Updated 20 th March 2018

Transcription

1 TECHNICAL DATA - VEHICLE SECTION TDA ohe164 Page Dimensions & Weights... 2 Capacities... 3 Wheels & Tyres... 5 Chassis Ride Height Points... 7 Front Suspension... 8 Rear Suspension... 9 Electrical Transmission Clutch Brakes Steering Fuel Consumption Updated 20 th March 2018 Page 1

2 DIMENSIONS & WEIGHTS C I G E D F A J H B ohe164 Dimensions* Evora 400 Evora GT430 Evora GT430 Sport A. Overall length 4385 mm 4394 mm 4394 mm B. Overall width - excl. mirrors 1845 mm C. Overall height (mid-unladen) 1240 mm D. Wheelbase 2575 mm E. Front overhang 1023 mm F. Rear overhang 787 mm G. Ground clearance (mid-laden) 140 mm H. Track - front 1564 mm - rear 1575 mm I. Approach (ramp) angle front J. Approach (ramp) angle rear *Dimensions listed where different from the Evora 400 Weights (Evora 400) Manual Automatic Transmission Transmission Unladen* Total 1395 kg 1425kg > inc. weight Front 545 kg 556kg > full Rear 850 kg 869kg > fuel tank Maximum Total 1836 kg 1842kg > incl. weight Front 679 kg 718kg > occupants Rear 1157 kg 1124kg & luggage *Without any options fitted Weights (Evora Sport 410) Manual Automatic Transmission Transmission Unladen* Total 1325 kg 1335kg > inc. weight Front 543 kg 547kg > full Rear 782 kg 832kg > fuel tank Maximum Total 1650 kg 1650kg > incl. weight Front 677 kg 677kg > occupants Rear 973 kg 978kg & luggage *Without any options fitted Trailer towing Not permissible Updated 10 th October 2017 Page 2

3 CAPACITIES, STANDARDS & APPROVED PRODUCTS Please see service notes section OM for information on fluid change intervals as well as track use conditions. Engine oil 5.75 litre Figure shown is for the engine and oil filter capacity, additional oil is contained within the oil cooler and hoses which cannot be drained during a routine service oil change. Viscosity: ambient above -20 C Quality Standard PETRONAS Syntium W/40 Fully synthetic SAE 0W/40 (Fully synthetic) API SN: ACEA A3/B4 High/low dipstick mark difference Supercharger oil Quality standard 1.5 litre 150 ml Ford Material Specification ESE-M99C115A Nye synthetic oil 605 Transmission oil (manual - without oil cooler) Viscosity Quality Standard Transmission oil (manual - with oil cooler) Viscosity Quality Standard Transmission oil (automatic) s Brake system hydraulic fluid Specification Clutch system hydraulic fluid Specification 2.3 litre Havoline Multigear MTF HD 75W/80 - Fully Synthetic SAE 75W/80 API GL litre (including oil contained within cooler circuit Havoline Multigear MTF HD 75W/80 - Fully Synthetic SAE 75W/80 API GL litre Figure shown is for the gearbox capacity, additional fluid is contained within the torque converer, oil cooler and hoses which cannot be drained during a routine service fluid change.. TOYOTA Genuine ATF WS Transmission oil EXXON MOBIL JWS 3324 Transmission oil 450 cc Non-mineral (non-petroleum) hydraulic fluid DOT 4 PETRONAS Tutela Top 4 brake fluid 130 cc Non-mineral (non-petroleum) hydraulic fluid DOT 4 PETRONAS Tutela Top 4 brake fluid Updated 29 th March 2017 Page 3

