Vibration Between MPH
|
|
- Florence Hampton
- 5 years ago
- Views:
Transcription
1 L-SB March 14, 2012 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION LS460 Drive Type(s): 4WD VDS(s): CL1EF, CL46F, CL5EF, DL1EF, DL46F, DL5EF Introduction Some model year LS 460 vehicles equipped with 4WD may exhibit a vibration or shudder feeling between mph ( km/h). The Engine Control Module (ECM) (SAE term: Powertrain Control Module/PCM) logic has been revised to address this condition. Follow the procedure in this bulletin to determine if recalibration of the ECM (PCM) is required. Parts Information MODEL YEAR PREVIOUS PART NUMBER CURRENT PART NUMBER PART NAME D D F91 Computer, Engine Control J J31 (ECM/PCM) K P LBL Same Authorized Modifications Label 1 QTY The ECM (PCM) should NOT be replaced as part of the repair procedure. Authorized Modification Labels may be ordered in packages of 25 from the Materials Distribution Center (MDC) through Dealer Daily Dealer Support Materials Orders. Page 1 of 7
2 L-SB March 14, 2012 Page 2 of 7 Warranty Information OP CODE DESCRIPTION MODEL YEAR TIME OFP T1 T D62 EG1206 Recalibrate ECM (PCM) Engine F J31 8A K20 APPLICABLE WARRANTY This repair is covered under the Lexus Federal Emission Warranty. This warranty is in effect for 96 months or 80,000 miles, whichever occurs first, from the vehicle s in-service date. Warranty application is limited to occurrence of the specified condition described in this bulletin. Calibration Information MODEL YEAR ECM (CPU) PREVIOUS CALIBRATION ID NEW CALIBRATION ID VDS Engine A A B B C B G2000 CL46F DL46F CL1EF CL5EF DL1EF DL5EF
3 L-SB March 14, 2012 Page 3 of 7 Required Tools & Equipment REQUIRED EQUIPMENT SUPPLIER PART NUMBER QTY TIS Techstream* or Techstream Lite : Software version or later is required. ADE TSPKG1 or TSLITEDLR01 1 Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE) at The Diagnostic Tester is NOT recommended for flash reprogramming with this calibration file. Please use TIS Techstream or an approved J2534 interface to perform this update. Visit techinfo.toyota.com for more information regarding J2534 reprogramming. SPECIAL SERVICE TOOLS (SST) PART NUMBER QTY GR8 Battery Diagnostic Station* MCGR8 1 Additional SSTs may be ordered by calling * Essential SST.
4 L-SB March 14, 2012 Page 4 of 7 Repair Procedure 1. Test drive the vehicle and confirm a vibration or shudder feeling is felt throughout the vehicle between mph ( km/h). 2. Perform a test drive with Techstream, take a snapshot and place a flag when the condition is occurring. 3. Review the snapshot and confirm the following conditions (see Figure 1). Figure 1. Techstream Snapshot Example 1 Vehicle Speed Between MPH 3 Torque Converter Lock Up Is ON 2 Vehicle Is in 7th or 8th Gear
5 L-SB March 14, 2012 Page 5 of 7 Repair Procedure (Continued) A. Is the vehicle speed between mph ( km/h) when the condition occurred? YES Continue to next question. NO This bulletin does NOT apply, continue diagnosis per the Repair Manual. B. Is the vehicle in 7th or 8th gear when the condition occurred? YES Continue to next question. NO This bulletin does NOT apply, continue diagnosis per the Repair Manual. C. Is torque converter lock-up ON when the condition occurred? YES Continue to step 4. NO This bulletin does NOT apply, continue diagnosis per the Repair Manual.
