EMB Manufacturing Inc. Boomer Line St. Clements, On N0B M0 Canada Ph: (9) 99-98 Fax: (9) 99- www.embmfg.com WX0-LEU Trailer Log Splitter Parts Manual S/N E9USES00 & After Refer to the operators manual for safe operation and maintenance
WX0-LEU Splitter Parts Manual Foreword WALLENSTEIN by EMB Mfg. EMB Mfg. has prepared this parts manual to assist customers in ordering quality OEM replacement parts. Proper and regular service and replacing old, worn or broken parts with the correct OEM parts are essential to prolonging the life of your EMB product. Please refer to this manual before ordering any replacement parts. All information contained in this parts manual is based on the latest product specification available at the time of printing this manual. If your product differs from the specifications contained within this manual contact EMB Mfg. for information. EMB reserves the right to alter specifications on their products at any time. Reproduction of this parts manual of any kind is prohibited without prior written permission from EMB Mfg. For parts and information please contact your dealer. If your dealer is no longer available please go to our website: http://www.embmfg.com and click on FIND A DEALER NEAR YOU for information on a local dealer. Page
WALLENSTEIN by EMB Mfg. WX0-LEU Splitter Parts Manual Table of Contents Bolt Torque... Hydraulic Fitting Torque... Wheel Lug Torque... Main Assembly... Splitter Bed Assembly... Trailer Assembly... 8 Light Bar Assembly... 9 Electrical Harness Detail... 9 Hub Assembly... 0 Hydraulic Assembly... 0 Valve Seal Kit... Cylinder Detail... Hydraulic Hose List... Hydraulic Schematic... Label Layout... Accessories... Page
WX0-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Bolt Torque CHECKING BOLT TORQUE The tables shown below give correct torque values for various bolts and capscrews. Tighten all bolts to the torques specified in chart unless otherwise noted. Check tightness of bolts periodically, using bolt torque chart as a guide. Replace hardware with the same strength bolt. Torque figures indicated above are valid for non-greased or non-oiled threads and heads unless otherwise specified. Therefore, do not grease or oil bolts or capscrews unless otherwise specified in this manual. When using locking elements, increase torque values by %. * Torque value for bolts and capscrews are identified by their head markings. ENGLISH TORQUE SPECIFICATIONS Bolt Diameter "A" SAE (N.m) (lb-ft) Bolt Torque* SAE (N.m) (lb-ft) SAE 8 (N.m) (lb-ft) /" /" /8" /" /" 9/" /8" /" /8" " 8 9 8 0 0 0 0 0 9 0 0 90 0 80 9 9 80 0 90 0 0 00 0 0 0 880 0 0 00 0 90 METRIC TORQUE SPECIFICATIONS Bolt Diameter "A" M M M M M8 M0 M M M M0 M M0 M 8.8 (N.m) (lb-ft). 0 0 90 0 0 9 00 Bolt Torque*.. 0 0 9 0.9 (N.m) (lb-ft).8. 9 0 00 0 0 00 00.. 9 8 9 0 0 0 Page
WALLENSTEIN by EMB Mfg. WX0-LEU Splitter Parts Manual Hydraulic Fitting Torque Tightening Flare Type Tube Fittings *. Check flare and flare seat for defects that might cause leakage.. Align tube with fitting before tightening.. Lubricate connection and hand tighten swivel nut until snug.. To prevent twisting the tube(s), use two wrenches. Place one wrench on the connector body and with the second tighten the swivel nut to the torque shown. Tube Nut Size Torque Recommended Size Across Value Turns To Tighten OD Flats (After Finger Tightening) (in.) (in.) (N.m) (lb-ft) (Flats) (Turn) / / 8 / / 9/ 9 / / /8 / /8 / / / /8 / /8 / / -/ 0 / /8 /8 -/8 90 / /8 The torque values shown are based on lubricated connections as in reassembly. Wheel Lug Torque It is extremely important safety procedure to apply and maintain proper wheel mounting torque on your trailer axle. Torque wrenches are the best method to assure the proper amount of torque is being applied to a fastener. Wheel lugs should be torqued before first road use and after each wheel removal. Check and re torque after the first Km (0 miles), 0Km ( miles), and again at 80Km (0 miles). Check periodically thereafter. Note: Wheel lugs must be applied and maintained at the proper torque levels to prevent loose wheels, broken studs, and possible dangerous separation of wheels from your axle. Start all lugs by hand to prevent cross threading. Tighten lugs in sequence, per wheel lug torque sequence chart. The tightening of the fasteners should be done in stages. Following the recommended sequence, tighten fasteners per wheel torque requirements chart. Wheel Size 8" " " " " " Wheel Torque Requirements Torque Unit st Stage nd Stage rd Stage ft-lbs Nm ft-lbs Nm ft-lbs Nm ft-lbs Nm ft-lbs Nm ft-lbs Nm - 0-0 - -. 0 - -. 0 - -. 0 - -. 0 - -. 0-9 -. - 0. - - 0. - 0-0 - 8 0-0 - 8 0-0 - 8 Wheel Lug Torque Sequence - 8. -. 0-0 - 8 0-0 - 8 90-0 - 90-0 - 90-0 - Page
WX0-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Main Assembly See Cylinder Detail See Lightbar Assembly See Hydraulic Ass y 9 9 8 0 0 9 0M0 Pin, Pivot Threaded 0A0 Z0 Vented Breather Plug cap Dipstick dipstick x 9 0A LEU Lightbar Assembly 0S Rain Flap 0S CE Stat Plate Z0 Suction Hose, " x " Z0 Front White Reflex Reflector CE 8 Z0 Side Yellow Reflex Reflector CE 9 Z WX0-LEU Light Harness 0 Z Euro Plug Holder ( & pin) Z89 Rubberized Wire Clamp, /" Z8 Rubber Grommet / x / Z0 Hex Bolt, /NC x / Z0 Hex Bolt, /NC x Z0 Hex Lock Nut #8NC 8 Z Hex Lock Nut, /NC Z Hex Lock Nut, /8NC Z Hex Lock Nut, /NC 9 Z Hex Lock Nut, /NC 0 Z Flat Washer, /8 Z Flange Bolt, /8NC x Z809 Machine Screw, #8-NC x / 8 Z90 Dome Rivet, /8" x /8" Alum Z90 Hose Clamp, # Z9.80-8 LRC USATrail E-marked Page
WALLENSTEIN by EMB Mfg. WX0-LEU Splitter Parts Manual Splitter Bed Assembly 9 9 9 0 0 0S0 Housing, Latch Spring 0W0 Handle, Spring Latch Z Cotter Pin / X -/ Z0 Spring 9mm x 9mm Med Z0 Wide Flat Washer, / 9 0 8 0 0A0 LATCH KIT (WELDED ON) 8 8 8 0 0 0S Plate, Sliding Wedge Capture 0W0 Weldment, Sliding Wedge Z Hex Bolt /NF x -/ Z Hex Lock Nut /8NC 0 9 0M Spacer, Shredder.80 0A0 Assembly, Wide Sliding Wedge 0S Plate, Cylinder Retaining (Bolt) 0C0 Cylinder, x x -/ 0L Clamp, Two Hose 0S Handle, Lift 0W0 Splitter Base for WX0-LEU 8 9S0 Bar, Connecting 9 9S0 Handle Stem, Euro 0 9W Weldment, Angle Base 9W Arm, Stub Base 9W Arm, Log Holder Z0 Clevis Pin, / x / Z0 Hitch Pin Clip, / Z Snapper Pin /8 x -/ Z9 Grip, " x " Z9 Rod End Bearing, / Z0 Spring, x x.9 9 Z Elbow 90 MP x FPX 0 Z- Brand Valve No Detent Z9 Knob, Handle Kit Z0 Hex Bolt, /NC x Z0 Hex Bolt, /NC x Z Hex Bolt, /8NC x -/ Z Hex Bolt, /NC x -/ Z Hex Lock Nut, /NC Z Hex Lock Nut, /NC 9 8 Z Hex Lock Nut, /8NC 9 Z Hex Lock Nut, /NC 0 Z Jam Nut, /NF Z SHCS, /NC x -/ Z Carriage Bolt, /8NC x -/ Z Eye Bolt /NC x Page
