tons. Class 1 - sit-down type SPECIFICATIONS

Transcription

1 .0. tons Class sitdown type SPECIFICATIONS

2 STANDARD SPECIFICATIONS STANDARD SPECIFICATIONS LOAD CHART Characteristics Dimensions Performance Weight Chassis Electric Motors and Control Manufacturer Load Capacity Power Type Control Type Tire Type Wheels ( X = driven) Maximum Fork Free Lift Fork Size Tilt Angle Length to Fork Face Overall Width Fork Lowered Overall Fork Overhead Guard Turning Radius (Outside) / / L x W x T Fwd / Bwd Fork Overhang(Centerline of front axle to front face of forks) Right Angle Stacking Aisle pallet x (clearance = 00 ) 7 Speeds 7 Drawbar Pull ) Gradeability ) Total Weight (out battery) Weight Distribution ( STD capacity battery) Tires 7 Wheelbase Tread Ground clearance Brake Battery ) (STD capacity type) 7 Electric Motors Control Type Operating Pressure ) Travel ) (Fwd / Rvs.) Lifting ) Lowering momentary / continuous / out Load Number Size / at lowest point Frame Service Parking Voltage / Capacity(hour rating) Weight case Drive motor(ac) Hydraulic motor(ac) Steering mortor(dc) Drive Load handling Power steering For Attachment km/h km/h /s /s /s /s kn % V / AH kw / 0min. kw / min. kw / 0min. MPa(/cm ) UNICARRIERS FB0(T) FB(T) FB(T) FB0(T) FB(T) Battery Sit Down Rider Type Pneumatic x / 0 x x x x / ( ) ) ( ) ) 00 (700 ) ) (7 ) ) 070 ( ) ) (70 ) ) /.0. /.. / 0.0. / /.00 0PR.00PR x PR x 0PR 0 0 x 7 PR Hydraulic Foot pedal Mechanical Hand lever / 0 / 0 / / () ) FET chopper.7 (0) ) 7. (7) UNICARRIERS FBLB(T) FBV(T) FB0(T) FB0V(T) FBS(T) Battery Sit Down Rider Type x x (0 ) ) /.. /.7 / x / x x (0 ) ) x PR x 7 PR /..0 / Pneumatic ( ) ) /.7 / Hydraulic Foot pedal Mechanical Hand lever /.0 x PR x 7 PR 7 / 0. FET chopper 7. (7) 0..0 Pneumatic/SE 70 x 0 x 0 / (0 ) ) (0 ) ) / PR x 7 (SE) 00 7 / FB0(T) FB(T) FB(T) CAPACITY () FB FB FB LOAD CENTER () FB0(T) FB(T) / LB(T) / V(T)FB0(T) / V(T) FB0 CAPACITY () FB FB0 FBS(T) FB CAPACITY () LOAD CENTER () LOAD CENTER () NOTES: Meets following major standards and code: ISO Counter Balanced Lift Trucks, Stability & Safety Test (Int'l) JIS D00 Industrial Lift Trucks (Japan) ISO D0 Stability & Safety Test (Japan) Overhead guard meets ISO 0, JIS D0 NOTE: ) Above figures are measured at "Supermode" operation ) Computed Values ) Batteries are optional equipment ) For European and Scandinavian export trucks ) Figures are given for trucks optional EPS ) Fingertip control 7.MPa(7/cm )

3 WIDE VIEW MAST Wide View VM Wide View VM FB0(T) FB0(T) Capacity at : Overall Tilting Angle FB(T) FB(T) Fork Lowered FB(T) FB(T) Service Weight ( battery) FB0(T) FB(T) FB(T) FB0(T) Capacity at : Overall Tilting Angle FB0(T) FB(T) FB(T) FBLB(T) FB0(T) FB0(T) Fork () FBLB(T) FBV(T) FB0V(T) ()Lowered FBV(T) FB0V(T) Service Weight ( battery) FB0(T) FB(T) FBLB(T) FBV(T) FB0(T) FB0V(T) VM VM00 0 VM VM VM70 VM00 VM VM70 VM00 VM0 () VM VM0 VM * VM * 700 VM0 0 * 0 * 7 VM0 * 7 VM *0 7 0 * 7 VM 0 * 0 0 * 0 00 * * 0 7 VM 0 *0 0 * 00 * * 0 0 VM 0 * *0 * * 7 7 VM0 *0 * *00 0 * 70 VM0 * *700 *0 0 * 7 *0 *00 * 700 * 70 0 *00 * * 700 * NOTE: The load chart for trucks Unique solid tires is a specialorder item. NOTE: () Figures for (t,.t model) +. For (t model) +0;The figure in parentheses is given for model LB. () Figures for (t,.t model). For (t model) +0 The load chart for trucks Unique solid tires is a specialorder item. Wide View Full Free stage VFM VFM00 VFM0 VFM70 VFM00 VFM0 VFM0 VFM70 VFM0 VFM VFM Wide View Full Free stage VFHM Capacity at : VFHM0 VFHM0 VFHM VFHM0 VFHM VFHM0 VFHM00 