2013-14 State Price Quote Specification TYPE C 48 PASSENGER, DIESEL & PROPANE Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I Engine Transmission Axle Front Axle Rear Axle Ratio Axle Oil Seals Alternator CHASSIS STATE-SUPPORTED SPECIFICATIONS and 180 H.P. minimum. Automatic Allison, PTS 2500 or equal. 8,000 lb. minimum. 17,500 lb. minimum. Must comply with power and grade-ability formula. Refer to Washington State School Bus Specifications Manual. Front and rear oil bath. 185 amp minimum with or w/o lift-equipped vehicle. Engine mfr. International Model or liters 6.4 Price of items bid will establish the state cost. Engine mfr. Model or liters Net torque 620 @ 1400 R.P.M Net torque @ R.P.M Net H.P. 240 @ 2600 R.P.M Net H.P. @ R.P.M Allison Model no. 2500 PTS Net input torque 620 Net input H.P. 300 Meritor Capacity 8,000 Meritor Capacity 17,500 IC Model no. 5.29 Stemco Voyagerl Bosch LH200 Model no. Net input torque Net input H.P. Capacity Capacity Model no. Max. amps output w/o lift 200 w/lift 200 Max. amps output w/o lift w/lift FORM SPI 1394-2 (Rev. 7/13) Part I Page 1
TYPE C 48 PASSENGER, DIESEL & PROPANE Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I (cont.) Vendor: Harlows Bus Sales Battery(ies) Brakes Engine Heater Engine Temperature Fuel Tank CHASSIS STATE-SUPPORTED SPECIFICATIONS 1200 CCA 12 volt minimum to be mounted in body battery compartment w/o lift. 1400 CCA 12 volt minimum to be mounted in body battery compartment w/lift. Hydraulic disc. Refer to Washington State School Bus Specifications Manual. Engine manufacturer s recommended in-block heater. To be controlled electronically, by fan clutch/drive, or shutters. 60 gallon minimum. 60 gallon minimum. Price of items bid will establish the state cost. Size/group w/o lift 31 CCA 1950 Size/group w/o lift CCA Size/group w/lift 31 CCA 1950 Size/group w/lift CCA Size Front 15x1.44 Rear 15x1.44 Watts 1,000 Volts 120 Phillips Borg Warner Fan clutch Capacity 65 Gallon Capacity N/A Hood Tilt. Fiberglass Metal Tires 6 first quality, radial ply. No low profile tires. Continental Size 11R22.5 Load range H Wheels 6 to be compatible with tire size. Size 22.5 Rim width 8.25 Electronic Shutters FORM SPI 1394-2 (Rev. 7/13) Part I Page 2
TYPE C 48 PASSENGER, DIESEL & PROPANE Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I (cont.) Vendor: Harlows Bus Sales Seating Capacity BODY STATE-SUPPORTED SPECIFICATIONS Price of items bid will establish the state cost. Gas 48 passenger based upon an average center-to-center seat spacing of at IC Capacity w/o lift least 27.5. Capacity Capacity 48 Capacity w/lift Auxiliary Fans Back-up Lights Battery Compartment Door, Service Heaters P.A. System Seat Spacing 2 fans, 6 maximum, mounted to right and left windshield and service door. All required backup lights to be LED (Light Emitting Diode). Refer to Washington State School Bus Specification s Manual. Battery storage tray must be large enough to accommodate batteries as specified in chassis section. Power operated. Minimum of 4 heaters; 2 front, 1 center, 1 rear. Shutoff valves at engine for all heaters. Two-speed motors. Must include recirculating pump. AM/FM/PA radio with 2 interior and 1 exterior speakers. To permit specified passenger capacity based on an average center-to-center seat spacing of at least 27.5. Bergstrom Round: Other: Swing out Air Electric Other Diameter 4 Inch Square inches Roll out Folding Split, Outward opening Other Left-front B.T.U. 90,000 Right-front B.T.U. 50,000 Center B.T.U. 50,000 Rear B.T.U. 50,000 Total B.T.U. 240,000 Panasonic Model No. CQ-CM14OU AM/FM/CD Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 252.9 w/lift 252.9 Mfg. s C/C seat measurement of vehicle (inches): w/o lift 27.61 w/lift 29.43 Steering Wheel Tilt. Check if as specified Step Tread Studded or pebbled top tread covering. Koroseal FORM SPI 1394-2 (Rev. 7/13) Part I Page 3
