Mini Pure. User Manual. Model Number:
|
|
- Gwendoline Ryan
- 5 years ago
- Views:
Transcription
1 User Manual Rev Sailing Toward a Greener and Safer Tomorrow Mini Pure A Revolutionary system used to produce a limited supply of both a cleaner & a sanitizer from just salt, water, and electricity. It is not only a greener solution to cleaning it is 100% NON-TOXIC. Model Number: PN: VPM-SB (115VAC/230VAC) 1 P a g e
2 Contents Warnings Diagrams Unit Diagram Inside Unit Diagram Cell Diagram Installation & Set Up of Your Unit Pre-installation Water Test Diagram Connecting the VPM-SB User Information Smart Button Instructions Adding Salt Solution/Label Information Warranty Information Trouble Shooting Guide User Reference Guide Other Products By Viking Pure P a g e
3 Warnings The following warnings include general safety information for this equipment with detailed descriptions. ELECTRIC SHOCK HAZARD WARNING WARNING Improper grounding, setup, or usage of the system can cause electric shock and death. Turn off and disconnect power cord before servicing equipment. Use only grounded electrical outlets. Use only 3-wire extension cords. LIMITED PRODUCTION NOTICE Unit is intended to be used for smaller applications only. Unit is limited to use in the following ways: Unit shall not run, continuously, for more than 1 hour (6 runs) or unit may become damaged and/or cause injury. Unit shall not run for more than 3 hours (18 runs) per 24 hour period or unit may become damaged And/or cause injury. *Please See Warranty (Page 14) For Full Warranty Information*. EQUIPMENT MISUSE HAZARD Misuse can cause death or serious injury. Misuse of equipment will damage unit, void warranty (if new), or cause serious injury, even death. Check equipment daily. Repair or replace worn or damaged parts immediately. Do not alter or modify equipment. For use only by trained staff. Use equipment only for its intended purpose. Call your Viking Pure 1000 distributor for information. Route hoses and cables away from traffic areas, sharp edges, moving parts, and hot surfaces. Do not use hoses to pull equipment. Only use Viking accessories for this unit. Any other accessories may damage unit & void warranty Only Use Viking Pure Salt Use of any other types of salt will damage unit s membranes, chemically change the solutions, and may even cause physical harm. If you have any questions or comments regarding the warning information above please contact us at: Info@vikingpure.com Or 1-(386) USA 3 P a g e
4 1 Unit Diagram 3 VPM-SB Mini Pure 10 2 Key 1. Power Entry Module/Power Switch- This is where you plug in your power cord and turn the unit ON/OFF as well as the fuse for the system. 2. Salt Tube Cap/Salt Input 3. Smart Button- Used to Setup and Start Production (See pages for instructions) Salt Tube Level Window- Used to determine when you need to add another salt cartridge. 5. Filtered Water Inlet (On lower right side of unit) 6. Salt Tube Drain- To be used when refilling salt (See page 13 for more details) 7. Safe-T-Clean Outlet- This is where the Safe-T-Clean (NaOH) solution exits the cell into a container 8. Safe-T-San Outlet- This is where the Safe-T-San (HOCl) solution exits the cell into a container. 9. Door Latch- Latched with a phillips head screw 10. Control Lock- Lock comes with 2 keys 6 4 P a g e
5 17 Inside Unit Diagram VPM-SB Viking Pure: Mini Pure 11 Key 11. Salt Tube- This is where you will fill your salt tube. 12. Electrolyzer Cell- This is where both HOCl and NaOH solutions are produced. 13. Safe-T-San Flow Control- This should be adjusted only under the direction of a Viking Pure representative 14. Safe-T-Clean Flow Control- This should be adjusted only under the direction of a Viking Pure representative 15. Safe-T-San Outlet- This is where the Safe-T-San (HOCl) solution exits the cell into a container Safe-T-Clean Outlet- This is where the Safe-T- Clean (NaOH) solution exits the cell into a container. 17. Electrical Compartment- Turn off and Remove power cord prior to opening control door. (KEEP AREA DRY) 5 P a g e
6 18 Cell Diagram VPM-SB Viking Pure: Mini Pure 20 Key 18. Mounting Bracket 19. Safe-T-San Flow Control- This should be adjusted only under the direction of a Viking Pure representative 20. Red Tubes- Denotes all tubing used to transport HOCl Safe-T-Clean Flow Control- This should be adjusted only under the direction of a Viking Pure representative 22. Blue Tubes- Denotes all tubing used to transport NaOH. 23. Salt Brine Inlet- This is where the salt brine from the salt tube enters the cell. 24. Salt Brine Outlet- This is where the salt brine, that was not used, is recycled back to the salt tube. 25. Yellow Tubes- Denotes all tubing used to transport salt brine from the salt tube to the Electrolyzer Cell P a g e
7 Setting Up Your Control Pre-Installation Hard Water Test 1. Before installing your system you should do a quick Hard Water Test. 2. This test can be done by bringing a sample of your water (fresh out of the tap) to a local water testing facility or you may purchase a water testing kit from Viking Pure. 3. The different levels you will be testing for are as follows: a. Degrees Hardness: This test should result in NO MORE than 5 dh. b. Parts per Million: This test should result in NO MORE than 100 PPM. c. Grains per Gallon: This test should result in NO MORE than 5 gpg. d. Milligrams per Liter: This test should result in NO MORE than 90 Mg/L 4. The test must be performed to determine if a water softener is needed to run the system properly. 5. If a water softener is needed, shown by failed testing, one must be installed or warranty will be void (See page 10 for all warranty information). This is due to the fact that hard water will damage the membranes in the cell and drastically affect the lifespan of the unit. 7 P a g e
8 Setting up your Control: Diagram Water Filter (Included) Water Softener (Not Included) Water Source Salt Tube Draining (See Adding Salt on page 11 for more information) 8 P a g e
