen III HEMI engine. It is meant to be used in conjunction with an injector harness, a coil harness, and
More informationDTC P0325 KNOCK SENSOR 1 CIRCUIT (BANK 1 OR SINGLE SENSOR) DTC P0327 KNOCK SENSOR 1 CIRCUIT LOW INPUT (BANK 1 OR SINGLE SENSOR)
DIGNOSTICS SFI SYSTEM (pril, 2003) DTC KNOCK SENSOR 1 CIRCUIT (BNK 1 OR SINGLE SENSOR) 05 163 05DIN 01 DTC P0327 KNOCK SENSOR 1 CIRCUIT LOW INPUT (BNK 1 OR SINGLE SENSOR) DTC P0328 KNOCK SENSOR 1 CIRCUIT
More informationFEATURES APPLICATIONS OPERATING PRINCIPLE FOR OIL LEVEL CONTROLLERS OPERATING PRINCIPLE FOR OIL LEVEL SWITCHES
FEATURES Reduces maintenance by maintaining a constant oil level Protects against lubrication failure Controller mechanism fully removable without draining oil Easy view convex sight window Low to high
More informationIGNITION SYSTEM IG 1 2GR-FE IGNITION IGNITION SYSTEM INSTRUMENT PANEL JUNCTION BLOCK - IG2 FUSE ECM
NITION SYSTEM EINE 2GR-FE PARTS LOCATION 2GR-FE NITION NITION SYSTEM 1 INSTRUMENT PANEL JUNCTION BLOCK - 2 FUSE ECM EINE ROOM NO. 1 RELAY BLOCK, JUNCTION BLOCK - 2 RELAY - AM2 FUSE A126956E01 2 2GR-FE
More informationTECHNICAL BULLETIN Engine Vibration/Noise Above 1000 RPM Oil Pump Resonance Install Revised Oil Pump SERVICE DATE MODEL 2002 MY.
SERVICE V8 XJ Series DATE 12/02 TECHNICAL BULLETIN Engine Vibration/Noise Above 1000 RPM Oil Pump Resonance Install Revised Oil Pump 100-21 MODEL 2002 MY V8 XJ Series VIN F44114 - F55936 Issue: Some 2002
More informationDiag. Code 14, 15 Ignition Signal Circuit
TR26 EINE TROUBLESHOOTI Diag. Code 14, 15 Ignition Signal Circuit CIRCUIT DESCRIPTION The ECU determines the ignition timing, turns on Tr1 at a predetermined angle ( CA) before the desired ignition timing
More information5.3 Distributor Ignition System (DI) Engine 120 LH-SFI
Preliminary work: Diagnostic Trouble Code (DTC) Readout.................... 11 Preparation for Test 1. Ignition: OFF 2. After determining which ignition control module (N1/4) and/or (N1/5) is indicating
More informationOperating Instructions
Operating Instructions CPU-XL VariSpark Digital Ignition System with Enhanced Display Form 1.0 OVERVIEW 1.1 The Altronic CPU-XL VariSpark Digital Ignition with enhanced display is a DCpowered, microprocessor-based,
More informationCarl M. Cummings Manufacturing Company. A Division of Maven Engineering Corporation
Carl M. Cummings Manufacturing Company USA 15946 Derwood Road Rockville, Maryland USA 20855 Main Phone: 301-519-3400 Main Fax: 301-975-0712 sales@mavencorporation.com 2818-A Metropolitan Blvd. Pomona,
More informationJOHNSON/EVINRUDE (OMC) Ignition System OUTBOARD
ck 18-5001 ➀ 18-5001N➁ AP# 13339 Replaces: 172525 18-5200 Condenser 580256 1 18-5157 Contact set 580290 2 18-5002 AP# 21006 Replaces: 172523 18-5205 Condenser 581419 2 18-5156 Contact Set 580148 2 18-5003
More informationPOWER WINDOWS Toyota 4Runner DESCRIPTION & OPERATION TROUBLE SHOOTING COMPONENT TESTS POWER WINDOW SWITCH CONTINUITY TEST (DRIVER S SIDE SWITCH)
POWER WINDOWS 1995 Toyota 4Runner 1995-96 ACCESSORIES & EQUIPMENT Toyota Power Windows - Trucks 4Runner DESCRIPTION & OPERATION System components consist of a power window relay, power window switches
More information1VAL2401-SG Rev D. Spare parts list for Outdoor Products Reclosers, breakers, & padmount switches
1VAL2401-SG Rev D Spare parts list for Outdoor Products Reclosers, breakers, & padmount switches Reclosers GridShield recloser 12A00736H05 Actuator assist capacitor Single-phase upgrade 15 KV, 800 A, 12.5
More informationBefore repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs.
