AERO 8 PRE-DELIVERY INSPECTION CHECKLIST CHASSIS NUMBER :- CUSTOMER :- DEALER :- DATE INSPECTED :- INSPECTED BY :- ROAD TESTED BY :- MILEAGE :-

Transcription

1 AERO 8 PRE-DELIVERY INSPECTION CHECKLIST CHASSIS NUMBER :- CUSTOMER :- DEALER :- DATE INSPECTED :- INSPECTED BY :- ROAD TESTED BY :- MILEAGE :- ISSUE 4 A 1

2 TECHNICAL INSPECTION CHECK FUNCTION WITH IGNITION OFF 01) CHECK BATTERY CABLES AND MOUNTING 02) HORN 03) HEAD LAMP FLASH 04) PARKING LIGHT LEFT AND RIGHT 05) DOOR OPEN SOUNDER 06) INTERIOR LIGHT (TEN SECOND DELAY ON DOOR CLOSE) 07) HAZARD LIGHTS 08) COURTESY DELAY AND DOOR OPEN SOUNDER FUNCTION IGNITION ON WITH ENGINE NOT RUNNING 09) INTERIOR LIGHTS FADE OUT WHEN IGNITION ON 10) START BUTTON ILLUMINATED 11) IGNITION LAMP ON 12) MILL LAMP ON 13) ABS AND EBD LAMPS COME ON THEN GO OFF 14) SRS LAMP COMES ON THEN AFTER FIVE FLASHES GOES OFF 15) RIGHT INDICATOR, CHECK ON CAR AND DASH REPEATER 16) LEFT INDICATOR, CHECK ON CAR AND DASH REPEATER 17) INDICTOR SOUNDER AND ACTIVE AFTER 30 SECONDS 18) SIDE LAMPS, CHECK ON CAR AND DASH (ALSO SIDE MARKERS, IF US MODEL) 19) DIP LIGHTS AND LAMP ALIGNMENT 20) MAIN BEAM AND DASH LAMP 21) REAR FOG, CHECK ON CAR AND DASH (CHECK OFF WHEN LIGHTS ARE OFF) 22) HORN 23) BRAKE LIGHTS AND HIGH LEVEL 24) NUMBER PLATE LIGHTS 25) REVERSING LIGHTS, CHECK ON CAR 26) FRONT SCREEN WINDOW DEMIST 27) CHECK PANEL ILLUMINATION, CLOCK BACK LIGHTING DIMMER SWITCH 28) CHECK SMART TYRE SYSTEM 29) CHECK ALL INSTRUMENTS WORK AND SPEEDO CALIBRATION 30) CHECK WIPER SPEED1, 2, DELAY AND WASHERS 31) CHECK BOOT SWITCH 32) CHECK BOOT MANUAL RELEASE (IF APPLICABLE) 33) CHECK BOOT LIGHT 34) CHECK RADIO, SPEAKERS AND AERIAL 35) DEPRESS CLUTCH AND PRESS ENGINE START 36) FOOT ON CLUTCH MILL LAMPOUT 37) IGNITION LAMP OUT 38) ABS LAMP OUT 39) EBD LAMP OUT 40) SRS LAMP OUT 41) TACHOMETER = 700 / 800 RPM HIGH REVS 42) SPEEDO DISPLAY OK AND CALIBRATION 43) TEMPERATURE GAUGE 44) FUEL GAUGE 45) TIME CLOCK FUNCTIONS WITH ENGINE RUNNING 2

