Jabiru Aircraft Pty. Ltd. Final Inspection Checklist. Engine Compartment
|
|
- Douglas Stephens
- 6 years ago
- Views:
Transcription
1 Jabiru Aircraft Pty. Ltd. Final Inspection Checklist Registration No: Aircraft Checklist Pre Ground Test Model: Serial No: Engine Compartment Propeller: Prop Size: 60 x 53 Other:.. Propeller Serial No: Prop Bolts: 1. Check Torque (6 ft/lbs) 2. Check Tracking 3. Torque seal nuts 4. Spinner screws secure 5. Check spinner tracking 6. Visual check prop for serviceability Engine: Engine Serial No: (change to J if necessary) Engine Mount bolts secure: 1. Firewall 2. Engine 3. Thrust washer in place Fuel hose secure: 1. Carburettor to pump 2. pump to bulkhead 3. clamped and tied 4. breather hose a. carburettor to ho air mixer box b. fuel pump to firewall Spark Plugs/Coil leads: Preflight Inspection checklist 23/10/01 Page 1
2 1. Check plugs are secure 2. terminal nuts secure 3. CHT sender (12mm terminal) 4. leads secure on plugs 5. leads secure on distributor cap gauge earth wire secure and clipped into coil Ram Air Ducts: 1. Baffles in place 2. Bolts secure x 4 3. springs in place 4. spring lockwire correct and secure x 2 Oil: 1. Level correct (4 cylinder 2.4) (6 cylinder 3.4) 2. sump plug wired 3. cooler bracket secure to engine 4. cooler secured to bracket 5. air dam in place 6. check hose route 7. cooler hose clamps secure x 4 8. fire sleeve secure 9. filter secure 10. oil breather hose & bottle secure Throttle cable: 1. cable lock nuts secure on both ends 2. cable end free in carburettor link 3. split pins secure 4. 2 x 5/16 washers between cable and carburettor link 5. cable alignment correct with outer at both ends 6. cable adjustment a) full throttle b) idle Choke Cable: 1. Lock nuts secure both ends 2. cable end free in carburettor link 3. split pin secure 4. cable alignment correct with outer 5. operational Carburettor Heat Cable: 1. Lock nuts secure both ends 2. cable end free in carburettor link 3. split pin secure 4. cable alignment correct with outer 5. operational Preflight Inspection checklist 23/10/01 Page 2
3 Scat Hose: 1. carburettor to hot box a) hose clamps secure b) not bunched up under carburettor c) smooth route 2. hot box to NACA duct a) hose clamps secure b) smooth route 3. hot box to heat muff a) hose clamps secure b) smooth route Nose leg & housing: 1. Tyre pressure psi (std 260 x 4) 2. wheel - ease of rotation 3. leg lubricated and ease of rotation 4. assembly all bolts secure in nose leg 5. Housing bolts secure a) ¼ washers on head of bolt 6. rod end secure both ends 7. safety hole within limits 8. jam nut secure 9. air valve grommet in place 10. spats screws secure 11. steering link pushrod boot in place Electrical: Rudder: 1. battery tie down secure 2. battery terminals secure 3. battery earth secure on firewall 4. starter solenoid locknuts & wires secure 5. regulator wires secure & correct 6. temp sender wires secure x 3 (oil & CHT) 7. all wiring cable tied and secure 8. oil pressure wire correct & secure (G terminal) Interior 1. pedal mount bolts secure x 2 2. bell crank secure a) 4 x rivets TLR b) 1 x ¼ bolt c) 5 x 3/16 bolts d) check jam nuts on push rods x 6 e) check safety within limits on push rods x 3 f) check rod end free play at full deflection, both directions 3. rudder cable Preflight Inspection checklist 23/10/01 Page 3
4 a) anchor secure and correct position in clamp b) rod end secure in pedal c) safety within limits d) jam nuts secured e) rod end free play at full deflections, in both directions f) rudder stoppers adjusted and secure g) centring spring not binding in console Fuel: Trim: Brake: 1. filter secure 2. fuel line secure a) filter to bulk head b) valve to filter c) valve to tank 3. check hose route 4. check valve operation 5. check valve cover and mount secure 6. check filler hose clamps 7. check breather hose clamps and breather route 8. check fuel tank secure 1. handle secure 2. lever pivot secure and split pin 3. friction correct & secure 4. rod end secure 5. check safety hole within limits 6. jam nuts secure 7. cable position in clamp correct & anchor secure 8. operation 9. spring not coil bound with elevator fully deflected up 10. decal fitted and correct 1. handle assembly correct and secure 2. lever pivot secure and split pin 3. rod end secure 4. check safety hole within limits 5. jam nuts secure 6. operation 7. free play 8. fluid level 9. stainless striker in place 10. handbrake correct and operational Throttle: Preflight Inspection checklist 23/10/01 Page 4
