CARPENTER CO. WEIGHT ESTIMATION GUIDE INTRODUCTION
|
|
- Andrew Tyler
- 6 years ago
- Views:
Transcription
1
2 CARPENTER CO. WEIGHT ESTIMATION GUIDE INTRODUCTION The following pages are Carpenter Co. s updated Weight Estimation Guide. There are many new sizes listed in this book, and many of the weights have been estimated. Please remember this is only an estimation guide for the amount of Rely product needed to fill tires. This estimation was calculated using a mathematical formula which is based on the outside dimen sions of the tire and thus includes tread and sidewall thicknesses. We emphasize again: this is an estimation guide because tire cavities are not identical. There are no standards on cavity size in the industry. This is the reason you can proc ess ten tires of the same size and brand and each tire could have a different filled weight. There are also other reasons tires hold various amounts of Rely product. For example stretch ing the tire casing can lead to a different weight. Any new bias tire can stretch from 5% to 10%. Radial tires will stretch as well, although not as much. Determining which tires will stretch and to what extent depends also on whether the tire is new, used or a retread. Each of these types will have a different amount of stretch, therefore each will take a different amount of Rely product to reach the desired pressure. However, the correct way to determine the exact amount of Rely product a tire requires to be flat proofed is to weigh the mounted wheel and tire before and after it is filled to get the amount of product used. If you have any questions, please call your Carpenter Co. representative. Care has been taken to ensure the accuracy of the weights in Carpenter s Rely Weight Estimation Guide. Carpenter is not responsible for any loss or damage that may result from its use. No allowance has been made for filled weight variations (more or less) which occur between different tire manufacturers. The weights for some tires have been revised to reflect a more accurate amount of fill. Although tires will take various amounts of fill we believe this is the most current listing of new sizes and weights available to the industry today. Assumptions to the accuracy of Carpenter s Rely Weight Estimation Guide: The weights shown in the charts assume the following; 1. Tires are being filled with Rely T-25. The use of other brands and types of product will differ in weights. 2. The tires are mounted on the standard width rims listed. (Use of over or under sized rims will require more or less material respectively.) 3. The tires are pressurized to 100 percent of the maximum recommended pressure for each tire. This can be found on the sidewall of the tire, or the Tire and Rim Associations Inc. yearbook. 4. The diameters and section widths of the tires to be filled are in conformity with those specified by The Tire and Rim Association Inc. Yearbook. (Tires which do not conform to those standards may require significantly more or less material to fill.) 5. Tires being filled are new tires which have been pressurized (pre-stretched) with air to their maximum rated inflation pressure for 24 hours prior to being filled to allow the casing to grow. (It is not recommended to fill used tires.) 1
3 ESTIMATION GUIDE BY TIRE SIZE RIM DIAMETER RIM WIDTH KGS LBS 4 INCH WHEELS / / / / / / x x x INCH WHEELS 3.40 / / / x x x INCH WHEELS / / / N/A / N/A / x x x x x x x x
4 14 x x x N/A x x x x x x N/A x x x x N/A x x x 150 / 15 x N/A / 420 x x N/A x N/A INCH WHEELS x INCH WHEELS N/A N/A / N/A x x x x x N/A x x x x x N/A x x x x x
5 18 x x x x x x x x x x x x x x x x x N/A x x x x x x x R INCH WHEELS SL / / x x x x x x 8-9 NHS x x x x x x x N/A N/A INCH WHEELS N/A SL / / SL
6 SL x N/A x x x x x x x N/A H19.5 x x x x x x x x x x x x x x N/A x x x x x x x x x x x x x x x x x x x x L x x / x x INCH WHEELS x x x x x x
7 25 x NHS x NHS x x x INCH WHEELS SL / / 28 x N/A N/A x x 4.4 R x x x x x x x x N/A x x x x x x x x x x x x x x x NHS x NHS x NHS x x NHS x x NHS x x NHS x H31 x x
8 34 x x x INCH WHEELS x x x 7.75 R N/A x x x x / 80 R N/A x INCH WHEELS SL SL L - 14 SL L - 14 SL L - 14 SL x x x x x x x 8.0 R x 6.75 R x x 6.60 R x x x 8.50 R x x x 9.00 R x R 14 NHS x x 8.50 R x x 9.50 R x x x x 9.50 R x x x x x x
9 34.6 x x x x / 70 R N/A INCH WHEELS x x 8.75 R x 11.5 R INCH WHEELS SL SL SL N/A NHS SL SL SL OD OD L - 15 SL SL / K NHS R L - 15 SL FI N/A R L - 15 SL NHS R L - 15 SL L FI x NHS L R N/A x x x x N/A x 7.75 R x x 8.50 R N/A x x x x x x x x x NHS
10 28 x x x x x x x x x x x x 8.8 R x x NHS x NHS x x 8.8 R N/A x x x x N/A x x LT x x x x x x N/A x LT / N/A / / / 75 R N/A / 70 R 15 NHS / 60 D INCH WHEELS SL SL SL / N/A SL SL SL
