2014-15 State Price Quote Specification TYPE C60 BID AS 48 PASSENGER, DIESEL & PROPANE Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I Engine Transmission Axle Front Axle Rear Axle Ratio Axle Oil Seals Alternator CHASSIS STATE-SUPPORTED SPECIFICATIONS and 180 H.P. minimum. Automatic Allison, PTS 2500 or equal. 8,000 lb. minimum. 17,500 lb. minimum. Must comply with power and grade-ability formula. Refer to Washington State School Bus Specifications Manual. Front and rear oil bath. 200 amp minimum with or w/o lift-equipped vehicle. Engine mfr. Cummins Model or liters 6.7L VENDOR SPECIFICALLY IDENTIFY BID Price of items bid will establish the state cost. Engine mfr. N/A Model or liters Net torque 520 @ 1600 R.P.M Net torque @ R.P.M Net H.P. 200 @ 2400 R.P.M Net H.P. @ R.P.M Allison Model no. 2500 PTS Net input torque 520 Net input H.P. 200 Meritor Capacity 8,000 Meritor Capacity 19,800 IC Model no. 5.29 Stemco Voyager Bosch LH200 Model no. Net input torque Net input H.P. Capacity Capacity Model no. Max. amps output w/o lift 200 w/lift 200 Max. amps output w/o lift w/lift FORM SPI 1394-2 (Rev. 7/14) Part I Page 1
TYPE C60 BID AS 48 PASSENGER, DIESEL & PROPANE Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I (cont.) Battery(ies) Brakes Engine Heater Engine Temperature Fuel Tank CHASSIS STATE-SUPPORTED SPECIFICATIONS VENDOR SPECIFICALLY IDENTIFY BID Price of items bid will establish the state cost. 1200 CCA 12 volt minimum to be mounted in body battery Size/group w/o lift 31 CCA 1950 Size/group w/o lift CCA compartment w/o lift. 1400 CCA 12 volt minimum to be mounted in body battery Size/group w/lift 31 CCA 1950 Size/group w/lift CCA compartment w/lift. Hydraulic disc. Refer to Washington State School Bus Specifications Manual. Engine manufacturer s recommended in-block heater. To be controlled electronically, by fan clutch/drive, or shutters. 60 gallon minimum. 60 gallon minimum. Size Front 70mm Rear 70mm Watts 750 Volts 120 Phillips Borg Warner Fan clutch Capacity 60 Capacity Hood Tilt. Fiberglass Metal Tires Wheels 6 first quality, radial ply. No low profile tires. 6 to be compatible with tire size. Goodyear Size 11R22.5 Load range H Size 22.5 Rim width 8.25 Electronic Shutters FORM SPI 1394-2 (Rev. 7/14) Part I Page 2
TYPE C60 BID AS 48 PASSENGER, DIESEL & PROPANE Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I (cont.) Seating Capacity Auxiliary Fans Back-up Lights Battery Compartment Door, Service Heaters Lights P.A. System Seat Spacing BODY STATE-SUPPORTED SPECIFICATIONS 48 passenger based upon an average center-to-center seat spacing of at least 27.5. 2 fans, 6 maximum, mounted to right and left windshield and service door. All required backup lights to be LED (Light Emitting Diode). Refer to Washington State School Bus Specification s Manual. Battery storage tray must be large enough to accommodate batteries as specified in chassis section. Power operated. Minimum of 4 heaters; 2 front, 1 center, 1 rear. Shutoff valves at engine for all heaters. Two-speed motors. Must include recirculating pump. LED (Light Emitting Diode). Includes Clearance Lights, Stop Lights 7, Tail Lights, Turn Signals, Eight-Light System, and Dome-Light System. AM/FM/PA radio with 2 interior and 1 exterior speakers. To permit specified passenger capacity based on an average center-to-center seat spacing of at least 27.5. VENDOR SPECIFICALLY IDENTIFY BID Price of items bid will establish the state cost. Capacity w/o lift 48 Capacity w/lift 36+1 Bergstrom Round: Other: Swing out Air Electric Other Diameter 4 Inch Square inches Capacity w/o lift Capacity w/lift Roll out Folding Split, Outward opening Other Left-front B.T.U. 90,000 Right-front B.T.U. 50,000 Center B.T.U. 50,000 Rear B.T.U. 50,000 Total B.T.U. 240,000 Check if as specified Panasonic Model No. CRCM120UA Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 252.9 w/lift 252.9 Mfg. s C/C seat measurement of vehicle (inches): w/o lift 27.61 w/lift 29.43 FORM SPI 1394-2 (Rev. 7/14) Part I Page 3
