Zip's Truck Equipment 316 W. Milwaukee Street New Hampton, Iowa 50659 Phone: 641-394-3166 Fax: 641-394-4044 Visual Inspection Page: 1 of 6 Customer: Address: Equipment Type: Light-Duty Tow Truck Division: null Phone: Reference #: 1GBJK39103E269025 Order #: Event Performed: Light Duty Wrecker Inspection Inspected On: 08/09/16 2:48 PM CDT Result: Pass Total Score: Inspected By: : Iowa Shop Service Tech 1 Light-Duty Tow Truck- * Year: 2003 * Make: Chevrolet * Model: 3500EC 4x4 * Drive Type: 4 Wheel Drive * Engine Make: Duramax * Engine Model: 6.6L * Fuel Type: Diesel * Transmission Type: Automatic * Odometer Reading:? * GVW: 12,000# * GAWR Front: 4,899# * GAWR Rear: 8,600# * Cab Trim Package: Silverado * Cab to : 60" * Wheel Base: 160" Wheel Type: * Cab Color ONLY: White * Body Make: Century * Body Model: 412 Body Width: 86" * Beacon/Lightbar Make: * Beacon/Lightbar Model: PTO Type: Switch Panel & # Of Switches: Stainless Steel Wheel Simulators Federal Signal JetStream Hot Shift In Dash - 5 * Wrecker Body/Pylon Color: Red * Brake Type: Hydraulic * Suspension Type: Spring * Air ing: * Radio: AM/FM/CD * Driver Seat: Rear Passenger Seat: Windows: Door Locks: Window Deflectors: Cruise Control: Tilt Steering Wheel: Flooring: Floor Mats: Bug Shield: Split Cloth w/head Rests & Center Console Cloth Bench w/head Rests Power Power Rubber or Vinyl Rubber or Vinyl * Bumper: Chrome Grille: Chrome Front Tow Hooks: 2 Jumper Cable Plug/Where: Cab Fenders: Mirrors: Cab Roof Marker Lights: Fiberglass Fenderettes Power Swing Out * Tire Size-Front: LT215/85R16 Tire Depth-Front: 5/32" * Tire Size-Rear: LT215/85R16
Page: 2 of 6 Tire Depth-Rear: 12/32" * Tow Sling: # of Winches: 2 Winch Brand: Winch Clutch Release: Cable Tensioner: Pylon: Work Lights: Toolbox System: Dual Controls: Rear Safety Chains: Light Plug Ins: Hook Up Lights: Ramsey Standard Steel LH & RH CR6 * Wheel Lift: Wheel Lift Style: Aluminum Rail Caps: # Of Mounted D- Rings/Where: Straps/Rachets: Tow Light System: Basic L-Arm Style 2 - Tailboard Tow Light Kit Engine Check Ability to Start Engine Blow-By Check Engine Engine Noise Engine Warning Lights Engine Water Leaks Performance Engine Mounts Other Engine Engine Brake Starts No Noticeable Blow-By Issue Engine sounds are normal -Leak left side Replaced leaking power booster. -It is on -There is a bad water leak Batteries of Cables of Batteries Load Testing Pass Water pump was leaking replaced. -Do not go to far with the water leak -Need to clean Cooling System Radiator Fan Fan Clutch Fan Shroud Water Hoses Fan Belt Other Cooling Automatic Transmission Check Automatic Transmission Check Transmission Operation Other Transmission Manual Transmission Check Shifting Clutch Operation Throw-Out Bearing Transmission Noise Other Transmission Overall Body Other Overall Body notes Poor -I could only yard drive because of the water and brake trouble 4/4 seemed ok,tranny shifted ok Cab Exterior Hood Right Fender Left Fender Grille Back of Cab Driver Side Door Passenger Side Door Roof Other Cab Exterior Fuel Tank Appearance Entry Steps Head-Light Doors Battery Box Driver Side Door Hinges Passenger Side Door Hinges -Both rocker panels are rusted out also the cab floor is rusted Removed doors and removed and replaced rockers inner rockers and cab corners. -Rust spot by the latch -Rusted on the bottom Replaced. -Rusted on the bottom Fenderette is loose Replaced fender. -Both bottom corners are rusted out Replaced cab corners. -Some rust on the inside bottom -Some rust on the inside bottomp -Both extended cab doors have a lot of rust on the bottom Both rear doors don't open Front bumper down on left side Removed both rear doors and installed used ones Glass Windshield Driver Side Window Passenger Side Windw Back Window Other Glass Overall Interior Other Overall Interior Good -It has big scratches left side -It goes up slow Interior Drivers Seat -Needs repair
