Title: TCM CALIBRATION UPDATE: M.I.L. ON DTC P2716 Models: 07 Camry (2GR -FE, 6 -Speed A/T)

Size: px
Start display at page:

Download "Title: TCM CALIBRATION UPDATE: M.I.L. ON DTC P2716 Models: 07 Camry (2GR -FE, 6 -Speed A/T)"

Transcription

1 Technical Service BULLETIN December 12, 2006 Title: TCM CALIBRATION UPDATE: M.I.L. ON DTC P2716 Models: 07 Camry (2GR -FE, 6 -Speed A/T) TSB REVISION NOTICE: S January 12, 2007: Production Change has been added. Previous versions of this TSB should be discarded. TC TRANSMISSION & CLUTCH Introduction Under certain driving conditions, some vehicles may exhibit a M.I.L. ON condition with DTC P2716 (Pressure Control Solenoid D Electrical [Shift Solenoid SLT]) and no noticeable change in vehicle operation. The Transmission Control Module (TCM) calibration has been revised to address this issue. S Version 14.0a or later Diagnostic Tester software is required to perform this procedure. S Before proceeding, verify the TCM calibration has NOT been updated by checking for the Authorized Modifications Label (shown in step 1 of the ). Applicable Vehicles S 2007 model year Camry vehicles equipped with the 2GR -FE engine and 6 -speed automatic transmission, produced BEFORE the Production Change Effective VINs shown below. Production Change MODEL ENGINE PLANT PRODUCTION CHANGE EFFECTIVE VIN Tsutsumi JTNBK46K# Camry 2GR--FE TMMK Line 1 4T1BK46K#7U TMMK Line 2 4T1BK46K#7U Warranty OP CODE DESCRIPTION TIME OFP T1 T2 TC5004 Recalibrate TCM A 99 Applicable Warranty**: This repair is covered under the Toyota Comprehensive Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from the vehicle s in-service date. ** Warranty application is limited to correction of a problem based upon a customer s specific complaint. Toyota Supports ASE Certification Page 1 of 5

2 Parts PREVIOUS PART NUMBER CURRENT PART NUMBER PART NAME QTY * Transmission Control Computer Assembly (TCM) 1 * The TCM does NOT need to be replaced as part of the. Required SSTs ITEM NO. SPECIAL SERVICE TOOLS (SSTs) PART NUMBER QTY DRW** 1 2 Toyota Diagnostic Tester Kit* S All components from this kit/set are required. S 12 Megabyte Diagnostic Tester Program Card (P/N ) with version 14.0a Software (or later) is required. CAN Interface Module Kit* S All components from this kit/set are required. TOY * Essential SSTs. ** Drawer number in SST Storage System. Additional Diagnostic Tester Kits, CAN Interface Modules, Program Cards, or other SSTs may be ordered by calling SPX/OTC at Calibration Identification Chart MODEL YEAR MODEL ENGINE PREVIOUS NEW 2007 Camry 2GR--FE Page 2 of 5

3 1. Check for the Authorized Modifications Label affixed to the vehicle in the location shown in Figure 1. Confirm if the TCM calibration has been updated. If the calibration ID listed is NOT the latest TCM calibration go to step 2. Replacement TCM Part Number Calibration ID(s) THE FOLLOWING MODIFICATIONS HAVE BEEN MADE: THESE MODIFICATIONS HAVE BEEN APPROVED AS APPROPRIATE BY EPA AND CARB DEALER CODE: DATE: CHANGE AUTHORITY: TSB TC Date Completed Dealer Code TSB Number Figure 1. Location of Authorized Modifications Label on 2007 Camry 2. To start diagnosis of DTC P2716, refer to the Technical System (TIS), 2007 model year Camry Manual, Drivetrain - Automatic Transmission/ Transaxle - U660E Automatic Transaxle: Automatic Transaxle System: P2716: Pressure Control Solenoid D Electrical (Shift Solenoid Valve SLT), and perform step 1 of the Inspection. 3. If the transmission wire and shift solenoid SLT resistance is within Manual specification, perform the TCM calibration update. If NOT, complete Manual diagnostics to determine the cause of the M.I.L. ON. Page 3 of 5

