RedGum GP160 Splitter. Owner s Manual
|
|
- Betty Wilkins
- 6 years ago
- Views:
Transcription
1 RedGum GP160 Splitter Owner s Manual Product Description & Intended Purpose: This Log Splitter / Wood Splitter is an outdoor product that splits wood logs for use as fuel in a fireplace or a woodstove. Read this manual, before operating RedGum Splitter.
2 Read this manual, before operating RedGum Splitter. Serious injury or death can result if safety instructions are not followed. RedGumSplitter is assembled and ready for use however, - Verify hydraulic oil level can be seen in the sight glass on the Hydraulic oil reservior tank. - Check engine oil level by sighting engine dip stick. - Closely inspect all log splitter components. - If you sight damaged components then contact your RedGum dealer before use. - Always wear safety glasses while operating this logsplitter. Hazard Signal Word Definition This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death. Table of Contents Important Safety Rules Log Splitter Component Definitions Operation Instructions Proper Operation of the Log Splitter How to split the log with slant surface Horizontal & Vertical Operating Modes Vehicle Towing Maintenance and Storage DANGER DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. Engine Specifications 12 Engine Operation 13 indicates a potentially hazardous situation which, if not avoided, will result in death or serious injury. Engine Maintenance 14 CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, could result in minor or moderate injury. Troubleshooting Specifications
3 IMPORTANT SAFETY RULES 1.) Read this manual completely. Serious injury or death can result if safety instructions are not followed. Everyone who operates the log splitter must read and completely understand all safety rules, operating instructions, and maintenance instructions. You must be 16 or older to operate this logsplitter. 2.) Crush Hazard & Work Zone. Splitter wedge (4) can cut through skin and break bones. Keep both hands away from splitter wedge (4) and endplate (7). - Serious accidents can happen when other people are allowed inside the work zone (See Work Zone Diagram page 7). Keep everyone else out of the work zone while operating control valve (3). - Do not wear loose clothing. It can get tangled in moving parts of log splitter. - Only use the log splitter in daylight so you can see what you are doing. 3.) Flying Objects Pieces of log may fly out while splitting. Wear safety glasses. Serious eye injury can occur. 4.) Skin injection hazard. High pressure fluid can inject under skin resulting in serious injury requiring amputation. - Make sure all hose and control fittings are tight before applying pressure. Relieve system pressure before servicing. - Do not check for leaks with hand. Instead, place a piece of cardboard under the unit to check for leaks. - If skin injection happens, seek immediate Surgical Treatment. Call ) Risk of fire and explosion. Hot exhaust fumes from engine can cause fire. Petrol is highly flammable and explosive. You can be burned or seriously injured when handling fuel. - Position muffler at least 2 metres from combustible objects. - Before adding fuel, stop the engine and keep heat, sparks and flame away. - Do not add fuel when engine is running or still hot. No smoking near engine. - Do not pump fuel directly into engine at petrol station. Static charge can build and ignite fuel. Use a ULP approved fuel container to transfer petrol to the engine. Wipe up fuel spills immediately. - Only store and handle fuel outdoors. Petrol vapors can ignite if they collect inside an enclosure. Explosion can result. - Do not change or add to exhaust system. Fire can result. - Do not change or add fuel tanks or fuel lines. Fire can result. - Before each use, check fuel tank and fuel lines for leaks. Any fuel leak is a fire hazard. Fix any fuel leaks before starting engine. - During transportation take precautions to make sure machine will not tip over and cause a fuel leak fire hazard. 1.) Hot Muffler. You can be burnt by the muffler. Do not touch. CAUTION 5.) Towing Hazard. Serious injury or death can occur if towing safety rules are not followed. - Review towing safety warnings in your towing vehicle manual. - Drive safely. Be aware of the added length of the log splitter. - Never ride or transport cargo on the log splitter. - Drive the vehicle with the log splitter securely attached. - Turn off the vehicle before leaving the log splitter unattended. - Choose a level surface to operate the log splitter - Block the log splitter wheels to prevent unintended movement. - Never tow or operate this splitter while under the influence of alcohol, drugs or medication. - The RedGumSplitter should not be towed at speeds exceeding 30km per hour. - The RedGumSplitter is designed for towing around owners property and should never be towed on public roads or highways 6.) Breathing Hazard. Poisonous fumes from engine can kill you. Do not operate indoors even if ventilated. For outdoor use only. Save these important safety rules for later reference
4 LOG SPLITTER COMPONENT DEFINITIONS 5 OPERATION INSTRUCTIONS Proper Operation of the Log Splitter ) Follow Safety Instructions. 2.) Load a log onto the beam (6) and against the endplate (7). See next page for instructions on splitting logs with a slant or uneven surfaces. 3.) Serious accidents can happen when other people are allowed inside the work zone (see diagram below). Keep everyone else out of the work zone while operating control valve (3). 4.) Make sure hands are clear of crush hazard zone. 5.) Push and hold control valve handle (3) FORWARD to split log. 6.) Pull control valve handle (3) BACKWARD to return wedge to its original position. 7.) Clear the split wood from the work zone. 8.) Repeat above steps as required ) 2 Coupler - Attaches the log splitter to the 2 ball. 2.) Hydraulic Cylinder - 4 bore and 23 stroke, rated at 3500psi 3.) Control Valve Lever - Controls the forward and backward movement of splitting wedge. 4.) Splitter Wedge - Features wedge wings and tapered ends making splitting easier. 5.) Log Cradle - Holds the log on the beam without operator assistance. 6.) Beam - 6 extra wide flange. 7.) End Plate - Supports logs in position. 8.) Engine - Genuine Honda GP160 Engine 9.) Tyres - Maximum rated towing speed is 30 MPH. 10.) Gear Pump - Pumps the hydraulic oil through the system. 11.) Support Legs - Supports the log splitter while operating. 12.) Safety Chains - Safety feature to prevent loss of log splitter while towing 6. Crush Hazard Zones - Crash Hazard. Wedge can cut through skin and break bones. Keep both hands away from wedge and beam endplate. - While operating the log splitter safety glasses must be worn at all times. - Serious accidents can happen when other people are allowed inside the work zone. Keep everyone else out of the work zone while operating control valve. - Do not wear loose clothing. It can get tangled in moving parts of log splitter. - Only use the log splitter in daylight so you can see what you are doing. 7.
