BigDog Mowers C Series Parts Manual 00 South Ridge Road Hesston, Kansas 6706
WARNING The engine exhaust from this product contains chemicals known to the state of California to cause cancer, birth defects or other reproductive harm. NOTICE OF REQUIREMENT OF SPARK ARRESTER MUFFLER This equipment may create sparks that can start fires around dry vegetation. California Public Resources Code Section.6 provides that it is unlawful to use or operate an internal combustion engine on any forest-covered, brush-covered, or grass-covered land unless the engine is equipped with a spark arrester maintained in effective working order. A spark arrester is a device constructed of nonflammable materials specifically for the purpose of removing and retaining carbon and other flammable particles over 0.0 of an inch in size from the exhaust flow of an internal combustion engine that uses hydrocarbon fuels or which is qualified and rated by the United States Forest Service. Other states or federal areas may have similar laws. The Operator Should Contact Local Fire Agencies For Laws or Regulations Relating to Fire Prevention Requirements. THIS EQUIPMENT DOES NOT HAVE A SPARK ARRESTER AND YOU SHOULD CONTACT YOUR AUTHORIZED DEALER FOR THE PURCHASE OF A SPARK ARRESTER. Inspect spark arrester daily; replace every 500 hours or as needed. The Engine Owner s Manual provides information regarding the U.S. Environmental Protection Agency (EPA) and the California Emission Control Regulation of emission systems, maintenance and warranty. Keep Engine Owner s Manual with your unit. Should the Engine Owner s Manual become damaged or illegible, replace immediately. Replacements may be ordered per the information found in the Product Information section of the owner s manual. Federal law and California State law prohibit the following acts or the causing thereof:. The removal or rendering inoperative by any person other than for purposes of maintenance, repair, replacement, of any device or element of design incorporated into any equipment for the purposes of emissions control prior to or after its sales or delivery to the ultimate purchaser or while it is in use, or. The use of the equipment after such device or element of design has been removed or rendered inoperative by any person.
Table of Contents General Information Service Literature............................................... - Available From Your Dealer....................................... - Using This Manual.............................................. - Hardware Description Codes & Abbreviations......................... - Standard Torques............................................... - Section Frame S/N 0507 & Higher................................... - Frame S/N Prior to 0507..................................... - Engine Guard.................................................. -6 Section Hydraulic System............................................... - Pump Belt..................................................... - Transmission Assembly.......................................... -6 Transmission Service Parts....................................... -8 Steering..................................................... -0 Steering Sub-Assembly.......................................... - Park Brake................................................... - Section Wheel & Tire................................................... - Front Wheel Breakdown.......................................... - Drive Wheel Breakdown Black Rim................................ -6 Drive Wheel Breakdown Chrome Rim.............................. -7 Section 5 Engine, Briggs & Stratton 7.5/ HP S/N 0000 & Higher............ 5- Fuel System, Briggs & Stratton 7.5/ HP S/N 0000 & Higher....... 5- Engine, Briggs & Stratton 7.5/ HP S/N Prior to 0000............. 5-6 Fuel System, Briggs & Stratton 7.5/ HP S/N Prior to 0000........ 5-8 Engine Service Parts, Briggs 7.5 HP & HP....................... 5-0 Engine, Briggs & Stratton 6 HP S/N 0000 & Higher............... 5- Fuel System, Briggs & Stratton 6 HP S/N 0000 & Higher.......... 5-6 Engine, Briggs & Stratton 6 HP S/N Prior to 0000................ 5-8 Fuel System, Briggs & Stratton 6 HP S/N Prior to 0000........... 5- Engine Service Parts, Briggs 6 HP................................ 5- Engine, Kaw FR5V & FR600V S/N 0000 & Higher.............. 5-6 Fuel System, Kaw FR5V & FR600V S/N 0000 & Higher.......... 5-8 Engine, Kaw FR5V & FR600V S/N Prior to 0000............... 5-0 Fuel System, Kaw FR5V & FR600V S/N Prior to 0000.......... 5- Engine Service Parts, Kawasaki FR5V & FR600V................... 5- Engine, Kaw FR65V S/N 0000 & Higher...................... 5-6 Fuel System, Kaw FR65V S/N 0000 & Higher.................. 5-8 Engine, Kaw FR65V S/N Prior to 0000........................ 5-0 Fuel System, Kaw FR65V S/N Prior to 0000................... 5-56_07 c-
