DATA COMPENDIUM FAULT MESSAGES TRUCKNOLOGY GENERATION. SD 812a en-online Page 1 of 276

Transcription

1 DATA COMPENDIUM FAULT MESSAGES TRUCKNOLOGY GENERATION SD 812a en-online Page 1 of 276

2 For notes on setting or repairing the individual systems please see the repair manuals or the relevant Service Information sheets. After completing repairs delete the fault memory. The last page folds out; on the inside you will find the FMI code and its meaning. The SPN for the door module driver's and co-driver's side can be read out only with MAN-cats II; the SPN is not shown in the display. If one SPN refers to the same fault/component in several control units/systems, only the generic term of the system is given. Example: "03512 EBS OBD, request, red warning lamp for diagnosis": this SPN applies to all EBS variants although they are not all expressly named (EBS2, EBS5 etc.) Ifo ne SPN refers to different fauls/components in several control units/systems each relevant variant is named. Example: EDC (Common Rail) fuel pressure sensor rail pressure EDC (no Common Rail) fuel pressure sensor This SD supersedes SD MAN Nutzfahrzeuge Aktiengesellschaft VAST, mr SD 812a en-online Page 2 of 276

3 Main instrument Message in display Message via check lamp panels SD 812a en-online Page 3 of 276

4 Display Text in display ABS in trailer ABS in trailer, failure ABS in tractor, failure CAN network failure ASR failure Check lamp panel LED Buz- zer- yellow yellow yellow yellow yellow yes yes yes yes yes Remarks Line to trailer ABS to earth, fault in trailer ABS or trailer ABS speed sensor test Power supply to trailer ABS is not between 100mA and 2A ABS function is restricted Reaction stored in instrument Connection to engine control unit disrupted EBS failure red yes EBS not on CAN Reservoir pressure too low red yes Reservoir pressure K1 red yes Pressure is below warning pressure ECAM substitute function in ZBR Reservoir pressure K2 red yes Reservoir pressure K3 red yes Reservoir pressure implausible, shown only with ECAM Reservoir pressure K4 red yes SD 812a en-online Page 4 of 276

5 Display Text in display Check lamp panel LED Buz- zer- Reservoir pressure K1 too low red yes Reservoir pressure K2 too low red yes Reservoir pressure K3 too low red yes Reservoir pressure K4 too low red yes Remarks Pressure below warning pressure or ECAM substitute function in ZBR or short-circuit/interruption in sensor/sensor cable or pressure constantly below reservoir pressure ECAM failure red yes ECAM not on CAN Fault in trailer brake red yes CAN brake, tractor to trailer CAN network failure red yes Reaction saved in instruments Brake pads/linings warn red yes INFO Not driving level yellow yes No valid ride level set ECAS failure red yes ECAS not on CAN Lock cab! red yes Tipper operation red yes At least one of switching contacts for cab lock is open Cable from tipper switch contact to earth SD 812a en-online Page 5 of 276

6 Display Text in display Check lamp panel LED Lock liftgate red yes Gas filter contaminated red yes Remarks Cable from liftgate switch to High Potential Comfort Shift defective red yes Comfort Shift cannot be used Reservoir pressure do not shift red yes No reservoir pressure on gearbox Gearbox temp. too high red yes Gearbox temp. much too high Buz- zer- Change air filter yellow yes Oil pressure too low red yes Oil pressure too high red yes Coolant level too low red yes Cooling system red yes Cooling system switch off engine Coolant temp. too high red yes SD 812a en-online Page 6 of 276 Partial vacuum has exceeded limit Gradient for coolant > 102 C too high red yes To EDC anti-boiling feature Engine speed too high red yes EDC speed monitoring Engine brake failure red yes EGR valve above/below position

7 Display Text in display Check lamp panel LED Buz- zer- Engine oil temp. too high red yes Remarks ESP failure yellow yes ESP no oncan or CAN message with ESP contents is missing ESP failure - No text - No text - No text - No text yellow FDR function is restricted or not present yellow yellow yellow yellow - No text red no yes no yes yes no ABS switch-off or ABS OFFROAD Reaction in instrument saved on CAN in event of failure Reaction in instrument saved on CAN in event of failure No ABS on trailer Comes on when ignition is switched on, remains on after bulb test, - No text red no Cable for belt check is on earth - No text yellow no ASR intervention (LED comes on) or ASR OFFROAD (LED flashes) SD 812a en-online Page 7 of 276

8 Display Text in display Check lamp panel LED Remarks - No text grün no Flasher check for trailer - No text no ESP (FDR) interventions - No text blau no High beam function check - No text red no Parking brake function check - No text - No text Overload on rear axle or overload on front axle Buz- zer- yellow yellow yellow no no - - yes Level not reached - - yes Flame start function check Ride level implausible or cannot be set by ECAS TCO failure - - yes EU tachograph not on CAN Check TCO - - yes EU tachograph not in order. Brake lights without function - - yes Brake light signal failure on CAN SD 812a en-online Page 8 of 276

9 Display Text in display Check lamp panel LED Buz- zer- Tractor brake lights failure - - yes Trailer brake lights failure - - yes Trailer flashers rh failure or Trailer flashers lh failure Tractor flashers rh failure or Tractor flashers lh failure - - yes - - yes Clear lighting monitoring - - no Remarks Lamp defective short-circuit, cable interrupted Lamp defective short-circuit, cable interrupted Failure of flasher lamp, or lamp load out of tolerance Block lighting monitoring - - no Flasher test - - no Light test - - no Light test aborted - - no Light test again - - no End of light test - - no SD 812a en-online Page 9 of 276

10 Display Text in display SD 812a en-online Page 10 of 276 Check lamp panel LED Buz- zer- New trailer, learn light test - - no High beam rh failure or high beam lh failure - - yes Remarks Add. headlight failure - - yes Relay for add. high beam (roof) Add. headlight lh failure or Add. headlight rh failure Foglamp lh failure or Foglamp rh failure Rear foglamp failure on tractor rear foglamp failure on trailer Fault in lh side marker lights or fault in rh side marker lights - - yes - - yes - - yes - - yes Failure of at least one side marker light on tractor Parking lights failure - - yes Relay for parking lights (ZBR output) Trailer parking lights lh failure or trailer parking lights rh failure Tractor parking lights lh failure or tractor parking lights rh failure - - yes - - yes Winter service lighting failure - - yes Relay for winter service cannot be triggered

