Modern Auto Tech Study Guide Chapter 67 & 69 Pages Suspension & Steering 32 Points. Automotive Service
|
|
- Simon Fletcher
- 5 years ago
- Views:
Transcription
1 Modern Auto Tech Study Guide Chapter 67 & 69 Pages Suspension & Steering 32 Points Automotive Service
2 1. The system allows a vehicle s tires & wheels to move up and down as they roll. Steering Suspension Brake
3 2. Suspension can be grouped into 2 broad categories: &. Independent & Non independent Coil Springs & Air Springs Active & Passive
4 3. The perfect suspension system balances understeer and oversteer, resulting in steering. Tight Neutral Loose
5 4. Compressing springs is known as. As springs extend, they are said to. Jounce, Rebound Bounce, Resound Dribble, Rebound
6 5. Springs can be one of 4 types: A., B., C., & D.. Coil Leaf Air Torsion Bar
7 6. weight is all of the weight supported by the springs. weight is all of the weight not supported by the springs. The more sprung weight, the better the vehicle will ride. Spring, Unspring Sprang, Unsprang Sprung, Unsprung
8 7. Control arms are connected to the steering knuckles with pivoting joints called joints.
9
10 8. limit spring oscillations (jounce & rebound), but don t effect ride height Slack Absorbers Shock Absorbers Shock Restorers
11 9. shocks are filled with low pressure nitrogen gas to prevent fluid aeration (bubble formation). Gas Water Air
12 10. Options on shock absorbers include the feature & adjustable stiffness. Self Leveling Self Igniting Self Energizing
13
14
15 11. A assembly consists of a shock, coil spring & an upper damper/pivot bearing. (No upper ball joint) Strut Strat Shock
16 12. A bar or stabilizer bar prevents the vehicle body from leaning excessively in sharp turns. Sway Bar Links Sway Bar Bushings Sway Bar Stray Spray Sway
17 13. A rod controls lateral or side to side axle movement during cornering. Track Strut Tie
18 14. Suspension systems can be of the SHORT LONG arm, TORSION bar, or the MACPHERSON STRUT design. Slightly modified versions of each type can be found.
19 15. suspension systems can be either, independent, semi independent, or non independent. Rear
20 15. suspension systems can be either, independent, semi independent, or non independent. Rear
21 15. suspension systems can be either, independent, semi independent, or non independent. Rear
22 15. suspension systems can be either, independent, semi independent, or non independent. Rear
23 16. Electronic RIDE control systems use computerization to monitor and maintain correct ride height.
24 17. ACTIVE suspensions use PCM controlled hydraulics for ride control instead of springs & shocks.
25 ~~~ Automotive Service 18. The system must provide control of the steering wheels, maintaining the correct amount of effort to transmit road feel to the driver s hands. Steering Suspension Brake
26
27 19. In rack & pinion steering, the is a flat steel bar with gear teeth. The is a small gear that meshes with the rack, it is rotated by the steering wheel and steering shaft.
28
29
30
31
32 20. steering columns help prevent driver chest & face injury during collisions Collapsible Inflatable Regenerative
33 21. RECIRCULATING BALL & worm gear steering boxes are heavier & more complicated than rack & pinion.
34 22. On parallelogram steering, the arm and the arm support the ends of the center link. Tie rods & tie rod ends connect the steering system center parts to the knuckles.