WX0-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Trailer Assembly 0 0 8 9 0 8 0 8 0 0L Clamp, Two Hose 0L Harness Junction Plate 0W0 Jack Stand, Rear 0W0 Jack Stand, Front 0W0 Handle, Rear Jack Lock 0W 0W WX0-LEU Tank - Axle 0W LEU Fender Weldment, LH 8 0WH LEU Fender Weldment, RH 9 0W Lateral Bar, LH 0 0W Weldment, LEU Trailer Spine 0W9 Lateral Bar, RH 0W0 0mm Coupler Mount Weldment Z Cotter Pin, /8 x Z Snapper Pin /8 x -/ Z Reducer MP x FP Z Elbow 90 MP x FPX Z0 Oil Filter - / - Particulate Z0 Filter Cap, / x / 9 Z0 Hex Bolt, /NC x / 0 Z Hex Bolt, /NC x /8 See Hub Ass y 9 9 9 Z0 Hex Bolt, /NC x 0 Z Hex Bolt, /NC x -/ Z Hex Bolt, /NC x -/ Z Hex Lock Nut, /NC Z Hex Lock Nut, /NC Z Hex Lock Nut, /8NC Z Hex Lock Nut, /NC 8 Z Hex Lock Nut, /NC 9 Z9 Slotted Castle Nut, -NF x /" Thick 0 Z Flat Washer, / 8 Z Flat Washer, / Z Flat Washer, / Z Carriage Bolt, /8NC x Z9 Flexi-ride Axle 9# RH Z9 Flexi-Ride Axle 9#, LH Z90 Assembly, 000# -Bolt Hub Z90 0mm Ball Hitch Coupler 8 Z90 Safety Chain / x ' 9 Z90 Manual Tube -/ Short Page 8
WALLENSTEIN by EMB Mfg. WX0-LEU Splitter Parts Manual Light Bar Assembly 8 9 0 Hex Nut, M x.0 (Included with Lights) 0M Spacer, Shredder.80 0L Light Bar Lock 0W LEU Light Bar Z0 Spring / x -/ x.0 Z CE Combo Light LH O Fog Z CE Combo Light RH O Fog Z Euro Plug Holder ( & pin) 8 Z89 Rubberized Wire Clamp, /" 9 Z0 Hex Bolt, /NC x 0 Z Hex Lock Nut, /NC Z Hex Lock Nut, /8NC Z Hex Lock Nut, /NC Z Flat Washer, /8 Z FHCS, /8NC x -/ Z80 Machine Screw, /-0NC x / Electrical Harness Detail BLU RED BRN GRN WHT RH MULTIFUNCTION -PIN RIGHT SIDE -PIN CE RV SOCKET AND BACKPLATE -PIN CE RV CONNECTOR " -PIN CE RV CONNECTOR BLU WHT BLK YLW GRN PIN-OUT (VIEWED ON FRONT OF CONNECTOR) RED BRN BLU BLK WHT RED YLW LH MULTIFUNCTION -PIN LEFT SIDE Page 9
WX0-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Hub Assembly 0 000# -BOLT HUB PARTS BREAKDOWN Z0 L Cone, L0 Cup Z80 Double Lip Seal -/ Shaft Z90 Grease Fitting, /8 Z9 Lug Nut /NF Z90 000# -Bolt Hub Z90 Dust Cap.98 Bore 0 Z9 Z9 Slotted Castle Slotted Nut, Hex -NF Nut NF x / Thick Z Cotter Pin / X Hydraulic Assembly BOM ID Part No. Description Qty Z0 Shaft Coupler, L0 x /" Z Spider, L0 Z0 Shaft Coupling, L0 x /" Z Key, /" x /" x /8" Z9 Woodruff Key, /8" x /" Z Honda GX0UTQH, Rope Z Elbow 90, MP x FPX 8 Z0 Two-Stage Pump, GPM 9 Z80 Pump Mount, PM- 0 Z0 Hex Bolt, /NC x /" Z Hex Bolt, /NF x /" Z Hex Lock Nut, /NC Z Hex Bolt, /NC x -/" 9 0 8 Page 0
WALLENSTEIN by EMB Mfg. Valve Seal Kit WX0-LEU Splitter Parts Manual Seal kit for #Z Valve: #SDC-K ITEM NO. QTY. DESCRIPTION ORING, 0 QUAD RING WIPER Cylinder Detail BOM ID Part No. Description Qty 0C0 Rod, -/ x Z9G8 Hex Lock Nut NF Grade 8 0C0 Barrel, " P00-00SP Piston, " Bore G00-0S Gland, " x -/" Z Elbow 90, MP x FPX Page
WX0-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Hydraulic Hose List Part Number Description Qty Z8 /" Hose, MP x MP x "SC Z9 /" Hose, MP x MP x "SC Z /" Hose, MP x MP x "SC Z0 Suction Hose, " x " Hydraulic Schematic 0C0 Z0 Filter Cap Z "(cm) Z9 "(cm) HB Z0 Filter Z0 "(cm) Z8 "(8cm) Z "(cm) Fitting Identification WX0 Hydraulic Reservoir Tank Z0 Hydraulic Pump Connection Type National Pipe Thread JIC Tube Flare ORB O Ring Boss HB Hose Barb Connection Type Connection Size Page
WALLENSTEIN by EMB Mfg. WX0-LEU Splitter Parts Manual Label Layout Z90 x Z99 x Z9 x Z9 x 99 Z9 x Z9 x Z9 x Z9 x Page
WX0-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Accessories #0 - WAY WEDGE For WX0-LEU Boost your productivity and make quick work out of logs by splitting four pieces at once. This is an ideal way to save time. #0 #Z90 WX0-LEU TRAILER WOOD SPLITTER OPERATOR S MANUAL Available as a download at www.embmfg.com Page