NOTICE: When inspecting or repairing the SRS, perform the operation in accordance with the following precautionary instructions and the procedure and precautions in the Repair Manual for the applicable
More informationDTC P0130 OXYGEN SENSOR CIRCUIT MALFUNCTION (BANK 1 SENSOR 1) DTC P0132 OXYGEN SENSOR CIRCUIT HIGH VOLTAGE (BANK 1 SENSOR 1)
DIGNOSTICS DTC P0130 YGEN SENSOR CIRCUIT MLFUNCTION (BNK 1 SENSOR 1) 05359 0574901 DTC P013 YGEN SENSOR CIRCUIT HIGH VOLTGE (BNK 1 SENSOR 1) DTC P0133 YGEN SENSOR CIRCUIT SLOW RESPONSE (BNK 1 SENSOR 1)
More informationSEIMA Workshop Air Quality in Saskatchewan Friday, Jan 17, 2014
SEIMA Workshop Air Quality in Saskatchewan Friday, Jan 17, 2014 Slide No. 1 Presentation Overview 1. Introductions & Background 2. Background on NOx Emissions 3. Rich Burn Engine Control 4. Lean Burn Engine
More informationMANDATORY CHECKING AND REPLACEMENT OF STATOR ASSY. SB SB Repeating symbols: 1) Planning information
CHECKING AND REPLACEMENT OF STATOR ASSY. MANDATORY Repeating symbols: Please, pay attention to the following symbols throughout the Service Bulletin emphasizing particular information. WARNING: Identifies
More informationof 9 2/3/204 :44 PM 2007 GMC Yukon 5.3L Eng Base ENGINE OIL CONSUMPTION ON ALUMINUM BLOCK/IRON BLOCK ENGINES WITH ACTIVE FUEL MANAGEMENT (AFM) (INSTALL AFM OIL DEFLECTOR AND CLEAN CARBON FROM CYLINDER
More informationIndividual ignition coil system,
Page 1 of 11 28-17 Individual ignition coil system, checking Ignition coils, checking Notes: Measuring the primary resistance of the ignition coils is normally not necessary for this test (primary resistance
More informationPage 1 of 6 NO START - ENGINE CRANKS OKAY General Inspection 1. Ensure proper starting procedure is being used. 2. Visually check vacuum hoses for splits, kinks and improper connections. See underhood
More informationSystem Description. Diagnostic Aids. Enhanced Ignition System Diagnosis
Enhanced Ignition System Diagnosis System Description This system includes the distributor, the CAM position sensor ignition coil with the ignition coil driver, the secondary wires, spark plugs, the knock
More informationSUBJECT: Long Engine Crank Time And/Or MIL Illumination Due To DTC P0340 / P0344
NUMBER: GROUP: 08-001-08 REV. A Electrical DATE: February 23, 2008 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationDTC P1300 Igniter Circuit Malfunction No.1. DTC P1310 Igniter Circuit Malfunction No.2
DIAGNOSTICS EINE (5SFE) DI63 DI0G06 DTC P300 Igniter Circuit Malfunction No. DTC P30 Igniter Circuit Malfunction No.2 CIRCUIT DESCRIPTION The ECM determines the ignition timing, turns on Tr at a predetermined
More informationTECHNICAL SERVICE PARTS
B C1 Fuel Pump Check Valves Connector Plug Kits Connector Plugs Terminals Protective Rubber Boots Miscellaneous Service Parts General Service Tools Fuel Distributor Service Parts C2 B FUEL PUMP CHECK VALVE
More informationInstallation Instructions 15/25/35kV, 600/900 AMPERE
Installation Instructions 15/25/35kV, 600/900 AMPERE Two---, Three--- and Four---Point Deadbreak Junctions IS---600/900A J2,J3,J4 Page 1 of 7 CONTENTS: The contents always include: 1---Deadbreak Junction,
More informationIGNITION TO INDEX IGNITION SYSTEM (3SZ-VE) OPERATION CHECK... LOCATION... IGNITION SYSTEM (K3-VE) CAM POSITION SENSOR (3SZ-VE) COMPONENTS...
