INSTALLATION INSTRUCTION ELECTRIC HEATER ACCESSORY S NH0005 THRU NH005, NP000 THRU NP005, ND006, AND NX006 Supersedes: 0-65-003-A-0704 0-65-003-B-005 GENERAL This instruction covers the installation of the following electric heaters: ND006, NH0006, NH000706, NH00006, NH006, NH00006, NH006, NH0005, NH0055, NH0005, NH0055, NH00046, NH00546, NH00046, NH00546, NH00058, NH00558, NH00058, NH00558, NP00006, NP0005, NP00046, NP006, NP0055, NP00546, NP00006, NP0005, NP006, NP0055, NP00046, NP00546, NP00058, NP00558, NX006 The electric heat accessories are used for applications of cooling with electric heat and heat pump with electric heat. Each of the unit models are approved for use with specific electric heat accessories. Tables through 6 list the possible combinations and other important electrical data and limitations. Refer to the unit wiring diagram during installation. CAUTION: Unit is approved for zero clearance to combustible material and when equipped with electric heat a minimum clearance of one inch must be maintained on all sides of the supply duct and/or plenum for three feet as shown in the detail in Figure for the 0 kw and 5 kw electric heaters only. 4. Install the element support bracket with the two sheet metal screws provided as shown in Figure 3. 5. Install the electric heat accessory. Patch Plate Patch Plate FIGURE - PATCH PANEL PLATE & CAUTION: To prevent damage, carefully pass the accessory heating element through the rectangular opening in the plenum side. The heating element support rods must be seated in the hole in the element support bracket, see Figure 3. 6. Align holes and fasten the accessory to the plenum side with the screws removed from the patch plate in step 3. FIGURE - CLEARANCES NOTE: The electric heat accessory should be installed before the supply air duct is attached to the supply air opening flanges. INSTALLATION Install the electric heater accessory as follows:. Disconnect all electric power to unit.. Remove the indoor blower/electric heat compartment access panel and the unit control box access panel. 3. From the plenum side, remove and discard the patch plate exposing the opening for installation of the electric heat accessory. For the 4 and 5 ton units, remove patch plate for the 5 kw through 5 kw heaters or patch plates and for 0 kw or 5 kw heaters. See Figure. Save four screws for Step 6. FIGURE 3 - ELECTRIC HEATER MOUNTING 7. Route the high voltage harness, the end without the plug, behind the indoor blower assembly using the wire clip with the base unit, and through the coil support bracket. See Figure 3. 8. Install the fuse block or terminal block assembly in the control box as shown in Figure 4, 5 or 6 using the sheet metal screws provided. NOTE: For 4 Volt units with the indoor blower transformer mounted in the control box, remove the terminal block from the mounting plate before installing the terminal block. Discard the mounting plate.