35
36
37
38
39
40
41
42
43 Parallelogram Steering Short Long Arm Suspension
44 McPherson Strut Suspension Rack & Pinion Steering
Chapter. Suspension System Technology. Basic Suspension System. Functions of a Suspension System
76 Chapter Suspension System Technology Name Instructor Date Score Objective: After studying this chapter, you will be able to explain the construction and operation of modern suspension systems. Basic
More informationChapter. Steering System Technology
Chapter 78 Steering System Technology Objectives After studying this chapter, you will be able to: Explain the operating principles of steering systems. Identify the major parts of a steering system. Compare
More informationChapter. Steering System Technology. Basic Steering Systems. Functions of a Steering System. Basic Steering Systems
78 Chapter Steering System Technology Name _ Instructor Date _ Score Objective: After studying this chapter, you will be able to summarize the construction and operation of steering systems. Basic Steering
More informationAER Automotive Steering and Suspension
2013 NATEF JOB TASKS COMPLETION REQUIREMENT: P1-95% P2-80% P3-50% Student Name: DETAILED COURSE CONTENT AUTOMOTIVE SUSPENSION AND STEERING TECHNICIAN DEMONSTRATE PROFICIENCY IN SUSPENSION AND STEERING
More informationSteering and Suspension
The Steering and Suspension system is engineered to allow the vehicle to turn and absorb road irregularities. The suspension is comprised of springs, suspension arms or links and shock dampers. These components
More informationRack and Pinion Steering Inspection and Repair
JOB SHEET 187 Rack and Pinion Steering Inspection and Repair Name: --------------- Station: Date: NATEF Correlation This Job Sheet addresses the following NATEF task(s): 4.B.3 4.B.5 4.B.6 4.B.9.4.B.18
More information2013 NATEF Task Area A-4 Suspension, Steering, Alignment7-2013
2013 NATEF Task Area A-4 Suspension, Steering, Alignment7-2013 A. Steering System Diagnosis & Repair B. Suspension System Diagnosis & Repair C. Wheel Alignment Diagnosis & Adjustment D. Wheel & Tire Diagnosis
More information1. SPECIFICATIONS 2. WHEEL ALIGNMENT
441101 083 1. SPECIFICATIONS Front Suspension Rear Suspension Description Suspension type Spring type Shock absorber type Stabilizer bar type Suspension type Spring type Shock absorber type Stabilizer
More informationHemet High School NATEF SUSPENSION AND STEERING CHECKLIST. Name Date Period
Hemet High School NATEF SUSPENSION AND STEERING CHECKLIST Name Period For every task in Suspension and Steering, the following safety requirement must be strictly enforced: Comply with personal and environmental
More informationSU11 Independant, SLA
Uniform Procedures For Collision Repair UPCR SU11 Independant, SLA 1. Description This procedure describes the diagnosis, repair, and inspection of an independent, short-arm, long-arm (SLA) suspension
More informationVERNON COLLEGE SYLLABUS. DIVISION: Information & Industrial Technology DATE: Fall COURSE NUMBER AND TITLE: AUMT 1416 Suspension and Steering
VERNON COLLEGE SYLLABUS DIVISION: Information & Industrial Technology DATE: Fall 2010 CREDIT HRS: 4 HRS/WK LEC: 3 HRS/WK LAB: 3 LEC/LAB: 6 I. CATALOG DESCRIPTION: Theory and operation of automotive suspension
More informationSuspension and Steering Alignment
Suspension and Steering Alignment Matthew Whitten Brookhaven College Alignment Components Ride height Caster Camber Included angle Scrub radius Thrust angle Toe Turning radius Toe out on turns Steering
More informationSU01 Independent, Strut
Uniform Procedures For Collision Repair SU01 Independent, Strut 1. Description This procedure describes the diagnosis, repair, and inspection of an independent, strut-type suspension system. 2. Purpose
More informationCamber Angle. Wheel Alignment. Camber Split. Caster Angle. Caster and Ride Height. Toe Angle. AUMT Wheel Alignment
AUMT 1316 - Wheel Alignment 11/15/11 Camber Angle Wheel Alignment Donald Jones Brookhaven College Camber Split Camber is the amount that the centerline of the wheel tilts away from true vertical when viewed
More informationUNIBODY/FRAME/WHEEL ALIGNMENT II ABCT 2212
UNIBODY/FRAME/WHEEL ALIGNMENT II ABCT 2212 A. Course Description Credits: 6.00 Lecture Hours/Week: 1.00 Lab Hours/Week: 5.00 OJT Hours/Week: 0 Prerequisites: None Corequisites: None MnTC Goals: None This
More information1. SPECIFICATIONS 2. WHEEL ALIGNMENT Front Suspension. (gas type) Rear Suspension. (gas type)
441101 053 1. SPECIFICATIONS Front Suspension Rear Suspension Description Suspension type Spring type Shock absorber type Stabilizer bar type Suspension type Spring type Shock absorber type Stabilizer
More informationSteering Fundamentals
