FLASHBAY ELECTRONICS

Transcription

1 CONSUMER PRODUCTS SERVICES DIVISION FLASHBAY ELECTRONICS Date Received: January 08, 2018 Page 1 of 12 LEVIN FLASHBAY ELECTRONICS BLGD B & C XI FENG CHENG IND ZONE, NO.2 FUYUAN ROAD HE PING, VILLAGE, FUYONG TOWN, SHENZHEN, CHINA Sample Description: BLUETOOTH HEADPHONE 1. ) A 2. ) B 3. ) C 4. ) D Vendor: N/A Sample Size: 12 Manufacturer: N/A Style No(s): MAMBO(MO), NAPPA(NP), CRAFT(CC), INDIE(ID) Buyer: N/A SKN/SKU No.: N/A Labeled Age Grade: N/A PO No.: N/A Appropriate Age Grade: N/A Ref #: N/A Client Specified Age N/A Country of Origin: N/A Grade: Tested Age Grade: ADULT Assortment No.: N/A UPC Code: N/A EXECUTIVE SUMMARY: The sample(s) MEET the following requirement(s): - European Parliament and Council Directive 2011/65/EU on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment (RoHS) - Phthalates Test Directive 2015/863/EU Amendment of European Parliament and Council Directive 2011/65/EU on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment (RoHS) Note: The amendment will be effective on 22 July For medical devices and control instruments, effective date will be 22 July BUREAU VERITAS SHENZHEN CO.,LTD AC/dk Choy Hon Kwong, Adams Senior Manager Analytical Department Bureau Veritas Shenzhen Co.,Ltd. 1& 4/F, B Building, Min Li Da Industrial Bldg., Hong Hua Ling Industrial Park, Xili Town, Nanshan District, Shenzhen, China Tel: Fax: This report is governed by, and incorporates by reference, the Conditions of Testing as posted at the date of issuance of this report at and is intended for your exclusive use. Any copying or replication of this report to or for any other person or entity, or use of our name or trademark, is permitted only with our prior written permission. This report sets forth our findings solely with respect to the test samples identified herein. The results set forth in this report are not indicative or representative of the quality or characteristics of the lot from which a test sample was taken or any similar or identical product unless specifically and expressly noted. Our report includes all of the tests requested by you and the results thereof based upon the information that you provided to us. You have 60 days from date of issuance of this report to notify us of any material error or omission caused by our negligence; provided, however, that such notice shall be in writing and shall specifically address the issue you wish to raise. A failure to raise such issue within the prescribed time shall constitute you unqualified acceptance of the completeness of this report, the tests conducted and the correctness of the report contents.

2 Page 2 of 12 RESULTS: Compliance Test - European Parliament and Council Directive 2011/65/EU on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment (RoHS) Test Method : See Appendix. Test Item(s) Item / Component Description(s) Location(s) Style(s) 1 Black soft plastic / deep blue fabric Headphone 2 Grey printed black plastic Headphone 3 White foam Inner headphone 4 Red / black printed white plastic Case, headphone 5 White soft plastic / glue Headphone A 6 Light white soft plastic Headphone B 7 White soft plastic Glue B 8 Transparent plastic Washer, headphone B 9 Brown wood Headphone C 10 Silvery metal Headphone D 11 Translucent soft plastic Adhesive tape 12 Black plastic Headphone 13 Light blue printed transparent plastic / glue Sticker 14 Grey foam / glue Inner headphone 15 Black soft plastic Inner case, headphone 16 Deep grey foam Inner case, headphone 17 Silvery metal Shaft 18 White soft plastic USB 19 White soft plastic Sleeve, wire jacket 20 Silver plated coppery metal Case, USB 21 White plastic Inner USB 22 Silver plated golden metal Connector, USB 23 Silvery solder Connector, USB 24 Silvery metal Small case, USB 25 Black plastic Inner small case, USB 26 Silver plated golden metal Connector, small case, USB 27 Silvery solder Connector, small case, USB 28 Bright white soft plastic Case, line 29 Silver plated golden metal Connector, line 30 Silvery solder Connector, line 31 Red soft plastic Thin wire jacket 32 White soft plastic Thin wire jacket 33 Black soft plastic Thin wire jacket 34 Red soft plastic Thick wire jacket 35 White soft plastic Thick wire jacket