FB0(T) 0 *0 FB0(T) *00 *70 FB0(T) 0 FB0(T) Capacity at : FB(T) * FB(T) * 00 * *00 00 *00 0 * FB(T) 00 FB(T) 70 FB(T) 0 * *0 * FB(T) * *0 * 0 * 0 *0 FB(T) 0 00 FB(T) Fork Fork Overall () Lowered NOTE: ()For height out backrest: 70 ()For free lift out backrest: +70 ()Weight for out backrest: The load chart for trucks Unique solid tires is a specialorder item. Overall () Lowered NOTE: ()For height out backrest: 70 ()For free lift out backrest: +70 ()Weight for out backrest: The load chart for trucks Unique solid tires is a specialorder item. ()Free lift ()Free lift 7 Tilting Angle ()Service Weight ( battery) FB0(T) FB(T) FB(T) * 77 0 * * * 0 70 Tilting Angle ()Service Weight ( battery) * * * * * FB0(T) FB(T) FB(T) Wide View Full Free stage VFM VFM00 VFM0 VFM70 VFM00 VFM0 VFM0 VFM70 VFM0 VFM VFM NOTE: () Figures for (t,.t model). For (t model) +0 () Figures for (t,.t model). For (t model) +0 For height out backrest: 7 (t,.t model), (t model) Wide View Full Free stage VFHM Capacity at : Overall Tilting Angle Service Weight ( battery) ()Free lift FB0(T) FB(T) FB(T) FBLB(T) FB0(T) FB0(T) Fork () FB0(T) FB0(T) FBLB(T) FBV(T) FB0V(T) ()Lowered FB0(T) FB(T) FBLB(T) FBV(T) FBV(T) FB0V(T) FB0V(T) VFHM0 VFHM0 VFHM VFHM0 VFHM VFHM0 VFHM00 Capacity at : Overall Tilting Angle Service Weight ( battery) ()Free lift FB0(T) FB(T) FB(T) FBLB(T) FB0(T) FB0(T) Fork () FB0(T) FB0(T) FBLB(T) FBV(T) FB0V(T) ()Lowered FB0(T) FB(T) FBLB(T) FBV(T) FBV(T) FB0V(T) FB0V(T) * 0 7 * * 0 0 * 0 00 * * 7 0 * *0 * * *0 700 *00 *00 *700 0 * NOTE: () Figures for (t,.t model) +. For (t model) +0 () Figures for (t,.t model). For (t model) +0 For height out backrest: (t,.t model), 0 (t model) *0 0 *00 *0 0 * * * 00 *0 00 *70 0 *00 * () Figures for (t,.t model). For (t model) For free lift out backrest: +7 (t,.t model), + (t model) Weight for out backrest: 0 (t,.t model), 0 (t model) The load chart for trucks Unique solid tires is a specialorder item * * ) Figures for (t,.t model) +. For (t model) For free lift out backrest: + (t,.t model), + 0 (t model) Weight for out backrest: 0 (t,.t model), 0 (t model) The load chart for trucks Unique solid tires is a specialorder item NOTE: Rated capacity (* ): Shows capacity front dual tires. Service weight dual tires: + dual tires (.0PR"J"). Service weight of VM000 represents the weight of vehicles equipped "dual tires". Lifting speed VFM/VFHM mast: VFM (t model) /s load. /s out load. (.t model) /s load. /s out load. (.t model) 0/s load. /s out load. VFHM (t model) /s load. 0/s out load. (.t model) /s load. 0/s out load. (.t model) 0/s load. 0/s out load. Lowering speed VFM/VFHM mast: 0/s load. 0/s out load. Overall vehicle length VFM mast: +0 longer than of standard model VM mast. VFHM mast: +0 longer than of standard model VM mast. NOTE: Rated capacity (* ): Shows capacity front dual tires. Service weight dual tires: for (t,.t model) +70 dual tires (.00PR). for (t model) + dual tires (.000PR"J"). Service weight of VM000 represents the weight of vehicles equipped "dual tires". Lifting speed VFM/VFHM mast: VFM (t model) /s load. /s out load. (.t model) /s load. /s out load. (t model) /s load. 0/s out load. VFHM (t model) /s load. /s out load. (.t model) 0/s load. /s out load. (t model) /s load. /s out load. Lowering speed VFM/VFHM mast: (t,.t model) 0/s load. 0/s out load. (t model) 0/s load. 00/s out load. Overall vehicle length VFM mast: +0 (t,.t model) longer than of standard model VM mast. VFHM mast: +0 (t,.t model), + (t model) longer than of standard model VM mast.

