Created By: Publication Cell, Launch Planning Technical, A.S.Kandivali

Published : September 2003 VERSION - 1 JULY - 2004 Created By: Publication Cell, Launch Planning Technical, A.S.Kandivali

INDEX SHEET INDEX SHEET S. NO. GROUP DESCRIPTION PAGE NO. S. NO. GROUP DESCRIPTION PAGE NO. 1 INDEX INDEX 3 45 2501 INDEPENDENT FRONT SUSPENSION 2501.1 2 M25A01 ENGINE MOUNTING M25A01.1 46 2502 FRONT SPRING AND SHOCK ABSORBER 2502.1 3 1102 CLUTCH HOUSING 1102.1 47 2601 HOOD 2601.1 4 1103 CLUTCH AND BRAKE PEDAL 1103.1 48 2602A FENDER RIGHT 2602A.1 5 1104 CLUTCH CYLINDER 1104.1 49 2602B FENDER LEFT 2602B.1 6 1201 FUEL TANK GAUGES AND LINES 1201.1 50 2603 RADIATOR GUARD 2603.1 7 1203 ACCELERATOR LINKAGE 1203.1 51 2604 FOOT STEPS 2604.1 8 1301 RADIATOR AND HOSES 1301.1 52 2605 BODY MOUNTINGS 2605.1 9 1503 HEAD LIGHTS 1503.1 53 2606 ASSEMBLY INSTRUMENT PANEL 2606.1 10 1504 TURN SIGNAL, ROOF & MARKER LIGHT 1504.1 54 2607A BODY SHELL ASSEMBLY 2607A.1 11 1505 TAIL, STOP, TURN SIGNAL AND REVERSE LIGHT 1505.1 55 2607B CARGO BOX 2607B.1 12 1506 AUDIO SYSTEM 1506.1 56 2608 DOORS AND FITTINGS - FRONT 2608.1 13 1506A SWITCHES AND CONTROLS 1506A.1 57 2609 DOORS AND FITTINGS - REAR 2609.1 14 1508 HORN 1508.1 58 2610 TAIL GATE AND FITTINGS 2610.1 15 1509 WINDSHIELD WIPER MOTOR 1509.1 59 2611 BODY TRIMMING 2611.1 16 1510A WIRING HARNESS 1510A.1 60 2612 PLATES AND COVERS 2612.1 17 1601 INSTRUMENTS 1601.1 61 2613 DRIVER SEAT 2613.1 18 1602 WINDSHIELD WASHER 1602.1 62 2614 FRONT PASSENGER SEAT 2614.1 19 1700 TRANSMISSION ASSEMBLY 1700.1 63 2615 MIDDLE PASSENGER SEAT 2615.1 20 1701 RANSMISSION HOUSING AND ATTACHING 1701.1 64 2617A FRONT BUMPER 2617A.1 21 1702 SELECTION BIASING 1702.1 65 2617B REAR BUMPER 2617B.1 22 1703 SHAFT RAIL AND FORKS 1703.1 66 2618A FENDER EXTENSION AND FRONT MUD FLAP 2618A.1 23 1704 DRIVE SHAFT 1704.1 67 2618B REAR WHEEL ARCH AND MUD FLAP 2618B.1 24 1705 MAIN SHAFT DRIVE GEAR & SYNCHRONIZER 1705.1 68 2619 TOOLS 2619.1 25 1706 COUNTER LAY SHAFT GEAR & SYNCHRONIZER 1706.1 69 2620 FLOOR TRIMMING 2620.1 26 1707 TRANSMISSION SHIFT LEVER 1707.1 70 2621A SEAT BELT FRONT 2621A.1 27 1801 TRANSMISSION AND TRANSFER CASE ASSY 1801.1 71 2621C SEAT BELT REAR 2621C.1 28 1801B TRANSFER CASE ASSY (MECHANICAL SHIFT) 1801B.1 72 2701 AIR CONDITIONER (WITH HEATER) 2701.1 29 1802 TRANSFER CASE LINKAGE 1802.1 30 1901 PROPELLER SHAFT 1901.1 31 2001 FRONT AXLE 2001.1 32 2002 REAR AXLE 2002.1 33 2101 STEERING GEAR & MOUNTINGS 2101.1 34 2103 STEERING TIE ROD 2103.1 35 2104 STABILIZER BAR 2104.1 36 2201 HAND BRAKE 2201.1 37 2202A FRONT DRUM BRAKE 2202A.1 38 2202B WHEEL BRAKE REAR 2202B.1 39 2204 BRAKE MASTER CYLINDER & RESERVOIR 2204.1 40 2206 BRAKE TUBES 2206.1 41 2301A WHEEL AND ATTACHING PARTS - FRONT 2301A.1 42 2301B WHEEL AND ATTACHING PARTS - REAR 2301B.1 43 2401A FRAME 2401A.1 44 2401B SPARE WHEEL MOUNTING 2401B.1 3

GROUP M25A01 - ENGINE MOUNTING GROUP 1102 - CLUTCH HOUSING FIG. NO. DESCRIPTION FIG. NO. DESCRIPTION 1 091245 BRACKET T/F SUPPORT 1 1 068604 SCREW BELL HOUSING M12 x 1.5-64 4 2 G120394 WASHER PLAIN M3 4 2 7903055011 GROWER WASHER WL - 12 4 3 7903055007 SPRING LOCKWASHER M10 4 3 7903201047 SCREW HEX M10 x 1.5-30 3 4 7703001079 SCREW M10 x 1.5-30 2 4 7903055007 SPRING LOCKWASHER M10 3 5 0203AD0050N INSULATOR ENGINE REAR SUPPORT 1 6 5110206 NUT HEX M10 x 1.25 2 7 091246 VIBRATION DAMPNER 1 8 6508212 LOCK WASHER SPRING M8 1 9 5108206 NUT HEX M8 x 1.25 1 M25A01.1 1102.1

GROUP 1103 - CLUTCH AND BRAKE PEDAL GROUP 1103 - CLUTCH AND BRAKE PEDAL FIG. NO. DESCRIPTION 1 029872 ASSEMBLY BRKT SUPPORT PEDAL MTG 1 2 029866 ASSEMBLY CLUTCH PEDAL (HYD) 1 3 036422 BUSH 4 4 099269 PEDAL SHAFT 1 5 G131016 PLAIN WASHER (I.D. 21/32") 1 6 7032208 PIN COTTER 3.2 x 25 1 7 062452 SPRING RETRACTING 2 8 3108206 SCREW HEX HD M8 x 1.25-20 4 9 5108206 NUT HEX M8 x 1.25 7 10 3108208 SCREW HEX HD M8 x 1.25-25 5 11 081805 PEDAL PAD COVER 1 12 029860 REINF DASH PANEL OUTER 1 13 081452 STOPPER BOLT 1 14 6108212 WASHER PLAIN M8 9 15 6508212 LOCK WASHER SPRING M8 9 16 3106208 SCREW HEX M6 x 1-20 4 17 6106208 PLAIN WASHER M6 4 18 6506208 WASHER SPRING M6 4 20 069346 CLEVIS PIN 1 21 7002210 PIN COTTER 2 x 20 1 22 035963 RUBBER STOPPER 1 23 01000F0080N STAY TUBE SUSP PEDAL HORIZONTAL 1 24 01000K0310N STAY TUBE SUSP PEDAL 1 BRAKE PEDAL 029871 ASSEMBLY SUSP PEDAL COMPLETE 1 7 062452 SPRING RETRACTING 1 11 081805 PEDAL PAD COVER 1 22 035963 RUBBER STOPPER 1 25 029865 ASSEMBLY BRAKE PEDAL 1 1103.1 1103.2

GROUP 1104 - CLUTCH CYLINDER GROUP 1104 - CLUTCH CYLINDER FIG. NO. DESCRIPTION 1 069340 ASSEMBLY CLUTCH MASTER CYLINDER 1 2 3108210 SCR HEX HD M8 x 1.25-30 2 3 6108212 WASHER PLAIN M8 4 4 6508212 LOCK WASHER SPRING M8 6 5 5108206 NUT HEX M8 x 1.25 2 11 099685 CLUTCH TUBE LOWER 1 12 060353 FRT BRAKE HOSE 1 13 033839 SPECIAL WASHER 4 14 011644 LOCKWASHER BRAKE HOSE SECURING 2 15 011645 NUT LOCK HOSE SECURING 2 16 069968 BRKT SUPPT CYL TUBE MTG LOWER 1 17 0802CA0691N CLUTCH TUBE LOWER 1 18 069345 ASSEMBLY SLAVE CYLINDER 1 19 08020A0190N BRACKET CLUTCH SLAVE CYL MTG 1 20 069073 ALLEN SCREW M8 x 1.25-20 mm 2 21 7910033393 CLUTCH RELEASE FORK 1 22 7910030761 PROP. SPRING CLUTCH RELEASE 1 23 7703011004 SCR HEX HD M4 x 0.7 1 24 069028 NUT NYLON M4 x 0.7 1 25 7910009516 SEALING BOOT 1 26 027924 GROMMET CLUTCH RELEASE FORK 1 27 027925 RETAINER PLATE GROMMET 1 28 024615 FLANGE BOLT M6 x 1-12 4 0802CA0371N KIT CLUTCH MASTER CYLINDER MAJOR 1 0802CA0381N KIT CLUTCH MASTER CYLINDER MINOR 1 0802CA0391N KIT CLUTCH SLAVE CYLINDER 1 1104.1 1104.2

GROUP 1201 - FUEL TANK GAUGES AND LINES GROUP 1201 - FUEL TANK GAUGES AND LINES FIG. NO. DESCRIPTION 1 1001AA0400N FUEL TANK ASSEMBLY 1 2 098032 ASSEMBLY FUEL TANK MTG BRACKET 2 3 2108244 BOLT HEX HD M8 x 1.25-65 6 4 6108212 WASHER PLAIN M8 20 5 5108206 NUT HEX M8 x 1.25 8 6 2108230 BOLT HEX HD M8 x 1.25-30 2 7 6508212 LOCK WASHER SPRING M8 10 8 070653 REST BUTTON - BATTERY TRAY BOTTOM 4 9 087698 FERRULE FUEL LINE 7 10 10000A0450N STRAP ASSEMBLY FUEL TANK 2 11 067147 COPPER WASHER 16 MM 2 12 098010 SKID PLATE FUEL TANK 1 13 3108220 SCREW HEX HD M8 x 1.25-12 4 14 10000A0200N TANK UNIT 1 15 011594 GASKET FUEL TANK 1 16 6204204 LOCK WASHER EXT TOOTH M4 6 17 3304206 SCREW PAN HD M4 x 0.7-12 6 18 098035 HOSE FUEL TANK TO FILLER NECK 1 19 062140 CLIP WORM TYPE NO - 2 (42-55) 2 20 1001DA0430N HOSE VENTILATOR FUEL TANK 1 21 1001DA0200N FUEL FILLER NECK ASSEMBLY 1 22 098869 HOSE BREATHER FUEL TANK 1 23 3106206 SCREW HEX HD M6 x 1-16 3 24 098726 BREATHER FUEL TANK HOSE 1 25 067893 GROMMET FILLER NECK 1 27 1001CA2240N FUEL LINE TANK TO FILTER 1 28 050331 BANJO BOLT 3 29 050332 COPPER WASHER 14 MM 8 30 10010A0540N FUEL RTN LN INJ PUMP TO FUEL TANK 1 31 068223 FUEL LINE FILTER TO INJECTION PUMP 1 32 067148 BANJO BOLT 16 MM 1 33 097888 CLIP FUEL LINE 7 1201.1 1201.2