TYPE C 48 PASSENGER, DIESEL & PROPANE Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I (cont.) Vendor: Harlows Bus Sales BODY STATE-SUPPORTED SPECIFICATIONS Toolbox Exterior, manufacturer standard. Size (cubic feet) 2.9 Two-way Communications Wheelchair Lift Installed Wheelchair/Occupant Tie-down System Installed Line Setting Ticket Owner s/operator s Handbook Repair Manuals Service and Cleaning Warranty ICOM 45-watt, VHF, mil. spec. Model No. F-5011 SPECIAL NEEDS REQUIREMENTS CHASSIS AND BODY Must meet state minimum specification. Platform shall be a Braun Century minimum of 32 x 52. Model No. NCL919IB-2 Q-Straint Must meet state minimum specification. Model No. Q-8100-A1-SC ADDITIONAL REQUIREMENTS CHASSIS AND BODY Legible copy of manufacturer s Line Setting Ticket will be delivered with each vendor s packet at the time of delivery of the Check if as specified bus. One copy of the chassis manufacturer s owner s/operator s handbook or manual will be furnished with each bus at time of Check if as specified delivery. A complete set of chassis, engine, transmission, and body repair manuals, including wiring diagram for all components, will be Check if as specified made available at time of delivery, with instructions available on accessing repair materials. Cleaning and service by vendor prior to delivery will include: Chassis lubrication. Check fluid levels: verify all are at recommended full levels. Cooling system protected at -20 F. Interior and exterior will be clean (including glass). Check if as specified All systems (electric, air, hydraulic, mechanical and manual) be inspected to ensure proper operation at time of delivery. All components and accessories will be installed and operational at time of delivery. A complete copy of all warranty agreements will be furnished at Check if as specified time of delivery. FORM SPI 1394-2 (Rev. 7/13) Part I Page 4 Price of items bid will establish the state cost.
PUPIL TRANSPORTATION Old Capitol Building PO BOX 47200 Olympia, WA 98504-7200 (360) 725-6120 TTY (360) 664-3631 2013-14 VEHICLE DATA SHEET AND OFFICIAL PRICE QUOTATION TYPE C 48 PASSENGER (DIESEL) VENDOR S COMPANY NAME Harlow's Bus Sales, Inc ADDRESS 1240 West Main Street PO Box 1107 Auburn, WA 98071 REPRESENTATIVE S NAME Jim Landgraf TELEPHONE NUMBER 253-939-7700 Estimated delivery date to school district from time purchase order is received: 180 Days ARO Firm where engine and chassis can be serviced or repaired and parts obtained: Any IC or International dealer Firm where body can be serviced or repaired and parts obtained: Harlow's Bus Sales, Inc. MAKE IC Corporation MODEL CE 105 YEAR 2014 BODY Warranty: Years 5 Miles Unlimit Seat color: Gray Floor color: Black Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 252.9 w/lift 252.9 Equipped seating capacity: w/o lift 48 w/lift 36+1 Overall vehicle length (inches): w/o lift 365 w/lift 365 MAKE IC Corporation CHASSIS Warranty: Years 5 Miles Unlimit MANUFACTURER International ENGINE Torque: 620 @ 1400 RPM H.P.: 240 @ 2600 RPM MODEL PB105 MANUFACTURER Allison MODEL 2500 PTS YEAR 2014 Wheel base: 218 MODEL MaxxForce 7 TRANSMISSION Warranty: Years 5 Speeds forward: 5 Miles Unlimit Warranty: Years 3 Miles 100,000 YEAR 2014 Number of cylinders: 8 Inline V-type X C.I.D.: 389 Fuel type: Battery type/grp: 31 31 Number batteries: 3 3 Total CCA: 1950 1950 QUOTED PRICE Quoted price is based upon payment within 30 days after delivery to the school district (without sales tax). Bid w/o lift $ 84,501 Bid w/lift $ 87,785 VENDOR REPRESENTATIVE S SIGNATURE DATE FORM SPI 1394-2 (Rev. 7/13)
DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 D84 Use this document to bid both non-lift and lift buses. PART II Price of items bid will establish the district cost. Activity Securement Seating 2-passenger position seats with lap-shoulder belts in all passenger positions. Passenger Capacity 32 Cost $ 17,216 Air Conditioning To cool passenger compartment as required in the Washington TransAir 60k State School Bus Specifications manual. Cost $ 9,474 Alternate Fuel N/A Must comply with power and gradeability formula. Refer to CNG CNG Cost $ N/A Washington State School Bus Specifications manual. Other Other Cost $ N/A Alternator 200 amp. minimum. Cost $ Standard Anti-spray Device Rubber fender extenders. Type C: Cost $ 136 Type D: Cost $ 272 Back-up Alarm Must meet state minimum specification. Ecco #SA-917-87 Cost $ 123 Brakes 4-wheel hydraulic disk brake. Cost $ Standard Deduct $ Brakes