Henny Penny Model OE/OG 30/30/303 SECTION 7. PARTS INFORMATION 7-. INTRODUCTION This section identifies and lists the replaceable parts of the Henny Penny 3-Well Open Fryer. 7-. GENUINE PARTS Use only genuine Henny Penny parts in your unit. Using a part of lesser quality or substitute design may result in unit damage or personal injury. 7-3. WHEN ORDERING PARTS Once the part you want to order has been found in the Part List, write down the following information:. From the exploded drawing and Parts List (Sample) Item Number 8 Part Number 43768 Description On/Off Switch. From the data plate (Sample) Product Number 0400 Serial Number 0000 Voltage 08 7-4. PRICES Your distributor has a price parts list and will be glad to inform you of the cost of yours parts order. 7-5. DELIVERY Commonly replaced items are stocked by your independent Henny Penny distributor and will be sent out when your order is received. Other parts will be ordered by the distributor from Henny Penny Corporation. Normally, these will be sent to your distributor within three working days. 7-6. WARRANTY All replacement parts (except lamps and fuses) are covered under warranty for 90 days against manufacturing defects and workmanship. If damage occurs during shipping, notify the carrier at once so that a claim may be properly filed. Refer to the warranty in this manual for other rights and limitations. 7-7. RECOMMENDED SPARE PARTS FOR DISTRIBUTORS Recommended replacement parts, stocked by your distributor, are indicated with in the parts lists. Please use care when ordering recommended parts, because all voltages and variations are marked. Distributors should order parts based upon common voltages and equipment sold in their territory. 06 7-
33309 33308 44784 43768 40500 30978 8979 Control Panel Assembly Complete (Gas Models) - 0V Control Panel Assembly Complete (Electric Models) - 08/4OV Control Panel Assembly Complete (Gas Models) - 40V Power (ON/OFF) Switch Replaceable Beeper Transformer - OV-V (Gas) Transformer - 08/4OV- V (Electric) uaqti~ per unit 30
..
Electrical Components (Electric Models) Thermal Sensor (Probe) High Temperature Limit Control Thermocouple Pot Fitting Fuse Holder Assy. (5 amp) Fuse Holder Assy. (5 amp) Fuse Holder Assy. - CE Contactor - Mercury 8 30094 Compression Fitting 3 9 968 Contactor Bracket 3 0 9405 Contactor 3 76 High Limit Bracket 3 33376* Insulation-Pot Front 3 3 990* Cap.-Resistor Assy.-Primary Contactor 3 4 5065 EMC Filter Board Assy. (CE) 5 33498 Cap.-Resistor A&Y.-Heat Contactor 3 6 360* Cap.-Resistor Assy.-Pump Motor *not shown
Limit control.
Henny Penny Model OE/OG 30/30/303 Thermal Sensor and High Temperature Limit Control (Gas Models) Item Part Quantity per unit No. Number Description 303 30 30 7-3 Thermal Sensor and High Temperature Limit Control (Gas Models) l 6738 High Temperature Limit Control 3 467 High Temp. Limit Control Kit- CE - Electronic 3 48 High Temp. Limit Control Kit - CE - Electro-mech. 3 33068 Terminal Block 3 3 SC0-08 Screw, Thread Forming #8 6 4 4 NS0-00 Nut, #0-3 Hex Keps 3 6 333 Control Shroud Access Plate 3 7 FP0-04 Bushing - 3/8-/8 3 8 FP0-099 Pipe Plug 3 9 33094 Compression Fitting 3 5 76 High Limit Control Bracket 3 0 5568 Thermal Sensor - 6 3 0 5567 Thermal Sensor - 3 3 0 348 Thermal Sensor - 6 - CE 3 507 Thermocouple Pot Fitting 3 3483 Capillary Bulb Mounting Assy. 3 50698 Clamp-Rear, Capillary Bulb - CE (not shown) 3 50699 Clamp-Front, Capillary Bulb - CE (not shown) 3 3 4437 Seal Weld Assy. (not shown) 4 360 Capacitor - Resistor Assy. (not shown) 7 5 3 5 33304 Insulation - Front Cover recommended parts 06 7-7
Figure 7-4. Firebox and Flue Assembly (Gas Model)
Part Number 3366 6406 3364 336 5538 Description Firebox and Flue Assembly (Gas Models) Firebox Front Cover Assy. Heat Shield Outer Firebox Weld Assy. Flue Assy. Firebox Assv. - CE - 06-30 Quantity per unit 303 30 30
re 7-5.
