' C H M A PARTS MANUAL 2447 Model 85A Articulated Tractor Shovel Information contained herein pertains to Machine Serial Numbers listed below: 85 M A G.M. 4A3 and After Record Your Machine Serial Number Here CLARK COMPANY Construction Machinery Division 2M683BP275SPR428 Printfod in U.S.A.
AIR CLEANER TAILPIPE COCKPIT BUCKET CYLINDER HOOD BELLCRANK REAR AXLE FRONT AXLE BUCKET 3,3 MODEL 85 III A TRACTOR SHOVEL TS-8998
CUIRK MICHIGAII WHEN ORDERING REPAIR PARTS To assure the best results and to maintain the original quality built into the machine it is important that only Clark-Approved s be used when new parts are required. IMPORTANT: Always furnish the distributor with the machine serial number when ordering parts. Order through your nearest Clark Distributor, for THE MICHIGAN LINE. Always give serial number of machine. Furnish: Quantity, Number and. WHEN PARTS ARE RECEIVED Check immediately for quantity, correctness and condition. Advise your Michigan Distributor of any error. Claims for damages, during shipment, should be made to the carrier immediately. INDEX MODEL 85IIIA A Page Page Accelerator Pedal and Linkage 5 Brake Lever Assembly, Parking 3 Accelerator Rods 5 Brake Pedals 5 Accessories, Engine Brake Valve, Air 5 Air Brake Pedals 5 Brake Valve and Controls 5 Air Brake Valve 5 Breather, Torque Converter Air 37 Air Breather Check Valve, Torque Converter 37 Bucket Assembly Data Air Breather, Torque Converter 37 Bucket and Boom Hydraulic Pump 63 Air Cleaner Assembly 2 Bucket and Boom Hydraulic System 67, 69 Air Cleaner Connections 2 Bucket Cutting Edges Air Cleaner, Element 2 Bucket Cylinder Assembly 64 Air Lines, Brake 53 Bucket Leveler 9 Air Pressure Gauge 79 Bucket Leveler Piping 9 Air Pressure Sender Unit 53 Bucket Leveler Valve Air Reservoir 53 Bucket Pushrods 9 Air Valve Assembly, Bucket Leveler Bucket, Seat 77 Alternator Bucket Seat Assembly 77 Alternator Belt Button, Starter 79 Ammeter 79 Axle Assembly Front Drive 4 C Axle Assembly Rear Drive 45 Cab Assembly 83, 85 Cab Head Lamp 83, 85 B Cab Wiring Harness 83, 85 Back Rest Cushion 77 Cables, Battery 86 Back-Up Lamp Assembly 7 Cap, Fuel Tank / 8 Battery, Battery Hold Down and Cables 8 Cap, Oil Reservoir 9 Battery Box 8 Cap, Radiator 3 Battery Cables 86 Cap, Steering Gear Filler 55 Battery Hold Down 8 Case, Transmission 23 Bearing Assembly, Mid Mount 38 Cartridge Kit, Transmission and Converter Filter 37 Bellcranks, Boom and Push Rod 9 Charging Pump, Converter 33 Belts Cleaner, Air 2 Boom 9 Clips, Wiring, Pipe and Hose 87 Boom Cylinder Assembly 65 Clutch Group, Forward, Reverse and Low 26 Brake Air Lines 53 Clutch Group High 27 Brake Assembly Front and Rear 49 Cockpit 76 Brake Assembly, Parking 29 Cockpit Wiring Harness 86 Brake Controls, Parking 3 Column Assembly, Steering 55 PM 2447 [ A ]
CLARK michigan Connections, Muffler, Tailpipe and Air Cleaner Connections, Radiator Control Valve Assembly Transmission Control Valve Assembly Main Converter Assembly, Torque Converter Charging Pump Converter Pressure Regulating Valve Converter to Transmission Prop Shaft Cushion, Back Rest Cushion, Seat Cutting Edges, Main Cutting Edges, Side Cylinder Assembly, Boom Cylinder Assembly, Bucket Cylinder Assembly, Steering D Dash Lamp Decals and Name Plates De-Clutch Valve, Transmission Diagram, Cockpit Wiring Diagram, Engine Wiring Differential and Carrier Assembly Front Drive Differential and Carrier Assembly Rear Drive Dipstick, Fuel Tank Dipstick, Oil Reservoir Drag Link Assembly Drawbar Pin E Element, Air Cleaner Element, Hydraulic Reservoir Filter Element, Lighter Engine and Accessories Engine Filter Elements Engine Hourmeter