11 SL L SL L - 16 SL / N/A L L x x x H30 x x x 8.8 R x x x H34 x 10.0 R N/A x x x x x x x x x x x N/A / x / 85 R N/A / 85 R N/A x 395 R INCH WHEELS SL L SL / / SL L SL L SL L SL x x x
12 16.5 INCH WHEELS N/A / N/A / N/A / N/A x x 9.50 R x x R x x R x N/A x x x R x x x x R x x R x x R x x R / 70 D / 70 D / 70 D / 55 D / 55 D INCH WHEELS R R R R x x x x / INCH WHEELS R R R R R R
13 NHS ML R x x NHS / / 55 D / / 70 D INCH WHEELS N/A SL / N/A / N/A / NHS / N/A / 55 R N/A / / N/A x H34 x x N/A H35 x N/A x x H36 x x x x x x x x / 80 R / IND / 80 R 18 IND / 80 R / 80 R N/A / IND / 80 R 18 IND / 70 R N/A / / 70 R 18 IND / 70 R N/A INCH WHEELS INCH WHEELS SL / 80 R N/A SL x
14 H40 x H40 x x H42 x INCH WHEELS R NHS R R R R ML x / 70 R / 70 R / 70 R / N/A / / 55 D / 65 R INCH WHEELS R SL R R SL NHS R / R ML R R L - 20 SL R N/A / 80 R R / 80 R ML / 80 R
15 14.50 R N/A R / N/A x x NHS x x N/A x N/A x NHS x N/A x x x NHS x x 18 L x NHS x H44.5 x x H45 x x x 17.0 R H46 x x x NHS x x x x x x x x x x / 80 R / IND / 80 R / IND / 80 R 20 IND / / N/A / 80 R N/A / 75 R / 80 R / 85 R N/A / N/A / 70 R / IND / 70 R 20 IND / N/A / 70 R / 75 R 20 IND / 75 R / 95 R
16 20.5 INCH WHEELS / 65 R INCH WHEELS NHS R 21 NHS R R ML ML 21 N/A DT 21 N/A R 21 DT DT R 21 DT C40 x H43.5 x H44.5 x H44.5 x / 90 R N/A INCH WHEELS R R x x H49 x x INCH WHEELS R R R R R R R R R R / / 80 R /
17 245 / 75 R / / 70 R N/A / 80 R / 75 R / 80 R / 60 R / 75 R / 75 R / 85 R / 80 R / 65 R / 65 R / 65 R / 65 D N/A INCH WHEELS x x x 530 R ML B46 x 16 x INCH WHEELS TG TG SL TG SL TG R 24 TG R SL SL SL R R 24 TG R 24 NHS R R / N/A R R L L R R
18 L R R L x NHS / 70 R / 75 R / 70 R / 70 R / 85 R / 95 R / IND / 70 R / N/A / IND / 70 R / 70 R / 70 R / 80 R / 70 R / 70 R / 70 R / 70 R / 70 R / 65 D H54 x INCH WHEELS R R R / / 75 R / 80 R / / 75 R INCH WHEELS ML NHS R 25 NHS NHS R 25 NHS ML R 25 NHS R R R R / R
19 21.00 R N/A / 65 R R R / / 65 R R R / / 65 R / x x x NHS x NHS x NHS / 95 R / 80 R / 80 R / 95 R / 95 R / 80 R / 65 R / 70 R / 95 R / 65 R N/A / 80 R / 70 R / 65 R / 70 R / 65 R / 70 R / 65 R / 50 R INCH WHEELS R R TG R L L R x NHS x NHS x NHS / 70 R / IND / 80 R 26 IND / 75 R
20 28 INCH WHEELS SL R R R R R L / 70 R / 85 R / 70 R / 85 R N/A / 80 R N/A / 80 R / 70 R / 70 R 28 IND / 65 R N/A INCH WHEELS R R R R / / / / 65 R / / 65 R / 65 R / 65 R INCH WHEELS R R / x NHS / / 85 R / N/A / 70 R / 90 R / 70 R / 70 R / 65 R / 70 R
21 32 INCH WHEELS L L R L L DH35.5 L L L x NHS / 75 R / 65 R / 60 R / 50 R VA73 x INCH WHEELS R R R R / 90 R / / / 65 R / 65 R N/A INCH WHEELS R R R R R / 95 R / 95 R / 85 R / 85 R / 80 R / 85 R / 70 R / 75 R / 80 R N/A / 85 R / 70 R / 70 R / 65 R / 75 R / 75 R / 75 R
22 35 INCH WHEELS R R R R R INCH WHEELS INCH WHEELS R R R R L L L L / 90 R / 85 R / 80 R / 85 R N/A / 70 R / 80 R / 70 R / 85 R / 70 R / 70 R / 70 R INCH WHEELS R R / / 65 R / 75 R
23 41.25 / / / 65 R INCH WHEELS 96 x N/A INCH WHEELS R R / 90 R / 80 R N/A / 90 R / 80 R / 85 R / 70 R / 70 R / 65 R / 70 R / 50 R INCH WHEELS INCH WHEELS 40 / / / 65 R / / / 65 R N/A INCH WHEELS R R R / 90 R / 85 R / 90 R / 80 R / 80 R / 70 R / 70 R INCH WHEELS 230 / 95 R N/A / 95 R / 95 R INCH WHEELS R R R
24 27.00 R / 80 R / 90 R INCH WHEELS 250 / 95 R / 90 R / 90 R / 80 R INCH WHEELS R R R DT R 51 DT R / / 65 R / / / INCH WHEELS 39 / 90 R INCH WHEELS 12.4 R / 115 R / 90 R / 90 R INCH WHEELS INCH WHEELS R R / 90 R / 90 R / 80 R / 80 R INCH WHEELS 320 / 90 R INCH WHEELS
25 LSW SIZES 23 x x x 12 D / 55 D / 50 D BICYCLE TIRES 16 x x x x x x x x Use this space to record unlisted weights. FORMULA The tire weight charts presented may be used to determine the approximate amount (weight in pounds) of Rely Products that will be needed to fill any of a wide range of standard size tires. For any tire not listed in the chart using the following formula may approximate the fill weight. Approximate Fill Weight = 2.47 x Section Height x Section Width x (Section Height + Rim Diameter) x SH = SECTION HEIGHT (OUTSIDE DIAMETER) RIM DIAMETER 2) The tire weight charts, as well as the above formula, will produce only approximate weights due to normal variances among individual tires with respect to internal volumes and final pressure. The exact weight of the tire fill can only be determined by subtracting the weight of each unfilled tire from the weight of the tire after filling. When using the Lincoln Powerfill 2000 series pump, equipped with pneumatic stroke counter, record the number of strokes shown. The fill weight of each tire can be approximated using the following formula. Fill Weight = Number of strokes x strokes = 9 lbs. For the Lincoln Pumps equipped with the digital counter, simply record the numbers shown. The digital counter reads in pounds not strokes. For the Intelli-Pumps equipped with the digital counter, simply record the numbers shown. The digital counter reads in pounds not strokes. When using Graco Pump, the fill weight of each tire can be approximate using the following formula: Fill Weight = Number of strokes x strokes = 8.4 lbs. Again, keep in mind that these formulas will only give an approximate weight. The most accurate method of determining the fill weight is to weigh the tire both before and after processing.. 24