4 WIDE VIEW MAST DIMENSIONS INSTRUMENTS & CONTROLS Wide View VM VM00 VM0 VM70 VM00 VM0 VM0 VM70 VM0 VM VM VM0 Capacity at : FBS(T) 0 *00 *0 Fork NOTE: Rated capacity (* ): Shows capacity front dual tires. Wide View Full Free stage VFHM Lowered 7 Overall Tilting Angle * * * Service Weight ( battery) FBS(T) a RASA 0 a RASA= a (a=00) Operator's seat. Horn switch. Steering wheel. Directional control lever. Parking brake lever. Brake pedal 7. Accelerator pedal. Turn signal & lighting switch. Lift lever 0. Tilt lever. Starter switch. Charge operation panel (Optional). Super equalizing charge switch (Optional). LCD panel. Key pad VFHM0 Capacity at : FBS(T) 0 Fork 00 Overall Lowered 0 Free lift Tilting Angle Service Weight ( battery) FBS(T) 70 Groundclearance () Frame axle axle Counter weight FB0(T) FB0(T) FBLB(T) FB0(T) FBS(T) FB(T) FB(T) FBV(T) FB0V(T) FB(T) VFHM0 VFHM VFHM0 VFHM VFHM0 VFHM00 BATTERY BATTERY SELECTION TABLE (option) Battery voltage / capacity (hr) / 0 / 0 / 0 / / 0 *0 * 00 *00 0 * *00 Battery case size (Inside L x W x H ) x x 0 0 FB0(T) FB(T) FB(T) 7 x x 7 x 0 x x x 7 x x / x x 7 x x / / 00 7 x 0 x / 700 x 0 x / x 0 x / 7 x 0 x 7 / x 0 x 7 / 7 x 0 x 7 / x 0 x 7 / 7 x 0 x Battery weight range (Min.~) 00~7 ~0 0~ FB0(T) FB(T) FBLB(T) FBV(T) FB0(T) FB0V(T) 700~0 0~0 0~ ~ NOTE : Battery case, bonnet, side panels and relative individual components are changed as compared standard capacity type. NOTE: Lifting speed VFHM mast: (.t model) 0/s load. 0/s out load. Lowering speed VFHM mast: (.t model) /s load. 0/s out load : Standard capacity type,: High capacity type FBS(T) 00~ STANDARD DIMENSIONS MODEL Overall height, fork raised ( backrest) Maximum fork height height, fork lowered height Free lift Fork thickness Minimum underclearance Overall length ( forks) Overall length (out forks) Fork length Fork overhang Wheelbase overhang Drawbar height Steering wheel height* Overhead guard clearance (from face of seat)** Overall height (overhead guard)** Overall width Lateral fork adjustment (outside) Tread (front) Tread (rear) Fork width Outside turning radius Minimum intersecting aisle Tilt angles (forwardbackward) FB0(T) ~ (700 ) ) FB(T) ~ (700 ) ) FB(T) ~ 0 0 (7 ) ) 70 FB0(T) ~ ( ) ) FB(T) ~ 00 (70 ) ) FBLB(T) FBV(T) 0 (00) (0) 0 () ~ (0 ) ) FB0(T) FB0V(T) () () 0 ~ 0 ( ) ) 00 NOTE: ( ) for V models * In Scandinavian export trucks +70 except V model ** In European and Scandinavian export trucks +0 except V model ) Figures are given for trucks optional EPS NOTE: ) Figures are given for trucks optional EPS FBS(T) ~ 0 0 (0 ) ) 0 0 DIMENSIONS WITH FRONT DUAL DRIVE WHEELS (option) MODEL Tire size (front dual) Service weight FB0(T).0PR + FB(T).0PR + FB(T).0PR + FB0(T).00PR +70 FB(T).00PR +70 FBLB(T) FBV(T).00PR +70 FB0(T) FB0V(T).000PR + FBS(T).000PR +0 Overall width Tread (front) Outside turning radius ( ) ) ( ) ) 0 ( ) ) (70 ) ) 0 ( ) ) 0 (0 ) ) 0 (0 ) ) 0 (0 ) ) Minimum intersecting aisle

