Illustrated Parts List YTH 1848 XP A

Size: px

Start display at page:

Download "Illustrated Parts List YTH 1848 XP A"

Curtis Byrd
5 years ago
Views:

1 Illustrated Parts List I YTH 14 XP A 9470 Repair Parts Manual Ride Mower

2 SCHEMATIC RED BATTERY SOLENOID A AMMETER (OPTIONAL) RED WHITE RED FUSE WHITE C G RED WHITE RED M STARTER B G L S M A1 A2 CLUTCH / BRAKE (PEDAL UP) RED B F H RED ELECTRIC CLUTCH IGNITION SWITCH ORANGE SEAT SWITCH (NOT OCCUPIED) A E D PTO (DISENGAGED) 7 7A 0 GREEN GREEN BLUE HOUR METER OPERATOR PRESENCE RELAY #1 BLUE FUEL LINE (OPTIONAL) IGNITION UNIT SPARK PLUGS GAP (2 PLUGS ON TWIN CYL. ENGINES) FUEL SHUT-OFF SOLENOID CHARGING SYSTEM OUTPUT 1 AMP 00 RPM 2 VOLTS 00 RPM (REGULATOR DISCONNECTED) RED REGULATOR ALTERNATOR BROWN WIRING INSULATED CLIPS NOTE: IF WIRING INSULATED CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING. HEADLIGHTS G F C IGNITION SWITCH POSITION CIRCUIT MAKE OFF M+G+A1 NONE RUN/LIGHT B+A1 A2+L RUN B+A1 NONE START B + S + A1 NONE PTO SWITCH POSITION CIRCUIT OFF C + G, B + H ON C + F, B + E, A + D NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS 7 7A 0 RELAY H D E A B

3 ELECTRICAL D.C. AMPERES

4 ELECTRICAL Battery 12 Volt AMP Bolt Hex Hd 1/4-20unc X / Tray Battery Bolt Brt Frt 1/4-20 x 7 Ainc Holddown Battery Front Mount Nut Push Nylon 1/4" Battery Frt Switch Interlock Push-In Harness Asm Light W/412j Bulb Light # Cable Battery Ga " red Cable Battery Ga 22" red w/1 wire 2171 Fuse Nut Keps Hex 1/4-20 Unc Cable Ground Ga 21" black Switch Plunger Nc Gray Switch Ign Key Ign Molded Generic Harness Ign Bolt Blk Fin Hex 1/4-20 x 1/ Cover Terminal Red Solenoid Ammeter Rectangular 1 Amp Meter Hour Switch PTO Ring Retainer TTO Screw Thdrol /1-1 x 1-1/2 Tyt Relay Asm Bracket Snap-In Hourmeter NOTE: All component dimensions given in U.S. inches. 1 inch = 2.4 mm. 1

5 CHASSIS AND ENCLOSURES

6 CHASSIS AND ENCLOSURES Chassis Stamping Drawbar Screw /-1x/ Bumper Dashboard Bolt Rdhd Sqnk /-1 Unc x Panel Dash Lh Clip Tinnerman Grille Panel Dash Rh Screw Thdrol /-1 x 1/ Hood Bumper Plate Mtg Battery/Fuel Tank Bushing Washer 1/2 x 1/1 x 12 Ga Nut Lock w/insert /-1 UNC Grille Lens Asm 2174 Lens Fender Bracket Screw Thdrol /1-1 x 1/ Bracket Asm Pivot Mower Rear Nut Lock w/insert 1/ Washer 9/2 x 7/ x 1 Ga Bracket Grille Lh Screw Hex Wshd -1 x 7/ Bracket Grille Rh Bolt Fin Hex 1/4-20 Unc x /4 212 Duct Air Bolt RDHD SQNK /-1 x / Dash Lower Stlt Nut Crownlock / Plate Reinforcement Stlt Bracket Swaybar Chassis Bracket Ft Rest Rod Pivot Chassis Hood Cupholder YTGT Grey Bolt Shoulder /1-1 TT Screw Thdrol /1-1 x 1/2 TYTT Screw Thdrol /-1 x 1/2 Ty-TT Insert Lens Reflect NOTE: All component dimensions given in U. S. inches. 1 inch = 2.4 mm