0-65-003-B-005 9. For the ND006 model, mount the grounding lug inside the control box with the sheet metal screw provided. 0. Route the appropriate wires from the fuse holder or terminal block to the M contactor as indicated in the unit wiring diagram.. Route the high voltage wiring harness from step 7 to the fuse holder and connect to the appropriate fuses identified in the unit wiring diagram. Install a wire tie in the hole next to the extruded opening in the control box and secure the wire harness.. Remove wire 04 from the 6-pin receptacle on the electric heat/fan control board in the control box. 3. Route the high voltage wiring harness (with the 4-pin plug P3) and the low voltage wiring harness (with the 6-pin plug P) from step 7 into the control box and plug into the electric heat/fan control board. Install a wire tie in the hole next to the extruded opening in the control box and secure the wire harness. 4. Route the power supply wiring to the fuse holder as outlined in the unit installation instructions. See appropriate table in BLOCK ASSEMBLY M" CONTACTOR the following pages for electrical requirements. 5. For three-phase applications, install the electric heat cover over the contactor/relay with the screws supplied. 6. Replace the indoor blower/electric heat compartment access panel and the unit control box access panel. NOTE: All wiring must comply with local and national electrical code requirements. Read and heed all unit caution labels. 7. Mark the appropriate box on the unit nameplate for the particular heater installed. 8. Reconnect the power to the unit after making certain that the field wiring size satisfies minimum requirements for specific combinations of unit/heater installed and the indoor blower speed tap is connected to at least the minimum speed, identified on unit nameplate. NOTE: The electric heaters have a thermal limit control. If failure occurs, this limit control must be replaced with the identical part number. BLOCK ASSEMBLY M" CONTACTOR 08/-- FIELD SUPPLIED DISCONNECT SWITCH P3" ELECTRIC HEAT/ BOARD UNIT BOX LOW VOLTAGE P" 08/-3- FIELD SUPPLIED DISCONNECT SWITCH P3" ELECTRIC HEAT/ BOARD UNIT BOX LOW VOLTAGE P" FIGURE 4 - TYPICAL SINGLE POINT 08/-- FIELD WIRING FIGURE 5 - TYPICAL SINGLE POINT 08/-3- FIELD WIRING TERMINAL BLOCK ASSEMBLY M" CONTACTOR BLOCK ASSEMBLY "M" CONTACTOR 4-3- 575-3- FIELD SUPPLIED DISCONNECT SWITCH P3" ELECTRIC HEAT/ BOARD UNIT BOX LOW VOLTAGE P" FIGURE 6 - TYPICAL SINGLE POINT 4/575-3- FIELD WIRING 08/-- FIELD SUPPLIED DISCONNECT SWITCH "P3" ELECTRIC HEAT BOARD UNIT BOX LOW VOLTAGE "P" FIGURE 7 - TYPICAL DUAL POINT 08/-- FIELD WIRING Unitary Products Group