26 SALES & TECHNICAL MONUMENT AVENUE P.O. BOX RICHMOND, VIRGINIA DINTING LODGE INDUSTRIAL ESTATE GLOSSOP, DERBYSHIRE SK13 6LE UNITED KINGDOM FAX CR-WEIGHT CHART GUIDE 11-08
SELECTION OF TIRES FOR LIGHT TRUCKS, TRUCKS, BUSSES, TRAILERS AND MULTI-PURPOSE PASSENGER VEHICLES AND DEFINITIONS OF TERMS TIRE SELECTION
SELECTION OF TIRES FOR LIGHT TRUCKS, TRUCKS, BUSSES, TRAILERS AND MULTI-PURPOSE PASSENGER VEHICLES AND DEFINITIONS OF TERMS TIRE SELECTION Light Truck and Truck/Bus Tires Selection of size and load range
More informationTyre Chart. Section 1 Passenger and Light Trucks Pg Section 2 Highway Trucks and Busses Pg. 5-6
Tyre Chart Section 1 Passenger and Light Trucks Pg. 2-4 Section 2 Highway Trucks and Busses Pg. 5-6 Section 3 Main Chart (Industrial, Mining/Logging, Agricultural, etc.) Pg. 7-14 Section 4 All Terrain
More informationSidewall Markings UTQG Ratings
Sidewall Markings There is a lot of information on the sidewall of a tire. Typically, you'll find UTQG ratings for treadwear, traction and temperature, the size of the tire, the load rating index number
More informationEM, MPT & Industrial Tyres TECHNICAL DATABOOK 12 TH EDITION
EM, MPT & Industrial s TECHNICAL DATABOOK 12 TH EDITION INTRODUCTION AND CONTENTS Introduction The extensive technical data and other information relating to tyres and accessories on the following pages
More informationCONTACT ME If you have comments or suggestions with regard to this or any of our bulletins, contact me at:
DISCLAIMER The content of this bulletin reflect my opinion and the feedback from our customers on the subject discussed unless otherwise credited. You are free to agree or disagree with it. CONTACT ME
More informationHighway (DOT) Mobile Road Crane: L5, Radial: MS501, MS502, MS503 Loader, Solid: Scraper, Radial: Backhoe, Front 2WD: MS901, MS902, MS903, MS904, MS907
PATTERN REFERENCE GUIDE: Highway (DOT) Mobile Road Crane: MSV01 Off-the-Road E2/G2/L2, Radial: MS202, MS203 E3/L3, Radial: MS300, MS301, MS302 E3/L3, Bias: MS913 E4 Haulage, Radial: MS306, MS401, MS402,
More informationSOLID INDUSTRIAL TIRES INNER TUBES FLAPS
SOLID INDUSTRIAL TIRES INNER TUBES FLAPS CONTENTS Treads by Size guide... Solid Tires Cover Page... 3 Traction Solid Pneumatic... Non-Marking Solid Pneumatic... 5 Rib Solid Pneumatic... Crosslug Solid
More informationFALKEN TIRE LIMITED WARRANTY
For questions: technical@falkentire.com Effective February 1, 2016 FALKEN TIRE LIMITED WARRANTY I. Tires Covered by this Warranty: This limited warranty applies to FALKEN brand steel belted radial passenger
More informationTerminology for OTR TG 12PR 23.5 R NHS 16PR 45 / PR. Nominal Section Width Diameter (in)
Terminology for OTR Nominal Section Width Diameter (in) - Bias R Radial NHS - Non Highway Service TG - Tractor & Grader (Not for highway) 16.00-24 TG 12PR 23.5 R 25 14.00-24 NHS 16PR 45 / 65-45 38PR Nominal
More informationTIRE BASICS GENERAL INFORMATION WHAT S INSIDE A TIRE TREAD BELTS BELT EDGE INSULATION BODY PLIES INNERLINER CASING BEAD SIDEWALL BEAD FILLER
WHAT S INSIDE A TIRE BELTS TREAD BELT EDGE INSULATION BODY PLIES INNERLINER CASING BEAD SIDEWALL The tire s INNERLINER -- keeps air inside the tire. BEAD FILLER The CASING (or CARCASS) the internal substructure
More informationSUMMARY: On July 8, 2016, the Department of Commerce (the Department) published its
DEPARTMENT OF COMMERCE International Trade Administration A-570-016 This document is scheduled to be published in the Federal Register on 08/22/2016 and available online at http://federalregister.gov/a/2016-20023,
More informationTIRE BASICS HOW TO READ A SIDEWALL. Ratio of height to width (aspect ratio) Width of tire in millimeters Passenger car tire
Ratio of height to width (aspect ratio) Width of tire in millimeters Passenger car tire Radial Diameter of wheel in inches Load index & speed symbol U.S. DOT safety standard code Max. cold inflation &
More informationModern Auto Tech Study Guide Chapter 65 & 66 Pages Tires, Wheels, Bearings 51 Points. Automotive Service. Danger of Old Tires!!