11 Display Text in display Check lamp panel LED Buz- zer- Remarks Switch defective - foglamps - - yes Switch defective low beam - - yes Switch defective high beam - - yes Switch defective headlight flash - - yes Switch defective parking lights - - yes Brake pad/lining wear - yellow yes Parking brake display defective - - yes Apply parking brake - - yes Limit of wear reached in at least one brake lining/pad Parking brake display not possible, as CAN signal not available Pre-glow - - yes Refers to pre-glow period Pre-glow again - - yes Shows that readiness for starting has expired, pre-glow must be repeated Start engine - - yes Refers to readiness for starting SD 812a en-online Page 11 of 276

12 Display Text in display Check lamp panel LED Buz- zer- Flammstart Ausfall - - yes Remarks Danger black ice - - yes Refers to black ice Clutch lining worn - - yes Limit of wear for clutch lining Clutch overloaded shift down - - yes Load too high during moving off Actuate clutch - - yes Clutch did not open during shifting Clutch oil level too low - - yes Clutch fluid level too low Alternator display defective - - yes When ignition is on cable from terminal L is not on earth Alternator failure - - yes Terminal L is on earth and engine running Charge voltage too low - - yes Charge voltage constantly too low Tension V-belts - - yes Charge voltage too high - - yes Battery undervoltage - - yes Switch defective warning flashers SD 812a en-online Page 12 of yes At rated speed (engine) charge voltage is too high Battery undervoltage after standing too long

13 Display Text in display Check lamp panel LED Buz- zer- Service due - - yes Remarks TBM failure - - yes TBM not on CAN Apply parking brake - - yes Tells you to apply parking brake Engage neutral - - yes Tells you to shift gearbox to neutral SET xxkm/h - - no MEMO xxkm/h - - no LIMIT - - no Info! Fault or grease fault in central lube - - yes EDC failure - - yes EDC not on CAN Boost pressure sensor defective - - yes Boost pressure cannot be measured correctly No text - - no Engine brake (in vehicles without retarder) FFR failure - - yes FFR not on CAN LGS failure - - yes LGS not on CAN SD 812a en-online Page 13 of 276

14 Display Text in display Check lamp panel LED Buz- zer- Remarks KSM failure - - yes KSM not on CAN No text - - no Engine brake (in vehicles with retarder) RET P failure - - yes Primary retarder (water pump) not on CAN RET S failure - - yes Secondary retarder not on CAN Retarder temp. too high - - yes SD 812a en-online Page 14 of 276 Oil temperature at retarder outlet too high (advance warning) Retarder temp. too high - - yes Retarder temp. much too high No text - - no CAN Verbund Ausfall - - yes Low beam lh failure or low beam rh failure Headlight height lh failure autom. - - yes Headlight height rh failure autom. - - yes T-CAN BusOff, Reaction saved in instruments - - yes Low beam lh on tractor Automatic beam regulator implausible on lh side Automatic beam regulator implausible on rh side Steering oil level fault - - yes Oil level too low

15 Display Text in display Check lamp panel LED Buz- zer- Steering oil pressure too low - - yes Remarks Switch for flow meter in emerg. steering pump is closed TCU failure - - yes Automatic gearbox not on CAN Comfort Shift defective - - yes Engage higher gear - - yes Comfort Shift button is not being evaluated Speed difference between engine and gearbox too high No idle gas - - yes Tells you to take foot off accelerator Gearbox temp. too high - - yes Temperature in gearbox oil sump (advance warning) Fill tank - - yes Tank on reserve Tank pickup failure - - yes Monitoring of tank pickup 1 in ZBR Tank pickup 2 failure - - yes Monitoring of tank pickup 2 in ZBR Coolant level too low - - yes Coolant level below min. No text - - no No text - - no Function feedback from rear foglamp SD 812a en-online Page 15 of 276

16 Display Text in display Check lamp panel LED Buz- zer- No text - - no No text - - no No text - - no Remarks Display message for moving-off aid ECAS Nordland or ECAS EFR Nordland SD 812a en-online Page 16 of 276

17 Abbreviations Adaptive Cruise Control... ACC Exhaust-gas recirculation... EGR Arithmetic Logic Unit... ALU AS-Tronic... AST Service brake valve...bbv Belt tensioner... BT Control unit network... CAN Cruise Control Vehicle Speed... CCVS Continuously Regenerating Trap (catalytic converter)...crt Comfort Shift... CS Butterfly valve stipulation (adjustment angle)...dkv Diagnostic message... DM Drive Neutral Reverse (selector lever/switches for autom. gearbox) DNR Pressure before radiator... DvK Speed pickup... DZG Electronic Brake System...EBS Electronically Controlled Air Management...ECAM Electronically Controlled Air Suspension (applies to trucks and afterbody of articulated buses)... ECAS Electronically Controlled Air Suspension (applies to forebody of articulated buses)... ECAS2 Eelctronic control unit... ECU Electronic Diesel Control... EDC Final speed control... EDR Electronic Engine Controller...EEC Electrically programmable non-volatile read-only memory... EEPROM Exhaust gas recirculation... EGR Electrohydraulic steering system...ehla AS-Tronic lite... EMOS End of Line programming...eol Electronic Transmission Control...ETC Exhaust Valve Brake...EVB Ride dynamics control...fdr Vehicle management computer... FFR Road speed limiter...fgb Road speed control... FGR SD 812a en-online Page 17 of 276

18 Failure mode identification (fault type)...fmi Closed-loop diesel catalyst... GDK Behr air-conditioner control... GKR Urea metering system... HDS Hydraulic front axle drive (HydroDrive)...HVA Auxiliary speed pickup... HZG Integrated circuit... IC CAN-connection between the two processors in main instrument...icom Identification... ID Instrument...INST Intarder... INT Customer-specific module... KSM Message from customer-specific module...ksma Temperature sensor... KTY Data transfer protocol MAN-cats II...KWP2000 Lane Guard System...LGS Local Identifier... LID Idling speed... LLR Microprocessor... µc Delivery control rack... MES Modular door control... MTS On-board diagnostic unit...obdu Parameter group number... PGN Pulse width modulation... PWM Rear Axle Steering...RAS Central tyre inflation system...rdra Secondary retarder...ret-s Primary retarder...ret-p Ship vehicle management computer...sffr Side marker light...sml Suspect Parameter Number...SPN Headlight cleaning system...swr Telematic Board Module... TBM EU tachograph... TCO Gearbox control unit...tcu Torque speed control (brake torque)...tsc Central on-board computer...zbr Intermediate speed control...zdr SD 812a en-online Page 18 of 276