GROUP 1203 - ACCELERATOR LINKAGE GROUP 1203 - ACCELERATOR LINKAGE FIG. NO. DESCRIPTION 1 1002AA0130N ACCELERATOR PEDAL ASSEMBLY 1 2 650484 ACCELERATOR TREADLE HINGE PIN 1 3 039600 SPRING RETURN ACC PEDAL 1 4 6105206 WASHER PLAIN M5 1 5 7002210 PIN COTTER 2 x 20 2 6 036623 PIN CLEVIS 2 7 070562 ACCELERATOR PEDAL PAD 1 8 6106208 WASHER PLAIN M8 1 9 1002AA1780N CABLE ASSY ACCELERATOR COMP 1 10 5108206 NUT HEX M8 x 1.25 2 11 A11775 PLAIN WASHER 5/16" 2 12 052619 WIRE STOP 1 13 052621 SCREW WIRE STOP 1 1203.1 1203.2

GROUP 1301 - RADIATOR AND HOSES GROUP 1301 - RADIATOR AND HOSES FIG. NO. DESCRIPTION 1 0304AG0131N RADIATOR ASSEMBLY 1 2 0304BG0010N INSULATOR RADIATOR MOUTING BOTTOM 2 3 028761 SPACER RAD RETAINER CUP ASSY 2 4 028552 WASHER PLAIN 2 5 7903234004 NUT NYLOC M10 x 1.5 2 6 028550 COLLAR INSULATOR 1 7 2108232 BOLT HEX HD M8 x1.25-35 1 8 6508212 LOCK WASHER SPRING M8 1 9 5108206 NUT HEX M8 x 1.25 1 10 028551 CUSHION RADIATOR SUPPORT 2 1301.1 1301.2

GROUP 1503 - HEAD LIGHTS FIG. NO. DESCRIPTION 1 1701AA0180N HEAD LAMP ASSEMBLY (AUTOPAL) 2 2 G138479 LOCKWASHER EXTN #10 8 3 G159920 SCREW PAN HD M/C #10-24 x 1/2" 8 17010A0010N KIT SPARE BULBS HALO HEAD LAMP 1 1503.1

GROUP 1504 - TURN SIGNAL, ROOF & MARKER LIGHT GROUP 1504 - TURN SIGNAL, ROOF & MARKER LIGHT FIG. NO. DESCRIPTION FRONT TURN SIGNAL LAMP 1 028533 FRONT TURN SIGNAL LAMP LH 1 1 028534 FRONT TURN SIGNAL LAMP RH 1 SIDE MARKER LAMP 2 028354 ASSEMBLY MARKER LAMP LH 1 2 028355 ASSEMBLY MARKER LAMP RH 1 3 059330 SCREW SPECIAL M4 x 0.7 4 4 6505206 SPRING LOCK WASHER M5 4 5 5104206 NUT HEX M4 x 0.7 4 REAR REGISTRATION PLATE 6 0001BF0010B PLATE ASSEMBLY REGISTRATION 1 7 3108204 SCREW HEX HD M8 x 1.25-16 2 8 6508212 LOCK WASHER SPRING M8 2 9 6108212 WASHER PLAIN M8 2 NUMBER PLATE LIGHT 10 069262 ASSEMBLY NUMBER PLATE LAMP 1 11 6106208 PLAIN WASHER M6 2 12 6506208 WASHER SPRING M6 2 13 5106206 NUT HEX M6 x 1 2 ROOF LIGHT 14 097614 ASSEMBLY ROOF LAMP 1 15 3306212 SCREW PAN HD SLOTTED M6 x 1-25 2 WARNING TRIANGLE ASSY 16 19000A3391N WARNING TRIANGLE ASSEMBLY NS 1504.1 1504.2

GROUP 1505 - TAIL, STOP, TURN SIGNAL AND REVERSE LIGHT GROUP 1506 - AUDIO SYSTEM FIG. NO. DESCRIPTION FIG. NO. DESCRIPTION 1 17030A0030N REAR COMBINATION LAMP RH (PRODN) 1 1 1501BA0030N KIT RADIO / TAPE 1 1 17030A0040N REAR COMBINATION LAMP LH (PRODN) 1 2 1502AA0091N INTERNAL ANTENNA 1 3 15030A0020N ASSEMBLY SPEAKER 4" 2 1505.1 1506.1

GROUP 1506A - SWITCHES AND CONTROLS FIG. NO. DESCRIPTION 1 098466 SWITCH POWER WINDOW FRONT 2 0111HN0101N POWER WINDOW REGULATOR FRT-LH 1 0111HN0111N POWER WINDOW REGULATOR FRT-RH 1 2 098510 SWITCH POWER WINDOW REAR 4 0111HN0121N POWER WINDOW REGULATOR RR-LH 1 0111HN0131N POWER WINDOW REGULATOR RR-RH 1 1506A.1

GROUP 1507 - BATTERY HOLD DOWN & CABLE GROUP 1507 - BATTERY HOLD DOWN & CABLE FIG. NO. DESCRIPTION 1 1401BA0250N TRAY BATTERY 1 2 G120741 BOLT HEX HD 5/16" - 24 4 3 6508212 LOCK WASHER SPRING M8 6 4 6108212 WASHER PLAIN M8 6 5 070651 SUPPORT BATTERY TRAY BOTTOM 1 6 3108224 SCREW HEX HD M8 x 1.25-20 6 7 070653 REST BUTTON-BATTERY TRAY BOTTOM 2 8 083812 REST PAD REAR - BATTERY 2 9 070654 CLAMP BRACKET BATTERY HOLD DOWN 1 10 G120214 WASHER SPRING LOCK M5 3 11 070749 WING NUT 5/16" - 18 2 12 071779 BATTERY POSITIVE CABLE 1 13 071777 CAP POSITIVE CABLE 1 14 027607 BATTERY CABLE ASSEMBLY NEGATIVE 1 16 029556 REST BUTTON BATTERY TRAY BOTTOM 6 17 1801EA0100N EARTH CABLE 1 1507.1 1507.2

GROUP 1508 - HORN FIG. NO. DESCRIPTION 1 028194 CLEAR TONE HORN HIGH (PROD) 1 1 028195 CLEAR TONE HORN LOW (PROD) 1 2 6508212 LOCK WASHER SPRING M8 2 3 6108212 WASHER PLAIN M8 2 4 3108206 SCREW HEX HD M8 x 1.25-20 2 1508.1

GROUP 1509 - WINDSHIELD WIPER MOTOR FIG. NO. DESCRIPTION 1 029874 WIPER MOTOR ASSEMBLY (LINK TYPE) 1 2 0101CK0080N BRACKET ASSEMBLY WIPER MOTOR 1 3 3105208 SCREW HEX HD M5 x 0.8-14 3 4 6505206 SPRING LOCK WASHER M5 3 5 6106208 PLAIN WASHER M6 2 6 6506208 WASHER SPRING M6 2 7 3106228 SCREW HEX HD M6 x 1-20 2 8 0116BK0030N KIT LINKAGE WIPER MOTOR ASSEMBLY 1 9 0116AK0010N WIPER ARM ASSEMBLY 2 10 028418 WIPER BLADE ASSEMBLY 2 GROUP 1509 - WINDSHIELD WIPER MOTOR 1509.1 1509.2

GROUP 1510A - WIRING HARNESS GROUP 1510A - WIRING HARNESS FIG. NO. DESCRIPTION FIG. NO. DESCRIPTION 1 0114CN0050N BRKT ASSEMBLY LEVER BONNET 1 6 1306BA0021N HORN RELAY 1 2 3306208 SCREW SLOTTED PAN HEAD M6 x 1-16 4 13 028750 WIPE & WASH WIPER INTO RELAY 1 3 6106208 PLAIN WASHER M6 4 2 3306208 SCREW SLOTTED PAN HD M6 x 1.0-16 4 4 6506208 SPRING LOCKWASHER M6 4 3 6106208 PLAIN WASHER M6 4 9 3305208 SCR SLOTTED PAN HD M5 x 0.8-16 2 4 6506208 SPRING LOCKWASHER M6 4 10 6105206 PLAIN WASHER M5 2 32 028741 BRACKET BONNET LEVER 1 11 6505206 SPRING LOCK WASHER M5 * 2 (* FUSE BOX ATTACH) 12 088587 RELAY HEAD LAMP 1 12 18000A0300N RELAY HEAD LAMP (OPT) 1 14 088454 IC BASED FLASHER (ATD TO FUSE BOX) 1 14 13050A0011N IC BASED FLASHER (OPT) 14 13050A0012N IC BASED FLASHER (OPT) 46 18000A0150N AC RELAY OEN 2 46 1801DA0090N AC RELAY (OPT) 2 1510A.1 1510A.2

GROUP 1510A - WIRING HARNESS GROUP 1510A - WIRING HARNESS FIG. NO. DESCRIPTION FIG. NO. DESCRIPTION 19 098575 MOUNTING BRACKET POWER WINDOW 28 064549 TIMER GLOW PLUG 7 SECOND 1 RELAY AND FUSE 1 28 19000A0190N TIMER GLOW PLUG TIMER - MICO (OPT) 1 20 3106206 SCREW HEX HEAD M6 x 1.0-16 1 28 19000A0191N TIMER GLOW PLUG TIMER - BERU (OPT) 1 21 098467 POWER WINDOW RELAY ASSY. 8 30 18040A0061N STARTER RELAY ANU AUTO 1 21 027997 INTERFACE POWER RELAY (OPT) 8 2 3306208 SCREW SLOTTED PAN HD M6 x 1.0-16 1 2 3306208 SCREW SLOTTED PAN HD M6 x 1.0-16 2 3 6106208 PLAIN WASHER M6 1 3 6106208 PLAIN WASHER M6 4 4 6506208 SPRING LOCKWASHER M6 1 4 6506208 SPRING LOCK WASHER M6 4 61 098980 MOUNTING BRACKET GLOW TIMER 1 22 5106206 NUT HEX M6 x 1.0 2 62 028743 BRACKET MAXI FUSE 1 27 098576 COVER ASSEMBLY P/W RELAY & FUSE 1 1510A.3 1510A.4