5 OPERATION INSTRUCTIONS CONTINUED HOW TO SPLIT A LOG WITH SLANT (OR UNEVEN) SURFACE Correct operating procedures are required to ensure your RedGum GX200 logsplitter is not damaged. Incorrect operation can result in bending the beam or end plate, and is not a manufacturers fault and subsequently is not covered under warranty. OPERATION INSTRUCTIONS CONTINUED FOR HORIZONTAL USE: i.) Before use in horizontal position, rotate rear leg down and lower front leg. Secure both legs with holding pins. ii.) Ensure beam lock pin is correctly positioned. Incorrect Operation i.) Holding Pin i.) Holding Pin ii.) Beam Lock Please note image for illustration purposes only. FOR VERTICAL USE: a.) Release Beam by pulling beam lock pin b.) Lift the beam at the end side, and rotate it down slowly. c.) Secure Beam in vertical position by securely fitting vertical holding pin. Correct Operation b.) Beam End Handle a.) Beam Lock Pin c.) Holding Pin Please note image for illustration purposes only
6 OPERATION INSTRUCTIONS CONTINUED FOR VEHICLE TOWING: 1.) Press handle down and lock tightly 2.) Rotate rear leg and slide the lock pin 3.) Raise front leg up and slide the lock pin 4.) Hook safety chain to towing vehicle MAINTENANCE AND STORAGE Before performing maintenance, the log splitter must be placed in maintenance mode. To do so follow these steps: 1.) Turn off engine. 2.) Move the control valve handle (3) forward and backward to relieve hydraulic pressure. After performing maintenance, make sure all guards, shields and safety features are put back in place. Failure to follow this warning can result in serious injury. Refer to engine section for engine maintenance. 1. Press handle down and lock tightly 2. Rotate rear leg up and slide the lock pin 3. Raise front leg up and slide the lock pin 4. Hook safety chain to towing vehicle What When How Hoses Inspect for exposed wire mesh & leaks. Replace all worn or damaged hoses before starting engine. Hydraulic Fittings Inspect for cracks & leaks. Replace all damaged fittings before starting engine. Nuts & Bolts Check for loose bolts Beam Apply grease to beam surface Moving Parts Clear debris Towing Hazard. Serious injury or death can occur if towing safety rules are not followed. - Review towing safety warnings in your towing vehicle manual. - Drive safely. Be aware of the added length of the log splitter. - Never ride or transport cargo on the log splitter. - Drive the vehicle with the log splitter securely attached. - Turn off the vehicle before leaving the log splitter unattended. - Choose a level surface to operate the log splitter - Block the log splitter wheels to prevent unintended movement. - Never tow or operate this splitter while under the influence of alcohol, drugs or medication. - The RedGum Splitter is designed for towing around owners property and should never be towed on public roads or highways - The RedGum Splitter should not be towed at speeds exceeding 30km per hour. 10. Skin injection hazard. High pressure fluid can inject under skin resulting in serious injury including amputation. - Make sure all hose and control fittings are tight before applying pressure. Relieve system pressure before servicing. - Do not check for leaks with hand. Instead, place a piece of cardboard under the unit to check for leaks. - If skin injection happens, seek immediate Surgical Treatment. Call
7 ENGINE SPECIFICATIONS Type ENGINE OPERATION HONDA GP160 Air cooled 4-stroke OHV Weight STARTING THE ENGINE COLD 1. Turn the engine switch to ON position 2. Pull the choke rod out to CLOSE position 3. Turn the fuel tap to RUN 4. Raise the throttle lever slightly. 5. Pull the starter grip lightly until resistance is felt, then pull briskly. 6. Push the choke rod in to OPEN as the engine warms. 7. CAUTION Do not allow the starter grip to snap back. Return it slowly by hand. 14.9kg Dimensions 306mm x 363mm x 335 mm Displacement 163 cm3 Bore x Stroke Net Power Output Max. Net Torque P.T.O. Shaft Rotation Ignition System Starting System Fuel Tank Capacity Fuel Type Engine Oil Capacity 68 x 45 mm 3.6 kw (4.9 3,600 rpm 10.3 Nm (1.05 2,500 rpm Counterclockwise STOPPING THE ENGINE Transistor magneto 1. Move the throttle lever down fully. 2. Turn off fuel tap. 3. Turn the engine switch to the OFF position. Recoil Starter 3.1 Litre Unleaded 86 Octane or higher 0.58 Litre STARTING THE ENGINE HOT COMPONENT IDENTIFICATION Muffler Air Cleaner SAFETY INSTRUCTIONS Spark Plug Fuel Filler Cap Fuel Tank Starter Grip Engine Control Types Choke Lever Oil Drain Plug Oil Filler Cap Fuel Valve Lever Recoil Starter 1. Turn the engine switch to ON position 2. Raise the throttle lever slightly. 3. Turn the fuel tap to RUN position 4. Pull the starter grip lightly until resistance is felt, then pull briskly. - Do not use in a confined area. - Beware exhaust gases are harmful, avoid intake. - Inclination of engine should not exceed 20 during operation. - Keep flammables away from RedGum Splitter at all times. - When refueling: Stop engine. Do not spill fuel. No smoking while refueling. Engine Switch Throttle Lever Choke Lever