Outer Front Firebox Assy. (Gas Model) Outer Front Weld Assy. Insulation-Front Firebox Insulation-Top Front
w Y
Part Number 33348 33046 5537 6503 650 33346 33456 5536 Description Firebox Insulation Assembly (Gas Model) Insulation-Top/Sides Insulation-Firebox Sides Insulation-Firebox sides - CE - OG-30 Insulation-Bottom Panel Insulation-Back Panel Insulation- in.-top/rear Insulation-3/4 in.-top/rear Insulation-Firebox to Frame - CE (not shown) Quantity per unit 30 30
T - \ \
er escri~tio Qu 303 itity pe 30 nnit 30 7-7 la lb A B a A b B 3 4 5 66 67 6380 638 654 670 6386 6384 653 635 667 Gas Control Valve (Gas Model) Valve, Control, Natural Gas, 0 Volt Valve, Control, Propane Gas, 0 Volt Valve, Control, Natural Gas, 08-40 Volt Valve, Control, Propane Gas, 08-40 Volt Operator, Gas Valve, 0 Volt, Natural Operator, Gas Valve, 08-40 Volt, Natural Operator, Gas Valve, 0 Volt, Propane Operator, Gas Valve, 08-40 Volt, Propane Regulator, Gas Valve, Natural Gas Regulator, Gas Valve, Propane Gas Dial, Gas Cock i 3 3 I 3 x 3 3 f NOTE: la consists of a, 3, and 5 A consists of A, 3, and 5 lb consists of b, 4, and 5 B consists of B, 4 and 5
Gas Line and Burner Assembly (Gas Model)
Henny Penny Model OE/OG 30/30/303 Gas Line and Burner Assy. (Gas Model) Item Part Description Quantity per unit No. Number 303 30 30 7-8 Gas Line and Burner Assy. (Gas Model) FP0-093 Elbow - in. NPT x 90 Female BI - - 4 FP0-08 Nipple - Pipe "x 8" BI - - 5 FP0-09 Cross Tee - in. NPT Female BI - - 6 FP0-085 Bushing - Reducing I in. to / BLK 3 - - 7 6335 Male Connector 37 Flare 5 - - 8 3335 Assy. - Gas Line - - 8 33489 Assy. - Gas Line - Left - 303 DS - - 8 33835 Assy. - Gas Line - Right - 303 DS - - 9 456 Assy. - Middle Gas Line - - NS0-00 Nut - Keps - /4-0 C 6 4-703- SET, Orifice, Natural Gas 3 656- Orifice, Nat. Gas - S.S. 3 656- Orifice, Nat. Gas - Brass 69 46 3 703-3 SET, Orifice, Propane Gas 3 656-3 Orifice, Propane Gas - S.S. 3 656-3 Orifice, Propane Gas - Brass 69 46 3 3 9969 Bracket, Pilot Holder 3 4 SC0-009 Screw, Pilot Holder Bracket 3 5 983 Pilot & Orifice Assembly 3 6 SC0-006 Screw, Pilot Holder 3 7 3093 Pilot & Bracket Assy. - Nat. 3 7 30904 Pilot & Bracket 3 8 605 Casting, Burner 3 9 SC06-03 U-Bolt, Gas Line 3 0 45393 Gas Valve Supply Tube 3 38464 Gas Burner to Control Line Assy. 3 38446 Solenoid - Gas 3 38467 Solenoid - Gas - 40V 3 3 FP0-035 Nipple - Close 3 3480 Solenoid - Gas - 40V - CE 3 3480 Solenoid - Gas - 40V - CE 3 4 66 Valve - Nat. Gas Valve 3 4 67 Valve - Propane Gas Valve 3 4 6380 Valve - Nat. Gas Valve - 40V 3 4 638 Valve - Propane Gas Valve - 40V 3 4 34804 Valve - Nat. Gas Valve - 40V - CE 3 4 34803 Valve - Propane Gas Valve - 40V - CE 3 5 6336 Elbow - / NPT x 90 Female BI 9 6 3 7 3378 Valve - 3/4 in. Gas Ball 3 7 4540 Valve - / in. Gas Ball 3 3 980 Orifice - Pilot - Nat. Gas 3 3 3407 Orifice - Pilot - Propane Gas 3 33 69 Thermocouple 3 33 3480 Thermocouple - CE 3 34 68 Tube - Pilot Assy. 3 35* 3367 Gas Line Assembly - w/ Swivel - - 36* FP0-04 /8 in. Elbow - Gas Check Port 3 37* 45484 Gas Line Assy. - OG-30 - - recommended parts/*not shown 06 7-7