GROUP 1510A - WIRING HARNESS GROUP 1510A - WIRING HARNESS FIG. NO. DESCRIPTION 35 1705CA0031N SWITCH DOOR LIGHT 2 38 097552 MECH STOP LIGHT SWITCH 1 41 038525 CLIP CHASSIS WIRING HARNESS 5 43 11050A0111N COMBINATION SWITCH 1 45 19000A3891N COVER UPPER HALF - COMB SWITCH 1 45 19000A3901N COVER LOWER HALF - COMB SWITCH 1 53 088409 SPACER SPRING LOCK 4 069923 CABLE REV SWITCH TO CHAS WIRING 1 028699 P/W FUSE BOX & RELAY HARNESS 1 028701 FRT DOOR WIRING - LH 1 028702 RR DOOR WIRING RH/LH 2 028704 ROOF LAMP WIRING 1 067497 PIGTAIL TANK UNIT 1 18000A0130N DOOR WIRING - FRT RIGHT REMOTE 1 1801AA0440N WIRING HARNESS ENGINE 1 1801CA1310N WIRING HARNESS BODY 1 1801CA1320N WIRING HARNESS - CHASSIS 1 0114CN0050N BRKT ASSY LEVER BONNET 1 13000A0070N SEAT BELT WARNING MODULE 1 13020A0030N SPEED SENSOR 4WD 1 1801CA0040N WIRING STEREO AFL 1 18000A0120N INSTRUMENT WIRING 1 1510A.5 1510A.6

GROUP 1601 - INSTRUMENTS GROUP 1602 - WINDSHIELD WASHER FIG. NO. DESCRIPTION FIG. NO. DESCRIPTION 1 1301AA0281N INSTRUMENT CLUSTER 1 074612 FERRULE WINDSHIELD WASHER TUBE 1 1 19000A3661N KIT WINDSHIELD WASHER 1 1 19000A3662N KIT WINDSHIELD WASHER (OPT) 1 2 3306206 SCREW SLOTTED PAN HD M6 x 1-14 2 3 6306208 WASHER INTERNAL TOOTH M6 2 4 6106208 PLAIN WASHER M6 2 1601.1 1602.1

GROUP 1700 - TRANSMISSION ASSEMBLY FIG. NO. DESCRIPTION 07000D0830N TM ASSY (BA10 V0 DC EM BW M0.294) 1 07030D0120N TM ASSEMBLY 4WD BOLERO DC LHD EM 1 093685 ASSY T/F CASE B/W MECHANICAL SHIFT 1 1700.1

GROUP 1701 - TRANSMISSION HOUSING AND ATTACHING GROUP 1701 - TRANSMISSION HOUSING AND ATTACHING FIG. NO. DESCRIPTION 1 9603392680 TRANSMISSION HOUSING FRONT ASSY 1 2 7903067078 PIN ELASTIC 8-18 5 3 7903001457 SCREW M7 x 1 6 4 7903057053 WASHER ELASTIC 6 5 7903001422 BOLT M8 x 1.25-85 6 6 7903057003 ELASTIC WASHER M7 6 7 7903067033 ELASTIC PIN 12-15 2 8 7903067034 ELASTIC PIN 14-15 2 9 0703HD0010N PLUG M18 x 1.5 1 10 018898 GASKET (CO WASHER) 1 11 9603707280 SWITCH - REVERSE CONTACT 1 12 7903062030 SEAL N/S 1 13 9159509080 STUD M8 x 1.25 3 14 7903201048 SCREW M10 x 1.5-35 2 15 07000D0510N ASSY INT & RR HOUSING BA10 DS (4WD) 1 16 7903057100 WASHER ELASTIC M10 7 17 7910030169 BREATHER 1 18 7903057005 ELASTIC WASHER M8 14 19 07000D0361N LIP SEAL 40D 58E 10 1 20 7903201214 SCREW M8 x 1.25 4 21 092656 PIVOT - GEAR SHIFT LEVER 1 22 092658 PIN PIVOT 1 23 7903032071 NUT 1 24 023950 PLUG DRAIN - OIL SUMP 1 25 7903062003 SEAL 16 1 092692 HSG TRANSMISSION INTERNAL (2WD) 1 1701.1 1701.2

GROUP 1702 - SELECTION BIASING GROUP 1703 - SHAFT RAIL AND FORKS FIG. NO. DESCRIPTION FIG. NO. DESCRIPTION 1 092665 SHIM SET 1 1 0703CD0010N RAIL ASSY 1-2 1 2 092654 SLEEVE SELECTION 1 2 0703CD0020N RAIL ASSY 3-4 1 3 092653 PLUNGER SELECTION 2 3 0703CD0040N SHIFT FORK REVERSE 1 4 07060D0311N SPRING SELECT 1/2 1 4 7903067005 ELASTIC PIN 6-27 4 5 092659 PLATE RETAINER 2 5 052359 BALL 8 N/S 4 6 092655 SLEEVE SELECTION 5TH / REV 1 6 7903090037 PIN 4-12 1 7 07060D0321N SPRING SELECTION 5TH / REV 1 7 7836174000 FINGER INTERLOCK 1 8 092685 STUD 4 8 7836279000 SPRING LOCKING 3 9 5306202 NYLOC NUT M6 x 1 4 9 7903075044 PLUG M12 x 1.25 2 10 092663 SPACER -1/2" SLEEVE 1 1702.1 1703.1

GROUP 1704 - DRIVE SHAFT FIG. NO. DESCRIPTION 1 07000D0470N INPUT GEAR ASSEMBLY 1 2 068624 DEFLECTOR OIL 1 3 9603417880 TAPER ROLLER BEARING 1 4 9152211280 THICKNESS WASHER (STOCK NO) 1 1704.1

GROUP 1705 - MAIN SHAFT DRIVE GEAR & SYNCHRONIZER GROUP 1705 - MAIN SHAFT DRIVE GEAR & SYNCHRONIZER FIG. NO. DESCRIPTION 1 091270 OUTPUT SHAFT (SAE 8620) 1 2 9152194880 DRIVEN GEAR ASSEMBLY 1ST SPEED 1 3 9152125280 ASSEMBLY 2ND DRIVEN GEAR 1 4 9152195080 DRIVEN GEAR ASSEMBLY 3RD SPEED 1 5 9153656880 5TH DRIVEN GEAR 1 6 9603489380 GEAR DRIVEN - REVERSE 1 7 9151969680 SYNCHRONISER ASSEMBLY 1ST & 2ND 1 8 7910030856 SYNCHRONISER ASSEMBLY 3RD & 4TH 1 9 7910004479 SPACER FIRST GEAR 1 10 9159508380 NUT M31 x 1.25 1 11 9153845480 SHIM ADJUSTING 1.6 MM THICK 1 12 7910004494 SHIM 3.05 THK. 1 13 7903058015 SPRING WASHER 35.3 1 14 7903066036 CIRCLIP 32-7 1 15 7903066110 SNAP RING 25-7 1 16 7903066109 CIRCLIP PE 29 1 17 090283 SHIM O/P SHAFT 1 18 9600067680 TAPER ROLLER BEARING - SNR 32004 1 19 9603417880 TAPER ROLLER BEARING - INPUT SHAFT 1 20 7903066016 CIRCLIP 81-2 1 21 9159501780 CYLINDRICAL ROLLER BEARING 1 22 7903066114 CIRCLIP 68 - O/P SHAFT REAR HOUSING 1 23 9151061380 NEEDLE CAGE 40.2 x 44.2 x 30 2 24 9151139780 NEEDLE CAGE 40.2 x 44.2 x 29 1 1705.1 1705.2

GROUP 1706 - COUNTER LAY SHAFT GEAR & SYNCHRONIZER GROUP 1706 - COUNTER LAY SHAFT GEAR & SYNCHRONIZER FIG. NO. DESCRIPTION 1 9607867180 SUB - SHAFT 5TH GEAR 1 2 068602 ASSEMBLY 5TH DRIVING GEAR (4WD) 1 3 9153691280 SYNCHRONISER ASSEMBLY 5TH & REV 1 4 9159514180 CYLINDRICAL ROLLER BEARING 1 5 7910028075 SHIM 5TH DRIVE GEAR 1 6 7910029041 ADJ. SHIM - SUB SHAFT BEARING 1 7 9152194780 COUNTER SHAFT (BA10 V0) 1 8 9603417980 TAPER ROLLER BEARING 1 9 9603418080 CIRCLIP 1 10 9159512180 TAPER ROLLER BEARING 1 11 7910012677 ADJ. SHIM C'SHAF BEARING (STOCK NO) 1 12 9603489480 GEAR SLIDING - REVERSE 1 13 9153970780 PIN SLIDING GEAR 1 14 7903067031 PIN ELASTIC 6-33 1 15 9151433080 NEEDLE BEARING CAGE 25 x 30 x 60 1 5TH DRIVING GEAR 1706.1 1706.2

GROUP 1707 - TRANSMISSION SHIFT LEVER GROUP 1707 - TRANSMISSION SHIFT LEVER FIG. NO. DESCRIPTION 07060D0350N SHIFT LEVER ASSEMBLY 1 1 07060D0021N GEAR SHIFT LEVER BOTTOM 1 2 092660 NYLON BUSH 1 3 082788 LEVER SPRING 1 4 092661 PLATE COVER 1 5 7903057005 ELASTIC WASHER M8 3 6 2108258 SCREW M8 x 1.25-30 3 7 092664 GROMMET LEVER 1 8 07060D0340N GEAR SHIFT LEVER TOP ASSEMBLY 1 9 071544 RUBBER BUSH 2 10 07060D0111N FOAM BUSH 1 11 07060D0131D BUSH PIVOT 2 12 07060D0121N PIVOT PIN TOP LEVER 1 13 5108206 NUT HEX M8 x 1.25 1 14 0706AA0160N KNOB GEAR SHIFT 1 15 6106208 WASHER M6 1 16 5306202 NYLOC NUT M6 x 1.0 1 1707B.1 1707B.2

GROUP 1801 - TRANSMISSION AND TRANSFER CASE ASSY GROUP 1801 - TRANSMISSION AND TRANSFER CASE ASSY FIG. NO. DESCRIPTION 1 093685 TF CASE B/W MECHANICAL SHIFT 1 2 090439 ADAPTOR BA10 TO BORG WARNER 1 3 090849 SOCKET HEAD CAP SCREW 5 4 7903057100 ELASTIC WASHER M10 5 6 090440 STUD T/M TO ADAPTOR 6 7 090441 STUD T/M TO ADAPTOR 2 8 6108212 PLAIN WASHER M8 8 9 6508212 SPRING LOCK WASHER M8 8 10 7903232005 NUT HEX M8 x 1.25 8 11 090846 'O' RING 1 12 7903367033 ELASTIC PIN DIA 12 x 15 2 13 07030D0140N TM ASSEMBLY BA10 V1 4WD 1 14 098693 PARKING BRAKE MOUNTING BRACKET 1 15 5308204 NYLOC NUT M8 x 1.25 2 16 029464 T/F BREATHER WITH L BRACKET 1 17 076852 TUBE BREATHER 1 18 075764 CLAMP BREATHER TUBE 2 1801.1 1801.2

