S P E C I F I C A T I O N W O R K S H E E T (INTERNAL USE ONLY)

Size: px

Start display at page:

Download "S P E C I F I C A T I O N W O R K S H E E T (INTERNAL USE ONLY)"

Darrell Stone
6 years ago
Views:

1 S P E C I F I C A T I O N W O R K S H E E T (INTERNAL USE ONLY) Price Level Data Version PRL-04D SD PRL-04D (EFF:07/26/12) DRL-019 SPECPRO21 DATA RELEASE VER 019 Vehicle Configuration SD CONVENTIONAL CHASSIS 6,830 3, MODEL YEAR SPECIFIED SET BACK AXLE - TRUCK TRAILER TOWING PROVISION AT END OF FRAME FOR TRUCK LH PRIMARY STEERING LOCATION General Service AA1-003 TRUCK/TRAILER CONFIGURATION AA6-002 DOMICILED, USA (EXCLUDING CALIFORNIA AND CARB OPT-IN STATES) A UTILITY/REPAIR/MAINTENANCE SERVICE A84-1GM GOVERNMENT BUSINESS SEGMENT AA4-010 DIRT/SAND/ROCK COMMODITY AA5-002 TERRAIN/DUTY: 100% (ALL) OF THE TIME, IN TRANSIT, IS SPENT ON PAVED ROADS AB1-008 MAXIMUM 8% EXPECTED GRADE AB5-001 SMOOTH CONCRETE OR ASPHALT PAVEMENT - MOST SEVERE IN-TRANSIT (BETWEEN SITES) ROAD SURFACE MEDIUM TRUCK WARRANTY A66-99D EXPECTED FRONT AXLE(S) LOAD : lbs A68-99D EXPECTED REAR DRIVE AXLE(S) LOAD : lbs Page 1 of 13

2 A63-99D EXPECTED GROSS VEHICLE WEIGHT CAPACITY : lbs A70-99D EXPECTED GROSS COMBINATION WEIGHT : lbs GVWR Truck Service Tractor Service Engine RATED MAXIMUM VEHICLE CAPACITY - GVWR : lbs AA3-018 FRONT PLOW/END DUMP BODY AA2-005 FLATBED TRAILER AH6-001 SINGLE (1) TRAILER 101-2N6 CUM ISB RPM, 2600 GOV, RPM Electronic Parameters A MPH ROAD SPEED LIMIT 79B-000 CRUISE CONTROL SPEED LIMIT SAME AS ROAD SPEED LIMIT 80G-002 PTO MINIMUM RPM J-002 REGEN INHIBIT SPEED THRESHOLD - 5 MPH Engine Equipment 99C ONBOARD DIAGNOSTICS/2010 EPA/CARB/GHG14 99D-010 NO 2008 CARB EMISSION CERTIFICATION ENGINE MOUNTED OIL CHECK AND FILL SIDE OF HOOD AIR INTAKE WITH FIREWALL MOUNTED DONALDSON AIR CLEANER 124-1D7 DR 12V 160 AMP 28-SI QUADRAMOUNT PAD ALTERNATOR WITH REMOTE BATTERY VOLT SENSE (2) ALLIANCE MODEL 1231, GROUP 31, 12 VOLT MAINTENANCE FREE 2250 CCA THREADED STUD BATTERIES BATTERY BOX FRAME MOUNTED STANDARD BATTERY JUMPERS SINGLE BATTERY BOX FRAME MOUNTED LH SIDE UNDER CAB WIRE GROUND RETURN FOR BATTERY CABLES WITH ADDITIONAL FRAME GROUND RETURN NON-POLISHED BATTERY BOX COVER Page 2 of 13

