Anoka, MN. 0- Telephone -00--00 Facsimile -00--0 FCB POST-MIX DISPENSER WITH HOT-GAS DEFROST AND V ELECTRONICS (DEFROST/ERROR INDICATOR LIGHTS) UNIT PART NO. 0000 000 THIS DOCUMENT CONTAINS IMPORTANT INFORMATION This manual contains the illustrated parts list for the FCB H.P. Post-Mix Dispenser. Retain this manual as part of your equipment manual (P/N 000). FCB ( H.P.) of Manual Part No. 0000-0- Rev: -- IMI Cornelius Co.,
Anoka, MN 0 Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0 0 0 0 0 FIGURE. FCB H.P. POST-MIX DISPENSER (-FLAVOR) Manual Part No. 0000-0- Rev: -- IMI Cornelius Co., of FCB ( H.P.)
Anoka, MN. 0- Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 000 Thread Rolling Screw, Hex Washer Hd., No. - By /-In. Long 000 Self-Drilling Screw, Hex Washer Hd., No. - By /-In. Long 000 Washer,. I.D. 000 Hex Nut, /- 0000 Hex Nut, No. - 0000 Bushing, Snap,. Dia. 0000 Tapered Gasket, Black 0000 Washer, No. 0 Frame 0 0 Receiver 00 Accumulator 000 Solenoid, Refrigeration, 0/0V 0/0HZ 0000 Expansion Valve, Refrigeration Solenoid Dryer 0 Grommet, Compressor 0 Spacer, Compressor 000 Washer,. I.D. Compressor Kit, H.P. 0V 0HZ 0000 Washer,. I.D. 0 0 Condenser Coil and Bracket 0 Clip, Retainer, Syrup Lines 00 Clip, Sensor Filter, Solenoid 00 Clip, Sensor 000 Lug, Ground 000 Washer, No. 0 0000 Machine Screw, Sl Hex Washer Hd., No. 0- By /-In. Long Wire Harness, Input (Not Shown) Wire Harness, Output (Not Shown) 0 Wire Harness, Hotgas (Not Shown) Tube Ass y, Water Coil (See Figure ) 00000 Thread Rolling Screw, Phil Pan Hd., No. - By -In. Long 0000 Panel, Top, Stainless Steel Panel, Back, Stainless Steel 0 Thread Cutting Screw, Phil Pan Hd., No. 0- By -In. Long Panel, Side, Right-Hand, Stainless Steel Tube, Drain 0000 Strap, Drain Tube Panel, Side, Left-Hand, Stainless Steel 0 000 Cover, Control Box, Lower Cup Rest Drip Tray Support, Drip Tray 000 Panel Splash Spacer,.00 I.D. 000 Washer,. I.D. Grille, Stainless Steel Filter 000 Condenser Coil 0 00 Blade, Fan 000 Shroud, Condenser 000 Machine Screw, Phil Pan Hd., No. - By /-In. Long 000 Motor, 0V 0/0HZ 0W 0RPM 00 Bracket, Condenser Motor 000 Control Box, Lower 00000 Relay, 0/0V 0/0HZ 0 Relay, Start, 0V 0HZ 000 Strap, Capacitor 0 Capacitor, Start 0 00 Capacitor, Run 000 Thread Rolling Screw, Phil Pan Hd, No. 0- By /-In. Long FCB ( H.P.) of Manual Part No. 0000-0- Rev: -- IMI Cornelius Co.,
Anoka, MN 0 Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0 0 0 0 0 0 0 FIGURE. FCB H.P. POST-MIX DISPENSER (-FLAVOR) Manual Part No. 0000-0- Rev: -- IMI Cornelius Co., of FCB ( H.P.)
