Flammability Characterization of Li-ion Batteries in Bulk Storage
|
|
- Silvia Wells
- 5 years ago
- Views:
Transcription
1 Flammability Characterization of Li-ion Batteries in Bulk Storage Benjamin Ditch Global Research Update: High Challenge Storage Protection 22 May 2014, London, England
2 Goal Develop sprinkler protection recommendations for bulk storage of Li-ion batteries
3 Markets Automotive industry Consumer electronics Power tools
4 How to Evaluate Li-ion Batteries Large-scale evaluation not feasible Provides direct evaluation of protection Requires multiple pallets loads Commodity expensive and difficult to acquire Reduced commodity approach Limit commodity to one pallet load per test Freeburn (no water)
5 Combustible Product (Li-ion batteries or standard commodity) Ring burner Non-combustible Rack storage configuration 3-tier storage Single-row rack Commodity lining ignition flue Bottom tier non-combustible Simulate fire from 1 st tier Propane ring burner, ~50 kw 5 MW Fire Products Collector Side Elevation View Ignition flue
6 Reduced-Commodity Approach 1. Estimate time-of-involvement of Li-ion Batteries Time in fire development where the batteries are observed to contribute to the fire severity 2. Characterize fire development up to theoretical sprinkler operation 3. Compare predicted sprinkler operation time versus time of battery involvement Ditch, B. and de Vries, J., Flammability Characterization of Lithium-ion Batteries in Bulk Storage, FM Global Research Technical Report, March 2013,
7 Heat Release Rate FM Global Fire Growth Comparison High Hazard Sprinkler operation Low Hazard Time
8 Commodities Baseline and Li-ion Batteries
9 Baseline Commodity Class 2 Cartoned Unexpanded Plastic
10 Array Configuration [50 kw] Class 2 Cartoned Unexpanded Plastic
11 Cylindrical Cells 19,200 cells total Cobalt oxide
12 Power Tool Battery Packs 200 power packs total 2,000 cells total Nickel mang. cobalt oxide
13 Polymer Cells 15,552 cells total Cobalt oxide
14 Results and Analysis
15 Fire Development 30 s 90 s 360 s 480 s Characterization period 75 ± 5 s for each commodity
16 Convective Heat Release Rate (kw) FM Global Heat Release Rate 5000 CUP - Test 7 Class 2 - Test Time (s)
17 Convective Heat Release Rate (kw) FM Global Heat Release Rate CUP - Test 7 Class 2 - Test 10 Li-ion Cylindrical Cells Li-ion Power Tool Packs Li-ion Polymer Cells Similar initial fire growth rate Packaging and mass impacts fire growth Involvement observed for polymer and cylindrical cells Time (s)
18 Sprinkler Link Response Measure convective flow from fire Calculate fire plume temp and velocity Rack storage height Clearance above commodity Calculate response of sprinkler link Link rating and response
19 QR Sprinkler Response Fire sprinkler operation Quick-response sprinkler, 74 o C link rating, 3 m clearance (165 o F link rating, 10 ft clearance )
20 Rack Storage Configuration Configuration Units Value Sprinkler RTI m 1/2 s 1/2 Link Rating Ceiling Clearance [ft 1/2 s 1/2 ] o C [ o F] m [ft] 27.6 and 170 [50 and 300] 74 [165] 3.0 and 4.6 [10 and 15]
21 QR Sprinkler, 3 m (10 ft) Clearance Commodity Link Operation Time (s) Q be (kw) Fire Growth Rate (kw/s) Class CUP Li-ion Cylindrical Cells Li-ion Power Tool Packs Li-ion Polymer Cells Fire size at sprinkler operation, Q be (kw)
22 Compiled Sprinkler Response (s) Commodity 3 m (10 ft) Ceiling 4.6 m (15 ft) Ceiling QR SR QR SR Class CUP Li-ion Cylindrical Cells Li-ion Power Tool Packs Li-ion Polymer Cells Excludes all sprinkler operation times greater than 75 ± 5 s
23 Convective Heat Release Rate (kw) FM Global Battery Involvement CUP - Test 7 Class 2 - Test 10 Li-ion Cylindrical Cells Li-ion Power Tool Packs Li-ion Polymer Cells Based on HRR curves Cylindrical cells: ~ 4-6 minutes Polymer cells: ~ 5-8 minutes Power tool packs: not discernable Nominal value: 5 minutes Time (s) Threshold values based on steady-state contribution from commodity, excluding Li-ion batteries Ditch, B., Yee G. and Chaos M., Estimating the Time-of-Involvement of Bulk Packed Lithium-Ion Batteries in a Warehouse Storage Fire, Fire Safety Science 11, 2014.