7 DRIVE

8 DRIVE Transaxle, Hydro (Order Parts From Transaxle Manufacturer) 21 Rod Shift Fender Adjust STLT Clutch Elecric Pin Cotter 1/ x 1 CAD Washer Lock Hvy Helical Bolt Hex /1-1 Unc Flghd Nut Lock Hex W/Ins. /1-1 Unc P Washer 1-1/2 x 1/ Nut Lock Hex W/Ins /-1 Unc Bolt, Hex 7/1-20 x 4-1/4 Ga Knob Deluxe 1/2-1 UNC BLK/BLK Rod, Brake Hydro Bracket Asm Mtg CL Nut Hex Jam /-1 UNC Spring, Brake Rod 191 Washer Pin Cotter 1/ x /4 CAD Rod, Parking Brake Cap,Parking Brake Bracket, Transaxle Bolt Hex Hd /1-1 Unc x / Shaft, Foot Pedal Bearing, Nylon 1921 Washer Pin, Roll 219 Pulley, Composite, Flat Bolt, Fin, Hex /-1 x Spacer Split Keeper, Belt Idler Washer 1/2 x 1/1 x 12 Ga Pulley, Idler, V-Groove Plastic Bellcrank Clutch Grnd Drv STL Retainer, Belt Style Spring Bolt Hex Hd /-1 Unc x 1-1/ Nut Link, Clutch Spring, Return, Clutch Screw /-1 x V-Belt, Ground Drive Keeper, Center Span Screw /-1 x / Cover, Pedal Pulley, Clutch Elect Washer Lock Hvy HLCL Spr 7/ Keeper Belt Engine Strap Torque Lh Hydro Strap Torque Rh Hydro Spacer, Axle Washer 2/2 x 1-1/4 x 1 Ga E-Ring Key, Square Washer 2/2 x 1-/ x 1 Ga Shaft Asm Cross Tapered Spring Torsion T/A Washer 17/2 x /4 x 1 Ga Link Transaxle Console, Shift Nut Self Thd 1/ Control Asm. Bypass Hydro Retainer Spring 1" Zinc/Cad Bolt Rdhd Sqnk /-1 Unc x Nut Lock Flg / Spacer Retainer Washer 1/2 x 2 x 10 Ga Washer Srrted /1ID x Bracket Shift Mount Hub Tapered Flange Shift Lt Bolt Rdhd Sqnk 1/4-20 x /4 Gr Nut Crownlock 1/4-20 Unc Bolt Hex Fin 1/4-20 Unc x 1 Gr Washer / x.21 x 10 Ga Bracket Pivot Lever Screw /1-1 x / Bolt Shoulder /1-1 x Plate Fastening STLT/CRD Nyliner Snap /" ID Washer Nyl 7/ ID x.10 Hyd Bolt Shoulder /1-1 Unc Bolt Rdhd Sqnk /1-1 Unc x Bolt Nut Hex Flange Lock NOTE: All component dimensions given in U.S. inches 1 inch = 2.4 mm

9 STEERING ASSEMBLY

10 STEERING ASSEMBLY Wheel Steering Axle Cast Lt Machined Spindle Asm LH Spindle Asm RH Bearing Race Thrust Harden Washer 2/2 X 1-/ X 1 Ga Ring Klip #t Link Drag Washer Lock Hvy Hlcl Spr / Spacer Brg Axle Front Nut Hex Flange Lock Shaft Asm Strg Screw /-1x/ Rod Tie Ball J Washer /2 x /4 x 1 Ga Washer Lock Hvy Helical / Nut Crown Lock /1-24Unf Bushing Strg Screw 21 Insert Cap Strg Wh Washer 1/2 x 1-1/20 x Ga Lock nut Adaptor Wheel Strg Boot Steering Shaft Washer 2/2 X 1 1/4 X 1 Ga Extension Steering Shaft LR/LT Cap Spindle Fr Top Blk Nut Lock Hex w/ins / Bolt Fin Hex /1-1 Unc x 1-1/ Bolt Fin Hex /-1unc x 1 Gr Spacer Brace Axle Bolt Rdhd Sq /-1 x 2-1/ Axle, Brace Steering Asm Bracket Susp Chassis Front Washer Flat.71 x 1-1/2 x Bolt Shoulder 7/ Clip Steering NOTE: All component dimensions given in U.S. inches. 1 inch = 2.4 mm. 7