Anoka, MN. 0- Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 000 Thread Rolling Screw, Hex Washer Hd., No. - By /-In. Long 000 Self-Drilling Screw, Hex Washer Hd., No. - By /-In. Long 000 Washer,. I.D. 000 Hex Nut, /-0 000 Hex Nut, /- 0000 Washer, No. 0 000 O-Ring,. I.D. By.00 C.S. 000 O-Ring,.0 I.D. By. C.S. Frame 0 0000 Extension, Foam Pack 0 Foam Pack Cover, Motor 000 Clamp, Cover 0 O-Ring,. I.D. By. C.S. Retaining Ring Coupling, Shaft Bracket, Motor 000 Washer,. I.D. 00000 Self-Drilling Screw, Hex Washer Hd., No. 0- By /-In. Long 0 Motor, / H.P. 0V 0HZ 0 RPM Bearing, Shaft Housing, Shaft O-Ring,. I.D. By. C.S. Drive Shaft Ass y Plate, Beater Motor, Right-Hand Plate, Beater Motor, Left-Hand 0000 Door Ass y, Freeze Cylinder (See Figure ) 0000 Washer,.0 I.D. 000 Hex Nut, /- 0 Bushing,.00 I.D. Body, Beater 000 Blade, Scraper 0000 Washer,. I.D. 0000 Tank, Blender 000 Machine Screw, Sl Hex Washer Hd., No. -0 By /-In. Long 000 Retainer, Blender 0000 Relief Valve Ass y, 0-PSI 000 Switch Ass y, Float 0000 Holder, Float Switch 0 000 Washer,. I.D. 000 Ring, Retainer 0000 Strain Relief 000 Support, Blender 0 Soldout Switch 00 Check Valve Ass y, Single (See Figure ) Solenoid Valve Ass y, Syrup (See Figure 0) Retainer, Module 000 Machine Screw, Phil Pan Hd., No. - By /-In. Long Solenoid Ass y, Water (See Figure 0) 0 Panel, Solenoid 0000 O-Ring,. I.D. By.00 C.S. Connector, Solenoid 00000 O-Ring,. I.D. By.00 C.S. 0000 Tube Ass y, Syrup (See Figure ) 000 Body, Float Switch 0000 Float Switch 000 Cover, Switch 0000 Machine Screw, Phil Pan Hd., No. - By /-In. Long 0000 Thread Rolling Screw, Phil Truss Hd., No. 0- By /-In. Long 0 0000 Bracket, Tank Regulator Ass y Components (See Figure ) Control Box Components (See Figure ) Sign Display Components (See Figure ) Carbonator and Pump Components (See Figure ) FCB ( H.P.) of Manual Part No. 0000-0- Rev: -- IMI Cornelius Co.,
Anoka, MN 0 Telephone -00--00 Facsimile -00--0 Regulator Ass y Components FCB -FLAVOR ( H.P.) DISPENSER 000 Thread Rolling Screw, Hex Washer Hd., No. - By /-In. Long 000 Tapered Gasket, White 000 Pressure Switch, CO Regulator Ass y (See Figure ) 0000 Tube,. I.D. By -In. Long, CO Regulator to Tee 000 Fitting, Tee, /-Barb 0000 Tube,. I.D. By -In. Long, Regulator Tee to Drain Tee 00000 Fitting, Tee, /-Barb By /-Barb 0 0000 Tube,. I.D. By -In. Long, CO Regulator to Tee 0 000 Bracket, Regulator 0000 Machine Screw, Phil Rd Hd., No. 0- By /-In. Long 00 Hex Nut, No. 0- FIGURE. REGULATOR ASS Y COMPONENTS Control Box Components 000 Self-Drilling Screw, Hex Washer Hd., No. - By /-In. Long 0000 Bushing, Snap,. Dia. 000 Cover, Control Box, Upper 00 Board, P.C. 0000 Board, P.C., Motor No. 0000 Board, P.C., Motor No. 00 Wire Harness, Circuit Board (Not Shown) 000 Thread Rolling Screw, Phil Pan Hd., No. 0- By /-In. Long 000 Control Box, Upper 0 00 Fan, 0V W 000 Support, P.C. Board 0 FIGURE. CONTROL BOX COMPONENTS Manual Part No. 0000-0- Rev: -- IMI Cornelius Co., of FCB ( H.P.)