Assy. - Right Gas Line Gas Line Assy. w/swivel (not shown) el
Henny Penny Model OE/OG 30/30/303 Drain Valve Assembly (Gas Model) Item Part Description Quantity per unit No. Number 303 30 30 7-9 Drain Valve Assembly (Gas Model) 760 Body Assembly, Drain Valve 3 70 Cover, Microswitch 3 3 87 Microswitch 3 4 SC0-058 Screw, Microswitch 6 4 5 NS0-005 Nut, Microswitch 6 4 6 33334 Bracket, Drain, Valve Rod 3 7 SC03-005 Screw, Drain Bracket 6 4 8 754 Rod, Drain Valve 3 8 55369 Rod, Drain Valve - OG-30 (SN: EN006IH - - and above) 9 693 Cover, Valve Handle 3 0 8644 Connector, 90 Flexible Conduit (Includes Nut) 3 805 Insulator 6 4 3303 Conduit, Flexible 3 3 8 Connector, Flexible Conduit (Includes Nut) 3 4 33355 Extension Nipple 3 4 45395 Extension Nipple w/ Splash Guard (not shown) 3 5 465 Kit - OG30X - Normally Open Drain Switch 3 recommended parts 06 7-
Y
Drain Valve Assembly (Electric Model) Nipple, Drain Extension Rod, Drain Valve Extension Cover, Valve Handle Bracket, Drain Valve Screw, Drain Valve Bracket Screw, Microswitch Nut, Microswitch Cover, Microswitch
et
Henny Penny Model OE/OG 30/30/303 Drain Pan and Filter Screen Assembly (Gas and Electric Models) Item Part Description Quantity per unit No. Number 303 30 30 7- Drain Pan and Filter Screen Assy. (Gas and Electric Models) 750 Screen Assembly, Filter 750 Catcher Crumb 3 750 Screen, Top Filter 4 7503 Screen, Bottom Filter 5 7505 Clips, Filter Envelope 6 0 Filter, Envelope Paper (00 per Carton) 7 3356 Cover, Drain Pan Assy. - OG-303 SN: GN05IE & below - - 7 3357 Cover, Drain Pan Assy. - OE-303 SN: GM003IE & below - - 7 33455 Cover, Drain Pan Assy. - OG-30 SN: GN05IE & below - - 7 33454 Cover, Drain Pan Assy. - OE-30 SN: GM003IE & below - - 7 33763 Cover, Drain Pan Assy. - OE-30 SN: GN05IE & below - - 7 3376 Cover, Drain Pan Assy. - OG-30 SN: GM003IE & below - - 7 45437 Cover, Drain Pan Assy. - OG-303 SN: GN06IE & above - - 7 4544 Cover, Drain Pan Assy. - OE-303 SN: GM004IE & above - - 7 55377 Cover, Drain Pan Assy. - OG-30 SN: HN00IH & above - - 7 4547 Cover, Drain Pan Assy. - OG-30 SN: GN06IE to HN00IH - - 7 55375 Cover, Drain Pan Assy. - OE-30 SN: HM00IH & above - - 7 45436 Cover, Drain Pan Assy. - OE-30 SN: GM004IE to HM00IH - - 7 4556 Cover, Drain Pan Assy. - OE-30 SN: GM004IE & above - - 7 45443 Cover, Drain Pan Assy. - OG-30 SN: GN06IE & above - - 8 3348 Drain Pan - OG/OE-303 - - 8 55373 Drain Pan - OG/OE-30 - - 8 33749 Drain Pan - OG/OE-30 - - 9 45386 Pan Latch Assy. (not shown) 0 45384 Pan Stop (not shown) recommended parts 06 7-5