5 STANDARD EQUIPMENTS AND ACCESSORIES [Equipment] Antiroll back system Asbestosfree brake Auto power off system (PAO) Brake fluid reservoir tank Cylinder type bonnet stay locking function Deluxe suspension seat safety belt ) Drawbar device Durable overhead guard Fork length:0 (.ton), (.ton) ITA Class, carriage Level gauge for hydraulic oil Lift circuit cutoff valve Load backrest (BRE) Load check valve Orbitrol fullyhydraulic power steerig Regenerative braking system Return hydraulic filter Riblug tires Shock less liftcylinder Suction hydraulic strainer Tilt adjustable steering post Tilt lock valve Traveling interlock system ) Wide view mast spool control valve pressure relief valve OPTIONAL LOADING ATTACHMENTS Fork extension sleeves (EF) Fork positioner (hydraulic, manual type) (FS,FSM) High, wide type load backrest Load grab (LG) Load pushpull (PPC) Load stabilizer (STA) Long forks (LF) Rotating forks (hookon, integral type) (RF) Rotating paper roll clamp (PR) Side shift (hookon, integral type) (SS) Sleevein hook Turna fork Wide type fork carriage (WF) Wide view full free stage (VFM) mast Wide view full free stage (VFHM) mast Others on request [Controls] Electric controlled direction change lever Lift and tilt levers Parking brake system interlock Power mode (Super / Power / Economy) select switch Speed control (SC) switch Turn signal lights selfcancelling mechanism [Accessories] Backup buzzer Document clip Document holder Electoric horn combination lights (turn signal, clearance) Head lights Hand grip Highmounted rear combination lights (tail, brake, backup, turn signal and reflector) Large rubber floor mat Operator tool kit Side view mirrors OPTIONAL EQUIPMENTS AND ACCESSORIES [Equipment] Auxiliary hyd.valve modules (SV SV) Battery ) Battery chargers Central battery electrolyte refilling system (BCW) Coldstorage & fishery package (ºC, ºC) (FCS, FCS) Coldstorage package (ºC) (CS) Color solid tire (white, green) Electric power steering (EPS) F / R direction lever RH type (LCR) Fingertip control (FITSV FITSV) Fishery industry package (FC) dual drive wheels High profile overhead guard (HGH00) ) Leaser pointer Oilfilled lift cylinder (RTL) Solid tires (Unique cushion, Softone) Travel & loading interlock system (SIL) ) Windowshield wiper (AW07) brake pedal configuration (BK) Note : )Except V model trucks ) Standard specification for EXC, EXE & EXN configulation ) Refer to the battery selection table [Instruments and Switch] Combined type switch lever (lighting & turn signal) Main key switch (LCD digital display) Battery charge / discharge level indicator Battery discharge warning indicator Contoroller overheat warning indicator Drive motor overheat warning indicator Hourmeter Neutral indicator & safety warning Ope. Seat switch ) Parking brake indicator Power mode (Super / Power / Economy) indicator Selfdiagnostic function display Speed control (SC) operating indicator Speedometer (SM) [Accessories] Battery container hoisting bracket Beacon light,interlocked backup alarm (BBR) Buckup buzzer volume switch (BBA) Center rearview mirror (BMC) Chime (buzzer) for forward travelling (TAF) Custom coloring paint (P) Fire extinguisher (FE) Head light guard (HLG) LED beacon light (yellow & red) (RLR,RLY) Overhead guard canvas (HGC) working light (RWL) Rustproof painting (PRR) Steel net (for overhead guard) (HGD) ) Tilt cylinder boots (TLB) UniCarriers Corporation retains the right to change these products and specifications out incurring any obligation relating to such changes. These products and specifications are subject to change out notice. Photos and illustrations may or may not include optional equipment and accessories. Features and specifications may vary depending on markets. Produced in ISO certified factory. UniCarriers Corporation Bellport E,7,MinamiOi,Shinagawaku Tokyo,Japan TEL:+70 CATALOGUE No. BS07P0/E (SPEC) Printed in Japan SI070