24 Convective Heat Release Rate (kw) FM Global A Timeline for Protection Suppression Time (s) 1. QR link 2. SR link 3. Batteries involved 4. Partial collapse 5. Fire fighting
25 Conclusions Initial fire growth similar for all commodities Dominated by carton material Battery involvement: Expected within 5 min after ignition Occurs after sprinkler operation Not observable for power tool packs Sprinklered fire tests needed with Li-ion batteries
26 Protection Recommendations Sprinkler protection recommendations, based on: Included in FM Global Technical Report Li-ion battery hazard assessment at sprinkler operation Commodities with analogous hazard characteristics, e.g., fire growth, projectiles, reignition, etc. Small format Li-ion batteries Cartoned in bulk storage
27 Disclaimer Unique test approach only used due to availability of Li-ion batteries Does not provide same information as Commodity Classification or sprinklered fire testing Protection recommendations may be amended with additional research specific to Li-ion battery hazard
28 Special Thanks to: Exponent, Inc. Property Insurance Research Group FM Global More Data at Search: lithium ion, FM Global
COMMODITY CLASSIFICATION OF BIOMASS FEEDSTOCK ON WOOD PALLETS
COMMODITY CLASSIFICATION OF BIOMASS FEEDSTOCK ON WOOD PALLETS Erin Webb, PhD, P.E. Senior Research Engineer Oak Ridge National Laboratory Daniel R. Steppan Senior Staff Engineer Large Scale Fire Testing
More informationA leading engineering & scientific consulting firm dedicated to helping our clients solve their technical problems.
A leading engineering & scientific consulting firm dedicated to helping our clients solve their technical problems. 1 2 Suppressing Lithium-ion Electric Drive Vehicle Battery Fires with Water R. Thomas
More informationBattery technology advancements: Solid state electrolyte
MARITIME Battery technology advancements: Solid state electrolyte Presented at NOx Fund Seminar - Oslo, Norway Dr. Benjamin Gully 06 September 2018 1 DNV GL 06 September 2018 SAFER, SMARTER, GREENER Lithium
More information2030 Battery R&D Roadmap for Hybridization and E-Mobility
2030 Battery R&D Roadmap for Hybridization and E-Mobility Rene Schroeder EU Affairs Manager 31 January 2017 About the association and members Manufacturers and supply chain of automotive and industrial
More informationU.S. Army s Ground Vehicle Energy Storage R&D Programs & Goals
U.S. Army s Ground Vehicle Energy Storage R&D Programs & Goals Sonya Zanardelli Energy Storage Team, US Army TARDEC sonya.zanardelli@us.army.mil 586-282-5503 November 17, 2010 Report Documentation Page
More informationAnnual Update on Lithium-ion Battery Technology
Annual Update on Lithium-ion Battery Technology White Paper inventuspower.com Table of Contents Introduction.... 3 Market Dynamics... 3-5 Li-ion Classification... 5-6 Li-ion Roadmaps and Technology....7-8
More informationThe Advanced Rechargeable & Lithium Batteries Association Li-batteries hazards classification
Li-batteries hazards classification UN IWG, Dec 6, 2017 Geneva Claude Chanson- Philippe Bermis Content 1. Li-ion batteries hazards background 2. Li-ion batteries hazards quantification 1. Tests data base
More informationUN/SCETDG/47/INF.13/Rev.1
Committee of Experts on the Transport of Dangerous Goods and on the Globally Harmonized System of Classification and Labelling of Chemicals New proper shipping name for rechargeable lithium metal batteries
More informationImplementation and development of standards for Lithium-ion energy storage technologies within the South African context
Implementation and development of standards for Lithium-ion energy storage technologies within the South African context by Nico Rust, Nelson Mandela University uyilo EMTIP uyilo emobility Technology Innovation
More informationMaterial demand for batteries and potential supply constraints