4 (Continued) 4. Connect the Diagnostic Tester to the vehicle and select CURRENT ECU CAL from the ECU REPROGRAM MAIN MENU. Determine the vehicle s current ECU calibrations (see Figure 2). -- The sample screen prints seen below are the 14.0a software version and may differ from subsequent software versions. A ECU REPROGRAM MAIN MENU 1: GET CAL FROM PC 2: CURRENT ECU CAL 3: UPDATE ECU CAL 4: CAL ON TESTER 5: CLEAR CAL DATA B CURRENT ECU CAL Figure 2. Determining Current ECU Calibration S If the Calibration ID matches the Previous Calibration ID as shown in the Calibration Identification Chart in this TSB, proceed with flash reprogramming. S If the Calibration ID matches the New Calibration ID as shown in the Calibration Identification Chart, this vehicle has already been programmed. Refer to TIS for diagnostic procedures applicable to any stored DTCs. 5. If the ECU calibration ID is NOT the same as the New Calibration ID listed previously, proceed to Flash Reprogram TCM. 6. Flash Reprogram TCM A battery charger MUST be connected to the battery and set at a medium charge setting during the Flash Reprogram procedure in order to maintain battery voltage above 11.4 volts and prevent damage to the TCM. Follow the procedures outlined in TSB No. SS002-01, ECU Flash Reprogramming Process, and flash the TCM with the NEW calibration file update. S If the Check Engine light is ON when the ignition is turned back ON to begin the reprogramming process, a scan tool cable problem exists. Refer to TSB No. SS004-01, ECU Flash Reprogramming Error Message. S If the Check Engine, VSC, and TRAC OFF lights are ON when the process is complete, confirm that the stored DTC in the TCM is U0101: Lost Communication with TCM and the stored DTC in ABS/VSC is C1201: Engine Control System Malfunction. These two DTCs occur during the Flash Reprogram ECU procedure. Clear the DTCs and perform a road test. Refer to TIS for diagnostic procedures applicable to any other stored DTCs. Page 4 of 5

5 (Continued) 7. Enter the required information on the Authorized Modifications Label and affix it to the vehicle at the location shown in Figure 1. The Authorized Modifications Label is available through the MDC, P/N LBL. 8. Calibration update is complete. Page 5 of 5

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN April 6, 2007 Title: Models: 04 & EG07-07 ENGINE Introduction Under certain driving conditions, some 2004 model year and vehicles may exhibit a M.I.L. ON condition with DTC P033

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN November 23, 2005 Title: Models: 03 & EG062-05 ENGINE Introduction Under certain driving conditions, some 2003 model year and vehicles equipped with a 2AZ FE engine may exhibit

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN February 8, 2005 Title: Models: 04 05 Camry (V6) EG009-05 ENGINE Introduction Under certain driving conditions, some 2004 and 2005 model year Camry vehicles may exhibit a M.I.L.

More information

Technical Service Information Bulletin

Technical Service Information Bulletin Technical Service Information Bulletin August 4, 2003 Title: Models: 02 03 ES 300 & 04 05 ES 330 REVISION NOTICE: April 1, 2005: 2004 2005 model year ES 330 vehicles have been added to Applicable Vehicles.

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN July 1, 2004 Title: Models: 02 04 Camry (2AZ FE) (Non PZEV) EG024-04 ENGINE TSB REVISION NOTICE: April 3, 2007: A new step 3 and Figure 2 have been added to the (regarding removal

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN July 2, 2004 Title: Models: 03 04 Matrix (ZZ FE) EG026-04 ENGINE TSB REVISION NOTICE: October 8, 2004: Part number for replacement (PCM) in Figure 2 on page 5 has been updated;

More information

Technical Service BULLETIN July 1, 2004

Technical Service BULLETIN July 1, 2004 2004 Camry (L4 2AZFE) Technical Service BULLETIN July 1, 2004 Title: M.I.L. "ON" DTC P0420 Models: 02 04 Camry (2AZ FE) (Non PZEV) Report a problem with this article TSB REVISION NOTICE: April 3, 2007:

More information

Vibration Between MPH

Vibration Between MPH T-SB-0069-08 Rev1 May 21, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2009 Camry Engine(s): 2AZ Transmission(s):

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN Introduction November 28, 2007 Title: Models: 07 Tundra Some customers may complain about a M.I.L. ON condition with DTC P2714 (Pressure Control Solenoid D Performance Shift

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN May 28, 2004 Title: Models: 03 04 Corolla EG016-04 ENGINE Introduction Some customers may complain of excessive sulfur dioxide odor on 2003 2004 model year Corolla vehicles under

More information

Title: M.I.L. ON DTC P3191, P3190, AND/OR P0A0F Models:

Title: M.I.L. ON DTC P3191, P3190, AND/OR P0A0F Models: Technical Service BULLETIN October 18, 2004 Title: M.I.L. ON DTC P3191, P3190, AND/OR P0A0F Models: 04-05 Prius EG047-04 ENGINE TSB REVISION NOTICE: S February 22, 2005: Applicable Vehicles has been updated

More information

2009 Corolla, Matrix Drive Type(s): 2WD Engine(s): 2ZR VDS(s): BL40E, BU40E, KU40E

2009 Corolla, Matrix Drive Type(s): 2WD Engine(s): 2ZR VDS(s): BL40E, BU40E, KU40E T-SB-0175-09 Rev1 June 11, 2009 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 Corolla, Drive Type(s): 2WD Engine(s):

More information

YEAR(S) MODEL(S) ADDITIONAL INFORMATION Camry Engine(s): 2AZ Transmission(s): 5AT VDS(s): BE46K

YEAR(S) MODEL(S) ADDITIONAL INFORMATION Camry Engine(s): 2AZ Transmission(s): 5AT VDS(s): BE46K T-SB-0212-09 July 15, 2009 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2009 Camry Engine(s): 2AZ Transmission(s):

More information

ECM/TCM Calibration: Shift Feeling Enhancement

ECM/TCM Calibration: Shift Feeling Enhancement T-SB-0287-10 October 13, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 Camry Engine(s): 2AR Transmission(s):

More information

YEAR(S) MODEL(S) ADDITIONAL INFORMATION Camry Engine(s): 2AZ VDS(s): BE30K, BE32K Solara Engine(s): 2AZ VDS(s): CE30P, CE38P

YEAR(S) MODEL(S) ADDITIONAL INFORMATION Camry Engine(s): 2AZ VDS(s): BE30K, BE32K Solara Engine(s): 2AZ VDS(s): CE30P, CE38P T-SB-0242-09 July 31, 2009 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2006 Camry Engine(s): 2AZ VDS(s): BE30K, BE32K

More information

MIL "ON" DTC P2195, P0138, and/or P0031

MIL ON DTC P2195, P0138, and/or P0031 T-SB-0065-10 February 5, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 Corolla Engine(s): 2ZR Transmission(s):

More information

1st to 2nd Gear Upshift Shudder

1st to 2nd Gear Upshift Shudder T-SB-0089-2 June 5, 202 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 200 202 Drive Type(s):, Engine(s): GR Transmission(s):

More information

YEAR(S) MODEL(S) ADDITIONAL INFORMATION. The Warranty Information and Parts Information sections have been updated.

YEAR(S) MODEL(S) ADDITIONAL INFORMATION. The Warranty Information and Parts Information sections have been updated. T-SB-0044-14 Rev1 July 7, 2014 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 2014 Tacoma REVISION NOTICE October 14,

More information

AB60 Transmission C1 Clutch Damage

AB60 Transmission C1 Clutch Damage T-SB-0170-09 June 4, Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Sequoia Drive Type(s):, 2WD Engine(s): 3UR

More information

Abnormal Noise when Brake Pedal Released

Abnormal Noise when Brake Pedal Released T-SB-0363-10 December 22, 2010 Service Category Brake Section Brake Control/Dynamic Control System Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 Prius Introduction Some 2010

More information

MIL "ON" DTC P2195, P0138, and/or P0031

MIL ON DTC P2195, P0138, and/or P0031 T-SB-0066-10 February 5, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 Corolla Engine(s): 2ZR Transmission(s):

More information

MIL "ON" - DTC P0087/P Fuel Rail / System Pressure Too Low

MIL ON - DTC P0087/P Fuel Rail / System Pressure Too Low L-SB-0050-5 September 9, 205 MIL "ON" - DTC P0087/P008700 - Fuel Rail / System Pressure Too Low Service Category Engine/Hybrid System Section Fuel System Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL

More information

MIL "ON" DTC P0A80 due to Dust or Debris in HV Battery Cooling Fan

MIL ON DTC P0A80 due to Dust or Debris in HV Battery Cooling Fan T-SB-0098-12 July 13, 2012 MIL "ON" DTC P0A80 due to Dust or Debris in HV Battery Cooling Fan Service Category Engine/Hybrid System Section Hybrid/Battery Control System Market USA Applicability YEAR(S)

More information

Vibration Between MPH

Vibration Between MPH L-SB-0013-12 March 14, 2012 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 2012 LS460 Drive Type(s): 4WD VDS(s):