Engine Service Parts, Kawasaki FR65V............................5- Fuel Tank & Fender S/N 0000 & Higher........................5-6 Fuel Tank & Fender S/N Prior to 0000.........................5-8 Fuel Tank Service Parts S/N Prior to 050000......................5-50 Section 6 Battery........................................................6- Instrument Panel, 7 HP & HP Briggs & Stratton.....................6- Instrument Panel, 6 HP Briggs & Stratton............................6-6 Instrument Panel, Kawasaki........................................6-8 Section 7 " Service Deck................................................7- " Deck Pulleys & Spindles.......................................7- " Deck......................................................7-6 6" Service Deck................................................7-8 6" Deck Pulleys & Spindles......................................7-0 6" Deck.....................................................7-5" Service Deck...............................................7-5" Deck Pulleys & Spindles......................................7-6 5" Deck.....................................................7-8 Deck Lift......................................................7-0 Deck Mounting Hardware.........................................7- Section 8 Seat..........................................................8- c- 56_07
General Information This Manual covers BigDog C-Series models 9055, 906, 907, 90669, 90677 & 90685. Service Literature PART NO. DESCRIPTION 60 OPERATOR S MANUAL 95 WARRANTY STATEMENT 089BD SERVICE MANUAL Available From Your Dealer PART NO. DESCRIPTION PART NO. DESCRIPTION 609 " MULCH KIT 9965 CATCHER, -BAG " & 6" 60 6" MULCH KIT 9986 CATCHER, -BAG 5" 6 5" MULCH KIT 077 LED LIGHT KIT 67 HOUR METER KIT 7 STEERING ARM EXTENSION KIT 65 5 CONTAINMENT KIT 606 ARM REST KIT Note: When ordering parts, you must use the part number as shown for each part, not the index number. Always give the model and serial number to your parts and service representative. Note: Items sold in bulk such as seals and hoses are sold by the foot. Using This Manual This manual is part of a service package for the BigDog mowers. Use of this manual in conjunction with other Big- Dog mower and component manuals will provide the information necessary to service and maintain BigDog mowers. This Parts Manual provides a complete parts listing for the unit. Use this manual when ordering parts. Illustrations used were current at the time of printing, but subsequent production changes may cause your machine to vary slightly in detail. Excel Industries, Inc. reserves the right to redesign and change the machine as deemed necessary, without notification. If a change has been made to your machine which is not reflected in this parts manual, see your BigDog dealer for current information and parts. The Service Manual is a service guide for use by Service Technicians. It provides the necessary information needed to perform normal maintenance requirements on these units. The Operator's Manual provides fundamental operational information and operational safety that is needed when operating the mower. The component manuals are furnished by the various manufacturers to be used for the troubleshooting and servicing of their products. 56_07 -
Hardware Description Codes & Abbreviations The following codes are used throughout this parts manual. Refer to this list when ordering parts. ABBREVIATION DESCRIPTION ABBREVIATION DESCRIPTION CB CARRIAGE BOLT MB MACHINE BUSHING CE CLEVIS PIN MS MACHINE SCREW CN CLIP NUT NT NUT CP COTTER PIN SC SELF TAPPING CAP SCREW CS CAP SCREW SH SOCKET HEAD CW CUP WASHER SB SHOULDER BOLT FDRW FENDER WASHER SS SET SCREW FW FLAT WASHER OD OUTSIDE DIAMETER HX HEX HEAD ID INSIDE DIAMETER LW LOCK WASHER Standard Torques The following chart lists the standard torque values for the threaded fasteners found in this manual. Torque all cap screws, nuts and set screws to these values unless a different torque is shown in the Notes section next to the fastener. SIZE FT-LBS N-M SIZE FT-LBS N-M.50 8.. M.. 7 M..75 0 0 M5.5 6..8 8 65 M6 7.7 0..500 7 99 M8 8.5 5.56 05 M0 7 50.65 5 00 M 6 87.750 60 50 M 80 08.5.875 0 565 M6 60 5.00 65 850 M0 0 5 M 555 750-56_07
Section Frame S/N 0507 & Higher............................ - Frame S/N Prior to 0507............................. - Engine Guard........................................... -6 56_07 -
Frame S/N 0507 & Higher 5 6 7 8 9 0 5-56_07
Frame S/N 0507 & Higher INDEX NO. PART NO. QTY. DESCRIPTION 55068 " MOWER FRAME (WITH DECALS & RIVET NUTS) 55068 6" MOWER FRAME (WITH DECALS & RIVET NUTS) 550685 5" MOWER FRAME (WITH DECALS & RIVET NUTS) 60 BIG DOG LOGO DECAL 777 MADE IN USA DECAL 0879 SERIAL NUMBER / SPEC DECAL 5 600 HOT DECAL 6 60967 ENGINE COMPARTMENT DECAL 7 7859 LS STEERING DECAL 8 6099 SAFE OPERATION DECAL 9 600899 PUMP BELT WARNING DECAL 0 7850 RS STEERING DECAL 80885 5/6-8 THREAD RIVET NUT 60 C DECAL 55099 BUMPER (WITH DECAL) 05606 CS.75-6 X.5 HX G5 5 06899 NT.75-6 HX FLK ZNYC NOTES:. Serial Number plate. In the event the serial number tag becomes damaged or illegible, please contact your dealer to order a replacement.. EPA compliance plate.. Patent numbers plate. 56_07 -