CHAPTER 65 Fundamentals OBJECTIVES Upon completion of this chapter, you should be able to: List the parts of steering systems. Describe the principles of operation of steering systems. Compare linkage
More informationAutomotive Suspension and Steering Course number-20123
Automotive Suspension and Steering Course number-20123 There is a high demand for trained individuals in the automotive service field. The desire for the students to receive industry-based training at
More informationTechnician Handbook. 453 Suspension, Steering and Handling. Technician Objectives
Technician Objectives 1. List the six functions of suspension components.. 2. List the six major groups of components that require inspection. 3. Explain the inspection methods for the individual suspension
More informationSU41 Solid Axle, Leaf Springs
Uniform Procedures For Collision Repair SU41 Solid Axle, Leaf Springs 1. Description This procedure describes the diagnosis, repair, and inspection of a solid-axle, leaf-spring suspension system. 2. Purpose
More informationShock Absorbers What is Ride Control Vehicle Dynamics Suspension System Shock Absorbers Struts Terminology
Home Tech Support Shock Absorbers Shock Absorbers What is Ride Control Vehicle Dynamics Suspension System Shock Absorbers Struts Terminology A BRIEF HISTORY These first shock absorbers were simply two
More informationJEFFERSON COLLEGE COURSE SYLLABUS AUT141 AUTOMOTIVE STEERING AND SUSPENSION SYSTEMS. 3 Credit Hours. Prepared by: Gerard Uhls Date: November, 2011
JEFFERSON COLLEGE COURSE SYLLABUS AUT141 AUTOMOTIVE STEERING AND SUSPENSION SYSTEMS 3 Credit Hours Prepared by: Gerard Uhls Date: November, 2011 Revised by: Gerard Uhls Date: September 16, 2016 Chris DeGeare,
More informationPan Car Setup and Troubleshooting
Pan Car Setup and Troubleshooting Problems can come up in the midst of competition. Either the car is not handling properly on the track or there are problems with equipment. Troubleshooting problems should
More informationSR11 Steering, Rack-And-Pinion
Uniform Procedures For Collision Repair SR11 Steering, Rack-And-Pinion SR Menu Procedure Menu 1. Description This procedure describes diagnosis, replacement, and inspection of a rack-and-pinion steering
More informationSUSPENSION 2-1 SUSPENSION TABLE OF CONTENTS
DN SUSPENSION 2-1 SUSPENSION TABLE OF CONTENTS page ALIGNMENT... 1 FRONT SUSPENSION - 4x2... 6 page FRONT SUSPENSION - 4x4... 14 REAR SUSPENSION... 23 ALIGNMENT TABLE OF CONTENTS page AND OPERATION WHEEL
More informationAccording to Newton's First Law, a moving body will continue moving in a straight line until it is acted
RIDE CONTROL DEFINED According to Newton's First Law, a moving body will continue moving in a straight line until it is acted upon by another force. Newton's Second Law states that for each action there
More informationSUSPENSION 2-1 SUSPENSION TABLE OF CONTENTS
XJ SUSPENSION 2-1 SUSPENSION TABLE OF CONTENTS page ALIGNMENT... 1 FRONT SUSPENSION... 7 page REAR SUSPENSION... 16 ALIGNMENT TABLE OF CONTENTS page AND WHEEL ALIGNMENT...1 DIAGNOSIS AND TESTING SUSPENSION
More informationJEFFERSON COLLEGE COURSE SYLLABUS AUT142 AUTOMOTIVE STEERING AND SUSPENSION SYSTEMS LAB. 3 Credit Hours. Prepared by: Gerard Uhls Date: December 2011
JEFFERSON COLLEGE COURSE SYLLABUS AUT142 AUTOMOTIVE STEERING AND SUSPENSION SYSTEMS LAB 3 Credit Hours Prepared by: Gerard Uhls Date: December 2011 Revised by: Gerard Uhls Date: September 16. 2016 Chris
More informationCourse Name : Diploma in Automobile Engineering Course Code : AE Semester : Fourth Subject Title : Automobile Systems Subject Code : 12098
Course Name : Diploma in Automobile Engineering Course Code : AE Semester : Fourth Subject Title : Automobile Systems Subject Code : 12098 Teaching and examination scheme: Teaching Scheme TH TU PR PAPER
More informationSRI VIDYA COLLEGE OF ENGINEERING & TECHNOLOGY DEPARTMENT OF MECHANICAL ENGINEERING. ME AUTOMOBILE ENGINEERING Question Bank
SRI VIDYA COLLEGE OF ENGINEERING & TECHNOLOGY DEPARTMENT OF MECHANICAL ENGINEERING ME6602 - AUTOMOBILE ENGINEERING Question Bank UNIT-4 - STEERING, BREAKS AND SUSPENSION PART-A 1. Define wheel track and
More informationColorado/ Canyon 4, 5, and 6 Lift Kit
*1221BAG3* 1221BAG3 921221200B 2015-16 Colorado/ Canyon 4, 5, and 6 Lift Kit Thank you for choosing Rough Country for all of your suspension needs. Rough Country recommends a certified technician installs
More informationDRIVE-CONTROL COMPONENTS
3-1 DRIVE-CONTROL COMPONENTS CONTENTS FRONT SUSPENSION................... 2 Lower Arms............................... 5 Strut Assemblies........................... 6 REAR SUSPENSION.....................