Anoka, MN. 0- Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0 0 FIGURE. SIGN DISPLAY COMPONENTS Sign Display Components 000 Thread Rolling Screw, Hex Washer Hd., No. - By /-In. Long 0000 Hex Nut, No. - 0000 Snap Bushing,. Dia. 000 Transformer, 0V 0/0HZ-V 0 Plate, Backup, Sign 0000 Housing, Display Switch, Touch 0 Holder, Flavor Tab 000 Support, P.C. Board 0 0000 P.C. Board, Circuit 0000 Cable, Ribbon 000 Latch Ass y 000 Relay, V 0HZ A 000 Transformer, /V 0/0HZ Hinge 0000 Light, Indicator 0000 Label, Indicator Light 0000 Panel, Door, Backup 0000 Thread Cutting Screw, Phil Pan Hd, No. - By /-In. Long 0 0000 Hex Nut, No. - 000 Holder, Fuse 0000 Fuse,. Amp FCB ( H.P.) of Manual Part No. 0000-0- Rev: -- IMI Cornelius Co.,
Anoka, MN 0 Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0 0 FIGURE. CARBONATOR AND PUMP COMPONENTS Carbonator and Pump Components 000 Tapered Gasket, White 0000 Clamp, For. O.D. Tube 0000 Fitting, Elbow, /-NPT Bracket, Carbonator Pump and Motor Ass y Pressure Switch, Water 0000 Carbonator Ass y (See Figure ) 000 Deflector, Relief Valve 0000 Tube Ass y, Water Pump to Carbonator (See Figure ) 0 0000 Machine Screw, Phil Pan Hd., No. 0- By /-In. Long 00 Check Valve Ass y, Dual (See Figure ) Fitting, Elbow, /-MPT By / Fitting, Tee, /-MPT By / 0000 Fitting, /-NPT By /-Brass Tube,.0 I.D. By -In. Long 0 Tube,.0 I.D. By -In. Long 0 Pressure Regulator, Water 0000 Fitting, /-NPT By /- Tube,.0 I.D. By -In. Long 0 000 Thread Cutting Screw, Phil Pan Hd., No. 0- By /-In. Long Clip, Lock 000 Clip, Guide Manual Part No. 0000-0- Rev: -- IMI Cornelius Co., of FCB ( H.P.)
Anoka, MN. 0- Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0 FIGURE. FCB H.P. POST-MIX DISPENSER FLOW DIAGRAM (-FLAVOR) 000 Tapered Gasket, White 0000 Clamp, For. O.D. Tube 0000 Tapered Gasket, Black 0000 Tube,. I.D. By -In. Long 000 Tapered Gasket, Red 0 Tube Ass y, CO Cylinder to CO Regulator Ass y (See Figure ) 000 Tube,. I.D. By 0-In. Long Tube Ass y, Water Inlet (See Figure ) Tube Ass y, CO Regulator to Carbonator (See Figure ) 0 000 Fitting, /-0 Tube Ass y, With Shutoff Valve, Carb Water (See Figure ) 0000 Tube Ass y, Syrup (See Figure ) 000 Syphon Tube Tube Ass y, Blender to Freeze Cylinder (See Figure 0) Tube Ass y, Water Solenoid to Blender (See Figure ) 0000 Tube Ass y, CO Regulator to Blender (See Figure ) FCB ( H.P.) of Manual Part No. 0000-0- Rev: -- IMI Cornelius Co.,
Anoka, MN 0 Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0 FIGURE. FACEPLATE ASSEMBLY 0000 Door, Freeze Cylinder Ass y 000 Door, Freeze Cylinder 0 Relief Valve Ass y 0000 O-Ring,.0 I.D. By.0 C.S. Valve Head Ass y (See Figure ) 000 Shank Nut 000 Spacer 00 Spinner 000 Sensor Shaft 0 Pin, Beater Bar Manual Part No. 0000-0- Rev: -- IMI Cornelius Co., 0 of FCB ( H.P.)