5 1. cable anchor secure 2. cable alignment correct 3. cable end free in output lever 4. output lever secure 5. input lever x 2 secure 6. bearing blocks x 2 secure 7. throttle stop correct and secure Horizontal shaft: 1. control stick pivot secure 2. yolk secure (no free play) 3. rod end secure 4. safety hole within limits 5. jam nuts secure 6. elevator cable anchor secure and correct position in clamp 7. cable clear of centre console in all positions 8. rod end free at full deflections 9. bell crank plate secure Aileron Cable: 1. cable anchor - wedges i. left ii. right - R clip i. left ii. right - rivets x 3 TLR i. left ii. right 2. rod ends secure x 2 3. safety within limits x 2 4. jam nuts secure x 2 5. aileron stoppers secure (cannot over centre aileron bellcrank) Seat Belts: 1. check bolts are through nyloc and buckle has free play i. Left ii. Right 2. Operation 3. belts not twisted 4. seat belt anchor secure (lower and upper) Headsets: hook secure Instrument Panel: Preflight Inspection checklist 23/10/01 Page 5
6 1. secure 2. instruments square 3. switches secure 4. choke cable decal square 5. registration number p-touch on panel 6. balance ball air bubble not visible 7. mag guard in place and square with rounded edges 8. all instruments fitted as per order 9. instrument markings correct 10. altimeter QNH correct 11. all instruments operational 12. cigarette lighter installed 13. all avionics as per order and operational Flap handle: Upholstery: Decals: 1. pivot bolt secure & torqued 2. pivot bolt split pin 3. locater bolt secure 4. ease of location in all three positions 5. rod end bolt secure handle - input shaft 6. push rod not binding in all three position 7. safety hole within limits x 2 8. jam nuts secure x 2 9. visual on input lever 10. visual on bearing blocks 1. fitted & clean 2. correct as per order 3. seat covers 4. map pockets 1. warning 2. baggage 3. loading Stall warning: 1. operation correct (suck to ensure reed is correct) 2. gauze and stainless plate installed correctly and clear Doors: LEFT RIGHT 1. operation 2. restraining straps secure and correct length 3. hinge and pin secure 4. catches secure and freely operating 5. heat shrink on handle 6. visual on door jam LEFT RIGHT Preflight Inspection checklist 23/10/01 Page 6
7 7. visual on door seal 8. visual on rope handle 9. visual on top block 10. door kick strip 11. decals a) Do not lean on door b) Exit c) Open d) Flight Manual EXTERIOR Wings: LEFT RIGHT 1. route bolts inspected ( correct tension) x 2 2. strut bolts x 2 inspected, correct tension 3. warning decals x 2 (Do not Tighten) 4. speed fairing secure and clear of strut 5. flap/deflections a) first stage b) second stage c) neutral 6. flaps a) hinge points secure with pivot bolts in safety b) push rod ends secure and not binding in 3 positions c) safety hole within limits d) jam nuts secure e) push rod not fowling on cover strip f) drive shaft output secure g) drain holes h) wing route cover strips secure i) top wing strut fairings secure 7. Aileron Deflections a) up b) down c) neutral 8. Ailerons a) Hinge pin and retainer secure b) Rod ends secure c) Safety hole within limits d) Jam nuts secure e) Cable anchor secure and correct position in clamp f) Drain holes 9. wing drain hole in trailing edge 10. inspection window secure LEFT RIGHT Preflight Inspection checklist 23/10/01 Page 7
8 11. pitot a) secure b) operation c) cover Main Undercarriage: 1. tyre pressure 25 psi 2. ease of rotation Nos: 3 7 to be checked by Authorised Personnel before spat is attached 3. calliper secure 4. stub axle secure 5. hubs secure 6. discs secure 7. stub axle extension is secure 8. legs secure x 3 9. spat a) screws secure b) clear of tyre a) retain nuts b) outer edge c) air valve grommet in place d) no step decal in place Fuel: 1. filler cap secure 2. drain a) operation b) lock wired 3. tape on fuse for cap 4. decals Elevator Deflections 1. up 2. down 3. 2mm clearance to stops on fuse Elevator: 1. hinge pins and retainers secure 2. rod ends secure 3. safety within limits 4. jam nuts secure 5. cable anchor secure and correct position in clamp 6. drive plate secure 7. rod end free play at full deflections 8. end-plug not touching end-cap full deflection down Trim: Preflight Inspection checklist 23/10/01 Page 8
9 Trim Cable: Rudder: Static Vent: a) pivots secure b) spring rod a) split pins secure b) springs lubricated c) black block secure and free d) rod ends secure e) safety hole within limit f) jam nuts secure g) rod end free at full deflections a) cable anchor secure and correct position in clamp b) rod ends secure c) safety within limits d) jam nuts secure e) rod end free at full deflections. 1. Deflection a) left b) right c) 2mm clearance to stops on fuse 2. hinge pin and retainers secure 3. 5mm off set to right 4. rod end secure 5. safety within limits 6. jam nuts secure 7. cable anchor secure and correct position in clamp 8. rod end free at full deflections 9. cover fin fuselage secure 1. tip secure 2. holes clear 3. decal in place Preflight Inspection checklist 23/10/01 Page 9
Jabiru Aircraft Pty. Ltd. Final Inspection Checklist J200/400. Firewall forward components