0-65-003-B-005 TABLE - ELECTRICAL DATA (0 SEER COOLING / ELECTRIC HEAT) COMPRESSOR ELECTRIC RLA LRA, NO. KW 08 08/-- 9.0 48.0..6 NH0006 8./0.8 NH000706 7./3.3 NH0006 8./0.8 04 08/--..0..6 NH000706 7./3.3 NH00006 7.5/0.0 * 36./4.7 DEB/DPB 0 08/-- 4.7 73.0..6 036 08/-- 7.3 94.0. 3.5 04 08/-- 0.5 0.0. 3.5 048 08/-- 4.4.0.3 4.0 0 08/-- 8.9 65.0.3 7.0 036 08/-3-0.9 78.0. 3.5 04 08/-3-4. 0.0. 3.5 048 08/-3-4. 05.0 0.7 4.0 0 08/-3-6.0 5.0.3 7.0 036 4-3- 5.8.0 0.6.8 04 4-3- 7. 54.0 0.6.8 048 4-3- 7. 55.0 0.6.0 0 4-3- 8.0 67.0 0.7 3.5 036 575-3- 4.5 3.0 0.4.5 04 575-3- 5.8 44.0 0.4.5 048 575-3- 5.6 44.0 0.6.6 0 575-3- 6.4.0 0.6.8 NH0006 NH000706 NH00006 NH006 NH00006 NH006 NH0006 NH000706 NH00006 NH006 NH00006 NH006 NH00006 NH006 NH00006 NH006 NH00006 NH006 NH0005 NH0055 NH0005 NH0055 NH0005 NH0055 NH0005 NH0055 NH0005 NH0055 NH0005 NH0055 NH00046 NH00546 NH00046 NH00546 NH00046 NH00546 NH00046 NH00546 NH00046 NH00546 NH00046 NH00546 NH00058 NH00558 NH00058 NH00558 NH00058 NH00558 NH00058 NH00558 NH00058 NH00558 NH00058 NH00558 STAGE 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 *** 5.0 *** 0.0 *** 5.0 *** 0.0 *** 5.0 *** 0.0 *** 5.0 *** 0.0 *** 5.0 *** 0.0 *** 5.0 *** 8./0.8 7.3/3.3 36./4.7 54./6.5 36./4.7 54./6.5 8./0.8 7./3.3 36./4.7 54./6.5 36./4.7 54./6.5 7./83.3 90.3/04. 36./4.7 54./6.5 7./83.3 90.3/04. 0.8/4. 3.3/36. 0.8/4. 3.3/36. 0.8/4. 3.3/36. 4.7/48. 5./. 0.8/4. 3.3/36. 4.7/48. 5./..0 8.0.0 8.0.0 8.0 4...0 8.0 4.. 4.4 4.4 4.4 9. 4. 4.4 9. 4. 5.8/9.3 37./4.3 5.8/9.3 37./4.3 48.4/55.3 5.8/9.3 37./4.3 48.4/55.3 7.0/8.4 49.5/56.5 7./8.5./.4 38./43.4 49.5/56.5 7./8.5./57. 7./83. 95.3/09. 7.8/. 53.9/.8 76.5/86.9 99.0/.9.6/39.0.4/34.4 43.5/49.5.4/34.4 43.5/49.5 3./. 44./. 57./65. 70./80. 34.8/38.8 47.8/53.9.9/68.9 73.9/83.9 7.3 4.8 7.3 4.8 7.5 5. 3.6. 9.4 6.9 34.4 4.0 3.9 9.9 3.9 9.9 4.0 0.0 6. 3. 5.5.5 7.6 33.6, / / / / / / / / / 00/0 5/ 00/5 5/ / / / / / / / 0 5 0 5 0 0 5 0 5 0 5 5 0 5 HACR / / / / / / / / / 00/0 5/ 00/5 5/ / / / / / / / 0 5 0 5 0 0 5 0 5 0 5 5 0 5 = Dual element, time delay type. = Standard circuit breakers may be used in Canada and on applications over amps where the heaters are separately fused. ELECTRIC HEAT CORRECTION FACTORS * = KW listed is for volts, use this table for 08 or volts. ** = KW listed is for 480 volts, use this table for 4 volts. *** = KW listed is for 0 volts, use this table for 575 volts. NOMINAL VOLTAGE VOLTAGE KW CAP. MULTIPLIER 08.75.9 480 4.9 0 575.9 Unitary Products Group 3
0-65-003-B-005 TABLE - ELECTRICAL DATA (0 SEER HEAT PUMP / ELECTRIC HEAT) BHA/BUA COMPRESSOR OUTDOOR, RLA LRA NO. ELECTRIC STAGE KW, HACR 08 08/-- 9.0 48.0..6 NH0006 8./0.8 37.5/4.0 / / NH000706 7./3.3 48.8/54.0 04 08/--..0..6 NH0006 NH000706 NH00006 7.5/0.0 * 8./0.8 7./3.3 36./4.7.7/44. 5.0/57. 63.3/70. / / 70/80 / / 70/80 NH0006 8./0.8 44.7/48. / / NH000706 7.3/3.3 56.0/6. 4.7 73.0..6 NH00006 7.5/0.0 * 36./4.7 67.3/74. 70/80 70/80 0 08/-- NH006.3/5.0 * 54./6.5 89.8/00.3 90/0 90/0 4.7 73.0..6 3.8/5.0 8./0.8 44.7/48. / / ND006 0.0 0.0 0.0 0.0 7.5/0.0 36./4.7./5. NH0006 8./0.8 48.8/5.3 / / NH000706 7./3.3./65.3 7.3 94.0. 3.5 NH00006 7.5/0.0 * 36./4.7 7.4/78.3 80/80 80/80 036 08/-- NH006.3/5.0 * 54./6.5 93.9/04.4 00/0 00/0 7.3 94.0. 3.5 3.8/5.0 8./0.8 48.8/5.3 / / ND006 0.0 0.0 0.0 0.0 7.5/0.0 36./4.7./5. 04 08/-- NH00006 7.5/0.0 * 36./4.7 75.4/8.3 0.5 0.0. 