2015-16 State Price Quote Specification TYPE D84 BID AS 78 PASSENGER DIESEL & Use this document to bid both non-lift and lift buses for 61 84 capacity. PART I Vendor: SCHETKY NW SALES, INC. Seating Capacity Alternator Auxiliary Fans Axle Front Axle Rear STATE-SUPPORTED SPECIFICATIONS 78 passenger based upon maximum seat spacing allowed in accordance with FMVSS 222. 240 amp minimum. Lift-equipped and/or Air-condition, maximum capacity available. Diesel Mfr. LEECE-NEVILLE Max. amps output w/o lift 240 w/lift 240 2 fans, 6 maximum, mounted to right and left windshield and service door. 13,200 lb. minimum. 19,000 lb. minimum. Price of items bid will establish the state cost. Capacity w/o lift 78 Capacity w/lift 67 Mfr. BERGSTROM Diesel Mfr. DETROIT Capacity 13,200 lbs Mfr. DETROIT Capacity 21,000 LBS Axle Oil Seals Front and rear oil bath. Mfr. CHICAGO RAWHIDE Axle Ratio Back-up Lights Battery(ies) Battery Compartment Must comply with power and gradeability formula. Refer to Washington State School Bus Specifications Manual. All required backup lights to be LED (Light Emitting Diode). Refer to Washington State School Bus Specification s Manual. 1200 CCA 12 volt minimum to be mounted in body battery compartment w/o lift. 1400 CCA 12 volt minimum to be mounted in body battery compartment w/lift. Battery storage tray must be large enough to accommodate batteries as specified in chassis section. Mfr. LEECE-NEVILLE Max. amps output w/o lift 240 w/lift 240 Ratio 5.57, 5.13 DSL Mfr. DETROIT Capacity 13,200 LBS Mfr. DANA Round: Diameter 7" Other: Square inches 22" Capacity 23,000 LBS Size/group w/o lift 31 CCA 1520 DSL,1850 Size/group w/lift 31 CCA 1520 DSL, 1850 Swing out Roll out FORM SPI 1394-5 (Rev. 7/15) Part I Page 1
State Price Quote Specification TYPE D84 BID AS 78 PASSENGER DIESEL & Use this document to bid both non-lift and lift buses for 61 84 capacity. Vendor: SCHETKY NW SALES, INC. PART I (cont.) Brakes Door, Service Engine STATE-SUPPORTED SPECIFICATIONS Air: Drum or Disc. If Drum, minimum 16.5 x 5 front, minimum 16.5 x 7 rear. Refer to Washington State School Bus Specifications Manual. Power operated. Diesel 210 H.P. minimum. Diesel Price of items bid will establish the state cost. Disc Front Rear Disc Front Rear Drum Front Rear Drum Front Rear Size Front 16.5" x 5" Size Front 16.5" x 6" Rear 16.5" x 7" Rear 16.5" x 8.58" Air Electric Other Folding Split, Outward opening Other Diesel Engine mfr. CUMMINS Engine mfr. CUMMINS Model or liters ISB 220 Model or liters ISLG 250 Net torque 520 @ 1600 R.P.M Net torque 730 @ 1300 R.P.M Net H.P. 220 @ 2400 R.P.M Net H.P. 250 @ 2200 R.P.M Engine Heater Engine Temperature Fuel Tank Engine manufacturer s recommended in-block heater. Location: Rear Forward Location: Rear Forward Diesel Watts 750 Volts 120 Watts 750 Volts 120 Mfr. KIM To be controlled electronically, by fan clutch/drive, or shutters. Diesel 100 gallon minimum. Dedicated Fuel system, maximum capacity available. Diesel Capacity 100 GALLONS Specify life time (years): LIFETIME OF VEHICLE Mfr. KIM Mfr. THOMAS Fan clutch Electronic Shutters Capacity 60 GALLONS EQUIVALENT Specify life time (years): 20 FORM SPI 1394-5 (Rev. 7/15) Part I Page 2