TYPE C60 BID AS 48 PASSENGER, DIESEL & PROPANE Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I (cont.) BODY STATE-SUPPORTED SPECIFICATIONS Steering Wheel Tilt and telescoping column. Check if as specified Step Tread Studded or pebbled top tread covering. Koroseal Toolbox Exterior, manufacturer standard. Size (cubic feet) 2.9 VENDOR SPECIFICALLY IDENTIFY BID Price of items bid will establish the state cost. Two-way Communications Wheelchair Lift Installed Wheelchair/Occupant Tie-down System Installed Line Setting Ticket Owner s/operator s Handbook Repair Manuals 45-watt, VHF, mil. spec. ICOM Model No. F-5011 SPECIAL NEEDS REQUIREMENTS CHASSIS AND BODY Must meet state specification. Platform shall be a minimum of Braun Century 32 x 52. Model No. NCL919IB-2 Must meet state specification. Q-Straint Model No. Q-8100-A1-SC ADDITIONAL REQUIREMENTS CHASSIS AND BODY Legible copy of manufacturer s Line Setting Ticket will be delivered with each vendor s packet at the time of delivery of the Check if as specified bus. One copy of the chassis manufacturer s owner s/operator s handbook or manual will be furnished with each bus at time of Check if as specified delivery. A complete set of chassis, engine, transmission, and body repair manuals, including wiring diagram for all components, will be Check if as specified made available at time of delivery, with instructions available on accessing repair materials. FORM SPI 1394-2 (Rev. 7/14) Part I Page 4
TYPE C60 BID AS 48 PASSENGER, DIESEL & PROPANE Use this document to bid both non-lift and lift buses for 35 60 capacity. PART I (cont.) Service and Cleaning Warranty ADDITIONAL REQUIREMENTS CHASSIS AND BODY Cleaning and service by vendor prior to delivery will include: Chassis lubrication. Check fluid levels: verify all are at recommended full levels. Cooling system protected at -20 F. Interior and exterior will be clean (including glass). Check if as specified All systems (electric, air, hydraulic, mechanical and manual) be inspected to ensure proper operation at time of delivery. All components and accessories will be installed and operational at time of delivery. A complete copy of all warranty agreements will be furnished at time of delivery. Check if as specified FORM SPI 1394-2 (Rev. 7/14) Part I Page 5
PUPIL TRANSPORTATION Old Capitol Building PO BOX 47200 Olympia, WA 98504-7200 (360) 725-6120 TTY (360) 664-3631 2014-15 VEHICLE DATA SHEET AND OFFICIAL PRICE QUOTATION TYPE C60 BID AS 48 PASSENGER (DIESEL) VENDOR S COMPANY NAME Harlow's Bus Sales ADDRESS 1240 West Main Street PO Box 1107 Auburn, WA 98071 REPRESENTATIVE S NAME Jim O'Connell TELEPHONE NUMBER 253-939-7700 Estimated delivery date to school district from time purchase order is received: 180 Days ARO Firm where engine and chassis can be serviced or repaired and parts obtained: Any IC or International Dealer Firm where body can be serviced or repaired and parts obtained: Harlow's Bus Sales MAKE IC Corporation CE 105 YEAR 2015 BODY Warranty: Years 5 Miles Unlimit Seat color: Gray Floor color: Black Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift 252.9 w/lift 252.9 Equipped seating capacity: w/o lift 48 w/lift 36+1 Overall vehicle length (inches): w/o lift 365 w/lift 365 MAKE IC Corporation CHASSIS Warranty: Years 5 Miles Unlimit MANUFACTURER Cummins ENGINE Torque: 520 @ 1600 RPM H.P.: 200 @ 2400 RPM PB105 MANUFACTURER Allison 2500 PTS YEAR 2015 Wheel base: 218 ISB 200 TRANSMISSION Warranty: Years 5 Speeds forward: 5 Miles Unlimit Warranty: Years 3 Miles 100,000 Number of cylinders: 6 Inline X V-type YEAR 2015 C.I.D.: 409 Fuel type: Battery type/grp: 31 31 Number batteries: 3 3 Total CCA: 1950 1950 QUOTED PRICE Quoted price is based upon payment within 30 days after delivery to the school district (without sales tax). Bid w/o lift $ 87,004 Bid w/lift $ 89,147 VENDOR REPRESENTATIVE S SIGNATURE DATE FORM SPI 1394-2 (Rev. 7/14)
PUPIL TRANSPORTATION Old Capitol Building PO BOX 47200 Olympia, WA 98504-7200 (360) 725-6120 TTY (360) 664-3631 2014-15 VEHICLE DATA SHEET AND OFFICIAL PRICE QUOTATION TYPE C60 BID AS 48 PASSENGER (PROPANE) VENDOR S COMPANY NAME REPRESENTATIVE S NAME TELEPHONE NUMBER ADDRESS Estimated delivery date to school district from time purchase order is received: Firm where engine and chassis can be serviced or repaired and parts obtained: Firm where body can be serviced or repaired and parts obtained: MAKE Warranty: Years Miles YEAR Seat color: Floor color: BODY Inside measurement from rear of stepwell to appropriate point at rear of passenger seating area: w/o lift w/lift Equipped seating capacity: w/o lift w/lift Overall vehicle length (inches): w/o lift w/lift CHASSIS MAKE Warranty: Years Miles ENGINE MANUFACTURER Torque: @ RPM H.P.: @ RPM YEAR Wheel base: YEAR C.I.D.: Fuel type: MANUFACTURER TRANSMISSION Speeds forward: Warranty: Years Miles Battery type/grp: Number batteries: Warranty: Years Miles Number of cylinders: Inline V-type QUOTED PRICE Quoted price is based upon payment within 30 days after delivery to the school district (without sales tax). Bid w/o lift $ Bid w/lift $ Total CCA: VENDOR REPRESENTATIVE S SIGNATURE DATE FORM SPI 1394-2 (Rev. 7/14)
DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 Use this document to bid both non-lift and lift buses. Vendor: PART II Activity Securement Seating Air Conditioning 2-passenger position seats with lap-shoulder belts in all passenger positions. To cool passenger compartment as required in the Washington State School Bus Specifications manual. VENDOR SPECIFICALLY IDENTIFY BID Price of items bid will establish the district cost. Passenger Capacity 32 Cost $ 17,216 TransAir 60k Cost $ 9,474 Alternate Fuel N/A Must comply with power and gradeability formula. Refer to CNG CNG Cost $ Washington State School Bus Specifications manual. Other Other Cost $ Alternator 200 amp. minimum. Cost $ Standard Anti-spray Device Back-up Alarm Rubber fender extenders. Must meet state specification. Type C: Cost $ 136 Type D: Cost $ 272 Ecco #SA-917-87 Cost $ 123 Brakes 4-wheel hydraulic disk brake. Cost $ Standard Deduct $ Brakes Air, Drum or Disc. Refer to Washington State School Bus Specifications manual. Color Exterior white roof. Cost $ 776 Door Locks Vandal lock system on all exterior doors. Cost $ 718 Driver s Seat Fire Suppression System Suspension type, 6-way adjustable, with lumbar adjustment. Cloth panel covers. Jomarr VT-6-E-NAF, or equal engine compartment fire suppression system of appropriate size to be installed according to manufacturer recommendation. Disc Cost $ 957 Disc Deduct $ Drum Cost $ Drum Deduct $ Non-Air Magnum National Cost $ 250 Cost $ 302 Jomarr AGX-450 Cost $ 1,995 Floor Color Nonstandard color. Cost $ 371 Fuel Tank Larger fuel capacity ( only). Size: 65 Cost $ 150 Air FORM SPI 1394-2 (Rev. 7/14) Part II Page 1