19 FMI Definition - No fault - Fault saved - Intermittent fault - Fault is present and saved 0 Fault not specified 1 Too high 2 Too low 3 Implausible 4 No signal present 5 Short-circuit to earth 6 Short-circuit to UBatt. 7 Short-circuit 8 Fault signal 9 Fault in component 10 Interruption 11 Not defined 12 Not defined 13 Not defined 14 Not defined 15 Not defined SD 812a en-online Page 19 of 276

20 00000 MTS Base module AB Date, time, mileage in km ACC Date, time, mileage in km AST Date, time, mileage in km ASTMID Date, time, mileage in km BHTC Date, time, mileage in km CNG_ME7 Date, time, mileage in km CRT Date, time, mileage in km DIW5 Date, time, mileage in km EBS Date, time, mileage in km EBS_5 Date, time, mileage in km EBS_K1 Date, time, mileage in km ECAM Date, time, mileage in km ECAS_4X2 Date, time, mileage in km ECAS2_GBV Date, time, mileage in km ECAS2_GBW Date, time, mileage in km ECO2 Date, time, mileage in km EDC Date, time, mileage in km EDC_7 Date, time, mileage in km EDC_7_M Date, time, mileage in km EDC_7_MASTER Date, time, mileage in km EDC_7_S Date, time, mileage in km EDC_7_SLAVE Date, time, mileage in km EDC6 Date, time, mileage in km EDC64 Date, time, mileage in km EDC7 Date, time, mileage in km EDC7_6 Date, time, mileage in km EDC7C32 Date, time, mileage in km EDC7C32_6 Date, time, mileage in km EDC7C32_M Date, time, mileage in km EDC7C32_S Date, time, mileage in km EDC7C32M_10 Date, time, mileage in km EDC7C32M_12 Date, time, mileage in km EDC7C32S_10 Date, time, mileage in km EDC7C32S_12 Date, time, mileage in km EDC7M_10 Date, time, mileage in km EDC7M_12 Date, time, mileage in km EDC7S_10 Date, time, mileage in km EDC7S_12 Date, time, mileage in km EHLA Date, time, mileage in km EMOS Date, time, mileage in km FFR Date, time, mileage in km GKR Date, time, mileage in km HDS Date, time, mileage in km HEITZ Date, time, mileage in km HVA Date, time, mileage in km HYD Date, time, mileage in km INST Date, time, mileage in km INT Date, time, mileage in km KR49X Date, time, mileage in km KSM Date, time, mileage in km LGS Date, time, mileage in km MTS Expansion module door OBDU Date, time, mileage in km OUZBRO Road speed OUZBRO_R Date, time, mileage in km PTM Date, time, mileage in km RAS Date, time, mileage in km RET Date, time, mileage in km SFFR Date, time, mileage in km SD 812a en-online Page 20 of 276

21 00001 SKG Date, time, mileage in km STON Date, time, mileage in km T509C Date, time, mileage in km TBM Date, time, mileage in km Test1Module Date, time, mileage in km Test2Module Date, time, mileage in km TPM Date, time, mileage in km TRON Date, time, mileage in km TRW Date, time, mileage in km TUER_DR Date, time, mileage in km TUER_PA Date, time, mileage in km UHV Date, time, mileage in km VRET Date, time, mileage in km VSM Date, time, mileage in km WSK Date, time, mileage in km ZBR2 Date, time, mileage in km ZBRO Date, time, mileage in km ZBRO_R Date, time, mileage in km ZFR Date, time, mileage in km ZH_AT3500_1580 Date, time, mileage in km ZH_AT3500_ST Date, time, mileage in km ZH_D5W_SC Date, time, mileage in km ZHZG_9a Date, time, mileage in km ZHZG_9c Date, time, mileage in km MTS Expansion module door OUZBRO Engine revs MTS Expansion module door OUZBRO Oil pressure MTS Expansion module door OUZBRO Reservoir pressure brake circuit MTS Motor/door valve door 1 (front) OUZBRO Reservoir pressure brake circuit MTS Motor/door valve door 1 (rear) OUZBRO Brake pressure brake circuit MTS Motor/door valve door 2 (front) OUZBRO Brake pressure brake circuit MTS Motor/door valve door 1 (rear) OUZBRO Accelerator pedal position MTS Motor/door valve door 3 (front) OUZBRO Preselected gear MTS Motor/door valve door 3 (rear) OUZBRO Engaged gear MTS Motor/door valve door 4 (front) OUZBRO Cooling water temperature MTS Motor/door valve door 4 (rear) OUZBRO Tank fill level MTS Motor/door valve door 5 (front) OUZBRO Reservoir pressure brake circuit MTS Motor/door valve door 5 (rear) OUZBRO Reservoir pressure brake circuit MTS Entry lighting door OUZBRO On-board voltage MTS Entry lighting door MTS Entry lighting door MTS Entry lighting door MTS Entry lighting door MTS Door closing warning device door MTS Door closing warning device door MTS Door closing warning device door MTS Door closing warning device door 4 SD 812a en-online Page 21 of 276

