INSTALLATION GUIDE Directed Digital Solutions FORD6 Designed by Installers for Installers 208 Directed, Vista CA This product is intended for installation by a professional installer only! Attempts to install this product by a person other than a trained professional may result in severe damage to a vehicle s electrical system and components. 208--28
Contents Warning! Safety first... 3 Introduction... 4 Pre-installation and application warnings... 4 Vehicle application guide... 5 Wiring connections... 6 Main power harness (H), 2-pin thick gauge connector... 6 Auxiliary output harness (H2), 6-pin black connector... 6 Analog harness (H3), 8-pin white connector... 7 MC50 harness (H4), 8 thick-gauge wires (optional)... 7 Installation (wiring diagrams & vehicle wiring reference charts)... 8 Type with T-Harness (THFC)... 8 Type... 9 Type 2 with T-Harness (THFC)... 2 Type 2... 22 Type 3... 3 Type 4... 36 Type 5 with T-Harness (THFC)... 39 Type 6... 42 Type 7... 44 Type 8... 46 Type 9... 48 Type 0... 50 Type... 53 Key2GO... 55 Understanding the difference between a Ford 80 & 40 bit... 55 What does it mean?... 55 How do I differentiate between the 40 & 80 bit?... 55 Connecting the module... 56 Important!... 56 Manual or automatic transmission selection... 56 Optional sensors... 57 RF Systems... 57 When used in conjunction with SmartStart... 57 Module programming - Using 2 Keys... 58 Module programming - -Key programming using Key2GO... 59 LED diagnostics and troubleshooting... 60 Soft reset... 62 Hard reset... 62 Learning the Tach (not needed with Virtual Tach)... 63 Initializing Virtual Tach (not needed with hardwired or data tach applications)... 63 Limited lifetime consumer warranty... 64 Quick Reference Guide... 65
Warning! Safety first The following safety warnings must be observed at all times: Due to the complexity of this system, installation of this product must only be performed by an authorized Directed dealer. When properly installed, this system can start the vehicle via a command signal from the remote control. Therefore, never operate the system in an area that does not have adequate ventilation. The following precautions are the sole responsibility of the user; however, authorized Directed dealers should: Never use a test light or logic probe when installing this unit. Always use a multimeter. Never operate the system in an enclosed or partially enclosed area without ventilation (such as a garage). When parking in an enclosed or partially enclosed area or when having the vehicle serviced, the remote start system must be disabled using the installed toggle switch. It is the user s sole responsibility to properly handle and keep out of reach from children all remote controls to assure that the system does not unintentionally remote start the vehicle. USER MUST INSTALL A CARBON MONOXIDE DETECTOR IN OR ABOUT THE LIVING AREA ADJACENT TO THE VEHICLE. ALL DOORS LEADING FROM ADJACENT LIVING AREAS TO THE ENCLOSED OR PARTIALLY ENCLOSED VEHICLE STORAGE AREA MUST REMAIN CLOSED AT ALL TIMES. Use of this product in a manner contrary to its intended mode of operation may result in property damage, personal injury, or death. Except when performing the Safety Check outlined in this installation guide, () Never remotely start the vehicle with the vehicle in gear, and (2) Never remotely start the vehicle with the keys in the ignition. The user is responsible for having the neutral safety feature of the vehicle periodically checked, wherein the vehicle must not remotely start while the car is in gear. This testing should be performed by an authorized Directed dealer in accordance with the Safety Check outlined in this product installation guide. If the vehicle starts in gear, cease remote start operation immediately and consult with the user to fix the problem immediately. OPERATION OF THE REMOTE START MODULE IF THE VEHICLE STARTS IN GEAR IS CONTRARY TO ITS INTENDED MODE OF OPERATION. OPERATING THE REMOTE START SYSTEM UNDER THESE CONDITIONS MAY RESULT IN PROPERTY DAMAGE OR PERSONAL INJURY. IMMEDIATELY CEASE THE USE OF THE UNIT AND REPAIR OR DISCONNECT THE INSTALLED REMOTE START MODULE. DIRECTED WILL NOT BE HELD RESPONSIBLE OR PAY FOR INSTALLATION OR REINSTALLATION COSTS. Remote starters for manual transmission pose significant risks if not properly installed and operated. When testing to ensure the installation is working properly, only remote start the vehicle in neutral gear, on a flat surface and with a functional, fully engaged parking brake. Do not allow anyone to stand in front of or behind the vehicle. This product should not be installed in any convertible vehicles, soft or hard top with a manual transmission. Installation in such vehicles may pose certain risk. 3 Directed Digital Solutions FORD6