6 L-SB March 14, 2012 Page 6 of 7 Repair Procedure (Continued) 4. Check for the Authorized Modifications Label affixed to the vehicle in the location shown in Figure 2. Confirm if the ECM (PCM) calibration has been updated. If the calibration ID listed is NOT the latest ECM (PCM) calibration go to step 5. Figure 2. Location of Authorized Modifications Label on LS Replacement ECM (PCM) Part Number (i.e., D63) 2 New Calibration ID(s) (i.e., ) 4 Date Completed 5 This Bulletin Number 3 Dealer Code
7 L-SB March 14, 2012 Page 7 of 7 Repair Procedure (Continued) 5. Flash Reprogram the ECM (PCM). The GR8 Battery Diagnostic Station MUST be used in Power Supply Mode to maintain battery voltage at 13.5 volts while flash reprogramming the vehicle. For details on how to use the GR8 Battery Diagnostic Station, refer to the GR8 Instruction Manual located on the Technical Information System (TIS), Diagnostics Tools & Equipment Battery Diagnostics. Follow the procedures outlined in Service Bulletin L-SB , Techstream ECU Flash Reprogramming Procedure, and flash the ECM (PCM) with the NEW calibration file update. 6. Start the engine and warm it up to normal operating temperature before test driving. 7. Perform Automatic Transmission initialization, and test drive the vehicle to confirm proper vehicle operation. Refer to the Technical Information System (TIS), applicable model year LS 460 Repair Manual: 2009 / 2010 / 2011 / 2012 LS 460: Drivetrain Automatic Transmission/Transaxle AA80F Automatic Transmission: Automatic Transmission System: Initialization 8. Install the Authorized Modifications Label. A. Using a permanent marker, enter the following information on the label: ECM part number [Refer to the Parts Information section for the CURRENT PART NUMBER] Calibration ID(s) [Refer to the Calibration Identification Chart for the NEW CALIBRATION ID] Dealer Code Repair Date Change Authority [This bulletin number] B. Affix the Authorized Modifications Label to the vehicle at the location shown in Figure 2. The Authorized Modifications Label is available through the MDC, P/N LBL.
1st to 2nd Gear Upshift Shudder
T-SB-0089-2 June 5, 202 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 200 202 Drive Type(s):, Engine(s): GR Transmission(s):
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION. The Warranty Information and Parts Information sections have been updated.
T-SB-0044-14 Rev1 July 7, 2014 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 2014 Tacoma REVISION NOTICE October 14,
More informationECM Calibration: Shift Feeling Enhancements
T-SB-0077-16 July 14, 2016 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2016 Tacoma VDS(s): AZ5CN, BZ5DN, CZ5AN,
More informationMIL "ON" - DTC P0087/P Fuel Rail / System Pressure Too Low
L-SB-0050-5 September 9, 205 MIL "ON" - DTC P0087/P008700 - Fuel Rail / System Pressure Too Low Service Category Engine/Hybrid System Section Fuel System Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More information2009 Corolla, Matrix Drive Type(s): 2WD Engine(s): 2ZR VDS(s): BL40E, BU40E, KU40E
T-SB-0175-09 Rev1 June 11, 2009 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 Corolla, Drive Type(s): 2WD Engine(s):
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION Camry Engine(s): 2AZ Transmission(s): 5AT VDS(s): BE46K
T-SB-0212-09 July 15, 2009 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2009 Camry Engine(s): 2AZ Transmission(s):
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION Camry Engine(s): 2AZ VDS(s): BE30K, BE32K Solara Engine(s): 2AZ VDS(s): CE30P, CE38P
T-SB-0242-09 July 31, 2009 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2006 Camry Engine(s): 2AZ VDS(s): BE30K, BE32K
More informationECM/TCM Calibration: Shift Feeling Enhancement
T-SB-0287-10 October 13, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 Camry Engine(s): 2AR Transmission(s):
More informationMIL "ON" DTC P2195, P0138, and/or P0031
T-SB-0065-10 February 5, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 Corolla Engine(s): 2ZR Transmission(s):
More informationMIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Separation
L-SB-0019-15 June 26, 2015 MIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationVibration Between MPH
T-SB-0069-08 Rev1 May 21, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2009 Camry Engine(s): 2AZ Transmission(s):
More informationHesitation on Acceleration
L-SB-0033-08 Rev2 June 6, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2012 LS460 2008 2012 LS600H REVISION NOTICE
More informationA/T Oil Temperature Light ON When Towing in Sub-Freezing Temperatures (AB60E/F)
T-SB-0224-12 November 13, 2012 A/T Oil Temperature Light ON When Towing in Sub-Freezing Temperatures Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S)
More informationMIL "ON" DTC P2195, P0138, and/or P0031