Frame S/N Prior to 0507 5 7 6 8 9 8 0 8-56_07
Frame S/N Prior to 0507 INDEX NO. PART NO. QTY. DESCRIPTION 55068 " FRAME (WITH DECALS & RIVET NUTS) 55068 6" FRAME (WITH DECALS & RIVET NUTS) 550685 5" FRAME(WITH DECALS & RIVET NUTS) 60987 STEP TREAD 80885 5/6-8 THREAD RIVET NUT 7850 RS STEERING DECAL 5 600899 PUMP BELT WARNING DECAL 6 600 HOT DECAL 7 60967 ENGINE COMPARTMENT DECAL 8 N/A SERIAL NUMBER / SPEC DECAL 9 7859 LS STEERING DECAL 0 777 MADE IN USA DECAL 60 BIG DOG LOGO DECAL 6099 SAFE OPERATION DECAL 60 C DECAL 60 C6 DECAL 6075 C5 DECAL 60 STEP TREAD NOTES:. In the event the serial number tag becomes damaged or illegible, please contact your dealer to order a replacement.. EPA compliance plate.. Patent numbers plate. 56_07-5
Engine Guard INDEX NO. PART NO. QTY DESCRIPTION 9000 BUMPER GUARD PLATE 068 CS.75-6 X.50 HX G5 76795 FW.06 X.8 X.060 SAE 086660 NT.75-6 HXZY NL NOTES: -6 56_07
Section Hydraulic System........................................ - Pump Belt............................................. - Transmission Assembly................................... -6 Transmission Service Parts................................ -8 Steering............................................. -0 Steering Sub-Assembly.................................. - Park Brake............................................ - 56_07 -
Hydraulic System 5 5 6 7 7-56_07
Hydraulic System INDEX NO. PART NO. QTY. DESCRIPTION 70087 CS.-8 X.50 HX G5 0067 CS.-8 X.00 HX G5 Z 7685 6 FW. X.687 X.05/.080H 797 TOWLINK ROD 5 0855 CP.06D X.00 LG HML Z 6 N/A TRANSMISSION ASSEMBLY 7 07 8 NT 0.-8 HX G5. Torque to 7 ft-lbs. NOTES: 56_07 -
Pump Belt 8 9 0 0 5 6 7 0 8 9-56_07
Pump Belt INDEX NO. PART NO. QTY. DESCRIPTION 8 0766 CS.500- X.75 HX G5 9 6098 CS.65- X.5 HX G5 ZY 0 088 FW.65 X.00 X. ZNYC 068 SPRING / COIL PL. 079 PUMP IDLER 6006 BEARING DISC 6005 BUSHING 5 78567 NT.500- HX G8 ZY NL 6 6098 IDLER SPACER 7 7887 IDLER PULLEY.00" OD 8 0697 NT.65- HX G5 ZNYC 9 769 BELT. Torque to 00 ft-lbs. NOTES: 56_07-5
Transmission Assembly 5 8 7 6 0 8 9-6 56_07
Transmission Assembly INDEX NO. PART NO. QTY. DESCRIPTION 05606 CS.75-6 X.5 HX G5 00 HYDROSTAT CROSS BRACE 76795 8 FW.06 X.8 X.060 SAE 0550 NT.75-6 HX G5 ZNY 5 6009 RS TRANSMISSION 6 60090 LS TRANSMISSION 7 0009 BRAKE ACTUATOR ROD 8 06855 NT.50-0 HX ZY NL 9 76855 FW.8 X.65 X.05/.080H 0 60 SPRING NOTES: 56_07-7
Transmission Service Parts 5 6 INDEX NO. PART NO. QTY. DESCRIPTION 609 FAN/PULLEY KIT 60 BOLT HUB KIT (INCLUDES NUT) 788877 HUB NUT 7987 RETAINING RING 5 7986 PARK BRAKE GEAR 6 79507 PARKING PAWL KIT NOTES: -8 56_07
This page intentionally left blank. 56_07-9
Steering STEERING SUB-ASSEMBLY 5 6 8 9 7 0 7-0 56_07
Steering INDEX NO. PART NO. QTY. DESCRIPTION 600 STEERING DAMPER 789 BALL STUD 7685 7 FW. X.687 X.05/.080H 0655 NT.- HX ZY NL 5 789 LOCK COLLAR 0.757 ID 6 60098 PUMP ROD 7 07 NT.-8 HX G5 ZNYC 8 080 CS.-8 X.75 HX G5 9 00 PIVOT TUBE 0 09876 LW. INT-EXT TOOTH 606 CAP LOCK NOTES: 56_07 -
Steering Sub-Assembly LEFT SIDE SHOWN RIGHT SIDE SIMILAR 5 6 7 8 0 9 9-56_07
Steering Sub-Assembly INDEX NO. PART NO. QTY. DESCRIPTION 7860 STEERING BAR GRIP 070 STEERING BAR (WITH GRIP) 0550 NT.75-6 HX G5 ZNY 76795 FW.79 X.8 X.06 SAE 5 0089 CONTROL LEVER 6 6086 CS.75-6 X.50 BH BO 7 79665 BALL JOINT LINK 8 0655 NT.- HX NL ZN 9 770867 BUSHING 0 70578 CS.75-6 X.75 HX G5 7685 FW. X.687 X.05/.080H 086660 NT.75-6 HX NL G5 0008 LS STEERING BOX 0007 RS STEERING BOX (NOT SHOWN) NOTES: 56_07 -
Park Brake 0 RIGHT SIDE SHOWN LEFT SIDE SIMILAR 6 BALL JOINT LINK 7 5 6 7 5 9 8-56_07
Park Brake INDEX NO. PART NO. QTY. DESCRIPTION 000 LS BRAKE ACTUATOR 0000 RS BRAKE ACTUATOR 7659 BUSHING 608 NUT PLATE.0 CENTERS 5 78 PUSH BUTTON SWITCH 6 086660 NT.75-6 HX ZY NL 7 76795 FW.06 X.8 X.060 SAE 8 75796 CS.75-6 X.00 HX G8 Z 9 0698 CS 0- X.75 HXFLK ZN 0 0855 CP.06D X.00 LG HML Z 7685 8 FW. X.687 X.05/.080H 0655 NT.- HX ZY NL 0009 BRAKE ACTUATOR ROD 06855 NT.50-0 HXZY NL 5 76855 FW.8 X.65 X.05/.080H 6 60 SPRING. Part of the wire harness. NOTES: 56_07-5
-6 56_07
Section Wheel & Tire........................................... - Front Wheel Breakdown.................................. - Drive Wheel Breakdown Black Rim........................ -6 Drive Wheel Breakdown Chrome Rim...................... -7 56_07 -
Wheel & Tire 6 7 5 9 8 8 0-56_07