Introduction The FORD6 firmware for Directed Digital Solutions is compatible with specific Ford and Lincoln vehicles. It is a complete solution for remote start, security (if applicable), bypass interface, and convenience. This guide provides information on the installation of the module using FORD6. If you would prefer using this system as a digital solution, go to www.directechs.com and search for the make, model and year of the vehicle. This will allow you to find the proper firmware and corresponding installation guide. Warning! This module can only be programmed via the web tool, which can be found on www.directechs.com or using the Directechs Mobile application for mobile devices. Features and functions will become accessible when you connect the module using the XKLoader. Pre-installation and application warnings Firmware notes: This section highlights important information for this specific firmware and will assist in pricing accordingly, as well as bringing awareness to any operational or vehicle limitations. T-Harness compatible THFC Keys required for programming 2 Keys required for operation 0 The optional Plug & Play THFC T-Harness is sold separately. The OBDII Diagnostic Connector features will remain the same even when the T-Harness is installed. Key2GO is required if only one key is available. You can program the interface without the need for Key2GO if two keys are present. Keys required to program: 80-Bit PATs requires 2 DIFFERENT master keys to program. Key2Go programming cannot be used and cloned keys are NOT compatible. 40-Bit PATS is Key2Go compatible and module programming can be done using or 2 different master keys. Refer to "Understanding the difference between a Ford 80 & 40 bit" on page 55 for more information. Unless specified otherwise, all connectors are displayed from the wire side, with the exception of the OBDII diagnostic connector. Refer to the "Vehicle wiring reference chart" following each installation type. General notes: This section highlights important information for this specific firmware. [] The installation of an aftermarket hood pin is ONLY required on vehicles that are NOT equipped with a factory hood pin. [2] The siren is ONLY required when enabling the security features during module flashing. [3] The green wire is ONLY required for starter disable and antigrind applications. [4] Vehicles with install Type 3, 4, 6, 7, 8, 9 & 0 are NOT compatible with optional T-Harness THFC [5] Connections ONLY required if features do not operate in data. [6] ONLY required if OEM alarm equipped. Additional parts required (maximum required): 87 Diode 6A x A Diodes 87a 86 30 85 x Relay esistor 00 0 x Resistor Fuse 7.5A 0 x Fuse 4 Directed Digital Solutions FORD6
Vehicle application guide The following table lists the vehicles and features which are compatible with this product. The number assigned to each year allows you to determine which installation type should be used for your vehicle. Vehicles 208 207 206 205 204 203 202 20 200 2009 2008 Ford Crown Victoria 6[4] 6[4] Edge (40-Bit) Edge (40-Bit) 2 2 2 Edge (80-Bit) Escape 2 2 Escape 2 2 2 Escape Hybrid 2 2 Escape Hybrid 2 2 2 E-Series (40-Bit) 4[4] 4[4] 4[4] 4[4] 4[4] 4[4] 4[4] E-Series (40-Bit) 4[4] 4[4] 4[4] 4[4] E-Series (80-Bit) 4[4] 4[4] 4[4] 4[4] 4[4] 4[4] 4[4] E-Series (80-Bit) 4[4] Expedition (40-Bit) 3[4] 3[4] 3[4] 3[4] 3[4] 3[4] Expedition (40-Bit) 3[4] 3[4] 3[4] 3[4] Expedition (80-Bit) 3[4] 3[4] 3[4] Expedition (80-Bit) 3[4] Explorer (40-Bit) Explorer (40-Bit) Explorer (80-Bit) F-50 (40-Bit) F-50 (40-Bit) [4] [4] 9[4] F-50 (80-Bit) F-250 (40-Bit) F-250 (40-Bit) 3[4] 3[4] 3[4] F-250 (80-Bit) F-350 (40-Bit) F-350 (40-Bit) 3[4] 3[4] 3[4] F-350 (80-Bit) F-450 (40-Bit) F-450 (40-Bit) 3[4] 3[4] 3[4] F-450 (80-Bit) Flex (40-Bit) Flex (40-Bit) 2 2 Flex (80-Bit) Focus (40-Bit) Focus (40-Bit) 2 Fusion (40-Bit) Fusion (40-Bit) 2 2 Fusion (80-Bit) Mustang (40-Bit) 2 Mustang (40-Bit) 2 2 7[4] 7[4] Mustang (80-Bit) 2 Mustang (80-Bit) 2 Sport Trac Taurus (40-Bit) Taurus (40-Bit) Taurus (80-Bit) Taurus X 8[4] 8[4] Transit Connect (40-Bit) (W/ Power Locks) Transit Connect (40-Bit) (W/O Power Locks) 5 5 5 5 Transit Connect (80-Bit) (W/ Power Locks) Transit Connect (80-Bit) (W/O Power Locks) 5 5 5 Lincoln 8 7 6 5 4 3 2 0 09 08 Mark LT 9[4] MKS 2 2 MKS 2 2 MKX 2 2 2 MKZ MKZ 2 2 Navigator 3[4] 3[4] 3[4] 3[4] 3[4] 3[4] 0[4] Mercury 8 7 6 5 4 3 2 0 09 08 Grand Marquis 6[4] 6[4] Mariner 2 Mariner 2 2 2 Mariner Hybrid 2 Mariner Hybrid 2 2 2 Milan Milan 2 2 Mountaineer Sable 2 2 [4] Vehicles with install Type 3, 4, 6, 7, 8, 9, 0 & are NOT compatible with optional T-Harness THFC. Legend: DL: OE Door Lock & Alarm Controls PK: Transponder & Immobilizer Override SS: Integrated Security & Monitoring FOB: Sync CAN Interface w/ FOB Remote RS: Remote Start & Engine Controls ST: Function/Feature Status PK-Immobilizer Bypass-Data No Key Req'd DL-Arm Factory Security DL-Disarm Factory Security DL-Door Lock Control DL-Door Unlock DL-Trunk / Hatch Release Ford Key2Go (40-bit keys only) Key2GO RS-3x LOCK START (Start control using OEM Remote) RS-3x LOCK STOP (Stop control using OEM Remote) RS-RAP Shut Down (Retained ACC Power) RS-Remote Start Takeover RS-SmartStart SS-Entry Monitoring ALL Door Pins SS-Entry Monitoring Hood Pin SS-Entry Monitoring Trunk/Hatch Pin SS-Factory Alarm Trigger Monitoring ST-Brake Status (foot brake) ST-Door Locks Status ST-E-Brake Status ST-Ignition Status 5 Directed Digital Solutions FORD6