PART II (cont.) State Price Quote Specification DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 Use this document to bid both non-lift and lift buses. VENDOR SPECIFICALLY IDENTIFY BID Price of items bid will establish the district cost. Fuel Tank Larger fuel capacity ( only). Size: N/A Cost $ Headlights Halogen. Cost $ Standard Heater (Auxiliary water) Noise Reduction Retarder Auxiliary fuel-fired heating systems. Refer to Washington State School Bus Specifications Manual, page 27. Exceeding minimum specifications. Manufacturer s standard. Brand: Webasto Model: Scholastic Cost $ 3,799 Driver compartment Cost $ 159 Engine compartment Cost $ 333 Full acoustical headliner Cost $ 131 Driveline Cost $ Exhaust Cost $ 184 Transmission Cost $ Seat Belt Ready Seat 3-passenger position seat with securement belts. Cost $ 956 2 by 2 Cost $ 17,216 Capacity 32 Seating System Identical, non-lift bus with lap-shoulder seat belt system installed in all positions. 3 by 2 Cost $ N/A Capacity N/A 3 by 3 Cost $ 19,584 Capacity 48 Left-side 16.5 cubic feet. Cost $ 1,116 Storage Compartments Largest available for unit bid. Right-side 11 Cost $ 728 cubic feet. Push-thru N/A cubic feet. Cost $ N/A FORM SPI 1394-2 (Rev. 7/14) Part II Page 2
DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 Use this document to bid both non-lift and lift buses. PART II (cont.) Strobe Light Student Protection System Installed Suspension Exterior roof mounted white strobe light. Electronic system to insure driver post-trip inspection of passenger compartment. Air ride (Air brake system only). VENDOR SPECIFICALLY IDENTIFY BID Price of items bid will establish the district cost. Specialty Model No. 515-400 Cost $ 149 IC Model No. NCLB Cost $ Included Front Cost $ N/A Cost $ 1,203 Toolbox Interior, manufacturer standard. Cost $ 47 Deduct $ 62 Traction Device Traction Device Transmission Vehicle Securement System Video Camera Systems Installed Automatic chains. Sanders. Automatic Allison, PTS 3000 or equal. On Spot Cost $ 3,102 Capacity 10 Gallon Cost $ 2490 Allison Model No. 3000 PTS Cost $ 5,544 Must meet state specification. SBS Cost $ 1,010 Digital audio/video system for monitoring the passenger compartment with more than two cameras. Seon Model No. TL4 Rear Cost $ 2,428 How many cameras 3 FORM SPI 1394-2 (Rev. 7/14) Part II Page 3
DISTRICT-SUPPORTED OPTIONS C48 C71 C71E D48 D78 Use this document to bid both non-lift and lift buses. PART II (cont.) Video Camera Systems Stop Sign Camera Installed Warning Light Monitor Additional Wheelchair/Occupant Tie-down System Installed Wheelchair Lift Installed (Rear Engine Only) Windows Must meet state specification. 16 light monitoring system. Must meet state specification. Must meet state specification. Platform shall be a minimum of 32 x 52. Laminated passenger-compartment side or rear glass. VENDOR SPECIFICALLY IDENTIFY BID Price of items bid will establish the district cost. Stand Alone System Added to Interior System Seon Model No. TL4F Seon Model No. TL4F Cost $ 1,874 Cost $ 3,048 How many cameras 1 How many cameras 4 Incandescent Cost $ 191 Cost $ 217 Q-Straint Model No. Q-8100-A1-SC Cost per station $ 1,115 Model No. Cost $ Side Cost $ 816 Rear Cost $ 103 Both Cost $ 919 Windows Tinted. Cost $ 820 Windows Thermal pane, left of driver and service door. Cost $ 495 LED Lights FORM SPI 1394-2 (Rev. 7/14) Part II Page 4