EMB Manufacturing Inc. Boomer Line St. Clements, On N0B M0 Canada Ph: (59) 99-98 Fax: (59) 99- www.embmfg.com WX50-LEU Trailer Log Splitter Parts Manual S/N E9USXDS000 & After Refer to the operators manual for safe operation and maintenance
WX50-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Foreword EMB Mfg. has prepared this parts manual to assist customers in ordering quality OEM replacement parts. Proper and regular service and replacing old, worn or broken parts with the correct Wallenstein parts are essential to prolonging the life of your Wallenstein product. Please refer to this manual before ordering any replacement parts. All information contained in this parts manual is based on the latest product specification available at the time of printing this manual. If your product differs from the specifications contained within this manual contact EMB Mfg. for information. EMB reserves the right to alter specifications on their products at any time. Reproduction of this parts manual of any kind is prohibited without prior written permission from EMB Mfg. For parts and information please contact your dealer. If your dealer is no longer available please go to our website: http://www.embmfg.com and click on FIND A DEALER NEAR YOU for information on a local dealer. Page
WALLENSTEIN by EMB Mfg. WX50-LEU Splitter Parts Manual Table of Contents Bolt Torque... Hydraulic Fitting Torque... 5 Wheel Lug Torque... 5 Main Assembly... Splitter Bed Assembly... Trailer Assembly... 8 Light Bar Assembly... 9 Electrical Harness Detail... 9 Hub Assembly... 0 Hydraulic Assembly... 0 Valve Seal Kit... Cylinder Detail... Hydraulic Hose List... Hydraulic Schematic... Label Layout... Accessories... Page
WX50-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Bolt Torque CHECKING BOLT TORQUE The tables shown below give correct torque values for various bolts and capscrews. Tighten all bolts to the torques specified in chart unless otherwise noted. Check tightness of bolts periodically, using bolt torque chart as a guide. Replace hardware with the same strength bolt. Torque figures indicated above are valid for non-greased or non-oiled threads and heads unless otherwise specified. Therefore, do not grease or oil bolts or capscrews unless otherwise specified in this manual. When using locking elements, increase torque values by 5%. * Torque value for bolts and capscrews are identified by their head markings. ENGLISH TORQUE SPECIFICATIONS Bolt Diameter "A" SAE (N.m) (lb-ft) Bolt Torque* SAE 5 (N.m) (lb-ft) SAE 8 (N.m) (lb-ft) /" 5/" /8" /" /" 9/" 5/8" /" /8" " 8 95 8 5 0 5 0 0 0 5 0 95 5 0 5 5 5 0 55 5 90 50 850 9 9 5 80 5 0 90 0 0 00 55 0 05 50 880 0 5 5 5 5 0 00 50 90 METRIC TORQUE SPECIFICATIONS Bolt Diameter "A" M M M5 M M8 M0 M M M M0 M M0 M 8.8 (N.m) (lb-ft).5 0 5 50 90 0 5 5 50 95 00 Bolt Torque*.. 0 55 0 9 0.9 (N.m) (lb-ft).8.5 9 5 5 0 5 00 0 0 050 00 5.. 5 9 8 9 50 550 0 Page
WALLENSTEIN by EMB Mfg. WX50-LEU Splitter Parts Manual Hydraulic Fitting Torque Tightening Flare Type Tube Fittings *. Check flare and flare seat for defects that might cause leakage.. Align tube with fitting before tightening.. Lubricate connection and hand tighten swivel nut until snug.. To prevent twisting the tube(s), use two wrenches. Place one wrench on the connector body and with the second tighten the swivel nut to the torque shown. Tube Nut Size Torque Recommended Size Across Value Turns To Tighten OD Flats (After Finger Tightening) (in.) (in.) (N.m) (lb-ft) (Flats) (Turn) / / 8 / / 9/ 9 / 5/ 5/8 / /8 / / / /8 / 5/8 / / -/ 0 5 / /8 /8 -/8 90 / /8 The torque values shown are