More informationREPAIR INSTRUCTIONS > LOWER CONTROL ARM REPLACEMENT (1500 SERIES) > TOOLS REQUIRED
Page 1 of 13 2007 GMC Yukon 5.3L Eng Base Service Manual: FRONT SUSPENSION SYSTEM Print Date: REPAIR INSTRUCTIONS > LOWER CONTROL ARM REPLACEMENT (1500 SERIES) > TOOLS REQUIRED J 43631 Ball Joint Separator.
More informationINSTALLATION INSTRUCTION Rev A
INSTALLATION INSTRUCTION 88587 Rev A FOR RANCHO SUSPENSION SYSTEM RS6587B: 2009 DODGE RAM 1500 READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION IMPORTANT NOTES! WARNING:
More informationAUTO-1400: AUTOMOTIVE ALIGNMENT, STEERING AND SUSPENSION
AUTO-1400: Automotive Alignment, Steering and Suspension 1 AUTO-1400: AUTOMOTIVE ALIGNMENT, STEERING AND SUSPENSION Cuyahoga Community College Viewing:AUTO-1400 : Automotive Alignment, Steering and Suspension
More informationFundamentals of Steering Systems ME5670
Fundamentals of Steering Systems ME5670 Class timing Monday: 14:30 Hrs 16:00 Hrs Thursday: 16:30 Hrs 17:30 Hrs Lecture 3 Thomas Gillespie, Fundamentals of Vehicle Dynamics, SAE, 1992. http://www.me.utexas.edu/~longoria/vsdc/clog.html
More informationSUSPENSION 2-1 SUSPENSION CONTENTS
DN SUSPENSION 2-1 SUSPENSION CONTENTS page ALIGNMENT... 1 FRONT SUSPENSION... 5 page REAR SUSPENSION... 13 ALIGNMENT INDEX page GENERAL INFORMATION WHEEL ALIGNMENT... 1 DIAGNOSIS AND TESTING PRE-ALIGNMENT
More informationEngine Exhaust system. Engine
Engine Engine 272 - Exhaust system The engine of the 6-cylinder version satisfies the US exhaust emissions limits. To meet these limits the monolith coating of the catalytic converters has been modified
More informationEnergy Power and Transportation Final Exam
Class: Date: Energy Power and Transportation Final Exam Multiple Choice Identify the choice that best completes the statement or answers the question. 1. Technician A says a 12-volt light bulb has a resistance
More informationSECTION steering mechanism
07-302.01/ 1 2011MR17 SECTION 07-302.01 GENERAL Description See Figure 1. The includes the steering wheel (1), the steering column, the miter box (3), the steering shafts (2 and 4), and the drag link (7).
More informationSTOP---READ THIS FIRST!
STOP---READ THIS FIRST! **Read These Entire Instructions Before Starting Anything** 2007-2013 GM 1500 TRUCK LIFT KIT INSTRUCTIONS (PART# 50700 & 50720) 5680 W. Barstow, Fresno, CA 93722 PH: (559) 226-8196
More informationSR01 Steering, Gearbox
Uniform Procedures For Collision Repair SR01 Steering, Gearbox 1. Description This procedure describes the diagnosis, repair, and inspection of a gearbox-type steering system. Requirements for both manual
More informationSTOP---READ THIS FIRST!
