2014-15 State Price Quote Specification TYPE D60 BID AS 48 PASSENGER Use this document to bid both non-lift and lift buses for 35 60 capacity. Vendor: PART I Engine Transmission CHASSIS STATE-SUPPORTED SPECIFICATIONS Diesel 180 H.P. minimum. Automatic Allison, PTS 2500 or equal. Price of items bid will establish the state cost. Engine mfr. CUMMINS Model or liters ISB-200 Net torque 520 @ 1600 R.P.M Net H.P. 200 @ 2400 R.P.M Location: Rear Forward Mfr. ALLISON Model no. PTS - 2500 Net input torque 550 GROSS INPUT Net input H.P. 300 GROSS INPUT Axle Front Axle Rear Axle Ratio 10,000 lb. minimum. 19,000 lb. minimum. Must comply with power and gradeability formula. Refer to Washington State School Bus Specifications Manual. Mfr. DETROIT Capacity 13,200 LBS Mfr. DETROIT Capacity 19,000 LBS Ratio 5.71 Axle Oil Seals Front and rear oil bath. Mfr. CHICAGO RAWHIDE Alternator Battery(ies) 200 amp minimum with or w/o lift-equipped vehicle. 1200 CCA 12 volt minimum to be mounted in body battery compartment w/o lift. 1400 CCA 12 volt minimum to be mounted in body battery compartment w/lift. Mfr. LEECE-NEVILLE Max. amps output w/o lift 240 w/lift 240 Size/group w/o lift 31 CCA 1520 Size/group w/lift 31 CCA 1520 FORM SPI 1394-5 (Rev. 7/14) Part I Page 1
TYPE D60 BID AS 48 PASSENGER Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I (cont.) Vendor: SCHETKY NW SALES, INC. Brakes Engine Heater Engine Temperature CHASSIS STATE-SUPPORTED SPECIFICATIONS Hydraulic disc. Refer to Washington State School Bus Specifications Manual. Engine manufacturer s recommended in-block heater. To be controlled electronically, by fan clutch/drive, or shutters. Price of items bid will establish the state cost. Size Front 15" x 1.44" Rear 15" x 1.44" Watts 750 Volts 120 Mfr. KIM Mfr. THOMAS Fan clutch Fuel Tank 100 gallon minimum. Capacity 60 GALLON Tires Wheels 6 first quality, radial ply. No low profile tires. 6 to be compatible with tire size. Mfr. GOODYEAR Size 10R22.5 Load range G Size 22.5 Rim width 7.5 Electronic Shutters FORM SPI 1394-5 (Rev. 7/14) Part I Page 2
TYPE D60 BID AS 48 PASSENGER Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I (cont.) Vendor: SCHETKY NW SALES, INC. Seating Capacity Auxiliary Fans Back-up Lights Battery Compartment Door, Service Heaters Lights P.A. System Seat Spacing BODY STATE-SUPPORTED SPECIFICATIONS 48 passenger based upon an average center-to-center seat spacing of at least 27.5. 2 fans, 6 maximum, mounted to right and left windshield and service door. All required backup lights to be LED (Light Emitting Diode). Refer to Washington State School Bus Specification s Manual. Battery storage tray must be large enough to accommodate batteries as specified in chassis section. Power operated. Minimum of 3 heaters; 1 front, 1 center, 1 rear. Shutoff valves at engine for all heaters. Two-speed motors. Must include recirculating pump. LED (Light Emitting Diode). Includes Clearance Lights, Stop Lights 7, Tail Lights, Turn Signals, Eight-Light System, and Dome-Light System. AM/FM/PA radio with 2 interior and 1 exterior speakers. To permit specified passenger capacity based on an average centerto-center seat spacing of at least 27.5. Price of items bid will establish the state cost. Capacity w/o lift 48 Capacity w/lift 37 Mfr. BERGSTROM Round: Diameter 4" Other: Square inches 12.56" Swing out Air Electric Other Front B.T.U. 90,000 Center B.T.U. 50,000 Rear B.T.U. 50,000 Total B.T.U. 190,000 Mfr. PANASONIC Roll out Folding Split, Outward opening Other Model No. B260101301 INCL. CD PLAYER Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 316.8 w/lift 316.8 Mfg. s C/C seat measurement of vehicle (inches): w/o lift 30.3 w/lift 30.3 FORM SPI 1394-5 (Rev. 7/14) Part I Page 3
Steering Wheel Tilt and telescoping column. FORM SPI 1394-5 (Rev. 7/14) Part I Page 4