More information

Technical Service Information Bulletin

Technical Service Information Bulletin Technical Service Information Bulletin August 2, 2006 Title: Models: 07 ES 350 TSIB REVISION NOTICE: August 7, 2006: The OFP has been updated in Warranty Information. Applicable Warranty has been changed

More information

MIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Separation

MIL ON DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Separation L-SB-0019-15 June 26, 2015 MIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL

More information

MIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Separation

MIL ON DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Separation T-SB-0041-15 June 30, 2015 MIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL

More information

ECM Calibration: Shift Feeling Enhancements

ECM Calibration: Shift Feeling Enhancements T-SB-0077-16 July 14, 2016 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2016 Tacoma VDS(s): AZ5CN, BZ5DN, CZ5AN,

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN March 31, 2006 Title: Models: 03 05 Sequoia BR006-06 BRAKES TSB REVISION NOTICE: August 3, 2007: Step 1A of the has been updated. Previous versions of this TSB should be discarded.

More information

Hesitation on Acceleration

Hesitation on Acceleration L-SB-0033-08 Rev2 June 6, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2012 LS460 2008 2012 LS600H REVISION NOTICE

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN December 4, 2003 Title: Models: 03 4Runner BR005-03 BRAKES Introduction Some 2003 model year 4Runner vehicles may experience a VSC light ON condition and DTC C1203 in the Skid

More information

M.I.L. "ON" DTC P2237, P2238, P2240, or P2241

M.I.L. ON DTC P2237, P2238, P2240, or P2241 T-SB-0278-08 September 5, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Avalon 2008 2009 Camry Introduction Some

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN December 15, 2007 Title: Models: 04 07 Sienna EL011-07 ELECTRICAL Introduction Some customers may experience difficulty when using the power close feature of the power back door

More information

Torque Converter Flex Lock-up Shudder

Torque Converter Flex Lock-up Shudder T-SB-0023-5 Rev May 2, 205 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 203 205 RAV4 REVISION NOTICE August 3, 207

More information

Techstream ECU Flash Reprogramming Procedure

Techstream ECU Flash Reprogramming Procedure L-SB-0001-18 January 22, 2018 Service Category Engine/Hybrid System Section Emission Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2001-2018 CT200H, ES300H, ES330, ES350, GS

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN July 4, 2007 Title: Models: 07 Avalon, Camry (NAP), Camry HV (NAP), & Solara EG035-07 ENGINE TSB REVISION NOTICE: August 22, 2007: Two parts have been added to the Parts Information

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN November 18, 2003 Title: Models: 03 Sequoia BR003-03 BRAKES TSB REVISION NOTICE: May 13, 2004: The iagnostic Tester screen flows on pages 3 5 have been changed. All previous

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN June 14, 2006 Title: Models: 01 06 Sequoia EL007-06 ELECTRICAL Introduction Some 2001 2006 model year Sequoia vehicles may experience a condition where the back door power window

More information

Previous versions of this TSB should be discarded. TSB UPDATE NOTICE: The information contained in this TSB supersedes TSB No. PG

Previous versions of this TSB should be discarded. TSB UPDATE NOTICE: The information contained in this TSB supersedes TSB No. PG BATTERY MAINTENANCE FOR IN-STOCK VEHICLES & PRE-DELIVERY -2008... Page 1 of 31 BATTERY MAINTENANCE FOR IN-STOCK VEHICLES & PRE-DELIVERY TECHNICAL SERVICE BULLETIN Reference Number(s): PG001-06, Date of

More information

A/T Oil Temperature Light ON When Towing in Sub-Freezing Temperatures (AB60E/F)

A/T Oil Temperature Light ON When Towing in Sub-Freezing Temperatures (AB60E/F) T-SB-0224-12 November 13, 2012 A/T Oil Temperature Light ON When Towing in Sub-Freezing Temperatures Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S)

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN November 20, 2002 Title: Models: 01 02 Prius EG021-02 ENGINE Introduction Under certain driving conditions, some Prius vehicles may exhibit a Master, Hybrid and M.I.L. Warning

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN September 12, 2002 Title: Models: 00 05 Tundra BR004-02 BRAKES TSB REVISION NOTICE: April 4, 2005: Applicable Vehicles has been updated to include 2003 2005 model years. The

More information

YEAR(S) MODEL(S) ADDITIONAL INFORMATION. The information contained in this TSB supersedes TSB No. T-SB

YEAR(S) MODEL(S) ADDITIONAL INFORMATION. The information contained in this TSB supersedes TSB No. T-SB T-SB-0163-11 October 20, 2011 Service Category Vehicle Interior Section Heating/Air Conditioning Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2011 Avalon 2007 2011 Camry, Camry

More information

Smart Key Intermittent No Crank / No Start

Smart Key Intermittent No Crank / No Start T-SB-0003-09 Rev1 January 7, 2009 Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2008 Avalon 2007 2008 Camry,

More information

THE SOFTWARE WILL BE AVAILABLE ON TechCONNECT ON FEBRUARY 3, 2004.