Anoka, MN. 0- Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0 FIGURE. DISPENSING VALVE ASSEMBLY Dispensing Valve Ass y Body and Shank Valve Housing Fitting 0000 Spring 000 Lever, Valve Knob 000 Plate 000 Thread Cutting Screw, Phil Truss Hd., Stainless Steel, No. - By /-In. long 0 O-Ring, Caged,. I.D. By.0 C.S. 000 O-Ring,. I.D. By.0 C.S. Spring Shaft Release FCB ( H.P.) of Manual Part No. 0000-0- Rev: -- IMI Cornelius Co.,
Anoka, MN 0 Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0 FIGURE 0. SOLENOID VALVE ASSEMBLY Solenoid Valve Ass y, Water Solenoid Valve Ass y, Syrup Block, Valve Body, Valve 0 Thread Rolling Screw, Phil Pan Hd., No. - By /-In. Long 00 Piston, Water 000 Piston, Syrup 0 Cylinder 0000 Spring 000 O-Ring,. I.D. By.00 C.S. 000 Adjusting Screw Flow Control, Top 0 00000 O-Ring,. I.D. By.00 C.S. Retainer, Flow Control 0 Thread Cutting Screw, Hex Washer Hd., No. - By /-In. Long 00 Solenoid, V. 000 Machine Screw, Phil Pan Hd., No. - By /-In. Long 000 Arm, Solenoid 0 Spring 000 Inlet Valve Manual Part No. 0000-0- Rev: -- IMI Cornelius Co., of FCB ( H.P.)
Anoka, MN. 0- Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0 0 0 0 FIGURE. CO REGULATOR ASSEMBLY 0000 CO Regulator Ass y and Bracket, Secondary (-Flavor) 0000 CO Regulator Ass y and Bracket, Secondary (-Flavor) 000 Gage, 0 PSI 000 Gage, 00 PSI 000 CO Regulator Ass y, 0 PSI, Orange (Includes -) 000 CO Regulator Ass y, 00 PSI, Gold (Includes -) 00000 Machine Screw, Phil Fill Hd., No. 0- By /-In. Long 0 Cover Kit (Includes Nonremovable Adjusting Screw) 0000 Retainer, Spring 000 Adjusting Spring, 0PSI 00000 Adjusting Spring, 00 PSI 0000 Diaphram Ass y 00 Baffle 0000 Guide 0 00000 Gasket 0000 Retainer, Seat 00000 O-Ring,. I.D. By.00 C.S. 00000 Filter Screen 00000 Spring, Poppet 00000 Valve, Poppet 0000 Reducing Valve Seat 00000 Gasket, Seat 000 Body 0000 Fitting, /-NPT 0 0000 Fitting, /-NPT By /-0 000 Fitting, Elbow, /-NPT By /-0 0000 Fitting, Elbow, /-NPT 000 Check Valve Ass y with Adapter (Includes -0) 0000 Adapter 000 Check Valve Ass y (Includes -0) 000 Quad Ring,. I.D. By.00 C.S. 000 Ball 000 Spring 000 Retainer 0 00 Body 000 Bracket, Regulator 000 Hex Nut, Keps, /-0 000 Fitting, /-NPT By /-Barb FCB ( H.P.) of Manual Part No. 0000-0- Rev: -- IMI Cornelius Co.,
Anoka, MN 0 Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0 FIGURE. CARBONATOR TANK AND LINKAGE ASSEMBLY 000 Carbonator Tank and Linkage Ass y 000 Tank, Carbonator 000 Link, Pivot 000 Pin 0000 Push-on Nut 000 Pivot Housing 000 Spring 0000 Insulation, Switch 000 Level Control Switch 000 Machine Screw, Sl. Rd. Hd., No. -0 By -/-In. Long 0 000 Switch, Actuator 000 Thread Cutting Screw, Phil Pan Hd., Sems, No. - By /-In. Long 000 Relief Valve Manual Part No. 0000-0- Rev: -- IMI Cornelius Co., of FCB ( H.P.)