Modern Auto Tech Study Guide Chapter 65 & 66 Pages 1241 1278 Tires, Wheels, Bearings 51 Points Automotive Service Danger of Old Tires!! Tires Manufactured Since 2000 Since 2000, the week and year the tire
More informationSequoia power steering rack service Match-mounting wheels and tires Oxygen sensor circuit diagnosis
In this issue: Sequoia power steering rack service Match-mounting wheels and tires Oxygen sensor circuit diagnosis PHASE MATCHING Often referred to as match mounting, phase matching involves mounting the
More informationFIRESTONE FARM TIRES WITH AD2 TM TECHNOLOGY:
TM TM FIRESTONE FARM TIRES WITH AD2 TM TECHNOLOGY: DESIGNED, ENGINEERED AND BUILT FOR TODAY S AGRICULTURE. Firestone farm tires with Advanced Deflection Design (AD2) technology represent the next generation
More informationE/ECE/324/Rev.2/Add.108/Rev.1/Amend.2 E/ECE/TRANS/505/Rev.2/Add.108/Rev.1/Amend.2
7 December 2017 Agreement Concerning the Adoption of Harmonized Technical United Nations Regulations for Wheeled Vehicles, Equipment and Parts which can be Fitted and/or be Used on Wheeled Vehicles and
More information49 CFR Ch. V ( Edition)
571.109 571.109 Standard No. 109; New pneumatic tires. S1. Scope. This standard specifies tire dimensions and laboratory test requirements for bead unseating resistance, strength, endurance, and high speed
More informationIndustrial pneumatic tires Technical data
Industrial pneumatic tires www.camoplastsolideal.com 8 4.00-8 (4.80-8) 10 Solideal Ecomatic ED JS2 90-8 3.25I 3.00D 422 115 12 196 10,00 97 A5 950 730 915 680 950 730 650 615 1100 5.00-8 (5.70-8) 8 Solideal
More informationPATTERN REFERENCE GUIDE:
PATTERN REFERENCE GUIDE: OTR Mobile Road Crane: MSV01 Mining/Loaders: E2/G2/L2: MS202 E3/G3/L3: MS300, MS301, MS302 E4/L4: MS405 L5: MS501, MS502, MS503 Solid: MS708 Scraper: MS303 Earthmover/Haulage:
More informationABOUT MAXAM p. 2 OTR RADIAL TIRE RANGE. TECHNICAL INFORMATION p. 18. OTR TIRE LIMITED WARRANTY p. 20
OFF THE ROAD TIRE CATALOGUE 2014 1 2 ABOUT MAXAM p. 2 OTR RADIAL TIRE RANGE MSV01 - Highway Service p. 4 MS201 - E2/G2/L2 p. 5 MS202 Snowxtra - E2/G2/L2 p. 6 MS300 - E3/L3 p. 7 MS301 - E3/L3 p. 8 MS302
More informationLOADER RADIAL PtxL31(L3)
ER RADIAL PtxL31(L3) CONTENTS Range of Petlas Ind-Otr Tires 3 Petlas Ind-Otr Tires by Size 4 General Information 8 RADIAL INDUSTRIAL TRACTION PAGE INDUSTRIAL / INDUSTRIAL TRACTION PAGE PtxND31 12 GRADER
More informationDELINTE LIMITED TIRE WARRANTY DH2 D7 D8, D8+ DH7 DX9, DX10, DX11, DV2
DELINTE LIMITED TIRE WARRANTY DH2 D7 D8, D8+ DH7 DX9, DX10, DX11, DV2 The limited warranty applies to tires purchased after March 1, 2016. The limited warranty applies to tires purchased after October
More informationE/ECE/324/Rev.1/Add.53/Rev.3/Amend.3 E/ECE/TRANS/505/Rev.1/Add.53/Rev.3/Amend.3
22 February 2017 Agreement Concerning the Adoption of Uniform Technical Prescriptions for Wheeled Vehicles, Equipment and Parts which can be Fitted and/or be Used on Wheeled Vehicles and the Conditions
More informationSOLIDEAL HAULER LT READY FOR YOUR CHALLENGES. PERFORMANCE INDUSTRIAL PNEUMATIC
IMPERIAL UNIT SOLIDEAL HAULER LT INDUSTRIAL PNEUMATIC READY FOR YOUR CHALLENGES. With a heavy-duty carcass and high abrasion-resistant tread, it delivers both incredible puncture resistance and long life.
More informationEM, MPT & Industrial Tyres
EM, MT & Industrial s Technical databook 12 th edition introduction and contents Introduction The extensive technical data and other information relating to tyres and accessories on the following pages
More informationAgricultural Tyres Technical Databook
Agricultural Tyres Technical Databook Edition 2018/2019 mitas-tyres.com Mitas Technical Databook for Agricultural Tyres World edition 2018 / 2019 The extensive technical data and other information relating
More informationE/ECE/324/Rev.2/Add.108/Rev.1/Amend.3 E/ECE/TRANS/505/Rev.2/Add.108/Rev.1/Amend.3
16 January 2019 Agreement Concerning the Adoption of Harmonized Technical United Nations Regulations for Wheeled Vehicles, Equipment and Parts which can be Fitted and/or be Used on Wheeled Vehicles and
More informationWheels. Wheels and Tires ! CAUTION. Wheel Selection
Wheel Selection Wheels Wheels are very important and critical components of your running gear system. When specifying or replacing your trailer wheels it is important that the wheels, tires, and axle are
More informationAPPLICATION INSTRUCTIONS Using 5 Gallon Pail and Metal Sealant Pump
APPLICATION INSTRUCTIONS Using 5 Gallon Pail and Metal Sealant Pump 1. 2. 3. 4. 5. 6. 7. Determine the recommended fluid ounces of SAFEGUARD for a specific tire size by consulting the application chart.