8 CLEANING AIR FILTER Check before use. Clean annually or every 50 hours of use. Clean more frequently as required. 1. Open the air cleaner cover and remove the air cleaner element. 2. Check for dirt in the air cleaner element. 3. Clean the air cleaner element by washing in water then sqeezing excess water out. Then soak in oil before sqeezing excess oil off before replacing in machine and closing the air cleaner cover. REPLACING SPARK PLUG Change as required, or every 100 hours of use. 1. Remove the plug. 2. Replace with new NGK BR4HS 3. Tighten the plug carefully. CAUTION Always use genuine spare parts only. OIL CHANGE Initial oil change required after 10 hours of operation, then change oil every 50 hours of operation. 1. Remove the oil filler cap 2. Remove the drain bolt and drain oil. Tighten the drain bolt. 3. Fill the new oil to the edge of the oil filler neck, 4. Tighten the oil filler cap. Recommended Engine Oil: SAE 10W-30 ENGINE STORAGE 1. Drain the fuel from the fuel tank. 2. Turn fuel tap off. 3. Consume the fuel from the carburetor by running engine with fuel tap off until it stops. 4. Store the engine in a clean area. ENGINE TROUBLESHOOTING ENGINE DOES NOT START 1. Is the engine switch OFF? 2. Check fuel. 3. Check oil. 4. Check spark plug. 5.Check spark plug for spark. 6. Is the fuel reaching the carburetor? ENGINE MAINTENANCE For further engine instructions please refer to the engine manual supplied with this machine. Problem LOG SPLITTER TROUBLESHOOTING Cylinder rod & splitting wedge will not move Slow cylinder shaft speed when extending or retracting Wood will not split or splits extremely slowly Engine bogs down during splitting Engine stalls under low load condition Cause A - Insufficient oil to pump B - Air in oil C - Excessive pump inlet vacuum D - Blocked hydraulic lines E - Blocked control valve F - Low control valve setting G - High control valve setting H - Damaged control valve I - Internal control valve leak J - Internal cylinder leak K - Internally damaged cylinder L - Engine control out of adjustment M - Engine is loaded during idle down mode Solution: A, D, E, H, J Solution: A, B, C, H, I, K, L Solution: A, B, C, F, I, K Solution: G, L Solution: D, E, L, M Solution Check oil level in reservoir Check oil level in reservoir Check pump inlet hose for blockage or kinks Flush & clean the splitter hydraulic system Flush & clean the splitter hydraulic system Adjust control valve with a pressue gauge Adjust control valve with a pressue gauge Return control valve for authorised repair Return control valve for authorised repair Return cylinder for authorised repair Return cylinder for authorised repair Return for authorised repair Use shorter log length (24 or less) to allow engine to speed up before contact
9 SPECIFICATIONS Ram Force Cycle Time Hydraulic Tank Capacity Wedge Size Wheel Size Max. Log Length Max. Log Weight Max. Towing Speed Cylinder Size Hydraulic Fluid Type Gear Pump Max. Pressure Max. Flow Capacity Overall Dimensions Weight Height Width Length 3000 PSI 15 to 20 Seconds 10 Litres 8 Harden Steel 40mm (16 ) 600mm (24 ) 45kgs (100Lbs) 30Km per hour 4 x 23 ISO-32 and ISO-46 2-Stage 3000 psi 11 GPM 255Kg (560Lbs) 1125mm (45 ) 1 m (40 ) 2.2 m (88 ) The manufacturer reserves the right to make improvements in design and/or changes in specifications at any time without incurring any obligation to install them on units previously sold. 16.
Firewood Processor Operator s Manual SSA400Z
Distribution Limited Firewood Processor Operator s Manual SSA400Z FOR YOUR SAFETY READ AND UNDERSTAND THE ENTIRE MANUAL BEFORE OPERATING THIS MACHINE Warranty Registration Form Model: Serial Number: Type
More informationaccidents which arise due to nonobservance and the safety information herein. SPECIFICATIONS
22 TON LOG SPLITTER Model: 6212 CALIFORNIA PROPOSITION 65 WARNING: You can create dust when you cut, sand, drill or grind materials such as wood, paint, metal, concrete, cement, or other masonry. This
More informationLog Splitter. Owner/Operator Manual. Models HCWP1-26
Log Splitter Owner/Operator Manual Models HCWP1-26 SAFETY..........................2 SAFETY WARNING SYMBOL.........3 SAFETY RULES.................. 4-5 SPECIFICATIONS................. 6 CONTROLS AND FEATURES.......
More information9HP EARTH AUGER W/5 AUGER BIT
9HP EARTH AUGER W/5 AUGER BIT Owner s Manual 1 ! Hazard Signal Word Definition!! DANGER!WARNING!CAUTION! CAUTION This is the safety alert symbol. It is used to alert you to potential personal injury hazards.
More informationOwner s Manual Pressure Washer Pump: For high pressure cleaning machines.
MA578F.2 TM ITEM NUMBERS: A57370, A57398, A57754, A578, A5787, A5783, A5788, A5785, A57820 A578203, A57873 Owner s Manual Pressure Washer Pump: For high pressure cleaning machines. WARNING Read this manual.
More informationOwner s Manual Pressure Washer: Machine that cleans dirty surfaces with high pressure water.
M1577541A TM ITEM NUMBERS: 1577541, 1577542 Owner s Manual Pressure Washer: Machine that cleans dirty surfaces with high pressure water. WARNING Read this manual. Serious injury or death can result if
More informationNo part of this publication may be reproduced without written permission.
Thank you for purchasing a Honda generator. This manual covers operation and maintenance of the EB3000 and EB4000 generators. All information in this publication is based on the latest product information
More informationTrench Filler for Compact Utility Loaders
Form No. 3353-608 Rev A Trench Filler for Compact Utility Loaders Model No. 22472 260000001 and Up Operator s Manual Register your product at www.toro.com Original Instructions (EN) Contents Page Introduction................................