Wheel & Tire INDEX NO. PART NO. QTY. DESCRIPTION 78866 PLASTIC WHEEL ASSEMBLY (WITH HARDWARE) 67 6 FW.50 X.5 X.87 SPL 78567 NT.500- NL G5 6096 TIRE/WHEEL 8 X 8.5-8 (BLACK RIMS " & 6" DECKS) 6080 TIRE/WHEEL 8 X 8.5-8 (CHROME RIMS " & 6" DECKS) 6055 TIRE/WHEEL 8 X 9.5-8 (BLACK RIMS 5" DECKS) 786 TIRE/WHEEL 8 X 9.5-8 (CHROME RIMS 5" DECKS) 5 06077 8 WHEEL NUT 6 70595 CS.500- X.5 HS G5 7 7976 FW.5 X.75 X.5 8 78 BEARING 9 7860 SPACER 0 N/A FRONT WHEEL SUB-ASSEMBLY 78708 CS.500- X.5 HX G5 76796 FW.5 X.06 X.090 SAE 0997 PLASTIC WHEEL 0599 NT.500- HX JAM ZNYC. Torque to 65 75 ft-lbs. NOTES: 56_07 -
Front Wheel Breakdown 5 6 7 6 8 7-56_07
Front Wheel Breakdown INDEX NO. PART NO. QTY. DESCRIPTION 9006 CASTER FORK 78567 NT.500- HX G8 ZY NL 76796 FW.5 X.06 X.090 SAE 060 CS.500- X 6.50 HX G5 Z 5 06969 GAUGE WHEEL SPACER 6 6096 TIRE/WHEEL X -5 (SMOOTH) 7680 TIRE/WHEEL X -5 (RIBBED) 7 77806 BEARING CAP 8 778 /" ROLLER BEARING NOTES: 56_07-5
Drive Wheel Breakdown Black Rim 6096 TIRE/WHEEL ASSEMBLY (" & 6" DECKS) INDEX NO. PART NO. QTY. DESCRIPTION 6067 TIRE 8 X 8.50 6096 WHEEL 8 X 6 095 TIRE VALVE 6055 TIRE/WHEEL ASSEMBLY (5" DECKS) INDEX NO. PART NO. QTY DESCRIPTION 787 TIRE 8 X 9.5-8 6056 WHEEL 8.00 X 6 095 TIRE VALVE NOTES: -6 56_07
Drive Wheel Breakdown Chrome Rim 6080 TIRE/WHEEL ASSEMBLY (" & 6" DECKS) INDEX NO. PART NO. QTY. DESCRIPTION 608 TIRE 8 X 8.50 6080 WHEEL 8 X 6.9 095 TIRE VALVE 786 TIRE/WHEEL ASSEMBLY (5" DECKS) INDEX NO. PART NO. QTY DESCRIPTION 787 TIRE 8 X 9.5-8 7880 WHEEL 8.00 X 6. 095 TIRE VALVE NOTES: 56_07-7
-8 56_07
Section 5 Engine, Briggs & Stratton 7.5/ HP............................. 5- Fuel System, Briggs & Stratton 7.5/ HP S/N 0000 & Higher..... 5-5 Fuel System, Briggs & Stratton 7.5/ HP S/N Prior to 0000...... 5-7 Engine Service Parts, Briggs 7.5 HP & HP...................... 5-9 Engine, Briggs & Stratton 6 HP................................ 5- Fuel System, Briggs & Stratton 6 HP S/N 0000 & Higher....... 5-5 Fuel System, Briggs & Stratton 6 HP S/N Prior to 0000........ 5-7 Engine Service Parts, Briggs 6 HP............................. 5-9 Engine, Kaw FR5V & FR600V................................ 5- Fuel System, Kaw FR5V & FR600V S/N 0000 & Higher...... 5- Fuel System, Kaw FR5V & FR600V S/N Prior to 0000........ 5-5 Engine Service Parts, Kawasaki FR5V & FR600V................ 5-7 Engine, Kaw FR65V........................................ 5-9 Fuel System, Kaw FR65V S/N 0000 & Higher............... 5- Fuel System, Kaw FR65V S/N Prior to 0000................ 5- Engine Service Parts, Kawasaki FR65V......................... 5-5 Fuel Tank & Fender S/N 0000 & Higher..................... 5-7 Fuel Tank & Fender S/N Prior to 0000...................... 5-9 Fuel Tank Service Parts S/N 05000 & Higher.................. 5- Fuel Tank Service Parts S/N Prior to 05000................... 5-56_07 5-
Engine, Briggs & Stratton 7.5/ HP 8 RED BLK 9 0 RED 5 6 7 0 5 TO BATTERY 6 9 5A FUSE 0 7 8 5 9 0 5 5-56_07
Engine, Briggs & Stratton 7.5/ HP INDEX NO. PART NO. QTY. DESCRIPTION N/A BRIGGS & STRATTON 7.5/ HP ENGINE 6006 SC # 8 X.00 PHCR BO 608 BRIGGS CONTACT COVER 07 NT.-8 HX G5 ZNYC 5 7685 8 FW. X.687 X.05/.080H 6 608 NEGATIVE BATTERY CABLE 7 09876 LW. INT-EXT TOOTH 8 778 RED BATTERY CABLE BOOT 9 097 NT.50-0 HX G5 ZNYC 0 76855 5 FW.8 X.65 X.05/.080H 6006 POSITIVE BATTERY CABLE 6080 POSITIVE BATTERY CABLE 055 NT #0- HX ZN 05599 CS.50-0 X.75 HX G5 5 0087 STARTER SOLENOID 6 6088 OIL DRAIN - /8-8 NPTF 7 606 8" OIL DRAIN HOSE 8 6098 CN.50-0 X.5 MAX THK 9 0506 CS.-8 X.75 HX G5 0 77 KEY / SQ X 0.66 LG 79760 ENGINE PULLEY 6080K CLUTCH KIT (WITH PIGTAIL) 795 CLUTCH HARNESS PIGTAIL 60680 FW.5 X. X.9 HRD 5 608 CS.7-0 X.5 HX G5 P85 NOTES:. Part of the wire harness.. The pigtail is supplied with the clutch.. Torque the bolt to 5 8 ft-lbs. Replace (do not reuse) the cap screw if it s removed or loosened. Use only hand tools to install this fastener. 56_07 5-
Fuel System, Briggs & Stratton 7.5/ HP S/N 0000 & Higher B 7 9 FUEL FILTER 8 9 9 9 A D 0 6 6 C 7 E 7 5 7 5-56_07
Fuel System, Briggs & Stratton 7.5/ HP S/N 0000 & Higher INDEX NO. PART NO. QTY. DESCRIPTION 6 60 CLAMP, /6" 7 606 67" /6" VAPOR LINE 8 608 PLASTIC TEE, /6" 9 000 HOSE CLAMP 0 06 CS.75-6 X.00 HX G5 00098 LOOP CLAMP 6057 VACUUM BREAKER 000 5 WIRE TIE 0588 " /" FUEL LINE 5 06899 NT.75-6 HX FLK ZNYC 6 76795 FW.06 X.8 X.060 SAE 7 606 VACUUM BREAKER FILTER NOTES: FUEL & VAPOR LINE LENGTHS A 9" TANK TO FUEL FILTER (FUEL) B " TANK TO TEE (VAPOR) C " TEE TO VACUUM BREAKER (VAPOR) D " FUEL FILTER TO ENGINE (FUEL) E " ENGINE TO TEE (VAPOR) 56_07 5-5
Fuel System, Briggs & Stratton 7.5/ HP S/N Prior to 0000 B 9 9 FUEL FILTER 8 9 9 9 A D 0 6 6 9 C 6 9 E 7 5 7 5-6 56_07
Fuel System, Briggs & Stratton 7.5/ HP S/N Prior to 0000 INDEX NO. PART NO. QTY. DESCRIPTION 6 60 CLAMP, /6" 7 606 " /6" VAPOR LINE 8 6005 PLASTIC TEE /" X /" X /6" 9 000 8 HOSE CLAMP 0 06 CS.75-6 X.00 HX G5 00098 LOOP CLAMP 608 VACUUM BREAKER 000 5 WIRE TIE 0588 56" /" FUEL LINE 5 06899 NT.75-6 HX FLK ZNYC 6 76795 FW.06 X.8 X.060 SAE 7 606 VACUUM BREAKER FILTER NOTES: FUEL & VAPOR LINE LENGTHS A 9" TANK TO FUEL FILTER (FUEL) B " TANK TO TEE (VAPOR) C " TEE TO VACUUM BREAKER (VAPOR) D " FUEL FILTER TO ENGINE (FUEL) E " ENGINE TO TEE (VAPOR) 56_07 5-7