9 Connecting your Mini Pure 1. After removing the unit from the shipping container, inspect the unit for any marks and/or damage that may have resulted from mishandling during freight. If the unit is damaged report it to UPS or the shipping company involved. 2. Install unit in the best area, as determined by Pre-Install Site Evaluation Sheet (filled out and sent to Viking Pure, Distributor or Sales Representative before purchase of unit). Power connection is a standard wall outlet with ground, 3 prongs. FOR 115VAC AND 230VAC UNITS, USE PROPER OUTLET. 3. Water connection can be made with the fitting supplied or any other means that has a shutoff valve. The connection should accommodate the ¼ plastic supply line supplied. 4. Mount the water filter using the bracket supplied. The filter comes with a fitting installed on the Outlet end. Water supply should be connected to the inlet on filter. 5. Route the tubing from the water filter to the Mini Pure in such a way as to protect the tubing from damage and cut to size. Then install the tube into the Mini Pure lower right side as indicated, FILTERED WATER INLET (Item #5 on Pg. 4 of Manual). 6. Turn water on and check for any leaks at the water supply or on the water filter, if leaks occur: turn off water supply and check connection of all fittings to tubes and ensure they are pressed in firmly as shipment may have loosened some connections. 7. Add salt to the unit (see pg. 13 for Adding Salt to Unit) 8. Plug unit into a standard house hold type receptacle that is grounded to code (Item #9 on Pg. 4 of Manual). FOR 115VAC AND 230VAC UNITS, USE PROPER OUTLET. 9 P a g e
10 9. Turn system ON by activating power switch on upper left side of unit. (Item #1 on Pg. 4 of Manual). 10. Insert the One Gallon Containers (Provided) under their respective tubes, Red for Safe-T-San and Blue for Safe-T-Clean, into the lower section 11. Activate Smart Button (Item #3 on Pg. 4 of Manual) to full and run 1 full run to allow the air to purge out of all the lines then dispose of these solutions. (See page in Manual for Smart Button Instructions). 12. Replace the containers and reactivate the Smart Button (Item #3 on Pg. 4 of Manual), watching the first cycle to insure the proper fill of the bottles. The bottles should fill to the base of the handle. 13. If the fill is too high or too low please call Viking Pure, your distributor or your sales representative and they will assist you on adjusting the fill volume. 14. If adjustment was necessary, please reactivate Smart Button for another full run to ensure fill is now correct. 15. Place cap (provided) on the Safe-T-San One Gallon Container to retain the strength of the solution. When required amount of product is obtained, turn the power off and it will be ready for the next cycle when required just turn the power on and start Sailing with us Toward a Greener and Safer Tomorrow. 10 P a g e
11 Smart Button Instructions 1. When unit is first powered up (activated by Item # 1 on Pg. 4 of Manual), screen on Smart Button will display the Startup Screen featuring the Viking Pure logo for a few seconds. 2. The next screen, Dashboard Screen, will show the Model Number, Program Version Number and the Preset Run Time 3. Unit run time will be preset to fill the 1 Gallon Containers (included). If you require more or less fill solution output, for containers of varying sizes, you will need to adjust the run time. 4. To adjust the time, hold the Smart Button for approx. 3 seconds until the screen switches to a Minute Adjustment Screen. Once the Minute Adjustment Screen appears, tap the screen to change the time in minute increments. If adjustment is not made quickly enough, screen will change to Second Adjustment Screen. (Image to right shows the minutes being set at 11 minutes). 5. Once you are done with the Minute Adjustment Screen, do not press Smart Button for a few seconds and screen will switch to the Second Adjustment Screen. This screen will operate in the same manner as the Minute Adjustment Screen with the only difference that you will be adjusting the seconds in 10 second increments. If adjustment is not made quickly enough, screen will revert back to the Dashboard Screen. (Image to right shows the seconds being set at 20 seconds). 11 P a g e
12 6. When you are ready to begin producing solution, press and release Smart Button from the Dashboard Screen. Doing this will then bring you to the Ready Screen. This screen will display the total hours the unit has been in operation. This number will be used when determining Warranty (See page 14 of Manual for more Warranty information). (Image to the right shows that this unit has been in operation, ie. Only making solution, for 1 hour and 40 minutes) 7. To start normal operation and begin producing solutions, press the Smart Button one more time, from Ready Screen, and unit will start production for the set time. As system is in production, you will see an indication that the system is on (SYS ON) and a countdown timer displayed. This will show you how much time is left on your cycle. Once countdown reaches zero, your unit will stop production and will revert back to the Dashboard Screen. If you need to stop production in the middle of the cycle, you can press the Smart Button once and release. Please Note: Stopping production during a cycle does not PAUSE the production. It reverts the screen back to the Dashboard Screen and when you start production again, you will be starting from the full production time. To prevent spillage, empty 1 gallon jugs completely before running a new cycle. 12 P a g e
13 Adding Salt 1. Loosen salt tube cap (Item #2 on Pg. 4 of Manual). 2. Open salt tube drain valve (Item #6 on Pg.4 of Manual) at base of control and allow liquid to drain into a container (Do not dispose of this liquid, it is used in later steps). 3. When liquid stops draining close manual valve (Liquid will stop draining on its own at the correct level). 4. Fully remove salt tube cap (Item #2 on Pg. 4 of manual) 5. Begin filling salt tube with salt, stopping when approximately ¼ of space is still visible through clear salt tube. 6. Fill with the liquid drained (From step 2) to ½" from the top of the tube. 7. Ensure the outer surface of the tube is free from salt. 8. Replace the salt tube cap, but only until you feel it starts to get tight then stop. 13 P a g e
14 Solution/Label Information Safe-T-San - Product Name: Safe-T-San Product Purpose: Sanitizing/Disninfecting Active Ingredient: Hypochlorous Acid (HOCl) HOCl EPA CAS# Product Labels: Safe-T-Clean - Product Name: Safe-T-Clean Product Purpose: Cleaning/Degreasing Active Ingredient: Sodium Hydroxide (NaOH) HOCl EPA CAS# Product Labels: 14 P a g e