3 POSITIVE LOAD DISCONNECT WITH CAB MOUNTED CONTROL SWITCH MOUNTED OUTBOARD DRIVER SEAT CUMMINS 18.7 CFM AIR COMPRESSOR WITH INTERNAL SAFETY VALVE ELECTRONIC ENGINE INTEGRAL SHUTDOWN PROTECTION SYSTEM CUMMINS EXHAUST BRAKE INTEGRAL WITH VARIABLE GEOMETRY TURBO WITH ON/OFF DASH SWITCH 016-1C2 RH OUTBOARD UNDER STEP MOUNTED HORIZONTAL AFTERTREATMENT SYSTEM ASSEMBLY WITH RH B-PILLAR MOUNTED VERTICAL TAILPIPE 28F-002 ENGINE AFTERTREATMENT DEVICE, AUTOMATIC OVER THE ROAD REGENERATION AND DASH MOUNTED REGENERATION REQUEST SWITCH FOOT 06 INCH (138 INCH+0/-5 INCH) EXHAUST SYSTEM HEIGHT 237-1CR RH CURVED VERTICAL TAILPIPE B-PILLAR MOUNTED ROUTED FROM STEP U GALLON DIESEL EXHAUST FLUID TANK 30N PERCENT DIESEL EXHAUST FLUID FILL 23Y-001 STANDARD DIESEL EXHAUST FLUID PUMP MOUNTING 23Z-002 NON-POLISHED ALUMINUM DIAMOND PLATE DIESEL EXHAUST FLUID TANK COVER 43X-002 LH MEDIUM DUTY STANDARD DIESEL EXHAUST FLUID TANK LOCATION 43Y-001 STANDARD DIESEL EXHAUST FLUID TANK CAP ALUMINUM AFTERTREATMENT DEVICE/MUFFLER/TAILPIPE SHIELD(S) BORG WARNER (KYSOR) REAR AIR ON/OFF ENGINE FAN CLUTCH AUTOMATIC FAN CONTROL WITH DASH SWITCH AND INDICATOR LIGHT, NON ENGINE MOUNTED CUMMINS SPIN ON FUEL FILTER FULL FLOW OIL FILTER SQUARE INCH ALUMINUM RADIATOR ANTIFREEZE TO -34F, NOAT EXTENDED LIFE COOLANT GATES BLUE STRIPE COOLANT HOSES OR EQUIVALENT Page 3 of 13

4 Transmission CONSTANT TENSION HOSE CLAMPS FOR COOLANT HOSES RADIATOR DRAIN VALVE ELECTRIC GRID AIR INTAKE WARMER DELCO 12V 38MT HD STARTER WITH INTEGRATED MAGNETIC SWITCH ALLISON 3500 RDS AUTOMATIC TRANSMISSION WITH PTO PROVISION Transmission Equipment WTEC CALIBRATION - 6 SPEED RDS/TRV (PACKAGE 113) VEHICLE INTERFACE WIRING WITH BODY BUILDER CONNECTOR MOUNTED BACK OF CAB 34C-001 ELECTRONIC TRANSMISSION CUSTOMER ACCESS CONNECTOR FIREWALL MOUNTED CUSTOMER INSTALLED CHELSEA 277 SERIES PTO PTO MOUNTING, LH SIDE OF MAIN TRANSMISSION MAGNETIC PLUGS, ENGINE DRAIN, TRANSMISSION DRAIN, AXLE(S) FILL AND DRAIN PUSH BUTTON ELECTRONIC SHIFT CONTROL, DASH MOUNTED 97G-004 TRANSMISSION PROGNOSTICS - ENABLED WATER TO OIL TRANSMISSION COOLER, IN RADIATOR END TANK TRANSMISSION OIL CHECK AND FILL WITH ELECTRONIC OIL LEVEL CHECK 35T-001 SYNTHETIC TRANSMISSION FLUID (TES-295 COMPLIANT) Axle and Equipment 400-1A8 DETROIT DA-F ,700# FF KPI/3.74 DROP SINGLE FRONT AXLE MERITOR 16.5X5 Q+ CAST SPIDER CAM FRONT BRAKES, DOUBLE ANCHOR, FABRICATED SHOES NON-ASBESTOS FRONT BRAKE LINING CONMET CAST IRON FRONT BRAKE DRUMS SKF SCOTSEAL PLUS XL FRONT OIL SEALS Page 4 of 13