T-SB-0066-10 February 5, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 Corolla Engine(s): 2ZR Transmission(s):
More informationMIL "ON" DTC P0A80 due to Dust or Debris in HV Battery Cooling Fan
T-SB-0098-12 July 13, 2012 MIL "ON" DTC P0A80 due to Dust or Debris in HV Battery Cooling Fan Service Category Engine/Hybrid System Section Hybrid/Battery Control System Market USA Applicability YEAR(S)
More informationTechnical Service BULLETIN
Technical Service BULLETIN April 6, 2007 Title: Models: 04 & EG07-07 ENGINE Introduction Under certain driving conditions, some 2004 model year and vehicles may exhibit a M.I.L. ON condition with DTC P033
More informationTechnical Service BULLETIN
Technical Service BULLETIN Introduction November 28, 2007 Title: Models: 07 Tundra Some customers may complain about a M.I.L. ON condition with DTC P2714 (Pressure Control Solenoid D Performance Shift
More informationMIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Separation
T-SB-0041-15 June 30, 2015 MIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationTorque Converter Flex Lock-up Shudder
T-SB-0023-5 Rev May 2, 205 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 203 205 RAV4 REVISION NOTICE August 3, 207
More informationAB60 Transmission C1 Clutch Damage
T-SB-0170-09 June 4, Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Sequoia Drive Type(s):, 2WD Engine(s): 3UR
More informationTechnical Service Information Bulletin
Technical Service Information Bulletin August 4, 2003 Title: Models: 02 03 ES 300 & 04 05 ES 330 REVISION NOTICE: April 1, 2005: 2004 2005 model year ES 330 vehicles have been added to Applicable Vehicles.
More informationAbnormal Noise when Brake Pedal Released
T-SB-0363-10 December 22, 2010 Service Category Brake Section Brake Control/Dynamic Control System Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 Prius Introduction Some 2010
More informationTechnical Service BULLETIN
Technical Service BULLETIN November 23, 2005 Title: Models: 03 & EG062-05 ENGINE Introduction Under certain driving conditions, some 2003 model year and vehicles equipped with a 2AZ FE engine may exhibit
More informationTechnical Service BULLETIN
Technical Service BULLETIN February 8, 2005 Title: Models: 04 05 Camry (V6) EG009-05 ENGINE Introduction Under certain driving conditions, some 2004 and 2005 model year Camry vehicles may exhibit a M.I.L.
More informationTechnical Service BULLETIN
Technical Service BULLETIN July 2, 2004 Title: Models: 03 04 Matrix (ZZ FE) EG026-04 ENGINE TSB REVISION NOTICE: October 8, 2004: Part number for replacement (PCM) in Figure 2 on page 5 has been updated;
More informationTechnical Service BULLETIN
Technical Service BULLETIN May 28, 2004 Title: Models: 03 04 Corolla EG016-04 ENGINE Introduction Some customers may complain of excessive sulfur dioxide odor on 2003 2004 model year Corolla vehicles under
More informationTechstream ECU Flash Reprogramming Procedure
L-SB-0001-18 January 22, 2018 Service Category Engine/Hybrid System Section Emission Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2001-2018 CT200H, ES300H, ES330, ES350, GS
More informationTechnical Service BULLETIN July 1, 2004
2004 Camry (L4 2AZFE) Technical Service BULLETIN July 1, 2004 Title: M.I.L. "ON" DTC P0420 Models: 02 04 Camry (2AZ FE) (Non PZEV) Report a problem with this article TSB REVISION NOTICE: April 3, 2007:
More informationTechnical Service BULLETIN
Technical Service BULLETIN July 1, 2004 Title: Models: 02 04 Camry (2AZ FE) (Non PZEV) EG024-04 ENGINE TSB REVISION NOTICE: April 3, 2007: A new step 3 and Figure 2 have been added to the (regarding removal
More informationTitle: TCM CALIBRATION UPDATE: M.I.L. ON DTC P2716 Models: 07 Camry (2GR -FE, 6 -Speed A/T)
Technical Service BULLETIN December 12, 2006 Title: TCM CALIBRATION UPDATE: M.I.L. ON DTC P2716 Models: 07 Camry (2GR -FE, 6 -Speed A/T) TSB REVISION NOTICE: S January 12, 2007: Production Change has been
More informationTitle: M.I.L. ON DTC P3191, P3190, AND/OR P0A0F Models:
Technical Service BULLETIN October 18, 2004 Title: M.I.L. ON DTC P3191, P3190, AND/OR P0A0F Models: 04-05 Prius EG047-04 ENGINE TSB REVISION NOTICE: S February 22, 2005: Applicable Vehicles has been updated
More informationIntermittent Battery Discharge
L-SB-0035-16 July 8, 2016 Service Category Power Source/Network Section Battery/Charging Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2013-2014 ES350, GS350 2014-2015 IS250, IS350 Introduction
More informationMIL "ON" DTC P030# and/or Intermittently Runs Rough
L-SB-0029-10 May 12, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2010 IS250 Introduction Some 2006 2010 model
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION. 1. Review DTC P0705 Freeze Frame Data to determine if this TSB may be applicable.
