NOTICE: hen inspecting or repairing the SS, perform service in accordance with the following precautionary instructions and the procedure, and precautions in the epair Manual applicable for the model year. SS Malfunction symptoms of the SS are difficult to confirm, so the DTCs become the most important source of information when troubleshooting. hen troubleshooting the SS, always inspect the DTCs before disconnecting the battery. ork must be started more than 90 seconds after the ignition S is turned to the OCK position and the negative (-) terminal cable is disconnected from the battery. (The SS is equipped with a back-up power source so that if work is started within 90 seconds from disconnecting the negative (-) terminal cable of the battery, the SS may deploy.) hen the negative (-) terminal cable is disconnected from the battery, the memory of the clock and audio system will be cleared. So before starting work, make a record of the contents in the audio memory system. hen work is finished, reset the audio systems as they were before and adjust the clock. Some vehicles have power tilt steering, power telescopic steering, power seat and power outside rear view mirror which are all equipped with memory function. However, it is not possible to make a record of these memory contents. So when the work is finished, it will be necessary to explain it to your customer, and ask the customer to adjust the features and reset the memory. To avoid erasing the memory in each system, never use a back-up power supply from outside the vehicle. efore repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair. Do not expose the following parts directly to hot air or flame; Even in cases of a minor collision where the SS does not deploy, the following parts should be inspected; Never use SS parts from another vehicle. hen replacing parts, replace with new parts. For the purpose of reuse, never disassemble and repair the following parts. If the following parts have been dropped, or have cracks, dents and other defects in their case, bracket, and connector, replace with new one. Use a volt/ohmmeter with high impedance (0 kω/v minimum) for troubleshooting electrical circuits of the system. Information labels are attached to the periphery of the SS components. Follow the instructions of the notice. fter work on the SS is completed, check the SS warning light. If the vehicle is equipped with a mobile communication system, refer to the precaution in the IN section of the epair Manual. Steering wheel pad Front passenger airbag assembly Side airbag assembly Curtain shield airbag assembly Seat belt pretensioner Center airbag sensor assembly Front airbag sensor assembly Side airbag sensor assembly 005 HIHNDE (ED59U) 55
SS From ower Source System (See age 6) 0 IN 6 6 M E 9 irbag Squib (Front assenger irbag ssembly) - - - S6 Side irbag Sensor Front H S7 Side irbag Sensor Front H SS+ SS- VU ES SS+ SS- VU ES 0 + - 8 7 + - 5 I 7 0 6 8 SS+ SS- VU ES 6(), 7(), 8(C) irbag Sensor ssembly +S - S 5 6 +S - S 9 0 D+ D- D+ D- 6 7 + - + - 9 C 0 C 6 C C SS+ SS- 7 C VU 5 C ES 8 7 5 C 6 C (*) IK IK - IK IK - - - - - - - +S - S +S -S 8 irbag Sensor Front H 9 irbag Sensor Front H 0 irbag Squib (Steering heel ad) retensioner H retensioner H 56 005 HIHNDE (ED59U)
* : w/ ear Seat Entertainment System * : w/o ear Seat Entertainment System * : w/ Curtain Shield irbag * : w/o Curtain Shield irbag S Side irbag Sensor ear H S Side irbag Sensor ear H VS ND CS+ CS- VUC ESC CS+ CS- VUC ESC 9 uckle S H Seat osition irbag Sensor H 5 CS+ CS- VUC ESC 8 C C 9 C 0 C CS+ CS- VUC ESC 5 C 6 C IC+ 9 IC- 7 C IC- 0 IC+ 8 C SF+ SF- SF+ SF- - 8 9 6 (*) S+ S- E+ E- E 7 E 8 - - (* *) - (* *) K K (* *) - (* *) (* *) - (* *) - D S8 Side irbag Squib H S9 Side irbag Squib H C8 Curtain Shield irbag Squib H C9 Curtain Shield irbag Squib H - - 6(), 7(), 8(C) irbag Sensor ssembly 9 I 005 HIHNDE (ED59U) 57
SS E E J7 Junction Connector E E * : w/ Curtain Shield irbag * : w/o Curtain Shield irbag * 5 : w/ Navigation System * 6 : w/o Navigation System J 6 Junction Connector 5 IO IO S0(), S() Short Connector 6 5 O 8 Occupant Classification Sensor Front H SVC SI SD O0 Occupant Classification Sensor ear H SVC SI SD SI S C FS+ C FS- FS- 8 FS+ 7 I 7 + SVC SI O 6(), O 7() Occupant Classification ECU SD 5 SVC 9 SI SD DI ND S 9 ND 5 SVC SI 8 SD SVC SI 6 0 SD V - O V E SVC SI SD SVC SI SD M - O 9 Occupant Classification Sensor Front H O Occupant Classification Sensor ear H IO C C 7 uckle S (Front assenger s Side) J8 Junction Connector MX MX 6(), 7(), 8(C) irbag Sensor ssembly C 0 C (*) - ON 5 8 5 K E I J6 Junction Connector 7 SI D Data ink Connector - F 58 005 HIHNDE (ED59U)