GROUP 1801B - TRANSFER CASE ASSY (MECHANICAL SHIFT) GROUP 1801B - TRANSFER CASE ASSY (MECHANICAL SHIFT) FIG. NO. DESCRIPTION 093685 TF CASE B/W MECHANICAL SHIFT 1 1 089862 NUT 2 2 089864 WASHER 2 3 089863 SEAL OIL 2 4 0707DA0171N FLANGE CIRCULAR 1 5 07070A0501N PLUG PIPE 2 6 0707DA0241N ASM SPEEDO GEAR & SHAFT (17T) 1 9 089871 'O 'RING 1 10 089872 SEAL SPEEDO 1 11 089873 BODY SPEEDO 1 12 07070A0401N BOLT 1 14 07070A0351N BOLT 15 17 0707BA0021N ASM COVER 1 22 07070A0331N SNAP RING 2 23 0707DA0011N BEARING 2 24 0707DA0031N BEARING NEEDLE 1 25 0707BA0011N COVER 1 26 07070A0171N MAGNET 1 27 0707DA0231N GEAR SPEEDO (5T) 1 28 089861 SEAL OIL 3 29 07070A0361N SPRING 1 32 0707CA0251N HUB SHIFT COLLAR 1 33 0707CA0051N ASM LOCKUP 1 34 07070A0221N SNAP RING 1 35 0707CA0031N HUB LOCKUP 1 36 07070A0281N SPRING 1 37 07070A0271N COLLAR, LOCKUP 1 38 0707CA0101N SHAFT RAIL 1 39 0707CA0131N ASM LOCKUP SHIFT FORK 1 40 07070A0191N SNAP RING 1 41 07070A0311N SPACER 1 42 0707DA0091N SPROCKET DRIVE (24T) 1 43 0707DA0101N SPROCKET DRIVEN (24T) 1 44 0707DA0071N CHAIN 1 45 0707DA0151N ASM SHAFT AND PUMP 1 48 0707CA0021N FACING LOCKUP FORK 2 49 07070A0251N CLAMP 1 50 07070A0261N HOSE COUPLING 1 51 07070A0411N ASM GEROTOR PUMP 1 55 0707DA0161N ASM OUTPUT SHAFT 1 56 07070A0371N FILTER 1 57 0707CA0061N HUB REDUCTION 1 CONTINUE... 1801B.1 1801B.2

GROUP 1801B - TRANSFER CASE ASSY (MECHANICAL SHIFT) GROUP 1801B - TRANSFER CASE ASSY (MECHANICAL SHIFT) FIG. NO. DESCRIPTION 58 0707CA0081N FACING REDUCTION FORK 2 59 0707CA0121N ASM REDUCTION SHIFT FORK 1 68 0707DA0221N ASM YOKE 1 69 07070A0491N DEFLECTOR DUST 1 71 0707DA0131N OUTPUT SHAFT LOWER 1 72 07070A0391N BREATHER NIPPLE 1 74 0707CA0261N ASM ADAPTER 1 75 07070A0201N SNAP RING 1 77 07070A0181N SPIRAL PIN 1 79 07070A0211N SNAP RING 1 80 0707DA0021N BEARING 1 81 0707DA0191N ASM INPUT SHAFT 1 82 0707DA0051N BUSHING 1 83 0707DA0111N BEARING NEEDLE 1 85 0707DA0081N THRUST WASHER 1 87 07070A0231N SNAP RING 1 88 0707DA0061N THRUST PLATE 1 89 0707DA0121N SUN GEAR 1 90 0707DA0141N ASM CARRIER (COMPLETE) 1 91 07070A0301N SCREW 2 92 07070A0241N CLIP RING 1 93 0707CA0071N SHIFT SHAFT 1 94 0707BA0061N 'O' RING 1 95 0707CA0111N SPRING 4L ASSIST 1 96 0707DA0041N ROLLER 4L ASSIST 1 97 0707CA0091N CAM 1 98 0707CA0041N PLUNGER DETENT 1 99 07070A0291N SPRING 1 102 0707CA0271N ASM LEVER AND PIN 1 103 089876 NUT SHIFT SHAFT 1 104 07070A0381N SWITCH 4WD INDICATOR 1 105 0707CA0281N ASM CASE 1 109 07070A0321N PIN DOWEL 2 1801B.3 1801B.4

GROUP 1802 - TRANSFER CASE LINKAGE GROUP 1802 - TRANSFER CASE LINKAGE FIG. NO. DESCRIPTION 1 098694 SHIFT LINK ASSEMBLY 1 2 069029 NUT NYLOC M8 x 1 2 3 098666 T/F SHIFT MAIN LEVER 1 4 099750 SHIFT LEVER ASSEMBLY 1 5 098680 TORSION SPRING 1 6 098685 PIVOT PIN LEVER 1 7 098684 PIVOT PIN BRACKET 1 8 098695 ASSEMBLY SHIFT LEVER PIVOT BRKT 1 9 098690 T/F LEVER KNOB ASSEMBLY 1 10 7032204 COTTER PIN 3.2 x 20 MM 2 11 7910005487 BEARING HOUSING 4 12 069095 GROMMET T/F CASE LEVER 1 13 069094 RETAINER GROMMET T/F CASE LEVER 1 1802.1 1802.2

GROUP 1901 - PROPELLER SHAFT GROUP 1901 - PROPELLER SHAFT FIG. NO. DESCRIPTION 1 098660 PROPELLER SHAFT ASSEMBLY FRONT 1 2 00A490 U - BOLT PROPELLER SHAFT 4 3 G120214 WASHER SPRING LOCK M5 8 4 G120368 NUT HEX 5/16" - 24 8 5 029908 PROP SHAFT ASSEMBLY REAR BA10 1 6 51100A0050N BOLT HEX 4 7 G103321 LOCK WASHER SPRING 3/8" 4 8 G451401 NUT HEX 3/8" - 24 4 038166 KIT UNIVERSAL JOINT 1 CONSIST OF: 038148 1 - JOURNAL ASSEMBLY NS 038167 4 - BEARING ASSEMBLY NS 038168 4 - SNAP RING NS G271287 2 - GREASE NIPPLE NS 1901.1 1901.2

GROUP 2001 - FRONT AXLE GROUP 2001 - FRONT AXLE FIG. NO. DESCRIPTION 0503AA0780N FRONT AXLE ASSEMBLY COMPLETE 1 (WITH DISC BRAKE) 1 027518 FRT AXLE TUBE ASSY LH 1 1 027519 FRT AXLE TUBE ASSY RH 1 2 0502AA1820N COVER, DIFFERENTIAL 1 3 52080A0111N FLANGE SCREW M8 x 1.25-17 2 4 52080A0101N FLANGE SCREW M8 x 1.25-14 8 5 076219 PLUG, FILLER AXLE HOUSING 1 6 076924 PLUG, DRAIN, AXLE HOUSING 1 7 802562 CASE, DIFFERENTIAL 1 019408 KIT CONE, ROLLER & CUP, DIFF BRG 2 CONSISTS OF: 8 052979 1 - CONE & ROLLER, DIFFRAL. BRG NS 9 052980 1 - CUP, DIFFERENTIAL BRG NS 10 648061 SHIM SET, ADJUSTING, DIFFERENTIAL 1 CONSISTS OF: 639959 2 - SHIM 0.003" THICK NS 639960 2 - SHIM 0.005" THICK NS 639961 3 - SHIM 0.010" THICK NS 639962 3 - SHIM 0.030" THICK NS 012141 KIT, DIFF GEAR AND PINION MATE 1 CONSISTS OF: 11 649355 2 - GEAR, SIDE NS 647062 2 - PINION MATE NS 12 636553 1 - SHAFT, PINION MATE NS 13 636360 1 - PIN, LOCK, PINION MATE SHAFT NS 14 090559 WASHER, THRUST 15 645789 WASHER, THRUST 037709 WASHER, THRUST 012109 WASHER, THRUST * 036394 WASHER, THRUST ( * AS REQUIRED) 059725 KIT AXLE DRIVE GEAR & PIN (4.88R) 1 CONSISTS OF: 16 039640 1 - GEAR SET (DRIVE GEAR & PIN) NS 17 802561 5 - STRAP, LOCK NS 18 0502EA0610N 10 - SCREW, DRIVE GEAR 19 020178 1 - NUT, DRIVE PINION (OPT: 801367) 20 G179890 BOLT, HEX HEAD 1/2" x 13-2 x 1/4" 4 019405 KIT CONE, ROLLER & CUP, PIN 1 BEARING INNER CONSISTS OF: 21 807266 1 - CONE, ROLLER & PIN BRG INNER NS 22 052877 1 - CUP, PINION BEARING INNER NS CONTINUE 2001.1 2001.2

GROUP 2001 - FRONT AXLE GROUP 2001 - FRONT AXLE FIG. NO. DESCRIPTION 019402 KIT CONE, ROLLER AND CUP 1 PINION BEARING OUTER CONSISTS OF: 23 052878 1 - CONE, ROLLER & PIN BRG OUTER NS 24 052879 1 - CUP, PINION BEARING NS 25 649228 SHIM SET ADJ PIN BRG INNER & OUTER 1 CONSISTS OF: 639969 4 - SHIM 0.003" THICK NS 639970 2 - SHIM 0.005" THICK NS 639971 3 - SHIM 0.010" THICK NS 639972 2 - SHIM 0.003" THICK NS 639973 2 - SHIM 0.005" THICK NS 639974 2 - SHIM 0.010" THICK NS 639975 1 - SHIM 0.030" THICK NS 26 075871 SLINGER, OIL DRIVE PINION 1 27 0502CA0211N SEAL PINION FRONT AXLE 1 28 0503CA0110N DUST SHIELD DISC BRAKE-LH 1 28 0503CA0120N DUST SHIELD DISC BRAKE -RH 1 29 636568 SEAL, DUST UNIVERSAL JOINT YOKE 1 30 00A1445 YOKE END, UNIVERSAL JOINT ASSY 1 31 00A1028 COMPANION FLANGE NUT WASHER 1 32 027527 FRONT AXLE SHAFT & UNV JOINT LH 1 33 027528 FRONT AXLE SHAFT & UNV JOINT RH 1 34 027532 DUST SHIELD - FRONT AXLE 4WD 2 35 098314 GUIDE, AXLE SHAFT 2 36 098313 OIL SEAL, AXLE SH, GEAR CARR END 2 37 027512 SPLIT RING SEAT - UPPER BALL JOINT 2 027534 STR. KNUCKLE & BALL JOINT ASSY - LH 1 38 027505 STEERING KNUCKLE - LH 1 40 027511 LOWER BALL JOINT 1 41 027515 CIRCLIP - LOWER BALL JOINT 1 42 027510 UPPER BALL JOINT 1 027535 STR. KNUCKLE & BALL JOINT ASSY - RH 1 39 027506 STEERING KNUCKLE - RH 1 40 027511 LOWER BALL JOINT 1 41 027515 CIRCLIP - LOWER BALL JOINT 1 42 027510 UPPER BALL JOINT 1 43 027514 NUT - LOWER BALL JOINT 2 44 027513 NUT - UPPER BALL JOINT 2 45 7032218 COTTER PIN 2 46 000A760 BOLT, HEX HD 3/8" - 16-3/2" 12 CONTINUE 2001.3 2001.4