Engine Oil Pressure Gauge Engine Support s Engine Temperature Gauge Fan Fan Belt Filler Cap, Oil Reservoir Filler Cap, Steering Gear Filter Assembly, Hydraulic Reservoir Oil Filter Assembly, Transmission and Converter Oil Filter Element, Hydraulic Reservoir Oil Filter Elements, Engine Forward, Reverse and Low Clutch Group Foot Switch, Horn Foot Valve, Brake Frame, Front and Rear Front Drive Axle Assembly Front Drive Differential and Carrier Assembly Front Drive Planet Carrier Assembly F Page Page 2 Fuel Lines 8 3 Fuel Tank 8 28 Fuel Tank Cap 8 73, 75 Fuel Tank Dipstick 8 33 Fuel Tank Inspection Plate 8 33 Fuel Tank Strainer 8 33 Fuse.75 Amp 79 39 Fuse 2 Amp 79 77 Fuse, Lighter 79 77 G Gauge, Air Pressure 79 65 Gauge, Engine Oil Pressure 79 64 Gauge, Engine Temperature 79 59 Gauge, Torque Converter Temperature 79 Gear Assembly, Steering 55 Glass Pattern Kit 85 79 Grille 7 86 Group, Seat and Support 77 28 Group, Steering Gear Mounting 56 92 H 93 Hand Brake Control Lever 3 43 Hand Rails 8, 9 47 Harness, Cab Wiring 83 8 Harness, Cockpit Wiring 86 9 Harness, Instrument Panel Wiring 79, 86 57 Harness, Main Wiring 86 5 Harness, Tail Light Wiring 86 Head Lamp Assembly Cab 79 2 Head Lamp Assembly Standard 5, 9 High Clutch Group 27.79 Hood, Hand Rail, Cover and Grille 7 Horn and Foot Switch 76 Hourmeter, Engine 3 3 Hydraulic Oil Reservoir 9 79 Hydraulic Pump Bucket and Boom 63 3 Hydraulic Pump Steering 62 79 Hydraulic Reservoir Filter Assembly, 9 Hydraulic System Bucket and Boom 67, 69 Hydraulic System Steering 6 Hydraulic System Transmission and Torque Converter 37 9 55 Ignition Switch 79 9 Inspection Plate, Fuel Tank 8 37 Inspection Plate, Oil Reservoir 9 9 Instrument Panel Assembly 79 Instrument Wiring Harness 79, 86 26 K 76 Kit, Brake Lining Parking Brake 29 5 Kit, Glass Pattern 85 5 Kit, Transmission and Converter Oil Filter Cartridge 37 4 43 48 Lamp Assembly, Back-Up 7 [ B PM 2447
CUIRK MICHIGAII Lamp Assembly, Cab Head Lamp Assembly, Head Standard Lamp Assembly, Tail and Stop Lamp, Dash Levers, Transmission Control Levers, Valve Control Light Switch Lighter Element Lighter Fuse Lighter Receptacle Lines, Fuel Link, Drag Linkage, Accelerator Pedal Linkage, Transmission Control Levers Linkage, Valve Control Levers Lubrication Instruction Plate M Main Control Valve 73, Main Cutting Edges Main Wiring Harness Michigan Name Plate Mid-Mount Bearing Assembly Mounts, Engine Mounts, Transmission Muffler, Tailpipe and Air Cleaner Connections Neutral Start Switch Oil Reservoir Cap Oil Reservoir Dipstick Oil Reservoir, Hydraulic Oil Reservoir Inspection Plate P Parking Brake Assembly Parking Brake Controls Parking Brake Lever Assembly Pedal, Accelerator Pedals, Brake Pitman Arm, Steering Gear Planet Carrier Assembly Front and Rear Plate, Lubrication Instruction Plate, Michigan Name Plate, Oil Reservoir Inspection Plate, Patent Plate, Shift Quadrant Plates, Cockpit Inspection Pressure Regulating Valve Assembly Pressure Relief Valve Steering System Propeller Shaft Assemblies Pushrods, Bellcrank to Bucket Pump, Bucket and Boom Hydraulic Pump, Converter Charging N Page PM 2447 [ C ] Page 83 Pump, Steering Hydraulic 62 5 5 Q Quadrant, Shift 79 2 2 R 7 Radiator Assembly 3 79 Radiator Cap 3 79 Radiator and Connections 3 79 Rail, Hand 8, 9 79 Rear Drive Axle Assembly 45 8 Rear Drive Differential and Carrier Assembly 47 57 Rear Frame 5 5 Regulator, Voltage 3 2 Reservoir, Air 53 7 Reservoir, Hydraulic Oil 9 86 Rods, Accelerator 5 Rods, Shift 2 Rods, Valve Control 7 75 S 86 Seat Assembly, Bucket 77 7 Seat Bucket 77 38 Seat Cushion 77 3 Seat Support 77 5 Seat and Support Group 77 2 Sender Unit, Air