Material demand for batteries and potential supply constraints IEA seminar on e-mobility Benjamin Jones Managing Consultant CRU Consulting March 7 218 The EV revolution is demanding larger proportions
More informationNew proper shipping name for rechargeable lithium metal batteries
Committee of Experts on the Transport of Dangerous Goods and on the Globally Harmonized System of Classification and Labelling of Chemicals New proper shipping name for rechargeable lithium metal batteries
More informationModeling and thermal simulation of a PHEV battery module with cylindrical LFP cells
Modeling and thermal simulation of a PHEV battery module with cylindrical LFP cells Paolo Cicconi, Michele Germani, Daniele Landi Università Politecnica delle Marche, Ancona, Italy Outline Research context
More informationAdvanced Technology Lithium Polymer Batteries for High Power Applications
Advanced Technology Lithium Polymer Batteries for High Power Applications Robert L. Myers Director, Science and Technology Athena Global Energy Solutions, Inc. bob.myers@athena1.com Today s Li-ion Battery
More informationLi-ion Technology Overview NTSB Hearing Washington, D.C. July 12-13, 2006
Li-ion Technology Overview NTSB Hearing Washington, D.C. July 12-13, 2006 Jason Howard, Ph.D. Distinguished Member of the Technical Staff, Motorola, Inc. Board of Directors, Portable Rechargeable Battery
More informationModeling Lithium-ion Batteries and Packs for Crash Safety. MIT Impact and Crashworthiness Lab
Modeling Lithium-ion Batteries and Packs for Crash Safety MIT Impact and Crashworthiness Lab Content of this Presentation Six Length Scales in a Battery Pack This set of slides presents selected important
More informationAnalytical thermal model for characterizing a Li-ion battery cell
Analytical thermal model for characterizing a Li-ion battery cell Landi Daniele, Cicconi Paolo, Michele Germani Department of Mechanics, Polytechnic University of Marche Ancona (Italy) www.dipmec.univpm.it/disegno
More informationEffect of Hybridization on the Performance of Fuel Cell Energy/Power Systems (FCEPS) for Unmanned Aerial Vehicle (UAV)
Effect of Hybridization on the Performance of Fuel Cell Energy/Power Systems (FCEPS) for Unmanned Aerial Vehicle (UAV) (Paper No: IMECE2010-38884) Dr. Mebs Virji Co-authors : K. Bethune, R. Rocheleau University
More informationModeling the Lithium-Ion Battery
Modeling the Lithium-Ion Battery Dr. Andreas Nyman, Intertek Semko Dr. Henrik Ekström, Comsol The term lithium-ion battery refers to an entire family of battery chemistries. The common properties of these
More informationEvaluation of the Adequacy of Lithium Resources for Fusion Reactor with the Aspect of Li-ion Battery-Driven Vehicles
Evaluation of the Adequacy of Lithium Resources for Fusion Reactor with the Aspect of Li-ion Battery-Driven Vehicles Chao Wang Contributed by FDS Team Key Laboratory of Neutronics and Radiation Safety
More informationWhy dermal exposure assessment? Concawe H/STF-29 Jan Urbanus, Shell (Chair)
ENVIRONMENTAL SCIENCE FOR THE EUROPEAN REFINING INDUSTRY Why dermal exposure assessment? Concawe H/STF-29, Shell (Chair) Dermal Exposure Studies on Workers and Consumers for Petroleum Substance REACH Dossiers
More informationUse of Aqueous Double Layer Ultracapacitor using Hybrid CDI-ED Technology for the use in Hybrid Battery Systems
Use of Aqueous Double Layer Ultracapacitor using Hybrid CDI-ED Technology for the use in Hybrid Battery Systems Overview By Robert Atlas, Aqua EWP,LLC. September 2007 Aqua EWP. has for the last 10 years
More informationGlobal Rechargeable Battery Market: Trends and Opportunities ( ) December 2015
Global Rechargeable Battery Market: Trends and Opportunities (2015-2019) December 2015 Global Rechargeable Battery Market Report Scope of the Report The report titled Global Rechargeable Battery Market:
More informationGROUP WORKING WORKING PAPER. International FIRST MEETING. related tests SUMMARY. 1.1 independent. The DGP also may 1.2. The report, strategies. 1.