15 Warranty Warranty Viking Industries, Incorporated (Viking Pure) warrants that products manufactured by it shall be free of defects in material and workmanship when operated in accordance with Viking s operating and maintenance procedures for the following period from the date of shipment: Product Viking Pure: Mini Pure Warranty Limit 1 Year or 1000 Hours (Whichever occurs first) Viking s liability is limited to the repair or replacement, at Viking s option, of any product, which proves to be defective during the warranty period outlined. The product must be returned, prepaid by purchaser, to Viking after obtaining a Return Authorization Number from Viking. Viking shall have the right of final determination as to the existence and cause of any defects. This warranty shall not cover unauthorized repairs, alterations, modifications, or use by the purchaser of product for which it is not intended without prior written consent from Viking. This warranty shall not cover abuse, neglect, improper operating or maintenance procedures, voluntary or involuntary damages of the product by the purchaser. Unit shall not be run, continuously, for more than 1 hour (6 runs) or unit may become damaged and/or injury may occur. Unit shall not be run more than 3 hours (18 runs) in a 24 hour period or unit may become damaged and/or injury may occur. Viking s liability under this warranty shall in no event exceed the purchase order price and shall not cover any losses caused by delays or for any expenses for labor, supplies, machine rental or loss or damages to other property. No warranty is made with respect to customer equipment or products manufactured to purchaser s specifications except as specifically stated in writing by Viking. Warranty will be void if salt other than that supplied by Viking Pure is used. Warranty will be void if : a) Hard Water Test is not performed b)hard Water Test is performed, failed to meet Viking s set limits (as defined on page 6) and no water softener is installed. Viking s responsibility for transportation under this warranty is limited to charges for delivery of repaired products via the least expensive transportation available, to the purchaser in the Continental United States only. Payment for shipment of Viking parts or products to Viking s facilities is the responsibility of the purchaser. Warranty for items that are repaired or replaced by Viking shall continue in effect for the remainder of the original warranty period or for ninety (90) days following the date of shipment by Viking, whichever period is longer. This warranty supersedes any other warranty, expressed or implied, and constitutes all of Viking Industries, Inc. s liability with respect to its products. 15 P a g e
16 Trouble Shooting Guide 1. My unit won t turn on Check to make sure power cord (supplied) is plugged into unit and also into wall outlet then turn switch on (See #1 on Page 4). If both ends of power cord are plugged in and flipping switch does nothing, you should check your power outlet. If you are comfortable with electricity and have an Electrical Meter available, check to make sure your power outlet is working properly by checking it for correct Voltage (115/230VAC). If you are not comfortable with or knowledgeable of working with electricity, contact your electrician to complete this step. If you are unable to start up your Mini Pure after trying the two steps above, contact your Distributor, Representative or Viking Pure. Quick Contact Info: ( ) - 2. Unit runs for a few seconds and then shuts off Check to ensure that your source water is turned on. If water does not flow to unit, unit will shut off to protect itself. Ensure there is salt in salt tube (See page 11 for proper salt filling procedure). Make sure you have water, or enough water, in the salt tube (See page 11 for proper salt filling procedure). Ensure there is not TOO MUCH salt in salt tube. If you have overfilled salt tube, you will not allow enough water to convert to brine and flow through cell. (See page 11 for proper salt filling procedure). If you are unable to start up your Mini Pure after trying the two steps above, contact your Distributor, Representative or Viking Pure. Quick Contact Info: ( ) - 16 P a g e
17 Viking Pure: Mini Pure User Reference Guide: Model Number : Serial Number : Installation Date : User Notes: 17 P a g e
18 Other Products by Viking Pure Viking Pure: MiniMAXX Part No: VPM-MAXX Output: 1 Gallon/10 Minutes/Solution Features: 2 X 5 Gallon Storage Tanks with Ball Valve Dispensers Recommended Accessories: Mini Pure Convenience Kit (VPM-CK) Extended Warranty (1,2 or 3 Years Available) Viking Pure 1000 w/ Twin 25 Gallon Tanks Part No: VPT2501 Output: Gallons/Hour/Solution Features: 2 X 25 Gallon Storage Tanks, Ultrasonic Sensors, Pumps, Touch Screen UI Recommended Accessories: Viking Pure 1000 Convenience Kit (VP-CK) Manual Dispense Kit (VPMD100) SanStorm PSV Sprayers, 10 Pack (PSV-HA-CASE) MistaClean PSV Sprayers, 10 Pack (PSV-SH-CASE) Extended Warranty (1,2 or 3 Years Available) Viking Pure 1000 w/ Twin 50 Gallon Tanks Part No: VPT5001 Output: Gallons/Hour/Solution Features: 2 X 50 Gallon Storage Tanks, Ultrasonic Sensors, Pumps, Touch Screen UI Recommended Accessories: Viking Pure 1000 Convenience Kit (VP-CK) Manual Dispense Kit (VPMD100) SanStorm PSV Sprayers, 10 Pack (PSV-HA-CASE) MistaClean PSV Sprayers, 10 Pack (PSV-SH-CASE) Extended Warranty (1,2 or 3 Years Available) 18 P a g e
19 511 Pullman Rd. Unit C5 Edgewater, FL USA Phone: (386) Fax: (386) Website: 19 P a g e
Items # and #
D I S P E N S E R T E C H N I C A L M A N U A L Items #91160-00 and #91161-00 1. System Description... 1 2. Equipment Included with the Green Earth II XL System... 2 3. Components Included with Green Earth
More informationQPET, QPETXU Battery Chargers
C O R P O R A T IO N O P E R A T I N G I N S T R U C T I O N S QPET, QPETXU Battery Chargers INTRODUCTION: The QPET line of chargers are designed for general purpose deep cycle batteries. They are an electronically
More informationOBAE, OBAEXU, ON BOARD Battery Chargers
C O R P O R A T IO N O P E R A T I N G I N S T R U C T I O N S OBAE, OBAEXU, ON BOARD Battery Chargers INTRODUCTION: The OBAE line of chargers are designed for the permanent installation on battery powered