TO INDEX ENGINE NITION NITION SYSTEM (3SZ-VE) OPERATION CHECK......................................... LOCATION.................................................. NITION SYSTEM (K3-VE) OPERATION CHECK.........................................
More informationThis Bulletin has been revised to update Warranty Information. Please discard Corporate Bulletin Number L.
2008 C hevrolet Avalanche - 2WD [3GNEC 12048G177472] Avalanche, Escalade, Suburban, Tahoe, Yukon VIN C /K Service Manual Engine Engine Mechanical - 4.8L, 5.3L, 6.0L, 6.2L, or 7.0L Repair Instructions -
More informationDIESEL EGT GAUGE INSTALLATION INSTRUCTIONS P14D AA
DIESEL EGT GUGE INSTLLTION INSTRUCTIONS P4D4-9235- Revision: - Dated 3/9/4 Replaces: None DIESEL EGT GUGE INSTLLTION HRDWRE CONTENTS P4D4-44- - DIESEL EGT GUGE KIT COMPONENT - DIESEL EGT GUGE SSY (PRT
More information1995 Ford Mustang ENGINE PERFORMANCE System/Component Tests - EEC-IV (5.0L)
DISTRIBUTOR IGNITION SYSTEM Preliminary Check Perform following preliminary checks: Visually inspect engine compartment to verify vacuum hoses and spark plug wires are properly routed/securely connected.
More informationON-VEHICLE INSPECTION
ON-VEHICLE INSPECTION 1. CHECK IGNITION COIL ASSEMBLY AND PERFORM SPARK TEST (a) Check for DTCs. NOTICE: If any DTC is present, perform troubleshooting in accordance with the procedure for that DTC. (b)
More informationT-630 with John Deere Electronic Engines Troubleshooting
T-630 with John Deere Electronic Engines Troubleshooting The T-630 is equipped with a digital readout located in the Gray Box on the right side of the engine compartment. This diagnostic gauge gives hours,
More informationDTC 14 Ignition Signal Circuit
EG672 ENGINE DTC 14 Ignition Signal Circuit CIRCUIT DESCRIPTION The ECM determines the ignition timing, turns on Tr 1 at a predetermined angle ( CA) before the desired ignition timing and outputs an ignition
More informationCPU-95 ADVANCED DIGITAL IGNITION SYSTEM FOR INDUSTRIAL ENGINES
New Backward-Compatible Enhanced CPU-95 Display Now Available CPU-95 ADVANCED DIGITAL IGNITION SYSTEM FOR INDUSTRIAL ENGINES Microprocessor-based, crankshaft referenced digital ignition system for medium-sized
More informationINSTALLATION INSTRUCTIONS
TT-07 9/0 INSTALLATION INSTRUCTIONS Original Issue Date: 9/0 Model: 7/RY, 0/RY/RZ, 0/CCE/CCZ, and 8/0/.E Generator Sets Market: Residential/Commercial and Marine Subject: Ignition Module Service Kit GM789
More informationBefore performing spark test, ensure ignitor is properly grounded.