GROUP 2001 - FRONT AXLE FIG. NO. DESCRIPTION 47 6510114 LOCKWASHER, SPRING M10 12 48 027523 SPINDLE ASSEMBLY - WHEEL BEARING 2 49 027524 SPINDLE WHEEL BEARING 2 50 027525 BUSH FRONT AXLE SHAFT 2 51 027526 OIL SEAL - FRONT AXLE SHAFT 2 52 5110208 NUT HEX M10 x 1.5 2 53 075763 BOLT, STOP, STEERING 2 54 052932 NIPPLE AIR BREATHER 1 55 012462 GASKET GEAR CARRIER COVER ASSY 1 059712 DIFFERENTIAL ASSEMBLY (4.88 RATIO) 1 052930 TUBULAR BREATHER FRONT 1 052934 BREATHER TUBE 1 GROUP 2001 - FRONT AXLE 2001.5 2001.6

GROUP 2002 - REAR AXLE GROUP 2002 - REAR AXLE FIG. NO. DESCRIPTION 0502AA0940N REAR AXLE ASSEMBLY 4.88R 1 1 0503BA0090N GC TUBE ASSEMBLY FRONT 4.88R 1 2 0502DA0340N GEAR CARRIER COVER ASSEMBLY 1 3 52080A0111N FLANGE SCREW M8 x 1.25-17 2 4 52080A0101N FLANGE SCREW M8 x 1.25-14 8 5 0502DA0360N FILLER PLUG 1 6 0502DA0370N DRAIN PLUG 1 0502EA0140N DIFF. ASSY 4.88R 1 7 090634 DIFFERENTIAL CASE LH 1 7 090635 DIFFERENTIAL CASE RH 1 091408 KIT, CONE, ROLLER & CUP, DIFF. BRG 2 CONSISTS OF: 8 052979 1 - DIFFERENTIAL BRG CONE & ROLLER NS 9 052980 1 - DIFFERENTIAL BEARING CUP NS 10 648061 SHIM SET ADJUSTING DIFFERENTIAL 1 CONSISTS OF: 0639959 4 - DIFF ADJUSTING SHIM 0.003" NS 0639960 3 - DIFF ADJUSTING SHIM 0.005" NS 0639961 4 - DIFF ADJUSTING SHIM 0.010" NS 0639962 2 - DIFF ADJUSTING SHIM 0.030" NS 0502DA0570N GEAR SET SIDE GEAR & PINION MATE 1 CONSISTS OF: 11 0647062 2 - DIFFERENTIAL BEVEL PINION MATE NS 11 0649355 2 - DIFFERENTIAL BEVEL SIDE GEAR NS 12 0636553 SHAFT, PINION MATE 1 13 0636360 PIN LOCK, PINION MATE SHAFT 1 14 090559 WASHER THRUST, DIFF PINION MATE 2 15 060654 WASHER THRUST, DIFF SIDE GEAR 2 15 645789 WASHER THRUST, DIFF SIDE GEAR 15 012109 WASHER THRUST, DIFF SIDE GEAR * 15 036394 WASHER THRUST, DIFF SIDE GEAR (* AS REQUIRED) 16 039460 KIT, DRIVE GEAR AND PINION (4.88R) 1 CONSISTS OF: 907059 1 - HYPOID BEVEL DRIVE GEAR NS 907060 1 - HYPOID BEVEL DRIVE PINION NS 17 0802561 LOCK STRAP-AXLE DRIVE GEAR SCR 5 18 0917292 BOLT 3/8" x 7/8" UNF 10 19 020178 NUT NYLOC 3/4" 1 19 0801367 NUT NYLOC 3/4" 1 20 G179890 BOLT 1/2" UNC x 2-1/4" 4 CONTINUE... 2002.1 2002.2

GROUP 2002 - REAR AXLE GROUP 2002 - REAR AXLE FIG. NO. DESCRIPTION 019405 KIT CONE, ROLLER & CUP PINION BEARING INNER 1 CONSIST OF : 21 807266 1 - CONE & ROLLER, PINION BRG INNER NS 22 052877 1 - CUP, PINION BEARING INNER NS 019402 KIT CONE, ROLLER & CUP PINION BEARING OUTER 1 CONSIST OF : 23 052878 1 - CONE & ROLLER, PINION BRG OUTER NS 24 052879 1 - CUP, PINION BEARING OUTER NS 25 649228 SHIM SET, PINION BRG INNER & OUTER 1 CONSISTS OF: 639969 4 - DR. PINION BRG ADJ SHIM 0.003"-RR NS 639970 2 - DR. PINION BRG ADJ SHIM 0.005"-RR NS 639971 3 - DR. PINION BRG ADJ SHIM 0.010"-RR NS 639972 3 - DR. PINION BRG ADJ SHIM 0.003"-FR NS 639973 3 - DR. PINION BRG ADJ SHIM 0.005"-FR NS 639974 3 - DR. PINION BRG ADJ SHIM 0.010"-FR NS 639975 3 - DR. PINION BRG ADJ SHIM 0.030"-FR NS 26 075871 OIL SLINGER 1 27 0502CA0131N SEAL PINION REAR AXLE 1 28 028199 REAR AXLE SHAFT 2 29 036991 SHIELD DUST 1 30 091743 COMPANION FLANGE 1 31 000A1028 COMPANION FLANGE NUT WASHER 1 32 083065 HEX BOLT HEAD 3/8" - 24 16 33 G108580 SPRING LOCK WASHER 3/8" 28 34 052932 NIPPLE AIR BREATHER 1 35 000A852 WHEEL BEARING SPINDLE 2 36 G181374 BOLT HEX HEAD 3/8" x 24-7 12 37 G120369 NUT HEX 3/8" - 24 12 38 087796 RATIO TAG 4.88R 1 39 0503DA0010N GASKET GEAR CARRIER COVER ASSY 1 052931 TUBULAR BREATHER REAR 1 052934 BREATHER TUBE 1 2002.3 2002.4

GROUP 2101 - STEERING GEAR AND MOUNTINGS GROUP 2101 - STEERING GEAR AND MOUNTINGS FIG. NO. DESCRIPTION 1 088535 ASSY STRG WHEEL WITH LEATHER CVR 1 CONSIST OF: 2 088822 1 - CONTAT PLATE ASSEMBLY 3 088823 4 - SPRING 4 088824 4 - SCREW 5 088825 1 - PAD COVER 6 088826 2 - DOWEL PIN 7 098464 UPPER STEERING COLUMN SUB ASSY 1 WITH STEERING LOCK CONSISTS OF : 8 099221 1 - JACKET TUBE STRG COLUMN 9 099222 1 - SHAFT STEERING COLUMN 10 099223 1 - RUBBER BUSH UPPER 11 099224 1 - RUBBER BUSH LOWER 12 099225 1 - BUSH 14 099280 1 - NUT STEERING COLUMN END 15 080680 ANTI SQUEAK STEERING COLUMN 1 16 3108208 SCREW HEX HEAD M8 x 1.25-25 4 17 6108212 PLAIN WASHR M8 4 18 6508212 SPRING LOCK WASHER M8 4 19 039587 STRG. COLUMN CLAMP 1 20 G123798 SCREW HEX HEAD 5/16" - 24 x 1 3/4" 1 21 G120393 PLAIN WASHER 5/16" 2 22 G120214 SPRING LOCK WASHER 5/16" 1 23 G120368 HEX NUT 5/16" - 24 1 24 098535 BRKT SUPPORT STRG COLUMN BOT 1 25 098536 GROMMET STRG COLUMN BOTTOM 1 27 029925 ASSY INTRM SHAFT WITH COUPLING 1 28 028046 STEERING GEAR AND DROPARM ASSY 1 CONTINUE 2101.1 2101.2

GROUP 2101 - STEERING GEAR AND MOUNTINGS GROUP 2101 - STEERING GEAR AND MOUNTINGS FIG. NO. DESCRIPTION 30 028047 STEERING DROP ARM 1 33 028048 BRACKET STEERING GEAR MTG 1 34 080654 BOLT HEX HEAD M12 x 1.75-50 2 35 6512216 SPRING LOCK WASHER M12 6 36 6112216 PLAIN WASHER M12 6 37 098646 BOLT HEX HEAD M12 x 1.75-130 2 38 080652 BOLT HEX HEAD M12 x 1.75-90 2 39 1102CA1280N PIPE RETURN 1 40 080670 COPPER WASHER M14 2 41 087624 BANJO BOLT M14 (PRESSURE) 1 43 1102CA1270N PIPE PRESSURE FEED 1 44 080669 COPPER WASHER M16 4 45 087626 BANJO BOLT M16 (RETURN) 1 CONTINUE 2101.3 2101.4

GROUP 2101 - STEERING GEAR AND MOUNTINGS FIG. NO. DESCRIPTION 42 080668 HOSE CLAMP (HOSE O.D.27) 2 46 087625 BANJO BOLT M16 1 47 1102CA0110N SUCTION HOSE 1 48 1102CA1261N ASSEMBLY RESERVOIR STEERING 1 16 3108208 SCREW HEX HEAD M8 x 1.25-25 2 17 6108212 PLAIN WASHR M8 2 18 6508212 SPRING LOCK WASHER M8 2 49 027975 BRKT FUEL FILTER MTG. 1 GROUP 2101 - STEERING GEAR AND MOUNTINGS 2101.5 2101.6