More informationOwner s Manual. PS48/PS80 Advantage Series Salt Based Water Softeners
Owner s Manual PS48/PS80 Advantage Series Salt Based Water Softeners Page 2 Copyright 2015 Enviro Water Solutions LLC. All rights reserved. All information contained herein is the property of Pelican Water
More informationCRD610 Automatic Fitting Inserter
CRD610 Automatic Fitting Inserter OPERATIONS MANUAL VERSION 1.2 LAST EDITED 12.12.2018 cleanroomdevices.com 1 Table of Contents Title Page. 1 Table of Contents...2 1.0 General Product & Safety Information....3
More informationCLEAN ROOM DEVICES, LLC "WHERE TUBING AND FITTINGS COME TOGETHER"
CLEAN ROOM DEVICES, LLC "WHERE TUBING AND FITTINGS COME TOGETHER" CRD600 Automatic Fitting Inserter OPERATIONS MANUAL VERSION 2.1 LAST EDITED 7.25.14 DOCUMENT NUMBER 001 cleanroomdevices.com 1 Table of
More informationOperations and Parts Manual
Operations and Parts Manual 300 Gallon Elliptical Brine Maker Electric www.deicing.com 954-781-9200 1 Contents Warranty 3 Section 1 Disclaimer 4 Section 2 Safety and General Information 5 Section 3 Component
More informationUsers Manual Certified Series Direct Drive Pump 1-7 LPM
Users Manual Certified Series Direct Drive Pump 1-7 LPM Safety, Operating, Installation, and Maintenance Instructions 600 S 56 th Street #9 Chandler, AZ 85226 Phone: 480-507-6478 Fax: 480-838-2232 www.fogco.com
More informationCRD600 Automatic Fitting Inserter
CRD600 Automatic Fitting Inserter OPERATIONS MANUAL VERSION 2.3 LAST EDITED 12.07.2018 cleanroomdevices.com 1 Table of Contents Title Page.. 1 Table of Contents. 2 1.0 General Product & Safety Information...3
More informationINSTALLATION INSTRUCTIONS, PARTS LIST AND CONFIGURATION GUIDE FOR THE CARBONATOR. Large Model No
Please refer to the Schroeder America website (www.schroederamerica.com) for information relating to Schroeder America installation and Service Manuals, Instruction Sheets, Technical Bulletins, Service
More informationCLEAN ROOM DEVICES, LLC "WHERE TUBING AND FITTINGS COME TOGETHER"
CLEAN ROOM DEVICES, LLC "WHERE TUBING AND FITTINGS COME TOGETHER" CRD600AF Automatic Fitting Inserter With Auto Feed OPERATIONS MANUAL (Shown with optional alcohol dispenser) 1 VERSION 1.1 LAST EDITED
More informationUser Manual. Posture+ Adjustable Base. For customer service call:
User Manual Posture+ Adjustable Base For customer service call: 1-877-707-7533 1 IMPORTANT INFORMATION PLEASE READ THESE INSTRUCTIONS THOROUGHLY BEFORE USING THIS PRODUCT. PROPER OPERATION OF YOUR ADJUSTABLE
More informationSUBMERSIBLE MINI-PUMP
SUBMERSIBLE MINI-PUMP Model 41287 Set up And Operating Instructions Diagrams within this manual may not be drawn proportionally. Due to continuing improvements, actual product may differ slightly from
More informationOBE, OBEXU, ON BOARD Battery Chargers
C O R P O R A T IO N O P E R A T I N G I N S T R U C T I O N S OBE, OBEXU, ON BOARD Battery Chargers INTRODUCTION: These chargers are designed for the permanent installation on battery powered vehicles
More informationQSSE, QSSEX INDUSTRIAL Battery Chargers
C O R P O R A T IO N O P E R A T I N G I N S T R U C T I O N S QSSE, QSSEX INDUSTRIAL Battery Chargers INTRODUCTION The QSE line are electronically controlled float chargers. The batteries are brought
More informationNew & Improved VariFlo Plural Component Equipment. Low Pressure Polymer Dispensing Equipment
New & Improved VariFlo Plural Component Equipment Low Pressure Polymer Dispensing Equipment Table of Contents Page One Page Two Page Three Page Four Page Five Page Six Page Seven Page Eight Page Nine Page
More information10 gallon Mist System
10 gallon Mist System Page 1 of 7 10 gal # 11525 CONTENTS: 10 gallon System Pressure Tester Remote Control Battery Charger If you should experience any difficulties, issues or problems while assembling
More informationTRAILER AUXILIARY POWER SYSTEM (TAPS) INSTALLATION GUIDE V1.10
TRAILER AUXILIARY POWER SYSTEM (TAPS) INSTALLATION GUIDE V1.10 TAPS INSTALLATION GUIDE V1.10 1 TRAILER AUXILIARY POWER SYSTEM CONTENTS General Information and System Logic... 2 Diagrams... 3 System Diagram
More informationINSTRUCTIONS FOR INSTALLING AND OPERATING THE UNIVERSAL AUTOSYNC MODEL ASPSS DUAL COMPRESSOR SEQUENCER CONSOLE S/N 1638 AND ABOVE
COMPRESSOR 1 EMERGENCY SHUTDOWN OFF POWER ON COMP LOADED COM PRESSOR OPERATING HOURS SYSTEM PRESSURE COMPRESSOR 2 EMERGENCY SHUTDOWN OFF POWER ON COMP LOADED COM PRESSOR OPERATING HOURS LEAD/LAG CONTROL
More informationOwner s Guide. ca5354
PROFESSIONAL SERIES Owner s Guide for models: ca5354 Deluxe Vehicle Remote Start System with 900Mhz 2 Way Confirming LED Remote Control IMPORTANT NOTE: The operation of the Security and Convenience System
More informationModel Combustible Gas Sample Draw Detector Head Operator s Manual
Model 1017-06 Combustible Gas Sample Draw Detector Head Operator s Manual Part Number: 71-0356 Revision: P1 Released: 2/4/15 www.rkiinstruments.com WARNING Read and understand this instruction manual before
More informationSingle Pump Station with Delay, 10HP/1PH DU PS2001C-PG
Single Pump Station with Delay, 10HP/1PH DU PS2001C-PG Owner s Manual #0810 Customer Number: Model Number: Serial Number: Installation Date: Please read and u n d e r s t a n d t h i s manual. Store in
More informationOCTA FLUORESCENT 7 SOCKET FIXTURE
OCTA FLUORESCENT 7 SOCKET FIXTURE OC-OF7 Bulbs are not included. INTRODUCTION Thank you for choosing the Raya Octa Fluorescent 7 Socket Fixture. Using Edison-base compact fluorescent lamps (CFL), this
More informationOwner s Manual & Safety Instructions
Owner s Manual & Safety Instructions Save Save This This Manual Keep Keep this this manual manual for for the the safety safety warnings warnings and and precautions, assembly, assembly, operating, inspection,
More informationModel Combustible Gas Sample Draw Detector Head Operator s Manual
Model 1017-07 Combustible Gas Sample Draw Detector Head Operator s Manual Part Number: 71-0480 Revision: P1 Released: 1/4/19 www.rkiinstruments.com WARNING Read and understand this instruction manual before
More informationOwner s Manual Nitrate Series Salt Based Filter System
Owner s Manual Nitrate Series Salt Based Filter System Page 2 Copyright 2012 Enviro Water Solutions Inc. All rights reserved. All information contained herein is the property of Pelican Water Systems.