Page: 3 of 6 Interior Passenger Seat Rear Seat Floor Mat Instrument Cluster Dash Door Panels Electric Door Locks Electric Windows Other Interior Air Vents Door Handles Other Interior Good Fair Operate Properly -Rear door latchs don't work Replaced doors. Windshield Wipers Wiper Arms Wiper Blades Washer Tank Washer Control Switch -Center console lid is broke Heating Heater Controls Fan Motor Heater Other Heat Excellent Heats Appropriately Air ing Air ing Controls Electrical System- Chassis Interior lights Turn Signals Head Lights Alternator Guages Dash Lights Cab Marker Lights Back-Up Lights Back-Up Alarm 4-Way Flashers Windshield Wipers Other Electrical System Cruise Control Engine Throttle All Interior Light Operate Operate All Gauges Perform Properly Operate Perform -Right side the outer part of the bulb fell off -Some are out -One on top of cab and one right front don't work Drive-Line U-Joints Rear Differential Transfer Case In good condition -The mileage don't show up on dash Drive-Line Other Drive-Line Hangar Bearings Brakes Air Compressor System Air Leaks Applied Brakes Brake Adjusters Air Lines Low Air Pressure Warning Front Brake Drums Pusher Brake Drums Front Brake Calipers Front Drive Brake Drums Front Brake Linings Rear Drive Brake Drums Rear Brake Calipers Pusher Brake Linings Front Drive Brake Linings Rear Drive Brake Linings Emergency Brake ABS Light Brake Pedal Pads Other Brake Air Dryer Brake apply normally 50% or Better Showing Normal (Not on) Worn -They are rusty But still functional -They are rusty Replaced. -Have to pull wheels to check Pads are good. Installed new cable from cab back and to both rear brakes. -A brake light is on Wheels Front Rims/Wheels Pusher Rims/Wheels Front Drive Rims/Wheels Rear Drive Rims/Wheels Fronts Nut and Studs Pusher Nut and Studs Wheel In Good Wheel In Good Front Drive Nuts and Studs (2) (2) Rear Drive Nuts and Studs Wheel Simulators Front In Fair Wheel Simulators Pusher Wheel Simulators Front Drive Wheel Simulators Rear Drive Aluminum Wheels Front Aluminum Wheels Pusher Aluminum Wheels Front Drive Aluminum Wheels Rear Drive Wheel Hubs -There is a leak by the left front under the cab Replaced two lines from master cylinder to brake valve.
Page: 4 of 6 Wheel Hubs Front Wheel Seals Front Drive Wheel Bearings Front Wheel Bearings Pusher Wheel Seals Front Drive Wheel Seals Oil Filled Hubs Front Drive Rear Drive Wheel Seals Oil Filled Hubs Front Pusher Wheel Bearings Oil Filled Hubs Pusher Oil Filled Hubs Rear Drive Rear Drive Wheel Bearings Not Adjusted but No Issue Visible Checked In Good Tires Front Pusher Front Drive Rear Drive on Tires -10% -60% Exhaust Systen Manifold Exhaust Tubing Muffler DPF System Emnsions Warning Light Exhaust Shield Exhaust Stack Exhaust Mounting Bracket -One broke on rear Frame Integrity of Frame -It is rusty Suspension Air Bags Air Leaks Air Lines Spring Packs -Rear has broken overload springs both sides Steering and Front Pitman Arm Drag Link Tie Rod Toe in Check 4x4 Hubs -Ds rear wheel seal leaking installed new wheel seal. Steering Wheel Steering Wheel Position Not Checked Wheel In Good Condtion -It is loose -It is loose -Have to drive Fuel System Fuel Gauge Fuel Tank Fuel Fill Fuel Lines Fuel Filter Glow Plugs or Exhaust Heater Glow Plug Operation Intake Manifold Heater Works Fills Not Replaced Fluids Windshield Washer Engine Oil Radiator Anti-Freeze Transmission Fluid Transfer Case Oil Front Drive Rear Drive Battery Acid Levels Hydraulic Oil Brake Fluid Power Steering Fluid Not Checked also check to -20-20 also check front differential Front Spring Hangars Rear Spring Hangars Radius Arms Rear Suspension Bushings Air Leveling Valve Steering and Front Steering Pump Steering Lines Steering Sector King Pins/Ball Joints Steering Shaft -The steering has a growling noise Low on power steering fluid. Winch 1 Oil Winch 2 Oil Winch 3 (Above Cab) Oil Filters Water Filter Engine Oil Filter Transmission Oil Filter Fuel Filter Carrier Hydraulic System Overall Wrecker Body Overall Condtion Not Changed Poor