Jabiru Aircraft Pty. Ltd. Final Inspection Checklist J200/400 Registration No: Aircraft Checklist Pre Ground Test Model: Aircraft Serial No: Firewall forward components Propeller: Prop Size: 60 x 53 Other:
More informationSection 1.4 FINAL INSPECTION
File Number MDRA C20 MANUAL of PROCEDURES for INSPECTION of METAL, TUBE, FABRIC and WOOD AMATEUR-BUILT AIRCRAFT, INSPECTION AND TECHNICAL INFORMATION RECORD Section 1.4 FINAL INSPECTION GENERAL 1. Have
More information11. Completing the Fuselage Engine Installation
11. Completing the Fuselage Engine Installation Engine Installations 11 1 230399 - Fit Engine Mount Reference: Photo 11.16(a) Parts Required: 4025094 Backing Plate Engine Mount (4) AN4-20A Bolt (4) AN3-11A
More informationMooney Mite M-18X Plans and Drawings Index Arranged by Group Miscellaneous Group
Miscellaneous Group 110470 Bushings - Special 314410 Airspeed & Altimeter Installation 110190 Arm - Landing Warning 110070 Button - Static Airspeed 213260 Cone - Wing Fillet 110120 Control - Placard 616100
More informationLower Fuselage Assembly. Controls
Lower Fuselage Assembly Jabiru Aircraft Controls Lower Fuselage Assembly 10.11 3 051000 1 Assemble & Fit Control References: Drawings 3000092-7 and 93000K4/1 see (10.12) Photo 10.11(a) to 10.11(i) Parts
More informationLANCAIR LEGACY PRE-TEST FLIGHT INSPECTION (8-04)
LANCAIR LEGACY PRE-TEST FLIGHT INSPECTION (8-04) OWNER PHONE # ADDRESS N SERIAL # AIRCRAFT TYPE DATE / / TACH TIME hrs. TOTAL TIME hrs. EMPTY WEIGHT CG. PAINT & INTERIOR? YES NO ENGINE TYPE PROPELLER ALL
More informationPIPER CUB J3-65 N68952 PRE-FLIGHT CHECKLIST
PRE-FLIGHT CHECKLIST COCKPIT Check airworthiness certificate, registration, weight & balance documentation Battery - CONNECTED Plug in headsets or secure as required Fuel ON Primer CLOSED & LOCKED Carb
More informationPIPER CUB J3-65 N68952 PRE-FLIGHT CHECKLIST COCKPIT
PIPER CUB J3-65 N68952 PRE-FLIGHT CHECKLIST COCKPIT Check airworthiness certificate, registration, weight & balance documentation Battery - CONNECTED Plug in headsets or secure as required Fuel ON Magnetos
More informationSeabee Annual/100-Hour Inspection
Date Completed Seabee Annual/100-Hour Inspection ENGINE Mechanic s Initials 1 Drain engine oil and check for foreign material 2 Check oil screen for proper rotation or looseness 3 Safety Oil Plug 4 Refill
More informationAccident Prevention Program
Accident Prevention Program Maintenance Aspects of Owning Your Own Airplane Introduction As an owner-pilot, FAR Part 43 allows you to perform certain types of inspections and maintenance on your airplane.
More informationA Simplified Index of Mooney M-18 Drawings at the NASM
A Simplified Index of Mooney M-18 Drawings at the NASM Dwg. No. Dwg. date Title Models Remarks IDnum Price 0000 23-Aug-54 M-18 Aileron Crank Mooney M-18 17 x 22 DD-0029487 $2.10 0000 [Lower Pick-Up Strap
More informationMOONEY MITE AIRCRAFT DRAWINGS NASM Archives Accession No HOW TO ORDER COPIES OF DRAWINGS
SI-382712 BLUEPRINT MOONEY MITE AIRCRAFT DRAWINGS NASM Archives Accession No.1989-0028 HOW TO ORDER COPIES OF DRAWINGS NASM s collection of Mooney M-18 Mite drawings is available to restorers, researchers,
More informationCessna 172RG WARNING. Maximum Demonstrated Crosswind. Takeoff or landing..15 KTS
Cessna 172RG INTRODUCTION: This aircraft checklist contains information from the original manufacturer s Pilot Information Manual. Normal procedures associated with optional systems can be found in Section
More informationAEROPRO Checklist B Service/Maintenance
AEROPRO Checklist B Service/Maintenance 2 Periodic maintenance AIRFRAME Maintenance Interval Time Limitation - after first 25 2 hours when reached - after first 50 3 hours when reached - after 100 5 hours
More informationVan s Aircraft RV-4. Pilot s Operating Handbook
Van s Aircraft RV-4 Pilot s Operating Handbook PERFORMANCE SPECIFICATIONS SPAN:.. 23 0 LENGTH:. 19 9 HEIGHT:. 6 8 SPEED: Maximum at Sea Level.. Cruise, 75% Power at 8,000 Ft.. 173 Knots 165 Knots RANGE
More informationPREFLIGHT CHECK COCKPIT RIGHT WING. NORMAL PROCEDURRES CHECKLIST PA-28RT 201 Arrow IV
NORMAL PROCEDURRES CHECKLIST PA-28RT 201 Arrow IV PREFLIGHT CHECK COCKPIT Control Wheel -- Release Restraints Avionics -- OFF Parking Brake -- SET All Switches -- OFF Mixture -- IDLE CUT-OFF Master Switch
More information100hr and Condition inspection checklist
100 Hour and Annual Inspection Guide 100hr and Condition inspection checklist AA-100CONISP-LS1 Revision Date Details 0 4-2009 Original 1 4-2012 Format change AA-100CONISP-LS1 R1-4-2012 100 Hour and Annual
More informationJump to Table of Contents
Jump to Table of Contents PIPER AIRCRAFT CORPORATION PA-28R-201, CHEROKEE ARROW III SECTION 3 EMERGENCY PROCEDURES 3.3 EMERGENCY PROCEDURES CHECK LIST ENGINE FIRE DURING
More informationAirframe Group Item Description Part Number Size