3.5 NH006.3/5.0 * 54./6.5 97.9/08.4 00/0 00/0 0.5 0.0. 3.5 3.8/5.0 8./0.8 5.8/56.3 ND006 0.0 0.0 0.0 0.0 7.5/0.0 36./4.7./5. NP00006 7.5/0.0 * 36./4.7 8./88. 90/00 90/00 048 08/-- 4.4.0.5 4.0 NP006 NP00006.3/5.0 * 5.0/0.0 * 54./6.5 7./83.3 03.7/4. 6.3/. 0/5 / 0/5 / NX006 8.8/5.0 * 90.3/04. 48.8/66. /75 /75 0 08/-- 8.9 65.0.5 7.0 036 08/-3-0.9 78.0. 3.5 04 08/-3-4. 0.0. 3.5 048 08/-3-4. 05.0.5 4.0 0 08/-3-6.0 5.0.5 7.0 036 4-3- 5.8.0 0.6.8 04 4-3- 7. 54.0 0.6.8 048 4-3- 7. 55.0 0.8.0 0 4-3- 8.0 67.0 0.8 3.5 NH00006 NH006 NH00006 NH006 NH0005 NH0055 NH0005 NH0055 NP0005 NP0055 NP0005 NH0055 NH0005 NH0055 NH0005 NH0055 NH00046 NH00546 NH00046 NH00546 NP00046 NH00546 NH00046 NH00546 NH00046 NH00546 NP00046 NP00546 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 36./4.7 54./6.5 7./83.3 90.3/04. 0.8/4. 3.3/36. 0.8/4. 3.3/36. 0.8/4. 3.3/36. 4.7/48. 5./. 0.8/4. 3.3/36. 4.7/48. 5./..8 8.0.0 8.0.0 8.0 4...0 8.0 4.. 89.8/96.7.3/.8 34.9/48.8 57.5/74.8 44.3/48.3 57.3/63.3 48.3/57.3 6.3/67.3 49./53. 6./68. 75.3/83.3 88.3/98.3 54.6/58.6 67.6/73.6 80.7/88.7 93.7/03.7 4.6 3. 6. 33.8 6.7 34. 4.7 49.3 9.4 36.9 44.4 5.9 00/0 5/5 / 75/75 / 90/00 / 70/80 90/90 00/0 5 00/0 5/5 / 75/75 / 90/00 / 70/80 90/90 00/0 5 = Standard circuit breakers may be used in Canada and on applications over amps where the heaters are separately fused. * = KW listed is for volts, use this table for 08 or volts. ** = KW listed is for 480 volts, use this table for 4 volts. *** = KW listed is for 0 volts, use this table for 575 volts. KW CAP. MULTI- NOMINAL VOLTAGE VOLTAGE ELECTRIC HEAT CORRECTION FACTORS PLIER.75.9 08 480 4.9 0 575.9 4 Unitary Products Group
0-65-003-B-005 TABLE - ELECTRICAL DATA (0 SEER HEAT PUMP / ELECTRIC HEAT) (CONTINUED) BHA/BUA COMPRES- SOR OUTDOOR, RLA LRA NO. ELECTRIC STAGE KW AMPAC- ITY, HACR 036 575-3- 4.5 3.0 0.4.5 NH00058 NH00558 0.0 *** 5.0 *** 4.4 5.6 0 0 04 575-3- 5.8 44.0 0.4.5 NH00058 NH00558 0.0 *** 5.0 *** 4.4. 7. 5 5 048 575-3- 5.6 44.0 0.6.6 NH00058 NH00558 NH00058 NH00558 0.0 *** 5.0 *** 0.0 *** 5.0 *** 4.4 9. 4..3 7.3 33.3 39.3 5 5 0 575-3- 6.4.0 0.6.8 NH00058 NH00558 NP00058 NP00558 0.0 *** 5.0 *** 0.0 *** 5.0 *** 4.4 9. 4. 3.4 9.5.5 4.5 5 5 = Dual element, time delay type. = Standard circuit breakers may be used in Canada and on applications over amps where the heaters are separately fused. * = KW listed is for volts, use this table for 08 or volts. ** = KW listed is for 480 volts, use this table for 4 volts. *** = KW listed is for 0 volts, use this table for 575 volts. KW CAP. MULTI- NOMINAL VOLTAGE VOLTAGE ELECTRIC HEAT CORRECTION FACTORS PLIER.75.9 08 480 4.9 0 575.9 Unitary Products Group 5