From ower Source System (See age 6) 7. 5 ECU- 7. 5 I 5 9 D 0 K 7 F 0 5 - IC 0 S K 6 F 8 I S 5 ower indow Master S with ECU 7V MX MX 8 I I+ T5 Telltale ight ssembly 5 ateway ECU I (*5) MD MD 9(), 0() ody ECU 5 O 0 IF MX E 5 Engine Control Module S 9 I MX 7 E J 9 MX- MX MX MX+ DIM 6 8 DIM ON - S 6 S 7 5- S 0 F (*6) V(*5) F - 0(), () /C Control ssembly irbag On irbag Off - 005 HIHNDE (ED59U) 59
SS From ower Source System (See age 6) 0 HETE K S 7 C 9 irbag 7V K S C(), C() Combination Meter - I 60 005 HIHNDE (ED59U)
System Outline The SS is a driver and front passenger protection device which has a supplemental role to the seat belts. hen the ignition S is turned to ON, the current from the IN fuse flows to TEMIN () 5 of the airbag sensor assembly. If an accident occurs while driving, when the frontal impact exceeds a set level, the current from the IN fuse flows to TEMINS (), () 6, () 0, () 8, () 8 (w/ curtain shield airbag), or () (w/o curtain shield airbag) and (C) 9 (w/ curtain shield airbag), or (C) 5 (w/o curtain shield airbag) of the airbag sensor assembly to the airbag squibs and the pretensioners to TEMINS (), () 7, (), () 7, () 7 (w/ curtain shield airbag), or () (w/o curtain shield airbag) and (C) 0 (w/ curtain shield airbag), or (C) 6 (w/o curtain shield airbag) of the airbag sensor assembly to TEMIN () 7, () 8 or OD OUND to OUND, so that current flows to the airbag squibs and the pretensioners and causes them to operate. hen the side impact also exceeds a set level, the current from the IN fuse flows to TEMINS (), (C) 5, () 9 and (C) 8 of the airbag sensor assembly to the side airbag squibs and the curtain shield airbag squibs TEMINS (), (C) 6, () 0 and (C) 7 of the airbag sensor assembly to TEMIN () 7, () 8 or OD OUND to OUND, causing side airbag squibs and curtain shield airbag squibs to operate. The airbag stored inside the steering wheel pad is instantaneously expanded to soften the shock to the driver. The airbag stored inside the passenger s instrument panel is instantaneously expanded to soften the shock to the front passenger. Side airbags are instantaneously expanded to soften the shock of side to the driver and front passenger. The curtain shield airbag can ease an impact on the head of the front and rear passengers and reduce risks of injury. In a head-on crash, the driver moves forward and may strike his/her lower limbs against the instrument panel, the key cylinder, etc. The pretensioners make sure of the seat belt restrainability. : TS OCTION Code See age Code See age Code See age 8 (MZ-FE) C8 O0 7 (w/o ower Seat) 8 0 (Z-FE) C9 6 (w/ ower Seat) O 8 (MZ-FE) D 7 (w/o ower Seat) 9 0 (Z-FE) E5 5 0 5 J6 6 J6 S6 5 7 J7 S7 5 8 C J8 9 0 9 0 6 (w/ ower Seat) 7 7 (w/o ower Seat) 9 6 (w/ ower Seat) C 6 (w/ ower Seat) O6 7 (w/o ower Seat) O7 O8 O9 6 (w/ ower Seat) C O0 6 (w/ ower Seat) 7 (w/o ower Seat) S0 6 (w/ ower Seat) S 7 (w/o ower Seat) S 5 6 (w/ ower Seat) S 5 7 (w/o ower Seat) T5 6 (w/ ower Seat) S8 7 (w/o ower Seat) 6 (w/ ower Seat) S9 7 (w/o ower Seat) 005 HIHNDE (ED59U) 6
SS,,,,,, : JUNCTION OCK ND IE HNESS CONNECTO Code See age Junction lock and ire Harness (Connector ocation) D E 9 Cowl ire and Instrument anel J/ (ower Finish anel) K 8 Instrument anel ire and Instrument anel J/ (ower Finish anel) 9 Cowl ire and Instrument anel J/ (ower Finish anel) 7 Engine oom Main ire and Engine oom J/ (Engine Compartment eft) C 0 E F J K E F M Instrument anel ire and Center J/ (ehind the Instrument anel Center) Cowl ire and assenger Side J/ (ight Side of rove ox) : CONNECTO JOININ IE HNESS ND IE HNESS Code See age Joining ire Harness and ire Harness (Connector ocation) I 5 Front Door H ire and Cowl ire (eft Kick anel) IC 5 Engine oom Main ire and Cowl ire (eft Cowl Side anel) IF 5 Instrument anel ire and Cowl ire (ight Side of Instrument anel J/) IK 5 Engine oom Main ire and Cowl ire (ight Cowl Side anel) I I 5 Instrument anel ire and Cowl ire (Upper Side of assenger Side J/) IO 5 Cowl ire and Floor ire (ight Kick anel) K 56 oof No. ire and Floor ire (ight ear Quarter anel) 58 Floor ire and Front Seat H ire (Under the Front assenger s Seat) : OUND OINTS Code See age round oints ocation I 5 eft Cowl Side anel I 5 ight Instrument anel race F 56 Near the ear Side Marker ight H 6 005 HIHNDE (ED59U)
MEMO 005 HIHNDE (ED59U) 6