Parts List: LS-1 Airframe Group Canopy - LS1 Aluminum sheet, 6061 T6 1241-8.050" x 1.5" 8" Angle, aluminum 6061-T6 987-6 2" x 2" x.125" 6" Bar stock, acetal 42367 1" x 1.25" 3" Bar stock, alum 1125-8 1"
More informationVan s Aircraft RV-7A. Pilot s Operating Handbook N585RV
Van s Aircraft RV-7A Pilot s Operating Handbook N585RV PERFORMANCE SPECIFICATIONS SPAN:..25 0 LENGTH...20 4 HEIGHT:.. 7 10 SPEED: Maximum at Sea Level...180 knots Cruise, 75% Power at 8,000 Ft...170 knots
More informationOwners Manual. Table of Contents 4.1. INTRODUCTION SPEEDS FOR NORMAL OPERATION CHECKLIST & PROCEDURES 4
NORMAL OPERATIONS Table of Contents 4.1. INTRODUCTION 2 4.2. SPEEDS FOR NORMAL OPERATION 2 4.3. CHECKLIST & PROCEDURES 4 4.3.1. PREFLIGHT INSPECTION 4 4.3.2. BEFORE STARTING ENGINE 8 4.3.3. STARTING ENGINE
More informationX-Air F - Parts Price List
Warning: These prices are outdated and will soon be replaced with current price lists. Please get a currently valid quote before ordering. X-Air F - Parts Price List Part Number 101058 101070 101074 101088
More informationSeabee Annual Inspection Procedures
Procedures Due to the wide variety of Seabee s flying out there, these procedures should be modified to fit YOUR Seabee. Make sure that all AD s are complied with as well as any required Service Bulletins
More informationMD RA Minister's Delegates - Recreational Aviation Représentants du Ministre - Aviation de loisir
Think Safety Pensons Securite MD RA Minister's Delegates - Recreational Aviation Représentants du Ministre - Aviation de loisir Inspection Service Service d'inspection MDRA C20 MANUAL of PROCEDURES for
More informationRAF BULLDOG MODIFICATION INDEX T Mk 1 SERIES
RAF BULLDOG MODIFICATION INDEX T Mk 1 SERIES ification Title Class Comments 1 1.4.73 Extension of Flap Shrouds B2 2 4.4.73 Resistor Part No 11212E (ITT Ltd) in Supply to Integral Lighting on CCS Panel
More information10. Lower Fuselage Assembly Undercarriage
10. Lower Fuselage Assembly Undercarriage Undercarriage 10.27 2 230399 0 Jabiru Undercarriage Configurations There are four combinations of tyres available, utilising two sets of hubs (standard and heavy
More informationCheck List for Maintenance Valid for SF 25 C Falke. Registration: Engine Type: ROTAX 912 A (1), (2), (3), (4) ROTAX 912 S (2) (3) (4) Owner:
Check List for Maintenance Valid for SF 25 C Falke Motor Glider Type: SF 25 C Serial No.: Engine Type: ROTAX 912 A (1), (2), (3), (4) ROTAX 912 S (2) (3) (4) Propeller Type: Registration: Year of Production:
More informationMODEL 95 PARTS CATALOG ALPHABETICAL INDEX , 21, 21A 31 3, 4, 4A , 58A 60 61A, 61B, 61C
A MODEL 5 PARTS CATALOG FIGURE A FIGURE Access Doors, Wing Accessories 7 Accumulatn~.' Propeller Governor Unfeathering. 56 Actuator Aileron T"JJ. Cover, Fl2v Cowl Flap Elevator Tab. Flap. Landing Gear
More informationTest Flying should only be performed by a pilot who is licensed, rated and experienced on the aircraft type.
Test Flying Procedure: Test Flying should only be performed by a pilot who is licensed, rated and experienced on the aircraft type. In particular, the test pilot should have recently demonstrated an ability
More informationInterior Pre Flight Documents: Check Control Wheel Lock: Remove Flight Controls: Check Instruments: Check for Damage Switches: Verify All Off Master
Interior Pre Flight Documents: Check Control Wheel Lock: Remove Flight Controls: Check Instruments: Check for Damage Switches: Verify All Off Master Switch ALT/BAT: On Fuel Gauge: Check Quantity Flaps:
More informationINSTALLATION MANUAL FOR JABIRU 5100 AIRCRAFT ENGINE
INSTALLATION MANUAL FOR JABIRU 5100 AIRCRAFT ENGINE This Manual has been prepared as a guide to correctly install the Jabiru 5100 engine into an airframe. Should you have any questions or doubts about
More informationPA28R ARROW CHECKLIST
PA28R ARROW CHECKLIST 2300.11.0112 1 Normal Procedures Initial PREFLIGHT CHECK General Appearance... CHECKED Position & Taxi Path... CHECKED Tie Downs, Locks, Chocks & Covers... REMOVED Cockpit Controls...UNLOCKED
More informationX-Air S - Parts Price List
X-Air S - Parts Price List Part Number Part Name Price AX06070 Trailing edge pin M6 Bolt (but and drill) $1.14 101058 Plate, Exhaust $6.44 101070 Bush, exhaust support $4.59 101074 Exhaust pipe support
More informationCARENADO COPYRIGHTS. Normal & Emergency Checklist
NORMAL PROCEDURES CHECKLIST PREFLIGHT CHECK Control wheel -- RELEASE BELTS Avionics -- OFF Master Switch -- ON Fuel quantity gauges -- CHECK Master switch -- OFF Ignition -- OFF Exterior -- CHECK FOR DAMAGE
More informationILLUSTRATED PARTS CATALOGUE
ILLUSTRATED PARTS CATALOGUE contains spare parts for: ATEC 122 Zephyr ATEC 321/322 Faeta ATEC 321 Faeta NG Pricelist valid from: April 1st, 2018 All prices indicated in EUR currency excluding VAT and freight;
More informationThe tie to tube front windshield was rounded to avoid a distorted by this point.