0-65-003-B-005 TABLE 3 - ELECTRICAL DATA ( SEER COOLING / ELECTRIC HEAT) DEH/DPH COMPRESSOR, RLA LRA NO. ELECTRIC STAGE KW, HACR 08 08/-- 9.0 48.0..6 NH0006 NH000706 NH0006 04 08/--..0..6 NH000706 NH00006 NH0006 0 08/--.0 73.0..6 NH000706 NH00006 NH006 NH0006 036 08/-- 7.3 94.0. 3.5 NH000706 NH00006 NH006 NH0006 04 08/-- 0.5 0.0. 3.5 NH000706 NH00006 NH006 0 08/-3-0.0 63.0..6 NH0005 NH0055 036 08/-3-0.9 78.0. 3.5 NH0005 NH0055 04 08/-3-4. 0.0. 3.5 NH0005 NH0055 0 4-3- 5.0 3.0 0.6.4 NH00046 NH00546 036 4-3- 5.8.0 0.6.8 NH00046 NH00546 04 4-3- 7. 54.0 0.6.8 NH00046 NH00546 036 575-3- 4.5 3.0 0.4.5 NH00058 NH00558 04 575-3- 5.8 44.0 0.4.5 NH00058 NH00558 NH00058 048 575-3- 5.8 36.0 0.6.0 NH00558 NH00058 NH00558 NH00058 0 575-3- 6.4.0 0.6.8 NH00558 NH00058 NH00558 = Dual element, time delay type. = Standard circuit breakers may be used in Canada and on applications over amps where the heaters are separately fused. 7.5/0.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 7.5/0.0 *.3/5.0 * 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 ** 5.0 ** 0.0 *** 5.0 *** 0.0 *** 5.0 *** 0.0 *** 5.0 *** 0.0 *** 5.0 *** 0.0 *** 5.0 *** 0.0 *** 5.0 *** 8./0.8 7./3.3 8./0.8 7./3.3 36./4.7 8./0.8 7.3/3.3 36./4.7 54./6.5 8./0.8 7./3.3 36./4.7 54./6.5 8./0.8 7./3.3 36./4.7 54./6.5 0.8/4. 3.3/36. 0.8/4. 3.3/36. 0.8/4. 3.3/36..0 8.0.0 8.0.0 8.0 4.4 4.4 4.4 9. 4. 4.4 9. 4. 5.8/9.3 37./4.3 5.8/9.3 37./4.3 48.4/55.3 5.8/9.3 37./4.3 48.4/55.3 7.0/8.4 6.9/.4 38./43.4 49.5/56.5 7./8.5./.4 38./43.4 49.5/56.5 7./8.5 9.3/33.3 4.3/48.4.4/34.4 43.5/49.5.4/34.4 43.5/49.5 6.8 4.3 7.3 4.8 7.3 4.8 3.9 9.9 3.9 9.9 4.5 0.5 6.6 3.6 5.5.5 7.6 33.6 / / / / / / / / / / / / / / / / 0 5 0 5 0 5 5 0 5 0 5 5 0 5 / / / / / / / / / / / / / / / / 0 5 0 5 0 5 5 0 5 0 5 5 0 5 * = KW listed is for volts, use this table for 08 or volts. ** = KW listed is for 480 volts, use this table for 4 volts. *** = KW listed is for 0 volts, use this table for 575 volts. KW CAP. MULTI- NOMINAL VOLTAGE VOLTAGE ELECTRIC HEAT CORRECTION FACTORS PLIER.75.9 08 480 4.9 0 575.9 6 Unitary Products Group
0-65-003-B-005 TABLE 4 - ELECTRICAL DATA ( SEER HEAT PUMP / ELECTRIC HEAT) BHH/BUH COMPRESSOR ELECTRIC RLA LRA, NO. KW NH0006 3.8 / 5.0 * 8. / 0.8 NH000706 5.6 / 7.5 * 7. / 3.3, HACR 08 08/-- 7. 48.0..6. / 38.6 / / 46.4 / 5.6 / / NH0006 3.8 / 5.0 * 8. / 0.8 37.9 / 4.4 / / 04 08/-- 9.3 57.0..6 NH000706 5.6 / 7.5 * 7. / 3.3 49. / 54.4 / / NH00006 7.5 / 0.0 * 36. / 4.7.5 / 67.4 NH0006 3.8 / 5.0 * 8. / 0.8.0 / 48.5 / / NH000706 5.6 / 7.5 * 7.3 / 3.3 56.3 / 6.5 5.0 7.5..6 NH00006 7.5 / 0.0 * 36. / 4.7 67.6 / 74.5 0 08/-- NH006.3 / 5.0 * 54. / 6.5 90. / 00.6 00 / 0 00 / 0 5.0 7.5..6 3.8/5.0 8./0.8.0/48.5 / / ND006 0.0 0.0 0.0 0.0 7.5/0.0 36./4.7./5. NH0006 3.8 / 5.0 * 8. / 0.8 48.7 / 5. NH000706 5.6 / 7.5 * 7. / 3.3.0 / 65. 7. 94.0. 3.5 NH00006 7.5 / 0.0 * 36. / 4.7 7. / 78. 80 / 80 80 / 80 036 08/-- NH006.3 / 5.0 * 54. / 6.5 93.8 / 04. 00 / 0 00 / 0 7. 94.0. 3.5 3.8/5.0 8./0.8 48.7/5. / / ND006 0.0 0.0 0.0 0.0 7.5/0.0 36./4.7./5. 04 08/-- NP00006 7.5 / 0.0 * 36. / 4.7 74.7 / 8.7 0.0 04.0. 3.5 NP006.3 / 5.0 * 54. / 6.5 97.3 / 07.7 00 / 0 00 / 0 0.0 04.0. 3.5 3.8/5.0 8./0.8 5./55.6 ND006 0.0 0.0 0.0 0.0 7.5/0.0 36./4.7./5. NP00006 7.5 / 0.0 * 36. / 4.7 79.9/86.8 90/90 90/90 048 08/-- 3.4 6.0.5 4.0 NP006 NP00006.3 / 5.0 * 5.0 / 0.0 * 54. / 6.5 7. / 83.3 0.5/.9 5.0/38.9 0/5 / 0/5 / NX006 8.8 / 5.0 * 90.3 / 04. 