More informationOwner s/operator s Manual
Water Pump MP2533E2 Owner s/operator s Manual Completely read and understand this manual before using this product. Foreword This Owner s/ Operator s Manual is designed to familiarize the operator with
More informationAIR-COOLED DIESEL GENERATOR OWNERʼS MANUAL. This manual contains important safety information. TDG2500E TDGW7000E TDG7000SE TDG4500E
AIR-COOLED DIESEL GENERATOR OWNERʼS MANUAL This manual contains important safety information. TDG2500E TDGW7000E TDG7000SE TDG4500E TDG8000-3 TDG7000SE-3 TDG7000E TDG8000E TDGW7000SE TDG7000E3 TDGW8000E
More informationEarth Auger MAG500 MAG500RS
Earth Auger MAG500 MAG500RS US Owner s/operator s Manual Completely read and understand this manual before using this product. - 0 - Foreword This Owner s/ Operator s Manual is designed to familiarize
More informationTable of Contents. Safety symbols... 3 Assembly 6. Operation Maintenance Troubleshooting 11. Storage. 12. Notes. 13
Table of Contents Safety symbols... 3 Assembly 6 Operation... 8 Maintenance... 10 Troubleshooting 11 Storage. 12 Notes. 13 2 Safety Information Attention; this machine can be dangerous! All operators should
More informationPORTABLE CONCRETE VIBRATOR
PORTABLE CONCRETE VIBRATOR OPERATION MANUAL MODEL PV45S INTRODUCTION We have taken care in the selection, testing and design of this product. Should service or spare parts be required this can be provided
More informationTP300 INDUSTRIAL TRASH PUMP OPERATOR S MANUAL
TP300 INDUSTRIAL TRASH PUMP OPERATOR S MANUAL IT IS EXTREMELY IMPORTANT TO READ AND UNDERSTAND THE ENTIRE CONTENTS OF THIS OPERATOR S MANUAL BEFORE ATTEMPTING TO OPERATE THE PRODUCT. THIS EQUIPMENT IS
More informationOPERATION & MAINTENANCE INSTRUCTIONS
WARNING Read the instructions before using the machine PETROL DRIVEN POWER WASHER MODEL NO: TIGER1700 PART NO: 7320054 OPERATION & MAINTENANCE INSTRUCTIONS LS0511 2 INTRODUCTION Thank you for purchasing
More informationMake/Type/Size/Model Honda Generator EB 3500X & EB5000X Operators Manual Open Well Ventilated Area to Start & Shut Down Machine
HONDA GENERATORS ARE DESIGNED TO GIVE SAFE AND DEPENDABLE SERVICE IF OPERATED ACCORDING TO INSTRUCTIONS. YOU CAN HELP PREVENT ACCIDENTS BY BEING FAMILIAR WITH YOUR GENERATORS CONTROLS AND BY OBSERVING
More information142F 144F GASOLINE ENGINE SM-142F-01A INSTRUCTION MANUAL
142F 144F GASOLINE ENGINE SM-142F-01A INSTRUCTION MANUAL Thank you for purchasing our engine. This manual covers the operation and maintenance of your engine. All information in this publication is base
More informationPF-4000, PF-4010, PF-4210 MULTI-PURPOSE ENGINE
PF-4000, PF-4010, PF-4210 MULTI-PURPOSE ENGINE Date 09-26-01 Supplier To The Outdoor Power Equipment Industry ISM, Inc. 1028 4 th Street SW Auburn, WA 98001 Phone: (253) 333-1200 Fax: (253) 333-1212 WWW.TANAKA-USA.COM
More informationRead instructions carefully and follow rules for safe operation. Failure to do so could result in serious injury. Fradan Manufacturing Corp.
OPERATOR MANUAL FRADAN POWER BLOWERS Part No. 888-011-222-0 Read instructions carefully and follow rules for safe operation. Failure to do so could result in serious injury. Fradan Manufacturing Corp.
More informationGENERATOR MODEL NO: FG3005 OPERATION & MAINTENANCE INSTRUCTIONS PART NO: LS0413
GENERATOR MODEL NO: FG3005 PART NO: 8857707 OPERATION & MAINTENANCE INSTRUCTIONS LS0413 INTRODUCTION Thank you for purchasing this CLARKE Generator. Before attempting to use this product, please read this
More informationHydraulic Immediate Need Power Pack
Safety, Operation, and Maintenance Manual WARNING Improper use of this tool can result in serious bodily injury This manual contains important information about product function and safety. Please read
More informationOwner s Manual ELECTRIC GENERADORS R7100DP / G7100G
Owner s Manual ELECTRIC GENERADORS R7100DP / G7100G Thank you for choosing a generator set of our company. This manual contains the information on how to do that. Please read it carefully before operating.
More informationHydraulic PTO Flow Device
Safety, Operation, and Maintenance Manual WARNING Improper use of this tool can result in serious bodily injury This manual contains important information about product function and safety. Please read
More informationTable of Contents. Safety symbols... 3 Assembly 6. Hydraulic oil Towing safety. 12 Pre-operation / Starting Operation Guidelines.
Table of Contents Safety symbols... 3 Assembly 6 Hydraulic oil.. 11 Towing safety. 12 Pre-operation / Starting.. 13 Operation Guidelines. 14 Operation 16 Maintenance... 18 Storage... 19 Troubleshooting.
More informationOwner s Manual. Mortar / Plaster Mixer. Models M785 M1000 M1200
Owner s Manual Mortar / Plaster Mixer Models M785 M1000 M1200 Tiger Equipment LLC. 15 Byrd Lane Rocky Mount, VA 24151 Tel: 540-489-7777 Fax: 540-489-7778 www.tigerequip.com 1. PREFACE This manual contains
More information1-1/2 DIAMETER WATER PUMP
1-1/2 DIAMETER WATER PUMP 2.2HP/79.8cc Engine MODEL # 101099 Operation Manual This safety alert symbol identifies important safety messages in this manual. Failure to follow this important safety information
More informationPW2750 HOT WATER HI PRESSURE WASHER INSTRUCTION MANUAL
4/10/2012 PW2750 HOT WATER HI PRESSURE WASHER INSTRUCTION MANUAL READ ALL INSTRUCTIONS AND WARNINGS BEFORE USING THIS PRODUCT. This manual provides important information on proper operation & maintenance.
