TYPE D 84 PASSENGER, REAR ENGINE PART I Vendor: BRYSON SALES AND SERVICE OF WASHINGTON, INC. 2015-16 Seating Capacity 84 passenger maximum design capacity seated for 78 passenger. Capacity 78 Alternator Auxiliary Fans Axle Front Axle Rear 240 amp minimum. 2 fans, 6 maximum, mounted to right and left windshield and service door. 13,200 lb. minimum total suspension GVWR. 23,000 lb. minimum total suspension GVWR. VENDOR SPECIFICALLY IDENTIFY BID Mfr. LEECE NEVILLE Maximum output 240 amps. 240 Mfr. MARADYNE Mfr. HENDRICKSON Capacity 13,200 Mfr. MERITOR Capacity 23,000 Axle Oil Seals Front and rear oil bath. Mfr. SKF Axle Ratio Back-up Lights Battery(ies) Battery Compartment Brakes Door, Service Driver s Seat Must comply with power and gradeability formula. Refer to Washington State School Bus Specifications Manual. All required backup lights to be LED (Light Emitting Diode). Refer to Washington State School Bus Specification s Manual. 1400 CCA 12 volt to be mounted in body battery compartment. Battery storage tray must be large enough to accommodate batteries as specified in chassis section. Air: Drum or Disc. If Drum, minimum 16.5 x 6 front, minimum 16.5 x 8 rear. Refer to Washington State School Bus Specifications Manual. Power operated. Suspension type, 6-way adjustable, with lumbar adjustment. Cloth panel covers. Ratio 5.38 Round: Diameter 4" Other: Square inches Number of batteries 3 CCA 2100 Swing out Roll out Disc Front Rear Drum Front Rear Size Front 16.5X6" Rear 16.5X8.62" Folding Split, Outward opening Mfr. NATIONAL Other FORM SPI 1394-6 (Rev. 7/15) Part I Page 1
TYPE D 84 PASSENGER, REAR ENGINE PART I (cont.) Engine Engine Heater Engine Temperature Diesel 280 H.P. minimum, located in the rear. Engine manufacturer s recommended in-block heater. To be controlled electronically, by fan clutch/drive, or shutters. VENDOR SPECIFICALLY IDENTIFY BID Engine mfr. CUMMINS Model or liters ISB Net torque 660 @ 1600 R.P.M Net H.P. 280 @ 2600 R.P.M Watts 750 Volts 120 Mfr. FLEETGUARD Mfr. HORTON Fan clutch Fuel Tank 100 gallon minimum. Capacity 100 GALLON Heaters Lights Minimum of 3 heaters; 1 front, 1 center, 1 rear. Shutoff valves at engine for all heaters. Two-speed motors. Must include recirculating pump. LED (Light Emitting Diode). Includes Clearance Lights, Stop Lights 7, Tail Lights, Turn Signals, Eight-Light System, and Dome-Light System. Front B.T.U. 90,000 Center B.T.U. 50,000 Rear B.T.U. 50,000 Total B.T.U. 190,000 If not, explain Electronic Shutters P.A. System Seat Spacing AM/FM/PA radio with 4 interior and 1 exterior speakers. 78 passenger based upon manufacturer s maximum seat spacing. Mfr. CLARION Model No. F2104PA Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: 413.5" inches Mfg. s C/C seat measurement: 29.0" inches Steering Wheel Tilt and telescoping column. Step Tread Studded or pebbled top tread covering. Mfr. SMI Tires 6 first quality, radial ply. No low profile tires. Mfr. HANKOOK Size 11R22.5 Load range H FORM SPI 1394-6 (Rev. 7/15) Part I Page 2
TYPE D 84 PASSENGER, REAR ENGINE PART I (cont.) VENDOR SPECIFICALLY IDENTIFY BID Toolbox Exterior, manufacturer standard. Size (cubic feet) 3.16 Transmission Two-way Communications Wheels Automatic Allison, PTS 3000 or equal. 45-watt, VHF, mil. spec. 6 to be compatible with tire size. Mfr. ALLISON Model no. PTS3000 Net input torque 950 Net input H.P. 300 Mfr. KENWOOD Model No. TK62GHK Size 22.5" Rim width 8.25" FORM SPI 1394-6 (Rev. 7/15) Part I Page 3