CHANGES IN AIRFRAME IBIS MAGIC GS-700 (2.008) Drilling of plastic polycarbonate drill with 9/64 so that it is an amplitude when riveting. The tie to tube front windshield was rounded to avoid a distorted
More informationILLUSTRATED PARTS CATALOGUE
ILLUSTRATED PARTS CATALOGUE contains spare parts for: ATEC 122 Zephyr ATEC 321/322 Faeta ATEC 321 Faeta NG Pricelist valid from: April 1st, 2018 All prices indicated in EUR currency excluding VAT and freight;
More informationSPARE PARTS CATALOGUE
SPARE PARTS CATALOGUE contains spare parts for: ATEC 321/322 Faeta ATEC 122 Zephyr Pricelist valid from: February 1st, 2017 All prices indicated in EUR currency excluding VAT and freight; EX WORKS conditions
More information22. Preparing for Flight
22 Preparing for flight 22. Preparing for Flight Rig the aeroplane ready to fly. 22.1 Airframe 22.1.1 Dihedral and washout The following specifications are intended as a rough indication of the correctness
More informationExpanded Flight Checklist Cessna 152
OUTSIDE CHECK INSIDE CABIN 1 Magnetos... OFF 2 Mixture... IDLE CUT OFF 3 Master switch... ON 4 Fuel quantity... CHECKED 5 Master switch... OFF OUTSIDE CABIN 1 Left wing... CHECKED Surface condition Flap
More informationINTRODUCTION. This Catalog:
Editor s Note: This Parts Catalog has been reproduced from the original Republic Parts Catalog. Obviously, most of the information is obsolete; the pictures are accurate and up-to-date. If nothing else,
More informationPIPER AIRCRAFT PA NOTE- Perform all inspections or operations at each oj the inspection. 1. Inspectspinnerandbackplate
PPER ARCRAFT PA-38-111 (.MANTENANCE MANUAL SCHEDULED MANTENANCE. PERODC NSPECTONS. -NOTE- Perform all inspections or operations at each oj the inspection intervals as indicated by a circle (). nspection
More informationASK 21 - Flight Manual. Check List / 1
Check List / 1 Pre Flight Check 1. Main pins secured? 2. Rear wing attachment pins: is the safety lock visible above the pin? 3. Horizontal tail unit pins secured. Is the spring retainer engaged? 4. Elevator
More informationOPERATIONS MANUAL FTO SECTION : 06.04
06.04.08. OO-WIK SECTION : 06.04 PARTENAVIA OO-WIK PAGE : 1 PRE ENTRY PITOT COVER - REMOVE SNOW / ICE CHECK AIRCRAFT NOSE INTO WIND AIRCRAFT WEIGHT & BALANCE WITHIN LIMITS EXTERNAL (COCKPIT FIRST) PARK
More informationOPERATOR CONTACT F U E L O I L TIRE S P E E D. Vg (best glide/flps0) 85Mph 74KIAS COM FAIL
OE-DLP CESSNA FR 172 G ROCKET 3fly.at: +43 2252 77340 MTOW: 1.157 kg / 2.250 lb A/C-Size: W: 10,93 m H: 2,9 m L: 8 m F P L ( E X A M P L E ) Tower LOAV +43 1 900729201 Maintenance LOAV +43 2252 790894
More information1. Ensure Bush Control Column (2) fit factory predrilled holes in Lower Fuselage Main Beam.
Assemble & Fit Control References: Drawings 3000092-7 and 93000K4/1 Photo 10.11(a), 10.11(b) Parts Required: 310408N Tube Handle Pivot 3000594 Input Drive Plate 3000394 Horizontal Tube 3100084 Output Yoke
More informationCHECKLIST 1969 CESSNA 172-K. NOTE: Verify all information with airplane's POH
CHECKLIST 1969 CESSNA 172-K NOTE: Verify all information with airplane's POH PRE-FLIGHT INSPECTION 1 CABIN 1 A.R.R.O.W. CHECK Airworthiness Cert. In Clear View Registration In Clear View Radio License
More informationINDEX: Normal Procedures Emergency Procedures Pre Flight Inspection NORMAL PROCEDURES BEFORE STARTING ENGINE
INDEX: Normal Procedures Emergency Procedures Pre Flight Inspection NORMAL PROCEDURES BEFORE STARTING ENGINE 1. Preflight Inspection -- COMPLETE 2. Seats, Belts, Shoulder Harnesses -- ADJUST and LOCK 3.