Wiring connections The wiring connections listed below are specific to this firmware. Main power harness (H), 2-pin thick gauge connector Conn./Pin Color Description H/ White Relay 3 COM (+) Parking Light Output H/2 White/Brown Relay 3 N.O. (+) 2V Input H/3 Brown/Red Relay 2 N.O. (-) Ground H/4 Yellow/Red Relay 2 COM RAP Off Interrupt or (-) RAP Off Output H/5 Orange/Red Relay 2 N.C. RAP Off Interrupt H/6 Yellow Relay COM (+) Ignition Output H/7 White Relay 3 COM (+) Parking Light Output H/8 White/Brown Relay 3 N.O. (+) 2V Input H/9 Black (-) Ground H/0 Red (+) 2 Volt (Battery) H/ Orange/Yellow Relay N.C. No Connection H/2 Brown Relay N.O. (+) 2V Input Auxiliary output harness (H2), 6-pin black connector Conn./Pin Color Description H2/ Violet/Brown No Connection H2/2 Yellow/Black Data TX H2/3 Orange/Black Data RX H2/4 Tan MS CAN Low H2/5 Tan/Black MS CAN High H2/6 Light Green No Connection H2/7 Orange/Green HS CAN Low H2/8 Orange/Brown HS CAN High H2/9 Violet/Green No Connection H2/0 Green/Black No Connection H2/ White/Violet No Connection 2 H2/2 White/Red (+) Accessory/Keysense Output 2 H2/3 Lt. Blue/Black (-) Factory Alarm Disarm 2 H2/4 Green/Red (+) Starter Output 2 H2/5 N/A No Connection H2/6 Violet/Yellow No Connection. If these outputs are not used by the firmware, they can be configured by the installer when the module is flashed. 2. If these outputs are not used by the firmware, they can be configured by the installer when the module is flashed. Note that they are low current and a relay may be necessary. 6 Directed Digital Solutions FORD6
Analog harness (H3), 8-pin white connector Conn./Pin Color Description H3/ Lt. Blue/Red No Connection H3/2 Black/White (-) Parking Brake Input (Manual Transmission) 2 H3/3 Gray (-) Hood Pin Input 2 H3/4 N/A No Connection H3/5 Gray/Black (+) Glow Plug Input 2 H3/6 Violet/White (AC) Tach Input 2 H3/7 Dark Blue (-) Unlock Output H3/8 Brown/Black (-) Horn H3/9 Red/White (-) Trunk Release Output H3/0 White/Green (-) Door Input 2 H3/ Yellow/Green (+) Door Input 2 H3/2 Blue/Red No Connection H3/3 Light Blue (-) Trunk Trigger Input 2 H3/4 Pink/Yellow (-) Activation (Start Trigger) Input H3/5 Dark Green (-) Lock Output H3/6 Brown/White (+) Brake Input 2 H3/7 Brown (+) Siren Output H3/8 Blue/White (-) Ground When Running (Status) Output MC50 harness (H4), 8 thick-gauge wires (optional) Conn./Pin Color Description H4/ Pink/White No Connection H4/2 Red/White No Connection H4/3 Pink No Connection H4/4 Red No Connection H4/5 Orange No Connection H4/6 Red No Connection H4/7 Green No Connection H4/8 Violet No Connection. If these outputs are not used by the firmware, they can be configured by the installer when the module is flashed. Note that they are low current and a relay may be necessary. 2. These connections are only required if the corresponding statuses are not supported by the firmware. See "Vehicle application guide" on page 5 for a list of compatible features. 3. If these outputs are not used by the firmware, they can be configured by the installer when the module is flashed. 4. The Green wire is only required for starter kill and anti-grind applications. 7 Directed Digital Solutions FORD6
Installation (wiring diagrams & vehicle wiring reference charts) Type with T-Harness (THFC) Refer to "Pre-installation and application warnings" on page 4 for important information, such as the description of each special note referenced in the diagram ( ). Ignition Barrel Ignition Switch Connector (connector side) RAP Off Interrupt: Yellow/Red P.A.T.S. - 4-pin Connector (connector side) Rap Off Output: Orange/Red (+) Parking Light Output: White (+) 2V Input: Yellow Relays Remote Start Safety Override Switch Driver Door Trigger Cut Refer to the Vehicle wiring reference charts for wire and connector details related to the standard connections in the vehicle. OBDII Diagnostic (connector side view) MS CAN High: pin 3 9 MS CAN Low: pin HS CAN High: pin 6 8 6 HS CAN Low: pin 4 Hood Pin Siren MS CAN Low: Tan MS CAN High: Tan/Black HS CAN High: Orange/Green HS CAN Low: Orange/Brown 6-pin Black Connector (-) Hood Pin Input: Gray: 3 (AC) Tach Input: Violet/White: 6 (-) Unlock Output: Dk. Blue: 7 (-) Trunk/Hatch Release / Power Liftgate Output: Red/White: 9 (-) Lock Output: Dk. Green: 5 (+) Siren Output: Brown: 7 2-pin Black Connector 2-pin White Connector The Remote Start Safety Override Switch MUST be in the ON position. THFC (optional T-Harness) 8 Directed Digital Solutions FORD6