International Civil Aviation Organization 1. INTRODUCTION 1.1 At DGP/23 meeting, the Secretariat requested data on tests that have been conducted on lithium batteries. Since 2005 PRBA has contracted with
More informationBATTERIES & SUPERCAPS POST MORTEM ANALYSIS PLATFORM EXTERNAL SERVICES
BATTERIES & SUPERCAPS POST MORTEM ANALYSIS PLATFORM EXTERNAL SERVICES CONTEXT Over the last years a remarkable evolution has taken place by the introduction of new batteries & supercapacitors technologies
More informationGenerator Efficiency Optimization at Remote Sites
Generator Efficiency Optimization at Remote Sites Alex Creviston Chief Engineer, April 10, 2015 Generator Efficiency Optimization at Remote Sites Summary Remote generation is used extensively to power
More informationBattery Pack Laboratory Testing Results
Battery Pack Laboratory Testing Results 2013 Toyota Prius Plug-in - VIN 8663 Vehicle Details and Battery Specifications¹ʹ² Vehicle Details Base Vehicle: 2013 Toyota Prius Plug-in Architecture: Plug-In
More informationArgonne Mobility Research Impending Electrification. Don Hillebrand Argonne National Laboratory
Argonne Mobility Research Impending Electrification Don Hillebrand Argonne National Laboratory 2018 Argonne: DOE s Largest Transportation Research Program Located 25 miles from the Chicago Loop, Argonne
More informationSizing of Ultracapacitors and Batteries for a High Performance Electric Vehicle
2012 IEEE International Electric Vehicle Conference (IEVC) Sizing of Ultracapacitors and Batteries for a High Performance Electric Vehicle Wilmar Martinez, Member National University Bogota, Colombia whmartinezm@unal.edu.co
More informationU.S. Army s Ground Vehicle Programs & Goals
Panel VII: State & Federal Programs to Support the Battery Industry U.S. Army s Ground Vehicle Programs & Goals Sonya Zanardelli Energy Storage Team Leader, U.S. Army TARDEC, DOD Power Sources Member sonya.zanardelli@us.army.mil
More informationDGP-WG/17-WP/13 Appendix APPENDIX PROPOSED AMENDMENTS TO TABLE 3-1
DGP-WG/1-WP/ Appendix APPENDIX PROPOSED AMENDMENTS TO TABLE 3-1 3-2-2 Part 3 Table 3-1. Dangerous Goods List Cargo only Articles, explosive, n.o.s. 034 1.4S A2 1 2 kg 1 0 kg Articles, explosive, n.o.s.
More informationCHEMKIN-PRO Exhaust Aftertreatment for Gas Turbine Combustors
Solution Brief Gas Turbine Combustors CHEMKIN-PRO Exhaust Aftertreatment for Gas Turbine Combustors Increasing public concerns and regulations dealing with air quality are creating the need for gas turbine
More informationPower-GEN Middle East
Power-GEN Middle East High efficiency gas turbine testing & validation Marcus H. Scholz Abu Dhabi, UAE 12-14, October 2014 GE Power & Water 2014, General Electric Company. GE Proprietary Information -
More informationThin film coatings on lithium metal for Li-S batteries AIMCAL 2016 Memphis, TN
Thin film coatings on lithium metal for Li-S batteries AIMCAL 2016 Memphis, TN Stephen Lawes, Research Scientist OXIS Company Background OXIS have been working on Li-S since 2005 at Culham Science Centre
More informationExperimental Investigation of Hot Surface Ignition of Hydrocarbon-Air Mixtures
Paper # 2D-09 7th US National Technical Meeting of the Combustion Institute Georgia Institute of Technology, Atlanta, GA Mar 20-23, 2011. Topic: Laminar Flames Experimental Investigation of Hot Surface
More informationThe lithium-ion battery end-of-life market Analysis of volumes, players, technologies and trends
The lithium-ion battery end-of-life market 2018-2025 Analysis of volumes, players, technologies and trends July 2018 Table of contents Executive summary 8 A billion dollar market 8 China and South Korea
More informationEnergy Storage Technology Roadmap Lithium Ion Technologies
Energy, Mining and Environment Portfolio Energy Storage Technology Roadmap Lithium Ion Technologies Isobel Davidson, Principal Research Officer 19 November 2014 Energy Storage Technology Roadmap Li ion
More informationAN LCA COMPARISON OF POWERTRAINS AND FUELS TODAY AND 2030
AN LCA COMPARISON OF POWERTRAINS AND FUELS TODAY AND 2030 B. PLAGA, VOLKSWAGEN, ENVIRONMENTAL AFFAIRS LIFE CYCLE MANAGEMENT CONFERENCE LUXEMBOURG SEP 4 TH, 2017 VOLKSWAGEN CHALLENGES OF THE FUTURE AND
More informationSafety Data Sheet. 1. Identification of the Product and of the Company undertaking
Safety Data Sheet (IPBT Safety Data Sheet LiPo MSDS S&A, Date of Issue: 1-January-2017) ----------------------------------------------------------------------------------------------------------------------------------------
More informationNFPA 286 STANDARD METHODS OF FIRE TESTS FOR EVALUATING CONTRIBUTION OF WALL AND CEILING INTERIOR FINISH TO ROOM FIRE GROWTH
NFPA 286 STANDARD METHODS OF FIRE TESTS FOR EVALUATING CONTRIBUTION OF WALL AND CEILING INTERIOR FINISH TO ROOM FIRE GROWTH Contego Latex Fire Barrier Intumescent (Also marketed in Canada by Pyrologistics,