THE SOFTWARE WILL BE AVAILABLE ON TechCONNECT ON FEBRUARY 3, 2004. NUMBER: 18-002-04 GROUP: Vehicle Performance DATE: February 3, 2004 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

2GR-FE Engine Ticking Noise and/or MIL "ON" P0014, P0015, P0024, P0025, P0017, or P0018

2GR-FE Engine Ticking Noise and/or MIL ON P0014, P0015, P0024, P0025, P0017, or P0018 T-SB-0094-09 Rev1 March 19, 2009 2GR-FE Engine Ticking Noise and/or MIL "ON" P0014, P0015, P0024, P0025, Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S)

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN August 0, 2007 Title: Models: 06 07 4Runner, Prius, & RAV4 & 07 Camry,, FJ Cruiser, Solara, & Yaris AU004-07 AUDIO Introduction Some customers may notice noise in the auxiliary

More information

YEAR(S) MODEL(S) ADDITIONAL INFORMATION. 1. Review DTC P0705 Freeze Frame Data to determine if this TSB may be applicable.

YEAR(S) MODEL(S) ADDITIONAL INFORMATION. 1. Review DTC P0705 Freeze Frame Data to determine if this TSB may be applicable. T-SB-0277-09 August 18, 2009 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2009 Tacoma Introduction Some 2005

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN Introduction November 28, 2005 Title: Models: 04 06 Sequoia Some 2004 2006 model year Sequoia vehicles may display one of the following conditions from corrosion inside of the

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN February 16, 2006 Title: Models: 03 06 Camry, 04 05 Highlander, & 04 06 Solara, ST001-06 STEERING TSB REVISION NOTICE: July 20, 2006: 2004 2005 model year Highlander vehicles

More information

TECHNICAL SERVICE BULLETIN

TECHNICAL SERVICE BULLETIN GROUP CHA MODEL 2014~2015MY Forte (YD) 2014MY Sportage (SL) NUMBER DATE 065 (REV 3, 06/29/2016) February 2016 TECHNICAL SERVICE BULLETIN This bulletin has been revised to include additional information.

More information

YEAR(S) MODEL(S) ADDITIONAL INFORMATION

YEAR(S) MODEL(S) ADDITIONAL INFORMATION T-SB-0007-11 January 7, 2011 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 2011 RAV4 Drive Type(s):, Engine(s):

More information

MIL "ON" P043E, P043F, P2401, P2402, & P2419 Due to Water Intrusion into Charcoal Canister

MIL ON P043E, P043F, P2401, P2402, & P2419 Due to Water Intrusion into Charcoal Canister T-SB-0200- December 6, 20 MIL "ON" P043E, P043F, P240, P2402, & P249 Due to Water Intrusion into Service Category Engine/Hybrid System Section Emission Control Market USA Applicability YEAR(S) MODEL(S)

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN December 22, 2005 Title: Models: 04 05 BR006-05 BRAKES TSB REVISION NOTICE: December 4, 2006: The Old Part Identification column of the Parts Identification table has been updated.

More information

OVERVIEW: This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software.

OVERVIEW: This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. NUMBER: 18-032-03 GROUP: Vehicle Performance DATE: Sep. 12, 2003 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

SUBJECT: Long Engine Crank Time And/Or MIL Illumination Due To DTC P0340 / P0344

SUBJECT: Long Engine Crank Time And/Or MIL Illumination Due To DTC P0340 / P0344 NUMBER: GROUP: 08-001-08 REV. A Electrical DATE: February 23, 2008 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN Introduction January 26, 2006 Title: Models: All Models & Model Years Through Current TSB UPDATE NOTICE: The information contained in this TSB supercedes TSB No. PG017 02. TSB

More information

THIS BULLETIN IS BEING PROVIDED IN ADVANCE. THE SOFTWARE WILL BE AVAILABLE ON TechCONNECT ON OR AFTER DECEMBER 15, 2003.