STOP---READ THIS FIRST! **Read These Entire Instructions Before Starting Anything** 2007-2010 GM 1500 TRUCK LIFT KIT INSTRUCTIONS (PART# 50700 & 50720) 5680 W. Barstow, Fresno, CA 93722 PH: (559) 226-8196
More informationINSTALLATION INSTRUCTION 88581
INSTALLATION INSTRUCTION 88581 FOR RANCHO SUSPENSION SYSTEM RS6581B: DODGE RAM READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev C IMPORTANT NOTES! WARNING: This suspension
More information2014 GM 1500 TRUCK STOP---READ THIS FIRST! 7" Lift KIT. **Read These Entire Instructions Before Starting Anything**
STOP---READ THIS FIRST! **Read These Entire Instructions Before Starting Anything** 2014 GM 1500 TRUCK LIFT KIT INSTRUCTIONS (PART #50768 & #50769 ) 5680 W. Barstow, Fresno, CA 93722 PH: (559) 226-8196
More informationWheel Alignment Fundamentals
CHAPTER 67 Wheel Alignment Fundamentals OBJECTIVES Upon completion of this chapter, you should be able to: Describe each wheel alignment angle. Tell which alignment angles cause wear or pull. KEY TERMS
More informationDIAGNOSIS AND TESTING
DIAGNOSIS AND TESTING SUSPENSION AND STEERING SYSTEM 2007 SUSPENSION Suspension - Nitro CONDITION POSSIBLE CAUSES CORRECTION FRONT END NOISE 1. Loose or worn wheel bearings. 1. Replace wheel bearings.
More informationCarli Suspension Front Instructions
Carli Suspension Front Instructions 94-08 DODGE 2500-3500 4X4 SUSPENSION SYSTEM Note: Prior to installation, carefully inspect the vehicle=s steering and drive train components. Be sure to check ball joints,
More informationSECTION 2C FRONT SUSPENSION TABLE OF CONTENTS
SECTION 2C FRONT SUSPENSION TABLE OF CONTENTS Description and Operation... 2C-2 Front Suspension... 2C-2 Specifications... 2C-4 Component Locator... 2C-5 Front Suspension Assembly... 2C-5 Cross-Sectional
More informationINSTALLATION INSTRUCTIONS 88518
INSTALLATION INSTRUCTIONS 88518 For Rancho Suspension Systems RS6518: 2009 FORD F-150 4WD READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev A IMPORTANT NOTES! WARNING:
More informationAUTOMOTIVE TECHNOLOGY Service and Maintenance
AUTOMOTIVE TECHNOLOGY Service and Maintenance Don Knowles Knowles Automotive Training Moose Jaw, Saskatchewan CANADA Jack Erjavec, Series Editor Professor Emeritus Columbus State Community College Columbus,
More informationLG CORVETTE GT2 COIL OVERS
LG CORVETTE GT2 COIL OVERS THE MOST POWERFUL HEADERS ON THE PLANET Brought to you by LG Motorsports 972-429-1963 Parts Inventory: 1. Assembled Front shock and spring 2. Assembled Rear shock and spring
More informationFor the 4 lift application we recommend an 18 wheel not to exceed 9 in width with 5 of backspacing/ 0 offset and a 275/65-18 tire.
921221200F *1221BAG16* 1221BAG16 2015-18 Colorado/ Canyon 4 and 6 Lift Kit Thank you for choosing Rough Country for all of your suspension needs. Rough Country recommends a certified technician installs
More informationSteering System Principles
C H A P T E R 8 Steering System Principles Chapter Objectives At the conclusion of this chapter you should be able to: KEY TERMS collapsible steering column end-takeoff rack flexible coupler gearbox multi-rib
More informationINSTALLATION INSTRUCTION 88088
INSTALLATION INSTRUCTION 88088 For Rancho Suspension Systems RS6588 & RS6589: FORD F-150 READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev B IMPORTANT NOTES! WARNING:
More informationSUSPENSION 2-1 SUSPENSION CONTENTS
TJ SUSPENSION 2-1 SUSPENSION CONTENTS page ALIGNMENT... 1 FRONT SUSPENSION... 5 page REAR SUSPENSION... 12 ALIGNMENT INDEX page GENERAL INFORMATION WHEEL ALIGNMENT... 1 DIAGNOSIS AND TESTING SUSPENSION
More informationA double-wishbone type suspension is used in the front. A multi-link type suspension is used in the rear. Tread* mm (in.) 1560 (61.