More informationSHAFT ALIGNMENT FORWARD
Service Application Manual SAM Chapter 630-76 Section 24 SHAFT ALIGNMENT FORWARD One of the basic problems of any installation is aligning couplings or shafts. Therefore, this section will endeavor to
More informationCT / Bias Tire Upgrade For Gl1800 and Valkyrie's
CT / Bias Tire Upgrade For Gl1800 and Valkyrie's Important Disclaimer: All information posted here is for reading enjoyment only is only a posting of my own experience and not intended to use by the general
More informationAircraft Tyres. Richard Skiba. Skiba, R. (1999). Aircraft Tyres: Differences Between Aircraft and Automotive Tyres, Pacific Flyer, September.
Aircraft Tyres Richard Skiba Skiba, R. (1999). Aircraft Tyres: Differences Between Aircraft and Automotive Tyres, Pacific Flyer, September. Skiba, R. (2000). Aircraft Tyres', Gyro News, Vol.14, No. 3,
More informationالتقييس لدول مجلس التعاون لدول الخليج العربية
هيي ة التقييس لدول مجلس التعاون لدول الخليج العربية STANDARDIZATION ORGANIZATION FOR G.C.C (GSO) ا طارات سيارات الركوب الجزء الثاني : المتطلبات العامة PASSENGER CAR TYRES PART 2: GENERAL REQUIREMENTS ICS:
More informationChapter. Tire, Wheel, and Wheel Bearing Fundamentals
Chapter 74 Tire, Wheel, and Wheel Bearing Fundamentals Objectives After studying this chapter, you will be able to: Identify the parts of a tire and wheel assembly. Describe different methods of tire construction.
More informationCONSTRUCTION & MINING BIAS TIRES
CONSTRUCTION & MINING BIAS TIRES YOKOHAMA PHILOSOPHY Since our establishment in 1917, our philosophy has been to embrace new ideas while upholding traditional values. Yokohama engineers and chemists push
More information2013 China Auto Parts
2013 China Auto Parts 2014.09. Contents 1. China Auto Parts & Accessories Export Enterprises Distribution...4 1.1. China New Pneumatic Tyres, of Rubber Enterprises Distribution, from Jan. to Dec. 2013...
More informationLOADER/DOZER/GRADER TYRE MATCHING POLICY
G L O B A L T Y R E M A N A G E M E N T Policy Document LOADER/DOZER/GRADER TYRE MATCHING POLICY February 2011 (This replaces Otraco s December 2010 policy document) Disclaimer: This Otraco International
More informationInstruction Manual. SmarTire Dealer Programming Tool. PN: Revision Copyright 2006 SmarTire Systems Inc.
SmarTire Dealer Programming Tool PN: 710.0021 Revision 1.04 Instruction Manual Copyright 2006 SmarTire Systems Inc. Duplication of this document in whole or in part for any purposes other than those for
More informationHandout Activity: HA511
Using a tire pressure gauge Engines: Motive Power Types: Handout Activity: HA511 HA511-2 Student/Intern information: Name Date Class Using a tire pressure gauge Summary There are two main types of tire
More informationIndian Tyre Production Estimate
Transmitted by the expert from India Informal Document No. GRRF-62-38 (62nd GRRF, 25-28 September 2007 agenda item 9(a)) Proposal: Comments from India on the GTR for Passenger Vehicle Tyres under formulation
More informationAgricultural Tyres TECHNICAL DATABOOK 13 TH EDITION
Agricultural Tyres TECHNICAL DATABOOK 13 TH EDITION INTRODUCTION AND CONTENTS Introduction Contents The extensive technical data and other information relating to tyres and accessories on the following
More informationSumitomo Rubber Industries, Ltd., Receipt of Petition for. AGENCY: National Highway Traffic Safety Administration (NHTSA),
This document is scheduled to be published in the Federal Register on 09/22/2017 and available online at https://federalregister.gov/d/2017-20248, and on FDsys.gov DEPARTMENT OF TRANSPORTATION National
More informationEPT Mounted Bearing Technical Support. Phone: FAX: Mounted Bearing Application Engineering
ENGINEERING EPT Mounted Bearing Technical Support Browning Technical Services Phone: 606-564-2093 FAX: 606-564-2079 Mounted Bearing Application Phone: 219-465-2211 FAX: 219-465-2290 E-mail: browningbearing.eng@emerson-ept.com
More informationTwo assumptions are made with off-car balancers that can become problematic:
EDITED DEC 3 RD 2017 Below is a modified communication to an article I wrote in Brake and Front End Magazine in 2015 that can be viewed at http://www.brakeandfrontend.com/on-car-wheel-balancing-wheel-to-hubindexing/
More informationFRONT/IMPLEMENT TIRES
FRONT/IMPLEMENT TIRES FULL-LINE BROCHURE IMPLEMENT THE BEST. Leave it to Firestone to offer a truly comprehensive line of rugged front and implement tires. Wagons, irrigators, planters, free-rolling or
More information2017 PRODUCT LINE UP
2017 PRODUCT LINE UP A Global Company MAXAM Tire, headquartered in Birmingham, UK and with American offices in Danvers, MA, has a dedicated team of skilled product, application, and manufacturing engineers,
More informationFRONT/IMPLEMENT TIRES
FRONT/IMPLEMENT TIRES FULL-LINE BROCHURE IMPLEMENT THE BEST. Leave it to Firestone to offer a truly comprehensive line of rugged front and implement tires. Wagons, irrigators, planters, free-rolling or
More informationCHAPTER 159. NEW PNEUMATIC TIRES
Ch. 159 NEW PNEUMATIC TIRES 67 159.1 Sec. 159.1. Scope. 159.2. Application. 159.3. Definitions. 159.4. Requirements. 159.5. Test procedures. 159.6. Nonconforming tires. CHAPTER 159. NEW PNEUMATIC TIRES
More informationMORE THAN PRESSURE SPRING RATE STAGGER CROSS WEIGHT CHANGES
MORE THAN PRESSURE Can you go faster with the right amount of air? Yes you can! Tire pressure, while simple on the surface, creates many variables and tire managers would be well served to be aware of
More informationBIAS TIRES FULL-LINE BROCHURE
BIAS TIRES FULL-LINE BROCHURE HARVEY FIRESTONE INVENTED FARM TIRES. HIS COMPANY KEEPS MAKING THEM BETTER. In 1936, Harvey Firestone put the American farmer on rubber. Every day the engineers who design
More informationEuropean Tyre and Rim Technical Organisation RETREADED TYRES IMPACT OF CASING AND RETREADING PROCESS ON RETREADED TYRES LABELLED PERFORMANCES
European Tyre and Rim Technical Organisation RETREADED TYRES IMPACT OF CASING AND RETREADING PROCESS ON RETREADED TYRES LABELLED PERFORMANCES Content 1. Executive summary... 4 2. Retreaded tyres: reminder
More informationHARD-WORKING TIRES FOR THE TOUGHEST TERRAINS PREMIUM TECHNOLOGY, EVERYDAY AFFORDABILITY. APPLICATION SPECIFIC, PURPOSE BUILT.