based on lubricated connections as in reassembly. Wheel Lug Torque It is extremely important safety procedure to apply and maintain proper wheel mounting torque on your trailer axle. Torque wrenches are the best method to assure the proper amount of torque is being applied to a fastener. Wheel lugs should be torqued before first road use and after each wheel removal. Check and re torque after the first Km (0 miles), 0Km (5 miles), and again at 80Km (50 miles). Check periodically thereafter. Note: Wheel lugs must be applied and maintained at the proper torque levels to prevent loose wheels, broken studs, and possible dangerous separation of wheels from your axle. Start all lugs by hand to prevent cross threading. Tighten lugs in sequence, per wheel lug torque sequence chart. The tightening of the fasteners should be done in stages. Following the recommended sequence, tighten fasteners per wheel torque requirements chart. Wheel Size 8" " " " 5" " Wheel Torque Requirements Torque Unit st Stage nd Stage rd Stage ft-lbs Nm ft-lbs Nm ft-lbs Nm ft-lbs Nm ft-lbs Nm ft-lbs Nm - 0-0 - 5 -.5 0-5 -.5 0-5 -.5 0-5 -.5 0-5 -.5 0-5 9-5.5 5-0 5.5-5 5-0 5.5-5 50-0 5-8 50-0 5-8 50-0 5-8 Wheel Lug Torque Sequence 5-55 58.5 -.5 50-0 5-8 50-0 5-8 90-0 - 5 90-0 - 5 90-0 - 5 Page 5
WX50-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Main Assembly See Cylinder Detail See Lightbar Assembly See Hydraulic Ass y 9 9 5 8 5 0 5 0 5 9 0M0 Pin, Pivot Threaded 05A0 Breather cap dipstick 05A LEU Lightbar Assembly 05S55 Rain Flap 5 05S5 CE Stat Plate Z505 Suction Hose, " x " Z0 Front White Reflex Reflector CE 8 Z0 Side Yellow Reflex Reflector CE 9 Z WX50-LEU Light Harness 0 Z Euro Plug Holder ( & pin) Z89 Rubberized Wire Clamp, /" Z8 Rubber Grommet / x / Z0 Hex Bolt, /NC x / Z0 Hex Bolt, /NC x 5 Z0 Hex Lock Nut #8NC 8 Z Hex Lock Nut, /NC Z Hex Lock Nut, /8NC Z Hex Lock Nut, /NC 9 Z5 Hex Lock Nut, /NC 0 Z Flat Washer, /8 Z Flange Bolt, /8NC x Z809 Machine Screw, #8-NC x / 8 Z90 Dome Rivet, /8" x /8" Alum Z90 Hose Clamp, # 5 Z9.80-8 LRC USATrail E-marked Page
WALLENSTEIN by EMB Mfg. WX50-LEU Splitter Parts Manual Splitter Bed Assembly 9 9 9 0 50 0S0 Housing, Latch Spring 5 0W0 Handle, Spring Latch 5 Z Cotter Pin / X -/ 5 Z0 Spring 9mm x 9mm Med 5 Z50 Wide Flat Washer, / 5 5 5 9 50 5 8 0 0A0 LATCH KIT (WELDED ON) 8 5 8 8 0 5 5 0 0S Plate, Sliding Wedge Capture 0W0 Weldment, Sliding Wedge Z5 Hex Bolt /NF x -/ 5 Z Hex Lock Nut /8NC 5 0 9 05M5 Spacer, Shredder.580 0A0 Assembly, Wide Sliding Wedge 0S Plate, Cylinder Retaining (Bolt) 05C0 Cylinder, x x -/ 5 05L Clamp, Two Hose 05S Handle, Lift 05W50 Splitter Base for WX50-LEU 8 9S0 Bar, Connecting 9 9S0 Handle Stem, Euro 0 9W Weldment, Angle Base 9W5 Arm, Stub Base 9W5 Arm, Log Holder Z0 Clevis Pin, / x / Z0 Hitch Pin Clip, / 5 Z Snapper Pin /8 x -/ Z9 Grip, " x 5" Z9 Rod End Bearing, / Z50 Spring, x x.9 9 Z5 Elbow 90 MP x FPX 0 Z5- Brand Valve No Detent Z59 Knob, Handle Kit Z0 Hex Bolt, /NC x Z0 Hex Bolt, 5/NC x Z5 Hex Bolt, /8NC x -/ 5 Z555 Hex Bolt, /NC x 5-/ Z Hex Lock Nut, /NC Z Hex Lock Nut, 5/NC 9 8 Z Hex Lock Nut, /8NC 9 Z5 Hex Lock Nut, /NC 0 Z Jam Nut, /NF Z5 SHCS, /NC x -/ Z Carriage Bolt, /8NC x -/ Z5 Eye Bolt 5/NC x Page