3 Page 3 of 12 RESULTS: Compliance Test - European Parliament and Council Directive 2011/65/EU on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment (RoHS) Test Method : See Appendix. Test Item(s) Item / Component Description(s) Location(s) Style(s) 36 Black soft plastic Thick wire jacket 37 Black soft plastic Wire jacket 38 Red soft plastic Wire jacket 39 Pink / silver plated coppery metal Wire 40 Black soft plastic Sleeve, case, MIC 41 Silvery metal Case, MIC 42 Silver plated golden metal Ring, MIC 43 White plastic Washer, MIC 44 Translucent blue soft plastic Washer, MIC 45 Silver plated golden metal Plate, MIC 46 Blue coated brown plastic / coppery metal MIC PCB 47 Silvery solder MIC PCB 48 Transparent plastic Diaphragm, speaker 49 Coppery metal Coil, speaker 50 Black plastic / glue Case, speaker 51 Silvery metal Ring, speaker 52 Silvery magnet Speaker 53 Silvery metal Bolt, speaker 54 Green coated translucent plastic / coppery metal PCB, speaker 55 Silvery solder PCB, speaker 56 Black plastic Case, earplug, PCB 57 Silver plated golden metal Connector, earplug, PCB 58 Grey plastic Button, button switch, PCB 59 Silver plated golden metal Case, button switch, PCB 60 Silver plated golden metal Connector, button switch, PCB 61 White body LED, PCB 62 Black body SMD IC, PCB 63 Silvery body Crystal, PCB 64 Brown body SMD capacitor, PCB 65 Black / white body SMD resistor, PCB 66 White printed green coated translucent plastic / coppery metal PCB 67 Silvery solder PCB 68 Silvery metal Screw, L:8mmФ :4mm

4 Page 4 of 12 RESULTS: Compliance Test - European Parliament and Council Directive 2011/65/EU on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment (RoHS) Test Method : See Appendix. See Analytes and their corresponding Maximum Allowable Limit in Appendix - Result Parameter Lead (Pb) Cadmium Mercury Chromium (Cd) (Hg) VI (Cr VI) PBBs PBDEs Conclusion Unit mg/kg mg/kg mg/kg mg/kg mg/kg mg/kg - Test Item(s) ND ND ND ND ND ND PASS 2 ND ND ND ND ND ND PASS 3 ND ND ND ND ND ND PASS 4 ND ND ND ND ND ND PASS 5 ND ND ND ND ND ND PASS 6 ND ND ND ND ND ND PASS 7 ND ND ND ND ND ND PASS 8 ND ND ND ND ND ND PASS 9 ND ND ND ND ND ND PASS 10 ND ND ND Negative # NA NA PASS 11 ND ND ND ND ND ND PASS 12 ND ND ND ND ND ND PASS 13 ND ND ND ND ND ND PASS 14 ND ND ND ND ND ND PASS 15 ND ND ND ND ND ND PASS 16 ND ND ND ND ND ND PASS 17 ND ND ND Negative # NA NA PASS 18 ND ND ND ND ND ND PASS 19 ND ND ND ND ND ND PASS 20 ND ND ND Negative # NA NA PASS 21 ND ND ND ND ND ND PASS 22 ND ND ND ND NA NA PASS 23 ND ND ND ND NA NA PASS 24 ND ND ND Negative # NA NA PASS 25 ND ND ND ND ND ND PASS 26 ND ND ND ND NA NA PASS 27 ND ND ND ND NA NA PASS 28 ND ND ND ND ND ND PASS 29 ND ND ND ND NA NA PASS 30 ND ND ND ND NA NA PASS 31 ND ND ND ND ND ND PASS 32 ND ND ND ND ND ND PASS

5 Page 5 of 12 RESULTS: Compliance Test - European Parliament and Council Directive 2011/65/EU on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment (RoHS) Test Method : See Appendix. See Analytes and their corresponding Maximum Allowable Limit in Appendix - Result Parameter Lead (Pb) Cadmium Mercury Chromium (Cd) (Hg) VI (Cr VI) PBBs PBDEs Conclusion Unit mg/kg mg/kg mg/kg mg/kg mg/kg mg/kg - Test Item(s) ND ND ND ND ND ND PASS 34 ND ND ND ND ND ND PASS 35 ND ND ND ND ND ND PASS 36 ND ND ND ND ND ND PASS 37 ND ND ND ND ND ND PASS 38 ND ND ND ND ND ND PASS 39 ND ND ND ND NA NA PASS 40 ND ND ND ND ND ND PASS 41 ND ND ND ND NA NA PASS 42 ND ND ND ND NA NA PASS 43 ND ND ND ND ND ND PASS 44 ND ND ND ND ND ND PASS 45 ND ND ND ND NA NA PASS 46 ND ND ND ND ND ND PASS 47 ND ND ND ND NA NA PASS 48 ND ND ND ND ND ND PASS 49 ND ND ND ND NA NA PASS 50 ND ND ND ND ND ND PASS 51 ND ND ND Negative # NA NA PASS 52 ND ND ND ND NA NA PASS 53 ND ND ND Negative # NA NA PASS 54 ND ND ND ND ND # ND # PASS 55 ND ND ND ND NA NA PASS 56 ND ND ND ND ND ND PASS 57 ND ND ND ND NA NA PASS 58 ND ND ND ND ND ND PASS 59 ND ND ND ND NA NA PASS 60 ND ND ND Negative # NA NA PASS 61 ND ND ND ND ND ND PASS 62 ND ND ND ND ND ND PASS 63 ND ND ND ND NA NA PASS 64 ND ND ND ND ND ND PASS 65 ND ND ND ND ND ND PASS