CHASSIS SUSPENSION AND AXLE CH-69 SUSPENSION AND AXLE SUSPENSION 1. General A double-wishbone type suspension is used in the front. A multi-link type suspension is used in the rear. 08D0CH111Z Specifications
More informationSUSPENSION 2-1 SUSPENSION CONTENTS
TJ SUSPENSION 2-1 SUSPENSION CONTENTS page ALIGNMENT... 1 FRONT SUSPENSION... 6 page REAR SUSPENSION... 13 ALIGNMENT INDEX page DESCRIPTION AND OPERATION WHEEL ALIGNMENT... 1 DIAGNOSIS AND TESTING SUSPENSION
More informationTOYOTA TACOMA (ALL 4WD, 2WD PRERUNNER, & 2WD TRD MODELS) 1.5 LEVELING LIFT KIT INSTALLATION INSTRUCTIONS KIT# TL224PA
Many states and municipalities have laws restricting bumper heights and vehicle lifts. Consult state and local laws to determine if the changes you intend to make to the vehicle comply with the law. 3651
More informationInstallation Manual. 3 suspension system Ford F150. Part # Part # Important customer information: Ford F150
Installation Manual 3 suspension system 2015-2018 Ford F150 Part # 23030 SS08282015 Part # 23030 2015-2018 Ford F150 3 suspension system Part # Description Qty. 23000-01 Driver side upper control arm 1
More informationTypical mounting of a dial indicator for a radial check. Moog Automotive, Inc.
Inspect / Service / Test / Replace To find out if the ball joint is loose beyond manufacturer's specifications, use an accurate measuring device. Most load carrying ball joints have a wear limit of 0.060"
More informationSUSPENSION 2-1 SUSPENSION CONTENTS
ZJ SUSPENSION 2-1 SUSPENSION CONTENTS page ALIGNMENT... 1 FRONT SUSPENSION... 6 page REAR SUSPENSION... 14 ALIGNMENT INDEX page GENERAL INFORMATION WHEEL ALIGNMENT... 1 DIAGNOSIS AND TESTING SUSPENSION
More informationtable of contents about our company PRODUCT OVERVIEW
PRODUCT CATALOG table of contents PRODUCT OVERVIEW Leveling Kits Chevy Lift Kits Dodge Lift Kits Ford Lift Kits Jeep Lift Kits Toyota Lift Kits Nissan Lift Kits Shock Absorbers & Steering Stabilizers Upper
More informationI. Assembling the Air Spring
B F H G D FRONT I Assembling the Air Spring 1 Install 90 degree air swivel fitting (D) to the top of the bellow This fitting is precoated with sealant Using an open-end wrench, tighten 1 and 1 /2 turns
More informationPart # Mustang Complete SA CoilOver Kit
Front Components: 350 S. St. Charles St. Jasper, In. 47546 Ph. 812.482.2932 Fax 812.634.6632 www.ridetech.com Part # 12100210 67-70 Mustang Complete SA CoilOver Kit 1 12103510 Single Adjustable Front CoilOvers
More informationAlways wear eye protection when operating power tools. Before you install this kit, block the vehicle tires to prevent the vehicle from rolling.
Many states and municipalities have laws restricting bumper heights and vehicle lifts. Consult state and local laws to determine if the changes you intend to make to the vehicle comply with the law. 3651
More information2011 MKS Workshop Manual. SECTION : Suspension System - General Information DESCRIPTION AND OPERATION Procedure revision date: 05/25/2010
SECTION 204-00: Suspension System - General Information 2011 MKS Workshop Manual DESCRIPTION AND OPERATION Procedure revision date: 05/25/2010 Wheel Alignment Angles Camber Negative and Positive Camber
More informationINSTALLATION INSTRUCTION 89400
INSTALLATION INSTRUCTION 89400 FOR RANCHO SUSPENSION SYSTEM RS66400B: 2012 RAM 1500 4WD. READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev B IMPORTANT NOTES! WARNING:
More informationSUSPENSION AND AXLE Specifications (Front/2WD)
A20 SUSPENSION AND AXLE Specifications (/2WD) Cold tire inflation pressure Pressure kpa (kgf/cm2, psi) Chassis ground clearance RN80L TRMDEA RN80L TRMDEK Clearance mm (in.) RN80L TRSDEA RN80L TRSDEK RN80L
More informationLATERAL LIMITER KIT TORSION BAR KIT
C42-429 C42-427 LATERAL LIMITER KIT Controls engine and transmission movement during hard acceleration or braking. With 4130 chromoly tubing and brackets, this kit is recommended when using motor plates.
More informationSECTION 3A WHEEL ALIGNMENT
SECTION 3A WHEEL ALIGNMENT NOTICE: All wheel alignment fasteners are important attaching parts in that they could affect the performance of vital components and systems, and/or could result in major repair
More information*1333BAG1* 1333BAG DODGE LIFT KIT
921333300 *1333BAG1* 1333BAG1 2012-18 DODGE 1500 4 LIFT KIT Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system. In addition
More informationPage 1 of 11 1Search FRAME CROSS BAR 2001 Chrysler PT Cruiser 2.4L Eng Base CAUTION: DO NOT attempt to modify any suspension or steering components by heating or bending. Removal [ STABILIZER BAR ] 1.