Engine Service Parts, Briggs 7.5 HP & HP INDEX NO. PART NO. QTY. DESCRIPTION 06878 IN-LINE FUEL FILTER 6086 AIR PRECLEANER FILTER, FLAT PANEL (7.5 HP) 6088 AIR PRECLEANER FILTER ( HP) 6087 AIR FILTER, FLAT PANEL (7.5 HP) 6089 AIR FILTER, CARTRIDGE ( HP) 6085 OIL FILTER NOTES: 5-8 56_07
This page intentionally left blank. 56_07 5-9
Engine, Briggs & Stratton 6 HP 5 6 8 9 0 7 5-0 56_07
Engine, Briggs & Stratton 6 HP INDEX NO. PART NO. QTY. DESCRIPTION N/A BRIGGS & STRATTON 6 HP ELS ENGINE 6006 SC # 8 X.00 PHCR BO 60 STATIC COVER ASSEMBLY 6088 OIL DRAIN - /8-8 NPTF 5 606 OIL DRAIN HOSE 6 6089 MUFFLER 7 79788 SC.75-6 X.0 HX FL STP 8 000 WIRE TIE 9 795 CLUTCH HARNESS PIGTAIL 0 77 KEY / SQ X 0.66 LG 79760 ENGINE PULLEY 6078K CLUTCH KIT (WITH PIGTAIL) 60680 FW.5 X. X.9 HRD 608 CS.7-0 X.5 HX G5 P85 NOTES:. Torque to 5 8 ft-lbs. Replace (do not reuse) the cap screw if it s removed or loosened. Use only hand tools to install this fastener.. Torque to 0 ft-lbs.. Supplied with the engine.. Torque to 7.5 ft-lbs. 56_07 5-
Engine, Briggs & Stratton 6 HP 5 5A FUSE 0 6 7 5 6 7 8 RED 5 7 9 5 BLK 5 6 6 7 5 7 8 5-56_07
Engine, Briggs & Stratton 6 HP INDEX NO. PART NO. QTY. DESCRIPTION 5 778 RED BATTERY CABLE BOOT 6 097 NT.50-0 HX G5 ZNYC 7 76855 5 FW.8 X.65 X.05/.080H 8 6080 POSITIVE BATTERY CABLE 9 0087 STARTER SOLENOID 0 6006 POSITIVE BATTERY CABLE 055 NT #0- HX ZN 05599 CS.50-0 X.75 HX G5 07 NT.-8 HX G5 ZNYC 7685 FW. X.687 X.05/.080H 5 09876 LW. INT-EXT TOOTH 6 608 NEGATIVE BATTERY CABLE 7 6098 CN.50-0 X.5 MAX THK 8 0506 CS.-8 X.75 HX G5 5. Part of the wire harness. NOTES: 56_07 5-
Fuel System, Briggs & Stratton 6 HP S/N 0000 & Higher A 0 5 8 6 8 9 C 0 D 8 B 7 9 5-56_07
Fuel System, Briggs & Stratton 6 HP S/N 0000 & Higher INDEX NO. PART NO. QTY. DESCRIPTION 9 0588 8" /" FUEL LINE 0 000 HOSE CLAMP 00098 LOOP CLAMP 6057 VACUUM BREAKER 608 PLASTIC TEE, /6" 606 75" /6" VAPOR LINE 5 06 CS.75-6 X.00 HX G5 6 60 CLAMP, /6" 7 06899 NT.75-6 HX FLK ZNYC 8 76795 FW.06 X.8 X.060 SAE 9 606 VACUUM BREAKER FILTER NOTES: FUEL LINE LENGTHS A " TANK TO TEE (VAPOR) B " TEE TO VACUUM BREAKER (VAPOR) C 8" TANK TO ENGINE (FUEL) D 0" TEE TO ENGINE (VAPOR) 56_07 5-5
Fuel System, Briggs & Stratton 6 HP S/N Prior to 0000 A 9 0 0 5 8 6 0 8 9 B 0 8 6 9 C 0 7 D 9 5-6 56_07
Fuel System, Briggs & Stratton 6 HP S/N Prior to 0000 INDEX NO. PART NO. QTY. DESCRIPTION 9 0588 6" /" FUEL LINE 0 000 6 HOSE CLAMP 00098 LOOP CLAMP 608 VACUUM BREAKER 6005 PLASTIC TEE /" X /" X /6" 606 0" /6" VAPOR LINE 5 06 CS.75-6 X.00 HX G5 6 60 CLAMP, /6" 7 06899 NT.75-6 HX FLK ZNYC 8 76795 FW.06 X.8 X.060 SAE 9 606 VACUUM BREAKER FILTER NOTES: FUEL LINE LENGTHS A " TANK TO TEE (VAPOR) B " TEE TO VACUUM BREAKER (VAPOR) C 8" TANK TO ENGINE (FUEL) D 0" TEE TO ENGINE (VAPOR) 56_07 5-7
Engine Service Parts, Briggs 6 HP INDEX NO. PART NO. QTY. DESCRIPTION 6057 AIR PRECLEANER FILTER 60570 AIR FILTER, CARTRIDGE 06878 IN-LINE FUEL FILTER 6057 OIL FILTER NOTES: 5-8 56_07
This page intentionally left blank. 56_07 5-9
Engine, Kaw FR5V & FR600V RED/BLK 6 5A FUSE RED 6 7 8 5 7 7 5 9 0 BLK 8 5 0 9 5 0 9 6 7 8 5-0 56_07
Engine, Kaw FR5V & FR600V INDEX NO. PART NO. QTY. DESCRIPTION N/A KAWASAKI FR5V & FR600V ENGINE 970 CABLE GUIDE 00098 LOOP CLAMP 06 CS.75-6 X.00 HX G5 5 7685 FW. X.687 X.05/.080H 6 06899 NT.75-6 HX FLK ZNYC 7 7056 CS M8 X.5 X 6 HX G0.9 8 60999 MUFFLER 9 09876 LW. INT-EXT TOOTH 0 608 NEGATIVE BATTERY CABLE 778 RED BATTERY CABLE BOOT 097 NT.50-0 HX G5 ZNYC 76855 FW.8 X.65 X.05/.080H 6006 POSITIVE BATTERY CABLE 5 05599 CS.50-0 X.75 HX G5 6 055 NT #0- HX ZN 7 0087 STARTER SOLENOID 8 7976 POSITIVE BATTERY CABLE 9 000 WIRE TIE 0 6098 CN.50-0 X.5 MAX THK 76795 6 FW.06 X.8 X.060 SAE 60580 CS.75-6 X.5 HX G5 P85 79760 ENGINE PULLEY 77 KEY / SQ X 0.66 LG 5 6080K CLUTCH KIT (WITH PIGTAIL) 6 795 CLUTCH HARNESS PIGTAIL 7 60680 FW.5 X. X.9 HRD 8 608 CS.7-0 X.5 HX G5 P85 9 7965 OIL DRAIN VALVE 0 606 " OIL DRAIN HOSE NOTES:. Part of the wire harness.. Supplied with the engine.. Torque to 5 8 ft-lbs. Replace (do not reuse) the cap screw if it s removed or loosened. Use only hand tools to install this fastener.. Torque to 0 5 ft-lbs. Replace (do not reuse) the cap screw if it s removed or loosened. Use only hand tools to install this fastener. 5. Torque to ft-lbs. 56_07 5-
Fuel System, Kaw FR5V & FR600V S/N 0000 & Higher A B 5 C D 6 6 7 5-56_07
Fuel System, Kaw FR5V & FR600V S/N 0000 & Higher INDEX NO. PART NO. QTY. DESCRIPTION 000 HOSE CLAMP 60 CLAMP, /6" 0588 5" /" FUEL LINE 606 59" /6" VAPOR LINE 5 608 PLASTIC TEE, /6" 6 6057 VACUUM BREAKER 7 606 VACUUM BREAKER FILTER NOTES: FUEL & VAPOR LINE LENGTHS A 5" TANK TO FUEL FILTER (FUEL) B " TANK TO TEE (VAPOR) C " TEE TO VACUUM BREAKER (VAPOR) D " TEE TO ENGINE PURGE PORT (VAPOR) 56_07 5-
Fuel System, Kaw FR5V & FR600V S/N Prior to 0000 A B 5 C D 6 6 7 5-56_07