BETTER VALUE. SMARTER CHOICE. BACKHOE/LOADER FAMILY HARD-WORKING TIRES FOR THE TOUGHEST TERRAI APPLICATION SPECIFIC, PURPOSE BUILT. PREMIUM TECHNOLOGY, EVERYDAY AFFORDABILITY. GALAY JUMBO HULK L4 The Hulk
More informationOPERATING MANUAL. Black Bruin hydraulic motors S-series model D
S-series model D CONTENTS 1 GENERAL INSTRUCTIONS... 3 1.1 About the manual... 3 1.2 Revision comments... 3 1.3 Applicability... 3 1.4 Warranty... 3 1.5 Product identification... 3 2 INSTALLATION INSTRUCTIONS...
More informationTIRE SELECTION GUIDE. u TIRE BASICS u CHOOSING THE RIGHT TIRE u PROPER TIRE CARE u WHEN TO REPLACE u REDUCING TIRE COSTS
TIRE SELECTION GUIDE u TIRE BASICS u CHOOSING THE RIGHT TIRE u PROPER TIRE CARE u WHEN TO REPLACE u REDUCING TIRE COSTS www.forkliftsmi.com 616-455-2376 TIRE BASICS SECTION 1 Forklift tires are not all
More informationA Rotating Information Center
A Rotating Information Center By Marvin Bozarth TIA Senior Technical Consultant Some people never look at a tire sidewall while others read every letter, number, mark and symbol on both sides. My wife
More informationTyre Endurance/Low Pressure Test
Tyre Endurance/Low Pressure Test Test versions implemented by US DOT in 1960s (FMVSS 109) for use on passenger car tyres. Updated in June 2003 (FMVSS 139) to more closely represent real world worst-case
More informationNot For Sale- PSQCA (c) Only for Research Purpose
L 0 v) Foreword ISO (the International Organization for Standardization) is a worldwide federation of national Standards bodies (ISO member bodies). The work of preparing International Standards is normally
More informationMotorcoach Tire & Weight Issues
Motorcoach Tire & Weight Issues who is riding your bus? and what are they carrying?... 2012 Litchfield IL Left Steer Tire FMCSA Deliberative Document - Internal Use Only Litchfield Right Steer Tire FMCSA
More informationSFI SPECIFICATION 35.1 EFFECTIVE: AUGUST 26, 2008 *
SFI SPECIFICATION 35.1 EFFECTIVE: AUGUST 26, 2008 * PRODUCT: Stock Car Steel Wheels 1.0 GENERAL INFORMATION 1.1 This SFI Specification establishes uniform test procedures and minimum standards for evaluating
More informationDELINTE. LIMITED TIRE WARRANTY Effective July 1, 2017 DH2 D7 D8, D8+ DS8 DH7 DX9, DX10 DX11, DV2
DELINTE LIMITED TIRE WARRANTY Effective July 1, 2017 DH2 D7 D8, D8+ DS8 DH7 DX9, DX10 DX11, DV2 Sentury Tire USA Delinte Limited Tire Warranty This limited warranty only applies to the original purchaser
More informationproduct manual U.S. EDITION PASSENGER, PERFORMANCE, LIGHT TRUCK, SPORT UTILITY AND WINTER PRODUCTS
product manual U.S. EDITION PASSENGER, PERFORMANCE, LIGHT TRUCK, SPORT UTILITY AND WINTER PRODUCTS SUV / LIGHT DUTY All-Season Starfire SF 510TM starfire standard limited warranty value HIGHWAY suv sizes
More informationArchival copy: for current recommendations see or your local extension office.
FCS5017 Shopping For Tires 1 Mary N. Harrison 2 There is an old saying, Where the rubber hits the road, that means facing reality. Its also a good statement to apply to the importance of selecting tires
More informationTest Plan Guideline. Test Plan. These mentioned parameters
Savari XL V7901117AA Tyre 185//65x14 86H OR 7901117 Parameter No. 001 Test Name Appearance Description The tire must not have any crack, warp, abrasion, shrinking, air lock, and such faults. Parameter
More informationLIMITED WARRANTY & OWNER S MANUAL
DH2 ALL SEASON PERFORMANCE TOURING CAR TIRE LIMITED WARRANTY & OWNER S MANUAL Effective October 1, 2013 Americas SUMMARY OF LIMITED WARRANTY COVERAGE BY TREAD DESIGN Pattern Size or Speed Rating Mileage
More informationDELINTE. LIMITED TIRE WARRANTY Effective July 1, 2017 DH2 D7 D8, D8+ DS8 DH7 DX9 DX10 DX11,, DX12 DV2 AW 5
DELINTE LIMITED TIRE WARRANTY Effective July 1, 2017 DH2 D7 D8, D8+ DS8 DH7 DX9 DX10 DX11,, DX12 DV2 AW 5 Sentury Tire USA Delinte Limited Tire Warranty This limited warranty only applies to the original
More informationEverything Rides on It
Everything Rides on It tudies of tire safety show that maintaining proper tire pressure, observing tire and vehicle load limits (not carrying more weight in your vehicle than your tires or vehicle can
More informationTIRE PRODUCT KNOWLEDGE Just the Facts!