WX50-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Trailer Assembly 0 0 8 5 9 0 8 5 0 8 5 5 5 5 0 05L Clamp, Two Hose 05L55 Harness Junction Plate 05W05 Jack Stand, Rear 05W0 Jack Stand, Front 5 05W0 Handle, Rear Jack Lock 05W5 WX50-LEU Tank - Axle 05W5 LEU Fender Weldment, LH 8 05W5H LEU Fender Weldment, RH 9 05W5 Lateral Bar, LH 0 05W5 Weldment, LEU Trailer Spine 05W59 Lateral Bar, RH 05W0 50mm Coupler Mount Weldment Z Cotter Pin, /8 x Z Snapper Pin /8 x -/ 5 Z5 Reducer MP x FP Z5 Elbow 90 MP x FPX Z550 Oil Filter - / - Particulate Z550 Filter Cap, / x / 9 Z0 Hex Bolt, /NC x / 0 Z Hex Bolt, /NC x /8 See Hub Ass y 9 9 5 5 9 Z0 Hex Bolt, 5/NC x 0 Z Hex Bolt, /NC x -/ Z55 Hex Bolt, /NC x -/ Z Hex Lock Nut, /NC 5 5 Z Hex Lock Nut, 5/NC Z Hex Lock Nut, /8NC Z Hex Lock Nut, /NC 8 Z5 Hex Lock Nut, /NC 9 Z9 Slotted Castle Nut, -NF x /" Thick 0 Z Flat Washer, 5/ 8 Z Flat Washer, / Z5 Flat Washer, / Z Carriage Bolt, /8NC x Z9 Flexi-ride Axle 95# RH 5 Z9 Flexi-Ride Axle 95#, LH Z90 Assembly, 000# -Bolt Hub Z90 50mm Ball Hitch Coupler 8 Z90 Safety Chain / x ' 9 Z950 Manual Tube -/ Short Page 8
WALLENSTEIN by EMB Mfg. WX50-LEU Splitter Parts Manual Light Bar Assembly 5 8 9 0 5 Hex Nut, M x.0 (Included with Lights) 05M5 Spacer, Shredder.580 05L5 Light Bar Lock 05W55 LEU Light Bar Z0 Spring / x -/ x.0 5 Z CE Combo Light LH O Fog Z CE Combo Light RH O Fog Z Euro Plug Holder ( & pin) 8 Z89 Rubberized Wire Clamp, /" 9 Z0 Hex Bolt, /NC x 0 Z Hex Lock Nut, /NC Z Hex Lock Nut, /8NC Z Hex Lock Nut, /NC Z Flat Washer, /8 Z5 FHCS, /8NC x -/ 5 Z80 Machine Screw, /-0NC x / Electrical Harness Detail BLU RED BRN GRN WHT RH MULTIFUNCTION 5-PIN RIGHT SIDE -PIN CE RV SOCKET AND BACKPLATE -PIN CE RV CONNECTOR " -PIN CE RV CONNECTOR BLU WHT BLK YLW GRN PIN-OUT (VIEWED ON FRONT OF CONNECTOR) 5 RED BRN BLU BLK WHT RED YLW LH MULTIFUNCTION 5-PIN LEFT SIDE Page 9
WX50-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Hub Assembly 5 5 0 000# -BOLT HUB PARTS BREAKDOWN Z0 L Cone, L0 Cup Z80 Double Lip Seal -/ Shaft Z90 Grease Fitting, /8 Z9 Lug Nut /NF 5 Z90 000# -Bolt Hub Z90 Dust Cap.98 Bore 0 Z9 Z9 Slotted Castle Slotted Nut, Hex -NF Nut NF x / Thick 5 Z Cotter Pin / X Hydraulic Assembly 05A05 PARTS BREAKDOWN Z0 Shaft Coupler L05 x / Z Coupler Spider L05 Z0 Shaft Coupler L05 x / Z5 Key 5/ x 5/ x 5 Z59 Woodruff Key, /8 x / Z Honda GX0 Engine Z5 Elbow 90 MP x FPX 8 Z50 Pump, gpm Two-Stage 9 Z580 Pump Mounting, PM-5 0 Z0 Hex Bolt 5/NC x Z5 Hex Bolt, 5/NC x -/ Z Hex Bolt, 5/NF x / Z Hex Lock Nut 5/NC 9 0 8 5 Page 0
WALLENSTEIN by EMB Mfg. Valve Seal Kit WX50-LEU Splitter Parts Manual Seal kit for #Z5 Valve: #SDC-K ITEM NO. QTY. DESCRIPTION ORING, 0 QUAD RING WIPER Cylinder Detail ORIENT SEALS AS SHOWN " x " STROKE CYLINDER PARTS ITEM PART NO. Description QTY. 0C0 Rod, -/ x 0C0 Barrel, " 05C05 Barrel, with Handle Base *05C05* *Barrel, " with Handle Base* * G00-50SA " Bore x -/" Rod Gland P00-00SA " Bore Piston 5 SLK-05 Seal Kit, x -/ Z9G8 Hex Lock Nut NF Grade 8 *REQUIRED FOR HORIZONTAL / VERTICAL MODELS WITH HANDLE* 05C0 HANDLE BASE WELDED Page
WX50-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Hydraulic Hose List Part Number Description Qty Z58 /" Hose, MP x MP x "SC Z59 /" Hose, MP x MP x "SC Z5 /" Hose, MP x MP x "SC Z505 Suction Hose, " x " Hydraulic Schematic Z550 Filter Cap Z5 "(cm) Z59 "(5cm) HB Z550 Filter Z505 "(5cm) Z58 "(8cm) Z5 "(cm) Fitting Identification WX50 Hydraulic Reservoir Tank Z50 Hydraulic Pump Connection Type National Pipe Thread JIC Tube Flare ORB O Ring Boss HB Hose Barb Connection Type Connection Size Page
WALLENSTEIN by EMB Mfg. WX50-LEU Splitter Parts Manual Label Layout Z905 x Z99 x Z9 x Z9 x 99 Z9 x Z9 x Z9 x Z9 x Page
WX50-LEU Splitter Parts Manual WALLENSTEIN by EMB Mfg. Accessories #0 - way wedge For WX50EU Boost your productivity and make quick work out of logs by splitting four pieces at once. This is an ideal way to save time. #0 #Z905 WX50EU TRAILER WOOD splitter OPERATOR S MANUAL Available as a download at www.embmfg.com Page