5 VENTED FRONT HUB CAPS WITH WINDOW, CENTER AND SIDE PLUGS - OIL STANDARD SPINDLE NUTS FOR ALL AXLES MERITOR AUTOMATIC FRONT SLACK ADJUSTERS STANDARD KING PIN BUSHINGS TRW TAS-85 POWER STEERING POWER STEERING PUMP QUART SEE THROUGH POWER STEERING RESERVOIR 40T-002 SYNTHETIC 75W-90 FRONT AXLE LUBE Suspension ,600# TAPERLEAF FRONT SUSPENSION GRAPHITE BRONZE BUSHINGS WITH SEALS - FRONT SUSPENSION FRONT SHOCK ABSORBERS Axle and Equipment RS ,000# R-SERIES SINGLE REAR AXLE REAR AXLE RATIO IRON REAR AXLE CARRIER WITH STANDARD AXLE HOUSING MXL 17T MERITOR EXTENDED LUBE MAIN DRIVELINE WITH HALF ROUND YOKES MERITOR 16.5X7 Q+ CAST SPIDER HEAVY DUTY CAM REAR BRAKES, DOUBLE ANCHOR, FABRICATED SHOES NON-ASBESTOS REAR BRAKE LINING BRAKE CAMS AND CHAMBERS ON FORWARD SIDE OF DRIVE AXLE(S) CONMET CAST IRON REAR BRAKE DRUMS SKF SCOTSEAL PLUS XL REAR OIL SEALS HALDEX GOLDSEAL LONGSTROKE 1-DRIVE AXLE SPRING PARKING CHAMBERS MERITOR AUTOMATIC REAR SLACK ADJUSTERS 41T-002 SYNTHETIC 75W-90 REAR AXLE LUBE Suspension 622-1DF 30,000# FLAT LEAF SPRING REAR SUSPENSION WITH HELPER AND RADIUS ROD SPRING SUSPENSION - NO AXLE SPACERS STANDARD U-BOLT PAD 160 Page 5 of 13

6 Brake System FORE/AFT CONTROL RODS WABCO 4S/4M ABS WITH TRACTION CONTROL REINFORCED NYLON, FABRIC BRAID AND WIRE BRAID CHASSIS AIR LINES FIBER BRAID PARKING BRAKE HOSE STANDARD BRAKE SYSTEM VALVES 46D-002 STANDARD AIR SYSTEM PRESSURE PROTECTION SYSTEM U.S. FRONT BRAKE VALVE RELAY VALVE WITH 5-8 PSI CRACK PRESSURE, NO REAR PROPORTIONING VALVE BW AD-9 BRAKE LINE AIR DRYER WITH HEATER AIR DRYER MOUNTED INBOARD ON LH RAIL STEEL AIR BRAKE RESERVOIRS PULL CABLES ON ALL AIR RESERVOIR(S) Trailer Connections AIR CONNECTIONS TO END OF FRAME WITH GLAD HANDS FOR TRUCK AND NO DUST COVERS PRIMARY CONNECTOR/RECEPTACLE WIRED FOR COMBINATION STOP/TURN, CENTER PIN POWERED THROUGH IGNITION WITH STOP SIGNAL PREWIRE PACKAGE SAE J560 7-WAY PRIMARY TRAILER CABLE RECEPTACLE MOUNTED END OF FRAME UPGRADED CHASSIS MULTIPLEXING UNIT Wheelbase & Frame MM (190 INCH) WHEELBASE /32X3-1/2X10-15/16 INCH STEEL FRAME (8.73MMX277.8MM/0.344X10.94 INCH) 120KSI BODY COMPANY INSTALLED ADDITIONAL FRONT FRAME REINFORCEMENT FOR SNOW PLOW MM (100 INCH) REAR FRAME OVERHANG 55W-009 FRAME OVERHANG RANGE: 91 INCH TO 100 INCH INCH INTEGRAL FRONT FRAME EXTENSION AC8-99D CALC'D BACK OF CAB TO REAR SUSP C/L (CA) : in Page 6 of 13