4 Engine coolant Antifreeze Colour Charge cooler coolant Antifreeze Colour Power Steering System (PAS) Specification 12.5 litre (Includiing 50% concentration of 6.25 litres of anti- freeze) Ethylene glycol antifreeze with OAT corrosion inhibitors Red PETRONAS Paraflu Up 5.5 litre (Includiing 50% concentration of 2.25 litres of anti -freeze) Ethylene glycol antifreeze with OAT corrosion inhibitors Red PETRONAS Paraflu Up 1.5 litre PAS or Automatic Transmission Fluid (ATF) Dexron IIII PETRONAS Tutela Starfluid HD-ED Air Conditioning Refrigerant (Market Dependant) R134a kg +/-25g Washer bottle : Concentration Fuel tank 1234yf kg 7 litre PETRONAS Tutela SC35 windscreen washer fluid Mixed as per the manufacturers recommendations as an insufficient concentration may result in the vehicles windscreen washers freezing in severe conditions. 60 litres Updated 19 th September 2016 Page 4

5 WHEELS & TYRES Tyres Evora 400 (From Start of Production to '18 Model Year VIN SCCLMDVN2JHB10811) Michelin Pilot Super Sport Size - front 235/35 ZR19-91Y - rear 285/30 ZR20-99Y Evora 400 & Optional for GT410 Sport (From '18 Model Year VIN SCCLMDVN9JHB10787) Michelin Pilot Sport 4S Size - front 235/35 ZR19-91Y - rear 285/30 ZR20-99Y Standard - front 2.0 bar (29 lb/in²) Pressures (cold) - rear 2.2 bar (32 lb/in²) Economy * - front 2.3 bar (33.5 lb/in²) Pressures*(cold) - rear 2.5 bar (36.0 lb/in²) *NOTE: Economy inflation pressures only applicable to European market vehicles equipped with Michelin Pilot Super Sport tyres. Inflating the tyres to the economy tyre pressures of 2.3 bar (front) and 2.5 bar (rear) will adversely affect the handling characteristics and the drivers enjoyment of the car. We do not recommend these tyre pressures are used at speeds in excess of 80mph (128kph). Tyres - Evora Sport 410, GT410 Sport & GT430 Sport Michelin Pilot Sport Cup 2 Size - front 235/35 ZR19-91Y - rear 285/30 ZR20-99Y With sidewall designation marking - (Star - BMW) Standard - front 2.0 bar (29 lb/in²) Pressures (cold/warm) - rear 2.2 bar (32 lb/in²) Tyres - Evora GT430 Michelin Pilot Sport Cup 2 XL Size - front 245/35 ZR19-93Y With sidewall designation marking - 'N0' (Porshe) - rear 295/30 ZR20-101Y With sidewall designation marking - 'N0' (Porshe) Standard - front 2.0 bar (29 lb/in²) Pressures (cold/warm) - rear 2.2 bar (32 lb/in²) The pressures should be reset for track use only once the tyres are warm, refer to service notes section GT.4 for further information. Winter Tyres Michelin Pilot Alpin Size - front 225/35 R19-88W - rear 255/35 R20-97W Pressure (cold) - front 2.4 bar (35 lb/in²) - rear 2.6 bar (38 lb/in²) Tyre studding Tyre chains Not permitted Thule CG snow chains, fitted only on the rear and only on the approved winter tyres. Updated 20 th March 2018 Page 5

