INSTALLATION INSTRUCTIONS Accessory S Application 2009 PILOT (LX ONLY) Publications No. AII 39396 Issue Date MAY 2008 PARTS LIST Fog Lights Kit P/N 08V31-SZA-100B Left fog light Ground bolt Relay Right fog light TOOLS AND SUPPLIES REQUIRED Headlight switch Fog light harness Flat-tip screwdriver Phillips screwdriver Ratchet 10 mm Socket 10 mm Combination wrench Plastic trim tool (T/N SILTRIMTL10) Diagonal cutters Illustration of the Fog Lights Installed on the Vehicle 10 Wire ties RIGHT FOG LIGHT RELAY HEADLIGHT SWITCH 4 Spring nuts 4 Washer-bolts, 5 x 16 mm 701120AE LEFT FOG LIGHT 2008 American Honda Motor Co., Inc. All Rights Reserved. AII 39396 (0805) 08V31-SZA-1000-91 1 of 11

INSTALLATION Customer Information: The information in this installation instruction is intended for use only by skilled technicians who have the proper tools, equipment, and training to correctly and safely add equipment to your vehicle. These procedures should not be attempted by do-it-yourselfers. 4. Remove the cover from the left fog light lid (four retaining tabs). LEFT HEADLIGHT 1. Make sure you have the anti-theft code for the radio, then write down the radio station presets. 2. Disconnect the negative cable from the battery. Removing the Vehicle Parts (Outside of the Vehicle) 3. Remove the air intake box (two clips). 2 CLIPS AIR INTAKE BOX COVER 4 RETAINING TABS 8 CLIPS LEFT FOG LIGHT LID 701010BE 5. Remove the left fog light lid from the front bumper (eight clips). 6. Repeat steps 4 and 5 on the right side of the vehicle. 700401AB 2 of 11 AII 39396 (0805) 2008 American Honda Motor Co., Inc. All Rights Reserved.

Routing the Fog Light Harness 7. Find the vehicle 1-pin connector, and remove the blue tape to free the connector. 1-PIN RADIATOR RESERVOIR POWER STEERING RESERVOIR WASHER TANK 10. Secure the fog light harness ground terminal to the vehicle frame with one ground bolt. GROUND TERMINAL GROUND BOLT BLUE TAPE Remove. 1-PIN GROUND TERMINAL RIGHT 701012BE 11. Pull the fog light harness 2-pin connector (shorter position of the harness) out of the right fog light lid opening. PANEL 701011CE 8. Plug the fog light harness 1-pin connector to the vehicle 1-pin connector. 9. Route the fog light harness ground terminal to the underside of the vehicle. 2-PIN RIGHT CLIP 701013BE 12. Secure the fog light harness clip to the vehicle panel. 2008 American Honda Motor Co., Inc. All Rights Reserved. AII 39396 (0805) 3 of 11

13. Route the fog light harness 2-pin connector (longer position of the harness) along the vehicle harness. WASHER TANK 15. Route the fog light harness 2-pin connector (longer position of the harness) along the vehicle harness to left side of the vehicle as shown. 3 WIRE TIES 701102BE 14. Secure the fog light harness to the vehicle harness with three wire ties. 2-PIN 701101AE 4 of 11 AII 39396 (0805) 2008 American Honda Motor Co., Inc. All Rights Reserved.

16. Route the fog light harness 2-pin connector (longer position of the harness) to the underside of the vehicle. 18. Secure the fog light harness clip to the vehicle panel. 19. Secure the fog light harness to the vehicle harness with one wire tie. WIRE TIE 2-PIN 7D0401AE 17. Pull the fog light harness 2-pin connector out of the left fog light lid opening. 701104BE PANEL CLIP LEFT 2-PIN 701105BE 2008 American Honda Motor Co., Inc. All Rights Reserved. AII 39396 (0805) 5 of 11

20. Secure the fog light harness to the vehicle harness with five wire ties. 22. Plug the fog light harness 2-pin connector to the left fog light. LEFT 5 WIRE TIES LEFT FOG LIGHT 2-PIN 701107BE 23. Insert the two hooks of the left fog light into the front bumper, and install the left fog light on the front bumper with two 5 x 16 mm washer-bolts. LEFT 701103BE 21. Slide two spring nuts onto the left fog light lid opening of the front bumper. 2 SPRING NUTS 2 WASHER- BOLTS, 5 x 16 mm LEFT FOG LIGHT 2 HOOKS 701108BE LEFT 701106BE 6 of 11 AII 39396 (0805) 2008 American Honda Motor Co., Inc. All Rights Reserved.