Page: 5 of 6 Wrecker Body Body Sides Condtion Body Deck Front of Body Conditon Body Side Side Rail Cap Conditon (2) Driver Side Tool Box 1 Conditon Passenger Side Tool Box 1 Conditon Tunnel Tool Box 1 Conditon Tail-Board -A lot of paint missing -A lot of rust and paint missing, the wrecker is in bad shape all rusty -Paint missing Power Take-Off Operation PTO Warning Light No -Left side has a big dent in the rear corner -A lot of rust and paint chipping D rings are froze -One light don't work Cylinder Conditon Boom Extend Cylinder Wheel-Lift Extend Cylinder Wheel-Lift Tilt Cylinder Wheel-Lift Lift Cylinder Wheel-Lift Lift Claw Cylinders -Has some rust on shaft Pylon -Has a lot rust Winch Free-Wheel Mechanism Winch 1 Free-Wheel Mechanism Winch 2 Free-Wheel Mechanism Winch 3 Housing Winch 1 Housing Winch 2 -Left has a small leak Replaced seal and paper gasket. Shifting Mechanism Electrical Switch Working Properly Housing Winch 3 Operation Without Load Air Leaks Hyraulic Pump Operation Pump Pressure Pump Flow No Pump Not Tested Controls & Valve Operation Control Levers and Rods Knobs Hydraulic System Hoses Hydraulic System Leaks Winch Hoses Boom Lift Cylinder Hoses Boom Extension Cylinder Hoses Wheel-Lift Tilt Cylinder Hoses Wheel-Lift Extend Cylinder Hoses (2) Wheel-Lift Up/Down Cylinder Hoses (2) Hydraulic Pump Hoses Hydraulic Filter Bed Lift Cylinders Extend Cylinder Wheel-Lift Tilt Cylinder Wheel-Lift Extend Cylinder Wheel-Lift Claw Cylinder Drivers Side Wheel-Lift Claw Cylinder Passenger Side In Operating No No No No No No No No -There is a leak at valve Replaced o ring on valve cap. -Some stick others are loose -Decals are worn off -Tilt don't work Cylinder Conditon Boom Lift Cylinder Operation Without Load Test Operation Loaded Test Operation Winch 1 Cable Winch 2 Cable Winch 3 Cable -No good -No good Wheel-Lift L-Arms/Scoops L-Arm Straps L-Arm Storage Driver Side Claw Passenger Side Claw Driver Side Slide Tray Passenger Side Slide Tray Passenger Side Slide Tray Locks Driver Side Slide Tray Locks Driver Side Front Stops (Vulcan) Passenger Side Front Stops (Vulcan) Driver Side L-Arm Swivel Passenger Side L-Arm Swivel Center Pivot Pin and Bushing Wheel-Lift Cross-Bar Pins and Bushings Extension Tube Outer Wheel-Lift Assembly Wheel-Lift Swivel Lock Pins In Fair Condtion In Fair In Fair In Fair Conditon In Fair Conditon -All rusty Replaced -Will not move -Will not move -Froze -Froze
Page: 6 of 6 Wheel-Lift Wheel-Lift Swive Removeable Lock Pins Scoop Locking Pins and Chains Driver Side Claw Cylinders Main Pivot Pin for Tilting Wrecker Electrical Systems Switch Panel Overall Wiring Bed Wiring Harness Junction Boxes Marker Lights Driver Side Turn Signals Upper Passenger Side Turn Signals Upper Driver Side Turn Signals Upper Lower Passenger Side Turn Signals Lower Extra Warning Lights Extra Clearance Lights UpperWork Lights Lower Work Lights Exposed or Patched Wiring -Tilt don't work -One 3ID is out Replaced light bulbs. -L6 don't work Installed new upper flood lights as old ones where all rusted out. Installed new 4411 bulbs. Fixed grounds. Chains J-Hook Chains -They are missing Tow Sling Sling Arms Sling Belts Top Lift Bar Lower Lift Bar Chassis Lubrication King Pins/Ball Joints Tie-Rod Ends Drag Link Steering Shaft Drive-Line U-Joints Spring Shackles Door Locks and HInges Wrecker Mounting System Front Bed Mounting Brackets Rear Bed Mounting Brackets (2) Brackets and Bolts in Good Brackets and Bolts in Good -The locks are froze -Need to lube Shock Absorbers Front Shocks Rear Shocks -Left leaks Work Lights Mounted Near Winch Beacon Light 2 Beacon Light 3 Beacon Light 1 Tow Light Plug at Tail-Board Not Checked Tool Boxes Box Driver Side 1 -Hinge is rusty latch don't work Box Driver Side 2 Box Passenger Side 1 -Hinge is rusty latch don't work Box Passenger Side 2 Fenderettes Drivers Side Passenger Side Wrecker Lubrication Lift Cylinder Pins Tilt Cylinder Pins Wheel-lift Tilt Pin Wheel-Lift Cross-Bar Pivot Pin Upper Wheel-Lift Extension Slide Pads Lower Wheel-Lift Extension Slide Pads (2) Wheel-Lift Lift Tower Wear Pads Wheel-Lift Arm Pins and Bushings Tool Box Hinges and Latches -Need to lube Chains Rear Safety Chains -They are stuck in there holes