AMM 6-00-00 1.0.0.0GENERAL 1. General This chapter includes information on dimensions, areas, oning, etc. and is presented as follows: Measurements and Figures which show the stations of fuselage frames, wing and stabilier ribs, etc. The method of oning used on this aircraft. Information on access doors and panels. Refer to 6-10-00, pb1. Refer to 6-20-00, pb1. Refer to 6-30-00, pb1. 6-00-00 Page 1
AMM 6-10-00 2.0.0.0DIMENSIONS, AREAS AND STATIONS 1. General Principal dimensions of aircraft. Refer to Figure 1. Fuselage stations. Refer to Figure 2. Wing stations. Refer to Figure 3 Empennage stations. Refer to Figure 4. Refer to Figure 5. The principal areas and volumes are as follows:- Area Sq.ft. (m 2 ) Wing (gross) 454.0 42.18 Flap (total) 83.3 7.74 Horiontal stabilier (gross) 05.8 9.83 Vertical stabilier (gross, excluding dorsal) 91.4 8.49 Aileron (aft of hinge line), per side) 13.7 1.27 Aileron (total), per side 17.6 1.64 Elevator (aft of hinge line) 27.9 2.59 Elevator (total) 39.8 3.70 Rudder (aft of hinge line) 26.3 2.44 Rudder (total) 35.8 3.33 Passenger compartment floor, untrimmed 223.0 20.72 Volume cu.ft. (m 3 ) Baggage compartment (forward) 45 1.274 Baggage compartment (aft) 170 4.814 6-10-00 Page 1
SD3-60 AIRCRAFT MAINTENANCE MANUAL Principal Dimensions Figure 1 6-10-00 Page 2
Fuselage Stations Figure 2 6-10-00 Page 3
SD3-60 AIRCRAFT MAINTENANCE MANUAL Wing Stations Figure 3 6-10-00 Page 4
Empennage Stations - Vert. Stab. & Rudder Figure 4 6-10-00 Page 5
SD3-60 AIRCRAFT MAINTENANCE MANUAL Empennage Stations - Hor. Stab. & ELevators Figure 5 6-10-00 Page 6
AMM 6-20-00 3.0.0.0ZONING 1. General This section includes a description of the method used in oning the aircraft and defines the boundaries of the major ones and major sub-ones. ones are identified by three-digit numbers. The first digit defines the major one. The major ones are as follows. Refer to Figure 1 Major Zone No. Definition 100 Under floor area between fuselage stations -60 and 595 200 Above floor area between fuselage nose and station 475 300 Empennage. Includes stabiliers, rudder, elevators and tail section of fuselage aft of station 475. 400 Powerplant 500 Left wing. Includes flaps, aileron and strut 600 Right wing. Includes flaps, aileron and strut 700 Landing gear. Includes stub wing 800 Doors The major sub-ones are identified by the remaining two digits. Refer to Figure 2. Refer to Figure 3. They are defined as follows:- Major Sub-one No. Definition 110 Between fuselage stations -60 and 3 121 (122) Between fuselage stations 3 and 74 left (right) but excluding the nose wheel well which is part of major one 700. 130 Between fuselage stations 74 and 508 140 Between fuselage stations 508 and 595 210 Between the fuselage nose and fuselage station 3 220 Between fuselage stations 3 and 74 6-20-00 Page 1
SD3-60 AIRCRAFT MAINTENANCE MANUAL Major Zones Figure 1 6-20-00 Page 2
Major Sub-ones - Fuselage and Tail Figure 2 6-20-00 Page 3
