Origo Mig 402cw, 402c, Mig 502cw, 502c, Mig 652cw, 652c

Transcription

1 Spare parts list Edition Valid for serial no. 712, 714,715,716,725,726,743,747,748,749,751,750-xxx-xxxx Ordering no Product Notes Ser.no Origo TM Mig 402cw 400V 415V, 3~50Hz; with water cooler Origo TM Mig 402c 400V 415V, 3~50Hz Origo TM Mig 502cw 400V 415V, 3~50Hz; with water cooler Origo TM Mig 502c 400V 415V, 3~50Hz Origo TM Mig 652cw 400V 415V, 3~50Hz; with water cooler Origo TM Mig 652c 400V 415V, 3~50Hz Origo TM Mig 402cw 230V 500V, 3~50Hz, 3~60Hz; with water cooler Origo TM Mig 402c 230V 500V, 3~50Hz, 3~60Hz Origo TM Mig 502cw 230V 500V, 3~50Hz, 3~60Hz; with water cooler Origo TM Mig 502c 230V 500V, 3~50Hz, 3~60Hz Origo TM Mig 652cw 230V 500V, 3~50Hz, 3~60Hz; with water cooler Origo TM Mig 652c 230V 500V, 3~50Hz, 3~60Hz 750 Spare parts are to be ordered through the nearest ESAB agency. Kindly indicate type of unit, serial number, denominations and ordering numbers according to the spare parts list. Maintenance and repair work should be performed by an experienced person, and electrical work only by a trained electrician. Use only recommended spare parts. Rights reserved to alter specifications without notice

2 (A) = accessory C = component designation in the circuit diagram Item 402c 502c 652c Ordering no. Denomination Notes C Bottom plate Rubber sheet Cover Blind plug Blind plug only c machines Chain L=700mm Side panel Bottle shelf Clamp Shaft Plain washer Wheel Locking washer Castor wheel Side panel Panel plate Roll pin Support plate Seal Switch Q Knob Guide pin c = machines without water cooling system - 2 -

3 - 3 -

4 C = component designation in the circuit diagram Item Ordering no. Denomination Notes C Handle Valid for serial no.: xxx 8xx xxxx to xxx 9xx xxxx, xxx 0xx xxxx to xxx 110 xxxx Right corner Valid for serial no.: xxx 8xx xxxx to xxx 9xx xxxx, xxx 0xx xxxx to xxx 110 xxxx Left corner Valid for serial no.: xxx 8xx xxxx to xxx 9xx xxxx, xxx 0xx xxxx to xxx 110 xxxx Handle Valid from serial no.: xxx 111 xxxx Cover right Valid from serial no.: xxx 111 xxxx Bracket right Valid from serial no.: xxx 111 xxxx Base right Valid from serial no.: xxx 111 xxxx Reduction insert Valid from serial no.: xxx 111 xxxx Cover left Valid from serial no.: xxx 111 xxxx Bracket left Valid from serial no.: xxx 111 xxxx Base left Valid from serial no.: xxx 111 xxxx Lower front plate Front panel Grill Knob Potentiometer P Signal lamp White, 48V H Indicating lamp Orange, 24V H1, H Socket burndy X01-4 -

5 - 5 -

6 Item 402c 502c 652c Ordering no. Denomination Notes C Protection frame Panel cpl Panel cpl Label MMC Panel M Label MMC Panel A Plate Shield Spacer Capacitor cpl Knob Knob Potentiometer R02, R Rotary switch S Potentiometer R01-6 -

7 - 7 -

8 Item Ordering no. Denomination Notes C Rear panel Radiator only cw machines Fan mantle Fan M Pump bracket only cw machines Pump only cw machines M Water tank only cw machines Sealing only cw machines Cover only cw machines Cable inlet Connection 8 pol. X Terminal X Capacitor 6uF C Capacitor 3uF C OKC contact Quick connector Blue, only cw machines Quick connector Red, only cw machines cw = machines with water cooling system - 8 -

9 - 9 -

10 Item 402c 502c 652c Ordering no. Denomination Notes C Shelf Intermediate plate Chopper 400 V Chopper 500 V Chopper 600 V SCOMES SEMIKRON Thermal switch Valid up to serial no xxx 145 xxxx B Transformer sv machines TC Transformer mv machines TC Contactor sv machines K Contactor sv machines K Contactor mv machines K Contactor mv machines K Contactor mv machines K Contactor K2, K Bracket PC board mains filter K Connection block 9 pol., > 1 piece for sv machines X Connection block XT Connection block 9 pol., > 2 pieces for mv machines X Rectifier bridge VB Resistor R Resistor R Electronics board CH Electronics board CH Electronics board CH Electronics board CH Shield sv = V mv = V

11 - 11 -

12 Item 402c 502c 652c Ordering no. Denomination Notes C Transformer sv machines TR Transformer mv machines TR Transformer sv machines TR Transformer mv machines TR Transformer sv machines TR Transformer mv machines TR Inductor L Inductor L Shunt RB OKC connector sv = V mv = V

13 NOTES notes

14 paut