7 AE8-99D CALCULATED EFFECTIVE BACK OF CAB TO REAR SUSPENSION C/L (CA) : in AE4-99D CALC'D FRAME LENGTH - OVERALL : AM6-99D CALC'D SPACE AVAILABLE FOR DECKPLATE : in FSS-0LH FRAME SPACE LH SIDE : 74.1 in FSS-0RH FRAME SPACE RH SIDE : in SQUARE END OF FRAME FRONT CLOSING CROSSMEMBER STANDARD WEIGHT ENGINE CROSSMEMBER STANDARD MIDSHIP #1 CROSSMEMBER(S) STANDARD REARMOST CROSSMEMBER STANDARD SUSPENSION CROSSMEMBER Chassis Equipment Fuel Tanks Tires 556-1E5 14 INCH PAINTED STEEL BUMPER FRONT TOW HOOKS - FRAME MOUNTED BUMPER MOUNTING FOR SINGLE LICENSE PLATE CLEAR FRAME RAILS FROM TRANSMISSION PTO OPENING TO 36 INCHES BACK OF CAB OUTBOARD/INSIDE/BELOW BOTH RAILS GRADE 8 THREADED HEX HEADED FRAME FASTENERS GALLON/189 LITER SHORT RECTANGULAR ALUMINUM FUEL TANK - LH RECTANGULAR FUEL TANK(S) PLAIN ALUMINUM/PAINTED STEEL FUEL/HYDRAULIC TANK(S) WITH PAINTED BANDS FUEL TANK(S) FORWARD PLAIN STEP FINISH FUEL TANK CAP(S) 122-1F8 DAVCO 243 FUEL/WATER SEPARATOR EQUIFLO INBOARD FUEL SYSTEM HIGH TEMPERATURE REINFORCED NYLON FUEL LINE 093-1T8 GOODYEAR G662 RSA FUEL MAX 11R PLY RADIAL FRONT TIRES (MATCH MARKED) Page 7 of 13

8 Hubs Wheels 094-1DG Cab Exterior GOODYEAR G338 11R PLY RADIAL REAR TIRES TIRE QTY - PUSHER AXLE: TIRE QTY - TAG AXLE: CONMET PRE-SET BEARING IRON FRONT HUBS CONMET PRE-SET BEARING IRON REAR HUBS ACCURIDE X HUB PILOT 2- HAND HD STEEL DISC FRONT WHEELS ACCURIDE X HUB PILOT 2- HAND HD STEEL DISC REAR WHEELS 829-1A5 108 INCH BBC FLAT ROOF ALUMINUM CONVENTIONAL CAB AIR CAB MOUNTS NONREMOVABLE BUGSCREEN MOUNTED BEHIND GRILLE LH AND RH GRAB HANDLES STATIONARY BLACK GRILLE 65X-004 BLACK HOOD MOUNTED AIR INTAKE GRILLE FIBERGLASS HOOD 727-1AH SINGLE 14 INCH ROUND POLISHED AIR HORN ROOF MOUNTED SINGLE ELECTRIC HORN SINGLE HORN SHIELD 657-1A0 ALL UNIT(S) KEYED ALIKE WITH CUSTOMER SPECIFIED KEY NUMBER FT REAR LICENSE PLATE MOUNT END OF FRAME HALOGEN COMPOSITE HEADLAMPS WITH BLACK BEZELS LED AERODYNAMIC MARKER LIGHTS DAYTIME RUNNING LIGHTS - LOW BEAM ONLY INTEGRAL STOP/TAIL/BACKUP LIGHTS STANDARD FRONT TURN SIGNAL LAMPS 744-1BC DUAL WEST COAST BRIGHT FINISH HEATED MIRRORS WITH LH AND RH REMOTE DOOR MOUNTED MIRRORS INCH EQUIPMENT WIDTH Page 8 of 13