11 SEAT ASSEMBLY Seat Bracket Pivot Seat Bolt Fin Hex /-1 x Washer Flat 1/2 x 1.0 x 10 Ga Clip Push-In Nut Hex w/ins. /-1 Unc Spring Seat Cprsn 2 20 Blk Zi Screw /-1 x Washer 1/2 x 1.0 x 14 Ga Pan Seat 219 Knob Seat Adj Wingnut Bracket Mounting Switch Bushing Snap Blk Nyl 0 Id Bolt Rdhd Sqnk 1/4-20x1-1/ Spacer Split 2 x. Zinc Spring Cprsn Plate Nut Lock 1/4 Lge Flg Gr Zinc Bolt Shoulder /1-1 Unc Nut Hex Lock W/Ins / Washer 17/2 X 1 -/1 X 12 Ga Bolt Shoulder /1-1 X 2 NOTE: All component dimensions given in U.S. inches. 1 inch = 2.4 mm

12 DECALS Decal Oper Inst Hyd E/F Decal Strg Wheel Logo Decal Hood RH Decal Hood LH 217 Decal Engine 2101 Decal Grille Husq 2170 Decal Warning Decal Fender Husq Decal Fender Danger E/F Decal Hood Sides Decal Clutch/Brake Decal V-Belt Schematic Decal Bat Dan/Psn Decal By Pass Lt Hydro Pad Footrest LH Pad Footrest RH Decal Handle Lft Height Adjust Manual Owner's (English) Manual Owner's (French) WHEELS & TIRES 1 2, 7 4,10, Cap Valve Tire Stem Valve Tire F Ts 1 X 0 - Service Tube Front (Service Item Only) 21 Rim Asm "front Silver Service Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel Only) 217 Rim Asm "rear Silver Service Tire R Ts 20x10- C Service Tube Rear (Service Item Only) Cap Axle Blk 1 0 X Sealant, Tire ( 10 oz. Tube) NOTE: All component dimensions given in U.S. inches 1 inch = 2.4 mm 9

13 ENGINE OPTIONAL EQUIPMENT Spark Arrester 4 40

14 ENGINE Control Throt Flg Screw Hex Thd Cut 1/4-20x/ T Engine KAWA FH1V (Order Parts from Engine Manufacturer) Muffler Asm Twin Lo-Tone Exhaust Tube 2170 Exhaust Tube Bolt /1-1unc x /4 W/Sems Shield Browning Gasket Muffler Tube Drain Oil Easy Washer Lock Ext Tooth / Shield Browning Choke Control Nut, Keps /-24 Unf Kit Spark Arrestor (Flat Scrn) Tank Fuel 0 Rear Cap Asm Fuel Top N/Lany Vented Clamp Hose Blk Pad, Spacer Line Fuel Plug Drain Oil (Order Parts from Engine Manufacturer) Pad, Idler Screw Hexwsh Thdr /-1 x / Nut Flange M Nut Keps Hex 1/4-20 Unc Screw /-1 x 1 NOTE: All component dimensions given in U.S. inches 1 inch = 2.4 mm 41