22 00024 MTS Door closing warning device door MTS Ramp activation door MTS Ramp activation door MTS Ramp activation door MTS Ramp activation door MTS Ramp activation door MTS Stop request display door MTS Stop request display door AB Split position ACC Split position AST Split position ASTMID Split position BHTC Split position CNG_ME7 Split position CRT Split position DIW5 Split position EBS Split position EBS_5 Split position EBS_K1 Split position ECAM Split position ECAS_4X2 Split position ECAS2_GBV Split position ECAS2_GBW Split position ECO2 Split position EDC Split position EDC_7 Split position EDC_7_M Split position EDC_7_MASTER Split position EDC_7_S Split position EDC_7_SLAVE Split position EDC6 Split position EDC64 Split position EDC7 Split position EDC7_6 Split position EDC7C32 Split position EDC7C32_6 Split position EDC7C32_M Split position EDC7C32_S Split position EDC7C32M_10 Split position EDC7C32M_12 Split position EDC7C32S_10 Split position EDC7C32S_12 Split position EDC7M_10 Split position EDC7M_12 Split position EDC7S_10 Split position EDC7S_12 Split position EHLA Split position EMOS Split position FFR Split position GKR Split position HDS Split position HEITZ Split position HVA Split position HYD Split position INST Split position INT Split position KR49X Split position KSM Split position LGS Split position MTS Stop request display door 3 SD 812a en-online Page 22 of 276

23 00032 OBDU Split position OUZBRO Split position OUZBRO_R Split position PTM Split position RAS Split position RET Split position SFFR Split position SKG Split position STON Split position T509C Split position TBM Split position Test1Module Split position Test2Module Split position TPM Split position TRON Split position TRW Split position TUER_DR Split position TUER_PA Split position UHV Split position VRET Split position VSM Split position WSK Split position ZBR2 Split position ZBRO Split position ZBRO_R Split position ZFR Split position ZH_AT3500_1580 Split position ZH_AT3500_ST Split position ZH_D5W_SC Split position ZHZG_9a Split position ZHZG_9c Split position AB Clutch travel sensor ACC Clutch travel sensor AST Clutch travel sensor ASTMID Clutch travel sensor BHTC Clutch travel sensor CNG_ME7 Clutch travel sensor CRT Clutch travel sensor DIW5 Clutch travel sensor EBS Clutch travel sensor EBS_5 Clutch travel sensor EBS_K1 Clutch travel sensor ECAM Clutch travel sensor ECAS_4X2 Clutch travel sensor ECAS2_GBV Clutch travel sensor ECAS2_GBW Clutch travel sensor ECO2 Clutch travel sensor EDC Clutch travel sensor EDC_7 Clutch travel sensor EDC_7_M Clutch travel sensor EDC_7_MASTER Clutch travel sensor EDC_7_S Clutch travel sensor EDC_7_SLAVE Clutch travel sensor EDC6 Clutch travel sensor EDC64 Clutch travel sensor EDC7 Clutch travel sensor EDC7_6 Clutch travel sensor EDC7C32 Clutch travel sensor EDC7C32_6 Clutch travel sensor EDC7C32_M Clutch travel sensor SD 812a en-online Page 23 of 276

24 00033 EDC7C32_S Clutch travel sensor EDC7C32M_10 Clutch travel sensor EDC7C32M_12 Clutch travel sensor EDC7C32S_10 Clutch travel sensor EDC7C32S_12 Clutch travel sensor EDC7M_10 Clutch travel sensor EDC7M_12 Clutch travel sensor EDC7S_10 Clutch travel sensor EDC7S_12 Clutch travel sensor EHLA Clutch travel sensor EMOS Clutch travel sensor FFR Clutch travel sensor GKR Clutch travel sensor HDS Clutch travel sensor HEITZ Clutch travel sensor HVA Clutch travel sensor HYD Clutch travel sensor INST Clutch travel sensor INT Clutch travel sensor KR49X Clutch travel sensor KSM Clutch travel sensor LGS Clutch travel sensor MTS Stop request display door OBDU Clutch travel sensor OUZBRO Clutch travel sensor OUZBRO_R Clutch travel sensor PTM Clutch travel sensor RAS Clutch travel sensor RET Clutch travel sensor SFFR Clutch travel sensor SKG Clutch travel sensor STON Clutch travel sensor T509C Clutch travel sensor TBM Clutch travel sensor Test1Module Clutch travel sensor Test2Module Clutch travel sensor TPM Clutch travel sensor TRON Clutch travel sensor TRW Clutch travel sensor TUER_DR Clutch travel sensor TUER_PA Clutch travel sensor UHV Clutch travel sensor VRET Clutch travel sensor VSM Clutch travel sensor WSK Clutch travel sensor ZBR2 Clutch travel sensor ZBRO Clutch travel sensor ZBRO_R Clutch travel sensor ZFR Clutch travel sensor ZH_AT3500_1580 Clutch travel sensor ZH_AT3500_ST Clutch travel sensor ZH_D5W_SC Clutch travel sensor ZHZG_9a Clutch travel sensor ZHZG_9c Clutch travel sensor MTS Stop request display door MTS Door enable display door MTS Door enable display door MTS Door enable display door AB Fuel fill level ACC Fuel fill level 2 SD 812a en-online Page 24 of 276

25 00038 AST Fuel fill level ASTMID Fuel fill level BHTC Fuel fill level CNG_ME7 Fuel fill level CRT Fuel fill level DIW5 Fuel fill level EBS Fuel fill level EBS_5 Fuel fill level EBS_K1 Fuel fill level ECAM Fuel fill level ECAS_4X2 Fuel fill level ECAS2_GBV Fuel fill level ECAS2_GBW Fuel fill level ECO2 Fuel fill level EDC Fuel fill level EDC_7 Fuel fill level EDC_7_M Fuel fill level EDC_7_MASTER Fuel fill level EDC_7_S Fuel fill level EDC_7_SLAVE Fuel fill level EDC6 Fuel fill level EDC64 Fuel fill level EDC7 Fuel fill level EDC7_6 Fuel fill level EDC7C32 Fuel fill level EDC7C32_6 Fuel fill level EDC7C32_M Fuel fill level EDC7C32_S Fuel fill level EDC7C32M_10 Fuel fill level EDC7C32M_12 Fuel fill level EDC7C32S_10 Fuel fill level EDC7C32S_12 Fuel fill level EDC7M_10 Fuel fill level EDC7M_12 Fuel fill level EDC7S_10 Fuel fill level EDC7S_12 Fuel fill level EHLA Fuel fill level EMOS Fuel fill level FFR Fuel fill level GKR Fuel fill level HDS Fuel fill level HEITZ Fuel fill level HVA Fuel fill level HYD Fuel fill level INST Fuel fill level INT Fuel fill level KR49X Fuel fill level KSM Fuel fill level LGS Fuel fill level MTS Door enable display door OBDU Fuel fill level OUZBRO Fuel fill level OUZBRO_R Fuel fill level PTM Fuel fill level RAS Fuel fill level RET Fuel fill level SFFR Fuel fill level SKG Fuel fill level STON Fuel fill level T509C Fuel fill level 2 SD 812a en-online Page 25 of 276