Pressure 53 Sender Unit, Engine Oil Pressure 3 28 Sender Unit, Engine Temperature 3 Sender Unit, Torque Converter Temperature 37 Shaft Assemblies, Propeller 39 9 Shift Levers 2 9 Shift Quadrant 2 9 Shift Quadrant Plate 2 9 Shift Rods 2 Side Cutting Edges Starter 29 Starter Button 79 3 Steering Column Assembly 55 3 Steering Cylinder Assembly 59 5 Steering Gear Assembly 55 5 Steering Gear Mounting Group 56 55 Steering Hydraulic System 6 48 Steering Pressure Relief Valve Assembly 58 86 Steering System Hydraulic Pump 62 7 Steering Wheel 55 9 Stop Lamp Assembly 5 86 Support, Seat 77 2 Supports, Engine 3 7 Switch, Horn Foot 76 33 Switch, Ignition 79 58 Switch, Light 79 39 Switch, Neutral Start 28 9 63 T 33 Tail Light Wiring Harness 86
CLeiRK michidru Page V Page Tailpipe 2 Valve Assembly, Air Brake 5 Tailpipe Connections 2 Valve Assembly, Control 73, 75 Tail and Stop Lamp Assembly 5 Valve Assembly, Foot 5 Tank, Fuel 8 Valve Assembly, Pressure Regulating 33 Tank, Oil Reservoir 9 Valve Assembly, Steering Gear 55 Tire Data 8 Valve Assembly, Steering Pressure Relief 58 Torque Converter Air Breather 37 Valve Assembly, Transmission De-Clutch 28 Torque Converter Air Breather Check Valve 37 Valve Assembly, Transmission Control 28 Torque Converter Assembly 33, 35 Valve Control Levers and Linkage 7 Torque Converter Temperature Gauge 79 Valve, Torque Converter Air Breather Check 37 Transmission Assembly 23 Voltage Regulator 3 Transmission Case 23 Transmission Control Valve Assembly 28 Transmission Control Levers and Linkage 2 Water Pump Belt Transmission and Converter Oil Filter 37 Wheel, Steering 55 Transmission De-Clutch Valve Assembly 28 Wheel and Tire Data 8 Transmission Mounts 5 Wiring 86 Transmission to Front Axle Prop Shaft 39 Wiring Diagram Cockpit 88 Transmission to Rear Axle Prop Shaft 39 Wiring Diagram Engine 89 Transmission and Torque Converter Hydraulic System 37 Wiring Harness, Cab 83, 86 U Wiring Harness, Cockpit 86 Unit, Air Pressure Sender 53 Wiring Harness, Instrument Panel 83, 86 Unit, Engine Oil Pressure Sender 3 Wiring Harness, Main 86 Unit, Engine Temperature Sender 3 Wiring Harness, Tail Light 86 Unit, Torque Converter Temperature Sender 37 Wiring, Pipe and Hose Clips 87 NOTES [ D ] PM 2447
CMRK michigaii ENGINE AND ACCESSORIES G.M. All orders for engine assembly or components thereof should be placed with the nearest G.M. Diesel Distributor. To obtain proper items, it is necessary to provide your engine model, serial number and necessary group type number for the equipment required. This data is stamped on the options and accessories plate on the rocker cover of engine. ENGINE ACCESSORIES 94632 *ALTERNATOR (Delco #7774) 2 539824 *STARTER ASSY (Delco #3873) 3 55673 *VOLTAGE REGULATOR (Delco #959) 4 *AIR COMPRESSOR (G.M. #5353) 5 *OIL FILTER ASSY FULL FLOW (G.M. #534392) 6 *FAN, Radiator (G.M. #57229) *NOTE: The above listed accessory items are serviced by the engine manufacturer. Specifications on these items are subject to change without notice. It is, therefore, recommended that complete model, specifications and serial number of the engine be provided to your G.M. Engine Distributor when ordering these parts. ALTERNATOR, WATER PUMP, AND FAN BELTS 7 557527 BELT, Alternator Drive 8 947952 BELT, Water Pump 9 94795 BELT, Fan Drive REPLACEMENT FILTERS AND ELEMENTS 946897 CARTRIDGE, Air Cleaner 947953 ELEMENT, Fuel Filter Primary 2 947575 ELEMENT, Fuel Filter Secondary 3 2552 ELEMENT, Engine Oil Filter 4 532445 FILTER, Hydraulic Oil Reservoir Suction 5 945989 CARTRIDGE KIT, Hydraulic Oil Reservoir Pressure 6 2552 CARTRIDGE KIT, Transmission & Torque Converter Hydraulic System PM 2447 [ ]