Fuel System, Kaw FR5V & FR600V S/N Prior to 0000 INDEX NO. PART NO. QTY. DESCRIPTION 000 6 HOSE CLAMP 60 CLAMP, /6" 0588 0" /" FUEL LINE 606 " /6" VAPOR LINE 5 6005 PLASTIC TEE /" X /" X /6" 6 608 VACUUM BREAKER 7 606 VACUUM BREAKER FILTER NOTES: FUEL & VAPOR LINE LENGTHS A 5" TANK TO FUEL FILTER (FUEL) B " TANK TO TEE (VAPOR) C " TEE TO VACUUM BREAKER (VAPOR) D " TEE TO ENGINE PURGE PORT (VAPOR) 56_07 5-5
Engine Service Parts, Kawasaki FR5V & FR600V INDEX NO. PART NO. QTY. DESCRIPTION 600 AIR FILTER 06878 IN-LINE FUEL FILTER 6058 ENGINE OIL FILTER NOTES: 5-6 56_07
This page intentionally left blank. 56_07 5-7
Engine, Kaw FR65V 8 5A FUSE 5 RED/BLK 6 7 0 6 RED 7 8 9 0 5 BLK 7 5 8 9 0 0 9 8 5 6 7 5-8 56_07
Engine, Kaw FR65V INDEX NO. PART NO. QTY. DESCRIPTION N/A KAWASAKI FR65V ENGINE 970 CABLE GUIDE 00098 LOOP CLAMP 06 CS.75-6 X.00 HX G5 5 7685 FW. X.687 X.05/.080H 6 06899 NT.75-6 HX FLK ZNYC 7 7056 CS M8 X.5 X 6 HX G0.9 8 6050 MUFFLER 9 09876 LW. INT-EXT TOOTH 0 608 NEGATIVE BATTERY CABLE 778 RED BATTERY CABLE BOOT 097 NT.50-0 HX G5 ZNYC 76855 FW.8 X.65 X.05/.080H 6006 POSITIVE BATTERY CABLE 5 05599 CS.50-0 X.75 HX G5 6 055 NT #0- HX ZN 7 0087 STARTER SOLENOID 8 7976 POSITIVE BATTERY CABLE 9 6098 CN.50-0 X.5 MAX THK 0 76795 6 FW.06 X.8 X.060 SAE 60580 CS.75-6 X.5 HX G5 P85 79760 ENGINE PULLEY 77 KEY / SQ X 0.66 LG 6078K CLUTCHKIT (WITH PIGTAIL) 5 795 CLUTCH HARNESS PIGTAIL 6 60680 FW.5 X. X.9 HRD 7 608 CS.7-0 X.5 HX G5 P85 8 7965 OIL DRAIN VALVE 9 606 " OIL DRAIN HOSE 0 000 WIRE TIE NOTES:. Part of the wire harness.. Supplied with the engine.. Torque to 5 8 ft-lbs. Replace (do not reuse) the cap screw if it s removed or loosened. Use only hand tools to install this fastener.. Torque to 0 5 ft-lbs. Replace (do not reuse) the cap screw if it s removed or loosened. Use only hand tools to install this fastener. 5. Torque to ft-lbs. 56_07 5-9
Fuel System, Kaw FR65V S/N 0000 & Higher A 6 7 B 0 7 0 D 7 0 C 7 0 6 5 8 5-0 56_07
Fuel System, Kaw FR65V S/N 0000 & Higher INDEX NO. PART NO. QTY. DESCRIPTION 000 HOSE CLAMP 60 CLAMP, /6" 608 PLASTIC TEE, /6" 00098 LOOP CLAMP 5 6005 VACUUM BREAKER 6 0588 5" /" FUEL LINE 7 606 59" /6" VAPOR LINE 8 606 VACUUM BREAKER FILTER NOTES: FUEL & VAPOR LINE LENGTHS A 5" TANK TO ENGINE (FUEL) B " TANK TO TEE (VAPOR) C " TEE TO VACUUM BREAKER (VAPOR) D " TEE TO ENGINE (VAPOR) 56_07 5-
Fuel System, Kaw FR65V S/N Prior to 0000 A 6 7 0 6 B 0 D 7 0 C 6 0 6 5 8 5-56_07
Fuel System, Kaw FR65V S/N Prior to 0000 INDEX NO. PART NO. QTY. DESCRIPTION 000 6 HOSE CLAMP 60 CLAMP, /6" 6005 PLASTIC TEE /" X /" X /6" 0570 LOOP CLAMP 5 608 VACUUM BREAKER 6 0588 0" /" FUEL LINE 7 606 " /6" VAPOR LINE 8 606 VACUUM BREAKER FILTER NOTES: FUEL & VAPOR LINE LENGTHS A 5" TANK TO ENGINE (FUEL) B " TANK TO TEE (VAPOR) C " TEE TO VACUUM BREAKER (VAPOR) D " TEE TO ENGINE (VAPOR) 56_07 5-
Engine Service Parts, Kawasaki FR65V INDEX NO. PART NO. QTY. DESCRIPTION 60059 AIR FILTER 06878 IN-LINE FUEL FILTER 6058 ENGINE OIL FILTER NOTES: 5-56_07
This page intentionally left blank. 56_07 5-5
Fuel Tank & Fender S/N 0000 & Higher 5 5 5 5 5-6 56_07
Fuel Tank & Fender S/N 0000 & Higher INDEX NO. PART NO. QTY. DESCRIPTION 6076 RS FENDER 6050 LS FENDER FUEL TANK ASSEMBLY (S/N 05000 & HIGHER) 6059 LS FENDER FUEL TANK ASSEMBLY (S/N 0000 050000) 6050 LS FENDER FUEL TANK ASSEMBLY (S/N 0000 00000) 60807 RATCHETING GAS CAP,.5" 7685 8 FW. X.687 X.05/.080H 5 080 6 CS.-8 X.750 HX G5. Torque to 7 ft-lbs. NOTES: 56_07 5-7
Fuel Tank & Fender S/N Prior to 0000 5 5 5 5 5-8 56_07
Fuel Tank & Fender S/N Prior to 0000 INDEX NO. PART NO. QTY. DESCRIPTION 6076 RS FENDER 6050 LS TANK FENDER ASSEMBLY 60807 RATCHETING GAS CAP,.5" 7685 8 FW. X.687 X.05/.080H 5 080 6 CS.-8 X.750 HX G5. Torque to 7 ft-lbs. NOTES: 56_07 5-9
Fuel Tank Service Parts S/N 05000 & Higher INDEX NO. PART NO. QTY. DESCRIPTION 6087 VENT FITTING 60559 SUCTION HOSE ASSEMBLY 6000 GROMMET NOTES: 5-0 56_07
Fuel Tank Service Parts S/N Prior to 05000 S/N PRIOR TO 066 S/N 0000 050000 6 5 S/N 066 00000 5 INDEX NO. PART NO. QTY. DESCRIPTION 78 VENT FITTING KIT 6099 FUEL VENT VALVE 6000 GROMMET 60896 SUCTION HOSE ASSEMBLY 0.5" 5 78595 GROMMET 6 6087 VENT FITTING NOTES: 56_07 5-
5-56_07
Section 6 Battery................................................ 6- Instrument Panel, 7 HP & HP Briggs & Stratton............. 6- Instrument Panel, 6 HP Briggs & Stratton.................... 6-6 Instrument Panel, Kawasaki............................... 6-8 56_07 6-
Battery 7 5 POSITIVE CABLE (RED) 6 5 5 6 5 NEGATIVE CABLE (BLACK) 0 8 9 6-56_07
Battery INDEX NO. PART NO. QTY. DESCRIPTION 6090 CS.50-0 X 6.50 HX G5 76855 FW.8 X.65 X.05/.080H 87 BATTERY CLAMP STRAP 05599 CS.50-0 X.75 HX G5 ZN 5 09868 LW.50 INT-EXT TOOTH Z 6 097 NT.50-0 HX G5 ZNYC 7 778 RED BATTERY CABLE BOOT 8 6098 CN.50-0 X.5 MAX THK 9 796 GROMMET 0 000 WIRE TIE NOTES: 56_07 6-
Instrument Panel, 7 HP & HP Briggs & Stratton 0 9 5 0 0 6 7 8 9 5 6-56_07