I I
Seal, Mechanical, Vitoq Spacer, Pump Filter Washer, Motor Shaft Screw, Pump Shield
et GAS & PILOT CONTROL VALVE r + ------ t-.-- CON- rrol ; SHFI OUD I -*-B--p.-lp-- ---
er uantity per unit 30 30 7-3 3 4 5 6 7 8 9 9 0 0 3 ME50-0 805 807 7 334 804 805 338 80 54944 80 54965 803 33353 790 5537 8644 Electric Conduit Assembly (Gas Model) Terminal Block Bushing, Antishort Connector, Conduit Conduit, Flexible Conduit, Flexible Connector, Conduit Bushing, Antishort Conduit, Flexible Cover, Junction Box Cover, Junction Box - CE Box, Junction Box, Junction - CE Connector, Electric Cord Power Cord, Coiled Power Cord - Straight Power Cord - 0-40 volt Conduit Connector 4 7 6 7 0 5 4 5 6 3 3
H - see
el) Electric Conduit Assembly (Electric Model) Cover, Junction Box Connqctor, Flexible Conduit Bushing, Antishort Conduit, Flexible Connector, Flexible Conduit Bushing, Antishort Conduit, Flexible 9 8644 Connector, Flexible Conduit - 90 0 846 Terminal Block 3
7- sse rie
ode Cookpot and Return Line Assemblies (Gas and Electric Models) Male Connector Return Line - 30 & 303 Return Line - 30 Return Line - Upper Fitting - Return Line, Swivel 6 FPOl-004 Pipe Plug 7 3377 Pot & Countertop Assy. - OE-30. 7 54966 Pot & Countertop Assy. - 06-30 7 33459 Pot & Countertop Assy. - OE-30-7 54967 Pot & Countertop Assy. - OG-30-7 33089 Pot & Countertop Assy. - OE-303 - - 7 54968 Pot & Countertop Assy. - OG-303 - - 7 48453 Pot & Countertop Assy. - 06-303 DS - -
,I\ WN --a -- -43-m /
Henny Penny Model OE/OG 30/30/303 Lower Filter Plumbing Components (Gas and Electric Models) Item Part Description Quantity per unit No. Number 303 30 30 7-6 Lower Filter Plumbing Componet (Gas and Electric Models) 67589 Motor and Pump, Filter 67583 Motor, Filter - / HP 7437 Pump, Filter 7476 Pump Seal Kit SC0-0 Screw, Motor 4 4 4 3 WA0-00 Washer 4 4 4 4 744 Connector, Assembly, Male Elbow 5 7407 Connector, Male Elbow 6 6808 Fitting, Sleeve 7 6809 Nut, Fitting 8 33340 Tubing, Stainless Steel 9 743 Fitting, Union Handle 0 743(use 6989) Fitting, Male Union 7430(use 6989) Fitting, Female Union 7433 Standpipe Assembly, Filter 3 7403 Nut, Filter Screen 4 55367 Tubing, Stainless Steel 5 NS0-0 Nut, Motor 4 4 4 6* FP0-06 Elbow - 5/8" Tube - / NPT - Male (OE/OG-30) - - 7 98 /"-90, Street Elbow - S.S. (OE/OG-30) - - recommended parts *not shown 06 7-35
Y el
I30 Heating Element and High Limit Assembly, (Electric Models) Element Complete, Heating, 08 Volts, Element Complete, Heating, 30 Volts, Element Complete, Heating, 0 Volts, Element Complete, Heating, 480 Volts, (All Elements Include Items Thru 7) Specify Volts and Watts Washer, Heating Element, Metal Nut, Heating Element, Brass Nut, Heating Element Washer, Heating Element Washer, Lock, Heating Element Screw, 8-3 x PH RD SS Screw, Thread Forming #8 Control, Hi Limit Temperature Nut, #lo-3 Hex Kepss Bracket Ass y, Hi Limit Thermostat