6 Lotus Service Notes Wheels Evora 400 Standard wheels on the Lotus Evora 400 are Lotus styled, cast alloy, 10-spoke ard in pairs, silver or gloss black painted, in sizes of 8.0J x 19 front, and 9.5J x 20 rear. Optional gloss black or high powered silver forged Lotus styled alloy wheels with 10 equally spaced radial spokes of a similar design are also available. PCD (Pitch Circle Diameter) Size - Front ± 0.1 mm - Rear ± 0.1 mm Centre spigot hole diameter Size - Front mm - Rear mm - std/opt Cast alloy or forged, 5-bolt fixing Size - front 8.0J x 19H2 ET55 - rear 9.5J x 20H2 ET69 Inset - front + 55 mm - rear + 69 mm Wheel bolt torque 105 Nm (77 lbf.ft) Evora Sport 410, GT410 Sport & GT430 Sport (2+0 Seat Configuration Models Only) A forged lightweight 10 spoke alloy road wheel is fitted to further exploit the reduced weight of the Evora Sport 410. GT410 Sport & Evora GT430 Sport models. For identification, Evora and Sport are displayed on the outer side of the wheel rim and the maximum load rating values applicable for the front and rear wheels are displayed on the inner side of the wheel rims. IMPORTANT: Due to the reduced maximum load rating, the road wheels displaying these rim markings are ONLY for use on the Evora Sport 410, GT410 Sport & GT430 Sport and 2+0 seat configuration models only. These wheels are NOT suitable for any other Evora model. Evora GT430 - Standard Fitment (Optional on other Models) - std Forged, 5-bolt fixing Size - front 8.0J x 19H2 ET55 - rear 10.5J x 20H2 ET69 Inset - front + 55 mm - rear + 69 mm Because of the additional downforce generated by the Evora GT430, new forged 10 spoke alloy road wheels have been developed which have greater load bearing capabilities without an increase in weight as compared to the forged wheels fitted on other Evora 400 models, M AMAX. X ML AOXLOAD ALDO A3 D k6g6 kkg g wheel) (front(front wheel) (front wheel) M A X ML AOXALDO A5 D6 15k6 g1 k g (rear wheel) MAX. 561 kg (rearload wheel) (rear wheel) ohe247/g31 MAX. LOAD 416 kg (front wheel) MAX. LOAD 620 kg (rear wheel) ohe246 For identification, the maximum load rating values applicable for the front and rear wheels are displayed on the inner side of the wheel rim. IMPORTANT: Due to the increase in downforce generated, the Evora GT430 must be fitted with this specification wheel. Page 6 Updated 22nd February 2018

7 CHASSIS RIDE HEIGHT POINTS Ride height to be measured from the ground up to the machined tooling holes located in the chassis siderails (highlighted and shaded in yellow). A B c59 Ride Height Preparation for Geometry Inspection & Adjustment Measurements should be taken from mid-laden ride height (Equivalent of 2 x 75 kg occupants + full fuel tank) Set car to front and rear ride heights and tyre pressures listed below applicable to the model type before measuring and resetting the geometry: Ride height settings Evora 400 Model Position Ride Height Evora 400 & GT410 Sport models fitted with touring pack dampers A - Front: B - Rear: 130 mm below front end of chassis siderail 153 mm below rear end of chassis siderail Model Position Ride Height Model - Evora GT430, Evora Sport 410 or GT410 Sport models fitted with sport or race pack dampers A - Front: B - Rear: 125 mm below front end of chassis siderail 147 mm below rear end of chassis siderail Note: Also ensure standard road wheels are fitted with sizes - 19" Front, 20" Rear - Front tyre pressures 2.0 bar (29 lb/in²) - Rear tyre pressures 2.2 bar (32 lb/in²) Updated 22 nd February 2018 Page 7

8 FRONT SUSPENSION Total Toe Optimum Tolerance Model - Evora 400 & GT410 Sport models fitted with touring pack dampers Model - Evora GT430, Evora Sport 410 or GT410 Sport models fitted with sport or race pack dampers (Toe In) +/ (Toe In) +/ Front of vehicle Front of vehicle Toe per Wheel Optimum Tolerance Model - Evora 400 & GT410 Sport models fitted with touring pack dampers Model - Evora GT430, Evora Sport 410 or GT410 Sport models fitted with sport or race pack dampers / / Camber Optimum Tolerance Model - Evora 400 & GT410 Sport models fitted with touring pack dampers Model - Evora Sport 410 or GT410 Sport models fitted with sport or race pack dampers Model - Evora GT430 & GT430 Sport / / / Maximum difference (side/side) Maximum difference (side/side) Caster Optimum Tolerance All Evora models / Maximum difference (side/side) Front of vehicle Evora GT410 Sport & GT430 - Öhlins TTX 2-Way Adjustable Front Damper Settings Damper Compression Rebound Position Setting Setting Front 21 Clicks 4 Clicks Updated 22 nd February 2018 Page 8