TYPE D60 BID AS 48 PASSENGER Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I (cont.) Vendor: SCHETKY NW SALES, INC. BODY Step Tread Studded or pebbled top tread covering. Mfr. RCA Toolbox Exterior, manufacturer standard. Size (cubic feet) 3.37 Two-way Communications Wheelchair Lift Installed Wheelchair/ Occupant Tie-down System Installed Line Setting Ticket Owner s/operator s Handbook Repair Manuals Service and Cleaning Warranty 45-watt, VHF, mil. spec. SPECIAL NEEDS REQUIREMENTS CHASSIS AND BODY STATE-SUPPORTED SPECIFICATIONS Must meet state specification. Platform shall be a minimum of 32 x 52. Must meet state specification. ADDITIONAL REQUIREMENTS CHASSIS AND BODY Legible copy of manufacturer s Line Setting Ticket will be delivered with each vendor s packet at the time of delivery of the bus. One copy of the chassis manufacturer s owner s/operator s handbook or manual will be furnished with each bus at time of delivery. A complete set of chassis, engine, transmission, and body repair manuals, including wiring diagram for all components, will be made available at time of delivery, with instructions available on accessing repair materials. Cleaning and service by vendor prior to delivery will include: Chassis lubrication. Check fluid levels: verify all are at recommended full levels. Cooling system protected at -20 F. Interior and exterior will be clean (including glass). All systems (electric, air, hydraulic, mechanical and manual) be inspected to ensure proper operation at time of delivery. All components and accessories will be installed and operational at time of delivery. A complete copy of all warranty agreements will be furnished at time of delivery. FORM SPI 1394-5 (Rev. 7/14) Part I Page 5 Mfr. KENWOOD Model No. TK-7102HK 50 WATT VHF Price of items bid will establish the state cost. Mfr. RICON Model No. S5510-F1020100A Mfr. SURE-LOK Model No. FE5217-1
PUPIL TRANSPORTATION Old Capitol Building PO BOX 47200 Olympia, WA 98504-7200 (360) 725-6120 TTY (360) 664-3631 2014-15 VEHICLE DATA SHEET AND OFFICIAL PRICE QUOTATION TYPE D60 BID AS 48 PASSENGER VENDOR S COMPANY NAME SCHETKY NW SALES, INC. ADDRESS 8430 NE KILLINGSWORTH ST. PORTLAND, OREGON 97220 REPRESENTATIVE S NAME KIM HEVIA TELEPHONE NUMBER 503-382-3126 Estimated delivery date to school district from time purchase order is received: 180-220 DAYS ARO Firm where engine and chassis can be serviced or repaired and parts obtained: ANY AUTHORIZED CUMMINS OR THOMAS DEALER Firm where body can be serviced or repaired and parts obtained: SCHETKY NORTHWEST SALES, INC. MAKE THOMAS BUILT BUSES MODEL 0918TS YEAR 2016 BODY Warranty: Years 1-5 Miles UNLTD Seat color: GRAY Floor color: BLACK Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 287" w/lift 287" Equipped seating capacity: w/o lift 48 w/lift 37 Overall vehicle length (inches): w/o lift 337.8" w/lift 337.8" MAKE THOMAS BUILT BUSES CHASSIS Warranty: Years 1-5 Miles UNLTD MANUFACTURER CUMMINS ENGINE Torque: 520 @ 1600 RPM H.P.: 200 @ 2400 RPM MODEL 0918TS MANUFACTURER ALLISON MODEL PTS - 2500 YEAR 2016 Wheel base: 136" MODEL ISB-200 TRANSMISSION Warranty: Years 5 Speeds forward: 5 Miles 100K Warranty: Years 5 Miles UNLTD Number of cylinders: 6 Inline X V-type YEAR NEW C.I.D.: 6.7L Fuel type: DIESEL Battery type/grp: 31 31 Number batteries: 2 2 Total CCA: 1520 1520 QUOTED PRICE Quoted price is based upon payment within 30 days after delivery to the school district (without sales tax). Bid w/o lift $ 95,408.00 Bid w/lift $ 99,731.00 VENDOR REPRESENTATIVE S SIGNATURE DATE FORM SPI 1394-5 (Rev. 7/14)
DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 Use this document to bid both non-lift and lift buses. PART II Vendor: SCHETKY NW SALES, INC. Activity Securement Seating Air Conditioning Alternate Fuel CNG Other 2-passenger position seats with lap-shoulder belts in all passenger positions. To cool passenger compartment as required in the Washington State School Bus Specifications manual. Must comply with power and gradeability formula. Refer to Washington State School Bus Specifications manual. FORM SPI 1394-5 (Rev. 7/14) Part II Page 1 Price of items bid will establish the district cost. Passenger Capacity 32 Cost $ 645.00 PER SEAT Mfr. CARRIER Cost $ 9,450.00 Mfr. N/A CNG Cost $ N/A Other Cost $ N/A Alternator 200 amp. minimum. Cost $ 350.00 Anti-spray Device Back-up Alarm Rubber fender extenders. Must meet state specification. Type C: Cost $ Type D: Cost $ 330.00 Mfr. THOMAS Cost $ 100.00 Brakes 4-wheel hydraulic disk brake. Cost $ INCL Deduct $ N/A Brakes Air, Drum or Disc. Refer to Washington State School Bus Specifications