REPAIR PARTS MANUAL. MODEL NO. LM145107A Lawn Tractor RH PRINTED IN U.S.A.

Size: px

Start display at page:

Download "REPAIR PARTS MANUAL. MODEL NO. LM145107A Lawn Tractor RH PRINTED IN U.S.A."

Spencer Lynch
5 years ago
Views:

1 REPAIR PARTS MANUAL MODEL NO. LM14107A Lawn Tractor RH PRINTED IN U.S.A.

2 HOW TO USE THIS MANUAL This manual is designed to provide the customer with a means to identify the parts on his/her tractor when ordering repair parts. The illustrations may or may not represent the actual assemblies; therefore, it is not recommended to use this manual as a guide to assemble or disassemble the tractor. Some hardware and parts are drawn larger in order to more readily identify them. Each tractor has its own model number. The model number for your tractor can be found on the fender under the seat. When ordering parts, always give the following information: Product - Lawn Tractor Model Number - LM14107A Part Number Part Description TABLE OF CONTENTS SCHEMATIC... ELECTRICAL CHASSIS DRIVE... - STEERING WHEEL ENGINE MOWER DECK MOWER LIFT LEVER SEAT... 1 DECALS

3 SCHEMATIC RED BLACK BATTERY A AMMETER (OPTIONAL) RED FUSE RED M STARTER BLACK WHITE RED B S M G A1 L A2 CLUTCH / BRAKE (PEDAL UP) SOLENOID WHITE BLACK IGNITION SWITCH WHITE SEAT SWITCH (NOT OCCUPIED) BLACK BLACK BLACK BLUE BLACK HOUR METER (OPTIONAL) FUEL LINE BLACK BLACK ATT'MENT CLUTCH (CLUTCH OFF) IGNITION UNIT GROUNDING CONNECTOR SPARK PLUG GAP (2 PLUGS ON TWIN CYL. ENGINES) CHARGING SYSTEM OUTPUT AMP 00 RPM 2 VOLTS AC 00 RPM (CHARGING SYSTEM DISCONNECTED) FUEL SHUT-OFF SOLENOID (IF SO EQUIPPED) ORANGE RED LIGHTING SYSTEM OUTPUT AMP 00 RPM DIODE ALTERNATOR IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A1 NONE RUN/LIGHT B+A1 A2+L RUN B+A1 NONE START B + S + A1 NONE NOTE YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. BECAUSE OF THIS, THE BRIGHTNESS OF THE LIGHTS WILL CHANGE WITH ENGINE SPEED. AT IDLE THE LIGHTS WILL DIM. AS THE ENGINE IS SPEEDED UP, THE LIGHTS WILL BECOME THEIR BRIGHTEST. 14 VOLTS AC 00 RPM (LIGHTS OFF) BROWN HEADLIGHTS NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. BLACK

4 ELECTRICAL

5 ELECTRICAL Battery 12 Volt 2 AMP Bolt Hex Hd 1/4-20unc X / Case Battery 1 14 Switch Interlock Push-In Harness Asm Light W/412j J Bulb Light # J Cable Battery Ga 11" red Cable Battery Ga 44" red Fuse Nut Keps Hex 1/ J Cable Ground Ga 12" black X Switch Plunger Nc Gray 0 17 Switch Ign Key Ign Harness Ignition Bolt Blk Fin Hex 1/4-20 x 1/ Cover Terminal Red Solenoid Adapter Ammeter Protection Wire Loop NOTE: All component dimensions give in U.S. inches 1 inch = 2.4 mm.