More informationGENERATOR MODEL NO: FG2500 OPERATION & MAINTENANCE INSTRUCTIONS PART NO: LS0114
GENERATOR MODEL NO: FG2500 PART NO: 8857727 OPERATION & MAINTENANCE INSTRUCTIONS LS0114 INTRODUCTION Thank you for purchasing this CLARKE Generator. Before attempting to use this product, please read this
More information5.5KVA GENERATOR MODEL NO: PG6500DVES OPERATION & MAINTENANCE INSTRUCTIONS PART NO: LS0616
5.5KVA GENERATOR MODEL NO: PG6500DVES PART NO: 8857810 OPERATION & MAINTENANCE INSTRUCTIONS LS0616 INTRODUCTION Thank you for purchasing this CLARKE 5.5KVA Generator. Before attempting to use this product,
More informationGENERATOR MODEL NO: FG3000 OPERATION & MAINTENANCE INSTRUCTIONS PART NO: LS0609
GENERATOR MODEL NO: FG3000 PART NO: 8857700 OPERATION & MAINTENANCE INSTRUCTIONS LS0609 INTRODUCTION Thank you for purchasing this CLARKE Generator. Before attempting to use this product, please read this
More informationGX120 GX160 GX200 OWNER S MANUAL 32ZH X32-ZH Serial number and engine type HONDA EUROPE N.V.(EEC)
GX120 GX160 GX200 Serial number and engine type OWNER S MANUAL 32ZH7620 00X32-ZH7-6201 1 HONDA EUROPE N.V.(EEC) Thank you for purchasing a Honda engine. This manual covers the operation and maintenance
More informationMOTORINI GP 50. User s Manual.
MOTORINI GP 50 User s Manual www.motorini.co.uk Dear user: Thank you for choosing to buy a Motorini GP 50 This manual provides the correct operation and maintenance methods for safe riding and maintaining
More informationGasoline High Pressure Washer
MODEL AGW-HF-3100 Gasoline High Pressure Washer Operator Manual BEFORE USING THE MACHINE PLEASE READ THESE INSTRUCTION! Model AGW-HF-3100 OVERVIEW Item Description 1. Spray Nozzle(Four) 2. Hose Hook 3.
More informationPRODIGY & PRO PLUS Skid Steer Snowplows
Western Products, PO Box 245038, Milwaukee, WI 53224-9538 www.westernplows.com June 15, 2017 Lit. No. 78552, Rev. 01 PRODIGY & PRO PLUS Skid Steer Snowplows PRODIGY Blade Assembly 57700 PRO PLUS Blade
More information1200W INVERTER GENERATOR
1200W INVERTER GENERATOR MODEL NO: IG1200 PART NO: 8877070 OPERATION & MAINTENANCE INSTRUCTIONS LS0117 INTRODUCTION Thank you for purchasing this CLARKE 1200W Inverter Generator. Before attempting to use
More informationBoring Unit Sitework Systems Attachment
FORM NO. 6 Boring Unit Sitework Systems Attachment Model No. 0 89000 & Up Operator s Manual English (CE) Contents Page Introduction................................. Safety......................................
More informationSINGLE STAGE SNOW ENGINE SERVICE MANUAL
RESIDENTIAL PRODUCTS SINGLE STAGE SNOW ENGINE SERVICE MANUAL LC154FS / LC154FDS (87cc) About this Manual This service manual was written expressly for Toro service technicians. The Toro Company has made
More informationDIRECT-DRIVE PRESSURE WASHERS
DIRECT-DRIVE PRESSURE WASHERS PJG SERIES PRESSURE WASHER MANUFACTURED BY: PJG-2001 PJG-2501-6.5 PJG-2501 PJG-3000 PJG-3001 PJG-3501 PJG-4001 OPERATOR s INTRODUCTION Thank you for purchasing a Mancorp Pressure
More informationThis unit has been used for many years to power the TapMate Too (351-00) with the hydraulic drive head attachment ( ).
Transmate 3 HP Honda Hydraulic Power Drive 372-351-01 Thank you for purchasing the Transmate 3 HP HONDA Hydraulic Power Unit. This unit will give you years of service if the simple instructions below are
More informationKING CANADA 950W PORTABLE GENERATOR MODEL: KCG-951G INSTRUCTION MANUAL COPYRIGHT 2011 ALL RIGHTS RESERVED BY KING CANADA TOOLS INC.
KING CANADA 950W PORTABLE GENERATOR MODEL: KCG-951G INSTRUCTION MANUAL COPYRIGHT 2011 ALL RIGHTS RESERVED BY KING CANADA TOOLS INC. WARRANTY & SERVICE INFORMATION 1-YEAR LIMITED WARRANTY FOR THIS 950W
More informationLight condition and operation Windshield glass condition Wiper blade condition Paint condition and corrosion Fluid leaks Door and hood lock condition
GENERAL CHECKS Engine Compartment The following should be checked regularly: Engine oil level and condition Transmission fluid level and condition Brake fluid level Clutch fluid level Engine coolant level
More informationNot for. Reproduction
IMPORTANT SAFETY INFORMATION AND INSTRUCTIONS FOR ENGINE SELECTION ENGINE INSTALLATION ENGINE OPERATION Keep these instructions for future reference. In the USA and Canada, our 24 hour hotline is: 1-800-233-3723
More informationIMPORTANT SAFETY INFORMATION AND
IMPORTANT SAFETY INFORMATION AND INSTRUCTIONS FOR ENGINE SELECTION ENGINE INSTALLATION ENGINE OPERATION Keep these instructions for future reference. In the USA and Canada, our 24 hour hotline is: 18002333723
More informationGasoline Inverter Generator
user manual Gasoline Inverter Generator table of contents Preface Introduction... Safety Information Exhaust fumes are poisonous... Fuel is highly flammable and poisonous... Engine and muffler may be hot...
More informationLP DEL PAC. ATLAS COPCO CONSTRUCTION TOOLS AB NACKA SWEDEN No
LP 13-20 DEL PAC ATLAS COPCO CONSTRUCTION TOOLS AB 2007-03 NACKA SWEDEN No. 3392 5146 01 www.atlascopco.com 1 English!"!" INTRODUCTION... 2 SAFETY INSTRUCTIONS... 2 Introduction to safety... 2 Safety symbols
More informationNOTES FOR SAFETY OPERATOR-ONLY.
NOTES FOR SAFETY Both the parents and their child must fully understand everything in this manual before riding. This vehicle is for OPERATOR-ONLY. This vehicle is only designed for operation on level,
More informationThis owner's manual is considered a permanent part of the engine and should remain with the engine if resold.