manual. Disc Cost $ N/A Drum Cost $ 1,500.00 Color Exterior white roof. Cost $ 700.00 Door Locks Vandal lock system on all exterior doors. Cost $ 350.00 Driver s Seat Fire Suppression System Suspension type, 6-way adjustable, with lumbar adjustment. Cloth panel covers. Jomarr VT-6-E-NAF, or equal engine compartment fire suppression system of appropriate size to be installed according to manufacturer recommendation. Non-Air Mfr. NATIONAL Disc Deduct $ N/A Drum Deduct $ N/A Air Mfr. NATIONAL Cost $ 375.00 Cost $ 525.00 Mfr. JOMARR Cost $ 2,500.00 Floor Color Nonstandard color. Cost $ 850.00 Fuel Tank Larger fuel capacity (Diesel only). Size: N/A Cost $ N/A
SALES INC. State Price Quote Specification DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 Use this document to bid both non-lift and lift buses. PART II (cont.) Vendor: SCHETKY NW Price of items bid will establish the district cost. Fuel Tank Larger fuel capacity (Propane only). Size: N/A Cost $ N/A Headlights Halogen. Cost $ INCL Heater (Auxiliary water) Noise Reduction Retarder Seat Belt Ready Seat Seating System Storage Compartments Auxiliary fuel-fired heating systems. Refer to Washington State School Bus Specifications Manual, page 27. Exceeding minimum specifications. Manufacturer s standard. 3-passenger position seat with belts. Identical, non-lift bus with lap-shoulder seat belt system installed in all positions. Largest available for unit bid. Brand: WEBASTO Model: TSL17 Cost $ 1,200.00 Driver compartment Cost $ 250.00 Engine compartment Cost $ 150.00 Full acoustical headliner Cost $ 900.00 Driveline Cost $ N/A Exhaust Cost $ 175.00 Transmission Cost $ 10,000.00 Cost $ 525.00 PER SEAT 2 by 2 Cost $ 6,400.00 Capacity 32 3 by 2 Cost $ 6,625.00 Capacity 40 3 by 3 Cost $ 7,200.00 Capacity 48 Left-side N/A cubic feet. Cost $ N/A Right-side 19.9 cubic feet. Cost $ 685.00 Push-thru N/A cubic feet. Cost $ N/A FORM SPI 1394-5 (Rev. 7/14) Part II Page 2
DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 Use this document to bid both non-lift and lift buses. PART II (cont.) Vendor: SCHETKY NW SALES Strobe Light Student Protection System Installed Suspension Exterior roof mounted white strobe light. Electronic system to insure driver post-trip inspection of passenger compartment. Air ride (Air brake system only). Price of items bid will establish the district cost. Mfr. THOMAS Model No. DOUBLE FLASH Cost $ 225.00 Mfr. THOMAS Model No. B200104000 Cost $ 295.00 Front Rear Cost $ N/A Cost $ 2,100.00 Toolbox Interior, manufacturer standard. Cost $ 50.00 Deduct $ N/A Traction Device Traction Device Transmission Vehicle Securement System Video Camera Systems Installed Automatic chains. Sanders. Automatic Allison, PTS 3000 or equal. Mfr. ON SPOT Cost $ 2,850.00 Capacity 158 LBS Cost $ 2,700.00 Mfr. ALLISON Model No. 3000 PTS Cost $ 9,500.00 Must meet state specification. Mfr. SAFETY BRAKE Cost $ 1,300.00 Digital audio/video system for monitoring the passenger compartment with more than two cameras. Mfr. SEON Model No. TL-4 Cost $ 2,450.00 How many cameras 3 FORM SPI 1394-5 (Rev. 7/14) Part II Page 3
DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 Use this document to bid both non-lift and lift buses. PART II (cont.) Vendor: SCHETKY NW SALES Video Camera Systems Stop Sign Camera Installed Warning Light Monitor Additional Wheelchair/Occup ant Tie-down System Installed Wheelchair Lift Installed (Rear Engine Only) Windows Must meet state specification. 16 light monitoring system. Must meet state specification. Must meet state specification. Platform shall be a minimum of 32 x 52. Laminated passenger-compartment side or rear glass. Price of items bid will establish the district cost. Stand Alone System Added to Interior System Mfr. SEON Model No. TL4 Mfr. SEON Model No. TLHD Cost $ 1,950.00 Cost $ 900.00 How many cameras 1 How many cameras 1 Incandescent LED Lights Cost $ 225.00 Cost $ 825.00 Mfr. SURE-LOK Model No. FE517-1 Cost per station $ 850.00 W/FLOOR POCKETS Mfr. Model No. Cost $ Windows Tinted. Cost $ 560.00 Windows Thermal pane, left of driver and service door. Cost $ 750.00 Side Cost $ 1,135.00 Rear Cost $ INC. WITH SIDE WINDOWS Both Cost $ 1,135.00 FORM SPI 1394-5 (Rev. 7/14) Part II Page 4