a i w ENGINE SUPPORT AND AUXILIARY PARTS =
CUIRK ENGINE AUXILIARY AND SUPPORT PARTS michigaf 4D- NUT, Sender Unit 2 4E- LKWSHR, Sender Unit 3 55323 SENDER, Engine Temp. 4 68574 SENDER, Engine Oil Press. 5 4E- LKWSHR, Sender Unit 6 4D- NUT, Sender Unit 7 PANEL, Hourmeter Mounting See Index 8 8D-4 NUT, Regulator Mounting 3 9 55673 REGULATOR, Voltage 5525 DAMPENER, Hourmeter Vibration 55896 WIRE, Hourmeter to Relay 2 2E-6 LKWSHR, Dampener Mtg. 3 3 85G-68 SCREW, Dampener Mtg. 3 4 58624 HOURMETER (Inc. 5, 6) 5 2E-6 LKWSHR, Hourmeter Mounting 3 6 85G-68 SCREW, Hourmeter Mounting 3 7 24C-42 BOLT, Regulator Mounting 3 8 24C-42 BOLT, Relay Mounting 2 9 698 WASHER, Relay Mounting 2 2 5266 RELAY, Hourmeter 2 8D-4 NUT, Relay Mounting 2 22 24C-236 BOLT, Mount to Frame 2 23 8C-824 BOLT, Mount to Engine 4 24 6824 RECT. FLAT (Welded to Frame) 25 52993 MOUNT, Engine to Frame 26 8D-2 NUT, Mount to Frame 2 27 ENGINE See G.M. Engine s Manual 28 52994 MOUNT, Engine to Frame 29 8D-2 NUT, Mount to Frame 2 3 6824 RECT. FLAT (Welded to Frame) 3 8C-824 BOLT, Mount to Engine 4 32 5749 SPRING, Mount to Frame R.H. Only 2 33 6689 WASHER, Mount to Frame R.H. Only 2 34 24C-236 BOLT, Mount to Frame 2 35 6485 RECT. FLAT (Welded to Frame) 2 36 8D- NUT, Engine to Frame Rear 2 37 24C-36 BOLT, Engine to Frame Rear 2 PM 2447 [3 ]
5 8 9 6 WP5 8 7 6 (,'9 5 \ 2 cg<4 22 e 23 4, 24 49 5 4\ 5 >52 53 54 45 55 / 56 ge-57 44 A A79 89 2 92 88-8 /"... Cm 86 85 84 8 26 39 4 38 '"/4 3N,/4 36NA,`" 35 N 34 NCe 4 / 42 43 62 6-4--63 u-4-64 65 82 8 9-D- 3 3 3k4 33 8 8 \ 2 \ t t 6 5 74 73 69 a FRONT AND REAR FRAME AND CRADLE 6 TS-93-P
CUIRK FRONT AND REAR FRAME AND CRADLE micmcnn 5295 COUNTERWEIGHT 2 56753 WASHER, Counterweight 2 3 24C-284 BOLT, Counterweight 2 4 53766 FRAME, Rear (Inc. 5, 25, 26) 5 5688 PIN, Drawbar 6 F-252 COTTER, Drawbar Pin 7 86G-2 SCREW, Lamp to Frame 6 8 56967 LAMP, Stop & Tail (Inc. 8A, 8B) 2 8A 368 t LENS, Lamp 2 8B 94664 "I- BULB, Lamp 2 9 736 PLUG, Tail Lamp For R.H. Side Only 7E- LKWSHR, Lamp to Frame 6 4D- NUT, Lamp to Frame 2 8D-8 NUT, Pin Retaining 4 3 56939 PIN, Steer Cyl. to Frame 4 4 24C-872 BOLT, Pin Retaining 4 5 52235 BUSHING, Upper Hinge 2 6 53845 PIN, Upper Hinge 7 4E-8 LKWSHR, Retainer 2 8 24C-82 BOLT, Retainer 2 9 53297 RETAINER, Hinge Pin 2 24C-268 BOLT, Lower Hinge Pin 2 24C-82 BOLT, Retainer 2 22 4E-8 LKWSHR, Retainer 2 23 53297 RETAINER, Hinge Pin 24 57654 PIN, Lower Hinge 25 53727 BUSHING, Lower Hinge Upper 26 27 57288 522429 BUSHING, Lower Hinge Lower PLATE, Bushing Retaining 28 522428 WASHER, Nut to Plate 29 5375 NUT, Lower Hinge Pin 3 24C-248 BOLT, Bracket to Frame 2 3 585972 WASHER, Bracket to Frame L.H. Side Only 2 32 327 PIN, Safety Link 2 33 F-424 COTTER, Safety Link Pin 2 34 53573 SPACER, Hinge Bushing 35 53842 SEAL, Lower Hinge Lower _ 36 3478 BUSHING, Hinge Pin Lower 37 57655 CAP, Bushing Retaining 38 53843 SEAL, Lower Hinge Upper _ 39 24C-32 BOLT, Cap to Frame 6 4 H-25 FITTING, Hinge Grease 2 4 7943 RING, Bushing Retaining 42 669896 BUSHING, Hinge Pin Upper _ 43 54949 FRAME FRONT (Inc. 44, 62, 63, 64, 65) 43A 53949 f BUSHING, Boom Cyl. to Frame 44 53346 BUSHING, Boom Pivot 2 45 54663 PIN, Boom to Frame 2 46 56594 LOCKPLATE, Boom Pin 4 47 5393 BRACKET, Head Light Mtg. 2 48 652448 SPACER, Head Light to Bracket 2 49 54888 LAMP, Head (Inc. 49A, 49B) _ 2 4 t Not Illustrated PM 2447 [5 ]
2 5 6 ) 9 89 Bad 87 7', 86 85 8r 83 2 3 4 \ C6 8 7 / la 6 V / I ' \ ' 2 / 222 ;di)",--23 38 37 36 35 34 It)V 39 4 4 42 43 48 \ \ 49 5 4% I 7 5 )42 46 53 54 45 55 44 6) 4 / 4 56 5 62 6 643 6 59 65 58 n N C n m x 82 8 8 8 9-- 32 33 3 t 76 77 75 4 3 FRONT AND REAR FRAME AND CRADLE 69 6 66 TS-93-P a 87