6 Page 6 of 12 RESULTS: Compliance Test - European Parliament and Council Directive 2011/65/EU on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment (RoHS) Test Method : See Appendix. See Analytes and their corresponding Maximum Allowable Limit in Appendix - Result Parameter Lead (Pb) Cadmium Mercury Chromium (Cd) (Hg) VI (Cr VI) PBBs PBDEs Conclusion Unit mg/kg mg/kg mg/kg mg/kg mg/kg mg/kg - Test Item(s) ND ND ND ND ND # ND # PASS 67 ND ND ND ND NA NA PASS 68 ND ND ND ND NA NA PASS Note / Key : Remark : ND = Not detected > = Greater than NR = Not requested mg/kg = milligram(s) per kilogram = ppm = part(s) per million % = percent mg/kg = 1 % Detection Limit : See Appendix. - The testing approach is listed in table of Appendix. - # denotes as reported result(s) was (were) performed by wet chemistry method. Others were screened by XRF. For XRF screening, the result(s) of Cr VI was (were) reported as total chromium and the result(s) of PBBs and PBDEs was (were) reported as total bromine. Also, the XRF result(s) may be different to the actual content based on various factors including, but not limit to, sample size, thickness, area, nonuniformity composition, surface flatness. - Only selected example(s) is (are) indicated on the photograph(s) in Comment. - According to European Parliament and Council Directive 2011/65/EU, Article 5 Adaptation of the Annexes to scientific and technical progress, exemption(s) should be granted to the materials and components of Test Item(s) in the lists in Annexes III and IV of this directive.

7 Page 7 of 12 TEST RESULT Phthalates Test Directive 2015/863/EU Amendment of European Parliament and Council Directive 2011/65/EU on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment (RoHS) Test Method : With reference to draft International Standard IEC Test Item(s) Item / Component Description(s) Location(s) Style(s) 1 Black soft plastic / deep blue fabric Headphone 2 Grey printed black plastic Headphone 3 White foam Inner headphone 4 Red / black printed white plastic Case, headphone 5 White soft plastic / glue Headphone A 6 Light white soft plastic Headphone B 7 White soft plastic Glue B 8 Transparent plastic Washer, headphone B 9 Brown wood Headphone C 11 Translucent soft plastic Adhesive tape 12 Black plastic Headphone 13 Light blue printed transparent plastic / glue Sticker 14 Grey foam / glue Inner headphone 15 Black soft plastic Inner case, headphone 16 Deep grey foam Inner case, headphone 18 White soft plastic USB 19 White soft plastic Sleeve, wire jacket 21 White plastic Inner USB 25 Black plastic Inner small case, USB 28 Bright white soft plastic Case, line 31 Red soft plastic Thin wire jacket 32 White soft plastic Thin wire jacket 33 Black soft plastic Thin wire jacket 34 Red soft plastic Thick wire jacket 35 White soft plastic Thick wire jacket 36 Black soft plastic Thick wire jacket 37 Black soft plastic Wire jacket 38 Red soft plastic Wire jacket 40 Black soft plastic Sleeve, case, MIC 43 White plastic Washer, MIC 44 Translucent blue soft plastic Washer, MIC 48 Transparent plastic Diaphragm, speaker 50 Black plastic / glue Case, speaker 56 Black plastic Case, earplug, PCB

8 Page 8 of 12 TEST RESULT Phthalates Test Directive 2015/863/EU Amendment of European Parliament and Council Directive 2011/65/EU on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment (RoHS) Test Method : With reference to draft International Standard IEC Test Item(s) Item / Component Description(s) Location(s) Style(s) 58 Grey plastic Button, button switch, PCB 61 White body LED, PCB Maximum Allowable Limit: DEHP, BBP, DBP & DIBP: 0.1% (Each) Tested Item(s) Result Detected Analyte(s) Conc. Unit Conclusion ND ND % PASS ND ND % PASS ND ND % PASS ND ND % PASS ND ND % PASS ND ND % PASS ND ND % PASS ND ND % PASS ND ND % PASS ND ND % PASS ND ND % PASS ND ND % PASS Note / Key : ND = Not detected > = Greater than NR = Not requested mg/kg = milligram(s) per kilogram = ppm = part(s) per million % = percent mg/kg = 1 % Detection Limit (%) : Remark : The list of phthalates is summarized in table of Appendix. Comment :