3 46) SEAT BELT LAMP AND SOUNDER OFF, WHEN SEAT BELT WORN 47) HANDBRAKE LAMP 48) HEATER CONTROL HOT AND COLD 49) FAN SPEEDS OK 50) AIR CON LIGHT FLASHES, WHEN FAN SWITCHED OFF 51) LIGHT STAYS ON WHEN FAN SWITCHED ON (CHECK CHILLED AIR IS PRESENT) 52) CHECK CIGARETTE LIGHTER 53) CHECK CRUISE CONTROL 54) CHECK WHEEL NUTS (70 Ft/Lbs / 95 Nm) 55) CHECK DRIVE CYCLE USING LAPTOP 56) CHECK ALL FAULT CODES 57) CHECK FAULT CODES ABS AND AIR BAGS USING MORGAN TESTER 58) CHECK CENTRAL LOCKING SYSTEM 59) CHECK ELECTRIC WINDOWS UP AND DOWN 60) CHECK WINDOW DROP SYSTEM LEFT AND RIGHT WHEN DOOR SHUT 3

4 61) HARD TOP 62) UPPER BACK PANEL 63) REAR LIGHT PANEL 64) BOOT PANEL 65) REAR WING RH 66) REAR WING LH 67) ¼ PANEL RH 68) ¼ PANEL LH 69) DOOR PANEL RH 70) DOOR PANEL LH 71) SCUTTLE 72) BONNET RH 73) BONNET LH 74) FRONT WING RH 75) FRONT WING LH 76) RUNNING BOARD RH 77) RUNNING BOARD LH 78) COWL 79) SPLITTER VISUAL INSPECTION BODYPANEL CONDITION AND ALIGNMENT 80) HARD TOP 81) UPPER BACK PANEL 82) REAR LIGHT PANEL 83) BOOT PANEL 84) REAR WING RH 85) REAR WING LH 86) ¼ PANEL RH 87) ¼ PANEL LH 88) DOOR PANEL RH 89) DOOR PANEL LH 90) SCUTTLE 91) BONNET RH 92) BONNET LH 93) FRONT WING RH 94) FRONT WING LH 95) RUNNING BOARD RH 96) RUNNING BOARD LH 97) COWL 98) SPLITTER PAINT WORK CONDITION 4

5 INTERIOR 99) IS THE TRIM FREE FROM ANY MARKS OR DEFECTS 100) SEAT UPHOLSTERY 101) SEAT BELTS 102) CARPETS 103) DOOR TRIM PANELS AND CASING BOARDS 104) TRIM IS FREE FROM INTERFERENCE WHEN CLOSING DOORS 105) BOOT CARPETS 106) INTERIOR LIGHTS 107) DASHBOARD CONDITION 108) TOTAL CLUTCH PEDAL TRAVEL 109) CLUTCH PEDAL FREE PLAY OPERATION OF LIGHTS AND INSTRUMENTS 110) HEAD LIGHTS/DIP AND MAIN BEAM 111) INDICATOR LIGHTS 112) BRAKE LIGHTS 113) COURTESY LIGHTS 114) OIL PRESSURE WARNING LIGHT 115) ALTERNATOR WARNING LIGHT 116) FRONT SEATS OPERATION 117) INSIDE LOCKS (DOORS AND HOOD HANDLES) OPERATION 118) WINDOWS OPERATION AND FIT 119) HEATER CHECK 120) WIPER FUNCTION CHECK 121) CIGARETTE LIGHTER TEST 122) RADIO FUNCTION/OPERATION 123) CHECK WINDSCREEN AND REAR WINDOW SEALS 124) CHECK DOORS AND QUARTER WINDOW GLASS SEALS 125) INTERIOR MIRROR CHECK 126) INTERIOR LIGHT WORKS PROPERLY 127) STEERING COLUMN ADJUSTMENT CHECK WEATHER EQUIPMENT 128) HOOD FIT AND CONDITION 129) FRONT RAIL TO WINDSCREEN FIT AND CATCH OPERATION 130) REAR HOOD SEAL GLUED PROPERLY AND NOT LOOSE 131) WINDOWS FIT AND EASE OF MOVEMENT 132) TOOL KIT 133) CAR CARE KIT 134) OWNERS MANUAL 135) TOUCH UP PAINT 136) ACCESSORIES CATALOGUE 137) SPARE KEYS 138) TYRE FOAM (IF REQUIRED) EQUIPMENT CHECKLIST 5