More informationThis file is available for free download at
This file is available for free download at http://www.iluvmyrx7.com This file is fully text-searchable select Edit and Find and type in what you re looking for. This file is intended more for online viewing
More informationSuspension System RS6582B
Suspension System RS6582B Tahoe/Yukon READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION IMPORTANT NOTES! WARNING: This suspension system will enhance the off-road performance
More informationAppendix X New Features in v2.4 B
Appendix X New Features in v2.4 B Version 2.4B adds several features, which we have grouped into these categories: New Suspension Types or Options The program now allows for solid front axles and for several
More information09-UP FORD F150 6 LIFT KIT
92159800 09-UP FORD F150 6 LIFT KIT THANK YOU FOR CHOOSING ROUGH COUNTRY FOR YOUR SUSPENSION NEEDS. Rough Country recommends a certified technician install this system. In addition to these instructions,
More informationDODGE DIESEL KIT DODGE DIESEL KIT
69120 2009-2013 DODGE 2500 8 DIESEL KIT 2009-2012 DODGE 3500 8 DIESEL KIT Heavy Duty Long Arm Construction For Superior Ride Quality And Travel Lower Arms Constructed Of 1.75 DOM Tubing W/ Urethane Bushing
More informationSUSPENSION 2-1 SUSPENSION CONTENTS
WJ SUSPENSION 2-1 SUSPENSION CONTENTS page ALIGNMENT... 1 FRONT SUSPENSION... 4 page REAR SUSPENSION... 15 ALIGNMENT INDEX page AND WHEEL ALIGNMENT... 1 SERVICE PROCEDURES PRE-ALIGNMENT... 2 AND WHEEL
More information(877) MON-FRI 7AM-5PM PST OR WEBSITE: ReadyLIFT.COM **Please retain this document in your vehicle at all times**
IF YOUR ReadyLIFT PRODUCT IS MISSING A OR HAS A DAMAGED PART, PLEASE CONTACT CUSTOMER SERVICE DIRECTLY. For warranty issues please return to the place of installation and contact ReadyLIFT. A NEW REPLACEMENT
More informationVehicle ride height chart
Please read Instructions thoroughly and completely before beginning installation. Installation by a certified mechanic is recommended. ReadyLIFT Suspension Inc. is NOT responsible for any damage or failure
More informationPRE-INSTALLATION. INSTALLATION INSTRUCTIONS Front Dodge Ram WD 6" Suspension Lift Kit
2012-2015 Dodge Ram 1500 4WD 6" Suspension Lift Kit PRE-INSTALLATION 35015 2 - Knuckle (Driv/Pass) 2 - Crossmember (Front/Rear) 2 - Differential Bracket (Driv/Pass) 1 - Diff. Brace Bracket (Pass) 2 - Front
More informationThis file is available for free download at
This file is available for free download at http://www.iluvmyrx7.com This file is fully text-searchable select Edit and Find and type in what you re looking for. This file is intended more for online viewing
More informationATASA 5 th. Wheel Alignment. Please Read The Summary. ATASA 5 TH Study Guide Chapter 47 Pages: Wheel Alignment 64 Points
ATASA 5 TH Study Guide Chapter 47 Pages: 1403 1423 64 Points Please Read The Summary Before We Begin Keeping in mind the Career Cluster of Transportation, Distribution & Logistics Ask yourself: What careers
More informationFRONT SUSPENSION GROUP 2 FRONT SUSPENSION 2-1 CONTENTS SPECIFICATIONS VC-1, VC-2, VC-3 VY-1 TOOL LIST. Page
GROUP 2 FRONT SUSPENSION CONTENTS Page Specifications 1 Tool List.... 1 Torque Reference 2 Preparation for Measuring Front End Alignment... 2 Front Suspension Height Adjustment 3 Front Suspension Alignment
More informationCHEVY COLORADO GMC CANYON 2 LEVELING KIT 2WD & 4WD INSTALLATION INSTRUCTIONS 2015 KIT# CL227PA
Many states and municipalities have laws restricting bumper heights and vehicle lifts. Consult state and local laws to determine if the changes you intend to make to the vehicle comply with the law. 3651
More informationPRODUCT BROCHURE. Straight advice, specialists you understand and...