THIS BULLETIN IS BEING PROVIDED IN ADVANCE. THE SOFTWARE WILL BE AVAILABLE ON TechCONNECT ON OR AFTER DECEMBER 15, 2003. NUMBER: 18-042-03 GROUP: Vehicle Performance DATE: November 28, 2003 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

TSB REVISION NOTICE: October 16, 2003: The Parts Information table has been changed. The previous version on this TSB should be discarded.

TSB REVISION NOTICE: October 16, 2003: The Parts Information table has been changed. The previous version on this TSB should be discarded. Technical ervice BULLETIN eptember 29, 2003 Title: M.I.L. ON DTC P0440, P044 OR P0446 Models: 00-03 Avalon, Camry & olara, 0-03 ienna EG03-03 ENGINE TB REVIION NOTICE: October 6, 2003: The Parts table

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN 01 03 Prius TSB REVISION NOTICE: October 2, 2003: Instructions for finding current STK# added to section C 3a on page 5. Special Service Tools table added on page 2. Charger

More information

THE StarSCAN FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET. StarSCAN SOFTWARE LEVEL MUST BE AT RELEASE 8.03 OR HIGHER.

THE StarSCAN FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET. StarSCAN SOFTWARE LEVEL MUST BE AT RELEASE 8.03 OR HIGHER. NUMBER: GROUP: 21-002-07 REV. E Transmission DATE: December 21, 2007 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

M.I.L. "ON" DTC B2799 "No Start" Due to Harness Water Intrusion

M.I.L. ON DTC B2799 No Start Due to Harness Water Intrusion T-SB-0220-08 Rev1 August 11, 2008 M.I.L. "ON" DTC B2799 "No Start" Due to Harness Water Intrusion Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S)

More information

OVERVIEW: This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software.

OVERVIEW: This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. NUMBER: GROUP: 18-026-03 REV. A Vehicle Performance DATE: September 12, 2003 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication

More information

OVERVIEW: This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software.

OVERVIEW: This bulletin involves reprogramming the Transmission Control Module (TCM) with the latest available software. NUMBER: 21 001 18 GROUP: 21 Transmission and Transfer Case DATE: January 4, 2018 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication

More information

Intermittent Battery Discharge

Intermittent Battery Discharge L-SB-0035-16 July 8, 2016 Service Category Power Source/Network Section Battery/Charging Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2013-2014 ES350, GS350 2014-2015 IS250, IS350 Introduction

More information

2AZ Engine Oil Consumption Inspection Procedure

2AZ Engine Oil Consumption Inspection Procedure T-SB-0158-14 Rev2 December 12, 2014 Service Category Engine/Hybrid System Section Lubrication Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2011 Camry HV Engine(s): 2AZ VDS(s):

More information

TECHNICAL SERVICE BULLETIN

TECHNICAL SERVICE BULLETIN GROUP ENG MODEL 2015MY K900 (KH) NUMBER DATE 141 (REV 1, 04/25/2014) April 2014 TECHNICAL SERVICE BULLETIN This bulletin has been revised to include additional information. New/revised sections of this

More information

THE witech SOFTWARE LEVEL MUST BE AT RELEASE **15.04** OR HIGHER TO PERFORM THIS PROCEDURE.

THE witech SOFTWARE LEVEL MUST BE AT RELEASE **15.04** OR HIGHER TO PERFORM THIS PROCEDURE. 2014 RAM 3500 HD 6.7L Eng Big Horn FLASH: 6.7L DIAGNOSTIC AND SYSTEM IMPROVEMENTS TECHNICAL SERVICE BULLETIN Reference Number(s): 18-045-15, Date of Issue: May 20, 2015 CHRYSLER: 2014 Ram 2500 Pick Up

More information

M.I.L. "ON" DTC P0101, P0121, P0171, P0172, P035#, P223#

M.I.L. ON DTC P0101, P0121, P0171, P0172, P035#, P223# T-SB-0379-08 November 26, 2008 M.I.L. "ON" DTC P0101, P0121, P0171, P0172, P035#, P223# Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN March 9, 004 Title: Models: 03 04 4Runner BO005-04 BODY TSB REVISION NOTICE: April 8, 004: A note has been added to step 4 on page 3 to clarify the removal of the roof rack.