T-SB-0277-09 August 18, 2009 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2009 Tacoma Introduction Some 2005
More informationTire Pressure Warning System Activation & Initialization
L-SB-0162-11 December 23, 2011 Service Category General Section Pre-Delivery Service Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2013 GS350 Introduction 2013 model year GS 350 vehicles
More informationTransaxle Whine Noise
T-SB-030-2 August 8, 202 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 202 RAV4 Drive Type(s): 4WD, 2WD Engine(s):
More informationRubbing Noise from Steering Shaft/Column Area
L-SB-0084-13 October 25, 2013 Service Category Steering Section Steering Gear/Linkage Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2011 2013 LS460 Drive Type(s): 4WD VDS(s): CL1EF,
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION
T-SB-0007-11 January 7, 2011 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 2011 RAV4 Drive Type(s):, Engine(s):
More informationSecondary Air Injection System - Water Intrusion: MIL "ON" DTC P0418, P0419, and/or P244#
T-SB-060- October 7, 20 Secondary Air Injection System - Water Intrusion: MIL "ON" DTC P048, P049, Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S)
More informationSRS Airbag Light "ON" - B0111/B0116 Open Side Squib Circuit
T-SB-0069-12 May 1, 2012 SRS Airbag Light "ON" - B0111/B0116 Open Side Squib Circuit Service Category Vehicle Interior Section Supplemental Restraint Systems Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationMIL "ON" P043E, P043F, P2401, P2402, & P2419 Due to Water Intrusion into Charcoal Canister
T-SB-0200- December 6, 20 MIL "ON" P043E, P043F, P240, P2402, & P249 Due to Water Intrusion into Service Category Engine/Hybrid System Section Emission Control Market USA Applicability YEAR(S) MODEL(S)
More informationTechnical Service BULLETIN
Technical Service BULLETIN December 15, 2007 Title: Models: 04 07 Sienna EL011-07 ELECTRICAL Introduction Some customers may experience difficulty when using the power close feature of the power back door
More information6-Speed Manual Clutch Release Bearing Squeak or Rattle Noise
T-SB-0365-10 December 22, 2010 6-Speed Manual Clutch Release Bearing Squeak or Rattle Noise Service Category Drivetrain Section Manual Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationMarket USA. The information contained in this bulletin supersedes SB No. EG
T-SB-0231-12 November 29, 2012 Service Category Engine/Hybrid System Section Cooling Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2004 2007 Prius SUPERSESSION NOTICE The information
More informationDriveline Vibration Between MPH
T-SB-0249-12 December 21, 2012 Service Category Drivetrain Section Drive Shaft/Propeller Shaft Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2013 Tacoma Body Type(s): Double Cab,
More informationHID Headlamp Housing Paint Bubble / Poor Appearance
L-SB-0005-12 Rev1 February 1, 2012 Service Category Vehicle Exterior Section Lighting (ext) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2011 2013 IS F, IS250, IS250C, IS350, IS350C
More informationABS Brake Noise with DTC C1431
T-SB-0172-13 November 22, 2013 Service Category Brake Section Brake System Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 2013 Camry Introduction Some 2012 2013 model year Camry
More information2WD Rear Propeller Shaft (Driveshaft) Clunk/Thunk Noise
T-SB-0250-2 Rev2 December 2, 202 Service Category Drivetrain Section Drive Shaft/Propeller Shaft Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 203 Tacoma Transmission(s): 5AT, 4AT
More informationATF Leak from Transfer Case
T-SB-0335-08 November 3, 2008 Service Category Drivetrain Section Transfer/4wd/Awd Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Highlander Drive Type(s): 4WD Engine(s): 2GR Transmission(s):
More information2ZR-FXE Engine Oil Consumption Inspection Procedure
T-SB-0168-16 November 16, 2016 Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010, 2012-2014 Prius PHV 2012-2014 Prius
More informationTECHNICAL INSTRUCTIONS FOR LIMITED SERVICE CAMPAIGN BST SMART STOP TECHNOLOGY (ECM) REFLASH
TECHNICAL INSTRUCTIONS FOR LIMITED SERVICE CAMPAIGN BST SMART STOP TECHNOLOGY (ECM) REFLASH -2010 COROLLA -2010 COROLLA MRIX 2008-2010 LAND CRUISER I. OPERION FLOW CHART Verify Vehicle Eligibility 1. Check
More informationWind (Reed/Buzz) Noise From Front Doors - Cross- Wind Conditions
T-SB-0170-16 Rev1 December 2, 2016 Wind (Reed/Buzz) Noise From Front Doors - Cross- Wind Conditions Service Category Vehicle Exterior Section Door/Hatch Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationMIL "ON" DTC P0012 and/or P0022