K + M Tire TIRE PRODUCT KNOWLEDGE Just the Facts! TIRE FUNCTIONS Carry the Vehicle s Weight and Load Transmit Acceleration Forces Transmit Braking Forces Transmit Cornering Forces Cushion Road Irregularities
More information# G: Shake/Vibration in Steering Wheel, Floor, Seat at Highway Speeds on Smooth Roads (Diagnose/Balance Tires/Wheels) - (Oct 1, 2004)
Page 1 of 7 2004 Buick LeSabre LeSabre (VIN H) Service Manual Document ID: 1552616 #00-03-10-007G: Shake/Vibration in Steering Wheel, Floor, Seat at Highway Speeds on Smooth Roads (Diagnose/Balance Tires/Wheels)
More informationEconomic and Social Council
United Nations Economic and Social Council ECE/TRANS/WP.29/GRRF/2014/24 Distr.: General 4 July 2014 Original: English Economic Commission for Europe Inland Transport Committee World Forum for Harmonization
More informationNat l Highway Traffic Safety Admin., DOT
Nat l Highway Traffic Safety Admin., DOT 571.119 571.119 Standard No. 119; New pneumatic tires for vehicles other than passenger cars. S1. Scope. This standard establishes performance and marking requirements
More informationTM1000 High Power. The solution for sustainable farming.
TM High Power. The solution for sustainable farming. Official Partner TM High Power. The solution for sustainable farming. With the world population expected to grow by 27 percent to 8.9 billion people
More informationStretch & Glue Frame Price List January 2019
Frame January 2019 Gt 75 / dia-mini.75 Max Size: 18 Width: 3/4 Height: 3/4 Wall Thickness:.063 Weight per Ft:.2 Lbs 20 22 24 26 28 30 32 34 36 38 $ 18.75 18.95 19.15 19.35 19.55 19.75 19.95 20.20 20.45
More informationSumitomo Rubber Industries, Ltd., Grant of Petition for Decision. AGENCY: National Highway Traffic Safety Administration (NHTSA),
This document is scheduled to be published in the Federal Register on 03/26/2018 and available online at https://federalregister.gov/d/2018-05983, and on FDsys.gov DEPARTMENT OF TRANSPORTATION National
More informationTires with inner tubes were used until the 50s. Inner tube tires
Tires Back in the day Way back in the day Pneumatic Tires Dunlop patented them for bicycles in 1888 Michelin put them on cars in 1895 Goodyear was started in 1898. Named after the inventor of vulcanized
More informationETSO-C62d Date :
European Aviation Safety Agency ETSO-C62d Date : 24.10.03 European Technical Standard Order Subject: AIRCRAFT TYRES 1 - Applicability This ETSO gives the requirements which tyres excluding tailwheel tyres
More informationT E C H N I C A L R E P O R T. N o. : L C A E C E R e g u l a t i o n N o. 109
T E C H N I C A L R E P O R T N o. : L C A 5 4 0 4 5 1 0 0 1 1 4 Inspection concerning the P r o d u c t i o n o f r e t r e a t e d p n e u m a t i c t y r e s f o r c o m m e r c i a l v e h i c l e
More informationTYRE RANGE INDUSTRIAL & OTR AGRICULTURE
TYRE RANGE INDUSTRIAL & OTR AGRICULTURE ABOUT GALAXY BRAND Galaxy specializes in segments of the Off-Highway tyre market, Including; Skidsteer, Forestry, Industrial Forklift and Lawn and Garden, providing
More informationGoodyear Radials Offer Strong, Dependable Performance
Goodyear Radials Offer Strong, Dependable Performance Vehicles that operate in and around ports, harbors, and other industrial sites need super-tough tires to overcome harsh working conditions. That s
More informationGENERAL INFORMATION. B. Suffix Letters Used in Tire Size Designations and Their Definitions. D. Load Range Designation Ply Rating Equivalency Table
A. Definitions B. Suffix Letters Used in Tire Size Designations and Their Definitions C. Conversion Factors D. Load Range Designation Ply Rating Equivalency Table E. VAI F. Sidewall Rib Guard Curb Scuff
More informationPREMIUM IF & VF TIRES
BETTER VALUE. SMARTER CHOICE. THE AGRIFLEX AGRIFLEX + FAMILY PREMIUM IF & VF TIRES FOR EVERY MACHINE ON THE FARM PREMIUM TECHNOLOGY, EVERYDAY AFFORDABITY. THE ALANCE AGRIFLEX WHOLE-FARM CONCEPT Why reduce
More informationLESSON Transmission of Power Introduction
LESSON 3 3.0 Transmission of Power 3.0.1 Introduction Earlier in our previous course units in Agricultural and Biosystems Engineering, we introduced ourselves to the concept of support and process systems
More informationBIODIESEL. Lesson 4d Test biodiesel in a diesel generator. Developed by Engineering and Technology Curriculum Team
BIODIESEL Lesson 4d Test biodiesel in a diesel generator In a laboratory setting, test biodiesel in a diesel generator by estimating Btu. define energy density, kwh, and Btu calculate energy density, kwh
More informationSPECIALISED RUBBER PRODUCTS. Donut Springs Spring Covers Rubber Bumpers Tensions Bands
SPECIALISED RUBBER PRODUCTS Donut Springs Spring Covers Rubber Bumpers Tensions Bands NOTE: The material in this booklet is intended for guidance only and the information has been produced using AB Pneumatics
More informationE/ECE/324/Rev.2/Add.105/Rev.2/Amend.5 E/ECE/TRANS/505/Rev.2/Add.105/Rev.2/Amend.5