Type Refer to "Pre-installation and application warnings" on page 4 for important information, such as the description of each special note referenced in the diagram ( ). (+) Ignition: Pin (+) 2V: Pin 4 2 3 4 5 6 7 Ignition Switch (black conn. at ign. switch) (+) Keysense: Pin 5 P.A.T.S. - 4-pin (at ignition switch) A Diode (+) Accessory: Pin 6 RX: pin 4 4 3 2 TX: pin 3 Data TX: Yellow/Black: 2 (+) Start: Pin 7 Data RX: Orange/Black: 3 MS CAN Low: Tan: 4 MS CAN High: Tan/Black: 5 MS CAN High: pin 3 9 MS CAN Low: pin HS CAN High: pin 6 8 6 HS CAN Low: pin 4 HS CAN High: Orange/Green: 7 HS CAN Low: Orange/Brown: 8 (+) Accessory/Keysense Ouput: White/Red: 2 (+) Starter Ouput: Green/Red: 4 Remote Start Safety Override Switch The Remote Start Safety Override Switch MUST be in the ON position. OBDII Diagnostic Connector, under Driver Dash (connector side view) Hood Pin (-) Hood Pin Input: Gray: 3 2: Brown: (+) 2V Input (AC) Tach Input: Violet/White: 6 0: Red: (+) 2V Input (-) Unlock Output: Dk. Blue: 7 (-) Trunk/Hatch Release / Power Liftgate Output: Red/White: 9 (-) Lock Output: Dk. Green: 5 (+) Siren Output: Brown: 7 9: Black: (-) Ground 6: Yellow: (+) Ignition Output 5: Orange/Red: RAP Off Interrupt 4: Yellow/Red: RAP Off Interrupt 2 & 8: White/Brown: (+) 2V Input & 7: White: (+) Parking Light Output Siren Refer to the Vehicle wiring reference charts for wire and connector details related to the standard connections in the vehicle. Driver Door Trigger Cut 9 Directed Digital Solutions FORD6
Vehicle wiring reference chart This section provides vehicle wiring information to guide you through the various stages of your installation. Refer to www.directechs.com for additional information. Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Edge 20-204 RX Violet/Gray 4 Data (PATS) connector. Black 4 A TX Yellow/Orange 3 Data (PATS) connector. Black 4 A Power Liftgate Gray/Yellow 6 (-) Power liftgate switch. Black 6 F 2V Green/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Yellow/Blue 6 (+) BCM in drivers kick panel. Gray 0 E HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 9 Cut BCM in drivers kick panel. Black 26 D Lock Blue/Green 6 (-) BCM in drivers kick panel. Black 26 D Unlock Yellow/Violet 8 (-) BCM in drivers kick panel. Black 26 D Tach Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown or Green/ White (AC) Any fuel injector. Black 2 N/A 0 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Expedition 205-207 RX Blue/Gray 4 Data (PATS) connector. Black 4 A TX Violet/Brown 3 Data (PATS) connector. Black 4 A 2V Green/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 9 Cut BCM in passenger kick panel. Black 26 J Hatch Release Brown 23 (-) BCM in passenger kick panel. Black 26 J Parking Lights Yellow/Green 8 (+) BCM in passenger kick panel. White 32 I Tach Green/Blue 84 (AC) PCM on passenger firewall. N/A 95 N/A Ford Explorer 2008-200 RX Violet/Gray 4 Data (PATS) connector. Black 4 A TX Yellow/Orange 3 Data (PATS) connector. Black 4 A 2V Violet/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Parking Lights Blue/White (+) Fuse/SJB under drivers dash. Brown 32 H Driver Door Trigger Green/Violet 7 Cut Fuse/SJB (Smart Junction Box) under drivers dash. Black 32 G Lock Gray/Yellow 27 (-) Fuse/SJB under drivers dash. Black 32 G Unlock Yellow/Violet 8 (-) Fuse/SJB under drivers dash. Black 32 G Tach Not Violet N/A (AC) Any fuel injector. N/A N/A N/A Tach Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown or Green/ White (AC) Any fuel injector. Black 2 N/A Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Explorer 20-205 RX Violet/Red or Violet 4 Data (PATS) connector. Black 4 A TX Yellow/Orange or Yellow 3 Data (PATS) connector. Black 4 A 2V Green/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Power Liftgate Gray/Yellow 7 (-) Power liftgate switch. Black 8 F Parking Lights Yellow/Blue 6 (+) BCM under drivers dash. Gray 0 H HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 9 Cut BCM under drivers dash. Black 26 G Lock Blue/Green 6 (-) BCM under drivers dash. Black 26 G Unlock Yellow/Violet 8 (-) BCM in passenger kick panel. Black 26 I Tach Ford F50 20-204 Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown or Green/ White (AC) Any fuel injector. Black 2 N/A RX Violet/Gray 4 Data (PATS) connector. Black 4 A TX Yellow/Orange 3 Data (PATS) connector. Black 4 A 2V Green/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Yellow/Blue 6 (+) BCM in passenger kick panel. Gray 0 J HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 9 Cut BCM (Body Control Module) in passenger kick panel. Black 26 I Lock Blue/Green 6 (-) BCM in passenger kick panel. Black 26 I Unlock Yellow/Violet 8 (-) BCM in passenger kick panel. Black 26 I Tach Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White, Gray/Brown or Violet/Orange (AC) Any fuel injector. Gray 2 N/A 2 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford F250 20-206 RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Blue/Red or Green/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Yellow/Blue 6 (+) SJB (Smart Junction Box) passenger kick panel. Gray 0 J HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 9 Cut SJB passenger kick panel. Black 26 I Lock Blue/Green 6 (-) SJB passenger kick panel. Black 26 I Unlock Yellow/Violet 8 (-) SJB passenger kick panel. Black 26 I Tach Blue N/A (AC) Customer Access Harness above driver kick, taped to wiring harness. On models without the Customer Access Harness, go to any fuel injector and use the wire that is not blue (gasoline), or use the camshaft position sensor, which is white/green at the Powertrain Control Module on passenger side of engine, middle, black 98 pin plug, pin 32 (diesel). Ford F350 20-206 Gray 2 N/A RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Blue/Red or