More informationEnergy storage projects for smart distribution grids
Energy storage projects for smart distribution grids 01/06/2018 Laura Pimpinella Agenda Introduction and Aim National and International Committees Classification of Energy Storage Systems EESS in MV/LV
More informationTechnical Challenges for Vehicle 14V/28V Lithium Ion Battery Replacement
: Dist A. Approved for public release Technical Challenges for Vehicle 14V/28V Lithium Ion Battery Replacement David Skalny Deputy Team Leader, Energy Storage Team, US Army TARDEC May 4, 2011 Agenda Goals
More informationResearch Report. FD807 Electric Vehicle Component Sizing vs. Vehicle Structural Weight Report
RD.9/175.3 Ricardo plc 9 1 FD7 Electric Vehicle Component Sizing vs. Vehicle Structural Weight Report Research Report Conducted by Ricardo for The Aluminum Association 9 - RD.9/175.3 Ricardo plc 9 2 Scope
More informationArmy Ground Vehicle Use of CFD and Challenges
Army Ground Vehicle Use of CFD and Challenges Scott Shurin 586-282-8868 scott.shurin@us.army.mil : Distribution A: Approved for public release Outline TARDEC/CASSI Introduction Simulation in the Army General
More informationFormation and finishing
System Engineering for the battery industry Formation and finishing of lithium-ion cells 2 3 Extensive experience, a global leader with close proximity to the customers thyssenkrupp System Engineering
More informationBrief Assessment of progress in EV Battery Technology since the BTAP June 2000 Report
Brief Assessment of progress in EV Battery Technology since the BTAP June 2000 Report Dr. Menahem Anderman President Advanced Automotive Batteries This report is a brief evaluation of changes in EV battery
More informationEnergy Storage. 9. Power Converter Demo. Assoc. prof. Hrvoje Pandžić. Vedran Bobanac, PhD
Energy Storage 9. Power Converter Demo Assoc. prof. Hrvoje Pandžić Vedran Bobanac, PhD Lecture Outline Rechargeable batteries basics Power converter for experimenting with rechargeable batteries Rechargeable
More informationHong-Zeng (Bert) Yu FM Global International Water Mist Conference Barcelona, Spain November 14-15, 2012
Using Well-Stirred-Reactor Modeling and Physical Scaling to Develop a Water Mist Protection to Extinguish Ignitable Liquid Fires in a Naturally-Ventilated Building Hong-Zeng (Bert) Yu FM Global 2012 International
More informationUpdate of EV GB Standards in China. March, 2018
Update of EV GB Standards in China March, 2018 Background Plans in adopting the GTR into their national regulation Contracting parties U.S. Canada EC Japan Korea China Timeline The United States start
More informationEvaluating Batteries: Deployment, Integration and Market Drivers
Evaluating Batteries: Deployment, Integration and Market Drivers Evaluating Batteries: Deployment, Integration, and Market Drivers TechAdvantage 2018 Nashville, Tennessee February 27, 2018 Taylor Gunn,
More information49 CFR Updates Dangerous Goods Symposium September 6, Brian Beetz Manager, Regulatory Affairs & Corporate Responsibility
49 CFR Updates Dangerous Goods Symposium September 6, 2017 Brian Beetz Manager, Regulatory Affairs & Corporate Responsibility 49 CFR Transitional Exceptions January 7, 2013 HM-215L Final Rule Harmonized
More informationASSEMBLY 39TH SESSION
International Civil Aviation Organization WORKING PAPER 16/9/16 (Information paper) English only ASSEMBLY 39TH SESSION TECHNICAL COMMISSION Agenda Item 37: Other issues to be considered by the Technical
More informationPhysical Scaling of Water Mist Protection of 260-m 3 Machinery Enclosure
Physical Scaling of Water Mist Protection of 260-m 3 Machinery Enclosure Hong-Zeng (Bert) Yu International Water Mist Conference October 28 29, 2015 Amsterdam, The Netherlands Background To reduce the
More informationVelocity Optimization of Pure Electric Vehicles with Traffic Dynamics Consideration
Velocity Optimization of Pure Electric Vehicles with Traffic Dynamics Consideration Liuwang Kang, Haiying Shen, and Ankur Sarker Department of Computer Science, University of Virginia Outline Introduction
More informationFire Safety for New Battery Technologies What's in Store for Your Jurisdiction? Kelly Nicolello Senior Regulatory Engineer
Fire Safety for New Battery Technologies What's in Store for Your Jurisdiction? Kelly Nicolello Senior Regulatory Engineer Energy Storage System (ESS) Applications Historical stationary battery system
More informationThe xev Industry Insider Report
The xev Industry Insider Report November 2017 REPORT OUTLINE I. xev Market Trends 1. Overview Market Drivers Recent EV-Market Boosters Until Tesla, most automakers had introduced subcompact and city EVs