15 MOWER DECK

16 MOWER DECK Deck Weldment Mower Bracket Asm., Sway Bar Retainer Spring 2102 Arm, Suspension, Rear (Sway Bar) 2174 Bolt, 7/1 Asm. Blade Washer, Hard Blade, Mower Vented Blade Shaft Asm. greaseable Housing Mandrel 4" Bearing, Ball, Mandrel Stripper, Mower Bolt Rdhd Sq Neck /-1 x Bolt, Carriage /1-1 x / Bolt, Hex Head, Shoulder / Baffle, Vortex Mower Nut, Crownlock /1-1 UNC Cap, Sleeve Spring, Torsion 2042 Nut, Push Shield, Deflector Mower Washer /2 x / x 1 Ga Rod, Hinge Screw, Thdroll, Washer Head Washer, Spacer Mower Vented Pulley, Mandrel Nut, Flg. Top Lock Cntr. 9/1 191 Washer 1/2 x 1/1 x 1 Ga Pulley, Idler, Flat Pulley, Idler, Driven Spacer, Retainer Arm, Idler Secondary Cover, Mandrel Deck Screw, Thdroll. 1/4-20 x / V-Belt, Mower, Secondary V-Belt, Mower, Primary Nut, Crownlock /-1 UNC Bolt, Carriage /-1 x 1-1/2 Gr Pulley Idler Flat 4 Pri. Drive Bolt Fin Hex /-1 x Bolt Rdhd Sqnk /-1 x Bar Pnt Adjusting Wheel Gauge Pin Head Rivet Washer 1/2 x 1/1 x Bolt, Fin, Hex /1-1 x Bracket, Asm Noseroller, LH Nut Lock Hex w/ins / Washer 17/2 x 7/ x 1 Ga Roller, Nose 4" Bracket, Asm Noseroller RH Washer Hardened Spring Primary Drive Pulley Idler "V" Bolt RDHD Sqnk /-1 Unc x Baffle Vac Edge Mower Bolt Carr Nut Crownlock 1/ Arm Spring Secondary Link Tension Relief Lever 7200 Bolt Carr. /1-1 x Tension Asm Relief Lever Arm Spring Tension Relief Bolt, Shoulder Gauge Wheel Nut, Centerlock /-1 UNC Washer / x 7/ x 14 Ga Spring Secondary Drive Arm, Idler, Primary Deck Screw /-1 x Nut, Lock, Hex / Deck Complete (Standard Deck Order separately nose roller components) Mandrel Assembly Service (Includes Key Nos. 1-1) NOTE: All component dimensions given in U.S. inche 1 inch = 2.4 mm 4

17 MOWER LIFT

18 MOWER LIFT Wire Asm Inner/Spring W/Plunger LT Shaft Asm Lift RH w/inf Pin Groove 1 00 Zinc E Ring # Washer 21/2 X 1 X 21 Ga Bearing Nylon Blk Id 7 2 Grip Handle Fluted Blk 2124 Button Plunger Black Link Lift LH Link Lift RH Retainer Spring Plate Asm Susp Front Nut Jam Hex 1/2-1 Unc Trunnion Nut Lock w/wsh 1/2-1unc Retainer Spring Nut Special Washer 1/2 X / X 1 Ga Spring 2-1/" Retainer Clip Rod Adj Lift Zinc 7.49 Wrk Lg Nut Hex Jam /-1 Unc 2107 Knob Inf /-1 Unc Blk W/sym Trunnion Infin Height Trunnion Nut Lift Link 7/ Indicator Height STLT 7 21 Plug Hole Blk 1.4/1.1 Dia Screw /1-1 x Washer /2 x 1-1/2 10 Ga Scale Ind. Height Blk Nut Hex Flange Lock Nut, Push Phos & Oil Washer 17/2 x 7/ x 1 Ga Arm Susp. Rear Lh Arm Susp. Rear Rh Pin Flange NOTE: All component dimensions given in U.S. inches 1 inch = 2.4 mm 4

Illustrated Parts List I YTH 1848 XPD

Illustrated Parts List I YTH 1848 XPD Illustrated Parts List 2001-12 I0102047 YTH 14 XPD 9470 Repair Parts Manual Ride Mower SCHEMATIC RED BLACK BATTERY SOLENOID A AMMETER (OPTIONAL) RED WHITE RED FUSE WHITE C G RED WHITE RED M STARTER BLACK