EH Range Technica Data Eectro-hydrauic Vave Actuators Redefining Fow Contro
EH Range Technica Data INTRODUCTION The Rotork EH Range of sef-contained, eectro-hydrauic actuator incudes an integrated contro modue; a hydrauic manifod; and a power unit consisting of a motor, hydrauic pump and reservoir. A eectronics are protected in a watertight or exposion-proof encosure. EH actuators are avaiabe in doube-acting or spring-return configurations for both quarter-turn and inear appications. They can be configured to mount in any position, incuding remote mounting of the contro modue. Torque requirements up to 600,000 Nm (5.3 miion bf-in) and thrusts up to 5,500,000 N (1,2 miion bf) can be accommodated. Other features incude oca manua contro, indication feedback via dry contacts and 4-20 ma signa; or optiona digita contro via Modbus, Foundation Fiedbus, Profibus, DeviceNet or Rotork Pakscan communication systems. The EH Range can be suppied for operation with virtuay any singe phase, three phase, or 24 VDC power suppy. EH systems can aso operated with an existing hydrauic power unit. The HPU must operate with compatibe hydrauic fuid at pressures that do not exceed EH Range maximums. Consut Rotork Fuid Systems for sizing and appication assistance. Standard Features Sef-contained system Non-intrusive set-up and interrogation via an Infra-red hand hed remote Mutipe input power options with either AC or DC suppy Loca position indication, diagnostics and faut indication via iuminated LCD dispay OPEN/CLOSE digita inputs and ESD (emergency shut down) input Positioning with a 4-20mA demand signa Partia stroke for OPEN/CLOSE configurations Water-tight or exposion-proof Manifod bock simpifies contro piping Lockabe Loca/Remote/Offine seector switch Loca Open/Cose seector switch Opto-isoated digita inputs Remote contro disabed indication Separate, doube seaed termina compartment 4-20 ma position transmitter Optiona Features Hydrauic manua override pump Fast stroke options Hydrauic speed contro Digita communication via Modbus, Foundation Fiedbus, Profibus, DeviceNet or Rotork Pakscan Soar power Accumuators Safety and reiabiity - suitabe for SIL3 appications 2
GENERAL SYSTEM SPECIFICATION Quarter-turn Torque Output Linear Thrust Output 600,000 Nm (5.3 miion inch pounds) Higher torques avaiabe upon request. 5.5 Miion N (1.2 miion pounds) Higher thrusts avaiabe upon request. Standard EH Range inear actuators are avaiabe with stroke engths up to 343mm (13.5in). Longer stroke engths avaiabe upon request. Consut Rotork Fuid Systems. Operating Pressure 170 bar (2500 psi) nomina 100 bar (1500 psi) nomina with accumuator INPUT POWER AC Votages 3 Phase 50Hz: 190, 200, 220, 240, 380, 400, 415, 440, 480, 500, 525, 550, 660, 690 3 Phase 60Hz: 200, 208, 220, 230, 240, 380, 400, 440, 460, 480, 575, 600, 660, 690 1 Phase 50Hz: 110, 115, 220, 230, 240 1 Phase 60Hz: 110, 115, 208, 220, 230, 240 DC Votages 24 Power Consumption AC SYSTEMS DC SYSTEMS POWER CONSUMPTION (watts) HOLDING RUNNING 15 35 + motor power 6.5 12 + motor power Where power consumption is a concern e.g., soar power, DC powered EH systems are avaiabe with hoding - power ratings as ow as 1.2 Watts. Contact Rotork Fuid Systems for ow-power consumption requirements. Toerances AC:Votage +/- 10%, Frequency 50/60Hz +/- 5% DC: Votage +/- 10% Redefining Fow Contro 3
EH Range Technica Data SYSTEM OPERATION Loca Operation LOCAL/REMOTE/OFFLINE seector switch OPEN/CLOSE switch Visua position indication via LCD dispay Optiona hydrauic manua override Remote Operation Inputs Limit Switches Run, Stop, Cose, ESD and partia stroke Low votage input: 20-60 VAC/VDC opto-isoated High votage input: 60-120 VAC opto-isoated Minimum On votage 17 VDC/VAC Maximum Off votage 3 VDC/VAC Maximum Off current 100 ua Minimum contro signa 300 msec (2) SPDT, (4) SPDT optiona VOLTAGE 240 110 50 24 LIMIT SWITCH CURRENT RATINGS AC DC 0.20 A 0.25 A 2.50 A 3.00 A Output 4-20 ma position transmitter Zero adjustment 3.22-5.50 ma Span adjustment 17.70-34.34 ma Maximum tota impedance must not exceed 500Ω. Positioning Quarter-turnCyce Rate: 100 starts/hr maximum Repeatabiity 0.5%, Linearity 1% Linear Cyce Rate: 200 starts/hr maximum Repeatabiity 0.5%, Linearity 5% Consut Rotork Fuid Systems for higher cyce rate requirements. Cyce rates over 1,200 starts/hour avaiabe. Wiring Diagrams WIRING DIAGRAMS AC INPUT STANDARD WD18170 PAKSCAN WD17984 MODBUS WD18204 FOUNDATION F BUS WD18494 DC INPUT WD18747 WD18202 WD18205 WD18206 Conduit Entries (3) ½ NPT 4
ENVIRONMENT Operating Temperatures Environmenta Protection Contro Encosure Motor Hydrauic Reservoir Actuator Watertight and exposionproof configurations avaiabe. -20 C to 40 C (-4 F to 104 F). Temperatures from -50 C to 60 C can be accommodated. Contact Rotork Fuid Systems. IP68 NEMA TEFC or IEC IP55, IP65 optiona IP54 (higher ratings avaiabe upon request) IP66, IP67M Area Cassifications FM 3600 and 3615 Exposionproof Cass I, Div. 1, Groups C, D Dust-ignitionproof Cass II, Div. 1, Groups E, F, G ATEX EN50014 and EN50018 Fameproof II 2GD EEx d IIB T4 IEC 60079-0 and 60079-1 Fameproof Ex d IIB T4 GOST (Russia) Additiona approvas avaiabe CSA Exposionproof Cass I, Div. 1, Groups C, D Dust-ignitionproof Cass II, Div. 1, Groups E, F, G INMETRO (Brazi) Redefining Fow Contro 5
Fow Contro www.rotork.com A fu isting of our wordwide saes and service network is avaiabe on our website. Rotork pc Brassmi Lane, Bath, UK te +44 (0)1225 733200 fax +44 (0)1225 333467 emai mai@rotork.com Scan with your smart phone for more information on this product range PUB021-007-00 Issue 02/13 Formery F711E. As part of a process of on-going product deveopment, Rotork reserves the right to amend and change specifications without prior notice. Pubished data may be subject to change. For the very atest version reease, visit our website at www.rotork.com The name Rotork is a registered trademark. Rotork recognises a registered trademarks. Pubished and produced in the UK by Rotork Contros Limited. ROWMH0213