6 CHASSIS AND ENCLOSURES

7 CHASSIS AND ENCLOSURES 1 11 Chassis Drawbar 12 Ga Screw /-1x/ Bumper Hood/Dash 124X011 Saddle LT 11 Clip Retainer Slide-On 147X011 Dash Private Label Bolt Carriage /-1 x Panel Pnt Dash Lh Clip Tinnerman Grille P/L X010 Panel Dash Rh Screw, Mach Trhd /1-1 UNC x / Nut Keps /1-1 UNC 17 1X0 Hood Paint Steel Private Label 1 12X Bumper Hood Bolt Fin Hex /-1unc X 1 Gr Washer 1/2 X 1/1 X 12 Ga Nut Lock Hex W/Ins /-1 Unc Grille Private Label X Lens Grille Private Label 0 14X0 Fender Pnt 1 11 Bracket Fender 1047X0 Footrest Pnt Lh X0 Footrest Pnt Rh Bolt Rdhd Sht Sqnk /-1 X/ Screw Thdrol /1-1 x 1/2 14 Bracket, Asm. Pivot, Mower Rear Nut Lock Hex W/Ins 1/ Washer /2 x 7/ x 1 Ga Bracket, Grille, LH Screw Hex Wshd -1 x 7/ 144 Bracket, Grille, RH Bolt Hex 1/4-20 x / Air Duct P/L Rod Pivot Chassis/Hood Bolt, Shoulder / Screw /-1 x 1/2 B.D Screw Hxwsh /-1 x / Insert Lens Reflective J Plug Button NOTE: All component dimensions given in U.S. inches 1 inch = 2.4 mm 7

8 DRIVE

9 DRIVE Transaxle Peerless, Model 20-44C (Order parts from transaxle manufacturer) Spring, Brake Return 12X Pulley, Transaxle Ring, Retainer 12120X Strap, Torque Screw, /1-1 x /4 SMGML Bracket, T/A, Saddle Shift 117 Rod, Shifter Pin, Cotter 1/ x X Washer, Shift Plate Washer 1/2 x /4 x Bolt 1/4-2 UNF Gr. w/patch Washer Lock Bolt, Fin Hex /-1 Unc x 1 Gr Locknut / X Knob Rod, Brake Nut, Hex Jam / X Spring, Rod, Brake Washer 1/2 x 1/1 x 1 Gauge Pin, Cotter 1/ x / Rod, Brake, Park Cap, Parking Brake Bracket, Transaxle Bolt Hex Hd /1-1 UNC x / Shaft, Foot Pedal 1201X Bearing Nylon Washer 21/2 x 1 x 1 Gauge 7 172H Pin,Roll /1 x Idler, Flat Bolt Fin Hex /-1 Unc x 2-/ J Spacer 41 1 Keeper, Belt Washer 1/2 x 1/1 x 12 Gauge Pulley, Idler Bellcrank Asm Clutch X Retainer, Belt Bolt, Hex /-1 x 1-1/ Nut, Crownlock / Nut, Crownlock / X Link, Clutch 1070X Spring, Return, Clutch Bolt, Fin, Hex /-1unc x 1-1/ V-Belt, Drive 11 Keeper Belt Center Span Screw, /-1 x /4 SMGML 2 R Cover, Foot Pedal 1401 Pulley, Engine Bolt, Hex 7/1-20 x 4 Gr Washer, Lock Hvy Hlcl Spr 7/ Keeper, Belt Engine F-Proof Guide Belt Mower Drive RH Washer 1/2 x 1-1/4 x 12 Ga Spacer, Split X Washer 2/2 x 1-1/4 x 1 Ga E-Ring 77 12X Key Square X Washer 2/2 x 1-/ x 1 Ga M Key Woodruff # /1 x /4 447H Retainer Spring 1" Ziinc/Cad Washer /2 x /4 x 10 Ga X Strap Torque L.H. Lt Bolt, RdHd Sq Neck /-1 x Nut Lock Flg /-1 Unc Bolt, Hex Flghd /1-1 Gr Bushing, Bellcrank Grd Dr Washer 1/2 x 2 x 10 Ga Keeper, Belt, Transaxle Bolt Carr Sh /-1 x 1-1/2 Gr Screw /1-1 x 1 SMGML Tap/R NOTE: All component dimensions give in U.S. inches 1 inch = 2.4 mm.

