ac-00 hot surface ignition & i.i.d.spark ignition vertically fired gas convection oven REPLACEMENT PARTS LIST Effective june, 0 Superseding All Previous Parts Lists. The Company reserves the right to make substitution in the event that items specified are not available. ERRORS: Descriptive and/or typographic errors are subject to correction. BLODGETT OVEN COMPANY Lakeside Avenue, Burlington, Vermont 00 USA Telephone: (80) 8-00 Fax: (80) 80-7 www.blodgett.com P/N 07 Rev E
serial number location / KEY: IMPORTANT: When ordering parts, please provide the model, gas type and serial number of the oven. The identification plate is located on the left side of the combustion compartment and, also, above the control panel under the ledge. serial number identification code: rc / rf / re ASAP Distributor Required Stocking Parts Doors Are Not Returnable table of contents Side view... solid state manual controls... solid state digital controls... intelliplus controls... ch0 fast controls...7 gas manifold assy, units before //98... 8 gas manifold assy, units after //98... 9 door components, Single door option... 0 door components, double door option... Exterior views... interior view... exclusive to export... june, 0 Ac-00
side view - right hand OLD - Before 0/0/97 NEW - After 0/0/97 LOOK HERE FOR SERIAL NUMBER 9 LOOK HERE FOR SERIAL NUMBER 7 NOTE: Part is not depicted at actual size. **See NOTE below. NOTE: Part is not depicted at actual size. 08 Motor, V, / HP, PH, SP, 0 HZ (Qty ) Units before 0/0/97 790 Motor, V, / HP, PH, SP, 0 HZ (Qty ) Units after 0/0/97 0 Motor Adapter Bracket NOTE: For units before 0/0/97 this bracket will not fit the Howell Motor. 7 Terminal Block, AMP, 00V (Qty ) Axial Fan, V, " (Qty ) 7 Lug, Grounding & Screw (Qty ) 90 Dual Solenoid Valve/Pressure Regulator LP M9 Dual Solenoid Valve/Pressure Regulator NAT 8 Spring, Solenoid Valve, Nat to LP (Qty ) 007 Spring, Solenoid Valve, LP to Nat (Qty ) R Gas valve, manual R0 Knob, Square D, controls manual gas valve R90 Pilot Valve, Units after 0/0/97 7 807 Union, for thru pipe Units before 0/0/97 june, 0 Ac-00
solid state manual controls 0 7 8 9 7 08 Control - HSI Units before 0/0/97 or 08 Spark Box Units after 0/0/97 NOTE: Picture depicts Part 08 Spark Box. Please use serial number for correct part. 878 Controller, Temperature (Qty ) 07 Probe, Temperature (Qty ) 8 Potentiometer, Remote (Qty ) 8 Knob, Temperature (Qty ) 08 Mode Selector Switch ( Position) (Qty ) 8 Knob, Mode Selector (Qty ) 09 Buzzer, 0V (Qty ) 8 Timer, 0 Minute, 0V, 0 HZ (Qty ) 8 Knob, Timer (Qty ) 7 Thermal Switch SPDT, Units after 0/0/00 89 Switch, Momentary for lights (Push-Button) (Qty ) 7 89 Contact Block, Amp., 00V (Qty ) 8 8 Indicator Light, 8V, Red, Round (Qty ) 9 7 Transformer, 0V to V (Units before 0/0/97 use Qty and Units after 0/0/97 use Qty ) 0 77 Contactor, Pole, 0V Coil (Qty ) Units before 0/0/97 90 Relay Assy Units after 0/0/97 8 Decal, Lexan Control (Manual) (Qty ) R0 Knob, Square D, controls manual gas valve R Gas Valve, manual NOTE: Gas valves are pictured on page 08 Ignition Control, Hot Surface Ignition Units before 0/0/97 7 08 Spark Box Units after 0/0/97 june, 0 Ac-00
solid state digital controls key (pictured with lights) 7 8 77 Contactor Before //97 OR 90 Relay After //97 0 08 Ignition Control-HSI Units before 0/0/97 OR 08 Spark Box Units after 0/0/97 NOTE: Picture depicts Part 08 Spark Box. Please use serial number for correct part. 08 Controller, Time & Temperature (Qty ) 07 Probe, Temperature (Qty ) 8 Knob, Adjust Temperature (Qty ) 08 Mode Selector Switch ( Position) (Qty ) 8 Knob, Mode Selector (Qty ) 90 Light Switch, Rocker (Momentary) (Qty ) 7 Thermal Switch SPDT, Units after 0/0/00 7 Transformer, 0V to V (Units before 0/0/97 use Qty and Units after 0/0/97 use Qty ) 7 77 Contactor, Pole, 0V Coil (Qty ) Units before 0/0/97 8 90 Relay Assy (Qty ) Units after 0/0/97 0 08 Ignition Control, Hot Surface Ignition Units before 0/0/97 08 Spark Box Units after 0/0/97 R0 Knob, Square D, controls manual gas valve R Gas Valve, manual NOTE: Gas valves are pictured on page june, 0 Ac-00