More informationCOMPACT GLYCOL FEED SYSTEMS OPERATION & MAINTENANCE MANUAL
COMPACT GLYCOL FEED SYSTEMS OPERATION & MAINTENANCE MANUAL Model Number: Service: Serial Number: Installation Date: Installation Location / Application: PLEASE RECORD THE FOLLOWING DATA (Information is
More informationLifeGuardLift. LifeGuard Power Lift Model #100287A OWNERS MANUAL. Rev: 2/14/11
LifeGuardLift OWNERS MANUAL LifeGuard Power Lift Model #100287A Rev: 2/14/11 Table of Contents 1. ASSEMBLY INSTRUCTIONS A. Lift Assembly B. Setup C. Disassembly 2. CONTROL SYSTEM A. Batteries B. Battery
More informationOwner s Guide. ca5154
PROFESSIONAL SERIES Owner s Guide for models: ca5154 Automatic / Manual Transmission Remote Start and Keyless Entry System IMPORTANT NOTE: The operation of the Security and Convenience System as described
More informationCLEAN ROOM DEVICES, LLC "WHERE TUBING AND FITTINGS COME TOGETHER"
CLEAN ROOM DEVICES, LLC "WHERE TUBING AND FITTINGS COME TOGETHER" CRD400 Fitting Inserter OPERATIONS MANUAL VERSION 3.1 LAST EDITED 03.08.11 DOCUMENT NUMBER 001 cleanroomdevices.com 1 Table of Contents
More informationOwners Manual. LifeGuard Power Lift Model # Rev. 2/1/13
Owners Manual LifeGuard Power Lift Model #100287 Rev. 2/1/13 Table of Contents 1. ASSEMBLY INSTRUCTIONS 3-5 A. Lift Assembly 3 B. Setup 3 1. Clinch Pin Location Drawings 4 2. Down Tube and Seat Assembly
More informationModel Combustible Gas Sample Draw Detector Head Operator s Manual
Model 1017-01 Combustible Gas Sample Draw Detector Head Operator s Manual Part Number: 71-0058RK Revision: B Released: 5/24/13 www.rkiinstruments.com WARNING Read and understand this instruction manual
More informationWARRANTY POLICY FOR LD SERIES LABEL DISPENSERS REPAIR POLICY
TDA025B INTRODUCTION Thank you for buying our automatic tape dispenser. The TDA025 can automatically cut and dispense many types of tape. Before using, please read this instruction manual carefully. WARRANTY
More informationDispenser & Warmer RIC-1909 RIC-1909EXP
Dispenser & Warmer RIC-1909 RIC-1909EXP Safety Precautions CAUTION This equipment is designed and sold for commercial use only. This equipment is not to be used by the consumer in home use. Do not allow
More informationInstallation, Operation and Maintenance Manual
IOM-HS-QTColdBevMax Installation, Operation and Maintenance Manual QT TM Cold Bev Max TM Models: QTCLDBMX-1S-.5M, QTCLDBMX-2S-.5M, QTCLDBMX-3S-.5M, QTCLDBMX-4S-.5M, QTCLDBMX-5S-.5M Tested and Certified
More informationSOLAR DASH CHARGING SYSTEM USER GUIDE
SOLAR DASH CHARGING SYSTEM Doc 1.01 INST049 INSTALLATION STEP 1 Place 20 watt solar panel in the dash of the vehicle facing up. Note: For ideal results position the vehicle in a manner in which the solar
More informationModel HPX60 Series Automatic Battery Charger User s Manual Rev. 1.0 October 17, 2006
B R A N D Model HPX60 Series Automatic Battery Charger User s Manual Rev. 1.0 October 17, 2006 For Sales, Support and Service phone: 407-331-4793 fax: 407-331-4708 website: www.xenotronix.com email: information@xenotronix.com
More informationInstruction Manual. Fudge Puppy Display Case
Instruction Manual Fudge Puppy Display Case Model No. 5535 10700 Medallion Drive, Cincinnati, Ohio 45241-4807 USA 2014 Gold Medal Products Co. Part No. 89074 SAFETY PRECAUTIONS DANGER Machine must be properly
More informationSUNC1200 / ITEM #40882 SUBMERSIBLE UTILITY PUMP OPERATIONS MANUAL
SUNC1200 / ITEM #40882 SUBMERSIBLE UTILITY PUMP OPERATIONS MANUAL WWW.SUNRUNNERPOOL.COM Performance Model HP GPH of Water @ Total Feet Of Lift 0 ft. 5 ft. 10 ft. 15 ft. 20 ft. 25 ft. Max. Lift SUNC1200
More informationCOLT CELL BATTERY CHARGER Installation and Operating Instructions
COLT CELL BATTERY CHARGER Installation and Operating Instructions INSTALLATION All COLT chargers are for indoor use only. All COLT chargers are designed for installation into the battery tray. Charging
More informationCA 5054 Owner s Guide
PROFESSIONAL SERIES CA 5054 Owner s Guide Remote Start and Keyless Entry System IMPORTANT NOTE: The operation of the Security and Convenience System as described in this manual is applicable to most vehicles.
More informationSpotlight 1,000,000 Power Series Cordless Rechargeable
VEC156CFL_Manual_012405 1/24/05 4:29 PM Page iv VEC156 Spotlight 1,000,000 Power Series Cordless Rechargeable OWNER S MANUAL & WARRANTY INFORMATION 53SB E231887 IMPORTANT SAFETY INFORMATION, SAVE THESE
More informationCAMBELT TENSION GAUGE
CAMBELT TENSION GAUGE Model 96557 Operating Instructions Diagrams within this manual may not be drawn proportionally. Due to continuing improvements, actual product may differ slightly from the product
More information1250 LB. CAPACITY MECHANICAL WHEEL DOLLY
1250 LB. CAPACITY MECHANICAL WHEEL DOLLY 67287 SET-UP AND OPERATING INSTRUCTIONS Visit our website at: http://www.harborfreight.com Read this material before using this product. Failure to do so can result
More informationAnthro Mobile Device Charging Carts and Cabinets Owners Manual
Anthro Mobile Device Charging Carts and Cabinets Owners Manual TECHNOLOGY FURNITURE Hello! Thank you for choosing Anthro. Anthro's Tablet Charging Carts and Cabinets are designed to automatically charge
More informationTALCO FIRE SYSTEMS. LSF Start-Up Instructions. 1) IMPORTANT: Inspect the unit for damage. Report any damage to the freight carrier immediately.