GROUP 2103 - STEERING TIE ROD GROUP 2103 - STEERING TIE ROD FIG. NO. DESCRIPTION 1 088456 ASSEMBLY MASTER TIE ROD 1 2 084852 CONNECTING TIE ROD ASSY 4WD 1 3 099805 TIE ROD SOCKET ASSEMBLY LEFT M18 1 4 099806 TIE ROD SOCKET ASSEMBLY RIGHT M18 2 6 A-837 SOCKET ASSEMBLY CLAMP 2 7 2108262 BOLT, HEX. HD. M8 x 1.25-40 2 8 6508212 LOCK WASHER SPRING M8 2 9 5108206 NUT HEX. M8 x 1.25 2 (* FOR TIE ROD SOCKET CLAMP) 10 074294 COVER, DUST, TIE ROD SOCKET 4 11 020231 WASHER SPECIAL 4 12 074298 NUT HEX. M12 x 1.5 4 (STEERING TIE ROD STUD ATTACHING) 13 7025212 PIN COTTER 2.5 x 25 4 14 099808 TIE ADJUSTING HEX. SLEEVE 1 15 099809 LOCK NUT RH M18 2 16 099810 LOCK NUT LH M18 1 17 099998 STEERING DAMPER 1 18 020154 NYLOC NUT 7/16" - 20 T TYPE 1 19 2108260 BOLT HEX HD M8 x 1.25-35 2 20 6108212 WASHER PLAIN M8 2 21 6508212 LOCK WASHER SPRING M8 2 22 028262 BRKT. STRG. DAMPER CON. END. 1 23 058974 SPECIAL BOLT - STEERING DAMP 1 24 G120395 WASHER PLAIN 7/16" (15/32" ID) 2 2103.1 2103.2

GROUP 2104 - STABILIZER BAR FIG. NO. DESCRIPTION 1 084840 STABILIZER BAR FRONT 1 2 084841 BUSHING STABILIZER BAR 2 3 060479 STABILIZER CLAMP 2 4 6510214 LOCKWASHER SPRING M10 4 5 099105 SPECIAL BOLT HEX HD M10 x 1.5-25 4 6 6112216 PLAIN WASHER M12 2 7 097964 BUSHING 4 8 084843 LINK STABILIZER BAR 2 9 G131016 PLAIN WASHER (I.D.21/32") 4 10 G137218 COTTER PIN 5/32" x 1.1/4" 2 11 097645 STUD STABILIZER BAR 2 12 5312204 NYLOC NUT M12 x 1.25 2 GROUP 2104 - STABILIZER BAR 2104.1 2104.2

GROUP 2201 - HAND BRAKE FIG. NO. DESCRIPTION 1 06050A0210N LEVER ASSEMBLY PARK BRAKE 1 2 3106226 SCREW HEX M6 x 1-16 3 3 6106208 PLAIN WASHER M6 3 4 6506208 WASHER SPRING M6 3 5 068153 WIRE CLIP 2 6 028023 GROMMET PARKING BRAKE 1 7 0605BA0461N CABLE PARKING BRAKE FRONT 1 8 0605BA0301N CABLE PARKING BRAKE REAR 1 9 06050A0200N BRACKET ROLLER HOLD DOWN 1 10 068266 ROLLER PARK BRAKE 1 11 6110214 PLAIN WASHER M10 1 12 068362 CIRCLIP HAND BRAKE CABLE FRONT 1 13 069504 CABLE SUPPORT PLATE 1 GROUP 2201 - HAND BRAKE 2201.1 2201.2

GROUP 2202A - FRONT DISC BRAKE GROUP 2202A - FRONT DISC BRAKE FIG. NO. DESCRIPTION 1 068005 DISC BRAKE 2 2 G123920 LOCKWASHER SPRING 3/8" 12 3 G181361 BOLT HEX HD 3/8" - 24 x 7/8" 12 4 088483 CALIPER ASSY LT. 1 4 088484 CALIPER ASSY RT. 1 5 G120384 LOCK WASHER SPRING 1/2" 4 6 068099 BOLT M12 x 1.25-30 4 7 089323 HOUSING 2 8 089324 SEALING RING 2 9 089325 PISTON 2 10 089326 BOOT - PISTON 2 11 089327 BOLT 4 12 089328 SLIDING PIN 4 13 089329 SLIDING PIN - BOOT 4 14 089330 CARRIER 2 15 076650 ASSY PAD & ANTI RATTLE SPRING 4 16 089332 ANTI RATTLE CLIP 4 17 089333 BLEED SCREW 2 18 089334 DUST CAP 2 19 0503CA0110N DUST SHIELD DISC BRAKE - LH 1 19 0503CA0120N DUST SHIELD DISC BRAKE - RH 1 089335 KIT, CALIPER (MAJOR) 2 CONSIST OF : 089324 1 - SEALING RING NS 089325 1 - PISTON NS 089326 1 - BOOT - PISTON NS 089329 2 - SLIDING PIN - BOOT NS 0603BA0511N 2 - SHIM NS 0603BA0521N 2 - GASKET NS 1 - GREASE SACHET NS 089336 KIT, CALIPER (MINOR) 2 CONSIST OF : 089324 1 - SEALING RING NS 089326 1 - BOOT - PISTON NS 089329 2 - SLIDING PIN - BOOT NS 0603BA0511N 2 - SHIM NS 0603BA0521N 2 - GASKET NS 1 - GREASE SACHET NS 089337 KIT,SLIDING PIN 2 CONSIST OF : 089327 2 - BOLT PIN NS 089328 2 - SLIDING PIN NS 089329 2 - SLIDING PIN - BOOT NS 1 - GREASE SACHET NS 2202A.1 2202A.2

GROUP 2202B - WHEEL BRAKE REAR GROUP 2202B - WHEEL BRAKE REAR FIG. NO. DESCRIPTION 0602BA1821N BRAKE ASSEMBLY REAR RH 1 0602BA1831N BRAKE ASSEMBLY REAR LH 1 1 071673 BACK PLATE ASSEMBLY RR LH 1 1 071674 BACK PLATE ASSEMBLY RR RH 1 011919 KIT BRAKE SHOE HOLD DOWN 2 CONSIST OF : 2 011876 2 - PINS NS 3 011877 2 - SPRINGS NS 4 011878 4 - CUP WASHER NS 0602BA2181N KIT BRAKE SHOE AND LINING 2 CONSIST OF : 5 0602BA2191N 2 - LINED SHOE LEADING NS 6 0602BA2201N 1 - ASSY LINED SHOE TRAILING LH NS 6 0602BA2211N 1 - ASSY LINED SHOE TRAILING RH NS 0602BA2221N KIT LINING SET BRAKE SHOE (STD) 1 CONSIST OF : 7 0602BA2231N 2 - LINING LEADING NS 8 0602BA2241N 2 - LINING TRAILING NS 9 011929 48 - RIVET NS 0602BA2251N KIT LINING SET (0.8MM U/S) 2 10 011880 SPRING SHOE RETURN ABT. END 4 11 012656 SPRING SHOE RETURN CYL END 4 12 0602BA2141N CYLINDER WHEEL BR ASSY DIA 28.58 2 0602BA2171N KIT RR WHEEL CYL 2 CONSIST OF : 13 012659 2 - DUST COVER NS 14 0602BA2151N 2 - SEAL NS 15 012657 SCREW AND LOCK WASHER ASSY 8 CONSIST OF : 17 012665 1 - SCREW BLEEDER NS 26 0602BA2421N 1 - WASHER NS CONTINUE 2202B.1 2202B.2

GROUP 2202B - WHEEL BRAKE REAR GROUP 2202B - WHEEL BRAKE REAR FIG. NO. DESCRIPTION 16 011898 SPRING WHEEL CYL. RR 2 18 0602BA2161N PISTON RR WHEEL CYL 4 19 012669 AIR EXCLUDER RR 4 20 032296 DUST COVER (BLEED SCREW) 2 21 071675 ASSY LEVER PARKING BRAKE LH 1 21 071676 ASSY LEVER PARKING BRAKE RH 1 22 071677 PIN SHOE 2 23 071678 SPRING SHOE 2 24 071679 RETAINER PLATE 2 25 071680 STRUT ASSEMBLY 2 27 0602BA2361N KIT, CAM ADJUSTER 4 CONSIST OF : 0602BA2391N 1 - CAM NS 0602BA2401N 1 - NUT NS 0602BA2411N 1 - WASHER NS 2202B.3 2202B.4

GROUP 2204 - BRAKE MASTER CYLINDER AND RESERVOIR GROUP 2204 - BRAKE MASTER CYLINDER AND RESERVOIR FIG. NO. DESCRIPTION 1 06060A0281N ASSY LSC65 BOOSTER WITH 1"TMC 1 2 06060A0431N KIT, SERVO 1 CONSIST OF : 3 029634 1 - FILTER 029635 1 - GROMMET - NRV 4 06060A0190N SERVO ASSEMBLY 1 5 0606AA1101N KIT, MASTER CYLINDER - MAJOR 1 CONSIST OF : 1 - PLUNGER ASSY - PRIMARY NS 1 - PLUNGER ASSY - SECONDARY NS 1 - CIRCLIP NS 1 - WASHER 6.5mm NS 1 - STOP PIN NS 2 - SEAL FLUID TANK NS 6 0606AA1111N KIT, MASTER CYLINDER - MINOR 1 CONSIST OF : 2 - SEAL RECUPERATING NS 2 - SHIM SEAL NS 2 - SEAL GLAND NS 1 - WASHER 6.5mm NS 2 - SEAL FLUID TANK NS 1 - CIRCLIP NS 7 6508212 LOCK WASHER SPRING M8 6 8 5108206 NUT HEX M8 x 1.25 6 9 0606AA0781N MASTER CYLINDER ASSEMBLY 1 0607AA0341N KIT, NON RETURN VALVE 1 CONSIST OF: 10 064334 1 - GROMMET NS 11 064333 1 - ASSY NON RETURN VALVE NS 12 097612 ASSEMBLY FLUID RESERVOIR 1 13 077654 FLUID LEVEL WARMING CAP 1 14 029635 GROMMET 2 15 0606CA7770N HOSE VACUUM PUMP TO BOOSTER 1 2204.1 2204.2