Page 1 of 10 IGNITION CHECKS SPARK TEST NOTE: Before performing spark test, ensure ignitor is properly grounded. 1. Disconnect high tension coil wire from distributor. Hold coil wire approximately 1/2"
More informationSpring Return DuraDrive Two-Position Actuator
MA40-704x Series, MA4-707x Series, nd MA4-75x Series Spring Return DurDrive Two-Position Actutor For spring return pplictions tht require twoposition control of dmpers nd vlves in HVAC system. Fetures:
More informationENGINE CONTROL (5VZ-FE)
ENGINE CONTROL (VZ-FE) SYSTEM OUTLINE The engine control system utilizes a microcomputer and maintains overall control of the engine transmission etc. An outline of engine control is given here.. INPUT
More informationMaintenance for HV & Auxiliary Batteries
T-SB-0152-09 April 30, 2009 Service Category General Section Pre-Delivery Service Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 Prius Introduction The 2010 model year Prius hybrid
More informationAPPLICATION GUIDE For WAUKESHA VHP Series
APPLICATION GUIDE For WAUKESHA VHP Series GAS ENGINE TECHNOLOGY reliable efficient worldwide Ignition Controllers & Harnesses MIC3+CEC Ignition Controllers High energy retrofit ignition controller 1) More
More informationC147B-FRONT AXLE DISCONNECT SENSOR CIRCUIT PERFORMANCE
- D - RM 00 PICKUP - 6.7L I6 CUMMINS TURBO DIESEL C7B- DISCONNECT SENSOR CIRCUIT PERFORMNCE For a complete wiring diagram, refer to the Wiring Information. 0 0 87 87 FUSE 77 0 RELY- RUN/ STRT FUSE 0 SSEMBLY-
More information1500 SERIES LARGE CAPACITY ULTRA 2 LOW NO X
1500 SERIES LRGE CPCITY ULTR 2 LOW NO X URNER CPILITIES High release rates with moderate air pressure Good turndown with flame characteristics and direction maintained Stable flames can range from highly
More informationTOYOTA TUNDRA NEW FEATURES. The main components of the 2UZ-FE engine control system are as follows:
60 TOYOTA TUNDRA NEW FEATURES Main Components of Engine Control System ) General The main components of the 2UZ-FE engine control system are as follows: 05 Toyota Tundra 04 4Runner Component Outline Quantity
More informationINSTALLATION INSTRUCTIONS
10.570 TECHNISCHE HANDELSONDERNEMING BV INSTALLATION INSTRUCTIONS RAIL INSTALLATION AND APPLICATION MANUAL * SPARE PARTS OVERVIEW * ALTRONIC CD200 IGNITION INSTALLATION INSTRUCTIONS HATRACO IGNITION PACKAGES
More informationIntegral Ignition Coils For Shielded Applications
Integral Ignition Coils For Shielded Applications GAS ENGINE TECHNOLOGY reliable efficient worldwide Integral Ignition Coils Slim Design General Features Primary connector pole for ALTRONIC compatibility
More informationDTC P0351 Ignition Coil A Primary/Secondary Circuit. DTC P0352 Ignition Coil B Primary/Secondary Circuit
DI06 DIAGNOSTICS EINE DIAFC0 DTC P05 A Primary/Secondary Circuit DTC P05 B Primary/Secondary Circuit DTC P05 C Primary/Secondary Circuit DTC P05 D Primary/Secondary Circuit CIRCUIT DESCRIPTION A Direct
More informationDTC 14 Ignition Signal Circuit CIRCUIT DESCRIPTION
DTC 14 Ignition Signal Circuit CIRCUIT DESCRIPTION The ECM determines the ignition timing, turns on Tr 1 at a predetermined angle ( CA) before the desired ignition timing and outputs an ignition signal
More informationFuel Selector Valve- Diagnosis/Replacement
1983 Ford Truck F 250 2WD Pickup V8-460 7.5L Copyright 2007, ALLDATA 9.90 Page 1 Technical Service Bulletin # 832221 Date: 831101 Fuel Selector Valve- Diagnosis/Replacement Article No. 83-22-21 FUEL SYSTEM
More informationEngine Control COROLLA (EWD533U) B O B W B W I 7 I10. Ignition SW R W R W (A/T) (M/T) E 3 15A AM2. Junction Connector. Clutch Start SW B W B W
Engine Control O 5 M IG 6 ST 4 I 7 I0 Ignition S 5 M 6 3 IM IM I4 I IC 5 IL 8 IK 5 E 3 3 E 0 E O 3 I II 0 I5 P N 6 E 9 30 MIN 5 EFI 3 5 3 4 IG 9 ID IG II G G FL MIN. 0L 9 E 9 II 4 M 5 G (/T) G C 8 Clutch
More informationDTC B1140/32 Side Airbag Sensor Assy (RH) Malfunction
DI428 DIAGNOSTICS DI9HU01 DTC B1140/32 Side (RH) Malfunction CIRCUIT DESCRIPTION The side airbag sensor assy (RH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc.