26 00038 TBM Fuel fill level Test1Module Fuel fill level Test2Module Fuel fill level TPM Fuel fill level TRON Fuel fill level TRW Fuel fill level TUER_DR Fuel fill level TUER_PA Fuel fill level UHV Fuel fill level VRET Fuel fill level VSM Fuel fill level WSK Fuel fill level ZBR2 Second Fuel Level (Right Side) ZBRO Fuel fill level ZBRO_R Fuel fill level ZFR Fuel fill level ZH_AT3500_1580 Fuel fill level ZH_AT3500_ST Fuel fill level ZH_D5W_SC Fuel fill level ZHZG_9a Fuel fill level ZHZG_9c Fuel fill level MTS Door enable display door MTS Workshop switch door MTS Workshop switch door MTS Workshop switch door MTS Workshop switch door MTS Workshop switch door MTS Pressure shaft door EMOS Cruise control nominal speed MTS Pressure shaft door MTS Pressure shaft door MTS Pressure shaft door MTS Pressure shaft door MTS Stop request button door CNG_ME7 Throttle butterfly MTS Stop request button door MTS Stop request button door MTS Stop request button door MTS Stop request button door MTS Baby carriage button door MTS Baby carriage button door MTS Baby carriage button door MTS Baby carriage button door MTS Baby carriage button door MTS Limit switch CLOSED door 1 (front) MTS Limit switch CLOSED door 1 (rear) MTS Limit switch CLOSED door 2 (front) MTS Limit switch CLOSED door 2 (rear) MTS Limit switch CLOSED door 3 (front) MTS Limit switch CLOSED door 3 (rear) MTS Limit switch CLOSED door 4 (front) MTS Limit switch CLOSED door 4 (rear) MTS Limit switch CLOSED door 5 (front) MTS Limit switch CLOSED door 5 (rear) MTS Pressure monitoring door OBDU Parking brake applied ZBR2 No 'parking brake' signal MTS Pressure monitoring door MTS Pressure monitoring door MTS Pressure monitoring door 4 SD 812a en-online Page 26 of 276

27 00074 AB Lamp, road speed limiting ACC Lamp, road speed limiting AST Lamp, road speed limiting ASTMID Lamp, road speed limiting BHTC Lamp, road speed limiting CNG_ME7 Lamp, road speed limiting CRT Lamp, road speed limiting DIW5 Lamp, road speed limiting EBS Lamp, road speed limiting EBS_5 Lamp, road speed limiting EBS_K1 Lamp, road speed limiting ECAM Lamp, road speed limiting ECAS_4X2 Lamp, road speed limiting ECAS2_GBV Lamp, road speed limiting ECAS2_GBW Lamp, road speed limiting ECO2 Lamp, road speed limiting EDC Lamp, road speed limiting EDC_7 Lamp, road speed limiting EDC_7_M Lamp, road speed limiting EDC_7_MASTER Lamp, road speed limiting EDC_7_S Lamp, road speed limiting EDC_7_SLAVE Lamp, road speed limiting EDC6 Lamp, road speed limiting EDC64 Lamp, road speed limiting EDC7 Lamp, road speed limiting EDC7_6 Lamp, road speed limiting EDC7C32 Lamp, road speed limiting EDC7C32_6 Lamp, road speed limiting EDC7C32_M Lamp, road speed limiting EDC7C32_S Lamp, road speed limiting EDC7C32M_10 Lamp, road speed limiting EDC7C32M_12 Lamp, road speed limiting EDC7C32S_10 Lamp, road speed limiting EDC7C32S_12 Lamp, road speed limiting EDC7M_10 Lamp, road speed limiting EDC7M_12 Lamp, road speed limiting EDC7S_10 Lamp, road speed limiting EDC7S_12 Lamp, road speed limiting EHLA Lamp, road speed limiting EMOS Lamp, road speed limiting FFR Lamp, road speed limiting GKR Lamp, road speed limiting HDS Lamp, road speed limiting HEITZ Lamp, road speed limiting HVA Lamp, road speed limiting HYD Lamp, road speed limiting INST Lamp, road speed limiting INT Lamp, road speed limiting KR49X Lamp, road speed limiting KSM Lamp, road speed limiting LGS Lamp, road speed limiting MTS Pressure monitoring door OBDU Lamp, road speed limiting OUZBRO Lamp, road speed limiting OUZBRO_R Lamp, road speed limiting PTM Lamp, road speed limiting RAS Lamp, road speed limiting RET Lamp, road speed limiting SFFR Lamp, road speed limiting SKG Lamp, road speed limiting SD 812a en-online Page 27 of 276

28 00074 STON Lamp, road speed limiting T509C Lamp, road speed limiting TBM Lamp, road speed limiting Test1Module Lamp, road speed limiting Test2Module Lamp, road speed limiting TPM Lamp, road speed limiting TRON Lamp, road speed limiting TRW Lamp, road speed limiting TUER_DR Lamp, road speed limiting TUER_PA Lamp, road speed limiting UHV Lamp, road speed limiting VRET Lamp, road speed limiting VSM Lamp, road speed limiting WSK Lamp, road speed limiting ZBR2 Lamp, road speed limiting ZBRO Lamp, road speed limiting ZBRO_R Lamp, road speed limiting ZFR Lamp, road speed limiting ZH_AT3500_1580 Lamp, road speed limiting ZH_AT3500_ST Lamp, road speed limiting ZH_D5W_SC Lamp, road speed limiting ZHZG_9a Lamp, road speed limiting ZHZG_9c Lamp, road speed limiting AB Steering axle temperature ACC Steering axle temperature AST Steering axle temperature ASTMID Steering axle temperature BHTC Steering axle temperature CNG_ME7 Steering axle temperature CRT Steering axle temperature DIW5 Steering axle temperature EBS Steering axle temperature EBS_5 Steering axle temperature EBS_K1 Steering axle temperature ECAM Steering axle temperature ECAS_4X2 Steering axle temperature ECAS2_GBV Steering axle temperature ECAS2_GBW Steering axle temperature ECO2 Steering axle temperature EDC Steering axle temperature EDC_7 Steering axle temperature EDC_7_M Steering axle temperature EDC_7_MASTER Steering axle temperature EDC_7_S Steering axle temperature EDC_7_SLAVE Steering axle temperature EDC6 Steering axle temperature EDC64 Steering axle temperature EDC7 Steering axle temperature EDC7_6 Steering axle temperature EDC7C32 Steering axle temperature EDC7C32_6 Steering axle temperature EDC7C32_M Steering axle temperature EDC7C32_S Steering axle temperature EDC7C32M_10 Steering axle temperature EDC7C32M_12 Steering axle temperature EDC7C32S_10 Steering axle temperature EDC7C32S_12 Steering axle temperature EDC7M_10 Steering axle temperature EDC7M_12 Steering axle temperature EDC7S_10 Steering axle temperature SD 812a en-online Page 28 of 276