Thank you for purchasing a water pump. Please reliably keep this Manual for your reference at any time. This owner's manual is considered a permanent part of the engine and should remain with the engine
More informationPORTABLE TRASH PUMPS MTP200 MTP300 MTP400
PORTABLE TRASH PUMPS MTP200 MTP300 MTP400 OPERATING & PARTS MANUAL INTRODUCTION This manual provides information and procedures to safely operate and maintain the engine and pump. For your own safety and
More information720W PORTABLE GENERATOR
720W PORTABLE GENERATOR MODEL NO: G720 PART NO: 8857800 OPERATION & MAINTENANCE INSTRUCTIONS LS0214 INTRODUCTION Thank you for purchasing this CLARKE 720W Portable Generator Before attempting to use this
More informationTurfMaker TAILGATE MULCHER
TurfMaker TAILGATE MULCHER OPERATORS MANUAL AND PARTS LIST FOREWORD Congratulations on your purchase of a TurfMaker Tailgate Mulcher. You will find this to be one of the most versatile and work-saving
More informationLDG6000SA DIESEL GENERATOR OWNERS MANUAL
LDG6000SA DIESEL GENERATOR OWNERS MANUAL BEFORE OPERATING THIS EQUIPMENT PLEASE READ THESE INSTRUCTIONS CAREFULLY Preface Thank-you for purchasing this generator. This operation manual contains information
More informationOWNER S / OPERATOR S MANUAL
OWNER S / OPERATOR S MANUAL SAFETY PAGE 1 RECOGNIZE SAFETY INFORMATION This is the safety-alert symbol. When you see this symbol in this manual or on your EdgeMasterTM, be alert to the potential for personal
More informationLAWN MOWER OWNER S MANUAL
LAWN MOWER OWNER S MANUAL Woodies SKU: 1153279 & 1153280 CAUTION: Read and follow all Safety Rules and Instructions before operating this equipment Thank you for choosing our Gasoline Lawnmower. 1 To ensure
More informationYK1900i DIGITAL INVERTER GASOLINE GENERATOR OWNER S MANUAL PLEASE READ THIS MANUAL CAREFULLY. IT CONTAINS IMPORTANT SAFETY INFORMATION.
YK1900i DIGITAL INVERTER GASOLINE GENERATOR OWNER S MANUAL PLEASE READ THIS MANUAL CAREFULLY. IT CONTAINS IMPORTANT SAFETY INFORMATION. PREFACE Thank you for purchasing YANGKE generator. This manual covers
More informationDYNAPAC CONCRETE EQUIPMENT RAMIRENT. BG70 Power Floats INSTRUCTIONS & SPARE PARTS CATALOGUE BG70 - IS ENG
DYNAPAC CONCRETE EQUIPMENT INSTRUCTIONS & SPARE PARTS CATALOGUE BG70 Power Floats BG70 - IS - 10682 - ENG SAFETY INSTRUCTIONS - MACHINES SUBMITTED : Powered with : Electric, Pneumatic, Petrol or Diesel
More informationBöhler-AG GASOLINE GENERATOR
Böhler-AG GASOLINE GENERATOR Instruction Manual The generator is a potential source of electrical shock if misused. Do not expose the generator to moisture, rain or snow. DO not let the generator get wet,
More informationPORTABLE TRASH PUMPS MDP200
PORTABLE TRASH PUMPS MDP200 OPERATING & PARTS MANUAL INTRODUCTION This manual provides information and procedures to safely operate and maintain the engine and pump. For your own safety and protection
More informationGASOLINE GENERATOR SET SPG8000 PORTABLE GENERATOR INSTRUCTION MANUAL IMPORTANT!
GASOLINE GENERATOR SET SPG8000 PORTABLE GENERATOR INSTRUCTION MANUAL IMPORTANT! Please make certain that persons who are to use this equipment thoroughly read and understand these instructions and any
More informationNorth Dakota State University Grounds Maintenance Equipment
North Dakota State University Grounds Maintenance Equipment I. Introduction Grounds maintenance equipment is an important part of the work activities on NDSU campus. They can make grounds maintenance jobs
More informationModels 8100PP & 86110LP. Installation Instructions CAUTION. Read this document before installing the snowplow. CAUTION
September 15, 2010 Lit. No. 48645, Rev. 02 POWER PLOW Snowplows Models 8100PP & 86110LP Installation Instructions Read this document before installing the snowplow. See your BLIZZARD outlet/web site for
More informationLOG CHOP. Hydraulic Wood Guillotine. Owners Illustrated Instruction Book & Parts List
LOG CHOP Hydraulic Wood Guillotine Owners Illustrated Instruction Book & Parts List Grovebury Road, Leighton Buzzard, Bedfordshire. LU7 4UX. UK. Tel:01525 375157. Fax:01525 385222. Email: enquires@brownsagricultural.co.uk
More information1100W PORTABLE GENERATOR
1100W PORTABLE GENERATOR MODEL NO: G1200 PART NO: 8010110 OPERATION & MAINTENANCE INSTRUCTIONS LS0312 INTRODUCTION Thank you for purchasing this CLARKE 1100W Portable Generator. Before attempting to use
More informationMTD OHV Series I15 FORM NO I. MTD Products Aktiengesellschaft Saarbrücken Germany
MTD OHV Series I15 FORM NO. 769-01577I MTD Products Aktiengesellschaft Saarbrücken Germany 8 15 23 31 38 46 54 61 68 75 82 90 99 107 115 122 130 138 145 152 159 166 175 183 193 202 211 218 226 English
More informationPETROL DRIVEN POWER WASHER
WARNING: Read these instructions before using the machine PETROL DRIVEN POWER WASHER MODEL NO: TIGER 2500/2900 PART NO: 7320055/7320056 OPERATION & MAINTENANCE INSTRUCTIONS LS0513 INTRODUCTION Thank you
More informationAir / Hydraulic Pump
Form No. 538016 Parts List & Operating Instructions for: 2510A Original Instructions Air / Hydraulic Pump Maximum Capacity: 690 bar (10,000 psi) Description: The 2510A air/hydraulic pump is designed to
More informationATV-50/90/100 I/II/V OWNER S MANUAL
1 ATV-50/90/100 I/II/V OWNER S MANUAL FOREWORD May we, the manufacturer, take this opportunity to thank you for choosing our ATV to serve you. This Owner s Manual is prepared for you the details as to
More informationMODEL HD99 HYDRAULIC ONE MAN TOWABLE EARTHDRILL
DO NOT THROW AWAY IMPORTANT MANUAL MODEL HD99 HYDRAULIC ONE MAN TOWABLE EARTHDRILL Operators Manual GROUND HOG, INC. P.O.BOX 290 San Bernardino, CA. 92402 Phone (909) 478-5700 Fax (909) 478-5710 E-mail:
More informationSBCNNS. Abrasive Blast Cabinet Assembly & Operating Instructions
SBCNNS Abrasive Blast Cabinet Assembly & Operating Instructions READ ALL INSTRUCTIONS AND WARNINGS BEFORE USING THIS PRODUCT. This manual provides important information on proper operation & maintenance.