T-SB-0019-10 January 0, 010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 010 Sequoia, Tundra Engine(s): 1UR, 3UR Introduction
More informationM.I.L. "ON" DTC P2237, P2238, P2240, or P2241
T-SB-0278-08 September 5, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Avalon 2008 2009 Camry Introduction Some
More informationBattery Maintenance During PDS
L-SB-0008-16 February 2, 2016 Service Category General Section Pre-Delivery Service Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2016 CT200H, ES300H, ES350, GS F, GS200T, GS350, GS450H,
More information2GR-FE Engine Ticking Noise and / or MIL ON P0014, P0015, P0024, P0025, P0017, or P0018
T-SB-0094-09 March 19, 2009 2GR-FE Engine Ticking Noise and / or MIL ON P0014, P0015, P0024, P0025, Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S) MODEL(S)
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION
T-SB-0008-14 Rev1 July 28, 2014 Service Category Drivetrain Section Drive Shaft/Propeller Shaft Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2014 Tacoma Engine(s): 1GR Transmission(s):
More informationMIL "ON" DTC P030#, Intermittently Runs Rough, and/or Engine Oil Consumption
L-SB-0068-11 Rev1 August 11, 2011 MIL "ON" DTC P030#, Intermittently Runs Rough, and/or Engine Oil Consumption Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S)
More informationDriveline Vibration Under Deceleration Around MPH
T-SB-0171-16 Rev1 December 6, 2016 Driveline Vibration Under Deceleration Around 10-30 MPH Service Category Drivetrain Section Drive Shaft/Propeller Shaft Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationM.I.L. "ON" DTC B2799 "No Start" Due to Harness Water Intrusion
T-SB-0220-08 Rev1 August 11, 2008 M.I.L. "ON" DTC B2799 "No Start" Due to Harness Water Intrusion Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S)
More informationWindow Freezing, Losing Initialization
S-SB-0001-14 January 9, 2014 Service Category Vehicle Exterior Section Window/Glass Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2013 FR-S Introduction Some 2013 model year Scion FR-S
More information2nd Row Tip-Up Style Seat Lower Cushion Excessive Movement
T-SB-0180-12 September 20, 2012 2nd Row Tip-Up Style Seat Lower Cushion Excessive Movement Service Category Vehicle Interior Section Seat Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION
More informationSmart Key Intermittent No Crank / No Start
T-SB-0003-09 Rev1 January 7, 2009 Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2008 Avalon 2007 2008 Camry,
More informationCenter Console Wood Grain Panel Cracked
L-SB-0040- July 3, 20 Service Category Vehicle Interior Section Interior Panels/Trim Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 20 LS460, LS600H Introduction Some 2007-20 model
More informationMIL "ON" DTC P030#, Intermittently Runs Rough, and/or Engine Oil Consumption
L-SB-0124-12 November 30, 2012 MIL "ON" DTC P030#, Intermittently Runs Rough, and/or Engine Oil Consumption Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S)
More informationM.I.L. "ON" DTC P0101, P0121, P0171, P0172, P035#, P223#
T-SB-0379-08 November 26, 2008 M.I.L. "ON" DTC P0101, P0121, P0171, P0172, P035#, P223# Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More information2AZ Engine Oil Consumption Inspection Procedure
T-SB-0158-14 Rev2 December 12, 2014 Service Category Engine/Hybrid System Section Lubrication Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2011 Camry HV Engine(s): 2AZ VDS(s):
More informationTechnical Service BULLETIN
Technical Service BULLETIN July 4, 2007 Title: Models: 07 Avalon, Camry (NAP), Camry HV (NAP), & Solara EG035-07 ENGINE TSB REVISION NOTICE: August 22, 2007: Two parts have been added to the Parts Information
More information2GR-FE Engine Ticking Noise and/or MIL "ON" P0014, P0015, P0024, P0025, P0017, or P0018
T-SB-0094-09 Rev1 March 19, 2009 2GR-FE Engine Ticking Noise and/or MIL "ON" P0014, P0015, P0024, P0025, Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S)
More informationGrille Wind Whistle Noise
T-SB-0144-13 September 23, 2013 Service Category Vehicle Exterior Section Exterior Panels/Trim Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 2013 Tacoma Introduction Some 2012 2013
More informationTechnical Service BULLETIN
Technical Service BULLETIN March 31, 2006 Title: Models: 03 05 Sequoia BR006-06 BRAKES TSB REVISION NOTICE: August 3, 2007: Step 1A of the has been updated. Previous versions of this TSB should be discarded.