More informationBuilding Blocks and Opportunities for Power Electronics Integration
Building Blocks and Opportunities for Power Electronics Integration Ralph S. Taylor APEC 2011 March 8, 2011 What's Driving Automotive Power Electronics? Across the globe, vehicle manufacturers are committing
More informationEENERGY EFFICIENCY. German-Japanese Energy Symposium Lithium-Ion-Technology in mobile und stationary applications. February 10 th, 2011
German-Japanese Energy Symposium 2011 Lithium-Ion-Technology in mobile und stationary applications EENERGY EFFICIENCY CO EENERGY EFFICIENCY CLIMATE PROTECTION2 February 10 th, 2011 Carsten Kolligs Evonik
More informationThe Discussion of this exercise covers the following points:
Exercise 1 Battery Fundamentals EXERCISE OBJECTIVE When you have completed this exercise, you will be familiar with various types of lead-acid batteries and their features. DISCUSSION OUTLINE The Discussion
More informationVERIFICATION OF LiFePO4 BATTERY MATHEMATIC MODEL
Journal of KONES Powertrain and Transport, Vol. 23, No. 4 2016 VERIFICATION OF LiFePO4 BATTERY MATHEMATIC MODEL Filip Polak Military University of Technology Faculty of Mechanical Engineering Institute
More informationVNIV.EX454 Sprinklers, Automatic and Open. Sprinklers, Automatic and Open
VNIV.EX454 Sprinklers, Automatic and Open Page Bottom Sprinklers, Automatic and Open See General Information for Sprinklers, Automatic and Open RELIABLE AUTOMATIC SPRINKLER CO INC 1470 SMITH GROVE RD LIBERTY,
More informationTechnologies & Economics
Panos Konstantin Power and Energy Systems Technologies & Economics Case Study Cycle Simulation CCT Notes: 1. Cells with black characters include inputs 2. Cells with red characters include formulas 3.
More informationDevelopment of a Smart High-power Battery for CubeSats
Development of a Smart High-power Battery for CubeSats David J. Wright & Andrew E. Kalman Pumpkin, Inc. Slide 1 Desirable Features Better estimate of battery capacity, to include aging effects Panasonic
More informationLithium-Ion Batteries
Risk Bulletin Allianz Global Corporate & Specialty Lithium-Ion Batteries 2017 North America AGCS_Insurance www.agcs.allianz.com Introduction An electric battery is a device consisting of one or more electrochemical
More informationThe Challenging Scenario in the Lithium Era
The Challenging Scenario in the Lithium Era David Klanecky VP Lithium Upstream Division Challenge: Macro Trends Driving Lithium Growth Opportunity Mobility performance, cost and safety Demand for mobile
More informationEU Battery Directive & Circular Economy. Rene Schroeder, Lead Conference, Berlin 30 June 2017
EU Battery Directive & Circular Economy Rene Schroeder, Lead Conference, Berlin 30 June 2017 «The Battery Directive is working well, but use the revision of the Directive to make it the central piece of
More informationMATERIAL SAFETY DATA SHEET
MATERIAL SAFETY DATA SHEET Section 1: Chemical Product and Company Identification Part Number: Description: Customer Description: Customer Part Number: National Stock Code: U-BPU60-66 Lithium ion rechargeable
More informationEnergy Storage Systems Fire Safety Concepts in the 2018 International Fire and Residential Codes
Energy Storage Systems Fire Safety Concepts in the 2018 International Fire and Residential Codes Presenter: Howard Hopper Tuesday, September 12, 2017 8:00 AM - 9:30 AM Energy Storage Systems Fire Safety
More informationAlternative Powertrain and Challenges for Next Decade
Alternative Powertrain and Challenges for Next Decade Prof. Dr. Willi Diez Director Institute for Automotive Research at the University of Applied Sciences Nuertingen (Germany) SIAM Annual Convention 2011
More informationThermal Stress Analysis of Diesel Engine Piston
International Conference on Challenges and Opportunities in Mechanical Engineering, Industrial Engineering and Management Studies 576 Thermal Stress Analysis of Diesel Engine Piston B.R. Ramesh and Kishan
More information[Mukhtar, 2(9): September, 2013] ISSN: Impact Factor: INTERNATIONAL JOURNAL OF ENGINEERING SCIENCES & RESEARCH TECHNOLOGY
IJESRT INTERNATIONAL JOURNAL OF ENGINEERING SCIENCES & RESEARCH TECHNOLOGY Consumpton Comparison of Different Modes of Operation of a Hybrid Vehicle Dr. Mukhtar M. A. Murad *1, Dr. Jasem Alrajhi 2 *1,2
More informationBattery Market Trends and Safety Aspects
Battery Market Trends and Safety Aspects Adam Sobkowiak PhD, Battery Technologies adam.sobkowiak@etteplan.com 2018-01-17, Breakfast Seminar at Celltech, Kista 1 Battery Market Trends Engineering with a
More informationEnergy Storage Requirements & Challenges For Ground Vehicles
Energy Storage Requirements & Challenges For Ground Vehicles Boyd Dial & Ted Olszanski March 18 19, 2010 : Distribution A. Approved for Public Release 1 Report Documentation Page Form Approved OMB No.