Anoka, MN. 0- Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER FIGURE. DOUBLE CHECK VALVE ASSEMBLY 00 Double Check Valve Ass y 00 Single Check Valve Ass y (Includes -) 000 Retainer 000 Spring 000 Ball 000 Washer,.00 I.D. 000 Quad Ring,. I.D. 000 Receptacle FCB ( H.P.) of Manual Part No. 0000-0- Rev: -- IMI Cornelius Co.,
Anoka, MN 0 Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER 0000 Hex Nut, /- 000 Washer,.0 I.D. 0000 Clamp,. O.D. 0000 Fitting, Drain Fitting, /- 000 Tube,. I.D. By -In. Long FIGURE. DRIP TRAY DRAIN KIT 0 Tube Ass y, Cylinder to Regulator 00 Tube Ass y, Regulator to Pump Tube Ass y, Water Inlet 000 Tube,. I.D. By -In. Long 000 Tube,. I.D. By -In. Long 000 Tube,. I.D. By -In. Long 000000 Ferrule,.00 O.D. Tube 00000 Ferrule,. O.D. Tube 0000 Ferrule,.0 O.D. Tube 00000 Nipple,. I.D. Tube 0000 Nipple,. I.D. Tube 0000 Nut, Swivel, /-0 000 Nut, Swivel, /- FIGURE. TUBING ASSEMBLY Tube Ass y, Regulator to Carbonator 0000 Tube Ass y, Pump to Carbonator 000 Tube,.0 I.D. By -In. Long 000 Tube,. I.D. By /-In. Long 00000 Ferrule,. O.D. Tube 00000 Nipple,.0 I.D. Tube 0000 Nut, Swivel, /-0 FIGURE. TUBING ASSEMBLY Manual Part No. 0000-0- Rev: -- IMI Cornelius Co., of FCB ( H.P.)
Anoka, MN. 0- Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER Tube Ass y, Carb Water Outlet 00000 Fitting, Tee, Barb 00000 Fitting, Elbow, Valve 0000 Shut-Off Valve 0000 Tube,.0 I.D. By -In. Long 0000 Tube,.0 I.D. By -/-In. Long 00000 Ferrule,. O.D. Tube 000 Tube,.0 I.D. By -In. Long FIGURE. TUBING ASSEMBLY (CARB WATER) 0000 Tube Ass y, Syrup 0000 Nut, Swivel, /-0 00000 Nipple,. I.D. Tube 000000 Ferrule,.00 O.D. Tube 000 Tube,. I.D. By -In. Long 000 Tube,. I.D. By -In. Long 0 Fitting, Tee, Barb 000 Nipple,. I.D. Tube 000 Nut, Swivel, /- FIGURE. TUBING ASSEMBLY (SYRUP) 0000 Tube Ass y, Regulator to Blender 0000 Tube,.0 I.D. -In. Long 00000 Ferrule,. O.D. Tube 0000 Nut, Swivel, /-0 00000 Nipple,.0 I.D. Tube 000 Connector, Barb FIGURE. TUBING ASSEMBLY (REGULATOR TO BLENDER) FCB ( H.P.) of Manual Part No. 0000-0- Rev: -- IMI Cornelius Co.,
Anoka, MN 0 Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER Tube Ass y, Blender to Freeze Cylinder 0000 Tube,.0 I.D. By -/-In. Long 0000 Tube,.0 I.D. By -/-In. Long 0000 Tube,.0 I.D. By -/-In. Long 0000 Tube,.0 I.D. By -In. Long 00000 Ferrule,. O.D. Tube 0000 Nut, Swivel, /- 00000 Nipple,.0 I.D. Tube Connector, Barb 0000 Shut-Off Valve 00000 Fitting, Tee, Barb FIGURE 0. TUBING ASSEMBLY (BLENDER TO FREEZE CYLINDER) Tube Ass y, Water Solenoid to Blender 000 Connector, Barb 00000 Ferrule,. O.D. Tube 0000 Tube,.0 I.D. By -/-In. Long 0000 Tube,.0 I.D. By -/-In. Long 0000 Clamp,.00 O.D. Tube 00000 Turnaround, Barb 00000 Nipple,.0 I.D. Tube 0000 Nut, Swivel, /-0 FIGURE. TUBING ASSEMBLY (WATER SOLENOID TO BLENDER) Manual Part No. 0000-0- Rev: -- IMI Cornelius Co., of FCB ( H.P.)
Anoka, MN. 0- Telephone -00--00 Facsimile -00--0 FCB -FLAVOR ( H.P.) DISPENSER ACCESSORIES/KITS CASTER (0000) WASHER (000) FCB ( H.P.) of Manual Part No. 0000-0- Rev: -- IMI Cornelius Co.,