Air, Drum or Disc. Refer to Washington State School Bus Specifications manual. Cost $ 957 Deduct $ Color Exterior white roof. Cost $ 776 Door Locks Vandal lock system on all exterior doors. Cost $ 718 Driver s Seat Fire Suppression System Suspension type, 6-way adjustable, with lumbar adjustment. Cloth panel covers. Jomarr VT-6-E-NAF, or equal engine compartment fire suppression system of appropriate size to be installed according to manufacturer recommendation. FORM SPI 1394-2 (Rev. 7/13) Part II Page 1 Non-Air Air Magnum National Cost $ 250 Cost $ 302 Jomar Cost $ 6446 Floor Color Nonstandard color. Cost $ 371 Fuel Tank Larger fuel capacity ( only). Size: N/A Cost $ Fuel Tank Larger fuel capacity ( only). Size: N/A Cost $
PART II (cont.) State Price Quote Specification DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 D84 Use this document to bid both non-lift and lift buses. Headlights Halogen. Cost $ Standard Heater (Auxiliary water) Lights, Exterior Noise Reduction Retarder Auxiliary fuel-fired heating systems. Refer to Washington State School Bus Specifications Manual, page 27. LED (Light Emitting Diode). Complete package includes clearance lights, stop lights, tail lights and turn signals, but does not include eight-light system. Exceeding minimum specifications. Manufacturer s standard. Seat Belt Ready Seat 3-passenger position seat with securement belts. Cost $ 296 2 by 2 Cost $ 17,216 Capacity 32 Seating System Identical, non-lift bus with lap-shoulder seat belt system installed 3 by 2 Cost $ N/A in all positions. Capacity N/A 3 by 3 Cost $ 19,584 Capacity 48 Steering Wheel Tilt and telescoping column. Cost $ 745 Price of items bid will establish the district cost. Brand: Webasto Model: Scholastic Cost $ 3,799 Clearance Lights Cost $ 97 Eight-Light System Cost $ 1049 Stop Lights 7 Cost $ 106 Tail Lights Cost $ 138 Turn Signals Cost $ 308 Complete Package Cost $ 649 Driver compartment Cost $ 159 Engine compartment Cost $ 333 Full acoustical headliner Cost $ 131 Driveline Cost $ Exhaust Cost $ 1,531 Transmission Cost $ FORM SPI 1394-2 (Rev. 7/13) Part II Page 2
DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 D84 Use this document to bid both non-lift and lift buses. PART II (cont.) Storage Compartments Strobe Light Student Protection System Installed Suspension Largest available for unit bid. Exterior roof mounted white strobe light. Electronic system to insure driver post-trip inspection of passenger compartment. Air ride (Air brake system only). Price of items bid will establish the district cost. Left-side 16.5 cubic feet. Cost $ 1116 Right-side 11 cubic feet. Cost $ 728 Push-thru N/A cubic feet. Cost $ N/A Specialty Model No. 515-400 Cost $ 145 IC Model No. NCLB Cost $ N/C Front Rear Cost $ N/A Cost $ 1022 Toolbox Interior, manufacturer standard. Cost $ 47 Deduct $ 62 Traction Device Traction Device Transmission Vehicle Securement System Automatic chains. Sanders. Automatic Allison, PTS 3000 or equal. On Spot Cost $ 2,327 Capacity 10 Gallon Cost $ 2490 Allison Model No. 3000 PTS Cost $ 5,544 Must meet state minimum specification. SBS Cost $ 792 FORM SPI 1394-2 (Rev. 7/13) Part II Page 3
DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 D84 Use this document to bid both non-lift and lift buses. PART II (cont.) Video Camera Systems Installed Warning Light Monitor Additional Wheelchair/Occupant Tie-down System Installed Wheelchair Lift Installed (Rear Engine Only) Windows Digital audio/video system for monitoring the passenger compartment with more than two cameras. 16 light monitoring system. Must meet state minimum specification. Must meet state minimum specification. Platform shall be a minimum of 32 x 52. Laminated passenger-compartment side or rear glass. Windows Tinted. Cost $ 820 Windows Thermal pane, left of driver and service door. Cost $ 495 Price of items bid will establish the district cost. Seon Model No. TL4F Cost $ 2,390 How many cameras 3 Incandescent LED Lights Cost $ 191 Cost $ 217 Q-Straint Model No. Q-8100-A1-SC Cost per station $ 1,115 Q-Straint Model No. Q-8100-A1-SC Cost $ 1,115 Side Cost $ 816 Rear Cost $ 103 Both Cost $ 919 FORM SPI 1394-2 (Rev. 7/13) Part II Page 4