LSF Start-Up Instructions 1) IMPORTANT: Inspect the unit for damage. Report any damage to the freight carrier immediately. 2) PRE-START-UP: Be sure there is water in the pump. Bleed air at all high points
More informationSUNC3000 / Item #40885
SUNC3000 / Item #40885 AUTOMATIC POOL COVER PUMP OPERATIONS MANUAL WWW.SUNRUNNERPOOL.COM 1 . Performance GPH of Water @ Total Feet Of Lift MODEL HP Max. Lift 0 ft. 5 ft. 10 ft. 15 ft. 20 ft. SUNC3000 1/3
More informationModel NTX7 Series Automatic Battery Charger User s Manual Rev. 1.0 October 17, 2006
B R A N D Model NTX7 Series Automatic Battery Charger User s Manual Rev. 1.0 October 17, 2006 For Sales, Support and Service phone: 407-331-4793 fax: 407-331-4708 website: www.xenotronix.com email: information@xenotronix.com
More information25 GALLON PORTABLE OIL LIFT
25 GALLON PORTABLE OIL LIFT Model 92859 SET UP AND OPERATING INSTRUCTIONS Diagrams within this manual may not be drawn proportionally. Due to continuing improvements, actual product may differ slightly
More informationPVI 60KW, PVI 82KW, PVI 95KW
PVI 60KW PVI 82KW PVI 95KW WARRANTY MANUAL Commercial, Grid-Tied Photovoltaic Inverters 2008, Solectria Renewables LLC Subject to Change DOC-020099 rev 024 1 1 Product Warranty & RMA Policy Warranty Policy
More informationRK Standby Battery Operator s Manual
49-8103RK Standby Battery Operator s Manual Part Number: 71-0117RK Revision: 0 Released: 8/18/08 www.rkiinstruments.com Product Warranty RKI Instruments, Inc., warrants gas alarm equipment sold by us to
More informationDROP-IN RACK DISPENSERS Models: DI-1020, DI-1216, DI-1418, DI-1620, DI-2020 Intended for other than household use
DESIGNED SMART. BUILT SOLID. INSTALLATION AND OPERATING INSTRUCTIONS DROP-IN RACK DISPENSERS Models: DI-1020, DI-1216, DI-1418, DI-1620, DI-2020 Intended for other than household use WARNING: California
More informationCardinal DETECTO. PORTABLE PLATFORM SCALES Digital Type Series 850F Owner s Manual
Cardinal DETECTO PORTABLE PLATFORM SCALES Digital Type Series 850F Owner s Manual CARDINAL SCALE MFG. CO. PO BOX 151, WEBB CITY, MO 64870 0066-M176-O1 Rev H 10/06 417-673-4631 www.cardinalscale.com Printed
More informationBRAVO Inverter/Battery Charger. Table of Contents
BRAVO 1050 Inverter/Battery Charger Table of Contents Introduction... 2 General Description... 2 Specifications... 3 Installation: Hardwire Units... 4 Operation: Hardwire Units... 5-6 Installation: GFCI
More informationCaution. Do not operate your Micro Rain traveler without a serious overview of this manual. Keep children and unauthorized people away from traveler
Thank you for purchasing a Micro Rain MR25 traveling sprinkler system. Please read this manual carefully before operation in order to become familiar with all components and their function. Safety is the
More informationAir Operated Double Diaphragm Pump. M-Pump ½ Metallic Non Metallic Pump INSTALLATION, OPERATION & MAINTENANCE MANUAL
Air Operated Double Diaphragm Pump M-Pump ½ Metallic Non Metallic Pump INSTALLATION, OPERATION & MAINTENANCE MANUAL 0.5 I.O.M rev 05. 12/2015 INDEX Title Section Introduction.1 Safety.2 Warranty, General
More informationActive Controlled Cooling System
Active Controlled Cooling System April 2011 3267 Progress Dr Orlando, FL 32826 www.apecor.com Preliminary www.apecor.com Table of Contents General Information... 3 Safety... 3 Introduction... 3 What s
More informationPVI 1800/PVI Residential/Commercial Grid-Tied Photovoltaic Inverter WARRANTY MANUAL. Subject to Change REV , Solectria Renewables
PVI 1800/PVI 2500 WARRANTY MANUAL Residential/Commercial Grid-Tied Photovoltaic Inverter 2009, Solectria Renewables Subject to Change REV 10.09 1 Product Warranty & RMA Policy 1.1 Warranty Policy The Solectria
More informationGW-120 Bar Glass Washer
GW-120 Bar Glass Washer This manual contains important information regarding your Admiral Craft unit. Please read this manual thoroughly prior to product setup, operation and maintenance. Failure to comply
More informationOwner s Guide CARS & CA4B5
PROFESSIONAL SERIES Owner s Guide For Model: CARS & CA4B5 Deluxe Vehicle Remote Start and Keyless Entry System IMPORTANT NOTE: The operation of the Security and Convenience System as described in this
More informationArch HTH Water Chemicals Commercial Equipment Trouble Shooting Guide
Arch HTH Water Chemicals Commercial Equipment Trouble Shooting Guide 8/28/00 TROUBLESHOOTER S GUIDE PROBLEM CAUSE SOLUTION Insufficient water flow to chlorinator Check water flow through Flow Controller
More informationGLOBE FLOWCELL. Operating Manual. Rola-Chem Flowcell PN /01/2013 page: 1 of 8
GLOBE FLOWCELL Operating Manual Rola-Chem Flowcell PN 550182 4/01/2013 page: 1 of 8 Table of Contents Section title Page 1.0 Safety Instructions 2 2.0 Description 2 3.0 Installation 3 4.0 Use of Manifold
More informationBattery Powered Hydraulic Pump; Kit PN [ ]
ORIGINAL INSTRUCTIONS Battery Powered Hydraulic Pump; Kit PN 1804111-[ ] Customer Manual 409-10060 16 NOV 16 Rev D SAFETY PRES IMPORTANT SAFETY INFO READ THIS FIRST!... 2 SAFETY PRES AVOID INJURY READ
More informationOwner s Guide CA 5055
PROFESSIONAL SERIES Owner s Guide For Model: CA 5055 Vehicle Remote Start and Keyless Entry System IMPORTANT NOTE: The operation of the Security and Convenience System as described in this manual is applicable
