DEPARTMENT OF PUBLIC WORKS 901 North Elm P.O. Box 979 Rolla, MO 65402 Phone: (573) 364-8659 FAX: (573) 364-8602 e-mail: shargis@rollacity.org www.rollacity.org INSTRUCTIONS TO BIDDERS 1. Bids must be submitted on the Bidder s Tabulation Sheet only. Bids must be submitted in sealed envelopes, property identified as 2019 Sludge Truck. 2. The bid must be filed with the City Clerk prior to the announced bid opening date and time. Bid opening will be October 24 th, 2018 at 11:00 AM local time. 3. The City of Rolla reserves the right to accept or reject any/or all bids. 4. It will be the City s intent to accept low competent bid if it meets specifications and conditions. 5. Bidders are advised that the City of Rolla shall consider prior substandard goods or prior substandard service delivery or excessive distance to the city as a criterion for bid rejection. 6. All bids shall meet or exceed specifications. 7. Alternate bids may be considered providing all specification differences are clearly indicated and contain justification statements. The City of Rolla shall be the sole judge as to the suitability of the service or equipment offered for the intended purpose from the alternate bid. 8. Any exceptions to these terms or conditions or deviations from written specifications shall be shown in writing and attached to the Bidder s Proposal. 9. Bidders are cautioned to verify their proposal before submission as requests for amendments, withdrawals or proposals, if received by the city after the time specified for opening, will not be considered. 10. In the event of discrepancies between Bidder s Per Unit price quotation and Extended Total quotation, the Per Unit quotation shall prevail. 11. Bidders must be factory authorized dealers for the equipment, service, and parts of the items they are bidding. 12. The City of Rolla reserves the right to use State of Missouri bids when applicable. 1
BID DOCUMENTS 2019 Sludge Truck The City of Rolla Public Works Department is seeking bids on current year and production model Sludge Truck, meeting the attached specifications, including all standard equipment and conditions as described in current literature. Any specifications or conditions not met by bidder must be noted as an exception UNIT SPECIFICATION FOR A SLUDGE TRUCK 1. General The machine shall be a new current model year advertised standard production chassis capable on and off road operation. 2. Engine Diesel, Cummins Turbo ISX 15, 485 HP@1800 RPM, Or owner approved equal. 3. Transmission Allison Automatic, 4500RDS, Programmable with PTO Provision for ON/OFF highway w/o retarder 5 th generation. 4. Chassis New Model KW T880, 6x6 chassis, 100 gallon fuel tank, air ride cab Or owner approved equal 5. Tires and Wheels Front: Alliance Semi-Float, Semi-Aggressive Tires, 10 stud steel wheels Rear: Alliance 16PR, 10 stud steel wheels 2
UNIT SPECIFICATION FOR A SLUDGE TRUCK 6. Instruments, Controls, and Electronics 1 Extra Aux. Power Switch wired & labeled for Customer installation Rear Floodlights 1 Extra Aux Power Switch wired & labeled for Customer installation Rear Work light 2 Extra Aux Power Switches wired for Customer installation w/o electrical pass-through. Battery Disconnect witch 200 Amp; Lever operated, Locks w/padlock, Battery Box Mtd. Does NOT Disconnect Charging Automatic Grease System: Groenveld on Chassis Weigh bar scale system Top-Load Hydraulic Hatch, Dual Loading fill options, Mapping & Recording Capabilities Raven Viper 4+ with 600S receiver controller 7. 5500 GALLON VACUUM TANK SPECIFICATIONS: Diameter: Tank Material: 5.16" A36; 82" x 19' Length, 3" Full-length taper rails Minimum 23000 lbs. With a minimum of 1400 lbs. of front counterweight. Interior sealed with Tnemec or same-as coating Two (2) baffles 20" hydraulic load manway 25" manual front & rear hatch 1-1/2" Manual pressure relief valve with handle kit National Vac Challenger MAX PAK 866 with hydraulic motor includes NVE Hytrel Spider National Vac Stainless steel knife-type air valves 50 Gal PWM Motor Control Six (6) inch Krohne Flow Meter All plumbing is TIG welded Stainless Steel Sch 10 316 3) Five (5) inch Site Gauges with removable glass bowl Four (4) inch spray deflector mounted at rear Hydraulically operated vacuum pressure system pump w/temperature controlled oil cooler Spool valve cab operated, one spool to be detented for pump with motor spool TIG welded stainless steel plumbing throughout Computer Sonar DR-250 Depth-Ray Tank Level Monitor Installed NVE Diesel flush kit Installed MAX PAK Oil-catch muffler and silencer Painted oil reservoir, filter and plumbing installation on chassis Stainless Steel fender package with Stainless steel mud flap bracketry and mud flap kit. Vision Works 1 Rear mtd Camera Installed, view projected In-Cab. Raven Viper 4+ Monitor, and 600S Receiver Installed 3
UNIT SPECIFICATION FOR A SLUDGE TRUCK 8. Training Minimum 16hrs on-site training on the use and maintenance. 9. Warranty Please detail the warranty provided and any extended warranties available. Attach description with the Bid Documents 10. Trade-In The City of Rolla has a 2003 Terragator. Provide a trade in allowance in your bid. The city reserves the right to reject trade-in allowances. 4
BID TABULATION SHEET SLUDGE TRUCK Bid Price: The Bid Price shall be for one (1) Sludge Truck, in accordance with the attached specifications. Any exceptions must be noted in the space provided. The Bid Price shall include delivery to the City of Rolla by a manufacturer's representative who will be available to give instructions in the operation and maintenance of the unit and accessories. One parts book, one service and repair manual, and one operator manual shall be included with the delivery. The City of Rolla reserves the right to reject any or all bids. Unit Price Lump Sum: $ Trade-In Allowance Lump Sum: $ Total Sum: $ Manufacturer and Model Number: I/we the undersigned have read and fully understand these Specifications and have noted in writing any exceptions under the exception column. If awarded the bid, I/we do hereby agree to provide the equipment as specified or as noted by exception. Signed Name Title Company Date Address Phone E-Mail Address: Delivery (Please specify Estimated Delivery Date): IF YOU HAVE ANY QUESTIONS, PLEASE CALL PUBLIC WORKS WASTEWATER SUPERINTENDEN, WILL OLMS AT (573) 466-3039.