Technical Application Guide for UP-SHINE LED Tube Light UP-T824W15-O
Introduction LED Glass Tube is the most practical and economical energy saving design compared to aluminum & PC tube or complete plastic LED tube T8. These glass tubes distribute light in 18 wide beam angle without dark area and provide high lumen output while achieving efficacies over 1 lumens per watt. It has translucent crystal appearance, smooth and moist texture, enjoyable experience. High thermal conductivity glass ensures low temperature during operating, which brings reliable and stable product performance throughout lifetime. Up to 7% energy saving compared to halogen lamp Long lifetime of 4, hours 18 beam angle 15mm length CCT: K 4K 5K 57K No UV/IR light Environment friendly, without Mercury or any other hazardous substances Application notes IP2 for indoor use only Professional electrician for installation only Switch off before installation Do not touch when in use Keep away from hot steam and corrosive gas Certificates
Product Information 28.5 151 1498 Technical Specifications Model Voltage Power Power Factor Lumen (±5%) Beam angle CCT Lifespan CRI Dimmable Dimension UP-T824W15-O AC1-24V 24W.9 215 18 o K 4h 8 No L151*W28.5*H28.5mm UP-T824W15-O AC1-24V 24W.9 228 18 o 4K 4h 8 No L151*W28.5*H28.5mm UP-T824W15-O AC1-24V 24W.9 2 18 o 5K 4h 8 No L151*W28.5*H28.5mm UP-T824W15-O AC1-24V 24W.9 25 18 o 57K 4h 8 No L151*W28.5*H28.5mm Driver data Sheet Driver data Non-dim Input rated Voltage Frequency Input Voltage AC1-24V 5/6Hz AC85-265V Efficiency 88% Total load Wattage 24W±5% Power Factor.9 Rated input current Full load output Voltage Rated output current Output current range.27a DC6-72V ma ma±5% Power tolerance ±5% Current output tolerance ±5% Short circuit protection Over voltage protection Over temperature protection Withstand voltage PASS PASS PASS AC75V Fixture Compatibility Rated Wattage Electrical Classification Ingress Protection Operating Temp Operating Humidity Storage Temp 24W Ⅱ IP2-2 o C~45 o C ~9% -2 o C~65 o C
Spectral Distribution K 4K.8 Max=58 [1.=2].5SDCM FK.8 Max=4914 [1.=2] 2.51SDCM F4K.7.7.6.6.5.4. x=.4464 y=.449.5.4. x=.788 y=.742.2.2.1.1. 8 5 6 7 8. 8 5 6 7 8 5K 57K.8 Max=8694 [1.=2] 2.5SDCM F5K.8 Max=742 [1.=2] 4.91SDCM F57K.7.7.6.6.5.4. x=.47 y=.564.5.4. x=.47 y=.564.2.2.1.1.. 8 5 6 7 8 8 5 6 7 8 Photometric Diagram K 4K -12-9 -/+18 6 12 9 MH=1m C/18 C9/27 Flux out: 69 lm.281ft 6.828, 24.55fc 1m 7.5, 264.2lx 6.562ft 1.77, 6.17fc 2m 18.7, 66.6lx 11.19ft 41.cm 22.8ft 681.99cm -12-9 -/+18 6 12 9 MH=1m C/18 C9/27 Flux out: 77.2 lm.281ft 7.551, 25.76fc 1m 88, 271.lx 6.562ft 88, 6.441fc 2m 2.2, 69.lx 1.9ft cm 21.79ft 664.2cm 12 9.84ft.7587, 28fc m 8.166, 29.6lx.56ft 122.99cm 12 9.84ft.89, 2.86fc m 9.1,.81lx 2.69ft 996.cm 18 18 24.9 1.12ft.4268, 4fc 4m 4.594, 16.51lx 44.75ft 16.99cm 24.9 1.12ft.4719, 1.61fc 4m 5.8, 17.lx 4.58ft 128.4cm - AVERAGE BEAM ANGLE(5%): 18.9 DEG.6. -25-2 -15-1 -5 5 1 15 2 25 16.4ft.271,.9819fc 55.94ft 5m 2.94, 7lx 174.98cm Height Eavg, Emax Angle: 179.22deg Diameter - AVERAGE