More information400 2x4/4x4 EFT SHARE OUR PASSION ṬM
SHARE OUR PASSION ṬM 400 2x4/4x4 EFT Model Number A2009IDG2BETR (Red - 2x4) Model Number A2009IDG2BETZ (Cat Green - 2x4) Model Number A2009IDG4BETR (Red - 4x4) Model Number A2009IDG4BETG (Green - 4x4)
More informationFUSELAGE ASSEMBLY SECOND SECTION (of three)
FUSELAGE ASSEMBLY SECOND SECTION (of three) 1 FRONT FLOOR ASSEMBLY The front floor assembly is fabricated from three pieces of the two ply pre-pregnated panel material supplied. The basic floor panel and
More informationParts Manual Rev. A Z 246 /
115 97 16-27 Rev. A Parts Manual Z 246 / 967 844501-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of
More informationSERIES GARDEN TRACTORS 1992 PARTS CATALOGUE CONTENTS
2000 SERIES GARDEN TRACTORS 1992 PARTS CATALOGUE CONTENTS PAGE No. 2000 SERIES GARDEN TRACTOR - CHASSIS, BODY PANELS, WHEELS, SEAT ETC 2 4 2000 SERIES PTO DRIVE, FRONT AXLE, ELECTRICS, MOUNTING FRAME AND
More informationPage 1 of HP B&S Vanguard Engine
1405 Page 1 of 41 14 HP B&S Vanguard Engine 1405 Page 2 of 41 14 HP B&S Vanguard Engine Ref # Part Number Qty S/P/F Description BS-28Q777-0647-E1 1 14 HP B&S Vanguard Engine 1 BS-496412 1 Cylinder Assembly
More informationModels AA-5, AA-5A & AA-5B Annual or 100-hour Inspection
Models AA-5, AA-5A & AA-5B Registration Number Serial Number Hours Registered Owner(s) Street Address City State/ Postal Code Provence Inspector Signature License No. Date Airport/City State/ Provence
More informationP O H / A F M - (AGX 2017 V1.5)
OE-AGX MTOW = 730 kg / 1.609 lb A/C-Size: W: 10,8 m H: 2,1 m L: 7,2 m F P L ( E X A M P L E ) 7 A/C ID OE-AGX Tower LOAV +43 1 900729201 Mainten. LOAV +43 2252 790894 A I S +43 51703 3211 M E T +43 51703
More informationPA32-RT LANCE II CHECKLIST
PA32-RT LANCE II CHECKLIST 6815.10.1112 1 Normal Procedures PREFLIGHT CHECK Control Wheel... RELEASE BELTS Parking brake... Set Master Switch... ON Fuel Quantity Gauges... check Master Switch... OFF Ignition...
More informationAircraft Maintenance Prof. A.K Ghosh Prof. Vipul Mathur Department of Aerospace Engineering Indian Institute of Technology, Kanpur
Aircraft Maintenance Prof. A.K Ghosh Prof. Vipul Mathur Department of Aerospace Engineering Indian Institute of Technology, Kanpur Lecture - 11 Inspection of Aircraft So, we are now on Cessna 206 edge
More informationProwler XTX SHARE OUR PASSION ṬM
SHARE OUR PASSION ṬM Prowler XTX Model Number U2009P3T4EUSV (Steel Blue) Model Number U2009P3T4EOSV (Steel Blue) International Model Number U2009P3T4EUSC (M4 Camo) Model Number U2009P3T4EUSQ (Black - LE)
More informationAA-5 SERIES MAINTENANCE MANUAL MODELS AA-5, AA-SA & AA-5B HOUR INSPECTION PROCEDURE ANNUAL OR 100 HOUR INSPECTION PROCEDURE GUIDELINE
MODELS AA-5, AA-SA & AA-5B ANNUAL OR 100 - HOUR INSPECTION PROCEDURE ANNUAL OR 100 HOUR INSPECTION PROCEDURE GUIDELINE FAR 43 15 (C) (1) states: Each person performing an annual or 100 hour inspection
More informationNORMAL CHECKLIST ATTENTION!
Avion Training CHECKLIST Normal Checklist CESSNA 172R / TC-STS Cessna 172 R TC-STS NORMAL CHECKLIST ATTENTION! DO NOT STOW THIS CHECKLIST IN DIRECT SUNLIGHT Avion Training - Doc.nr. 212 Revision 1 / 02022018
More informationParts Manual Rev. A
115 96 28-27 Rev. A Parts Manual Z 242F / 967 271802-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of
More informationChapter 52 DOORS -Title
Chapter 52 DOORS 52-Title Page 1 January 23, 2012 INTENTIONALLY LEFT BLANK 52-Title Page 2 January 23, 2012 LIST OF EFFECTIVE PAGES Chapter Section Page No. Date 52 52-Title 1 January 23, 2012 2 January
More informationParts Manual Rev. A
115 97 25-27 Rev. A Parts Manual Z 242F / 967 844702-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of
More informationT-51 Mustang - 3/4 Scale Kit
T-51 Mustang - 3/4 Scale Kit Description Titan Aircraft is pleased to offer the T-51D Mustang. This P-51D replica incorporates material and systems not commonly found in comparably priced aircraft. This,
More informationX4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY
2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY 2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 2 of 80 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3570-001 1 /P Intake,
More information26-Oct-2017 <NAME> <Aircraft Type> Annual CI / Pre-Buy Examination Checklist. Marc J. Zeitlin A&P #
AIRCRAFT INFO Aircraft Serial # Inspection Location Inspection Performed By Airframe Hours (TTAF) Engine Hours (SMOH) Propeller Hours Marc J. Zeitlin A&P #3052594 Annual CI / Pre-Buy
More informationSX300 for sale $249,000 or best offer 207 TTSN Airframe, Engine, Propeller Last Condition Inspection Last IFR Pitot-Static Mode-C
SX300 for sale $249,000 or best offer 207 TTSN Airframe, Engine, Propeller 11-2017 Last Condition Inspection 01-2017 Last IFR Pitot-Static Mode-C Certification SX300 for sale $249,000
More informationCessna 172P PPL Checklist Page 1
Cessna 172P PPL Checklist 06-08-2017 Page 1 Cessna 172P PPL Checklist 06-08-2017 Page 2 Checklist Items Informational Items Critical Memory Items PREFLIGHT COCKPIT CHECK (DO-LIST) Pitot Cover -- REMOVE
More informationRetriever PARTS LIST Advance MODEL 5200G(OBSOLETE)
Retriever PARTS LIST Advance MODEL 5200G(OBSOLETE) 5/85 revised 2/01 FORM NO. 56042131 TABLE OF CONTENTS DESCRIPTION PAGE OUTER BODY...1-2 HYDRAULIC PUMP, ENGINE & FUEL TANK...3-4 HYDRAULIC OIL FILTER,
More informationATV I l. l u. r a. Parts Manual ARCTIC CAT. 250 cc/300 cc
2000 I l l u st ATV 250 cc/300 cc Model No. A2000ATE2AUSG (250 - Green) Model No. A2000ATE2AUSR (250 - Red) Model No. A2000ATF2AUSG (300 2x4 - Green) Model No. A2000ATF2AUSR (300 2x4 - Red) Model No. A2000ATF4AUSG
More information4A.2 AIRSPEEDS FOR NORMAL OPERATING PROCEDURES
Normal Operating DA 40 AFM 4A.1 INTRODUCTION Chapter 4A contains checklists and describes extended procedures for the normal operation of the airplane. 4A.2 AIRSPEEDS FOR NORMAL OPERATING PROCEDURES Flight
More informationChapter 27. Flight Controls
Chapter 27 Flight Controls PAGE 1 Chapter 27 Table of Contents Chapter Title 27-00-00 GENERAL.................................. 3 27-00-01 Control Rods................................. 6 27-00-02 Bellcranks...................................