Instrument Panel, 7 HP & HP Briggs & Stratton INDEX NO. PART NO. QTY. DESCRIPTION 77676 PTO SWITCH 785808 KEY ASSEMBLY 05898 IGNITION SWITCH 6005 SEALED RELAY (WITH BRACKET) 5 60098 CB 0- X.50 ZYNC 6 000 5 WIRE TIE 7 6080 THROTTLE/CHOKE CABLE 8 709 FW.9 X.50 X.08 ZNYC 9 0598 NT #0- HX NL ZN 0 76855 FW.8 X.65 X.05/.080H 05597 CS.50-0 X.50 HX G5 550 INSTRUMENT PANEL (WITH DECAL) 608 INSTRUMENT PANEL DECAL 60676 WIRE HARNESS 5 05 CLUTCH CONNECTOR REPAIR KIT. Part of the wire harness. NOTES: 56_07 6-5
Instrument Panel, 6 HP Briggs & Stratton 0 0 9 0 9 9 8 5 6 7 8 5 6-6 56_07
Instrument Panel, 6 HP Briggs & Stratton INDEX NO. PART NO. QTY. DESCRIPTION 77676 PTO SWITCH 785808 KEY ASSEMBLY 05898 IGNITION SWITCH 60098 CB 0- X.50 ZYNC 5 000 5 WIRE TIE 6 60555 0" THROTTLE/CHOKE CABLE 7 709 FW.9 X.50 X.08 ZNYC 8 0598 NT #0- HX NL ZN 9 76855 FW.8 X.65 X.05/.080H 0 05597 CS.50-0 X.50 HX G5 550 INSTRUMENT PANEL (WITH DECAL) 608 INSTRUMENT PANEL DECAL 60676 WIRE HARNESS 6005 SEALED RELAY (WITH BRACKET) 5 05 CLUTCH CONNECTOR REPAIR KIT. Part of the wire harness. NOTES: 56_07 6-7
Instrument Panel, Kawasaki 0 5 6 7 8 9 0 6 5 6-8 56_07
Instrument Panel, Kawasaki INDEX NO. PART NO. QTY. DESCRIPTION 60097 CHOKE CABLE 77676 PTO SWITCH 785808 KEY ASSEMBLY 05898 IGNITION SWITCH 5 6005 SEALED RELAY (WITH BRACKET) 6 60098 CB 0- X.50 ZYNC 7 000 5 WIRE TIE 8 60096 THROTTLE CABLE 9 709 FW.9 X.50 X.08 ZNYC 0 0598 NT #0- HX NL ZN 05597 CS.50-0 X.50 HX G5 76855 FW.8 X.65 X.05/.080H 6009 INSTRUMENT PANEL DECAL 55090 INSTRUMENT PANEL (WITH DECAL) 5 60676 WIRE HARNESS 6 05 CLUTCH CONNECTOR REPAIR KIT. Part of the wire harness. NOTES: 56_07 6-9
6-0 56_07
Section 7 " Service Deck........................................ 7- " Deck Pulleys & Spindles............................... 7- " Deck.............................................. 7-6 6" Service Deck........................................ 7-8 6" Deck Pulleys & Spindles............................. 7-0 6" Deck............................................. 7-5" Service Deck....................................... 7-5" Deck Pulleys & Spindles............................. 7-6 5" Deck............................................. 7-8 Deck Lift.............................................. 7-0 Deck Mounting Hardware................................ 7-56_07 7-
" Service Deck 5 6 7-56_07
" Service Deck INDEX NO. PART NO. QTY DESCRIPTION 5509 " DECK (WITH DECALS & HARDWARE) 60069 CN.-8 X.00 MAX THK 606 DISCHARGE CHUTE DECAL 6087 DECK DANGERS DECAL 5 6089 THROWN OBJECTS DECAL 6 60 BELT ROUTING DECAL NOTES: 56_07 7-
" Deck Pulleys & Spindles 7 6 5 8 9 0 5 0 5 6 7 9 8 7-56_07
" Deck Pulleys & Spindles INDEX NO. PART NO. QTY DESCRIPTION 796 CS.65- X.50 HX G5 068 FW.656 X.00 X.078 ZNYC 7979 FW.650 X.5 X.8 ZNYC G5 7850 IDLER PULLEY 5.0" OD 5 09770 IDLER SLIDE 6 068 SPRING / COIL PL. 7 598 CHAIN, LINK 8 7899 CS.-8 X.5 FLT SH 9 6069 IDLER SLIDE UHMW 0 70595 CS.500- X.5 HS G5 7887 CS.65- X.5 HX G5 Z 79860 FW.55 X.65 X.5 HD ZY 787 CW.6 X.5 X.87 PNT 79778 DECK SPINDLE PULLEY 0550 8 NT.75-6 HX G5 ZNY 76795 6 FW.79 X.8 X.06 SAE 5 6080 SPINDLE ASSEMBLY 78506 BLADE SPINDLE 6 0056 8 CS.75-6 X.75 HX G5 7 05765 FW.00 X.50 X. 8 058776 NT.-8 HX ZY NL 9 7685 FW. X.687 X.05/.080H 0 78567 NT.500- NL G5 78866 PLASTIC WHEEL ASSEMBLY (WITH HARDWARE) 78708 CS.500- X.5 HX G5 76796 FW.5 X.06 X.090 SAE 0997 PLASTIC WHEEL 5 0599 NT.500- HX JAM ZNYC NOTES:. Used on mowers with serial numbers prior to 060 and higher than 070; Torque to 67 75 ft-lbs.. Used on mowers with serial numbers between 060 and 070. Torque the spindle bolt to 8 ft-lbs. 56_07 7-5
" Deck 5 6 5 5 6 9 7 0 8 8 5 6 7-6 56_07
" Deck INDEX NO. PART NO. QTY DESCRIPTION 60806 DISCHARGE CHUTE 608 DISCHARGE CHUTE PIN 608 TORSION SPRING 067 CHUTE BRACKET 5 086660 5 NT.75-6 HXZY NL 6 76795 FW.06 X.8 X.060 SAE HRD ZN 7 900 DISCHARGE CHUTE ADAPTOR 8 0595 CB.75-6 X.000 STD CD 9 6075 RS PULLEY COVER 0 6075 LS PULLEY COVER 60076 BELT A-SECTION." 080 CS.-8 X.750 HX G5 ZN 797 FW. X.00 X. HRD Z 7979 BLADE, 0.50"-L-F-CW 60090 BLADE, F0.50"-L-F-CW 7995 BLADE, 0.50"-CAT-F-CW 79 BLADE, 0.50"-MUL-F-CW 790 BLADE, 0.50"-GAT-F-CW 5 787 CW.6 X.50 X.87 PNT 6 7887 CS.65- X.50 HX G5 ZN NOTES:. Torque to 8 ft-lbs.. Do not torque; the discharge chute must pivot freely. 56_07 7-7
6" Service Deck 6 5 INDEX NO. PART NO. QTY. DESCRIPTION 5500 6" DECK (WITH DECALS & HARDWARE) 60069 CN.-8 X.00 MAX THK 6087 DECK DANGERS NO ROPS DECAL 606 DISCHARGE CHUTE DECAL 5 60 DECK BELT ROUTING DECAL 6 6089 THROWN OBJECTS DECAL NOTES: 7-8 56_07
This page intentionally left blank. 56_07 7-9
6" Deck Pulleys & Spindles 6 7 8 9 5 0 6 7 5 0 9 5 5 8 7-0 56_07