24. Install the left fog light lid on the front bumper. LEFT 27. Pull away the weatherstrip, and remove the right kick panel (two clips). WEATHERSTRIP LEFT FOG LIGHT LID 25. Repeat steps 21 through 24 on the right side. 701110AE 2 CLIPS RIGHT KICK PANEL 700904AE Installing the Relay and Headlight Switch 26. Remove the right front side step trim (four clips). 28. Install the relay into the vehicle relay block. RELAY RIGHT SIDE STEP TRIM RELAY BLOCK PASSENGER S SEAT 4 CLIPS 701111CE 700902AE 2008 American Honda Motor Co., Inc. All Rights Reserved. AII 39396 (0805) 7 of 11

29. Lower the tilt lever and pull the steering wheel out. UPPER STEERING COLUMN COVER 4 RETAINING TABS 2 SELF-TAPPING SCREWS 32. Turn the steering wheel 90 counterclockwise, and unplug the vehicle connector from the headlight switch. Push. TILT LEVER 30. Remove the upper steering column cover: 792404AE Remove the two self-tapping screws. Push the upper cover in at the areas shown to release the four retaining tabs. 31. Remove the lower steering column cover (two selftapping screws and one screw). HEADLIGHT SWITCH STEERING WHEEL 701112AE 33. Remove the two self-tapping screws from the headlight switch. While pushing the retaining tab, slide the headlight switch, and remove it from the steering column. Do not pull out the lever when removing the case. Do not damage the tab hole of the steering column. LOWER STEERING COLUMN COVER TAB HOLE STEERING COLUMN CASE RETAINING TAB SCREW 2 SELF-TAPPING SCREWS 792405AE LEVER HEADLIGHT SWITCH 2 SELF-TAPPING SCREWS 701113AE 8 of 11 AII 39396 (0805) 2008 American Honda Motor Co., Inc. All Rights Reserved.

34. Install the new headlight switch on the steering column using the two self-tapping screws. Hold the case by hand, then install the new headlight switch to the steering column. Do not push the lever when installing the case. Push the case and set the retaining tab to the tab hole securely. CASE TAB HOLE STEERING COLUMN USE AND CARE How to Operate Fog Lights Turn the light switch to the position (headlights on low beam). Turn the fog light switch on (indicator is on). NOTE: The fog light lenses can cloud when the outside temperature is cold; this is normal and should go away in warm weather. If the fog lights don t come on, check the fuse and all the connectors, including the ground cable. Fog Light Aiming Adjustment 1. Remove the fog light lid (eight retaining tabs). RETAINING TAB LEVER NEW HEADLIGHT SWITCH 2 SELF-TAPPING SCREWS 701114AE LID 35. Plug the vehicle connector into the new headlight switch. 8 RETAINING TABS 701110AE NEW HEADLIGHT SWITCH 36. Reinstall all removed parts. 701115AE 2008 American Honda Motor Co., Inc. All Rights Reserved. AII 39396 (0805) 9 of 11

2. Adjust the fog light: Adjust the aiming according to local laws and regulations. To adjust, turn the aiming adjustment knob in or out until the correct aiming is obtained. 2. Remove the fog light (two washer-bolts, two hooks, and unplug the fog light 2-pin connector). 2-PIN AIMING ADJUSTMENT KNOB To raise. To lower. 2 WASHER- BOLTS 2 HOOKS 701117BE 701116AE 3. Remove the bulb from the fog light. 3. Reinstall the fog light lid. BULB REPLACEMENT 1. Remove the fog light lid (eight retaining tabs). LID BULB 701118AE 8 RETAINING TABS 701110AE 10 of 11 AII 39396 (0805) 2008 American Honda Motor Co., Inc. All Rights Reserved.

4. Install the new bulb and socket to the fog light. Use only a Genuine Honda halogen light bulb of specified wattage. Rating: 12V 55W H11 Halogen Light Bulb P/N 33165-S5A-003 Do not touch the bulb. Oily or greasy substances on the bulb can shorten its service life due to the heat produced when the bulb is turned on. If the bulb is accidentally touched, wipe it clean with a soft cloth that has been dampened with a denatured alcohol or a mild detergent solution. When installing the new bulb, align the cutout on the fog light with the tab on the new bulb and turn the new bulb in completely. If not properly aligned, the fog light may blind oncoming drivers. Turn. NEW BULB NEW BULB 701119AE 5. Reinstall the removed parts. Check that the wire harnesses are not pinched. Be sure to tighten the two washer-bolts securely. 6. Check the operation of the fog light; adjust the aiming if necessary. 2008 American Honda Motor Co., Inc. All Rights Reserved. AII 39396 (0805) 11 of 11