CUIRK micmcnn FRONT AND REAR FRAME AND CRADLE (Continued) 49A 944872 tretainer 2 73 68D-2 NUT, Bracket to Frame 2 49B 55244 tsealed UNIT, Head Lamp 2 74 53787 BRACKET, Trans. Mtg. L.H. 5 4E-8 LKWSHR, Bracket to Frame 2 5 24C-82 BOLT, Bracket to Frame 2 52 8D-8 NUT, Lamp to Bracket 2 53 4E- LKWSHR, Lockplate to Frame 8 54 24C-24 BOLT, Lockplate to Frame 8 55 H-25 FITTING, Boom Pin Grease 2 56 24C-88 BOLT, Pin Retaining 2 57 H-3 FITTING, Boom Cylinder Pivot Grease 2 58 5365 BOLT, Tapped 2 59 568649 PIN, Bucket Cylinder 2 6 8D-8 NUT, Pin Retaining 2 75 53788 BRACKET, Trans. Mtg. R.H. 76 4E-2 LKWSHR, Trans. to Bracket 6 77 23C-232 BOLT, Trans. to Bracket 6 78 68D-2 NUT, Bracket to Frame 2 79 24C-248 BOLT, Bracket to Frame 2 8 68D-6 NUT, Axle Mounting 8 8 53775 CRADLE ASSY (Inc. 84) 82 24C-672 BOLT, Axle Mounting 8 83 WASHER, Cradle Shim 83A 55246 $'/, 6" 6 H-25 FITTING, Pin Grease 2 83B 55247 t/2" 3 62 53345 BUSHING, Bucket Cylinder to Frame 63 24C-28 BOLT, Anchor Cap 8 64 4E-2 LKWSHR, Anchor Cap 8 65 53953 CAP, Boom Cylinder Anchor 4 66 67536 RECTANGULAR FLAT (Welded to Frame) 4 67 68D-6 NUT, Axle Mounting 8 68 5743 SPACER, Axle Mounting 8 69 24C-652 BOLT, Axle Mounting 7 53954 LINK, Safety 7 23C-236 BOLT, Parking Brake Brk. & Trans. to Brk. 2 72 4E-2 LKWSHR, Parking Brake Brk. & Trans. to Brk. 2 84 5284 BUSHING, Cradle 2 85 WASHER, Cradle Shim 85A 55246 85B 55247 A 6 t ye/ 86 53783 PIN, Cradle to Frame 2 87 H-5 FITTING, Cradle Pin Grease 2 88 568259 LOCKPLATE, Pin Retaining 2 89 4E-8 LKWSHR, Lockplate 4 9 24C-82 BOLT, Lockplate 4 9 56753 WASHER, Counter Weight 2 92 8D-2 NUT, Counterweight 2 t Not Illustrated tas Required PM 2447 [ 7 ]
n n a BOOM, BELLCRANKS, PUSHRODS, BUCKET LEVELER AND PIPING
CMRK BOOM, BELLCRANKS, PUSHRODS, BUCKET LEVELER AND PIPING MICHIG ---- BRAKE FOOT VALVE See Index 2 3F-2 ELBOW, Hose to Foot Valve 3 52576 HOSE, Foot Valve to Air Valve 4 24C-62 BOLT, Clip Attaching 5 5 4E-6 LKWSHR, Clip Attaching 5 6 4E-6 LKWSHR, Clip Attaching 4 7 24C-62 BOLT, Clip Attaching 4 8 52576 HOSE, Control Valve to Air Valve 9 36F-2 ADAPTER UNION, Hose to Air Valve AIR VALVE See Index 528637 CAM, Bucket Leveler 2 3F-2 ADAPTER, Hose to Elbow 3 29F- ELBOW, Adapter to Valve 4 528638 BRACKET, Leveler Cam 5 24C-66 BOLT, Cam to Bracket 2 6 4E-6 LKWSHR, Cam to Bracket 2 7 692 WASHER, Cam to Bracket 2 8 692 WASHER, Bracket to Cylinder 2 9 4E-6 LKWSHR, Bracket to Cylinder 2 2 24C-66 BOLT, Bracket to Cylinder 2 2 24C-24 BOLT, Lockplate to Boom 8 22 4E- LKWSHR, Lockplate to Boom 8 23 56594 LOCKPLATE, Pin Retaining 4 24 532552 PIN, Boom Cylinder to Boom 2 25 53636 BOOM 26 53623 PIN, Bellcrank to Boom 2 27 588292 LOCKPLATE, Pin Retaining 4 28 4E- LKWSHR, Lockplate to Boom 8 29 24C-24 BOLT, Lockplate to Boom 8 3 24C-82 BOLT, Lockplate to Boom 8 3 4E-8 LKWSHR, Lockplate to Boom 8 32 568259 LOCKPLATE, Pin Retaining 4 33 5362 PIN, Bucket to Boom 2 34 H-25 FITTING, Bucket Grease 2 35 5344 36 8D-8 37 ---- 37A 52585 38 24C-876 39 5359 4 53592 4 53593 42 4E-6 43 24C-632 44 56679 45 H-25 46 53438 47 569963 48 56679 49 573 5 8D-8 5 5344 52 24C-876 53 H-25 54 56938 55 H-25 56 5345 57 8D-8 58 53442 59 24C-876 6 86G- 6 2E- 62 ---- 63 3H-42 64 3H-46 65 3F-2 66 ---- PIN, Pushrod to Bucket 2 NUT, Pin Retaining 2 BUCKET ASSY See Index t BUSHING, Bucket 4 BOLT, Pin Retaining t SPACER, Bucket Stop (Y6") $ SPACER, Bucket Stop ( /8") STOP, Bucket 2 LKWSHR, Bucket Stop 4 BOLT, Bucket Stop 4 BUSHING, Pushrod 2 FITTING, Pushrod Grease 2 PUSHROD (Inc. 44) 2 NUT, Jam 2 BUSHING, Pushrod Eye 2 EYE, Pushrod Adjusting (Inc. 48) 2 NUT, Pin Retaining 2 PIN, Pushrod to Bellcrank 2 BOLT, Pin Retaining 2 FITTING, Pushrod Eye Grease 2 BUSHING, Bellcrank 2 FITTING, Bellcrank Grease 2 BELLCRANK (Inc. 54) 2 NUT, Pin Retaining 2 PIN, Bucket Cylinder to Bellcrank 2 BOLT, Pin Retaining 2 SCREW, Air Valve Mtg. 4 LKWSHR, Air Valve Mtg. 4 BUCKET CYLINDER See Index 2 CLIP, Hose 4 CLIP, Hose 6 ELBOW, Hose to Control Valve CONTROL VALVE ASSY See Index 2 t Not Illustrated fas Required PM 2447 [ 9 ]