More information

VOLUNTARY SERVICE CAMPAIGN

VOLUNTARY SERVICE CAMPAIGN GROUP Service Campaign NUMBER MODEL 2015 MY Sedona (YP) (EX, SX & SXL) DATE SC109 (REV 1, 12/19/2014) December 2014 VOLUNTARY SERVICE CAMPAIGN This bulletin has been revised to include additional information.

More information

SRS Airbag Light "ON" - B0111/B0116 Open Side Squib Circuit

SRS Airbag Light ON - B0111/B0116 Open Side Squib Circuit T-SB-0069-12 May 1, 2012 SRS Airbag Light "ON" - B0111/B0116 Open Side Squib Circuit Service Category Vehicle Interior Section Supplemental Restraint Systems Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL

More information

THE StarSCAN FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET.

THE StarSCAN FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET. NUMBER: GROUP: 18-003-07 REV. A Vehicle Performance DATE: March 7, 2007 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be

More information

THE witech SOFTWARE LEVEL MUST BE AT RELEASE OR HIGHER TO PERFORM THIS PROCEDURE.

THE witech SOFTWARE LEVEL MUST BE AT RELEASE OR HIGHER TO PERFORM THIS PROCEDURE. NUMBER: 18-006-12 GROUP: Vehicle Performance DATE: February 04, 2012 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

THE StarSCAN FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET.

THE StarSCAN FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET. NUMBER: GROUP: 18-006-08 REV. A Vehicle Performance DATE: April 8, 2008 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be

More information

Secondary Air Injection System - Water Intrusion: MIL "ON" DTC P0418, P0419, and/or P244#

Secondary Air Injection System - Water Intrusion: MIL ON DTC P0418, P0419, and/or P244# T-SB-060- October 7, 20 Secondary Air Injection System - Water Intrusion: MIL "ON" DTC P048, P049, Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S)

More information

Market USA. The information contained in this bulletin supersedes SB No. EG

Market USA. The information contained in this bulletin supersedes SB No. EG T-SB-0231-12 November 29, 2012 Service Category Engine/Hybrid System Section Cooling Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2004 2007 Prius SUPERSESSION NOTICE The information

More information

THE DRBIII FLASH FILES FOR THIS BULLETIN ARE AVAILABLE ON DealerCONNECT.

THE DRBIII FLASH FILES FOR THIS BULLETIN ARE AVAILABLE ON DealerCONNECT. NUMBER: 18-033-04 GROUP: Vehicle Performance DATE: August 20, 2004 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

Noise from Auxiliary Port with External Device

Noise from Auxiliary Port with External Device T-SB-0067-08 May 2, 2008 Service Category Audio/Visual/Telematics Section Audio/Video Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2008 4Runner, Prius, RAV4 2007 Camry, Camry HV,

More information

FOR HELP WITH USING witech FOR ECU FLASH REPROGRAMMING, CLICK ON THE APPLICATION S HELP TAB.

FOR HELP WITH USING witech FOR ECU FLASH REPROGRAMMING, CLICK ON THE APPLICATION S HELP TAB. NUMBER: 21-019-17 GROUP: and Transfer Case DATE: April 22, 2017 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

ATF Leak from Transfer Case

ATF Leak from Transfer Case T-SB-0335-08 November 3, 2008 Service Category Drivetrain Section Transfer/4wd/Awd Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Highlander Drive Type(s): 4WD Engine(s): 2GR Transmission(s):

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN Title: Models: 01 03 Sequoia TSB UPDATE NOTICE: The information contained in this TSB supercedes TSBs AC001 01 and AC001 02. The previous TSBs, AC001 01 and AC001 02, should

More information

Entune Audio Head Unit Software Update (Pioneer)

Entune Audio Head Unit Software Update (Pioneer) T-SB-0047-14 July 23, 2014 Service Category Audio/Visual/Telematics Section Audio/Video Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2014 4Runner, Camry, Camry HV, Highlander, Highlander

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN November 10, 2005 Title: Models: 05 Tacoma SU002-05 SUSPENSION TSB REVISION NOTICE: November 11, 2005: Production Change Production Change Effective VINs have been updated. Warranty

More information

THE witech SOFTWARE LEVEL MUST BE AT OR HIGHER TO PERFORM THIS PROCEDURE.