9 REAR SUSPENSION Total Toe Model Evora 400 & GT410 Sport models fitted with touring pack dampers Evora GT430, Evora Sport 410 or GT410 Sport models fitted with sport or race pack dampers Optimum Tolerance + 4 (Toe In) +/ (Toe In) +/ Front of vehicle Total per Wheel Model Evora 400 & GT410 Sport models fitted with touring pack dampers Evora GT430, Evora Sport 410 or GT410 Sport models fitted with sport or race pack dampers Optimum Tolerance / / Maximum difference (side/side) Front of vehicle Camber Model Evora 400 & GT410 Sport models fitted with touring pack dampers Evora Sport 410 or GT410 Sport models fitted with sport or race pack dampers Evora GT430 & GT430 Sport Optimum Tolerance / / / Maximum difference (side/side) Evora Sport 410 & GT430 - Öhlins TTX 2-Way Adjustable Rear Damper Settings Damper Compression Rebound Position Setting Setting Rear 19 Clicks 19 Clicks Updated 22 nd February 2018 Page 9

10 ELECTRICAL Light Bulbs Wattage Headlamps 35 D1S electronic igniter/burner unit Rear turn indicators 21 P21W Licence plate lamps 5 C5W Interior lamp 5 W5W Note that other lamps are likely to be long life LED type, serviced only by lamp replacement. System voltage/polarity Alternator (Vehicles into cold markets from SOP) 12V negative earth 100A Alternator (Vehicles into hot markets from '17MY approx) 150A Battery (Lead acid service replacement) - type Varta L3B (T6) rating 72 Ah Battery (Lithium ion service replacement) - type SB12V25P-SC - rating 100 to 130Ah (equivelant to lead - acid) Updated 14 th December 2016 Page 10

11 TRANSMISSION - Manual Designation Differential 6 speed manual type EA60* 'Closed' bevel gear (Limited Slip Differential) Gear ratio table * Refers to Lotus alternative Sport ratio gear sets which are different than Toyota EA60 application. Gear Internal ratio Final drive * * * * Reverse Automatic Designation Differential 6 speed automatic type U660E Open bevel gear Gear ratio table Gear Internal ratio Final drive Reverse CLUTCH Single dry plate. Diaphragm spring cover. Hydraulic release, self adjusting Friction plate diameter 228 mm Friction plate clamped thickness - new 8.0 mm Damper springs 4 off Hub material Sintered steel Clamp load - new 8350N Page 11

12 BRAKES Brake discs Disc dimensions Callipers Piston size Operation Parking brake - front - rear - front - rear Cast iron, curved vane ventilated, 2-piece cross - drilled with rear discs incorporating parking drums. For GT430 model the brake disc faces are grooved with a J hook design pattern 370 x 32 mm 350 x 32 mm. 185 mm drum A.P. Racing, aluminium alloy body, 4 pistons in opposed pairs. Leading; 38.2 mm. Trailing; 41.3 mm Leading; mm. Trailing; 36.0 mm Tandem master cylinder with dual diaphragm vacuum servo and Bosch ESP 8.1 ESP (Electronic Stability Program) braking system Cable operated drum brakes incorporated into rear discs STEERING Power assisted rack and pinion Turns, lock to lock 2.86 Gear ratio 47mm rack movement/steering wheel revolution FUEL CONSUMPTION (Evora 400) (Mpg [L/100km]) Manual 1999/100/EC - urban 20.8 (13.6) - extra urban 38.7 (7.3) - combined 29.1 (9.7) Automatic - urban 20.0 (14.4) - extra urban 39.8 (7.1) - combined 29.1 (9.7) FUEL CONSUMPTION (Evora Sport 410 & GT410 Sport) (Mpg [L/100km]) Manual 1999/100/EC - urban 20.7 (13.6) - extra urban 38.7 (7.3) - combined 29.1 (9.7) Automatic - urban 19.2 (14.7) - extra urban 39.2 (7.2) - combined 28. (10.0) FUEL CONSUMPTION (Evora GT430 models) (Mpg [L/100km]) Manual 1999/100/EC - urban 20.6 (13.7) - extra urban 35.3 (8.9) - combined 27.9 (10.1) Updated 22 nd February 2018 Page 12