6" Deck Pulleys & Spindles INDEX NO. PART NO. QTY DESCRIPTION 796 CS.65- X.500 HX G5 ZNYC 068 FW.656 X.00 X.078 ZNYC 7979 FW.650 X.5 X.8 ZNYCG5 7850 PULLEY, 5.00" OD IDLER 5 09770 IDLER SLIDE 6 598 CHAIN DECK LIFT SPRING 7 068 TENSION SPRING 8 7899 CS.-8X.50 FLT SH ZNYC 9 6069 IDLER SLIDE 0 70595 CS.500- X.50 HX G5 ZN 79860 FW.55 X.65 X.5 HD ZY 609 PULLEY, 6.OO" OD 05765 FW.00 X.500 X. ZN 0550 8 NT.75-6 HX G5 ZN 5 76795 6 FW.06 X.8 X.060 SAE HRD ZN 6 7685 FW. X.687 X.05/.080 HD ZN/YL 7 058776 NT.-8 HX NL ZN 8 0056 8 CS.75-6 X.75 HX G5 ZN 9 6080 BLADE SPINDLE ASSEMBLY 0 78567 NT.500- HX G8 ZN NY 78866 PLASTIC WHEEL ASSEMBLY (WITH HARDWARE) 059 NT.500- HX JAM ZNYC 76796 FW.5 X.06 X.090 SAE 0997 PLASTIC WHEEL 5 78708 CS.500- X.50 HX G5. Torque to 67 75 ft-lbs. NOTES: 56_07 7-
6" Deck 5 7 5 6 5 6 8 0 9 9 5 6 7-56_07
6" Deck INDEX NO. PART NO. QTY DESCRIPTION 778 BELT, A 7" EL 608 CHUTE PIN 608 TORSION SPRING 60806 DISCHARGE CHUTE 5 086660 5 NT.75-6 HX G5 ZN NY 6 76795 FW.06 X.8 X.060 SAE 7 067 CHUTE BRACKET 8 900 DISCHARGE CHUTE ADAPTER 9 0595 CB.75-6 X.000 STD ZN 0 60750 RS PULLEY COVER 6075 LS PULLEY COVER 080 CS.-8 X.750 HX G5 ZN 797 FW. X.00 X. HRD Z 605 BLADE,.50"-L-F-CW 79850 BLADE,.50"-MUL-F-CW 7985 BLADE,.50"-GAT-F-CW 60 BLADE,.50"-CAT-F-CW 5 787 CW.6 X.50 X.87 PNT 6 7887 CS.65- X.50 HX G5 ZN NOTES:. Torque to 8 ft-lbs.. Do not torque; the discharge chute must pivot freely. 56_07 7-
5" Service Deck 5 7 6 INDEX NO. PART NO. QTY DESCRIPTION 550598 5" DECK (WITH DECALS & HARDWARE) 789 BELT ROUTING DECAL 6087 DECK DANGERS DECAL 60069 CN.-8 X.00 MAX THK 5 606 DISCHARGE CHUTE DECAL 6 6089 THROWN OBJECTS DECAL 7 7950 STEP TREAD NOTES: 7-56_07
This page intentionally left blank. 56_07 7-5
5" Deck Pulleys & Spindles 7 6 5 8 9 0 0 7 8 9 0 6 5 7-6 56_07
5" Deck Pulleys & Spindles INDEX NO. PART NO. QTY. DESCRIPTION 796 CS.65- X.50 HX G5 068 FW.656 X.00 X.078 ZNYC 7979 FW.650 X.5 X.8 ZNYC G5 7850 PULLEY IDLER 5.00" OD 5 09770 IDLER SLIDE 6 780 TENSION SPRING 7 598 CHAIN, LINK 8 7899 CS.-8 X.5 FLT SH 9 6069 IDLER SLIDE UHMW 0 70595 CS.500- X.5 HX G5 ZN 79860 FW.55 X.65 X.5 HD ZY 786889 DRIVE PULLEY 5.68 OP 0550 NT.75-6 HX G5 ZNY 76795 FW.06 X.8 X.060 SAE 5 0056 CS.75-6 X.75 HX G5 6 6080 SPINDLE ASSEMBLY 7 7685 FW. X.687 X.05/.080H 8 058776 NT.-8 HX ZY NL 9 78567 NT.500- HX G8 ZY NL 0 78866 PLASTIC WHEEL ASSEMBLY (WITH HARDWARE) 76796 6 FW.5 X.06 X.090 SAE 78708 CS.500- X.5 HX G5 0997 PLASTIC WHEEL 0599 NT.500- HX JAM ZNYC. Torque to 67 75 ft-lbs. NOTES: 56_07 7-7
5" Deck 6 7 5 8 9 5 0 9 0 7 5 6 8 7-8 56_07
5" Deck INDEX NO. PART NO. QTY. DESCRIPTION 77785 BELT, B 5.5" EL 6079 LS PULLEY COVER 6078 RS PULLEY COVER 080 CS.-8 X.750 HX G5 5 797 FW. X.00 X. HRD Z 6 60806 DISCHARGE CHUTE 7 608 TORSION SPRING 8 608 CHUTE PIN 9 067 CHUTE BRACKET 0 9007 CHUTE ADAPTER PLATE 0595 CB.75-6 X.00 STD CD 086660 5 NT.75-6 HXZY NL 76795 FW.06 X.8 X.060 SAE 60 BLADE, 8.50"-L-F-CW 797696 BLADE, F8.50"-H-F-CW 79770 BLADE, 8.50"-MUL-F-CW 7977 BLADE, 8.50"-GAT-F-CW 5 787 CW.6.50 X.87 PNT 6 7887 CS.65- X.5 HX G5 Z 7 058776 NT.-8 HXZY NL 8 999 "A" BLOWOUT BAFFLE 9 065 CB.-8 X.750 FUL ZN 0 7685 FW. X.687 X.05/.080H NOTES:. Torque to 8 ft-lbs.. Do not torque; the discharge chute must pivot freely. 56_07 7-9
Deck Lift 5 6 7 8 8 9 0 DETAIL VIEW 7 8 0 9 8 6 5 8 0 5 8 9 6 0 7-0 56_07
Deck Lift INDEX NO. PART NO. QTY. DESCRIPTION 0550 NT.75-6 HX GRD 5 ZNY 76795 6 FW.06 X.8 X.060 SAE 76957 FW.656 X.50 X.50 ZNY 089 HANDLE, DECK HT LOCK 5 886 STEERLEVER BUSHING 6 080655 CS.75-6 X.500 HX G5 7 6096 PIN, DECK HEIGHT STOP 8 706 NT.7- HX FLG ZN 9 099 DECK LIFT LINK, NON-SLOT 0 05579 6 CS.7-X.750 HX G5 0595 GREASE FITTING STRAIGHT 6089 6 PIVOT SPACER BUSHING 06 CS.75-6 X.000 HX G5 088 LIFT PEDAL LINK 5 0880 DECK LIFT LINK 6 0879 PULLER STRAP 7 550 DECK ADJUST PLATE LS (WITH DECAL) 8 60 DECK HEIGHT DECAL 9 05860 CS.75-6 X.5 HX G5 ZN 0 086660 NT.75-6 HX ZY NL NOTES: 56_07 7-
Deck Mounting Hardware 0 9 0 8 8 0 7-56_07
Section 8 Seat.................................................. 8- ROPS................................................ 8-56_07 8-
Seat 7 9 8 7 5 6 8 0 VIEWED FROM UNDERNEATH 9 0 5 6 8-56_07
Seat INDEX NO. PART NO. QTY. DESCRIPTION 60807 SEAT 750 CS.7-0 X.50 G5 ZNY 079 FW.0 X.000 X.08 ZNY 60 SEAT BELT 5 7065 NT.7-0 HX GR5 ZNYC 6 60680 FW.5 X. X.9 HRD 7 7960 SEAT BELT CROSS BAR 8 550570 SEAT PAN (WITH DECAL) 9 7685 FW. X.687 X.05/.080H 0 07986 CS.-8 X.5 HX G5 086660 NT.75-6 HXZY NL 76795 0 FW.06 X.8 X.060 SAE 05860 CS.75-6 X.5 HX G5 ZN 7985 COMPRESSION SPRING.5 X.00 X.88 5 0550 NT.75-6 HX GRD 5 ZNY 6 06 CS.75-6 X.000 HX G5 7 7558 SB.75 X.75 SH.-8 8 07 NT.-8 HX G5 ZNYC 9 00508 CS.75-6 X.50 HX G5 Z 0 6085 BATTERY WARNINGS DECAL 600 SEAT LATCH 7890 TORSION SPRING 795 SEAT SWITCH NOTES:. Do not torque; the seat pan and latch must pivot freely. 56_07 8-
ROPS 7 5 5 6 8-56_07
ROPS INDEX NO. PART NO. QTY. DESCRIPTION 6079 ROPS KIT (WITH DECALS, SEATBELT & HARDWARE) 0776 CS.7-0 X.00 HX G8 ZNYC 707 FW.5 X.8 X.060 ZNYC 07 NT.500- UNT LK G8 ZN 5 76796 8 FW.5 X.06 X.090 SAE 6 790 CS.500- X.75 HX G5 Z 7 60979 ROPS DECAL. Torque to 55 ft-lbs. NOTES: 56_07 8-5
8-6 56_07