More informationReproduction. Not for. Installation Instructions. Gearbox Replacement Kit. Part No WARNING REMOVING THE GEARBOX. Fits IS2600Z Models A B
Installation Instructions Kit ontents Part No. Qty. escription Part No. Qty. escription 5025394 5 Nut, 3/8-16 ex Nylock lange 5104533 1 earbox, Right ngle 5025396 4 Nut, 1/2-13 ex Nylock lange Part No.
More informationSECTION 2.10 IGNITION SYSTEM DESCRIPTION CEC IGNITION MODULE SYSTEM MAGNETO IGNITION SYSTEM
SECTION 2.10 SYSTEM DESCRIPTION CEC SYSTEM The Custom Engine Control (CEC) Ignition Module is located on the engine's left side (see Figure 2.10-1 and Figure 2.10-2). The CEC Ignition Module system consists
More informationHV: Cooling Fan Clutch
2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 12/10/2008 HV: Cooling Fan Clutch HV: Introduction HV1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs P0480, P0483 or P0528
More informationIG 1 1NZ-FE IGNITION IGNITION SYSTEM IGNITION SYSTEM ECM IGNITION COIL NO. 1 CAMSHAFT POSITION SENSOR SPARK PLUG CRANKSHAFT POSITION SENSOR A116185E01
NITION SYSTEM EINE 1NZ-FE PARTS LOCATION 1NZ-FE NITION NITION SYSTEM 1 ECM NITION COIL NO. 1 CAMSHAFT POSITION SENSOR SPARK PLUG CRANKSHAFT POSITION SENSOR A116185E01 2 1NZ-FE NITION NITION SYSTEM SYSTEM
More informationFX35; DTC P0300 AND IGNITION COILS BLISTERED
Classification: Reference: Date: EC11-007 ITB11-017 March 1, 2011 2003 2008 FX35; DTC P0300 AND IGNITION COILS BLISTERED APPLIED VEHICLES: 2003 2008 FX35 (S50) IF YOU CONFIRM Cylinder Misfire DTC (P0300
More informationMotronic ignition system, servicing
Page 1 of 25 28-2 Motronic ignition system, servicing Note: Motronic Engine Control Module (ECM) J220* with connector page 24-9, item 16. 1 - Highvoltage ignition cable Ignition secondary circuit Check
More informationIMPORTANCE OF PROPER SET-UP, INSTALLATION, AND PRE-DELIVERY SERVICE
IMPORTANCE OF PROPER SET-UP, INSTALLATION, AND PRE-DELIVERY SERVICE For Your Customer s Safety Proper set-up, installation and pre-delivery service are essential to the customer s safety and the reliability
More informationEND SEAL CAPS. SUPER SEAL CORPORATION 45 Seymour Street P.O. Box 394 Stratford, CT 06615
END SEL CPS SUPER SEL CPS Super Seal End Seal Caps provide wire and cable with superior environmental protection against damage and moisture. The patented material formulation provides high quality sealing
More informationFuel supply system components, removing and installing
20-1 Fuel supply system components, removing and installing Checking fuel system for leaks Removing and installing fuel filter and draining water, engine code AAZ: Repair Manual, 1.9 Liter 4-Cyl. 2V Eco-Diesel
More informationInstallation Instructions
Installation Instructions CD200D Digital Ignition System Form CD200D II 8-14 1.0 DESCRIPTION 1.1 This manual provides installation and operating instructions for the Altronic CD200D ignition system. It