9 Page 9 of 12 TEST RESULT Phthalates Test Directive 2015/863/EU Amendment of European Parliament and Council Directive 2011/65/EU on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment (RoHS) Photograph(s) [ Compliance Test for European Parliament and Council Directive 2011/65/EU ] : Photograph of Test Item(s) / END

10 Page 10 of 12 APPENDIX List of Analytes and their Corresponding Test Methods, Detection Limit and Maximum Allowable Limit [ Compliance Test for European Parliament and Council Directive 2011/65/EU ] : No. Name of Analytes Detection Limit (mg/kg) X-ray fluorescence (XRF) [a] Plastic Metallic / glass / ceramic Others Wet Chemistry Maximum Allowable Limit (mg/kg) 1 Lead (Pb) [b] Cadmium (Cd) [b] Mercury (Hg) [c] Chromium (Cr) NA NA 5 Chromium VI (Cr VI) NA NA NA 3 [g, h] / 10 [d] / / See [e, j] Negative [j] 6 Bromine (Br) 200 NA 200 NA NA 7 Polybromobiphenyls (PBBs) - Bromobiphenyl (MonoBB) - Dibromobiphenyl (DiBB) - Tribromobiphenyl (TriBB) - Tetrabromobiphenyl (TetraBB) - Pentabromobiphenyl (PentaBB) NA NA NA Each 50 [f] Sum Hexabromobiphenyl (HexaBB) - Heptabromobiphenyl (HeptaBB) - Octabromobiphenyl (OctaBB) - Nonabromobiphenyl (NonaBB) - Decabromobiphenyl (DecaBB) 8 Polybromodiphenyl ethers (PBDEs) - Bromodiphenyl ether (MonoBDE) - Dibromodiphenyl ether (DiBDE) - Tribromodiphenyl ether (TriBDE) - Tetrabromodiphenyl ether (TetraBDE) - Pentabromodiphenyl ether (PentaBDE) - Hexabromodiphenyl ether (HexaBDE) - Heptabromodiphenyl ether (HeptaBDE) - Octabromodiphenyl ether (OctaBDE) - Nonabromodiphenyl ether (NonaBDE) - Decabromodiphenyl ether (DecaBDE) NA NA NA Each 50 [f] Sum 1 000

11 Page 11 of 12 NA = Not applicable [a] Test method with reference to International Standard IEC : [b] Test method with reference to International Standard IEC : [c] Test method with reference to International Standard IEC : [d] Polymers and Electronics - Test method with reference to European Standard EN : [e] Metal - Test method with reference to International Standard IEC : 2015 [i]. [f] Test method with reference to International Standard IEC : [g] Leather - Test method International Standard ISO 17075: [h] Other Than Metal, Leather, Polymers and Electronics - Test method with reference to International Standard ISO 17075: [i] The principle of this method was evaluated and supported by two studies organized by IEC TC 111 WG3. These studies were focused on detecting the presence of Cr VI in the corrosion protection coatings on metallic samples. Result(s) of Cr VI for metallic material(s) was (were) expressed in term of positive and negative. Negative means the absence of Cr VI on the tested areas and the result(s) was (were) regarded as in compliance with European [j] Parliament and Council Directive 2011/65/EU, Article 4(1). While, positive means the presence of Cr VI on tested areas and the result(s) was (were) regarded as in conflict with European Parliament and Council Directive 2011/65/EU, Article 4(1). Testing Approach [ Compliance Test for European Parliament and Council Directive 2011/65/EU ] : The testing approach was with reference to the following document(s). 1 International Standards IEC : 2013 and IEC : 2013 RoHS Enforcement Guidance Document Version 1 by EU RoHS Enforcement Authorities Informal Network. 2 (May 2006) RoHS Regulations - Government Guidance Notes by United Kingdom Department for Business Innovation & 3 Skills. (February 2011) Final Report to RoHS substances (Hg, Pb, Cr(VI), Cd, PBB and PBDE) in electrical and electronic equipment in 4 Belgium by Belgium Federal Public Service Health, Food Chain Safety and Environment. (November 2005) List of Phthalates: No. Name of Analytes CAS-No. No. Name of Analytes CAS-No. 1 Bis(2-ethylhexyl) phthalate (DEHP) Dibutyl phthalate (DBP) Butyl benzyl phthalate (BBP) Diisobutyl phthalate (DIBP)

12 RESULTS: FLASHBAY ELECTRONICS Page 12 of 12