State Price Quote Specification TYPE D84 BID AS 78 PASSENGER DIESEL & Use this document to bid both non-lift and lift buses for 61 84 capacity. PART I (cont.) Vendor: SCHETKY NW SALES, INC. Heaters Lights P.A. System Seat Spacing STATE-SUPPORTED SPECIFICATIONS Minimum of 3 heaters; 1 front, 1 center, 1 rear. Shutoff valves at engine for all heaters. Two-speed motors. Must include recirculating pump. LED (Light Emitting Diode). Includes Clearance Lights, Stop Lights 7, Tail Lights, Turn Signals, Eight-Light System, and Dome-Light System. AM/FM/PA radio with 2 interior and 1 exterior speakers. 78 passenger based upon maximum seat spacing allowed in accordance with FMVSS 222. FORM SPI 1394-5 (Rev. 7/15) Part I Page 3 Price of items bid will establish the state cost. Front B.T.U. 90,000 Center B.T.U. 50,000 Rear B.T.U. 50,000 Total B.T.U. 190,000 Check if as specified If not, explain Mfr. PANASONIC Model No. 2600101301 INCL. CD PLAYER Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 430.6" DSL, 397.4" w/lift 430.6" DSL, 397.4" Mfg. s C/C seat measurement of vehicle (inches): w/o lift 27.5" w/lift 27.5" Steering Wheel Tilt and telescoping column. Check if as specified Step Tread Studded or pebbled top tread covering. Mfr. RCA Tires 6 first quality, radial ply. No low profile tires. Mfr. HANKOOK Size 11R22.5 Load range 16 PLY Toolbox Exterior, manufacturer standard. Size (cubic feet) 3.37 Transmission Automatic Allison, PTS 2500 or equal. Mfr. ALLISON Model No. 2500 PTS Diesel Mfr. ALLISON Model No. 3000 PTS Net input torque 550 GROSS Net input torque 950
FORM SPI 1394-5 (Rev. 7/15) Part I Page 4 Net input H.P. 300 GROSS Net input H.P. 300
State Price Quote Specification TYPE D84 BID AS 78 PASSENGER DIESEL & Use this document to bid both non-lift and lift buses for 61 84 capacity. PART I (cont.) Vendor: SCHETKY NW SALES, INC. Two-way Communications Wheels Wheelchair Lift Installed Wheelchair/ Occupant Tie-down System Installed STATE-SUPPORTED SPECIFICATIONS 45-watt, VHF, mil. spec. 6 to be compatible with tire size. SPECIAL NEEDS REQUIREMENTS CHASSIS AND BODY Must meet state specification. Platform shall be a minimum of 32 x 52. Must meet state specification. Price of items bid will establish the state cost. Mfr. KENWOOD Model No. TK-7302HVK 50WATT VHF Size 22.5 Rim width 8.25 Mfr. RICON Model No. S5510-F1020100A Mfr. SURE-LOK Model No. FE517-1 FORM SPI 1394-5 (Rev. 7/15) Part I Page 5
State Price Quote Specification TYPE D84 BID AS 78 PASSENGER DIESEL & Use this document to bid both non-lift and lift buses for 61 84 capacity. PART I (cont.) Vendor: SCHETKY NW SALES, INC. Line Setting Ticket Owner s/operator s Handbook STATE-SUPPORTED SPECIFICATIONS ADDITIONAL REQUIREMENTS CHASSIS AND BODY Legible copy of manufacturer s Line Setting Ticket will be delivered with each vendor s packet at the time of delivery of the bus. One copy of the chassis manufacturer s owner s/operator s handbook or manual will be furnished with each bus at time of delivery. Price of items bid will establish the state cost. Check if as specified Check if as specified RFID Tag WSP school bus inspection identification tag. Check if as specified Repair Manuals Service and Cleaning Warranty A complete set of chassis, engine, transmission, and body