intelliplus control key 7 8 77 Contactor Before 0/0/97 90 Relay After 0/0/97 08 Ignition Control HSI - Before 0/0/97 or 08 Spark Box - After 0/0/97 0 NOTE: Picture depicts Part 08 Spark Box. Please use serial number for correct part 90 Probe, Temperature (Qty ) 8 Knob, Control Time or Temperature (Qty ) 888 Mode Selector Switch ( Position) (Qty ) 8 Knob, Mode Selector (Qty ) 90 Light Switch, Rocker, Momentary (Qty ) 8 Indicator Light, 8V, Red, Round (Qty ) 7 Transformer, 0V to V (Units before 0/0/97 use Qty and Units after 0/0/97 use Qty ) 7 77 Contactor, Pole, 0V Coil (Qty ) Units before 0/0/97 8 90 Relay Assy (Qty. ) Units after 0/0/97 0 R0 Knob, Square D, controls manual gas valve R Gas Valve, manual Units before 0/0/97 R90 Pilot Valve Units after 0/0/97 NOTE: Gas valves are pictured on page 08 Ignition Control, Hot Surface Ignition Units before 0/0/97 08 Spark Box Units after 0/0/97 june, 0 Ac-00
ch0 fast controls key (with lights) 8 7 9 7087 Controller, CH0 ( Key) 90 Light Switch, Rocker, DPST, Momentary 8 Knob, Adjust (Qty ) 08 Mode Selector Switch ( Position) (Qty ) 7 Transformer, 0V to V (Qty ) 7 Thermal Switch SPDT, Units after 0/0/00 90 Relay Assy (Qty ) 7 08 Spark Box Assy, Nat & LP (Qty ) 89 Capacitor Assy, Snubber CH0 control 8 0 Control Panel & Decal Assy, CH0 9 R0 Knob, Square D, controls manual gas valve 79 Probe, K june, 0 7 Ac-00
gas manifold assembly Manufactured before //998 Serial Number 98RF008T Probe, Flame Sensing (Qty ) 09 Orifice, Main Burner, Nat (MTD #) (Qty ) 88 Orifice, Main Burner, LP (MTD #) (Qty ) 0 Relay & Hardware V, for Gas sytem shutoff june, 0 8 Ac-00
gas manifold assembly Manufactured after //998 Serial Number 98RF008T 09 Orifice, Main Burner, Nat (MTD #) (Qty ) 88 Orifice, Main Burner, LP (MTD #) (Qty ) M799 Elbow, Union Compression 8 Pilot Ignitor Assy (Qty ) 88 Tubing, Flex " (Qty ) M097 Pilot Orifice Nat (Qty ) M90 Pilot Orifice LP (Qty ) june, 0 9 Ac-00
door components single door option OLD - Before 0/0/97 NEW - After 0/0/97 8 7 9 Doors are not returnable AFTER JANUARY 0, 997 88 Door Assy, Glass (Qty ) R Handle R9 Catch & Latch Assy 07 Microswitch Assy, Pictured on page 907 Bracket, Door Switch 07 Arm, Door Upper &/or Lower (Qty ) 70 Nameplate Assy., Blodgett 0" (Qty ) BEFORE JANUARY 0, 997 7 79 Catch Assy, Door (Qty ) NOTE: One is located on the top of the door and the other is located on the bottom of the door 0 Plate, Striker Door Latch (Qty ) 0 Microswitch Assy, Door Pictured on page 8 88 Arm, Door Upper (Qty ) 9000 Bushings, Door Hinge (Set of ) 70 Nameplate Assy., Blodgett 0" (Qty ) june, 0 0 ac-00
door components specific to double door option 7 Door Assy, LH Glass (Qty ) Door Assy, RH Glass (Qty ) 7 Catch Assy, Door 70 Microswitch Assy 70 Gasket Assy, Center june, 0 ac-00
exterior components "old style" before 0/0/97 NOTE: The Microswitch is located behind this cover piece. june, 0 ac-00
exterior components "NEW style" AFTER 0/0/97 8 9 NOTE: The Microswitch is located behind this louvered cover piece. 789 Drafthood, Direct Venting, S/S (Qty ) 780 Draft Diverter, Canopy Venting, S/S (Qty ) 8 Installation Hose, " Installation Hose, 8" 9 Cord Set Assy, Feet (Qty ) 898 Legs, " w/ Bolts, S/S (Set of ) 9000 Studs, Leg (Set of ) 787 Bolts, Leg (Set of 8) 00 Casters (Sgl Oven) (Set of ) 98 Casters, Low Profile (Dbl Oven) (Set of ) BEFORE JANUARY 0, 997 097 Cover Assy, Combustion Compartment (Qty ) 097 Body Top, Front (Qty ) 078 Cover, Control (Qty ) AFTER JANUARY 0, 997 8 89 Body Side, RH S/S (Qty ) 9 07 Microswitch Assy, Door (Qty ) Units after 0/0/97 june, 0 ac-00
interior view 0988 Retainer, Probe Wire (Qty ) 077 Rack Support (Qty ) 07 Rack, Wire (7-/8" x -/") (Each) 09 Blower Wheel (Qty ) 7 Bulb, Light W, 0V, (Qty ) 79 Lens, Cover Light (Qty ) june, 0 ac-00
exclusive to export Motor, 0V, SP, 0/0 HZ 07 Indicator Light, 0V, Red, Round (Qty ) CE 008 Timer, 0 Minute, 0V, 0 HZ (Qty ) CE 88 Timer, Adjustable, 0V (Qty ) CE 89 Potentiometer, Control (Humidaire) CE (Qty ) 00 Buzzer, 0V (Qty ) CEE R Gas Valve, Manual /" (Qty ) CE 009 Control, Hot Surface Ignitor (Qty ) CE M8 Fitting, Pressure Tap (Qty ) CE june, 0 ac-00