TYPE D 84 PASSENGER, REAR ENGINE PART I (cont.) Line Setting Ticket Owner s/operator s Handbook ADDITIONAL REQUIREMENTS CHASSIS AND BODY Legible copy of manufacturer s Line Setting Ticket will be delivered with each vendor s packet at the time of delivery of the bus. One copy of the chassis manufacturer s owner s/operator s handbook or manual will be furnished with each bus at time of delivery. VENDOR SPECIFICALLY IDENTIFY BID RFID Tag WSP school bus inspection identification tag. Repair Manuals Service and Cleaning Warranty A complete set of chassis, engine, transmission, and body repair manuals, including wiring diagram for all components, will be made available at time of delivery, with instructions available on accessing repair materials. Cleaning and service by vendor prior to delivery will include: Chassis lubrication. Check fluid levels: verify all are at recommended full levels. Cooling system protected at -20 F. Interior and exterior will be clean (including glass). All systems (electric, air, hydraulic, mechanical and manual) be inspected to ensure proper operation at time of delivery. All components and accessories will be installed and operational at time of delivery. A complete copy of all warranty agreements will be furnished at time of delivery. FORM SPI 1394-6 (Rev. 7/15) Part I Page 4
PUPIL TRANSPORTATION Old Capitol Building PO BOX 47200 Olympia, WA 98504-7200 (360) 725-6120 TTY (360) 664-3631 2015-16 VEHICLE DATA SHEET AND OFFICIAL PRICE QUOTATION TYPE D 84 PASSENGER VENDOR S COMPANY NAME BRYSON SALES AND SERVICE OF WASHINGTON, INC. ADDRESS 2407 GIBSON ROAD EVERETT, WA 98204 REPRESENTATIVE S NAME BRANDON BRYSON TELEPHONE NUMBER 425-953-2820 Estimated delivery date to school district from time purchase order is received: 150 to 180 ARO Firm where engine and chassis can be serviced or repaired and parts obtained: BRYSON SALES & SERVICE OF WA, INC. Firm where body can be serviced or repaired and parts obtained: BRYSON SALES & SERVICE OF WA, INC. MAKE BLUEBIRD MODEL T3RE3904 YEAR 2016 Warranty: Years 3 Miles UNLIMITED Seat color: BROWN Floor color: BLACK BODY Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 413.5" w/lift 413.5" Equipped seating capacity: w/o lift 78 w/lift 57 Overall vehicle length (inches): w/o lift 472" w/lift 472" MAKE BLUEBIRD CHASSIS Warranty: Years 3 Miles UNLIMITED MANUFACTURER CUMMINS ENGINE Torque: 660 @ 1600 RPM H.P.: 280 @ 2600 RPM MODEL T3RE390 MANUFACTURER ALLISON MODEL PTS3000 YEAR 2016 Wheel base: 259" MODEL ISB TRANSMISSION Warranty: Years 5 Speeds forward: 5 Miles 100,000 Warranty: Years 5 Miles UNLTD Number of cylinders: 6 Inline X V-type YEAR 2016 C.I.D.: 404 Fuel type: DIESEL Battery type/grp: 31 31 Number batteries: 3 3 Total CCA: 2100 2100 QUOTED PRICE Quoted price is based upon payment within 30 days after delivery to the school district (without sales tax). Bid w/o lift $ 114,955.00 VENDOR REPRESENTATIVE S SIGNATURE DATE FORM SPI 1394-6 (Rev. 7/15)
DISTRICT-SUPPORTED OPTIONS Type D-84 Passenger, Rear Engine PART II Activity Securement Seating Air Conditioning 2-passenger position seats with lap-shoulder belts in all passenger positions. To cool passenger compartment as required in the Washington State School Bus Specifications manual. FORM SPI 1394-6 (Rev. 7/15) Part II Page 1 VENDOR SPECIFICALLY IDENTIFY BID Passenger Capacity 52 Cost $ 6,500 Mfr. TRANS ARCTIC Cost $ 8,700 Alternate Fuel Mfr. CUMMINS Must comply with power and gradeability formula. Refer to CNG CNG Cost $ REFER TO CNG CATAGORY Washington State School Bus Specifications manual. Other Other Cost $ Alternator Anti-spray Device Back-up Alarm Brakes Available options. Rubber fender extenders. Must meet state specification. Air, Drum or Disc. Refer to Washington State School Bus Specifications manual. Cost $ INCLUDED Cost $ 781 Cost $ 1,018 Type C: Cost $ 150 Type D: Cost $ 300 Mfr. ECCO Cost $ 135 Color Exterior white roof. Cost $ INCLUDED Door Locks Vandal lock system on all exterior doors. Cost $ 