CUIRK MICHIGAil BUCKET ASSEMBLY DATA BUCKET MAIN CUTTING EDGE SIDE CUTTING EDGES CORNER GUSSET 2 I T E M # S.A.E. HEAPED CAPACITY CU. YD. WIDTH PART NO. PART NO. SIZE L.H. PART NO. R.H. PART NO. SIZE PART NO. 3 4%" 5347 53739 3/8" x " x 4 34" 58483 58484 4" x 9" x 48 3/8" 53686 2 3 /2 4 7/8" 534 58825 3/8" x " x 4 34" 58493 58494 4" x 9" x 5%" 53686 3 4 47/8" 53765 58825 %" x " x 4 34" 57346, 57345 _. /4 x 9" x 53 /2" 53686 4 5 6 7 [ ] PM 2447
CUIRK mann AIR VALVE ASSEMBLY - BUCKET LEVELER A 559784 AIR VALVE ASSY (Inc. thru 2) B 895683 SEAL REPAIR KIT (Inc. 6, 8, 9, 3, 4, 6) 94778 ROLLER, Air Valve Lever 2 94775 LEVER, Air Valve 3 5G-46 SCREW, Adjusting 4 42G-8 SCREW, Cover Bracket Attaching 4 5 94776 BRACKET, Top Cover 6 94777 BUTTON ASSY (Inc. 6) 7 3339 RING, Retaining 8 25K-22 -RING, Stem 9 94765 BUTTON & STEM ASSY (Inc. 6 & 6) BODY See "A" 947226 CLOSED END CAP 2 3339 RING, Retaining 3 889239 DIAPHRAGM 4 889239 DIAPHRAGM 5 947225 OPEN END CAP 6 889242 SPRING 7 94779 PIVOT PIN 8 4E-4 LKWSHR, Adjusting Screw 9 D-4 NUT, Adjusting Screw Lock 2 94779 PIVOT PIN Not Sold Separately PM 2447 [ ]
CMRK CONSTRUCTION MACHINERY DIVISION MICHIGN MUFFLER, TAIL PIPE, AIR CLEANER AND CONNECTIONS 5686 MUFFLER 8 532 CAP, Air Cleaner 2 56269 PIPE, Tail 9 529625 INDICATOR, Service 3 556289 CLAMP, Tail Pipe 2 539 AIR CLEANER ASSY (Inc. 9, 4 24C-56 BOLT, Muffler to Bracket 4 2, 23 thru 28) 5 52665 BRACKET, Muffler L.H. 2 94444 -RING, Cup to Body 6 8D-5 NUT, Muffler to Bracket 4 22 534 BAND, Air Cleaner Mtg. 2 7 54797 CLAMP, Hose to Engine 23 946897 CARTRIDGE, Air Cleaner 8 53865 HOSE, Tube to Engine 24 886527 GASKET, Wing Nut 9 9448 CLAMP, Air Cleaner Cup 25 886526 WING NUT, Cartridge Retaining 656672 WASHER, Air Cleaner Mtg. 4 26 946898 BAFFLE, Cup 8D-6 NUT, Air Cleaner Mtg. 4 27 946899 CUP, Air Cleaner 2 5793 CLAMP, Hose to Air Cleaner 28 94686 VALVE, Vacuator 3 54797 CLAMP, Hose to Tube 29 556426 PIPE, Exhaust 2 4 5385 TUBE, Air Intake 3 544288 CLAMP, Pipe to Stem 2 5 5793 CLAMP, Hose to Tube 3 544268 STEM, Exhaust 2 6 52935 HOSE, Tube to Air Cleaner 32 5769 CLAMP, Pipe to Muffler 2 7 24C-62 BOLT, Air Cleaner Mtg. 4 33 52664 BRACKET, Muffler R.H. [ 2 PM 2447
CLgIRK MICHIG RADIATOR AND CONNECTIONS 863364 CAP, Radiator 7 72F-2 DRAIN COCK 2 53773 RADIATOR ASSY (Inc. ) 8 8D-8 NUT, Jam 2 3 54266 CLAMP, Hose to Radiator 2 9 569739 DAMPENER, Vibration 2 4 555979 HOSE, Tube to Radiator 2 2 8D-8 NUT, Support Rod to Frame 2 5 54266 CLAMP, Hose to Tube 2 2 66796 WASHER, Support Rod to 6 5389 TUBE, Radiator to Engine Frame 2 7 54266 Upper CLAMP, Hose to Tube 8 555979 HOSE, Tube to Engine 2 9 54266 CLAMP, Hose to Engine 2 548 CLAMP, Hose to Engine M-64 HOSE, Tube to Engine 2 2 22 66796 WASHER, Support Rod to Frame 2 23 8D-8 NUT, Radiator to Frame 4 24 66796 WASHER, Radiator to Frame 4 25 569739 DAMPENER, Vibration 4 2 548 CLAMP, Hose to Tube 26 24C-844 BOLT, Radiator to Frame 4 3 53267 TUBE, Radiator to Engine 27 24C-82 BOLT, Support Rod to Lower Radiator 2 4 548 CLAMP, Hose to Tube 28 4E-8 LKWSHR, Support Rod to 5 M-64 HOSE, Radiator to Tube Radiator 2 6 548 CLAMP, Hose to Tube 29 53786 ROD, Radiator Support 2 PM 2447 [ 3 ]