More informationLAD Inc. Beechcraft King Air 200 Series Technical Ground School Syllabus Material Covered
Topic Introduction Description Structures ATA 05 Technical Publications ATA 05 Aircraft Handling ATA 12 LAD Inc. Beechcraft King Air 200 Series Technical Ground School Syllabus Material Covered Course
More informationSECTION 4 NORMAL PROCEDURES CONTENTS
CONTENTS Page Recommended Airspeeds....................... 4-1 Daily or Preflight Checks........................ 4-1 Before Starting Engine.......................... 4-6 Starting Engine and Run-Up......................
More informationSTX-26 Stump Grinder
Form No. 3365-311 Rev B STX-26 Stump Grinder Model No. 23210 Serial No. 310000001 and Up Model No. 23210G Serial No. 310000001 and Up Register at www.toro.com. Original Instructions (EN) *3365-311* B Ordering
More informationPreflight Inspection Cabin EMPENNAGE RIGHT WING Trailing Edge RIGHT WING NOSE
Preflight Inspection Cabin 1. Control Wheel Lock REMOVED 2. Ignition Switch OFF 3. Avionics Power Switch OFF 4. Master Switch ON 5. Fuel Quantity Indicators CHECK QUANTITY 6. Master Switch OFF 7. Fuel
More informationPA ARCHER II Quick Reference Handbook
PA28-180 ARCHER II Quick Reference Handbook ALL GREY SHADED AREAS ARE MEMORY ITEMS 7813.03.0116 1 Table of Contents Normal Procedures... 4 PREFLIGHT CHECK... 4 BEFORE START... 6 FLOODED ENGINE START...
More informationSECTION 4 NORMAL PROCEDURES CONTENTS
CONTENTS Page Recommended Airspeeds....................... 4-1 Daily or Preflight Checks........................ 4-1 Before Starting Engine.......................... 4-6 Engine Starting Tips...........................
More informationCHAPTER 1 AIRCRAFT GENERAL
CHAPTER 1 AIRCRAFT GENERAL INTRODUCTION This manual provides a description of the major airframe and engine systems in the Cessna Citation Mustang (Figure 1-1). This material does not supersede, nor is
More informationSTX-26 Stump Grinder
Form No. 3383-656 Rev B STX-26 Stump Grinder Model No. 23208 Serial No. 314000001 and Up Model No. 23208G Serial No. 314000001 and Up Register at www.toro.com. Original Instructions (EN) *3383-656* B Ordering
More informationTable of content. Illustrated Parts Cataloque XA42 XA41
Table of content ATA Page Content 23 3 Communication 24 4 Electrical System 25 7 Equipment and Furnishings 27 11 Flight Controls 28 18 Fuel 31 20 Indicating / Recording Systems 32 23 Landing Gear 34 27
More informationParts Manual Rev. A
115 97 79-27 Rev. A Parts Manual Z 248F / 967 844801-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of
More informationCESSNA 182 CHECKLIST. LEFT WING Trailing Edge 1. Aileron CHECK freedom of movement and security
CESSNA 182 CHECKLIST PRE-FLIGHT INSPECTION CABIN 1. Pilot s Operating Handbook AVAILABLE IN THE AIRPLANE (A.R.R.O.W.E) 2. Landing Gear Lever DOWN 3. Control Wheel Lock REMOVE 4. Ignition Switch OFF 5.
More information400 4x4 Euro MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON.
2008 400 4x4 Euro Illustrated Parts Manual MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS 2008 ATV 400 4x4
More informationRECOMMENDED MOTOR AND BATTERY SET UP
SPECIFICATION - Wingspan: 1404mm (55.3in) - Length: 1134mm (44. 6 in) - Flying weight: 3.2-3.4 kg - Covering type: Genuine ORACOVER - Spinner size: scale type (not included) - Radio: 4 channel minimum
More informationInstruction Manual. Wingspan : 1400 mm (55.12 inch) : 1480 mm (58.27 inch) : 5500gr gr. : 6-9 channel/ 8 servo high torque,1 standard
Wingspan : 1400 mm (55.12 inch) g Length : 1480 mm (58.27 inch) Weight : 5500gr - 6000gr Radio : 6-9 channel/ 8 servo high torque,1 standard Engine : GT 22 OS KIT CONTENTS: We have organized the parts
More informationProwler XTZ Model Number U2013P4W1PUSU Model Number U2013P4W1POSU - International SHARE OUR PASSION.