BEAM ANGLE(5%): 18.8 DEG.6. -25-2 -15-1 -5 5 1 15 2 25 16.4ft.2,1.1fc 54.48ft 5m.251, 11.9lx 166.51cm Height Eavg, Emax Angle: 182.89deg Diameter 5K 57K -12-9 -/+18 6 12 9 MH=1m C/18 C9/27 Flux out: 912.5 lm.281ft 1, 41.6fc 1m 154.1, 98.2lx 6.562ft.24, 1.11fc 2m 7.6, 11.4lx 8.228ft cm 16.56ft 54.16cm -12-9 -/+18 6 12 9 MH=1m C/18 C9/27 Flux out: 648.8 lm.281ft 7.491, 24.1fc 1m 8.6, 258.4lx 6.562ft 7, 6.2fc 2m 6, 64.6lx 1.ft 14.2cm 2.61ft 628.5cm 12 9.84ft 1.469,.947fc m 16.91, 49.lx 24.8ft 8.12cm 12 9.84ft.82, 2.667fc m 8.959, 28.71lx.91ft 94cm 18 18 24 - AVERAGE BEAM ANGLE(5%): 181. DEG.9.6. -25-2 -15-1 -5 5 1 15 2 25 1.12ft.8189, 2.51fc.65ft 1.12ft.9.4682, fc 41ft 4m 9.851, 25.6lx 166.1cm 24 4m 5.4, 16.15lx 1256.1cm.6 16.4ft.5879, 61fc 4ft -. 16.4ft.2996,.96fc 51ft 5m 5.21, 17.7lx 14.55cm 5m.225, 1.4lx 157.12cm -25-2 -15-1 -5 5 1 15 2 25 Height Eavg, Emax Angle: 18.27deg Diameter Height Eavg, Emax Angle: 185.1deg Diameter AVERAGE BEAM ANGLE(5%): 18.8 DEG
Polar Diagram Comparison -15 O +/-18 O 15 O -12 O 12 O -9 O 9 O 6 12-6 O 18 6 O 24 - O O O AVERAGE BEAM ANGLE (5%): 18DEG C/18, 272. deg C/21, 24. deg C6/24, 141.1 deg C9/27, 1 deg Driver lifetime & LED light decay rate Driver Lifetime LED Light Decay Rate 9 11%.4 Lifetime (hours) 8 7 6 5 4 2 1 65 o C 75 o C 85 o C 95 o C 15 o C Capacitor Tc ( o C) % Luminous Flux 15% 1% 95% 9% 85% 8% 75% FLUX.1.5 U'V' 7%. 1 2 4 5 6 7 8 9 1 LifeTime (hours).5..25.2.15 Temperature The testing is operated at 25 C The lifetime of capacitor, minimum of 5, hours if operated at 15 C, will be doubled whenever the temperature drops 1 C. The highest withstand temperature of IC, MOS could be 12 C The highest withstand temperature of LED junction temperature is 15 C Temperature ( o C) 9 8 7 6 5 4 2 1 19:59:47 2:2:4 21:5:4 21:8:4 22:11:4 22:44:4 2:17:4 :2:4 :56:4 1:29:4 2:2:4 2:5:4 :8:4 4:14:4 5:2:4 5:5:4 6:26:4 7:2:4 8:5:4 8:8:4 Time IC Capacitor MOS PCB Voltage transformer Environmental temperature The driver lifespan is based on capacitor working temperature.
Installation 1. One end power tube, installation with Fluorescent tube 1-24Vac 1-24Vac 1-24Vac Step 1 Step 2 Step 2. One end power tube,installation with Inductive Ballast Inductive Ballast Remove the inductive ballast or not 1-24Vac 1-24Vac Remove the fluorescent starter 1-24Vac Fluorescent starter Fluorescent tube Step 1 Step 2 Step. Two end power tube, installation with Fluorescent tube 1-24VAC 1-24VAC 1-24VAC Step 1 Step 2 Step 4. Two end power tube, installation with Inductive Ballast 1-24VAC Inductive Ballast Fluorescent tube 1-24VAC Remove the inductive ballast or not 1-24VAC Connect the wire if the inductive ballast is removed Fluorescent starter Remove the Fluorescent starter Step 1 Step 2 Step Packaging Information SIZE(CM) N.W/pc (KGS) G.W.(KGS) Q'TY(PCS) Carton 159.5*21*21.8 16.75 25 2'' standard container 4'' standard container CTNS Q'TY(PCS) VOLUME(CBM) 9 975 28 78 195 56 Phone: +86 755 2919 789 Add: 2nd building Dingfeng High-Tech Zone, Fuyuan 1st road, Fu Yong Sub-district, Bao'an, Shenzhen China