47.6/65.0 /75 /75 0 08/-- 8.8 48.0.5 5.6 0 08/-3-0.0 63.0. 3.5 036 08/-3-.4 78.0. 3.5 04 08/-3-3.9 88.0. 3.5 048 08/-3-3.0 93.0.5 4.0 0 08/-3-7. 3.0.5 5.6 0 4-3- 5.0 3.0 0.6.8 036 4-3- 5.7.0 0.6.8 04 4-3- 6.4 44.0 0.6.8 048 4-3- 6.4 46.5 0.8.0 0 4-3- 8. 6.0 0.8 5.6 NP00006 NP006 NH00006 NP006 NH0005 NH0055 NH0005 NH0055 NP0005 NP0055 NP0005 NP0055 NP0005 NH0055 NH0005 NH0055 NH0005 NH0055 NH00046 NH00546 NH00046 NH00546 NH00046 NH00546 NP00046 NH00546 NH00046 NH00546 NP00046 NH00546 NH00046 NP00546 7.5 / 0.0 *.3 / 5.0 * 5.0 / 0.0 * 8.8 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 5.0 / 0.0 * 8.8 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 5.0 / 0.0 * 8.8 / 5.0 * 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 36. / 4.7 54. / 6.5 7. / 83.3 90.3 / 04. 0.8 / 4. 3.3 / 36. 0.8 / 4. 3.3 / 36. 0.8 / 4. 3.3 / 36. 0.8 / 4. 3.3 / 36. 4.7 / 48. 5. /. 0.8 / 4. 3.3 / 36. 4.7 / 48. 5. /..0 8.0.0 8.0.0 8.0.0 8.0 4...0 8.0 4.. 88./95. 0.8/. 33.4/47.3 55.9/73.3 4.3/46.3 55.3/6.3 44.9 / 48.9 57.9 / 64.0 48.0 / 5.0 6. / 67. 47.8/5.8.8/66.9 73.9/8.9 86.9/96.9 54.8/58.8 67.8/73.8 80.8/88.8 93.9/03.9 3.3.8 4.5 3.0 5.4 33.0 5.8 33.4.9 48.4 8.9 36.4 43.9 5.4 00/0 5/5 / 75/75 / / 90/00 70/80 90/90 00/0 5 5 00/0 5/5 / 75/75 / / 90/00 70/80 90/90 00/0 5 5 = Dual element, time delay type. * = KW listed is for volts, use table on previous page for 08 or volts. = Standard circuit breakers may be used in Canada and on applications ** = KW listed is for 480 volts, use table on previous page for 4 volts. over amps where the heaters are separately fused. *** = KW listed is for 0 volts, use table on previous page for 575 volts. Unitary Products Group 7
0-65-003-B-005 TABLE 4 - ELECTRICAL DATA ( SEER HEAT PUMP / ELECTRIC HEAT) (CONTINUED) BHH/BUH COMPRESSOR RLA LRA, 036 575-3- 4.7 3.0 0.4.5 04 575-3- 5.4 34.0 0.4.5 048 575-3- 5. 37. 0.6.6 0 575-3- 7.0.0 0.6.8 ELECTRIC NO. NH00058 NH00558 NH00058 NH00558 NH00058 NH00558 NH00058 NH00558 NH00058 NH00558 NP00058 NP00558 KW 0.0*** 5.0*** 0.0*** 5.0*** 0.0*** 5.0*** 0.0*** 5.0*** 0.0*** 5.0*** 0.0*** 5.0*** 4.4 4.4 4.4 9. 4. 9.8 5.8 0.7 6.7 0.6 6.7 3.7 38.7, 0 5 5 HACR = Dual element, time delay type. * = KW listed is for volts, use table on previous page for 08 or volts. = Standard circuit breakers may be used in Canada and on applications ** = KW listed is for 480 volts, use table on previous page for 4 volts. over amps where the heaters are separately fused. *** = KW listed is for 0 volts, use table on previous page for 575 volts. 4.4 9. 4. 4.. 36.3 4.3 5 0 0 5 5 5 8 Unitary Products Group