More information18VDC ESB6 Series Cordless Screwdrivers Operation Manual
18VDC ESB6 Series Cordless Screwdrivers Screwdriver Models : ESB6-8, ESB6-12, ESB6-15, ESB6-22 CAUTION - Please read, understand, and follow all operating and safety instructions in this manual before
More informationOWNER'S MANUAL & INSTALLATION INSTRUCTIONS 6500 Series
OWNER'S MANUAL & INSTALLATION INSTRUCTIONS 6500 Series "You push our buttons, we pour your drink!" SIDEBAR BEVERAGE SYSTEMS INC. (800)775-6150 PHOENIX, AZ Congratulations!! You are now the proud owner
More informationInstallation, Operation and Maintenance Manual
IOM-HS-QTCubeMax Installation, Operation and Maintenance Manual QT TM Cube Max TM Models: QTCBMX-1S-1M, QTCBMX-2S-1M, QTCBMX-3S-1M, QTCBMX-4S-1M, QTCBMX-1L-1M, QTCBMX-2L-1M, QTCBMX-3L-1M, QTCBMX-4L-1M,
More informationBOSS 107 SEPARATOR SYSTEM INSTALLATION & APPLICATION MANUAL
Website: www.recoveredenergy.com Email: oilwatersales@recoveredenergy.com BOSS 107 SEPARATOR SYSTEM INSTALLATION & APPLICATION MANUAL BOSS 2.2T/107 BOSS 5T/107 BOSS 11T/107 BOSS 25T/107 BOSS 45T/107 Installation
More informationII DISTRIBUTION & SUBSTATION TYPE C
CapCheckIII DISTRIBUTION & SUBSTATION TYPE Ca p a c i t o r C h e c ke r Operating & Instruction Manual 1475 Lakeside Drive Waukegan, Illinois 60085 U.S.A. 847.473.4980 f a x 8 4 7. 4 7 3. 4 9 8 1 w e
More informationRK Standby Battery Operator s Manual
49-8104RK Standby Battery Operator s Manual Part Number: 71-0118RK Revision: C Released: 8/4/17 www.rkiinstruments.com Product Warranty RKI Instruments, Inc. warrants gas alarm equipment sold by us to
More informationCentrifugal Separator Operations & Maintenance Manual
Centrifugal Separator Operations & Maintenance Manual Record Your Model, Serial Number and Other Information on the back of this document. Manufacturing: Bypass & Filter Feeders, Glycol Feed Packages,
More informationPENBERTHY MODELS GL AND GH GAS OPERATED JET PUMPS INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS
Before installation, these instructions must be read carefully and understood. PRODUCT WARRANTY Emerson warrants its Penberthy products as designed and manufactured to be free of defects in the material
More informationAdvanced Netbook Charging Carts for 10 laptops or 20 netbooks
Advanced Netbook Charging Carts for 10 laptops or 20 netbooks Owners Manual TECHNOLOGY FURNITURE Hello! Thank you for choosing Anthro. This unit has been tested to Underwriters Laboratories U.S. and Canadian
More informationSUBMERSIBLE POND PUMP
SUBMERSIBLE POND PUMP 258 Gallons Per hour 47117 ASSEMBLY AND OPERATING INSTRUCTIONS 3491 Mission Oaks Blvd., Camarillo, CA 93011 Visit our Web site at http://www.harborfreight.com Copyright 2002 by Harbor
More informationAdvanced Calibration Designs, Inc. Release II
Advanced Calibration Designs, Inc. Release II www.goacd.com WARNING: This instrument generates test gas for toxic gas detectors. The instruction manual should be read and understood prior to operation
More informationOWNER S MANUAL GUZZLER MODEL 620 READ THESE INSTRUCTIONS BEFORE USING
OWNER S MANUAL GUZZLER MODEL 620 OPERATION MAINTENANCE TROUBLE SHOOTING REPAIR PARTS WARRANTY READ THESE INSTRUCTIONS BEFORE USING 201 COMMERCE DRIVE MONTGOMERYVILLE, PA 18936 215-393-4700 800-331-1423
More informationPower. On Your Terms.
Power. On Your Terms. 10 YEAR LIMITED WARRANTY PHI 1310 TM 1 SIMPLIPHI POWER, INC. REV102016 10 YEAR LIMITED WARRANTY: PHI 1310 TM LIMITED PRO-RATED WARRANTY COVERAGE The SimpliPhi Power PHI 1310 as supplied
More informationINVERTER HARNESS INSTALLATION FOR FREIGHTLINER CASCADIA
FOR FREIGHTLINER CASCADIA Part #: P808 1004FC 08/05/2014 Doc 1.04 INST065 Page 1 Step 1: Unpack the plate assembly and both positive and negative cables. INSTALLATION INSTRUCTIONS Step 2: Insert the negative
More informationTERMS OF USE TERMS AND CONDITIONS. Plumbing and Heating Products (PL-WR)
TERMS OF USE 1. Watts pricing and product data is subject to change without notice and such changes supersede all previous versions. 2. Watts data is to be used as provided. Watts is not responsible for
More informationTop Mount Food Wells Models: TM-90, TM-90D
DESIGNED SMART. BUILT SOLID. REPLACEMENT PARTS AND WIRING DIAGRAM Top Mount Food Wells Models: TM-90, TM-90D INTENDED FOR OTHER THAN HOUSEHOLD USE WARNING: California Residents Only. This product can expose
More informationG1000 Feeder IMPORTANT INFORMATION
INSTALLATION GUIDE G1000 Feeder IMPORTANT INFORMATION Table of Contents Introduction...3 Installation...3 Exploded Parts Diagram...10 Operation...11 Feeder Overview...11 Filling the Feeder...11 Use of
More informationF PRO. 12 Volt Electric Sprayer. Part #AS76 Copyright 2014 by Hydro-Force Rev. 1/14
F PRO SPRAYER by 12 Volt Electric Sprayer Part #AS76 Copyright 2014 by Hydro-Force Rev. 1/14 Table of Contents Feature and Benefits... 3 Specifications... 3 Complete Sprayer Diagram... 4 Complete Sprayer
More informationPreSoak System (NonFoaming) DU PS1-HP DU PS6-HP
PreSoak System (NonFoaming) DU PS1-HP DU PS6-HP Serial Number: Owner s Manual #0786 040810 Installation Date: Please read and u n d e r s t a n d t h i s manual. Store in safe location for future reference.