405 Driver s Seat Fire Suppression System Suspension type, 6-way adjustable, with lumbar adjustment. Cloth panel covers. Jomarr VT-6-E-NAF, or equal engine compartment fire suppression system of appropriate size to be installed according to manufacturer recommendation. Size 240 AMP Size 275 AMP Size 300 AMP Disc Cost $ 2,516 Disc Deduct $ Drum Cost $ INCLUDED Drum Deduct $ Non-Air Mfr. NATIONAL Air Mfr. NATIONAL Cost $ INCLUDED Cost $ 218. Mfr. JOMARR Cost $ 7,212 Floor Color Nonstandard color. Cost $ 410 Fuel Tank Larger fuel capacity (Diesel only). Size: N/A Cost $ N/A
PART II (cont.) Specification DISTRICT-SUPPORTED OPTIONS Type D-84 Passenger, Rear Engine Headlights Halogen. Cost $ INCLUDED Heater (Auxiliary water) Noise Reduction Retarder Seat Belt Ready Seat Seating System Storage Compartments Auxiliary fuel-fired heating systems. Refer to Washington State School Bus Specifications Manual, page 27. Exceeding minimum specifications. Manufacturer s standard. VENDOR SPECIFICALLY IDENTIFY BID Brand: WEBASTO Cost $ 3,150 Driver compartment Cost $ 135 Engine compartment 3-passenger position seat with securement belts. Cost $ 489 Identical, non-lift bus with lap-shoulder seat belt system installed in all positions. Largest available for unit bid. Model: SCHOLASTIC Cost $ INCLUDED Full acoustical headliner Cost $ 985 Driveline Cost $ Exhaust Cost $ 400 Transmission Cost $ 7,200 2 by 2 Cost $ 11,750 Capacity 48 3 by 2 Cost $ 11,850 Capacity 60 3 by 3 Cost $ 13,750 Capacity 72 Left-side DOUBLE 28.4 CU. FT. Cost $ 1,124 Right-side DOUBLE 28.4 CU. FT Cost $ 1,124 Push-thru 122 FT. Cost $ 4,732 cubic feet. cubic feet. FORM SPI 1394-6 (Rev. 7/15) Part II Page 2
PART II (cont.) Specification DISTRICT-SUPPORTED OPTIONS Type D-84 Passenger, Rear Engine Strobe Light Student Protection System Installed Suspension Exterior roof mounted white strobe light. Electronic system to insure driver post-trip inspection of passenger compartment. Air ride (Air brake system only). VENDOR SPECIFICALLY IDENTIFY BID Mfr. SERVICE MATE Model No. SM-4213L Cost $ 185 Mfr. DORAN Model No. C-4 Cost $ 205 Front Rear Cost $ 805 Cost $ 1,350 Toolbox Interior, manufacturer standard. Cost $ 65 Deduct $ 105 Traction Device Traction Device Transmission Vehicle Securement System Video Camera Systems Installed Automatic chains. Sanders. Automatic Allison, PTS 3000 or equal. Mfr. ONSPOT Cost $ 2,350 Capacity 100 LBS Cost $ 2,350 Mfr. ALLISON Model No. PTS3000 Cost $ INCLUDED Must meet state specification. Mfr. BLUEBIRD Cost $ 500 Digital audio/video system for monitoring the passenger compartment with more than two cameras. Mfr. SEON Model No. TL4 Cost $ 2,200 How many cameras 3 FORM SPI 1394-6 (Rev. 7/15) Part II Page 3
PART II (cont.) Specification DISTRICT-SUPPORTED OPTIONS Type D-84 Passenger, Rear Engine Video Camera Systems Stop Sign Camera Installed Warning Light Monitor Additional Wheelchair/Occup ant Tie-down System Installed Wheelchair Lift Installed (Rear Engine Only) Windows Must meet state specification. 16 light monitoring system. Must meet state specification. Must meet state specification. Platform shall be a minimum of 32 x 52. Laminated passenger-compartment side or rear glass. VENDOR SPECIFICALLY IDENTIFY BID Stand Alone System Mfr. SEON Model No. TL4 Added to Interior System Mfr. SEON Model No. TL4 Cost $ 1,500 Cost $ 450 How many cameras 1 How many cameras 1 Incandescent Cost $ 205 Cost $ 205 Mfr. Q-STRAINT Model No. QRT Q-8106L Cost per station $ 715 Mfr. RICON Model No. S-5010ADA Cost $ 5,750 Side Cost $ 1,350 Rear Cost $ 105 Both Cost $ 1,455 Windows Tinted. Cost $ INCLUDED Windows Thermal pane, left of driver and service door. Cost $ 340 LED Lights FORM SPI 1394-6 (Rev. 7/15) Part II Page 4