E/ECE/324/Rev.2/Add.105/Rev.2/Amend.5 E/ECE/TRANS/505/Rev.2/Add.105/Rev.2/Amend.5 27 April 2018 Agreement Concerning the Adoption of Harmonized Technical United Nations Regulations for Wheeled Vehicles,
More informationCEAT SPECIALTY TIRES INC. LIMITED WARRANTY POLICY For AGRICULTURE BIAS TIRES
CEAT SPECIALTY TIRES INC LIMITED WARRANTY POLICY For AGRICULTURE BIAS TIRES Tires Covered This warranty covers CEAT-branded Agriculture bias tires which are sold in the USA, Canada and Mexico, manufactured
More informationEasy Weigh ADVANCED COUNTING SCALE MODEL: AC-100 OWNER S MANUAL VER 1.00
Easy Weigh OWNER S MANUAL MODEL: AC-100 ADVANCED COUNTING SCALE VER 1.00 TABLE OF CONTENTS SPECIFICATIONS... 1 NOMENCLATURE... 1 FUNCTION KEYS... 2 DISPLAY... 3 ACCURACY SPECIFICATIONS... 4 UNPACKING &
More informationWIDE TIRE BEAD HELP. Problem: The inside edge of the tire bead is very. Wheel & Tire Accessories
WIDE TIRE BEAD HELP Problem: The inside edge of the tire bead is very sharp. This is accentuated with large tires that have wider than normal beads. This applies to Interco, Maxxis, BFG, ProComp, Goodyear
More informationTires. We recommend that you visually check your tires every day. If you think a tire might be low, check it immediately with a tire gauge.
To safely operate your vehicle, your tires must be the proper type and size, in good condition with adequate tread, and correctly inflated. The following pages give more detailed informationonhowandwhento
More informationTitan Moves the World
LOW SIDEWALL (LSW) TECHNOLOGY skid steer, backhoe, grader, wheel loader and Articulated truck tires Titan Moves the World EXPERIENCE THE TITAN DIFFERENCE WITH THE STABILITY OF OUR LOW SIDEWALL (LSW) TECHNOLOGY
More informationChanges to the Approved Tyre List Groups Na, Nb, Nc, Sa, Sb and Sc to create an Approved tyre list which details approved tyres and sizes.
Page 1 of 6 Bulletin Number: B13/085 TECHNICAL BULLETIN 5 th CATEGORY 3.6.3 APPROVED TYRE LIST REFERENCE: CAMS Online Manual of Motor Sport; 5 th Category Historic; 3.6.3 Approved Tyre List Groups Na,
More informationDISCOVERING AND TRAVELING AMERICAN ROADS SINCE 1935
Atlas-Tires.com TBR 2 DISCOVERING AND TRAVELING AMERICAN ROADS SINCE 1935 Atlas Tires have deep American roots, having been exclusively distributed by Standard Oil throughout the United States since the
More informationFEATURES: Reinforced Tyre Construction Higher dimensions Longer life Tall and functional look
BIAS RANGE C-AUTO Reinforced Tyre Construction Higher dimensions Longer life Tall and functional look 4.00-8 6 400 N/A 61 N/A 418 110 9.0 C-SPEED Reinforced Tyre Construction Higher dimensions Longer life
More informationValvoline Fourth-Quarter Fiscal 2016 Earnings Conference Call. November 9, 2016
Valvoline Fourth-Quarter Fiscal 2016 Earnings Conference Call November 9, 2016 Forward-Looking Statements This presentation contains forward-looking statements within the meaning of Section 27A of the
More informationTire & Wheel Fundamentals
Tire & Wheel Fundamentals 1 Tire Function Provide traction (friction) with the road surface Provide cushion between the road and the metal wheel 2 Tire Construction Tube Tires Have a tube inside the tire
More informationIMPROVING EFFICIENCY AND REDUCING COSTS. Food Shippers Annual Conference March 7, Dick Giromini President & CEO
IMPROVING EFFICIENCY AND REDUCING COSTS Food Shippers Annual Conference March 7, 2011 Dick Giromini President & CEO ABOUT WABASH NATIONAL Industry leader: #1 in Total Trailer production for 17 of the past
More informationArkansas Trucking Association Maintenance Council
Arkansas Trucking Association Maintenance Council Tire Knowledge and Maintenance 1/29/2015 Larry Rambeaux, Sales and Service Engineer Purkeys Jack Henshall, Territory Service Manager Eaton Corporation
More informationFARM AND INDUSTRIAL TYRES
Dealer stamp FARM AND INDUSTRIAL TYRES Goodyear Luxembourg Tires S.A. Av. Gordon Smith L-77 Colmar-Berg Telephone Telefax (352) 8199-1 (352) 8199 28 www.goodyear.com Produced by Goodyear Europe 124/26/LUX
More information1.4 CORNERING PROPERTIES OF TIRES 39
1.4 CORNERING PROPERTIES OF TIRES 39 Fig. 1.30 Variation of self-aligning torque with cornering force of a car tire under various normal loads. (Reproduced with permission of the Society of Automotive
More informationTough Tires for Tough Jobs
Tough Tires for Tough Jobs Keep Rolling on Bobcat Tires Bobcat-approved tires give you a competitive edge on any worksite. They re tough, they re rugged, and they keep you on the job even under extreme
More informationAbout Tires. Tire Function. Tire Size Designation For
About Tires Tire Function Over one hundred years' experience of tire technology has enabled Pirelli to combine in their products maximum levels of security, longevity, comfort and attention to the environment.
More information