More informationManual. Economy Glycol Feeder. Installation Maintenance Repair Manual
Manual Economy Glycol Feeder Installation Maintenance Repair Manual Advantage Controls P.O. Box 1472 Muskogee, OK 74402 Phone: 800-743-7431 Fax: 888-686-6212 www.advantagecontrols.com email: support@advantagecontrols.com
More informationTransfer Switch GPTS 30
Transfer Switch GPTS 30 Owner s Manual Table of Contents Introduction 2 Installation 3 Operational Testing 7 Troubleshooting 8 Hi-Pot Testing 9 Generator Note 10 Medical Appliances 10 Caution 10 Warranty
More informationFeatures and Benefits Wide Bottom: Translucent Bottle: 2 1/2 Gallon Bottle: Removable Bottle: Large cap: 15 Feet of Coiled Hose:
12 Volt Battery Powered Sprayer This unit uses a lead acid battery. The charge capacity of the battery can be greatly diminished if fully discharged. Care should be given to charge the battery between
More informationRemove utility bag from plastic and install onto pivot arm with attached straps. Install utility bag with zippers facing away from machine.
Owner s Manual Packing List: C3XP Unit Spray gun w/ 2 settings 12-volt battery Telescoping handle Removable Cleaning Caddy Pivot arm Utility Bag 10 Gallon water reservoir (integral) 17 ft. discharge hose
More informationNo. 38 Water Tower Owner s Manual /01
No. 38 Water Tower Owner s Manual 71-4086-250 3/01 Congratulations! Congratulations on your purchase of the Lionel No. 38 Water Tower. The water tower is made of detail-molded plastic and die-cast construction
More informationHeavy Duty Engine Cranes
Heavy Duty Engine Cranes Operating Instructions & Parts Manual Model Number Atd-7484 Atd-7485 (Foldable Legs) Capacity 2 Ton 2 Ton Model Atd-7484 Model Atd-7485 Atd Tools Inc. 160 Enterprise Drive, Wentzville,
More informationSHOP PRO FXP TECHNICAL MANUAL. FOR ADDITIONAL INFORMATION, VISIT TABLE OF CONTENTS
SHOP PRO FXP TABLE OF CONTENTS Applications and Features...1 Shop Pro FXP Components...2 EEImportant Safety Precautions.... 3 Set-up and Maintenance...4 Hoses and Adapters....5 Hose Connections for Priming...6
More informationHeated Bakery Merchandiser Series. Series: WBC Operation Manual
Heated Bakery Merchandiser Series Series: WBC Operation Manual WHAT IS COVERED WHO IS COVERED COVERAGE PERIOD WARRANTY COVERAGE EXCEPTIONS EXCLUSIONS INSTALLATION BKI LIMITED WARRANTY 2812 Grandview Drive
More informationSOLAR BOLT CHARGING SYSTEM INSTALLATION GUIDE
CHARGING SYSTEM Doc 1.00 INST052 1 SOLAR BOLT CHARGING SYSTEM CONTENTS General Information... 2 Solar Panel Installation... 3 Solar Bolt Main Harness and Indicate Installation... 4 Cable Routing... 9 Solar
More informationPerformance Zone Assembly and Maintenance Manual
Performance Zone Assembly and Maintenance Manual 1 INTRODUCTION KEISER CORPORATION has always taken pride in designing and engineering the highest quality equipment on the market. This means that you will
More informationPresoak & Tire/Engine Cleaner Systems (Air Pump) DU TC_A & DU PS_A
Presoak & Tire/Engine Cleaner Systems (Air Pump) DU TC_A & DU PS_A Owner s Manual #0795 Customer Number: Model Number: Serial Number: Installation Date: IMPORTANT Please read and u n d e r s t a n d t
More informationGEARHEAD LIMITED WARRANTY FOR REMANUFACTURED ENGINES
GEARHEAD LIMITED WARRANTY FOR REMANUFACTURED ENGINES GEARHEAD Engines distributes a broad range of new, recycled, remanufactured and reconditioned automotive and truck replacement products. Our remanufactured
More informationMGFHVLP. Instructions/Parts. Mini Gravity Feed System E. Part No Includes MGFHVLP Mini Gravity Feed Spray Gun and MGC 125 Gravity Cup.
Instructions/Parts MGFHVLP Mini Gravity Feed System FOR PRODUCT INFORMATION CALL: 1-800-742-7731 309989E For gravity feed spraying of automotive colors and clears. Ideal for touch-up and detail work. Important
More informationMPT-250B SPECIFICATIONS AND OPERATING INSTRUCTIONS
1. SAFETY The MPT-250B Wire Crimp Pull Tester is a force measurement device, and as such should be operated with due caution. Operators should wear safety glasses for eye protection because the crimp under
More informationBNT 85 /185 Valve Operation Manual
BNT 85 /185 Valve Operation Manual Note: 1. Read all instructions carefully before operation. 2. Avoid pinched o-rings during installation by applying (provided with install kit) NSF certified lubricant
More informationSwing Arm Magnifying Lamp
Owner s Manual & Safety Instructions Save This Manual Keep this manual for the safety warnings and precautions, assembly, operating, inspection, maintenance and cleaning procedures. Write the product s
More informationBottom Loading Water Dispenser
Bottom Loading Water Dispenser Model # 601000 TO REDUCE THE RISK OF INJURY AND PROPERTY DAMAGE, USER MUST READ THIS MANUAL BEFORE ASSEMBLING, INSTALLING & OPERATING DISPENSER. SAVE THIS MANUAL FOR FUTURE
More information