More informationIntegration Relay - Poor Ground
T-SB-0179-12 Rev1 September 19, 2012 Service Category Power Source/Network Section Power Distribution Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 2013 Camry HV 2012 2013 Camry
More informationRoof Drip Molding Loose
T-SB-0053-12 March 6, 2012 Service Category Vehicle Exterior Section Exterior Panels/Trim Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2012 Highlander VDS(s): BK3EH, DK3EH, YK3EH,
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION
T-SB-0102-11 August 17, 2011 Service Category Brake Section Brake (rear) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 Introduction Some 2010 2011 vehicles may experience rear
More informationSRS LIGHT "ON" - B0111/B OPEN SIDE SQUIB CIRCUIT TECHNICAL SERVICE BULLETIN Reference Number(s): T-SB , Date of Issue: June 23, 2010
SRS LIGHT "ON" - B0111/B0116 - OPEN SIDE SQUIB CIRCUIT -2006 Toyota Sienna... Page 1 of 27 SRS LIGHT "ON" - B0111/B0116 - OPEN SIDE SQUIB CIRCUIT TECHNICAL SERVICE BULLETIN Reference Number(s): T-SB-0162-10,
More informationHigh Beam/DRL Bulb Inoperative
T-SB-0044-10 Rev2 January 27, 2010 Service Category Vehicle Exterior Section Lighting (ext) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 2010 Avalon TSB REVISION NOTICE October
More informationRear Differential Coupling Growl Noise
T-SB-0080-13 Rev1 June 14, 2013 Service Category Drivetrain Section Axle/Differential Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2012 RAV4 Drive Type(s): 4WD Transmission(s):
More informationTechnical Service BULLETIN
Technical Service BULLETIN December 4, 2003 Title: Models: 03 4Runner BR005-03 BRAKES Introduction Some 2003 model year 4Runner vehicles may experience a VSC light ON condition and DTC C1203 in the Skid
More informationFront Differential Growl/Howl/Rumble Noise at MPH
T-SB-0121-08 Rev1 June 30, 2008 Service Category Drivetrain Section Axle/Differential Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2008 Tundra Body Type(s): Double Cab, Crew Max,
More informationTechnical Service Information Bulletin
Technical Service Information Bulletin August 2, 2006 Title: Models: 07 ES 350 TSIB REVISION NOTICE: August 7, 2006: The OFP has been updated in Warranty Information. Applicable Warranty has been changed
More informationTECHNICAL SERVICE BULLETIN
GROUP ENG MODEL 2015MY K900 (KH) NUMBER DATE 141 (REV 1, 04/25/2014) April 2014 TECHNICAL SERVICE BULLETIN This bulletin has been revised to include additional information. New/revised sections of this
More informationCharging System Inoperative
T-SB-0055-12 March 13, 2012 Service Category Power Source/Network Section Battery/Charging Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2011 Avalon, RAV4, Venza 2011 2012 Camry, Highlander,
More informationTECHNICAL SERVICE BULLETIN
GROUP CHA MODEL 2014~2015MY Forte (YD) 2014MY Sportage (SL) NUMBER DATE 065 (REV 3, 06/29/2016) February 2016 TECHNICAL SERVICE BULLETIN This bulletin has been revised to include additional information.