THE witech SOFTWARE LEVEL MUST BE AT OR HIGHER TO PERFORM THIS PROCEDURE. NUMBER: 21-001-15 GROUP: and Transfer Case DATE: January 10, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

Technical Service Bulletin

Technical Service Bulletin SUBJECT: group model Engine Sorento (XM) 2.4L GDI 2013MY NUMBER DATE 126 [Rev 1, 12/11/12] November 2012 Technical Service Bulletin This bulletin has been revised to include additional information. New/revised

More information

Technical Service BULLETIN

Technical Service BULLETIN Technical Service BULLETIN September 16, 2002 Title: Models: 01 02 Sequoia BR005-02 BRAKES TSB REVISION NOTICE: March 5, 2004: A torque specification on page 9, step 24, was changed. September 8, 2003:

More information

Wind (Reed/Buzz) Noise From Front Doors - Cross- Wind Conditions

Wind (Reed/Buzz) Noise From Front Doors - Cross- Wind Conditions T-SB-0170-16 Rev1 December 2, 2016 Wind (Reed/Buzz) Noise From Front Doors - Cross- Wind Conditions Service Category Vehicle Exterior Section Door/Hatch Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL

More information

Side Window Glass Noise During Operation

Side Window Glass Noise During Operation T-SB-0077-12 May 21, 2012 Service Category Vehicle Exterior Section Window/Glass Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 Camry, Camry HV Introduction Some 2012 Camry and Camry

More information

THE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE.

THE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE. NUMBER: 18-095-15 GROUP: Vehicle Performance DATE: November 25, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

THE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE.

THE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE. NUMBER: GROUP: 21-021-15 REV. E Transmission and Transfer Case DATE: October 01, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication

More information

Instrument Panel Rattle Noise

Instrument Panel Rattle Noise T-SB-0333-08 Rev1 November 3, 2008 Service Category Vehicle Interior Section Interior Panels/Trim Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 Corolla, Matrix TSB REVISION NOTICE

More information

Title: FRONT BRAKE VIBRATION Models: Tundra. Front Brake Caliper & Rotor Replacement (2WD, Both Sides)

Title: FRONT BRAKE VIBRATION Models: Tundra. Front Brake Caliper & Rotor Replacement (2WD, Both Sides) Technical Service BULLETIN September 16, 2002 Title: FRONT BRAKE VIBRATION Models: 00-03 Tundra BR004-02 BRAKES TSB REVISION NOTICE: S March 5, 2004: A torque speification on page 10, step 24, was changed.

More information

THE DRBIII FLASH FILES FOR THIS BULLETIN ARE AVAILABLE ON DealerCONNECT.

THE DRBIII FLASH FILES FOR THIS BULLETIN ARE AVAILABLE ON DealerCONNECT. NUMBER: GROUP: 18-006-04 REV. B Vehicle Performance DATE: September 13, 2004 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication

More information

THE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE.

THE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE. NUMBER: 18-057-15 GROUP: Vehicle Performance DATE: July 25, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

TECHNICAL SERVICE BULLETIN

TECHNICAL SERVICE BULLETIN File Under: x GROUP FUEL NUMBER Circulate To: General Manager Service Manager Parts Manager x Service Advisor(s) x x x x MODEL 2014MY Forte (YD) w/2.0l GDI DATE 027 (REV 1, 11/15/2013) November

More information

2GR-FE Engine Ticking Noise and / or MIL ON P0014, P0015, P0024, P0025, P0017, or P0018

2GR-FE Engine Ticking Noise and / or MIL ON P0014, P0015, P0024, P0025, P0017, or P0018 T-SB-0094-09 March 19, 2009 2GR-FE Engine Ticking Noise and / or MIL ON P0014, P0015, P0024, P0025, Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S) MODEL(S)

More information

High Beam/DRL Bulb Inoperative

High Beam/DRL Bulb Inoperative T-SB-0044-10 Rev2 January 27, 2010 Service Category Vehicle Exterior Section Lighting (ext) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 2010 Avalon TSB REVISION NOTICE October

More information

Zoom and Print Options

Zoom and Print Options 1 of 6 11/16/2017, 7:43 PM Vehicle» Powertrain Management» Computers and Control Systems» Engine Control Module» Technical Service Bulletins» All Technical Service Bulletins» Campaign SA120 - MIL ON/DTC

More information

6-Speed Manual Clutch Release Bearing Squeak or Rattle Noise

6-Speed Manual Clutch Release Bearing Squeak or Rattle Noise T-SB-0365-10 December 22, 2010 6-Speed Manual Clutch Release Bearing Squeak or Rattle Noise Service Category Drivetrain Section Manual Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL

More information