More informationENGINE CONTROL (2RZ FE)
ENGINE CONTROL (RZ FE) IF (A/T) AM IG 6 FROM POER SOURCE SYSTEM (SEE PAGE 44) AM ACC IG ST IF. A STA F FUSE O. A IGN A EFI 0A OD A STOP I4 IGNITION S (A/T) (A/T) F 0 (M/T) Y Y V (A/T) IK3 (A/T) (M/T) 3
More informationYOU RE IN CONTROL WITH KENCO
YOU RE IN CONTROL WITH KENCO LUBRICATION CONTROL AND MONITORING EQUIPMENT FOR INDUSTRIAL ENGINES, GAS COMPRESSORS AND GENERATORS OIL LEVEL CONTROLLERS AND OIL LEVEL SWITCHES CONFORMING TO THE PROVISIONS
More informationELECTRONIC DASHBOARD GAUGE DROP-OUT CX, CV AND CH MODEL CHASSIS
SERVICE BULLETIN (Also applies to Mack Trucks Australia) (Supersedes bulletin SB-732-005 dated 12/10/02) NUMBER: SB-732-005 DATE: 1/13/03 MODEL: CX, CV, CH ELECTRONIC DASHBOARD GAUGE DROP-OUT CX, CV AND
More informationDTC P0327 KNOCK SENSOR 1 CIRCUIT LOW INPUT (BANK 1 OR SINGLE SENSOR) DTC P0328 KNOCK SENSOR 1 CIRCUIT HIGH INPUT (BANK 1 OR SINGLE SENSOR)
DIGNOSTICS SFI SYSTEM (MZFE) DTC P07 KNOCK SENSOR CIRCUIT LOW INPUT (NK OR SINGLE SENSOR) 0557 05MOO0 DTC P08 KNOCK SENSOR CIRCUIT HIGH INPUT (NK OR SINGLE SENSOR) DTC P0 KNOCK SENSOR CIRCUIT LOW INPUT
More informationENGINE CONTROL (5VZ-FE)
SYSTEM OUTLINE ENGINE CONTROL (Z-E) THE ENGINE CONTROL SYSTEM UTILIZES A MICROCOMPUTER AND MAINTAINS OERALL CONTROL O THE ENGINE, TRANSMISSION, ETC. AN OUTLINE O ENGINE CONTROL IS GIEN HERE.. INPUT SIGNAL
More informationThe following flow charts and schematics are courtesy of General Motors Corp. Chart No. No Malfunction Indicator Lamp (MIL)
Page 1 of 13 DIAGNOSTIC CHARTS NOTE: The following flow charts and schematics are courtesy of General Motors Corp. DIAGNOSTIC CHARTS Malfunction (1) Chart No. No Malfunction Indicator Lamp (MIL) (2) A1-1
More informationSection 6. Transformers. Table of Contents. General Purpose, Dry Type, 600 Volts and Below. Industrial Control. Instrument, 600 Volt Class
Tble of ontents Section Trnsformers Generl Purpose, Dry Type, 00 Volts nd elow Three-Phse, Energy Efficient Trnsformers -2 Single-Phse, Energy Efficient Trnsformers -2 K-Rted Trnsformers -3 Drive Isoltion
More informationDTC P0340 Camshaft Position Sensor A Circuit. DTC P0341 Camshaft Position Sensor A Circuit Range/Performance
DIAGNOSTIS EINE (2UZFE) DI637 DIDRK01 DT P0340 amshaft Position Sensor A ircuit DT P0341 amshaft Position Sensor A ircuit Range/Performance DT P0345 amshaft Position Sensor A ircuit (Bank 2) DT P0346 amshaft
More informationENGINE IMMOBILISER SYSTEM
TO INDEX 1 ENGINE IMMOILISER - ENGINE IMMOILISER SYSTEM ENGINE IMMOILISER SYSTEM ODY ND IMMOILISER ELECTRICL LOCTION STEERING COLUMN UPPER WITH SWITCH RCKET SSEMLY (IMMOILISER COIL) (NON-ROTTION SOLENOID)
More informationDescription Price Qty Picture PartNo. Horn - Electrical/Wiring A-Body Horn Relay $10.00 ea pr A-Body Horn Relay $10.