More informationTHIS BULLETIN IS BEING PROVIDED IN ADVANCE. THE SOFTWARE WILL BE AVAILABLE ON TechCONNECT ON OR AFTER DECEMBER 15, 2003.
NUMBER: 18-042-03 GROUP: Vehicle Performance DATE: November 28, 2003 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationTechnical Service BULLETIN
Technical Service BULLETIN Introduction November 28, 2005 Title: Models: 04 06 Sequoia Some 2004 2006 model year Sequoia vehicles may display one of the following conditions from corrosion inside of the
More informationTHE StarSCAN FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET.
NUMBER: GROUP: 18-006-08 REV. A Vehicle Performance DATE: April 8, 2008 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be
More informationSmart Key Intermittent No Crank/No Start
L-SB-0161-08 Rev1 November 11, 2008 Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2008 ES350, GS350, GS450H,
More informationWhine Noise From Rear of Vehicle
T-SB-003-8 February 6, 208 Service Category Drivetrain Section Axle/Differential Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMION 206-207 Tacoma Body Type(s): D CAB Introduction Some 206
More informationTechnical Service BULLETIN
Technical Service BULLETIN November 20, 2002 Title: Models: 01 02 Prius EG021-02 ENGINE Introduction Under certain driving conditions, some Prius vehicles may exhibit a Master, Hybrid and M.I.L. Warning
More informationTechnical Service BULLETIN
Technical Service BULLETIN December 22, 2005 Title: Models: 04 05 BR006-05 BRAKES TSB REVISION NOTICE: December 4, 2006: The Old Part Identification column of the Parts Identification table has been updated.
More informationEntune Audio Head Unit Software Update (Pioneer)
T-SB-0047-14 July 23, 2014 Service Category Audio/Visual/Telematics Section Audio/Video Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2014 4Runner, Camry, Camry HV, Highlander, Highlander
More information2ZR-FXE Engine Oil Consumption Repair Procedure
T-SB-0169-16 November 16, 2016 Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010, 2012-2014 Prius PHV 2012-2014 Prius
More informationHeadlamp Durability Enhancement
T-SB-004- Rev October 7, 0 Service Category Vehicle Exterior Section Lighting (ext) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 00-0 Prius REVISION NOTICE October 7, 07 Rev: The Repair
More informationMaintenance for HV & Auxiliary Batteries
T-SB-0305-10 November 5, 2010 Service Category General Section Pre-Delivery Service Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2011 Prius Introduction The 2011 model year Prius hybrid
More informationPrevious versions of this TSB should be discarded. TSB UPDATE NOTICE: The information contained in this TSB supersedes TSB No. PG
BATTERY MAINTENANCE FOR IN-STOCK VEHICLES & PRE-DELIVERY -2008... Page 1 of 31 BATTERY MAINTENANCE FOR IN-STOCK VEHICLES & PRE-DELIVERY TECHNICAL SERVICE BULLETIN Reference Number(s): PG001-06, Date of
More informationOVERVIEW: This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software.
NUMBER: 21 001 18 GROUP: 21 Transmission and Transfer Case DATE: January 4, 2018 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication
More informationTHE SOFTWARE WILL BE AVAILABLE ON TechCONNECT ON FEBRUARY 3, 2004.
NUMBER: 18-002-04 GROUP: Vehicle Performance DATE: February 3, 2004 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationTechnical Service BULLETIN
Technical Service BULLETIN September 12, 2002 Title: Models: 00 05 Tundra BR004-02 BRAKES TSB REVISION NOTICE: April 4, 2005: Applicable Vehicles has been updated to include 2003 2005 model years. The
More informationTechnical Service Bulletin
SUBJECT: group model Engine Sorento (XM) 2.4L GDI 2013MY NUMBER DATE 126 [Rev 1, 12/11/12] November 2012 Technical Service Bulletin This bulletin has been revised to include additional information. New/revised
More informationTHE witech SOFTWARE VERSION MUST BE AT **15.02** OR HIGHER TO PERFORM THIS PROCEDURE.
NUMBER: GROUP: 21-030-14 REV. A Transmission and Transfer Case DATE: October 24, 2014 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication
More information