More informationWARNING: Read these instructions before using the machine GENERATOR MODEL NO: IG3500F PART NO: OPERATION & MAINTENANCE INSTRUCTIONS
WARNING: Read these instructions before using the machine GENERATOR MODEL NO: IG3500F PART NO: 8877100 OPERATION & MAINTENANCE INSTRUCTIONS ORIGINAL INSTRUCTIONS LS0217 INTRODUCTION Thank you for purchasing
More informationENGINE DRIVEN 3 FULL TRASH PUMP
ENGINE DRIVEN 3 FULL TRASH PUMP MODEL NO: PF75 PART NO: 7230165 OPERATION & MAINTENANCE INSTRUCTIONS ORIGINAL INSTRUCTIONS LS0117 ISS 2 INTRODUCTION Thank you for choosing this Clarke Pump. The function
More informationGasoline Engine GE208 OWNER S MANUAL MODEL NO.
Gasoline Engine OWNER S MANUAL MODEL NO. GE208 2 ALL POWER GE208 GASOLINE ENGINE Congratulations on your purchase of an All Power GE208 Gasoline Engine! Thank you for purchasing a All Power engine. We
More informationSPEEDWING & Heavy Duty Skid Steer Snowplows
November 1, 2015 Lit. No. 84720, Rev. 00 SPEEDWING & Heavy Duty Skid Steer Snowplows HD Blade Assembly 77720, 77725, 77730 SPEEDWING Blade Assembly 77740 HD A Frame/Attachment Plate & Hydraulics 77825
More information3KVA DUAL VOLTAGE GENERATOR MODEL NO: PG3800DV
3KVA DUAL VOLTAGE GENERATOR MODEL NO: PG3800DV PART NO: 8857815 OPERATION & MAINTENANCE INSTRUCTIONS LS1016 INTRODUCTION Thank you for purchasing this CLARKE 3KVA Dual Voltage Generator. Before attempting
More informationAirless Spray Gun INSTRUCTIONS DP psi (345 bar) Maximum Working Pressure
INSTRUCTIONS DP-6376 Airless Spray Gun 5000 psi (345 bar) Maximum Working Pressure INSTRUCTIONS This manual contains important warnings and information. READ AND KEEP FOR REFERENCE. Table of Contents Warnings......................................
More informationSingle and Double Head Powered Screed. Screed King. User Manual. SCR-UM EN-04 (December 2018)
Single and Double Head Powered Screed Screed King SCR-UM-00364-EN-04 () User Manual Single and Double Head Powered Screed, Screed King CONTENTS Scope of This Manual.............................................
More informationLOG SPLITTER. 7 Ton OWNER S MANUAL AND OPERATING INSTRUCTIONS MODEL NUMBER
OWNER S MANUAL AND OPERATING INSTRUCTIONS 7 Ton LOG SPLITTER SAVE THESE INSTRUCTIONS Important Safety Instructions are included in this manual. MADE IN CHINA REV 90720-20180930 MODEL NUMBER 90720 12039
More informationFORZA BOLT OUTBOARD MOTOR OWNER S MANUAL
FORZA BOLT OUTBOARD MOTOR OWNER S MANUAL Table Of Contents 1.Introduction...1 2.Safety Information.1 3.Refuelling Information...1 4.Safety Matters 2 5.Preparation.3 6.Operation.3 7.Maintenance...4 8.Storage...5
More informationZ500 Series Z Master Mowers
Z500 Series Z Master Mowers Form No. 3352 977 Setup Instructions Loose s Use the chart below to verify all parts have been shipped. Note: Retain the bolts that hold the center rollbar to the packaging.
More informationSTALLION SOFT WASH SYSTEM Operations Manual
STALLION SOFT WASH SYSTEM Operations Manual INTRODUCTION Congratulations on your choice of a Delux Stallion Soft Wash System. We are certain you will be pleased with your purchase. This manual was created
More informationAND OPERATING INSTRUCTIONS IMPORTANT:
WOOD CHIPPER User Manual FM6.5WC SAFETY AND OPERATING INSTRUCTIONS IMPORTANT: Read safety rules and instructions carefully before operating equipment. Table of Contents Table of Contents PART I: General
More informationHonda WX10T OWNER S MANUAL
Honda WX10T OWNER S MANUAL Original instructions MANUEL DE L UTILISATEUR Notice originale BEDIENUNGSANLEITUNG Originalbetriebsanleitung MANUAL DE EXPLICACIONES Manual original Thank you for purchasing
More informationHOFFMANN POWER PRODUCTS PARTS LIST 2014
HOFFMANN POWER PRODUCTS PARTS LIST 2014 VIBRATORY PLATE COMPACTOR ALL PARTS ARE SUBJECT TO STANDARD HOFFMANN TERMS AND CONDITIONS OF SALE 2010 Replacement parts are not manufactured, sold or warranted
More informationMODEL CF-00-F3-O GAS FLANGE WAY CLEANER OPERATION, MAINTENANCE, AND REPAIR MANUAL
MODEL CF-00-F3-O GAS FLANGE WAY CLEANER OPERATION, MAINTENANCE, AND REPAIR MANUAL 1805 2 nd AVENUE NORTH * MOORHEAD, MN, USA 56560-2310 1 PHONE (218) 236-0223 * FAX (218) 233-5281 E-MAIL ADDRESS; info@portaco.com
More informationPOWER UNIT Operations Manual
PTO-TWIN-ATT & PTO-TWIN-ATT-LP POWER UNIT Operations Manual PTO-TWIN-ATT PTO-TWIN-ATT-LP TNT Rescue Systems, Inc. 2490 West Oak Street Ashippun, WI 53003 920-474-4101 or 800-474-4189 E-Mail: email@tntrescue.com!