SD3-60 AIRCRAFT MAINTENANCE MANUAL Major Sub-one No. Definition 230 Between fuselage stations 74 and 475 and between passenger compartment floor and roof levels 240 Between fuselage stations 74 and the wing centre section front spar frame above the passenger compartment roof 250 Between the wing centre section rear spar frame and fuselage station 475 above the passenger compartment roof 260 Passenger cabin - internal, sub-divided:- 261 Station 74-146.2 262 Station 146.2-249.2 263 Station 249.2-351.9 264 Station 351.9-475 265 Station 475-508 311 The fuselage portion of the empennage, aft of station 475 312 Aft baggage compartment 331 Left horiontal stabilier 332 Left elevator 333 Left horiontal stabilier tip 341 Right horiontal stabilier 342 Right elevator 343 Right horiontal stabilier tip 351 Vertical stabilier 352 Rudder 353 Vertical stabilier tip 410 Accessory bay 420 Air intake 430 Exhaust 440 Nacelle rear fairing 450 Nacelle/wing fairing 510 (610) Left (right) wing leading edge to rear spar between aircraft centre line and wing tip root rib 520 (620) Left (right) wing trailing edge aft of rear spar between fuselage side and wing tip root rib 530 (630) Left (right) inner flap 540 (640) Left (right) mid flap 550 (650) Left (right) outer flap 6-20-00 Page 4
Major Sub-one No. Definition 560 (660) Left (right) aileron 570 (670) Left (right) wing tip 580 (680) Left (right) wing strut 710 Nose wheel well and doors 720 (730) Right (left) main gear fairing. Includes doors, wheel well and stub wing 810 Nose baggage compartment door 820 Crew ditching hatch 830 Cargo door 840 (850) Right (left) forward emergency exit 860 Right aft emergency exit 870 Passenger door 880 Aft baggage door 6-20-00 Page 5
SD3-60 AIRCRAFT MAINTENANCE MANUAL Major Sub-one - Wings and Tail Plane Figure 3 6-20-00 Page 6
AMM 6-30-00 4.0.0.0ACCESS DOORS AND PANELS 1. General The figures which follow, which taken as a group, identify all access doors and panels throughout the aircraft (both external and internal). Refer to Figure 1. 2. Method of identification Each access door or panel is identified by a numeric/alpha number. The numeric component of the number is the three digit number which identifies the smallest one in which the door is located. The two-element alpha suffix designates the location of the door within the one. The first alpha letter identifies each door within the one in a logical sequence, i.e. inboard to outboard or front to rear, starting with `A' in each one. The second alpha letter locates the door in its relationship to the aircraft, as follows: T = Top B = Bottom L = Left hand R = Right hand Z = Internal For example, access door 230ER would be fifth access door aft of frame 74 on the fuselage right side. 6-30-00 Page 1
SD3-60 AIRCRAFT MAINTENANCE MANUAL Access Panels - Figure Identification Figure 1 6-30-00 Page 2
Access Panels - Fwd. Baggage Compt. Figure 2 6-30-00 Page 3
SD3-60 AIRCRAFT MAINTENANCE MANUAL Access Panels - Flight Compt. Figure 3 6-30-00 Page 4
Access Panels - Passenger Compt. Figure 4 6-30-00 Page 5
SD3-60 AIRCRAFT MAINTENANCE MANUAL Access Panels - Aft Baggage Compt. Figure 5 6-30-00 Page 6
Access Panels - Fwd. Roof Fairing Figure 6 6-30-00 Page 7
SD3-60 AIRCRAFT MAINTENANCE MANUAL Access Panels - Aft Roof Fairing Figure 7 6-30-00 Page 8
Access Panels - Power Plant Figure 8 6-30-00 Page 9
SD3-60 AIRCRAFT MAINTENANCE MANUAL Access Panels - Centre & Outer Wings Figure 9 6-30-00 Page 10
Access Panels - M.L.G Fairings & Stub Wings Figure 10 6-30-00 Page 11
SD3-60 AIRCRAFT MAINTENANCE MANUAL Access Panels - Vert. & Hori Stabiliers Figure 11 6-30-00 Page 12
Access Panels - Fuselage Figure 12 6-30-00 Page 13