0-65-003-B-005 TABLE 5 - ELECTRICAL DATA (3 SEER COOLING / ELECTRIC HEAT) DEM/DPH COMPRESSOR, RLA LRA NO. ELECTRIC STAGE KW, HACR 048 08/-- 0.5 5.0.3 7.3 NH00006 NH006 NH00006 NH006 NH00006 0 08/-- 8.8 69.0.3 9.4 NH006 NH00006 NH006 NH0005 048 08/-3-4. 90.0.3 7.3 NH0055 NH0005 NH0055 NH0005 0 08/-3-9.3 3.0.3 9.4 NH0055 NH0005 NH0055 NH00046 048 4-3- 7..0 0.7 7.3 NH00546 NH00046 NH00546 NH00046 0 4-3- 7.5 49.5 0.7 9.4 NH00546 NH00046 NH00546 = Dual element, time delay type. = Standard circuit breakers may be used in Canada and on applications over amps where the heaters are separately fused. 7.5/0.0 *.3/5.0 * 5.0/0.0 * 8.8/5.0 * 36./4.7 54./6.5 7./83.3 90.3/04. 54.3/6. 76.8/87.3 99.4/3.3.0/39.3 00/5 5/ 00/5 5/ 7.5/0.0 * 36./4.7 56.9/63.8.3/5.0 * 54./6.5 79.5/89.9 5.0/0.0 * 7./83.3 0.0/5.9 0/5 0/5 8.8/5.0 * 90.3/04. 4.6/4.0 5/ 5/ 7.5/0.0 * 0.8/4../39. / /.3/5.0 * 3.3/36. 48./54. 5.0/0.0 * 4.7/48. 6./69.3 8.8/5.0 * 5./. 74.3/84.3 7.5/0.0 * 0.8/4. 37.8/4.8 / /.3/5.0 * 3.3/36..8/56.9 / / 5.0/0.0 * 4.7/48. 63.9/7.9 70/80 70/80 8.8/5.0 * 5./. 76.9/86.9 0.0 **.0 0 0 5.0 ** 8.0 7. 0.0 ** 4. 34.6 5.0 **. 4. 0.0 **.0 0.9 5 5 5.0 ** 8.0 8.4 0.0 ** 4..9 5.0 **. 43.5 * = KW listed is for volts, use this table for 08 or volts. ** = KW listed is for 480 volts, use this table for 4 volts. NOMINAL VOLTAGE VOLTAGE KW CAP. MULTI- PLIER ELECTRIC HEAT 08.75 CORRECTION.9 FACTORS 480 4.9 0 575.9 Unitary Products Group 9
0-65-003-B-005 TABLE 6 - ELECTRICAL DATA (3 SEER HEAT PUMP / ELECTRIC HEAT) BHP/BUP COMPRESSOR ELECTRIC RLA LRA, NO. KW 04 08/-- 9.3 57.0. 5.0 0 08/-- 5.0 7.5. 5.0 036 08/-- 7. 94.0. 7.3 04 08/-- 0.0 04.0. 7.3 048 08/-- 3.4 6.0.5 7.3 0 08/-3-0.0 63.0. 5.0 036 08/-3-.4 78.0. 7.3 04 08/-3-3.9 88.0. 7.3 048 08/-3-3.0 93.0.5 7.3 0 4-3- 5.0 3.0 0.6 5.0 036 4-3- 5.7.0 0.6 7.3 04 4-3- 6.4 44.0 0.6 7.3 048 4-3- 6.4 46.5 0.8 7.3 NH0006 NH000706 NH00006 NH0006 NH000706 NH00006 NH006 NH0006 NH000706 NH00006 NH006 NP00006 NP006 NP00006 NP006 NP00006 NP006 NH0005 NH0055 NH0005 NH0055 NP0005 NP0055 NP0005 NP0055 NP0005 NP0055 NH00046 NH00546 NH00046 NH00546 NP00046 NP00546 NP00046 NP00546 NP00046 NP00546 3.8 / 5.0 * 5.6 / 7.5 * 7.5 / 0.0 * 3.8 / 5.0 * 5.6 / 7.5 * 7.5 / 0.0 *.3 / 5.0 * 3.8 / 5.0 * 5.6 / 7.5 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 5.0 / 0.0 * 8.8 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 5.0 / 0.0 * 8.8 / 5.0 * 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 8. / 0.8 7. / 3.3 36. / 4.7 8. / 0.8 7.3 / 3.3 36. / 4.7 54. / 6.5 8. / 0.8 7. / 3.3 36. / 4.7 54. / 6.5 36. / 4.7 54. / 6.5 36. / 4.7 54. / 6.5 7. / 83.3 90.3 / 04..3 / 43.8 5.6 / 56.8 6.9 / 69.8 47.4 /.9 58.7 / 63.9 70.0 / 76.9 / 03.0 5.5 / 55.9 63.8 / 69.0 75.0 / 8.0 97.6 / 08.0 78.5 / 85.5 0. /.5 83. / 90. 05.8 / 6. 8.3 / 4..9 / 68.3 0.8 / 4. 44.7 / 48.7 3.3 / 36. 57.7 / 63.7 0.8 / 4. 48.7 / 5.7 3.3 / 36. 6.7 / 67.8 0.8 / 4. 5.8 / 55.8 3.3 / 36. 64.9 / 70.9 0.8 / 4. 5. / 55. 3.3 / 36. 64. / 70. 4.7 / 48. 77. / 85. 5. /. 90. / 00..0 8.0.0 8.0.0 8.0.0 8.0 4.. 7.5.4.7 38.6 3.6 9.4 3.8 3 47.5 55.3, / / 00 / 0 00 / 0 00 / 5 90 / 90 0 / 5 / 75 / 75 / / 00 / 00 HACR / / 00 / 0 00 / 0 00 / 5 90 / 90 0 / 5 / 75 / 75 / / 00 / 00 = Dual element, time delay type. = Standard circuit breakers may be used in Canada and on applications over amps where the heaters are separately fused. * = KW listed is for volts, use table on previous page for 08 or volts. ** = KW listed is for 480 volts, use table on previous page for 4 volts. 0 Unitary Products Group