repair manuals, including wiring diagram for all components, will be made available at time of delivery, with instructions available on accessing repair materials. Cleaning and service by vendor prior to delivery will include: Chassis lubrication. Check fluid levels: verify all are at recommended full levels. Cooling system protected at -20 F. Interior and exterior will be clean (including glass). All systems (electric, air, hydraulic, mechanical and manual) be inspected to ensure proper operation at time of delivery. All components and accessories will be installed and operational at time of delivery. A complete copy of all warranty agreements will be furnished at time of delivery. Check if as specified Check if as specified Check if as specified FORM SPI 1394-5 (Rev. 7/15) Part I Page 6
PUPIL TRANSPORTATION Old Capitol Building PO BOX 47200 Olympia, WA 98504-7200 (360) 725-6120 TTY (360) 664-3631 2015-16 VEHICLE DATA SHEET AND OFFICIAL PRICE QUOTATION TYPE D84 BID AS 78 PASSENGER (DIESEL) VENDOR S COMPANY NAME SCHETKY NW SALES, INC. ADDRESS 8430 NE KILLINGSWORTH ST. PORTLAND, OR 97220 REPRESENTATIVE S NAME KIM HEVIA TELEPHONE NUMBER 503-382-3126 Estimated delivery date to school district from time purchase order is received: 180-220 DAYS ARO Firm where engine and chassis can be serviced or repaired and parts obtained: ANY AUTHORIZED CUMMINS OR THOMAS DEALER Firm where body can be serviced or repaired and parts obtained: SCHETKY NW SALES, INC. MAKE THOMAS BUILT BUSES 1408S YEAR 2017 BODY Warranty: Years 1-5 Miles UNLTD Seat color: GRAY Floor color: BLACK Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 430.6 w/lift 430.6 Equipped seating capacity: w/o lift 78 w/lift 67 Overall vehicle length (inches): w/o lift 471.6 w/lift 471.6 MAKE THOMAS BUILT BUSES CHASSIS Warranty: Years 1-5 Miles UNLTD MANUFACTURER CUMMINS ENGINE Torque: 520 @ 1600 RPM H.P.: 220 @ 2400 RPM 1408S MANUFACTURER ALLISON PTS 2500 YEAR 2017 Wheel base: 231" ISB 220 TRANSMISSION Warranty: Years 5 Speeds forward: 5 Miles 100K Warranty: Years 5 Miles UNLTD Number of cylinders: 6 Inline X V-type YEAR NEW C.I.D.: 6.7L Fuel type: DIESEL Battery type/grp: 31 31 Number batteries: 2 2 Total CCA: 1520 1520 QUOTED PRICE Quoted price is based upon payment within 30 days after delivery to the school district (without sales tax). Diesel Bid w/o lift $ 99,738.00 Diesel Bid w/lift $ 103,416.00 VENDOR REPRESENTATIVE S SIGNATURE DATE FORM SPI 1394-5 (Rev. 7/15)
PUPIL TRANSPORTATION Old Capitol Building PO BOX 47200 Olympia, WA 98504-7200 (360) 725-6120 TTY (360) 664-3631 2015-16 VEHICLE DATA SHEET AND OFFICIAL PRICE QUOTATION TYPE D84 BID AS 78 PASSENGER () VENDOR S COMPANY NAME SCHETKY NW SALES, INC. ADDRESS 8430 NE KILLINGSWORTH ST. PORTLAND, OR 97220 REPRESENTATIVE S NAME KIM HEVIA TELEPHONE NUMBER 503-382-3126 Estimated delivery date to school district from time purchase order is received: 180-220 DAYS ARO Firm where engine and chassis can be serviced or repaired and parts obtained: ANY AUTHORIZED CUMMINS OR THOMAS DEALER Firm where body can be serviced or repaired and parts obtained: SCHETKY NW SALES MAKE THOMAS BUILT BUSES 141YS YEAR 2017 BODY Warranty: Years 1-5 Miles UNLTD Seat color: GRAY Floor color: BLACK Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 412.50" w/lift 412.50" Equipped seating capacity: w/o lift 78 w/lift 67 Overall vehicle length (inches): w/o lift 475.1" w/lift 475.1" MAKE THOMAS BUILT BUSES CHASSIS Warranty: Years 1-5 Miles UNLTD MANUFACTURER CUMMINS ENGINE Torque: 730 @ 1300 RPM H.P.: 250 @ 2200 RPM 141YS MANUFACTURER ALLISON 3000 PTS YEAR 2017 Wheel base: 277" ISLG TRANSMISSION Warranty: Years 5 Speeds forward: 5 Miles 100,000 Warranty: Years 5 Miles UNLTD Number of cylinders: 6 Inline X V-type YEAR NEW C.I.D.: 5.9L Fuel type: Battery type/grp: 31 31 Number batteries: 2 2 Total CCA: 1850 1850 QUOTED PRICE Quoted price is based upon payment within 30 days after delivery to the school district (without sales tax). Bid w/o lift $ 145,217.00 Bid w/lift $ 149,323.00 VENDOR REPRESENTATIVE S SIGNATURE DATE FORM SPI 1394-5 (Rev. 7/15)
State Price Quote Specification DISTRICT-SUPPORTED OPTIONS C48 C71 D48 D78 Use this document to bid both non-lift and lift buses. PART II Vendor: SCHETKY NW SALES, INC. Activity Securement Seating Air Conditioning Alternate Fuel Other Alternator Anti-spray Device Back-up Alarm 2-passenger position seats with lap-shoulder belts in all passenger positions. To cool passenger compartment as required in the Washington State School Bus Specifications manual. Must comply with power and gradeability formula. Refer to Washington State School Bus Specifications manual. Available options. Rubber fender extenders. Must meet state specification. FORM SPI 1394-5 (Rev. 7/15) Part II Page 1 Price of items bid will establish the district cost. Passenger Capacity 50 Cost $ 660.00 PER SEAT Mfr. CARRIER Cost $ 10,292.00 Mfr. N/A Cost $ N/A Other Cost $ N/A Cost $ 950.00 Cost $ 400.00 200AMP Cost $ 676.00 Type C: Cost $ Type D: Cost $ 330.00 Mfr. THOMAS Cost $ 125.00 Capacity 320 AMP Capacity DELCO Capacity 270AMP Brakes 4-wheel hydraulic disk brake. Cost $ N/A Deduct $ 600.00 Brakes Air, Drum or Disc. Refer to Washington State School Bus Specifications manual. Disc Cost $ 5,100.00 Drum Cost $ INCL. Color Exterior white roof. Cost $ 780.00 Door Locks Vandal lock system on all exterior doors. Cost $ 350.00 Driver s Seat Fire Suppression System Suspension type, 6-way adjustable, with lumbar adjustment. Cloth panel covers. Jomarr VT-6-E-NAF, or equal engine compartment fire suppression system of appropriate size to be installed according to manufacturer recommendation. Non-Air Mfr. NATIONAL Disc Deduct $ N/A Drum Deduct $ N/A Air Mfr. NATIONAL Cost $ 375.00 Cost $ 600.00 Mfr. JOMARR Cost $ 3,200.00
Floor Color Nonstandard color. Cost $ 1,200.00 FORM SPI 1394-5 (Rev. 7/15) Part II Page 2
SCHETKY NW SALES, INC. State Price Quote Specification DISTRICT-SUPPORTED OPTIONS C48 C71 D48 D78 Use this document to bid both non-lift and lift buses. Vendor: PART II (cont.) Price of items bid will establish the district cost. Fuel Tank Larger fuel capacity ( only). Size: N/A Cost $ N/A Fuel Tank Larger fuel capacity (Diesel only). Size: N/A Cost $ N/A Fuel Tank Larger fuel capacity (Propane only). Size: N/A Cost $ N/A Headlights Halogen. Cost $ INCL. Heater (Auxiliary water) Noise Reduction Retarder Seat Belt Ready Seat Seating System Storage Compartments Auxiliary fuel-fired heating systems. Refer to Washington State School Bus Specifications Manual, page 27. Exceeding minimum specifications. Manufacturer s standard. 