Green/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Yellow/Blue 6 (+) SJB (Smart Junction Box) passenger kick panel. Gray 0 J HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 9 Cut SJB passenger kick panel. Black 26 I Lock Blue/Green 6 (-) SJB passenger kick panel. Black 26 I Unlock Yellow/Violet 8 (-) SJB passenger kick panel. Black 26 I Tach Blue N/A (AC) Customer Access Harness above driver kick, taped to wiring harness. On models without the Customer Access Harness, go to any fuel injector and use the wire that is not blue (gasoline), or use the camshaft position sensor, which is white/green at the Powertrain Control Module on passenger side of engine, middle, black 98 pin plug, pin 32 (diesel). Gray 2 N/A 3 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford F450 20-206 RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Blue/Red or Green/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Yellow/Blue 6 (+) SJB (Smart Junction Box) passenger kick panel. Gray 0 J HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 9 Cut SJB passenger kick panel. Black 26 I Lock Blue/Green 6 (-) SJB passenger kick panel. Black 26 I Unlock Yellow/Violet 8 (-) SJB passenger kick panel. Black 26 I Tach Blue N/A (AC) Customer Access Harness above driver kick, taped to wiring harness. On models without the Customer Access Harness, go to any fuel injector and use the wire that is not blue (gasoline), or use the camshaft position sensor, which is white/green at the Powertrain Control Module on passenger side of engine, middle, black 98 pin plug, pin 32 (diesel). Ford Flex 20-202 Gray 2 N/A RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) SJB (Smart Junction Box) under drivers dash. Gray 3 H HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut SJB under drivers dash. Gray 26 G Lock Blue/Green 7 (-) SJB under drivers dash. Gray 26 G Unlock Yellow/Violet 4 (-) SJB under drivers dash. Gray 26 G Power Liftgate Gray/Yellow N/A (-) Drivers kick panel harness to rear. N/A N/A K Tach Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White, Gray/Brown or Violet/Orange (AC) Any fuel injector. Gray 2 N/A 4 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Flex 203-208 RX Violet 4 Data (PATS) connector. Black 4 A TX Yellow 3 Data (PATS) connector. Black 4 A Power Liftgate Gray 6 (-) Power liftgate switch. Brown 6 F 2V Yellow/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Accessory Violet 6 (+) Ignition switch. Black 7 B Keysense Blue 5 (+) Ignition switch. Black 7 B Parking Lights Yellow/Blue 6 (+) BCM (Body Control Module) under drivers dash. Gray 0 H HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Violet 9 Cut BCM under drivers dash. Black 26 G Lock Blue 6 (-) BCM under drivers dash. Black 26 G Unlock Yellow 8 (-) BCM under drivers dash. Black 26 G Tach Ford Focus 2009-20 Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White, Gray/Brown or Violet/Orange (AC) Any fuel injector. Gray 2 N/A RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Brown/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange or Brown/ Yellow (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) SJB (Smart Junction Box) under drivers dash. Gray 3 H HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut SJB under drivers dash. Gray 26 G Trunk/Hatch Release Brown/Yellow 20 (-) SJB under drivers dash. Gray 26 G Lock Gray/Yellow 7 (-) SJB under drivers dash. Gray 26 G Unlock Violet/Gray 4 (-) SJB under drivers dash. Gray 26 G Tach Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange (AC) Any fuel injector. Black 2 N/A 5 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Fusion 200-202 RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Brown/Red or Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) Fuse/SJB (Smart Junction Box) under drivers dash. Gray 3 H HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut Fuse/SJB under drivers dash. Gray 26 G Trunk/Hatch Release Brown/Yellow 20 (-) Fuse/SJB under drivers dash. Gray 26 G Lock Gray/Yellow or Blue/Green 7 (-) Fuse/SJB under drivers dash. Gray 26 G Unlock Tach Ford Mustang 203-204 Violet/Gray or Yellow/ Violet Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White, Gray/Brown or Violet/Orange 4 (-) Fuse/SJB under drivers dash. Gray 26 G (AC) Any fuel injector. N/A 2 N/A RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Lt. Green/Violet or Blue/ Red 4 (+) Ignition switch. Black 7 B Ignition Gray/Violet (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) SJB (Smart Junction Box) in passenger kick panel. Gray 3 J HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut SJB in passenger kick panel. Gray 26 I Lock Blue/Green 7 (-) SJB in passenger kick panel. Gray 26 I Unlock Yellow/Violet 4 (-) SJB in passenger kick panel. Gray 26 I Trunk/Hatch Release Tach Brown/Yellow (Coupe); Brown/Yellow or Brown/ Violet (Convertible) Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White, Gray/Brown or Violet/Orange 20 (-) SJB in passenger kick panel. Gray 26 I (AC) Any fuel injector. Gray or Black 2 N/A 6 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Sport Trac 2008-200 RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Violet/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 7 Cut Fuse/SJB (Smart Junction Box) under drivers dash. Black 32 G Lock Gray/Yellow 6 (-) Fuse/SJB under drivers dash. Black 32 G Unlock Yellow/Violet 8 (-) Fuse/SJB under drivers dash. Black 32 G Tach NOT Violet N/A (AC) Any fuel injector. N/A N/A N/A Trunk/Hatch Release Brown 20 (-) Fuse/SJB under drivers dash. Gray 26 G Tach Ford Taurus 2008-2009 Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White (AC) Any fuel injector. N/A 2 N/A RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) Fuse/SJB (Smart Junction Box) under drivers dash. Gray 3 H HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut Fuse/SJB (Smart Junction Box) under drivers dash. Gray 26 G Lock Blue/Green 7 (-) Fuse/SJB under drivers dash. Gray 26 G Unlock Yellow/Violet 4 (-) Fuse/SJB under drivers dash. Gray 26 G Trunk/Hatch Release Brown 20 (-) Fuse/SJB under drivers dash. Gray 26 G Tach Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White (AC) Any fuel injector. N/A 2 N/A 7 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Taurus 200-202 RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) Fuse/SJB (Smart Junction Box) under drivers dash. Gray 3 H HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut Fuse/SJB under drivers dash. Gray 26 G Lock Blue/Green 7 (-) Fuse/SJB under drivers dash. Gray 26 G Unlock Yellow/Violet 4 (-) Fuse/SJB under drivers dash. Gray 26 G Trunk/Hatch Release Brown or Brown/Yellow 20 (-) Fuse/SJB under drivers dash. Gray 26 G Parking Lights Blue/White (+) Fuse/SJB under drivers dash. Brown 32 H Tach Ford Taurus 203-208 Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White (AC) Any fuel injector. Gray or Black 2 N/A RX Violet/Gray 4 Data (PATS) connector. Black 4 A TX Yellow/Orange 3 Data (PATS) connector. Black 4 A Trunk/Hatch Release Brown or Brown/Yellow 2 (-) Trunk release switch. Black 2 F Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Yellow/Blue 6 (+) BCM (Body Control Module) under drivers dash. Gray 0 H HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 9 Cut BCM under drivers dash. Black 26 G Lock Blue/Green 6 (-) BCM under drivers dash. Black 26 G Unlock Yellow/Violet 8 (-) BCM under drivers dash. Black 26 G 2V Red 6 (+) BCM under drivers dash. White 32 H Tach Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White (AC) Any fuel injector. White 2 N/A 8 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Transit Connect (with power locks) 200-203 RX White/Lt. Green 4 Data (PATS) connector. Black 4 A TX Gray/Orange 3 Data (PATS) connector. Black 4 A 2V Red 4 (+) Ignition switch. Black 7 B Starter Gray/Black or Orange/ Black 7 (+) Ignition switch. Black 7 B Ignition Green/Yellow (+) Ignition switch. Black 7 B Accessory Yellow 6 (+) Ignition switch. Black 7 B Keysense Black/Red 5 (+) Ignition switch. Black 7 B Parking Lights Orange/Yellow 3 (+) Headlight switch. Black 6 F HS CAN High Gray/Red 6 Data OBDII. Black 6 C HS CAN Low Blue/Red 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Blue/Black Data OBDII. Black 6 C Driver Door Trigger Black/Yellow 8 (-) GEM (Generic Electronic Module) behind dash fuse box. Gray 23 G Lock Black/Orange 0 (-) GEM behind dash fuse box. Green 23 H Unlock Black/Green (-) GEM behind dash fuse box. Green 23 H Tach Lincoln MKZ 200-202 Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange (AC) Any fuel injector. Black 2 N/A RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) Fuse/SJB (Smart Junction Box) under drivers dash. Gray 3 H HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut Fuse/SJB under drivers dash. Gray 26 G Lock Gray/Yellow or Blue/Green 7 (-) Fuse/SJB under drivers dash. Gray 26 G Unlock Trunk/Hatch Release Tach Violet/Gray or Yellow/ Violet Gray/Yellow or Brown/ Yellow Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White 4 (-) Fuse/SJB under drivers dash. Gray 26 G 20 (-) Fuse/SJB under drivers dash. Gray 26 G (AC) Any fuel injector. N/A 2 N/A 9 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Mercury Milan 200-20 RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) Fuse/SJB (Smart Junction Box) under drivers dash. Gray 3 H HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut Fuse/SJB under drivers dash. Gray 26 G Lock Blue/Green 7 (-) Fuse/SJB under drivers dash. Gray 26 G Unlock Yellow/Violet 4 (-) Fuse/SJB under drivers dash. Gray 26 G Trunk/Hatch Release Brown/Yellow 20 (-) Fuse/SJB under drivers dash. Gray 26 G Tach Mercury Mountaineer 2008-200 Green/Blue, Gray/Yellow, Violet/Gray, Yellow/ Orange, Brown, Green/ White (AC) Any fuel injector. N/A 2 N/A RX Violet/Gray 4 Data (PATS) connector. Black 4 A TX Yellow/Orange 3 Data (PATS) connector. Black 4 A 2V Violet/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Keysense Blue/Gray 5 (+) Ignition switch. Black 7 B HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Parking Lights Blue/White (+) Fuse/SJB (Smart Junction Box) under drivers dash. Brown 32 G Driver Door Trigger Green/Violet 7 Cut Fuse/SJB under drivers dash. Black 32 H Lock Gray/Yellow 27 (-) Fuse/SJB under drivers dash. Black 32 H Unlock Violet/Gray 26 (-) Fuse/SJB under drivers dash. Black 32 H Trunk/Hatch Release Brown 29 (-) Fuse/SJB under drivers dash. Black 32 H Tach NOT Violet N/A (AC) Any fuel injector. N/A N/A N/A 20 Directed Digital Solutions FORD6