6 7 8 9 2 2 7 \ 48 v 47 ;r) 46 Q., R. 45 '''''''''' I 43 44 4 4 5 4 42 8 w 4,7 8 I do 4 2 ACCELERATOR PEDAL AND LINKAGE 3, 35 a-36 v, \ \ 37 \ 38 39 9 t' t, 26 27 28 29 ".-3 '6 ) 3 l'*t.4ro NC2; 32 6,-33 ( D 34 <AO 24 TS-962-P -4 a C3
CLARK ACCELERATOR PEDAL AND LINKAGE muslin F-28 COTTER, Cable Connector 2 52329 CONNECTOR, Cable 3 86G-8 SCREW, Cable Connector 4 5373 ROD, Throttle (Inc. 5, 6) 5 8D-5 NUT, Ball Joint Jam 6 336 BALL JOINT, Throttle Rod 7 53266 BELLCRANK, Engine 8 66D-5 NUT, Ball Joint 9 53284 BRACKET, Rod Support 8D-4 NUT, Bellcrank Mtg. 2 24C-46 BOLT, Bellcrank Mtg. 2 2 8D-4 NUT, Bracket to Floor 2 3 62376 BRACKET, Acc. Pedal 4 24C-46 BOLT, Bracket to Floor 2 5 623762 PIN, Pedal to Bracket 6 569389 PLATE, Emergency Stop 7 6C-65 SCREW, Plate to Cockpit 2 8 529 CABLE, Emergency Stop 9 5293 CABLE, Engine Stop 2 F-36 COTTER, Pedal Pin 2 623829 PEDAL, Accelerator 22 24C-448 BOLT, Pedal Stop 23 556 STOP, Accelerator Pedal 24 8D-4 NUT, Pedal Stop 25 F-28 COTTER, Clevis Pin 26 4F-45 PIN, Clevis 27 5569 ROD, Pedal to Bellcrank 28 8D-4 NUT, Clevis Jam 29 2J-42 CLEVIS, Rod to Bellcrank 3 F-28 COTTER, Clevis Pin 3 4F-45 PIN, Clevis 32 56894 BELLCRANK 33 F-28 COTTER, Clevis Pin 34 4F-45 PIN, Clevis 35 4E-6 LKWSHR, Bracket to Cockpit 36 24C-66 BOLT, Bracket to Cockpit 37 5377 ROD, Accelerator (Inc. 9, 38, 39) 38 8D-5 NUT, Ball Joint 39 336 BALL JOINT, Rod to Bellcrank 4 4E-6 LKWSHR, Bellcrank to Engine 2 4 23C-66 BOLT, Bellcrank to Engine 2 42 66D-5 NUT, Ball Joint 43 559 SPRING, Return 44 5359 ANCHOR, Spring 45 4F-562 PIN, Clevis 46 F-32 COTTER, Clevis Pin 47 5232 CONNECTOR, Cable 48 85G-86 SCREW, Cable Connector PM 2447 [5 ]
pa n n rn a =I
CLARK HOOD, GRILLE AND PANELS MICHICAll 692 WASHER, Hood Mtg. 2 2 24C-632 BOLT, Hood Mtg. 2 3 23C-66 BOLT, Plate to Frame 2 4 4E-6 LKWSHR, Plate to Frame 2 5 656672 WASHER, Plate to Frame 2 6 24C-62 BOLT, Plate to Frame 7 4E-6 LKWSHR, Plate to Frame 8 656672 WASHER, Plate to Frame 9 5383 PLATE, Access 5385 HOOD 23C-66 BOLT, Plate to Cockpit 3 2 4E-6 LKWSHR, Plate to Cockpit 3 3 656672 WASHER, Plate to Cockpit 3 4 532766 PLATE, Cockpit Side 5 53793 PLATE, Air Cleaner Mtg. 6 539265 PLATE, Cover L.H. 7 23C-62 BOLT, Cover Plates to Frame 6 8 4E-6 LKWSHR, Cover Plates to Frame 6 9 656672 WASHER, Cover Plates to Frame 6 2 5384 PLATE, Cover R.H. 2 23C-66 BOLT, Plate to Cockpit 3 22 4E-6 LKWSHR, Plate to Cockpit 3 23 656672 WASHER, Plate to Cockpit 3 24 532766 PLATE, Cockpit Side 25 23C-62 BOLT, Mounting Plate to Frame 26 4E-6 LKWSHR, Mounting Plate to Frame 27 656672 WASHER, Mounting Plate to Frame 6 28 24C-624 BOLT, Hood Mtg. 2 29 692 WASHER, Hood Mtg. 2 3 692 WASHER, Hood Mtg. 2 3 8D-6 NUT, Hood Mtg. 2 32 24C-62 BOLT, Plate to Frame 33 4E-6 LKWSHR, Plate to Frame 34 656672 WASHER, Plate to Frame 35 23C-66 BOLT, Plate to Frame 2 36 4E-6 LKWSHR, Plate to Frame 2 37 656672 WASHER, Plate to Frame 2 38 5383 PLATE, Access 39 5883 * PANEL, Engine Side 4 4 587989 * CATCH, Side Panel 4 4 85G-84 *SCREW, Bumper to Panel 4 42 55434 * BUMPER, Side Panel 4 43 2D-8 * NUT, Bumper to Panel 4 44 5D- NUT, Lamp to Grille 6 45 567976 GRILLE 46 635682 WASHER, Grille Mtg. 4 47 4E-8 LKWSHR, Grille Mtg. 4 48 24C-824 BOLT, Grille Mtg. 4 49 535649 NAMEPLATE "Michigan" 5 7G-48 SCREW, Nameplate to Grille 4 5A 2E-4 ii-kwshr, Nameplate to Grille 5 54746 LAMP ASSY Back-Up (Inc. 5A, 5B) 2 5A 946389 t RETAINER 2 5B 55245 t SEALED UNIT 2 52 8D-6 NUT, Hood Mtg. 2 53 692 WASHER, Hood Mtg. 2 54 568276 DAMPENER, Vibration 2 55 692 WASHER, Hood Mtg. 2 *NOTE: Optional equipment Not furnished with machine. 'Mot Illustrated PM 2447 [ 7 ]