Horn - Electrical/Wiring Description Price Qty Picture PartNo 64-66 A-Body Horn Relay $10.00 ea pr015 67-69 A-Body Horn Relay $10.00 ea pr016 71-73 A-Body Horn Relay $10.00 ea pr017 70 B-Body Horn Relay
More informationInstallation Instructions
Installation Instructions CD200D Digital Ignition System Form CD200D II 4-17 1.0 DESCRIPTION 1.1 This manual provides installation and operating instructions for the Altronic CD200D ignition system. It
More informationVOLUNTARY RECALL CAMPAIGN FUEL HOSES
Reference: ITB06-006b April 4, 2006 Date: VOLUNTARY RECALL CAMPAIGN FUEL HOSES This bulletin has been amended. The Re-Assembly procedure for FX and G35 has been expanded. Please discard all previous versions
More informationDTC P1300 IGNITER CIRCUIT MALFUNCTION (NO.1) DTC P1305 IGNITER CIRCUIT MALFUNCTION (NO.2) DTC P1310 IGNITER CIRCUIT MALFUNCTION (NO.
SFI SYSTEM (ZZFE) DTC P00 IGNITER CIRCUIT MALFUNCTION (NO.) 055 057I50 DTC P05 IGNITER CIRCUIT MALFUNCTION (NO.) DTC P0 IGNITER CIRCUIT MALFUNCTION (NO.) DTC P5 IGNITER CIRCUIT MALFUNCTION (NO.4) CIRCUIT
More information1/11/2018 R.M. 2003::Diagnostics: SFI System: P1300, P1305, P1310, P1315 Igniter Circuit Malfunction (Corolla) 2003 Toyota Corolla MotoLogic
2003 Corolla DTC P1300 IGNITER CIRCUIT MALFUNCTION(NO.1) Report a problem with this article DTC P1305 IGNITER CIRCUIT MALFUNCTION(NO.2) DTC P1310 IGNITER CIRCUIT MALFUNCTION(NO.3) DTC P1315 IGNITER CIRCUIT
More informationhttps://w05.dealerconnect.chrysler.com/service/mds2002/common/jsp/xml.jsp?xmlurl=... P2149-BANK 2 (CYLINDERS 4-6) SHORTED HIGH OR LOW
Page 1 of 10 P2149-BANK 2 (CYLINDERS 4-6) SHORTED HIGH OR LOW Page 2 of 10 For a complete wiring diagram Refer to the Wiring Information. Page 3 of 10 When Monitored: While the engine is running. Set Condition:
More informationP0365-CAMSHAFT POSITION SENSOR CIRCUIT-BANK 1 SENSOR 2
8 - JS - DODGE AVENGER -.4L 4 CYL DOHC 6V DUAL V.V.T. P65-CAMSHAFT SENSOR CIRCUIT-BANK SENSOR BATT A FUSE 8 4A TOTALLY INTEGRATED POWER 7 C8 A4 RD/YL C8 FUSE TOTALLY INTEGRATED POWER 6 B4 B B RELAY-ASD/
More informationConstructionParts.com
Main assy, engine plate and lower part 18213-2 6 Main assy, engine plate and lower part Item Part No Rem Qty Description 1 D391218-01 1 Engine plate 2 Handle ( Page 60 ) 3 Ground plate and eccentric element
More informationT-Switches Range. TL Contactors TS disconnectors TP Contactors. TELARC s multipurpose DC and AC current switches for multiple application.