10 STEERING ASSEMBLY

11 STEERING ASSEMBLY X42 Wheel Steering Blk Axle Asm Fr LT W/gzks / Spindle Asm LH 4 1 Spindle Asm RH 2H Bearing Race Thrust Harden 12174X Washer 2/2 X 1-/ X 1 Ga Washer 27/2 X 1-1/4 X 1 Ga Ring Klip #t04-7 R Bearing Col Strg Blk Link Drag Washer Lock Hvy Hlcl Spr / 1 11 Bearing Axle Nut Lock Flange Shaft Asm Strg Private Label Washer Thrust 1x 70x Support Shaft Screw Hex Wsh Hd Torx 2 11 Shaft Asm Pittman Bracket Steering X Bushing Link Drag Blk LR Gear Sector Washer 1/2 X 7/ X 1 Ga Screw /-1x/ Pin Cotter 1/ X /4 Cad Rod Tie Wire Form 1 7 Mech 10 Bushing Strg ScrewTT #10-2 X X / Flange 14004X42 Cap Strg Wh AYP P/L 1112 Washer 1/2 X 2-/ X 12 Ga H Nut Lock Center /-24unf L Adaptor Wheel Strg 7/7 ID X42 Boot Steering X Washer 2/2 X 1 1/4 X 1 Ga Shaft Extention Steering X Cap Spindle Fr Top Blk 47 M Fitting Grease Nut Lock Hex w/ins / Bolt Fin Hex /1-1 Unc x 1-1/ Kit, Steering Assembly, Service Bolt Fin Hex /-1 x 1 Gr. 107 Spacer Axle Bearing Arm Pittman Bolt Rdhd /-1 x 2-1/4 127 Brace Axle Washer 1/2 x 1-1/4 x Bolt Hex Nylon /-1 x /4 2 1 Bracket, Susp. Chassis, Front 1 Fastener, Christmas Tree NOTE: All component dimensions given in U.S. inches. 1 inch = 2.4 mm. 11

12 ENGINE OPTIONAL EQUIPMENT Spark Arrester 12

13 ENGINE Control Th/ch Flag Screw Hex Thd Cut 1/4-20x/ T Engine, Briggs Model (Order Parts From Engine Manufacturer) Muffler LT B&S 14HP IC OHV Gasket Eng Tube Drain Oil Easy Washer Lock Ext Tooth / 2 17 Shield Brn/Dbr Guard Kit Spark Arrestor (Flat Scrn) X Tank Fuel Front Cap Asm Fuel W/sym Vented 1247X Clamp Hose Black Line Fuel 20" 141 Plug Drain Oil Easy X Bushing Snap Nyl Blk Fuel Line Screw Hexwsh Thdrol 1/4-20x/ Screw Hxwsh /-1 x /4 BD Washer /2 X 7/ X 1 Ga Washer Lock Hvy Hlcl Spr / Stop Throttle 000 RPM Screw Hexhd Cap /1-1x / Screw /-1x1-1/ Nut Flange 1/4-20 Starter Nut NOTE: All component dimensions given in U.S. inches. 1 inch = 2.4 mm. 1

14 MOWER DECK

15 MOWER DECK 1 12 Mower Deck Assembly, Bolt 1017 Bracket Assembly,Sway Bar, Front Bracket Sway Bar /42 Deck 4M Retainer Spring 102 Arm, Suspension, Rear 07 Bolt, Hex /-24 x 1.2 Gr Washer, Lock Washer, Hardened Blade, High Perf Shaft Assembly, Mandrel, Vented Housing, Mandrel, Vented X Bearing, Ball, Mandrel Stripper, Vented Mower Deck Bolt, Carriage /1-1 x / Bolt, Shoulder Baffle, Vortex Nut Crownlock /1-1 UNC Stiffener Bracket Bracket, Deflector X Cap, Sleeve X Spring, Torsion, Deflector X Nut, Push 27 10X42 Shield, Deflector Washer 11/2 x / x 1 Ga Rod, Hinge Screw Thdrol Washer Head 1 12 Washer, Spacer 2 1 Pulley, Mandrel 172 Nut, Toplock, Flanged Bolt 1 Fastner, Christmas Tree 1144 Pulley, Idler, Flat Washer 1/2 x 1/1 x 1 Gauge Nut Crownlock /-1 UNC Guard, Mandrel, L.H H Retainer Screw, Thd. Roll 1/4-20 x / Washer, Hardened Roller Assembly, Cam Follower Bolt, Shoulder #10-24 Grade 1 10 Locknut 2 1 Bolt, Shoulder /1-1 UNC 114 Arm Assembly, Pad, Brake 4 14 Washer, Hardened 104 Arm, Idler 172 Spacer, Retainer Guard, TUV Idler 7 102X Knob Round 144 V-Belt Bracket, Gauge, Wheel L.H Bracket, Gauge, Wheel R.H Screw Tapping /1-1 Unc Nut, Hex, Keps /1-1 UNC Bolt, Carriage /1 UNC x 1/2 11 4H Bolt, Shoulder X Wheel, Gauge Nut, Centerlock / Washer / x 7/ x 14 Gauge Washer 17/2 x 1/1 x 12 Ga Bracket Arm Spring Brake Mower Bracket Arm Idler Keeper Belt 42 Clutch Cable 14 1 Pulley Idler Flat Bolt Carriage Idler Spring Extension Spring Return Idler 14 1 Retainer Spring Yellow Zinc Washer /2 x /4 x 1 Ga Bracket Clutch Cable Clutch 42 In Washer Flat / Type B Spring Retainer Spring Retention Lever Spacer 17 1 Rod Clutch Screw Hex Thd Cut 1/4-20 x / Bolt /-1 x 1-/ Mandrel Assembly (Includes Key Numbers -10, 1-1, 1 and ) Replacement Mower, Complete NOTE: All component dimensions given in U.S. inches 1 inch = 2.4 mm 1