29 00075 EDC7S_12 Steering axle temperature EHLA Steering axle temperature EMOS Steering axle temperature FFR Steering axle temperature GKR Steering axle temperature HDS Steering axle temperature HEITZ Steering axle temperature HVA Steering axle temperature HYD Steering axle temperature INST Steering axle temperature INT Steering axle temperature KR49X Steering axle temperature KSM Steering axle temperature LGS Steering axle temperature MTS Reference voltage door sensors door OBDU Steering axle temperature OUZBRO Steering axle temperature OUZBRO_R Steering axle temperature PTM Steering axle temperature RAS Steering axle temperature RET Steering axle temperature SFFR Steering axle temperature SKG Steering axle temperature STON Steering axle temperature T509C Steering axle temperature TBM Steering axle temperature Test1Module Steering axle temperature Test2Module Steering axle temperature TPM Steering axle temperature TRON Steering axle temperature TRW Steering axle temperature TUER_DR Steering axle temperature TUER_PA Steering axle temperature UHV Steering axle temperature VRET Steering axle temperature VSM Steering axle temperature WSK Steering axle temperature ZBR2 Steering axle temperature ZBRO Steering axle temperature ZBRO_R Steering axle temperature ZFR Steering axle temperature ZH_AT3500_1580 Steering axle temperature ZH_AT3500_ST Steering axle temperature ZH_D5W_SC Steering axle temperature ZHZG_9a Steering axle temperature ZHZG_9c Steering axle temperature MTS Reference voltage door sensors door MTS Reference voltage door sensors door MTS Reference voltage door sensors door MTS Reference voltage door sensors door MTS Door sensor door 1 front EDC7 Exhaust gas differential or exhaust gas relative pressure MTS Door sensor door 1 rear MTS Door sensor door 2 front MTS Door sensor door 2 rear AB wheel-based vehicle speed ACC wheel-based vehicle speed AST wheel-based vehicle speed ASTMID wheel-based vehicle speed BHTC wheel-based vehicle speed SD 812a en-online Page 29 of 276

30 00084 CNG_ME7 wheel-based vehicle speed CRT wheel-based vehicle speed DIW5 wheel-based vehicle speed EBS wheel-based vehicle speed EBS_5 wheel-based vehicle speed EBS_K1 wheel-based vehicle speed ECAM wheel-based vehicle speed ECAS_4X2 wheel-based vehicle speed ECAS2_GBV wheel-based vehicle speed ECAS2_GBW wheel-based vehicle speed ECO2 wheel-based vehicle speed EDC wheel-based vehicle speed EDC_7 wheel-based vehicle speed EDC_7_M wheel-based vehicle speed EDC_7_MASTER wheel-based vehicle speed EDC_7_S wheel-based vehicle speed EDC_7_SLAVE wheel-based vehicle speed EDC6 wheel-based vehicle speed EDC64 wheel-based vehicle speed EDC7 wheel-based vehicle speed EDC7_6 wheel-based vehicle speed EDC7C32 wheel-based vehicle speed EDC7C32_6 wheel-based vehicle speed EDC7C32_M wheel-based vehicle speed EDC7C32_S wheel-based vehicle speed EDC7C32M_10 wheel-based vehicle speed EDC7C32M_12 wheel-based vehicle speed EDC7C32S_10 wheel-based vehicle speed EDC7C32S_12 wheel-based vehicle speed EDC7M_10 wheel-based vehicle speed EDC7M_12 wheel-based vehicle speed EDC7S_10 wheel-based vehicle speed EDC7S_12 wheel-based vehicle speed EHLA wheel-based vehicle speed EMOS wheel-based vehicle speed FFR wheel-based vehicle speed GKR wheel-based vehicle speed HDS wheel-based vehicle speed HEITZ wheel-based vehicle speed HVA wheel-based vehicle speed HYD wheel-based vehicle speed INST wheel-based vehicle speed INT wheel-based vehicle speed KR49X wheel-based vehicle speed KSM wheel-based vehicle speed LGS wheel-based vehicle speed MTS Door sensor door 3 front OBDU wheel-based vehicle speed OUZBRO wheel-based vehicle speed OUZBRO_R wheel-based vehicle speed PTM wheel-based vehicle speed RAS Rear axle speed sensor RET wheel-based vehicle speed SFFR wheel-based vehicle speed SKG wheel-based vehicle speed STON wheel-based vehicle speed T509C wheel-based vehicle speed TBM wheel-based vehicle speed Test1Module wheel-based vehicle speed Test2Module wheel-based vehicle speed SD 812a en-online Page 30 of 276