GROUP 2206 -BRAKE TUBES GROUP 2206 -BRAKE TUBES FIG. NO. DESCRIPTION 1 074216 BRAKE TUBE M/CYL PRI TO DASH 1 2 074214 BRAKE TUME M/CYL SEC TO DASH 1 3 060353 FRONT BRAKE HOSE 2 4 097635 BRAKE TUBE CHASS BRKT TO FRT TEE 1 4 080110 BRAKE TUBE CHASSIS BRKT TO TEE 1 5 029186 BR TUBE FRONT T TO HOSE RH 1 5 074215 BRAKE TUBE FRT HOSE TO FRT BRK 1 6 011639 TEE REAR 3 WAY 2 7 3106214 BOLT HEX HD M6 x 1-35 2 8 6506208 WASHER SPRING L M6 x 11.6 x 1.6 x ZN 2 9 098595 TUBE FRT TEE HOSE LH 1 9 098596 BRK TUBE FRT TEE TO HOSE LH 1 10 0606CA6970N TUBE COILED REAR TO LCRV INLET 1 10 0606CA0981N TUBE CONNECTOR TO HOSE RR 1 12 0606CA6980N TUBE LCRV OUTLET TO HOSE REAR 1 12 074215 BRAKE TUBE FRT HOSE TO FRT BRK 1 13 011631 BRAKE HOSE ASSEMBLY 1 17 089288 BRAKE TUBE RR T WHEEL RH 1 17 097639 BRK TUBE RR TEE TO WHEEL RH 1 18 0606CA1450N TUBE REAR TEE TO WHEEL LH 1 18 0606CA1430N TUBE REAR TEE TO WHEEL LH 1 19 081528 BRAKE TUBE CLIP 6 20 038525 CLIP NYLON 1 21 804201 CLIP AXLE TUBE BRK TUBE H/DOWN 2 22 011642 GASKET BRAKE HOSE 4 22 033839 SPECIAL WASHER 7 23 011644 LOCKWASHER BRAKE HOSE SECURING 7 24 011645 NUT LOCK HOSE SECURING 7 25 011642 GASKET BRAKE HOSE 1 26 075613 BANJO BOLT M10 x 1 2 27 028630 BRAKE HOSE FRONT 2 28 06000A0321N LCRV AND LINKAGE ASSEMBLY 1 29 5108206 NUT HEX M8 x 1.25 1 30 020164 UNION INV FLARED TUBE 1/4 1 0609CA0010N BRACKET LSV AXLE END 1 2206.1 2206.2

GROUP 2301A - WHEEL AND ATTACHING PARTS - FRONT GROUP 2301A - WHEEL AND ATTACHING PARTS - FRONT FIG. NO. DESCRIPTION 1 0404AA0171N WHEEL RIM 6J x 15 5 1 0404AA0331N WHEEL RIM 6J x 15 (SSWL) 5 2 097878 WHEEL BOLT 10 3 097882 WHEEL NUT M14 23 5 097877 FRONT WHEEL HUB 2 6 0502CA0080N OIL SEAL WHEEL HUB 2 7 083152 INNER WHEEL BEARING CUP - SKF 2 7 090189 INNER WHEEL BEARING CUP - IMP 2 7 917773 INNER WHEEL BEARING CUP - NBC 2 8 052880 INNER WHEEL BEARING CONE - NBC 2 8 083151 INNER WHEEL BEARING CONE - SKF 2 8 090188 INNER WHEEL BEARING CONE - IMP 2 9 083150 OUTER WHEEL BEARING CUP - SKF 2 9 090187 OUTER WHEEL BEARING CUP - IMP 2 9 925447 OUTER WHEEL BEARING CUP - NBC 2 10 083149 OUTER WHEEL BEARING CONE - SKF 2 10 090186 OUTER WHEEL BEARING CONE - IMP 2 10 925446 OUTER WHEEL BEARING CONE - NBC 2 11 00A865 WHEEL BEARING LOCK WASHER 2 12 00A866 WHEEL BEARING NUT 4 13 099825 TOOTHED LOCKWASHER 2 14 090708 'O' RING BIG 2 20 7903055007 SPRING LOCKWASHER M10 10 21 068019 BOLT DISC 3/8" - 16 x 1-1/4" 10 22 098442 WHEEL HUB COVER 2 22 099759 WHEEL HUB COVER 4WD 2 05000A0080N KIT SPACER AND SHIM 2 CONSIST OF : 23 029975 1 - SPACER WHEEL BEARING (27.575) 23 029976 1 - SPACER WHEEL BEARING (27.6) 23 029977 1 - SPACER WHEEL BEARING (27.625) 24 029978 1 - SHIM WHEEL BEARING (0.075) 24 029979 1 - SHIM WHEEL BEARING (0.2) 24 029980 1 - SHIM WHEEL BEARING (0.5) 25 076205 FREE WHEEL HUB 2 2301A.1 2301A.2

GROUP 2301B - WHEEL AND ATTACHING PARTS - REAR GROUP 2301B - WHEEL AND ATTACHING PARTS - REAR FIG. NO. DESCRIPTION 1 0404AA0171N WHEEL RIM 6J x 15 5 1 0404AA0331N WHEEL RIM 6J x 15 (SSWL) 5 2 097871 WHEEL BOLT 10 3 097882 WHEEL NUT M14 23 4 097872 BRAKE DRUM REAR 2 5 097870 REAR WHEEL HUB 2 6 0502CA0080N OIL SEAL WHEEL HUB 2 7 083152 INNER WHEEL BEARING CUP - SKF 2 7 090189 INNER WHEEL BEARING CUP - IMP 2 7 917773 INNER WHEEL BEARING CUP - NBC 2 8 052880 INNER WHEEL BEARING CONE - NBC 2 8 083151 INNER WHEEL BEARING CONE - SKF 2 8 090188 INNER WHEEL BEARING CONE - IMP 2 9 083150 OUTER WHEEL BEARING CUP - SKF 2 9 090187 OUTER WHEEL BEARING CUP - IMP 2 9 925447 OUTER WHEEL BEARING CUP - NBC 2 10 083149 OUTER WHEEL BEARING CONE - SKF 2 10 090186 OUTER WHEEL BEARING CONE - IMP 2 10 925446 OUTER WHEEL BEARING CONE - NBC 2 11 00A865 WHEEL BEARING LOCK WASHER 2 12 00A866 WHEEL BEARING NUT 4 13 090708 O RING BIG 2 14 099825 TOOTHED LOCKWASHER 2 15 071635 DOWEL PIN REAR AXLE 4 16 3206206 SCREW C/S SLOTTED M6 x 1-16 2 17 099759 WHEEL HUB COVER 4WD 2 05000A0080N KIT SPACER AND SHIM 2 CONSIST OF : 18 029975 1 - SPACER WHEEL BEARING (27.575) 18 029976 1 - SPACER WHEEL BEARING (27.6) 18 029977 1 - SPACER WHEEL BEARING (27.625) 19 029978 1 - SHIM WHEEL BEARING (0.075) 19 029979 1 - SHIM WHEEL BEARING (0.2) 19 029980 1 - SHIM WHEEL BEARING (0.5) 20 0502CA0070N DUST SHIELD - HUB REAR 2 21 G181643 BOLT HEX HD 3/8" - 24 x 1-1/2" 12 22 G123920 LOCKWASHER SPRING 3/8" 12 23 G120369 NUT HEX 3/8" - 24 12 2301B.1 2301B.2

GROUP 2401A - FRAME GROUP 2401A - FRAME FIG. NO. DESCRIPTION 0201AK0750N FRAME ASSEMBLY COMPLETE 1 1 029856 ASSY X-MEMBER FRONT COMPLETE 1 2 020168 NUT NYLOC 3/8" - 24 T TYPE 8 3 0201AA2640N X-MBR ASSY ENGINE SUPPORT REAR 1 4 G120394 WASHER PLAIN M3 12 5 065629 SPECIAL BOLT 8 6 079735 CROSS MEMBER CENTER 1 7 029718 ASSY X-MEMBER F/TANK MTG FRONT 1 8 097513 ASSEMBLY PLATE NUT RETAINER 2 9 029760 ASSY X-MBR SPARE WHEEL MOUNTING 1 10 02020E0060N FRAME X-MBR REAR 1 11 0201AA0780N BRACKET BUMPER SIDE 2 12 098285 TOWING HOOK FRONT AND REAR 2 13 097939 ASSY BRKT SPRING SHACKLE FRONT 2 14 097929 ASSY BRKT MTG STABILISER BAR 1 15 0201AA0790N BRACKET BUMPER BOTTOM 2 16 0201AE2350N BRACKET HOSE ANCHOR REAR 1 17 0201AA0640N BRACKET FRONT BRAKE HOSE 2 18 097948 ASSY BRKT SHOCK ABSORBER FRONT 2 19 02000D0120N SPECIAL BOLT HEX HD M10 x 1.5-50 4 20 0203AA0180N BRACKET ENGINE RH 1 21 0203AA0190N BRACKET ENGINE LH 1 22 097861 ASSY BRKT FRT SPRING RR PIVOT LH 1 23 097866 ASSY BRKT FRT SPRG RR PIVOT RH 1 24 084785 BODY OUTRIGGER NO '0' 2 25 084805 BODY OUTRIGGER NO '1' 2 26 02020D0020N CUP BODY MOUNTING 15 27 029713 BODY OUTRIGGER NO '3A' 2 28 084877 BODY OUTRIGGER NO '3' LH 1 29 084876 BODY OUTRIGGER NO '3' RH 1 30 029788 OUTRIGGER BODY NO. '6' 2 31 084809 BODY OUTRIGGER NO '5' AND '2' 2 32 097512 MTG BRKT X-MBR ENGINE REAR RH 1 33 02020D0030N CUP BODY MOUNTING WITH CUT 2 34 0201AE2660N BRACKET ASSEMBLY LSV 1 35 0203AA0200N BRACKET ENGINE STAY ROD 1 36 097511 MTG BRKT X-MBR ENGINE REAR LH 1 2401A.1 2401A.2

GROUP 2401A - FRAME GROUP 2401A - FRAME FIG. NO. DESCRIPTION 37 057526 RESTRICTOR BRKT 1 38 029714 BODY OUTRIGGER NO '4' 2 39 029747 ASSY BRKT SHOCK ABS REAR 2 40 097863 BRKT REAR SPRING FRONT PIVOT LH 1 41 097864 BRKT REAR SPRING FRONT PIVOT RH 1 42 098762 BRACKET AXLE BUMPER 2 43 029711 ASSY SPRING SHACKLE BRKT REAR 2 44 029710 ASSY C/MBR FUEL TANK MTG REAR 1 45 029814 AXLE BUMPER MOUNTING BRACKET 2 46 6110214 PLAIN WASHER M10 4 47 6510214 LOCKWASHER SPRING M10 4 48 028403 CROSS MEMBER FRONT BUMPER MTG 1 49 084766 ASSY X-MEMBER INTERMEDIATE CTR 1 50 091247 UNDER FRAME SKID PLATE 1 51 G120394 WASHER PLAIN M3 4 52 G138489 LOCKWASHER SPRING 3/8" EXT TOOTH 4 53 G120915 BOLT CARRIAGE 3/8" 4 54 G130377 NUT HEX 3/8" - 16 4 2401A.3 2401A.4

GROUP 2401B - SPARE WHEEL MOUNTING FIG. NO. DESCRIPTION 1 098026 ASSY SPARE WHEEL CARRIER 1 2 029774 SPARE WHEEL STOPPER BRKT 1 3 2108230 BOLT HEX HD M8 x 1.25-30 4 4 6108212 WASHER PLAIN M8 4 5 6508212 LOCK WASHER SPRING M8 4 2401B.1