More informationO&M Requirements for Utility-Scale Solar PV and Energy Storage. Nicholas Jewell, Ph.D., PMP Sr. Research Engineer Research & Development LG&E and KU
O&M Requirements for Utility-Scale Solar PV and Energy Storage Nicholas Jewell, Ph.D., PMP Sr. Research Engineer Research & Development LG&E and KU Overview Overview of E.W. Brown Solar System Design Solar
More informationFUEL CELL MARKET GERMANY STATUS & OUTLOOK
FUEL CELL MARKET GERMANY STATUS & OUTLOOK Dr. Christoph Hartnig Berlin, September 20, 2017 Brennstoffzellen AGENDA 1 VDMA AG Fuel Cells 2 Heraeus Fuel Cells and Heraeus Group 3 VDMA Fuel Cells Survey 2
More informationUse of Aqueous Double Layer Ultracapacitor using Hybrid CDI-ED Technology for the use in Hybrid Battery Systmes
Overview Use of Aqueous Double Layer Ultracapacitor using Hybrid CDI-ED Technology for the use in Hybrid Battery Systmes By Robert Atlas, Aqua EWP,LLC. September 2006 Aqua EWP. has for the last 10 years
More informationJoão Rafael Dezotti Neto, Everton Lopes da Silva, Eduardo Tomanik, Eduardo Nocera. MAHLE Metal Leve S.A.
Blucher Engineering Proceedings Agosto de 2014, Número 2, Volume 1 POWERCELL SOLUTIONS FOR ENGINE FUEL CONSUMPTION REDUCTION João Rafael Dezotti Neto, Everton Lopes da Silva, Eduardo Tomanik, Eduardo Nocera
More informationIs there really anything wrong with it? Generation II 2007 Toyota Prius 311,000 miles
Is there really anything wrong with it? Generation II 2007 Toyota Prius 311,000 miles Always make sure that the HV Disconnect is removed! Always use the proper protective equipment! 1,000 volt gloves Battery
More informationDID YOU KNOW THAT LITHIUM BATTERIES ARE DANGEROUS GOODS? RDIMS # March 2018
DID YOU KNOW THAT LITHIUM BATTERIES ARE DANGEROUS GOODS? RDIMS # 10277515 March 2018 Lithium batteries are dangerous goods, much like gasoline, propane, and sulphuric acid. In Canada, the shipping and
More informationItem No: Item Desc: Shared SDS s (Item No): SDS Origin. Note: This SDS cover page should accompany all printed copies of actual Safety Data Sheets
Item No: Item Desc: Note: This SDS cover page should accompany all printed copies of actual Safety Data Sheets Shared SDS s (Item No): SDS Origin Manufacturer: Mfg. Code No: SDS No: Phone: Print Date:
More informationThere are several technological options to fulfill the storage requirements. We cannot use capacitors because of their very poor energy density.
ET3034TUx - 7.5.1 - Batteries 1 - Introduction Welcome back. In this block I shall discuss a vital component of not only PV systems but also renewable energy systems in general. As we discussed in the
More informationSeoul, Korea. 6 June 2018
Seoul, Korea 6 June 2018 Innovation roadmap in clean mobility materials SPEAKER Denis Goffaux Chief Technology Officer Executive Vice-President Energy & Surface Technologies 2 Agenda Well to wheel efficiency
More informationStefan van Sterkenburg Stefan.van.sterken
Stefan van Sterkenburg Stefan.vansterkenburg@han.nl Stefan.van.sterken burgr@han.nl Contents Introduction of Lithium batteries Development of measurement equipment Electric / thermal battery model Aging
More informationDOC design & sizing using GT-SUITE European GT Conference Gauthier QUENEY 09/10/2017
DOC design & sizing using GT-SUITE European GT Conference 2017 Gauthier QUENEY 09/10/2017 Background Simulation tool target Predict exhaust outlet emissions Thermal modeling Chemical modeling This presentation
More informationC8000. Advanced Battery Analyzer. cadex.com/c8
C8000 Advanced Battery Analyzer cadex.com/c8 AN OUT-OF-THIS-WORLD BATTERY ANALYZER CREATED FOR ADVANCED USERS The Cadex C8000 delivers the versatility needed to ensure you get the right performance from
More informationEmissions Legislation
Emissions Legislation Potential Impact of the Medium Combustion Plant Directive 1 SAACKE Presentation All rights reserved by SAACKE Combustion Services Ltd, UK and SAACKE GmbH, Bremen The formation of
More informationSupercapacitors for Micro-Hybrid Automotive Applications. Anthony Kongats, CEO, CAP-XX Ltd 18 th April 2013