31 00084 TPM wheel-based vehicle speed TRON wheel-based vehicle speed TRW wheel-based vehicle speed TUER_DR wheel-based vehicle speed TUER_PA wheel-based vehicle speed UHV wheel-based vehicle speed VRET wheel-based vehicle speed VSM wheel-based vehicle speed WSK wheel-based vehicle speed ZBR2 wheel-based vehicle speed ZBRO wheel-based vehicle speed ZBRO_R wheel-based vehicle speed ZFR wheel-based vehicle speed ZH_AT3500_1580 wheel-based vehicle speed ZH_AT3500_ST wheel-based vehicle speed ZH_D5W_SC wheel-based vehicle speed ZHZG_9a wheel-based vehicle speed ZHZG_9c wheel-based vehicle speed MTS Door sensor door 3 rear AB Road speed, cruise control ACC Road speed, cruise control AST Road speed, cruise control ASTMID Road speed, cruise control BHTC Road speed, cruise control CNG_ME7 Road speed, cruise control CRT Road speed, cruise control DIW5 Road speed, cruise control EBS Road speed, cruise control EBS_5 Road speed, cruise control EBS_K1 Road speed, cruise control ECAM Road speed, cruise control ECAS_4X2 Road speed, cruise control ECAS2_GBV Road speed, cruise control ECAS2_GBW Road speed, cruise control ECO2 Road speed, cruise control EDC Road speed, cruise control EDC_7 Road speed, cruise control EDC_7_M Road speed, cruise control EDC_7_MASTER Road speed, cruise control EDC_7_S Road speed, cruise control EDC_7_SLAVE Road speed, cruise control EDC6 Road speed, cruise control EDC64 Road speed, cruise control EDC7 Road speed, cruise control EDC7_6 Road speed, cruise control EDC7C32 Road speed, cruise control EDC7C32_6 Road speed, cruise control EDC7C32_M Road speed, cruise control EDC7C32_S Road speed, cruise control EDC7C32M_10 Road speed, cruise control EDC7C32M_12 Road speed, cruise control EDC7C32S_10 Road speed, cruise control EDC7C32S_12 Road speed, cruise control EDC7M_10 Road speed, cruise control EDC7M_12 Road speed, cruise control EDC7S_10 Road speed, cruise control EDC7S_12 Road speed, cruise control EHLA Road speed, cruise control EMOS Road speed, cruise control FFR Road speed, cruise control SD 812a en-online Page 31 of 276

32 00086 GKR Road speed, cruise control HDS Road speed, cruise control HEITZ Road speed, cruise control HVA Road speed, cruise control HYD Road speed, cruise control INST Road speed, cruise control INT Road speed, cruise control KR49X Road speed, cruise control KSM Road speed, cruise control LGS Road speed, cruise control MTS Door sensor door 4 front OBDU Road speed, cruise control OUZBRO Road speed, cruise control OUZBRO_R Road speed, cruise control PTM Road speed, cruise control RAS Road speed, cruise control RET Road speed, cruise control SFFR Road speed, cruise control SKG Road speed, cruise control STON Road speed, cruise control T509C Road speed, cruise control TBM Road speed, cruise control Test1Module Road speed, cruise control Test2Module Road speed, cruise control TPM Road speed, cruise control TRON Road speed, cruise control TRW Road speed, cruise control TUER_DR Road speed, cruise control TUER_PA Road speed, cruise control UHV Road speed, cruise control VRET Road speed, cruise control VSM Road speed, cruise control WSK Road speed, cruise control ZBR2 Road speed, cruise control ZBRO Road speed, cruise control ZBRO_R Road speed, cruise control ZFR Road speed, cruise control ZH_AT3500_1580 Road speed, cruise control ZH_AT3500_ST Road speed, cruise control ZH_D5W_SC Road speed, cruise control ZHZG_9a Road speed, cruise control ZHZG_9c Road speed, cruise control MTS Door sensor door 4 rear MTS Door sensor door 5 front MTS Door sensor door 5 rear MTS C3 signal AB Accelerator pedal position ACC Accelerator pedal position AST Accelerator pedal position ASTMID Accelerator pedal position BHTC Accelerator pedal position CNG_ME7 Accelerator pedal position CRT Accelerator pedal position DIW5 Accelerator pedal position EBS Accelerator pedal position EBS_5 Accelerator pedal position EBS_K1 Accelerator pedal position ECAM Accelerator pedal position ECAS_4X2 Accelerator pedal position ECAS2_GBV Accelerator pedal position SD 812a en-online Page 32 of 276

33 00091 ECAS2_GBW Accelerator pedal position ECO2 Accelerator pedal position EDC Accelerator pedal position EDC_7 Accelerator pedal position EDC_7_M Accelerator pedal position EDC_7_MASTER Accelerator pedal position EDC_7_S Accelerator pedal position EDC_7_SLAVE Accelerator pedal position EDC6 Accelerator pedal position EDC64 Accelerator pedal position EDC7 Accelerator pedal position EDC7_6 Accelerator pedal position EDC7C32 Accelerator pedal position EDC7C32_6 Accelerator pedal position EDC7C32_M Accelerator pedal position EDC7C32_S Accelerator pedal position EDC7C32M_10 Accelerator pedal position EDC7C32M_12 Accelerator pedal position EDC7C32S_10 Accelerator pedal position EDC7C32S_12 Accelerator pedal position EDC7M_10 Accelerator pedal position EDC7M_12 Accelerator pedal position EDC7S_10 Accelerator pedal position EDC7S_12 Accelerator pedal position EHLA Accelerator pedal position EMOS Accelerator pedal angle signal FFR Accelerator pedal position GKR Accelerator pedal position HDS Accelerator pedal position HEITZ Accelerator pedal position HVA Accelerator pedal position HYD Accelerator pedal position INST Accelerator pedal position INT Accelerator pedal position KR49X Accelerator pedal position KSM Accelerator pedal position LGS Accelerator pedal position MTS Checklamp driver's workplace OBDU Accelerator pedal position OUZBRO Accelerator pedal position OUZBRO_R Accelerator pedal position PTM Accelerator pedal position RAS Accelerator pedal position RET Accelerator pedal position SFFR Accelerator pedal position SKG Accelerator pedal position STON Accelerator pedal position T509C Accelerator pedal position TBM Accelerator pedal position Test1Module Accelerator pedal position Test2Module Accelerator pedal position TPM Accelerator pedal position TRON Accelerator pedal position TRW Accelerator pedal position TUER_DR Accelerator pedal position TUER_PA Accelerator pedal position UHV Accelerator pedal position VRET Accelerator pedal position VSM Accelerator pedal position WSK Accelerator pedal position SD 812a en-online Page 33 of 276