PRODUCT BROCHURE Shock absorbers PEDDERS STEERING EQUIPMENT Pedders Shock Absorbers Replacement, Sports, Towing, Load Carrying & 4WD Bilstein Shock Absorbers Replacement Shocks to suits European Makes
More informationTools Needed. I. Getting Started
5 /16 ", 7 /16 ", 9 /16 " and 19mm open-end or box wrenches Crescent Wrench Ratchet with 9 /16 " and 1 /2 " deep well sockets 3 /8 " and 5 /16 " drill bits (very sharp) Heavy Duty Drill Torque Wrench Tools
More informationMounting Kit MKPB-QLIV
Mounting Kit 52720-MKPB-QLIV K1500 Sierra/Silverado 4x4 1999-2006 - For the snow plow lights (1999-2006), this kit requires: 800084,800085 or 800086 light kit, 53617-M wiring kit, Adapter kit 767054 (vehicle
More informationNew Generation Rear Wheel Drive
New Generation Rear Wheel Drive ABC HOBBY ORIGINAL RADIO CONTROL CAR Instruction Manual Study the instructions thoroughly before assembly. REAR 2 WHEEL DRIVE REAR MOUNTED MOTOR BELT DRIVE DOUBLE DECK CHASSIS
More informationPart # Mustang Complete CoilOver Kit
Front Components: 1 12103509 Front CoilOvers 1 12102899 Lower StrongArms 1 12103699 Upper StrongArms 350 S. St. Charles St. Jasper, In. 47546 Ph. 812.482.2932 Fax 812.634.6632 www.ridetech.com Part # 12100109
More informationTorque steer effects resulting from tyre aligning torque Effect of kinematics and elastokinematics
P refa c e Tyres of suspension and drive 1.1 General characteristics of wheel suspensions 1.2 Independent wheel suspensions- general 1.2.1 Requirements 1.2.2 Double wishbone suspensions 1.2.3 McPherson
More informationMOUNTING KIT MKPB
5288-MKPB MOUNTING KIT 5288-MKPB Blazer 500/Suburban 500/Yukon 500/Tahoe 500 4x4 992-999 Suburban 2500 Classic 4x4 992-999 K500 Classic 4x4 988-989 K500 Classic 4x4 990-998 K2500 Classic 4x4 988-989 K2500
More informationFront Suspension - Front Stabilizer Bar Bushing Removal and Installation
1 of 3 23/02/2012 7:34 AM Front Suspension - Front Stabilizer Bar Bushing Removal and Installation Published: 11-May-2011 Removal WARNING: Make sure to support the vehicle with axle stands. Raise and support
More informationSTEERING SYSTEM Introduction
STEERING SYSTEM Introduction The steering makes it possible to change direction. The steering must be reliable and safe; there must not be too much play in the steering. It must be possible to steer accurately.
More informationInstallation Instructions
79-04 Ford Mustang Perfect Fit K-Member Part # 20022 Installation Instructions Congratulations on your purchase of the AFCO Perfect Fit K-member for the 79-04 Ford Mustang. Please read and understand each
More informationSUSPENSION - FRONT Toyota Celica DESCRIPTION ADJUSTMENTS & INSPECTION WHEEL ALIGNMENT SPECIFICATIONS & PROCEDURES WHEEL BEARING
SUSPENSION - FRONT 1988 Toyota Celica FRONT SUSPENSION Toyota DESCRIPTION Vehicles are equipped with front wheel drive and independent MacPherson strut front suspension. Suspension consists of vertically
More informationSTUDY OF TRANSMISSION SYSTEM
STUDY OF TRANSMISSION SYSTEM AIM: To study about transmission system DESCRIPTION Transmission system is a system at which power delivered by the engine is transmitted to road wheels of the vehicle. The
More informationPERFORMANCE SUSPENSION PARTS
PERFORMANCE SUSPENSION PARTS Introduction Air Lift Performance The purpose of this publication is to assist with the installation, maintenance and troubleshooting of this Chrysler LX, LD, LC Platform 300C,
More information'99-03 CHEVROLET/GMC IFS 4WD 6" SUSPENSION SYSTEM P/N INSTALLATION INSTRUCTIONS
1/16/04 '99-03 CHEVROLET/GMC IFS 4WD 6" SUSPENSION SYSTEM P/N. 10-41099 INSTALLATION INSTRUCTIONS NOTE: Each Lift Kit and options to Lift Kits are packaged separately. Therefore, installation procedures
More information