9 Cab Interior LH AND RH 8 INCH BRIGHT FINISH CONVEX MIRRORS MOUNTED UNDER PRIMARY MIRRORS STANDARD SIDE/REAR REFLECTORS NO CAB MOUNTED STEPS X14 INCH TINTED REAR WINDOW TINTED DOOR GLASS LH AND RH WITH TINTED NON-OPERATING WING WINDOWS MANUAL DOOR WINDOW REGULATORS TINTED WINDSHIELD LITER WINDSHIELD WASHER RESERVOIR, CAB MOUNTED, WITHOUT FLUID LEVEL INDICATOR 707-1AK OPAL GRAY VINYL INTERIOR MOLDED PLASTIC DOOR PANEL MOLDED PLASTIC DOOR PANEL BLACK MATS WITH SINGLE INSULATION DASH MOUNTED ASH TRAYS AND LIGHTER FORWARD ROOF MOUNTED CONSOLE WITH UPPER STORAGE COMPARTMENTS WITHOUT NETTING IN DASH STORAGE BIN (2) CUP HOLDERS LH AND RH DASH GRAY/CHARCOAL FLAT DASH SMART SWITCH EXPANSION MODULE /2 LB. FIRE EXTINGUISHER HEATER, DEFROSTER AND AIR CONDITIONER STANDARD HVAC DUCTING MAIN HVAC CONTROLS WITH RECIRCULATION SWITCH STANDARD HEATER PLUMBING WITH BALL SHUTOFF VALVES DENSO HEAVY DUTY AIR CONDITIONER COMPRESSOR BINARY CONTROL, R-134A STANDARD INSULATION SOLID-STATE CIRCUIT PROTECTION AND FUSES V NEGATIVE GROUND ELECTRICAL SYSTEM * DOME DOOR ACTIVATED LH AND RH, DUAL READING LIGHTS, FORWARD CAB ROOF Page 9 of 13

10 YES NO WOOD GRAIN DASH CAB DOOR LATCHES WITH MANUAL DOOR LOCKS (1) 12 VOLT POWER SUPPLY IN DASH TRIANGULAR REFLECTORS WITHOUT FLARES J3 BASIC HIGH BACK AIR SUSPENSION DRIVER SEAT WITH MECHANICAL LUMBAR AND INTEGRATED CUSHION EXTENSION 760-1DC BASIC HIGH BACK NON SUSPENSION PASSENGER SEAT DUAL DRIVER SEAT ARMRESTS, NO PASSENGER SEAT ARMRESTS LH AND RH INTEGRAL DOOR PANEL ARMRESTS VINYL WITH VINYL INSERT DRIVER SEAT VINYL WITH VINYL INSERT PASSENGER SEAT POINT HIGH VISIBILITY ORANGE RETRACTOR DRIVER AND PASSENGER SEAT BELTS ADJUSTABLE TILT AND TELESCOPING STEERING COLUMN SPOKE 18 INCH (450MM) STEERING WHEEL DRIVER AND PASSENGER INTERIOR SUN VISORS Instruments & Controls GRAY DRIVER INSTRUMENT PANEL GRAY CENTER INSTRUMENT PANEL BLACK GAUGE BEZELS LOW AIR PRESSURE LIGHT AND BUZZER INCH PRIMARY AND SECONDARY AIR PRESSURE GAUGES INTAKE MOUNTED AIR RESTRICTION INDICATOR WITHOUT GRADUATIONS DB BACKUP ALARM ELECTRONIC CRUISE CONTROL WITH SWITCHES IN LH SWITCH PANEL KEY OPERATED IGNITION SWITCH AND INTEGRAL START POSITION; 4 POSITION OFF/RUN/START/ACCESSORY ODOMETER/TRIP/HOUR/DIAGNOSTIC/VOLTAG E DISPLAY: 1X7 CHARACTER, 26 WARNING LAMPS, DATA LINKED, ICU DIAGNOSTIC INTERFACE CONNECTOR, 9 PIN, SAE J1939, LOCATED BELOW DASH Page 10 of 13