34 00091 ZBR2 Accelerator pedal position ZBRO Accelerator pedal position ZBRO_R Accelerator pedal position ZFR Accelerator pedal position ZH_AT3500_1580 Accelerator pedal position ZH_AT3500_ST Accelerator pedal position ZH_D5W_SC Accelerator pedal position ZHZG_9a Accelerator pedal position ZHZG_9c Accelerator pedal position AB Current torque to maximum torque ACC Current torque to maximum torque AST Current torque to maximum torque ASTMID Current torque to maximum torque BHTC Current torque to maximum torque CNG_ME7 Current torque to maximum torque CRT Current torque to maximum torque DIW5 Current torque to maximum torque EBS Current torque to maximum torque EBS_5 Current torque to maximum torque EBS_K1 Current torque to maximum torque ECAM Current torque to maximum torque ECAS_4X2 Current torque to maximum torque ECAS2_GBV Current torque to maximum torque ECAS2_GBW Current torque to maximum torque ECO2 Current torque to maximum torque EDC Current torque to maximum torque EDC_7 Current torque to maximum torque EDC_7_M Current torque to maximum torque EDC_7_MASTER Current torque to maximum torque EDC_7_S Current torque to maximum torque EDC_7_SLAVE Current torque to maximum torque EDC6 Current torque to maximum torque EDC64 Current torque to maximum torque EDC7 Current torque to maximum torque EDC7_6 Current torque to maximum torque EDC7C32 Current torque to maximum torque EDC7C32_6 Current torque to maximum torque EDC7C32_M Current torque to maximum torque EDC7C32_S Current torque to maximum torque EDC7C32M_10 Current torque to maximum torque EDC7C32M_12 Current torque to maximum torque EDC7C32S_10 Current torque to maximum torque EDC7C32S_12 Current torque to maximum torque EDC7M_10 Current torque to maximum torque EDC7M_12 Current torque to maximum torque EDC7S_10 Current torque to maximum torque EDC7S_12 Current torque to maximum torque EHLA Current torque to maximum torque Relative engine torque signal, in relation to the current max. available engine torque EMOS FFR Current torque to maximum torque GKR Current torque to maximum torque HDS Current torque to maximum torque HEITZ Current torque to maximum torque HVA Current torque to maximum torque HYD Current torque to maximum torque INST Current torque to maximum torque INT Current torque to maximum torque KR49X Current torque to maximum torque KSM Current torque to maximum torque SD 812a en-online Page 34 of 276

35 00092 LGS Current torque to maximum torque MTS Pneumatic seal OBDU Current torque to maximum torque OUZBRO Current torque to maximum torque OUZBRO_R Current torque to maximum torque PTM Current torque to maximum torque RAS Current torque to maximum torque RET Current torque to maximum torque SFFR Current torque to maximum torque SKG Current torque to maximum torque STON Current torque to maximum torque T509C Current torque to maximum torque TBM Current torque to maximum torque Test1Module Current torque to maximum torque Test2Module Current torque to maximum torque TPM Current torque to maximum torque TRON Current torque to maximum torque TRW Current torque to maximum torque TUER_DR Current torque to maximum torque TUER_PA Current torque to maximum torque UHV Current torque to maximum torque VRET Current torque to maximum torque VSM Current torque to maximum torque WSK Current torque to maximum torque ZBR2 Current torque to maximum torque ZBRO Current torque to maximum torque ZBRO_R Current torque to maximum torque ZFR Current torque to maximum torque ZH_AT3500_1580 Current torque to maximum torque ZH_AT3500_ST Current torque to maximum torque ZH_D5W_SC Current torque to maximum torque ZHZG_9a Current torque to maximum torque ZHZG_9c Current torque to maximum torque EDC7 Fuel supply pressure MTS Red/green display MTS Depressurised buzzer AB Fuel fill level ACC Fuel fill level AST Fuel fill level ASTMID Fuel fill level BHTC Fuel fill level CNG_ME7 Fuel fill level CRT Fuel fill level DIW5 Fuel fill level EBS Fuel fill level EBS_5 Fuel fill level EBS_K1 Fuel fill level ECAM Fuel fill level ECAS_4X2 Fuel fill level ECAS2_GBV Fuel fill level ECAS2_GBW Fuel fill level ECO2 Fuel fill level EDC Fuel fill level EDC_7 Fuel fill level EDC_7_M Fuel fill level EDC_7_MASTER Fuel fill level EDC_7_S Fuel fill level EDC_7_SLAVE Fuel fill level EDC6 Fuel fill level EDC64 Fuel fill level 1 SD 812a en-online Page 35 of 276

36 00096 EDC7 Fuel fill level EDC7_6 Fuel fill level EDC7C32 Fuel fill level EDC7C32_6 Fuel fill level EDC7C32_M Fuel fill level EDC7C32_S Fuel fill level EDC7C32M_10 Fuel fill level EDC7C32M_12 Fuel fill level EDC7C32S_10 Fuel fill level EDC7C32S_12 Fuel fill level EDC7M_10 Fuel fill level EDC7M_12 Fuel fill level EDC7S_10 Fuel fill level EDC7S_12 Fuel fill level EHLA Fuel fill level EMOS Fuel fill level FFR Fuel fill level GKR Fuel fill level HDS Fuel fill level HEITZ Fuel fill level HVA Fuel fill level HYD Fuel fill level INST Fuel fill level INT Fuel fill level KR49X Fuel fill level KSM Fuel fill level LGS Fuel fill level MTS Bus-stop brake OBDU Fuel Level OUZBRO Fuel fill level OUZBRO_R Fuel fill level PTM Fuel fill level RAS Fuel fill level RET Fuel fill level SFFR Fuel fill level SKG Fuel fill level STON Fuel fill level T509C Fuel fill level TBM Fuel fill level Test1Module Fuel fill level Test2Module Fuel fill level TPM Fuel fill level TRON Fuel fill level TRW Fuel fill level TUER_DR Fuel fill level TUER_PA Fuel fill level UHV Fuel fill level VRET Fuel fill level VSM Fuel fill level WSK Fuel fill level ZBR2 Fuel Level ZBRO Fuel fill level ZBRO_R Fuel fill level ZFR Fuel fill level ZH_AT3500_1580 Fuel fill level ZH_AT3500_ST Fuel fill level ZH_D5W_SC Fuel fill level ZHZG_9a Fuel fill level ZHZG_9c Fuel fill level MTS Stop request display driver SD 812a en-online Page 36 of 276