Supercapacitors for Micro-Hybrid Automotive Applications Anthony Kongats, CEO, CAP-XX Ltd 18 th April 2013 World leader in high power energy storage devices (supercapacitors) for consumer and industrial
More informationLithium Ion Medium Power Battery Design
Bradley University Lithium Ion Medium Power Battery Design Project Proposal By: Jeremy Karrick and Charles Lau Advised by: Dr. Brian D. Huggins 12/10/2009 Introduction The objective of this project is
More informationCombustion characteristics of n-heptane droplets in a horizontal small quartz tube
Combustion characteristics of n-heptane droplets in a horizontal small quartz tube Junwei Li*, Rong Yao, Zuozhen Qiu, Ningfei Wang School of Aerospace Engineering, Beijing Institute of Technology,Beijing
More informationRetrofit von Industriekesseln zur Brennstoffänderung und NOx- Reduzierung. Dr.-Ing. Marco Derksen
Retrofit von Industriekesseln zur Brennstoffänderung und NOx- Reduzierung Dr.-Ing. Marco Derksen Contents NOx formation In-furnace NOx reducing measures Application of premixed combustion Experiences in
More informationComparing the powertrain energy and power densities of electric and gasoline vehicles
Comparing the powertrain energy and power densities of electric and gasoline vehicles RAM VIJAYAGOPAL Argonne National Laboratory 20 July 2016 Ann Arbor, MI Overview Introduction Comparing energy density
More informationfuel cell systems for the automotive sector
Intelligent t Energy fuel cell systems for the automotive sector 23 rd April 2012 Dan Ninan Dan.Ninan@intelligent-energy.com 2012 Intelligent Energy Limited The information in this document is the property
More informationSection II - Hazardous Ingredients / Identity Information
Document Number: YDS1099 Revision: 02 Page 1 of 5 IDENTITY (As Used on Label and List) Lithium Ion Battery Section I Information of Manufacturer Manufacturer's Name GPI International Ltd. Address (Number,
More informationWayside Energy Storage Project: Progress Update & Lessons Learned
Wayside Energy Storage Project: Progress Update & Lessons Learned Andrew Gillespie, Chief Engineering Officer Power Presentation to: APTA Rail Conference, June 2012 Goals 10% Energy Reduction by 2015 5%
More informationUnderstanding Lithium-Ion Technology Jim McDowall (updated from Battcon 2008)
Understanding Lithium-Ion Technology Jim McDowall (updated from Battcon 2008) PE/SB Winter Meeting 2015, New Orleans Background History Started with primary batteries with metallic lithium negatives True
More informationDevelopment of an Unmanned Aircraft Mounted Software Defined Ground Penetrating Radar
Development of an Unmanned Aircraft Mounted Software Defined Ground Penetrating Radar J. F. Fitter, A. B. McCallum & J. P. Leon University of the Sunshine Coast, Sippy Downs, Australia 8-Sep-16 1 Project
More informationDon t Overdesign Your Battery
Don t Overdesign Your Battery By Sol Jacobs VP & General Manager Tadiran Batteries When developing an industrial grade wireless device intended for long-term deployment, design engineers must strike a
More informationU.S. Army s Ground Vehicle Energy Storage R&D Programs & Goals
U.S. Army s Ground Vehicle Energy Storage R&D Programs & Goals James Mainero Energy Storage Team, US Army TARDEC James.m.mainero.civ@mail.mil 586-282-9513 November 10th, 2010 Disclaimer: Reference herein
More informationAdvanced Battery Models From Test Data For Specific Satellite EPS Applications
4th International Energy Conversion Engineering Conference and Exhibit (IECEC) 26-29 June 2006, San Diego, California AIAA 2006-4077 Advanced Battery Models From Test Data For Specific Satellite EPS Applications
More informationFuture trends on critical materials. Patrick Koller June 2018
Future trends on critical materials Patrick Koller June 2018 Agenda 1 Energy mix evolution 2 Critical raw material availability 3 Necessary investments 4 Take away World Materials Forum June 2018 2 Agenda
More informationKenta Furukawa, Qiyan Wang, Masakazu Yamashita *
Resources and Environment 2014, 4(4): 200-208 DOI: 10.5923/j.re.20140404.03 Assessment of the Introduction of Commercially Available Hybrid Automobiles - Comparison of the Costs of Driving Gasoline-fueled
More information