16 LIFT

17 LIFT Wire Asm Inner/Sprg w/plunger Shaft Asm Lift 1077X Pin Groove E Ring # Washer 21/2 X 1 x 21 Ga 1201X Bearing Nylon X Grip Handle Bicycle Matte Blk 1242X Button Plunger 11 1 Link Lift LH 12 1 Link Lift RH 1 4M Retainer Spring Link Front Nut Jam Hex 1/2-1 Unc Trunnion Blk Zinc Nut Lock W/wsh 1/2-1 Unc 1 1 Arm Suspension Rear Retainer Spring 1 1 Bearing Pvt. Lift Nut Crownlock /-24 NOTE: All component dimensions given in U.S. inches 1 inch = 2.4 mm 17

18 SEAT ASSEMBLY X Seat Bracket Pivot Seat Bolt Hex / - 1 X 1 Blk Washer 1/2 X 1" 1400 Clip Push-In Locknut, Hex W/Ins / - 1 Unc X Spring Seat Cprsn 2 20 Blk Zi Screw /-1 X 1-1/ Washer 1/2 X 1 X 14 Ga Pan Seat X Bracket Mounting Switch X Bushing Snap Blk Nyl 0 Id Bolt Rdhd Sht Nk 1/4-20x1-1/ X Spacer Split X Spring Cprsn X Nut Lock 1/4 Lge Flg Gr Zinc Bolt Shoulder /1-1 UNC-2A BD Locknut, Crown /1-1 UNC Bolt Hex Black Washer 17/2 X 1-/1 X 12 Ga X Bolt Shoulder /1-1 X Washer Lock Hvy Hlcl Spr 1/2 NOTE: All component dimensions given in U.S. inches 1 inch = 2.4 mm 1

19 DECALS Decal Engine Decal Read Owners Manual Syms 1721 Decal Hood 1447 Decal Europe Stand CE Decal Brake/Clutch Symbol LT 17 Decal Chassis Hot Muffler Decal Mower Cutfinger Symbol Decal Mower Enviro Decal Battery Dan/Poi/P/L Symbols Decal V-Belt Sch Decal Saddle Brake Parking X Decal 100 DBA Decal Handle LFT Height Adj Decal Drawbar Load Limit Decal Bypass Lt Hydro Manual Operator's (European) Manual Parts WHEELS & TIRES 1 2, 1 12 Cap Valve Tire 2 1 Stem Valve 4, X Tire F Ts 1 X 0 - Service Tube Front (Service Item Only), 1072X427 Rim Asm " (front White Service) 27H Fitting Grease (Front Wheel Only) H 1010X427 Bearing Flange (Front Wheel Only) Rim Asm " (rear White Service) 102X Tire R Ts 1 x.- C Service J Tube Rear (Service Item Only) X42 Cap Axle Blk 1 0 X Sealant, Tire (10 oz. Tube) NOTE: All component dimensions given in U.S. inches 1 inch = 2.4 mm. 1

20 20

REPAIR PARTS MANUAL. MODEL NO HP-107 CM (CM15542A) Lawn Tractor TR PRINTED IN U.S.A.

REPAIR PARTS MANUAL. MODEL NO HP-107 CM (CM15542A) Lawn Tractor TR PRINTED IN U.S.A. REPAIR PARTS MANUAL MODEL NO. 1. HP-107 CM (CM14A) Lawn Tractor 174 1..01 TR PRINTED IN U.S.A. HOW TO USE THIS MANUAL This manual is designed to provide the customer with a means to identify the parts