2013 Prowler XTZ Model Number U2013P4W1PUSU Model Number U2013P4W1POSU - International TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 Prowler XTZ (Model No. U2013P4W1PUSU) (Model No. U2013P4W1POSU - International)
More informationAIRCRAFT LANDING GEAR CONSTRUCTION MANUAL
APPENDIX AI KITPLANES FOR AFRICA AIRCRAFT LANDING GEAR CONSTRUCTION MANUAL Revision: C September 2008 Page L1 of 20 NOTE: Please read the General Manual before proceeding. Please read through the entire
More informationDAYTONA 700 (97DTA-1997) Page 1 of 60 BILGE PUMP ASSEMBLY
1997 DAYTONA 700 (97DTA-1997) Page 1 of 60 BILGE PUMP ASSEMBLY 1997 DAYTONA 700 (97DTA-1997) Page 2 of 60 BILGE PUMP ASSEMBLY Ref # Part Number Qty S/P/F Description 1 0673-377 1 Fitting, Outlet - Bilge
More informationIllustrated Parts List
FORM MS 4183 10/31/2006 REPLACES FORM MS 9748 7/1997 FILE IN SECT. 2 OF SERVICE MANUAL 290700 Illustrated Parts List Model Series 290700 TYPE NUMBERS 0100, 0102, 0106, 0107, 0108, 0333, 0402, 0410. TO
More informationDVX 300 Euro. Model Number A2012KSF2BEUK SHARE OUR PASSION.
ATV 2012ATV Illustrated Parts Manual DVX 300 Euro Model Number A2012KSF2BEUK TM SHARE OUR PASSION. TABLE OF CONTENTS 2012 ATV DVX 300 Euro (Model No. A2012KSF2BEUK) BODY PANEL AND HEADLIGHT ASSEMBLY...
More informationChecklist LN-DAG SFK 2014
Checklist LN-DAG SFK 2014 2 GROUND Exsterior Checklist 1. Fuel (wings & filter) - Drained 2. Documents - Checked 3. Fire extinguisher, first aid sur. kit - Checked 4. Magnetos - Off 5. Master switch -
More informationILLUSTRATED PARTS MANUAL
ILLUSTRATED PARTS MANUAL Wildcat X LTD Model Number U2014WTW1PUSE Model Number U2014WTW1PUSJ Model Number U2014WTW1POSE - International Model Number U2014WTW1POSJ - International TM SHARE OUR PASSION.
More informationPREFLIGHT CHECKLIST PA28R-200
PREFLIGHT CHECKLIST PA28R-200 COCKPIT AND CABIN MAINTENANCE STATUS VERIFIED / CLEARED HOBBS / TACH METERS VERIFIED / RECORDED POH / AIRCRAFT DOCUMENTS AVAILABLE / PARKING BRAKE SET FLIGHT CONTROLS FREE
More informationPIPER AIRCRAFT CORPORATION
PA-28-181 INSPECTION REPORT ARCHER II ARCHER III PIPER AIRCRAFT CORPORATION (PART NUMBER 230 1039) PIPER AIRCRAFT CORPORATION INSPECTION REPORT This form meets requirements of FAR Part 43 Inspections must
More informationN398CM. RC-3 Serial Number 387 Zero Timed Restoration Details
RC-3 Serial Number 387 Zero Timed Restoration Details WING GROUP: Complete disassembly of wings, flaps, ailerons, lift struts, floats, and float struts. removal, alodine dip, and epoxy prime, w/bms 10-11.
More informationVr V STANDARD EQUIPMENT LIST
Vr V5.02.09 STANDARD EQUIPMENT LIST IMPORTANT NOTE: this document is a general description of the aircraft equipment only. It is not a technical document and is to be used only for the purpose of generally
More informationN123AX Piper Saratoga II HP (PA-32R-301) Checklist (v23 - Revision 3 April 2011) AIRSPEEDS FOR SAFE OPERATIONS. Best Rate of Climb (gear up, flaps up)
N123AX Piper Saratoga II HP (PA-32R-301) Checklist (v23 - Revision 3 April 2011) AIRSPEEDS FOR SAFE OPERATIS Best Rate of Climb (gear down, flaps up) Best Rate of Climb (gear up, flaps up) Turbulent Air
More informationTS-L 1000 (98MCC-1998) Page 1 of 69 BILGE PUMP ASSEMBLY
1998 TS-L 1000 (98MCC-1998) Page 1 of 69 BILGE PUMP ASSEMBLY 1998 TS-L 1000 (98MCC-1998) Page 2 of 69 BILGE PUMP ASSEMBLY 1 0673-377 1 Fitting, Outlet - Bilge 2 0612-456 2 Seal, Fitting 3 0623-753 2 /P
More informationSIZE.120 OR 30CC SCALE 1:5 ARF
PC21 PILATUS MK2 SIZE.120 OR 30CC SCALE 1:5 ARF SPECIFICATION - Wingspan: 1772mm (69.72in) - Length: 2019mm (79.5 in) - Flying weight: 6.4-7.2 kg - Wing area: 57.6 dm2 - Wing loading: 113g/dm2 - Wing type:
More information