Type 2 with T-Harness (THFC) Refer to "Pre-installation and application warnings" on page 4 for important information, such as the description of each special note referenced in the diagram ( ). Ignition Barrel Ignition Switch Connector (connector side) RAP Off Interrupt: Yellow/Red Rap Off Interrupt: Orange/Red P.A.T.S. - 4-pin Connector (connector side) (+) Parking Light Output: White (+) 2V Input: Yellow Relays Remote Start Safety Override Switch Driver Door Trigger Cut Refer to the Vehicle wiring reference charts for wire and connector details related to the standard connections in the vehicle. MS CAN High: pin 3 OBDII Diagnostic (connector side view) 9 MS CAN Low: pin HS CAN High: pin 6 8 6 HS CAN Low: pin 4 Hood Pin Siren MS CAN Low: Tan MS CAN High: Tan/Black HS CAN High: Orange/Green HS CAN Low: Orange/Brown 6-pin Black Connector (-) Hood Pin Input: Gray: 3 (AC) Tach Input: Violet/White: 6 (-) Unlock Output: Dk. Blue: 7 (-) Trunk/Hatch Release / Power Liftgate Output: Red/White: 9 (-) Lock Output: Dk. Green: 5 (+) Siren Output: Brown: 7 2-pin Black Connector 2-pin White Connector The Remote Start Safety Override Switch MUST be in the ON position. THFC (optional T-Harness) 2 Directed Digital Solutions FORD6
Type 2 Refer to "Pre-installation and application warnings" on page 4 for important information, such as the description of each special note referenced in the diagram ( ). (+) Ignition: Pin (+) 2V: Pin 4 P.A.T.S. - 4-pin (at ignition switch) 2 3 4 5 6 7 (+) Accessory: Pin 6 Ignition Switch (black conn. at ign. switch) RX: Pin 4 4 3 TX: Pin 3 (+) Start: Pin 7 2 Data TX: Yellow/Black: 2 Data RX: Orange/Black: 3 MS CAN Low: Tan: 4 MS CAN High: Pin 3 HS CAN High: Pin 6 MS CAN High: Tan/Black: 5 HS CAN High: Orange/Green: 7 HS CAN Low: Orange/Brown: 8 (+) Accessory Ouput: White/Red: 2 (-) Factory Alarm Disarm Output: Lt. Green/Black: 3 Remote Start Safety Override Switch 9 MS CAN Low: Pin 8 6 HS CAN Low: Pin 4 (+) Starter Ouput: Green/Red: 4 The Remote Start Safety Override Switch MUST be in the ON position. OBDII Diagnostic (connector side view) Hood Pin (-) Hood Pin Input: Gray: 3 2: Brown: (+) 2V Input (AC) Tach Input: Violet/White: 6 0: Red: (+) 2V Input (-) Unlock Output: Dk. Blue: 7 9: Black: (-) Ground (-) Trunk/Hatch Release / Power Liftgate Output: Red/White: 9 (-) Lock Output: Dk. Green: 5 (+) Siren Output: Brown: 7 6: Yellow: (+) Ignition Output 5: Orange/Red: RAP Off Interrupt 4: Yellow/Red: RAP Off Interrupt 2 & 8: White/Brown: (+) 2V Input & 7: White: (+) Parking Light Output Siren Refer to the Vehicle wiring reference charts for wire and connector details related to the standard connections in the vehicle. Driver Door Trigger Cut 22 Directed Digital Solutions FORD6
Vehicle wiring reference chart This section provides vehicle wiring information to guide you through the various stages of your installation. Refer to www.directechs.com for additional information. Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Edge 2008-200 RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut Fuse/SJB (Smart Junction Box) under drivers dash. Gray 26 D Factory Alarm Disarm Violet/Brown 8 (-) Fuse/SJB under drivers dash. Gray 26 D Parking Lights Violet/White 20 (+) Fuse/SJB under drivers dash. Black 32 E Tach Green/Blue, Gray/ Yellow, Violet/Gray, Yellow/Orange, Brown, Green/White (AC) Any fuel injector. N/A 2 N/A 23 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Escape 2008-202 RX Violet/Gray 4 or 3 TX Yellow/Orange 3 or 4 Data (PATS) connector. Black 4 A Data (PATS) connector. Black 4 A 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut SJB (Smart Junction Box) passenger side of the center console. Gray 26 F Trunk/Hatch Release Brown 7 (+) SJB passenger side of the center console. Gray 26 F Lock Blue/Green 7 (-) SJB passenger side of the center console. Gray 26 F Unlock Yellow/Violet 4 (-) SJB passenger side of the center console. Gray 26 F Parking Lights Violet/White 20 (+) SJB passenger side of the center console. Black 32 G Factory Alarm Disarm Violet/Brown N/A (-) Drivers kick panel, door harness. N/A N/A H Tach Ford Escape Hybrid 2008-202 Green/Blue, Gray/ Yellow, Violet/Gray, Yellow/Orange, Brown, Green/White RX Violet/Gray 4 or 3 TX Yellow/Orange 3 or 4 (AC) Any fuel injector. N/A 2 N/A Data (PATS) connector. Black 4 A Data (PATS) connector. Black 4 A 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut SJB (Smart Junction Box) passenger side of the center console. Gray 26 F Trunk/Hatch Release Brown 7 (+) SJB passenger side of the center console. Gray 26 F Lock Blue/Green 7 (-) SJB passenger side of the center console. Gray 26 F Unlock Yellow/Violet 4 (-) SJB passenger side of the center console. Gray 26 F Parking Lights Violet/White 20 (+) SJB passenger side of the center console. Black 32 G Factory Alarm Disarm Violet/Brown N/A (-) Drivers kick panel, door harness. N/A N/A H Tach Green/Blue, Gray/ Yellow, Violet/Gray, Yellow/Orange, Brown, Green/White (AC) Any fuel injector. N/A 2 N/A 24 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Flex 2009-200 RX Violet/Gray 4 Data (PATS) connector. Black 4 A TX Yellow/Orange 3 Data (PATS) connector. Black 4 A 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) SJB (Smart Junction Box) passenger side of the center console. Gray 3 G HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 F Driver Door Trigger Green/Violet 4 Cut SJB passenger side of the center console. Gray 26 F Trunk/Hatch Release Brown 7 (+) SJB passenger side of the center console. Gray 26 F Lock Blue/Green 7 (-) SJB passenger side of the center console. Gray 26 F Unlock Yellow/Violet 4 (-) SJB passenger side of the center console. Gray 26 F Factory Alarm Disarm Green/Violet 8 (-) SJB passenger side of the center console. Gray 26 F Tach Ford Focus 2008 Green/Blue, Gray/ Yellow, Violet/Gray, Yellow/Orange, Brown, Green/White (AC) Any fuel injector. N/A 2 N/A RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition Gray/Violet (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) SJB (Smart Junction Box) under drivers dash. Gray 3 E HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut SJB (Smart Junction Box) under drivers dash. Gray 26 D Trunk/Hatch Release Brown 20 (-) SJB under drivers dash. Gray 26 D Lock Blue/Green 7 (-) SJB under drivers dash. Gray 26 D Unlock Yellow/Violet 4 (-) SJB under drivers dash. Gray 26 D Factory Alarm Disarm Violet/Brown 8 (-) SJB under drivers dash. Gray 26 D Tach Green/Blue, Gray/ Yellow, Violet/Gray, Yellow/Orange (AC) Any fuel injector. Black 2 N/A 25 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Ford Fusion 2008-2009 RX Violet/Gray 4 Data (PATS) connector. Black 4 A TX Yellow/Orange 3 Data (PATS) connector. Black 4 A Trunk/Hatch Release Brown 5 (-) Trunk release switch. Black 6 I 2V Brown/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Parking Lights Gray/Yellow 3 (+) Fuse/SJB (Smart Junction Box) under drivers dash. Brown 32 D Driver Door Trigger Green/Violet Cut Fuse/SJB under drivers dash. Black 32 D Lock Gray/Yellow 4 (-) Fuse/SJB under drivers dash. Black 32 D Unlock Violet/Gray 0 (-) Fuse/SJB under drivers dash. Black 32 D Factory Alarm Disarm Violet/Brown 5 (-) Fuse/SJB under drivers dash. Black 32 D Tach NOT Violet N/A (AC) NOT White/Blue (2.3L, 3.0L), NOT Violet/Green (3.5L) N/A N/A N/A Ford Mustang 200-202 RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Lt. Green/Violet or Blue/Red 4 (+) Ignition switch. Black 7 B Ignition Gray/Violet (+) Ignition switch. Black 7 B Parking Lights Violet/White 6 (+) SJB (Smart Junction Box) in passenger kick panel. Gray 3 K HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut SJB in passenger kick panel. Gray 26 J Lock Blue/Green 7 (-) SJB in passenger kick panel. Gray 26 J Unlock Yellow/Violet 4 (-) SJB in passenger kick panel. Gray 26 J Trunk/Hatch Release Brown/Yellow (Coupe); Brown/ Yellow or Brown/Violet (Convertible) 20 (-) SJB in passenger kick panel. Gray 26 J Factory Alarm Disarm Green/Violet 8 (-) SJB in passenger kick panel. Gray 26 J Tach Green/Blue, Gray/ Yellow, Violet/Gray, Yellow/Orange, Brown, Green/White, Gray/Brown or Violet/ Orange (AC) Any fuel injector. Gray or Black 2 N/A 26 Directed Digital Solutions FORD6
Wire Information Connector Information Function Color Pin Polarity Location Color Pins Ref. Lincoln MKS 2009-202 RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B Factory Alarm Disarm Green/Violet 2 (-) DDM (Drivers Door Module) in drivers door. Gray 2 L Parking Lights Violet/White 6 (+) Fuse/SJB (Smart Junction Box) under drivers dash. Gray 3 E HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut Fuse/SJB under drivers dash. Gray 26 D Lock Unlock Trunk/Hatch Release Tach Lincoln MKX 2008-200 Gray/Yellow or Blue/ Green Violet/Gray or Yellow/Violet Gray/Yellow or Brown/Yellow Green/Blue, Gray/ Yellow, Violet/Gray, Yellow/Orange, Brown, Green/White 7 (-) Fuse/SJB under drivers dash. Gray 26 D 4 (-) Fuse/SJB under drivers dash. Gray 26 D 20 (-) Fuse/SJB under drivers dash. Gray 26 D (AC) Any fuel injector. Gray or Black 2 N/A RX Yellow/Orange 4 Data (PATS) connector. Black 4 A TX Violet/Gray 3 Data (PATS) connector. Black 4 A Power Liftgate Gray/Yellow 5 (-) Power liftgate switch. Black 6 I 2V Blue/Red 4 (+) Ignition switch. Black 7 B Ignition White/Orange (+) Ignition switch. Black 7 B HS CAN High White/Blue 6 Data OBDII. Black 6 C HS CAN Low White 4 Data OBDII. Black 6 C MS CAN High Gray/Orange 3 Data OBDII. Black 6 C MS CAN Low Violet/Orange Data OBDII. Black 6 C Driver Door Trigger Green/Violet 4 Cut Fuse/SJB (Smart Junction Box) under drivers dash. Gray 26 D Lock Gray/Yellow 7 (-) Fuse/SJB under drivers dash. Gray 26 D Unlock Violet/Gray 4 (-) Fuse/SJB under drivers dash. Gray 26 D Factory Alarm Disarm Green/Violet 8 (-) Fuse/SJB under drivers dash. Gray 26 D Parking Lights Violet/White 30 (+) Fuse/SJB under drivers dash. Black 32 D Tach Green/Blue, Gray/ Yellow, Violet/Gray, Yellow/Orange, Brown, Green/White (AC) Any fuel injector. Gray or Black 2 N/A 27 Directed Digital Solutions FORD6