ode 0 \ cu
Henny Penny Model OE/OG 30/30/303 3-Well Front View Item Part Description Quantity per unit No. Number 303 30 30 7-8 Fry Station Front View FP0-087 Elbow, Male - 3/8 in. FP0-00 Nipple, Close - 3/8 in 3 7333 Disconnect, Female 4 7334 Disconnect, Male 5 4540 Line, Return Faucet Only - 5 33773 Line, Return Assembly (30) - - 6 34878 Top Cover Assy. (303) - - 6 34879 Top Cover Assy. (30) - - 6 34880 Top Cover Assy. (3 0 ) - - 7 3386 Side Panel - Right (303/30) - 7 55353 Side Panel - Right (30) - - 7 5864 Side Panel - Right (303/30) - CE Gas - 8 33048 Caster (303/30) - 8 7630 Caster (30) - - 9 3304 Locking Caster (303/30) - 9 769 Locking Caster (OG-30) - - 0 4567 Door Assembly - Right (303) - - 0 4565 Door Assembly - Right (30) - - 0 4564 Door Assembly (30) - - 43768 Switch - Filter 3309 Decal - Filter 3 4568 Door Assembly - Left (303) - - 3 4566 Door Assembly - Left (30) - - 4 3304 Basket Support (Electric Model) 3 4 3303 Basket Support (Gas Model) 3 5 330 Basket - / 6 4 5 59078 Basket - /3 size (Gas) - - 3 6 3388 Side Panel - Left (Gas) 6 55354 Side Panel - Left (Electric) 6 5865 Side Panel - Left (303/30) - CE Gas - 7* 33499 Full Size Basket - Gas 3 8* 33500 Full Size Basket - Electric 3 9* 33656 Frypot Cover 3 0 4836 Pocket Pull (Door Handle) * 3384 Full Size Basket - OG-303 DS - * 5776 Gasket - Side Panel (Gas Models) 3* 5779 Gasket - Top Cap - OG-303 - - 4* 5778 Gasket - Top Cap - OG-30 - - recommended parts *not shown 06 7-39
Y sse
Henny Penny Model OE/OG 30/30/303 FIGURE QTY. & ITEM PART DESCRIPTION PER NO. NUMBER ASSY AUTOMATIC RESET TIMER ASSEMBLY 6659 BUZZER COIL ASSY, 0 V... 830 BUZZER COIL ASSY, 08-40 V... 6673 TIMER MOTOR, 0 V... 8303 TIMER MOTOR, 08-40 V... 3 667 TIMER MICROSWITCH... 4 877 MICROSWITCH MOUNTING PLATE... 5 877 MICROSWITCH ACTUATOR ARM... 6 95 ON/OFF SWITCH (includes nut)... 7 664 INDICATOR LIGHT... 9 637 KNOB & POINTER ASSY... 0 6657 BEZEL... Recommeded Parts 06 7-4
-
Henny Penny Model OE/OG 30/30/303 FIGURE UNITS & ITEM PART PER NO. NUMBER DESCRIPTION WELL CONTROL PANEL 830 TIMER, Automatic Reset, 08-40 Volt 60 Hz... 660 TIMER, Automatic Reset, 5 Volt 60 Hz... 6596 TIMER, Automatic Reset, 5 Volt 50/60 Hz... 95 SWITCH, Timer... 3 664 LIGHT, Timer Indicator... 4 6659 COIL, Timer Buzzer, 5 Volt... 4 830 COIL, Timer Buzzer, 0 Volt... 5 SC0-073 SCREW, Timer... 4 6 664 LIGHT, Timer Indicator... 3 7 NS0-009 NUT, Timer... 4 8 4533 DECAL... 9 43768 SWITCH, Main... 6745 PLATE, Thermostat... 453 PANEL, Control... 3 SC0-034 SCREW, Control Panel... 4 4648 KIT, Thermostat Control - OE-30X... 4 493 KIT, Thermostat Control - OG-30X... 5 N/A THERMOSTAT, Body Only... 6 6706 KNOB, Thermostat... 7 6704 BEZEL, Thermostat... 8 SC0-03 SCREW, Thermostat... Recommeded Parts 06 7-43