0-65-003-B-005 TABLE 7 - ELECTRICAL DATA (3 SEER HEAT PUMP / ELECTRIC HEAT) BHZ/BUZ COMPRESSOR ELECTRIC RLA LRA, NO. KW 04 08/-- 4.3 0.9 4.8 NH0006 NH000706 NH00006 NH0006 0 08/-- 6.4 7.5.0 4.8 NH000706 NH00006 NH006 NH0006 036 08/-- 7. 83.0.0 6.9 NH000706 NH00006 NH006 04 08/-- 0.7 05.0. 6.9 NP00006 NP006 NP00006 048 08/-- 0.4 3.0. 6.9 NP006 NP00006 NP006 NP00006 0 08/-- 6.3.0.7 8.9 NP006 NP00006 NP006 0 08/-3-.6.0.0 4.8 NH0005 NH0055 036 08/-3-.9 77.0.0 6.9 NH0005 NH0055 04 08/-3-5.3 88.0. 6.9 NP0005 NP0055 NP0005 048 08/-3-6.0 0.0. 6.9 NP0055 NP0005 NP0055 NP0005 0 08/-3-7.6 0.0.7 8.9 NP0055 NP0005 NP0055 0 4-3- 5.0 3.0 0.5.4 NH00046 NH00546 036 4-3- 5.7.0 0.5 3.5 NH00046 NH00546 04 4-3- 7. 39.0 0.6 3.5 NP00046 NP00546 NP00046 048 4-3- 8.3.0 0.6 3.5 NP00546 NP00046 NP00546 NP00046 0 4-3- 70.0 0.9 4.5 NP00546 NP00046 NP00546 Q = Dual element, time delay type. R= Standard circuit breakers may be used in Canada and on applications 3.8 / 5.0 * 5.6 / 7.5 * 7.5 / 0.0 * 3.8 / 5.0 * 5.6 / 7.5 * 7.5 / 0.0 *.3 / 5.0 * 3.8 / 5.0 * 5.6 / 7.5 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 5.0 / 0.0 * 8.8 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 5.0 / 0.0 * 8.8 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 5.0 / 0.0 * 8.8 / 5.0 * 7.5 / 0.0 *.3 / 5.0 * 5.0 / 0.0 * 8.8 / 5.0 * 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 0.0** 5.0** 8. / 0.8 7. / 3.3 36. / 4.7 8. / 0.8 7.3 / 3.3 36. / 4.7 54. / 6.5 8. / 0.8 7. / 3.3 36. / 4.7 54. / 6.5 36. / 4.7 54. / 6.5 36. / 4.7 54. / 6.5 7. / 83.3 90.3 / 04. 36. / 4.7 54. / 6.5 7. / 83.3 90.3 / 04. 44.3 / 47.7 55.6 /.8 66.8 / 73.8 46.7 /. 58.0 / 63. 69.3 / 76.3 9.9 / 0.3 49.7 / 53. 6.0 / 66. 7.3 / 79. 94.9 / 05.3 76.4 / 83.3 99.0 / 09.4 7 / 86.6 0. /.6 4.8 / 38.6 47.3 / 64.7 88.5 / 95.4. /.5 33.6 / 47.5 56. / 73.6 0.8 / 4. 44.7 / 48.7 3.3 / 36. 57.7 / 63.7 0.8 / 4. 48.7 / 5.7 3.3 / 36. 6.7 / 67.8 0.8 / 4. 5.8 / 55.8 3.3 / 36. 64.9 / 70.9 0.8 / 4. 5. / 55. 3.3 / 36. 64. / 70. 4.7 / 48. 77. / 85. 5. /. 90. / 00. 0.8 / 4. 3.3 / 36. 4.7 / 48. 5. /..0 8.0.0 8.0.0 8.0.0 8.0 4...0 8.0 4.. 63.0 / 67.0 77. / 83. 9. / 99. 05. / 5. 3.6 4. 37.4.9 4..7 47.5 56.0 64.5 7.4 55.4 64.0 7.5 8.0,Q / / 00 / 0 80 / 80 00 / 0 00 / 0 90 / 90 0 / 5 5 / / 75 00 / 0 5 / 5 / 75 / 75 / / 00 / 00 00 / 00 0 / 5 70 80 80 70 80 90 00 * = KW listed is for volts, use table on previous page for 08 or volts. ** = KW listed is for 480 volts, use table on previous page for 4 volts. HACRR / / 00 / 0 80 / 80 00 / 0 00 / 0 90 / 90 0 / 5 5 / / 75 00 / 0 5 / 5 / 75 / 75 / / 00 / 00 00 / 00 0 / 5 70 80 80 70 80 90 00 Unitary Products Group
Subject to change without notice. Printed in U.S.A. Copyright 005 by Unitary Products Group. All rights reserved. Unitary Products Group 05 York Drive 0-65-003-B-005 Supercedes: 0-65-003-A-0704 Norman Oklahoma 769