More informationBRUSH CUTTER UMK435T OWNER S MANUAL. Honda Motor Co., Ltd MVK X3M-VK *UMK435T(3MVK9600)-omote 4/9/08 13:37 Page 1
*UMK435T(3MVK9600)-omote 4/9/08 13:37 Page 1 BRUSH CUTTER UMK435T OWNER S MANUAL Honda Motor Co., Ltd. 2005 3MVK9600 00X3M-VK9-6010 2008.09 PRINTED IN THAILAND 1 *UMK435T(3MVK9600)-omote 4/9/08 13:37 Page
More informationMulcher Operators Manual
Mulcher Operators Manual Skid Pro Attachments PO Box 982 Alexandria, MN 56308 October 2015 1 2 Contents 1. Introduction And Warranty... 4 1.1 Introduction... 4 1.2 Warranty... 4 2. Component Identification...
More informationSECTION 4 - FUEL SYSTEMS AND CARBURETION
SECTION - FUEL SYSTEMS AND CARBURETION FUEL SYSTEMS - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -62 FUEL PUMP - - - - - - -
More informationVehicle battery BATTERY WARNING SYMBOLS BATTERY CARE
Vehicle battery BATTERY WARNING SYMBOLS On the battery label, the warning signs are as follows: BATTERY CARE No smoking, no naked flames, no sparks. The battery may emit explosive gas. Keep away from children
More informationLOG SPLITTER. 20 Ton OWNER S MANUAL MODEL NUMBER
OWNER S MANUAL 20 Ton LOG SPLITTER MODEL NUMBER 92050-1 SAVE THESE INSTRUCTIONS Important safety instructions are included in this manual. MADE IN CHINA REV 92050-1-20180503 12039 Smith Ave. Santa Fe Springs
More informationAuger Dingo Attachment
Form No. 334-5 Auger Dingo Attachment Model No. 400 0000000 & Up Operator s Manual English (CE) Contents Page Introduction................................ Safety..................................... Safety
More informationLOG SPLITTER. 25 Ton Full Beam OWNER S MANUAL MODEL NUMBER
OWNER S MANUAL 25 Ton Full Beam LOG SPLITTER SAVE THESE INSTRUCTIONS Important Safety Instructions are included in this manual. Warranty Limited Year Two Two limitada limitada Garantía de de dos años Garantie
More informationPetrol Engine Powered Pump Instruction Manual
Petrol Engine Powered Pump Instruction Manual BIA-WP10-804448 CONTENTS 1. Safety information 2 2. Location of warning labels 3 3. Name of components 4 4. Pre-starting operation 5-7 5. Starting the engine
More informationBT-1.5, BT-1.5-LP (NITRO) POWER UNIT Operations Manual
BT-1.5, BT-1.5-LP (NITRO) POWER UNIT Operations Manual BT-1.5 BT-1.5-LP TNT Rescue Systems, Inc. 2490 West Oak Street Ashippun, WI 53003 920-474-4101 or 800-474-4189 E-Mail: email@tntrescue.com! WARNING!
More informationTable of Contents. Safety Assembly Pre-operation / Starting. 7. Operation.. 8. Maintenance. 9. Storage 10
Table of Contents Safety... 3 Assembly... 6 Pre-operation / Starting. 7 Operation.. 8 Maintenance. 9 Storage 10 Parts drawings..11 Parts list by number..12 Notes.13 2 Safety Information Attention; this
More informationOwner s Manual PORTABLE GENERATOR. Model: PR2800 PR6500
PORTABLE GENERATOR Owner s Manual Model: PR2800 PR6500 ALLPOWER INDUSTRIES AUSTRALIA A.B.N 46 650 681 742 Unit 5, 102-128 Bridge Road, Keysborough, VIC 3173, Australia Telephone: +61 38726 1444 / 1800
More informationAqua Scooter- Triton. Operations Manual
Aqua Scooter- Triton Operations Manual Contents Technical Data... 3 Shell Components... 3 Propane Kit Components... 4 Technical Specifications... 5 Preparing the Machine... 6 Before Use... 6 Propane Kit
More informationFOR SAFE OPERATION. * Exhaust contains poisonous carbon monoxide Avoid inhalation of exhaust gases. Never engine in a closed garage or confined area.
FOR SAFE OPERATION WARNING: * To prevent fire hazards and to provide adequate ventilation, keep the engine at least 3 ft away from buildings and other equipment, during operation. * Do not place flammable
More informationTrencher Dingo Attachment
Form No. 3326-453 Trencher Dingo Attachment Model No. 22459 2000000 & Up Operator s Manual English (CE) Contents Page Introduction................................ 2 Safety.....................................
More informationLAWNMOWER OWNER S MANUAL & Service Record Booklet HUT216
LAWNMOWER OWNER S MANUAL & Service Record Booklet HUT216 Contents WARRANTY 2 SAFETY INSTRUCTIONS 3 COMPONENT IDENTIFICATION 5 SETUP INSTRUCTIONS 6 IMPORTANT: BEFORE YOU START THE MOWER 7 OPERATIONAL PROCEDURES
More informationEngines Original Instructions Model: DG350
Engines Original Instructions Model: DG350 Henton and Chattell Ltd: London Road, Nottingham NG2 3HW. UK. CONTENTS SECTION 1 INTRODUCTION......3 SECTION 2 SAFETY MESSAGES...3 SECTION 3 SAFETY INFORMATION...3
More information