GROUP 2501 - FRONT SPRING AND SHOCK ABSORBER GROUP 2501 - FRONT SPRING AND SHOCK ABSORBER FIG. NO. DESCRIPTION 1 029725 ASSEMBLY FRONT SPRING 2 2 084777 SILENT BLOCK BUSH 2 3 912593 BUSH PIVOT END 2 4 097932 SPRING PIVOT PIN 2 5 6116220 PLAIN WASHER M16 6 6 5316202 NUT NYLOC M16 x 1.5 6 7 G191758 GREASE NIPPLE 1/8" NPTF STRAIGHT 2 8 089517 CLIP SPRING 3 8 029951 CLIP SPRING 1 9 084814 ASSY SPRING CLIP PLATE FRONT RH 1 9 084828 ASSY SPRING CLIP PLATE FRONT RH 1 10 080149 NYLOCK NUT 1/2" - 20 8 11 2116282 BOLT HEX HD M16 x 1.5-110 4 12 04000A0240N SHACKLE PLATE 70 4 13 029745 ASSY SHOCK ABSORBER FRONT 2 14 0403AA0050N BUSHING SHOCK ABSORBER EYE 4 15 G120389 WASHER PLAIN 1/2" 4 16 5312204 NYLOC NUT M12 x 1.25 4 2501.1 2501.2

GROUP 2502 - REAR SPRING AND SHOCK ABSORBER GROUP 2502 - REAR SPRING AND SHOCK ABSORBER FIG. NO. DESCRIPTION 1 029726 ASSEMBLY REAR SPRING COMPLETE 2 2 084835 ASSEMBLY SPRING CLIP PLT RR RH 1 2 084836 ASSEMBLY SPRING CLIP PLT RR LH 1 3 074048 CLIP SPRING 4 4 080149 NYLOC NUT 1/2" x 20 8 5 097932 SPRING PIVOT PIN 2 6 5316202 NUT NYLOC M16 x 1.5 6 7 6116220 PLAIN WASHER M16 6 8 G191758 GREASE NIPPLE 1/8" NPTF STRAIGHT 6 10 04020A0170N SHACKLE PLATE ASSEMBLY 2 11 079761 REAR SPRING SHACKLE PLATE 2 12 079756 REAR SPRING SHACKLE BUSHING 2 13 029746 ASSEMBLY SHOCK ABSORBER REAR 2 14 G120389 WASHER PLAIN 1/2" 4 15 5312204 NYLOC NUT M12 x 1.25 4 16 070175 BUSHING SHOCK ABSORBER EYE 4 17 097946 AXLE BUMPER 2 2502.1 2502.2

GROUP 2601 - HOOD GROUP 2601 - HOOD FIG. NO. DESCRIPTION 1 28346CED ASSEMBLY BONNET - CED 1 2 029546 CENTRAL LOCK UNIT UPPER 1 3 6106208 PLAIN WASHER M6 6 4 3106226 SCREW HEX M6 x 1-16 2 5 028330 ASSEMBLY BONNET HINGE LH 1 6 028530 ASSEMBLY COVER BONNET HINGE 2 7 6110214 PLAIN WASHER M10 8 8 6510214 LOCKWASHER SPRING M10 8 9 3110208 HEX SCREW M10 x 1.25-30 8 10 028333 ASSEMBLY REINF PLATE 4 11 028334 ASSEMBLY BONNET HINGE RH 1 12 3108226 SCREW HEX HD M8 x 1.25-25 H 4 13 6508212 LOCK WASHER SPRING M8 4 14 6108212 WASHER PLAIN M8 4 15 028326 WEATHERSTRIP BONNET RIGHT 1 16 028325 WEATHERSTRIP BONNET LEFT 1 17 028302 WEATHERSTRIP BONNET FRONT 1 18 028709 WEATHERSTRIP BONNET REAR 1 19 6506208 WASHER SPRING M6 2 01060K0980N KIT P U FOAM BONNET 1 CONSIST OF : 029436 1 - P U FOAM BONNET INNER LH 029437 1 - P U FOAM BONNET INNER RH 029438 1 - P U FOAM BONNET OUTER LH 029439 1 - P U FOAM BONNET OUTER RH 2601.1 2601.2

GROUP 2602A - FENDER RIGHT GROUP 2602A - FENDER RIGHT FIG. NO. DESCRIPTION 1 0102CN0220A FENDER ASSY COMPLETE RH - CED 1 2 028470 FILLER STRIP (FENDE TO DASH) 1 3 028468 ASSY RETAINER PLATE FENDER MTG 1 4 G120214 WASHER SPRING LOCK M5 5 5 G446363 PLAIN WASHER 3/8" ID 5 6 5108206 NUT HEX M8 x 1.25 3 7 072998 STAY BRKT VERT DASH TO FNDR RH 1 8 6110214 PLAIN WASHER M10 4 9 6510214 LOCKWASHER SPRING M10 4 10 7903201045 BOLT HEX HD M10 x 1.5-20 4 11 097573 GRIP HANDLE ROD HOOD PROP 1 12 979727 BRACKET HOOD PROP RET 1 13 0102EK0010N STAY ROD BONNET 1 14 028367 HOLDER BONNET STAY ROD 1 15 3306206 SCR SLTD PAN HD M6 x 1-14 8 16 073000 STAY BRKT HOR DASH TO FNDR RH 1 18 3108226 SCR HEX HD M8 x 1.25-25 H 2 19 G121753 LOCK WASHER EXT TH 1/4" 2 2602A.1 2602A.2

GROUP 2602B - FENDER LEFT FIG. NO. DESCRIPTION 1 0102CK0020A FENDER ASSEMBLY FRONT LH - CED 1 2 028470 FILLER STRIP (FENDE TO DASH) 1 3 028468 ASSY RETAINER PLATE FENDER MTG 1 4 G120214 WASHER SPRG LOCK M5 5 5 G446363 PLAIN WASHER 3/8" ID 5 6 5108206 NUT HEX M8 x 1.25 3 7 072997 STAY BRKT VERT DASH TO FNDR LH 1 8 6110214 PLAIN WASHER M10 2 9 6510214 LOCKWASHER SPRING M10 2 10 7903201045 BOLT HEX HD M10 x 1.5-20 2 11 072999 STAY BRKT HORI DASH TO FNDR LH 1 12 3108226 SCR HEX HD M8 x 1.25-25 H 2 GROUP 2602B - FENDER LEFT 2602B.1 2602B.2

GROUP 2603 - RADIATOR GUARD GROUP 2603 - RADIATOR GUARD FIG. NO. DESCRIPTION 1 0102BN0020A RADIATOR GRILL - CED 1 2 7903201020 SCREW M6 x 1-12 10 3 6506208 WASHER SPRING M6 20 4 6106208 PLAIN WASHER M6 18 5A 028651 HEAD LAMP BEZEL LH CHROM PLTD 1 5B 028652 HEAD LAMP BEZEL RH CHROM PLTD 1 6 029551 CSK CRSRES TAP SCR 10 x 16 x 1-3/4" 4 7 28368CED FACIA ASSEMBLY - CED 1 8 3106226 SCREW HEX M6 x 1-16 8 9 0102DN1190A AIR DEFLECTOR & FRAME ASSY - CED 1 10 028408 ASSEMBLY LOCK PLATE BONNET 1 11 029557 BONNET BUFFER 2 12 6508212 LOCK WASHER SPRING M8 10 13 5108206 NUT HEX M8 x 1.25 6 14 0102FN0010N COVER HEAD LAMP RH 1 14 0102FN0020N COVER HEAD LAMP LH 1 CONTINUE 2603.1 2603.2

GROUP 2603 - RADIATOR GUARD FIG. NO. DESCRIPTION 15 0114CN0091N BONNET LOCK ASSEMBLY 1 16 3108226 SCR HEX HD M8 x 1.25-25 H 3 18 6108212 WASHER PLAIN M8 10 19 029550 LOCK PLATE (BONNET) 1 20 029548 CABLE BONNET RELEASE 1 21 3106226 SCREW HEX M6 x 1-16 2 22 19000A1680N TIE ROD ASSY DASH TO FRONT END 2 23 6108212 WASHER PLAIN M8 3 25 5108206 NUT HEX M8 x 1.25 2 GROUP 2603 - RADIATOR GUARD 2603.3 2603.4

GROUP 2604 - FOOT STEP FIG. NO. DESCRIPTION 1 0108JF0160N FOOTSTEP ASSEMBLY SIDE RH 1 1 0108JF0170N FOOTSTEP ASSEMBLY SIDE LH 1 2 6110214 PLAIN WASHER M10 8 3 6510214 LOCKWASHER SPRING M10 8 4 7903201045 BOLT HEX HD M10 x 1.5-20 8 2604.1

GROUP 2605 - BODY MOUNTINGS FIG. NO. DESCRIPTION RADIATOR GUARD MOUNTING 02020D0110N BOLT SPECIAL POINTED M10 x 1.5-85 1 0A6360 PEDAL SHANK DRAFT PAD WASHER 1 02020D0060N SPACER BODY MOUNTING 2 02020D0040N INSULATOR BODY MOUNTING UPPER 2 02020D0050N INSULATOR BODY MOUNTING LOWER 2 02020D0080N WASHER 2 7903234004 NYLOC NUT M10 x 1.5 1 GROUP 2605 - BODY MOUNTINGS BODY MOUNTING : MTG NO '0' LH AND RH 067974 SPECIAL BOLT M10 x 1.5-52 2 6510214 LOCKWASHER SPRING M10 2 02020D0080N WASHER 2 02020D0050N INSULATOR BODY MOUNTING LOWER 2 02020D0040N INSULATOR BODY MOUNTING UPPER 2 02020D0060N SPACER BODY MOUNTING 2 MTG NO '1' LH AND RH 067974 SPECIAL BOLT M10 x 1.5-52 2 6510214 LOCKWASHER SPRING M10 2 02020D0080N WASHER 2 02020D0050N INSULATOR BODY MOUNTING LOWER 2 02020D0040N INSULATOR BODY MOUNTING UPPER 2 02020D0060N SPACER BODY MOUNTING 2 MTG NO '3' LH AND RH 067974 SPECIAL BOLT M10 x 1.5-52 2 6510214 LOCKWASHER SPRING M10 2 02020D0080N WASHER 2 02020D0050N INSULATOR BODY MOUNTING LOWER 2 02020D0040N INSULATOR BODY MOUNTING UPPER 2 02020D0060N SPACER BODY MOUNTING 2 DUMMY MOUNTING 074074 SNUBBER BODY MOUNTING 3/6" 2 MTG NO '4' LH AND RH 067974 SPECIAL BOLT M10 x 1.5-52 2 6510214 LOCKWASHER SPRING M10 2 02020D0080N WASHER 2 02020D0050N INSULATOR BODY MOUNTING LOWER 2 02020D0040N INSULATOR BODY MOUNTING UPPER 2 02020D0060N SPACER BODY MOUNTING 2 CONTINUE 2605.1 2605.2