11 INCH ELECTRIC FUEL GAUGE ELECTRICAL ENGINE COOLANT TEMPERATURE GAUGE TRANSMISSION OIL TEMPERATURE INDICATOR LIGHT ENGINE AND TRIP HOUR METERS INTEGRAL WITHIN DRIVER DISPLAY CUSTOMER FURNISHED AND INSTALLED PTO CONTROLS ELECTRIC ENGINE OIL PRESSURE GAUGE OVERHEAD INSTRUMENT PANEL 35M-998 NO WRG-BDY MULTIPLEX EXPNSN UNIT 746-1A2 AM/FM/WB RADIO WITH FRONT AUXILIARY INPUT DASH MOUNTED RADIO (2) RADIO SPEAKERS IN CAB AM/FM ANTENNA MOUNTED ON FORWARD LH ROOF * POWER AND GROUND WIRING PROVISION WIRING UNDER CENTER OF DASH ELECTRONIC MPH SPEEDOMETER WITH SECONDARY KPH SCALE, WITHOUT ODOMETER ELECTRONIC 3000 RPM TACHOMETER IGNITION SWITCH CONTROLLED ENGINE STOP FOUR ON/OFF ROCKER SWITCHES IN THE DASH WITH INDICATOR LIGHTS AND WIRE ROUTED TO CHASSIS AT BACK OF CAB, LABEL OPT 44R-998 NO ON/OFF LATCHING SMARTPLEX SWITCH 44S-998 NO ON/OFF MOMENTARY SMARTPLEX SWITCH 44T-998 NO ON/OFF/ON LATCHING SMARTPLEX SWITCH 44U-998 NO ON/OFF/ON MOMENTARY SMARTPLEX SWITCH 44V-998 NO PRE-DEFINED SMARTPLEX INDICATOR LAMPS 44W-998 NO UNDEFINED SMARTPLEX INDICATOR LAMPS BW TRACTOR PROTECTION VALVE TRAILER HAND CONTROL BRAKE VALVE 2 Page 11 of 13

12 Design Color DIGITAL VOLTAGE DISPLAY INTEGRAL WITH DRIVER DISPLAY SINGLE ELECTRIC WINDSHIELD WIPER MOTOR WITH DELAY MARKER LIGHT SWITCH INTEGRAL WITH HEADLIGHT SWITCH AND DUAL CONNECTORS AND SWITCH FOR CUSTOMER FURNISHED SNOW PLOW LIGHTS, LOW BEAMS OFF WITH HIGH BEAMS TWO VALVE PARKING BRAKE SYSTEM WITH WARNING INDICATOR SELF CANCELING TURN SIGNAL SWITCH WITH DIMMER, WASHER/WIPER AND HAZARD IN HANDLE INTEGRAL ELECTRONIC TURN SIGNAL FLASHER WITH HAZARD LAMPS OVERRIDING STOP LAMPS PAINT: ONE SOLID COLOR 980-5F6 CAB COLOR A: L0006EB WHITE ELITE BC BLACK, HIGH SOLIDS POLYURETHANE CHASSIS PAINT VENDOR WHITE FRONT WHEELS/RIMS (PW, TKWHT21, W, TW) VENDOR WHITE REAR WHEELS/RIMS (PW, TKWHT21, W, TW) 964-6Z7 BUMPER PAINT: FP24812 ARGENT SILVER DUPONT FLEX Certification / Compliance U.S. FMVSS CERTIFICATION Sales Programs NO SALES PROGRAMS HAVE BEEN SELECTED T O T A L V E H I C L E S U M M A R Y Adjusted List Price Adjusted List Price ** Page 12 of 13

13 Summary Total Factory lbs 4412 lbs lbs Total lbs 4412 lbs lbs I T E M S N O T I N C L U D E D I N A D J U S T E D L I S T P R I C E Other Factory Charges PMT OBD/2010 EPA/CARB/GHG14 ESCALATOR DELIVERY & ORDER PROCESSING CHARGE Extended Warranty WAG-052 TOWING EXTENDED/ROADSIDE SERVICE WARRANTY, 1 YEAR/UNLIMITED MILES/KM, $550 CAP Total Extended Warranty (Local Currency) (+) s shown are estimates only. If weight is critical, contact Customer Application Engineering. (**) Prices shown do not include taxes, fees, etc Net Equipment Selling Price is located on the Quotation Details Proposal Report. Page 13 of 13

S P E C I F I C A T I O N W O R K S H E E T (INTERNAL USE ONLY)

S P E C I F I C A T I O N W O R K S H E E T (INTERNAL USE ONLY) Price Level Data Version PRL-05M M2 PRL-05M (EFF:03/8/13) DRL-001 SPECPRO21 DATA RELEASE VER 001 Vehicle Configuration 001-172 M2 106 CONVENTIONAL