TP-PNORM T-Switches Range TL Contactors TS disconnectors TP Contactors TELRC s multipurpose DC and C current switches for multiple application Rolling Stock Energy generation Substation equipment Industrial
More informationSCOPELITE TIMING LIGHT OPERATING MANUAL
SCOPELITE TIMING LIGHT OPERATING MANUAL MOTORTECH Tools & Test Equipment for Ignition Systems P/N 01.10.020-EN Rev. 11/2015 Copyright Copyright 2015 MOTORTECH GmbH. All rights reserved. Distribution and
More informationP2314-IGNITION COIL 5 SECONDARY CIRCUIT - INSUFFICIENT IONIZATION - 5.7L/SRT8
- LC - DODGE CHALLENGER - 5.7L V8 HEMI MDS V.V.T. (EZH) P4-IGNITION COIL 5 SECONDARY CIRCUIT - INSUFFICIENT IONIZATION - 5.7L/SRT8 S9 IGNITION IGNITION 4 IGNITION 6 K7 DB/TN K5 DB/GY K DB/OR 9 C C COIL
More information2004 Nissan/Datsun Truck Quest Mini Van 3.5L SFI DOHC 6cyl Repair Guides Engin...
Page 1 of 10 SAVE 20% ON ONLINE SHIP-TO-HOME ORDERS OF $100 OR MORE. Use Code: MOM20 See Details Nissan Quest 2001-02 and 2004-06 REMOVAL & INSTALLATION Timing Chain Cover Removal & Installation 3.5L Engine
More information5.7L ENGINE PARTS BOOK. Not for. Reproduction
5.7L ENGINE PARTS BOOK Engine Model: Engine Family: PSI, Industrial Engine Spec N.: 39004120-39004248 Parts Book Revision: December, 2015 TABLE OF CONTENTS SECTION PAGE CYLINDER BLOCK... 3-5 CYLINDER HEAD...
More informationEngine Control for 3MZ-FE
Engine Control for MZ-FE - Y M CC IG ST - Y - R(*) 7 M IG 6 R- (*) ST I - R I Ignition S 8 IG8 - Y 7. M IG - - - R - Y - - R- E 9 C 8 C - G 0 IG - - 0 T 0 M /F 0 EFI EFI Relay C/ON Relay /F HTR Relay C
More informationEveryday Diagnostics
Page 1 of 11 Pico Technology Everyday Diagnostics Mercedes S-Class Misfire By Andy Cape, Cape Auto Diagnostics, Cape Town Vehicle details: 1995 Mercedes W140 S-Class M119 V8 Engine Background information
More informationDTC P1300 Igniter Circuit Malfunction (No.1) DTC P1305 Igniter Circuit Malfunction (No.2) DTC P1310 Igniter Circuit Malfunction (No.
DIAGNOSTICS EINE (RZFE, RZFE) DI 9 DI6 DTC P00 Igniter Circuit Malfunction (No.) DTC P05 Igniter Circuit Malfunction (No.) DTC P0 Igniter Circuit Malfunction (No.) DTC P5 Igniter Circuit Malfunction (No.)
More informationPARTS MANUAL EH17. Model. 1193P220 Rev. 11/99
PARTS MANUAL Model EH17 Note: This manual covers the original EH17 specifications. In 1998 the second series of the EH17 (EH17-2) was introduced. There are significant differences between these versions
More informationPneumatic. PVL Inline Valves. Catalogue No.
Pneumtic PVL Inline Vlves Ctlogue No. GB-c PVL High flow, compct size Push-in threded connection DIN ril block mounting Light weight construction Inline stnd lone stckble version Avilble in 2 x 3/2-5/3
More information