3-passenger position seat with securement belts. Identical, non-lift bus with lap-shoulder seat belt system installed in all positions. Largest available for unit bid. Brand: WEBASTO Model: 45K BTU Cost $ 4,200.00 Driver compartment Cost $ 125.00 Engine compartment Cost $ 150.00 Full acoustical headliner Cost $ 1,200.00 Driveline Cost $ N/A Exhaust Cost $ 135.00 DSL ONLY Transmission Cost $ N/A Cost $ 575.00 PER SEAT 2 by 2 Cost $ 10,875.00 Capacity 50 3 by 2 Cost $ 11,100.00 Capacity 60 3 by 3 Cost $ 11,800.00 Capacity 75 Left-side 34.8 Cost $ 1,375.00 Right-side 47.92 cubic feet. Cost $ 2,500.00 Push-thru N/A cubic feet. FORM SPI 1394-5 (Rev. 7/15) Part II Page 3
FORM SPI 1394-5 (Rev. 7/15) Part II Page 4 Cost $ N/A
State Price Quote Specification DISTRICT-SUPPORTED OPTIONS C48 C71 D48 D78 Use this document to bid both non-lift and lift buses. PART II (cont.) Vendor: SCHETKY NW SALES Strobe Light Student Protection System Installed Suspension Exterior roof mounted white strobe light. Electronic system to insure driver post-trip inspection of passenger compartment. Air ride (Air brake system only). Price of items bid will establish the district cost. Mfr. THOMAS Model No. DOUBLE FLASH Cost $ 225.00 Mfr. THOMAS Model No. B200126000 Cost $ 295.00 Front Rear Cost $ N/A Cost $ 4,000.00 Toolbox Interior, manufacturer standard. Cost $ 40.00 Deduct $ N/A Traction Device Traction Device Transmission Vehicle Securement System Video Camera Systems Installed Automatic chains. Sanders. Automatic Allison, PTS 3000 or equal. Mfr. ON SPOT Cost $ 2,740.00 Capacity 158 LBS Cost $ 2,700.00 Mfr. ALLISON Model No. PTS 3000 Cost $ INCL (), $9,500.00 (DSL) Must meet state specification. Mfr. SAFETY BRAKE Cost $ 1,300.00 Digital audio/video system for monitoring the passenger compartment with more than two cameras. Mfr. SEON Model No. TL-4 Cost $ 2,300.00 How many cameras 3 FORM SPI 1394-5 (Rev. 7/15) Part II Page 5
State Price Quote Specification DISTRICT-SUPPORTED OPTIONS C48 C71 D48 D78 Use this document to bid both non-lift and lift buses. PART II (cont.) Vendor: SCHETKY NW SALES Video Camera Systems Stop Sign Camera Installed Warning Light Monitor Additional Wheelchair/Occup ant Tie-down System Installed Wheelchair Lift Installed (Rear Engine Only) Windows Must meet state specification. 16 light monitoring system. Must meet state specification. Must meet state specification. Platform shall be a minimum of 32 x 52. Laminated passenger-compartment side or rear glass. Price of items bid will establish the district cost. Stand Alone System Added to Interior System Mfr. SEON Model No. TL4 Mfr. SEON Model No. CA WEDGE Cost $ 1,750.00 Cost $ 500.00 How many cameras 1 How many cameras 1 Incandescent LED Lights Cost $ 210.00 Cost $ 580.00 Mfr. SURE-LOK Model No. FE517-1 Cost per station $ 950.00 WITH FLOOR POCKETS Mfr. Model No. Cost $ Windows Tinted. Cost $ 460.00 Windows Thermal pane, left of driver and service door. Cost $ 760.00 Side Cost $ 1,530.00 Rear Cost $ INCL. WITH SIDE WINDOWS Both Cost $ 1,530.00 FORM SPI 1394-5 (Rev. 7/15) Part II Page 6