CMRK MICHICA FUEL TANK AND LINES 537 DIPSTICK, Fuel Tank 6 38F-9 CONNECTOR, Tube to Check 2 556655 CAP, Filler (Inc. 2A, 2B) 7 42543 VALVE, Check 2A 946953 tgasket, Filler Cap 8 53579 TUBE, Breather 2B 946954 PLATE, Gasket Back-Up 9 38F-4 CONNECTOR, Breather Tube 3 56994 RING, Screen Retaining 2 525293 MAGNET 4 943957 SCREEN, Filler 2 25K-4428 -RING, Inspection Plate 5 5379 TANK, Fuel 22 58763 PLATE, Inspection r 6 9F-6 BUSHING, Reducing 23 4K-6 PLUG, Inspection Plate 7 42F-8 ELBOW, Hose to Tank 24 4E-6 LKWSHR, Plate 6 8 3F-3 ADAPTER, Hose to Tank 25 24C-62 BOLT, Plate 6 9 53356 HOSE, Fuel Return 26 24C-828 BOLT, Step to Tank 4 38F-7 CONNECTOR, Hose to 27 6929 WASHER, Step to Tank 4 Engine 28 8D-8 NUT, Step to Tank 4 524959 HOSE, Suction 29 6929 WASHER, Step to Tank 4 2 8D- NUT, Tank to Frame 3 24C-24 BOLT, Tank to Frame 5 3 53853 TUBE, Fuel Suction 3 4E- LKWSHR, Tank to Frame 5 4 668 WASHER, Tank to Frame 32 668 WASHER, Tank to Frame 5 5 24C-32 BOLT, Tank to Frame 33 5374 STEP L.H. tnot Illustrated [ 8 ] PM 2447
CUIRK michigan HYDRAULIC OIL RESERVOIR, STEP AND FILTERS 24C-32 BOLT, Reservoir Mtg. 2 8D-6 NUT, Guide Rod 2 668 WASHER, Reservoir Mtg. 2 52974 WASHER, Guide Rod 3 8D- NUT, Reservoir Mtg. 22 53598 SPRING, Retaining 4 743563 HOSE, Vent (7" lg.) 23 529679 RETAINER, Filter 5 52874 CLAMP, Hose 24 945989 KIT, Filter Cartridge Return 6 52875 DIPSTICK, Reservoir 25 52972 ROD, Guide 7 554843 CAP, Filler 26 668 WASHER, Reservoir Mtg. 5 8 24C-62 BOLT, Filler Neck 6 27 4E- LKWSHR, Reservoir Mtg. 5 9 4E-6 LKWSHR, Filler Neck 6 28 24C-24 BOLT, Reservoir Mtg. 5 567742 FILLER NECK 29 536 RESERVOIR, Hydraulic Oil 25K-4624 -RING, Filler Neck 3 525293 MAGNET 2 532445 FILTER, Suction 3 58763 COVER, Inspection 3 6929 WASHER, Step to Reservoir 4 32 4K-6 PLUG, Drain 4 24C-828 BOLT, Step to Reservoir 4 33 24C-62 BOLT, Inspection Cover 6 5 24C-64 BOLT, Cover Plate 6 34 4E-6 LKWSHR, Inspection Cover 6 6 4E-6 LKWSHR, Cover Plate 6 35 25K-4428 -RING, Inspection Cover 7 529896 PLATE, Cover 36 53593 STEP R.H. 8 25K-488 -RING, Cover Plate 37 6929 WASHER, Step to Reservoir 4 9 53599 SPRING, Relief 38 8D-8 NUT, Step to Reservoir 4 PM 2447 [9]
37 39 38 \ \ 45 46 7 6 7 8 2 33 34 36 44 -,4,4 43 42 2 48 73 22 23 72 49 5, 7 27 28 29 5 52 53 rn 69-65 64 63 62 6 6 59 58 4,,_54 57 56 55 tn a TRANSMISSION CONTROL LEVERS AND LINKAGE TS-944-P
CUIRK TRANSMISSION CONTROL LEVERS AND LINKAGE michigar 8D-8 NUT, Bellcrank to Brk. 2 66795 WASHER, Bellcrank to Brk. 2 3 585596 SLEEVE, Bellcrank 4 585597 BUSHING, Bellcrank 5 336 BALL JOINT, Control Rod 6 5855 BELLCRANK, Transmission Control 7 66D-5 NUT, Ball Joint 8 23C-724 BOLT, Bracket to Transmission 2 9 533873 BRACKET, Bellcrank 4F-66 PIN, Clevis 52222 ROD, Bellcrank to Control Valve 2 66D-5 NUT, Ball Joint 3 5855 BELLCRANK, Transmission Control 4 585597 BUSHING, Bellcrank 5 336 BALL JOINT, Control Rod 6 585596 SLEEVE, Bellcrank 7 66795 WASHER, Bellcrank to Brk. 2 8 24C-86 BOLT, Bellcrank to Brk. 9 563753 KNOB, High & Low Lever 2 53667 LEVER, High & Low 2 2H-5 FITTING, Lever Grease 22 F-38 COTTER, Clevis Pin 23 4F-66 PIN, Clevis 24 5368 BELLCRANK 24A 23C-66 f BOLT, Bellcrank Mtg. 2 24B 4E-6 t LKWSHR, Bellcrank Mtg. 2 25 F-38 COTTER, Clevis Pin. 26 4F-66 PIN, Clevis 27 53663 ROD, Control (Inc. 5, 5, 53, 72) 28 24C-536 BOLT, Lever Support 2 29 58846 SUPPORT, Shift Lever (Inc. 56) 3 58846 SUPPORT, Shift Lever (Inc. 49) 3 24C-536 BOLT, Lever Support 2 32 5367 ROD, High & Low Upper (Inc. 4, 4) 33 585596 SLEEVE, Lever 34 585597 BUSHING, Lever 35 4F-66 PIN, Clevis 36 F-38 COTTER, Clevis Pin 37 66795 WASHER, Lever Mtg. 38 4E-8 LKWSHR, Lever Mtg. 39 24C-828 BOLT, Lever Mtg. 4 2J-628 CLEVIS, High & Low Rod 4 8D-6 NUT, Clevis Jam 42 533876 LEVER, Forward & Reverse 43 536275 QUADRANT, Shift 43A 24C-62 t BOLT, Shift Quadrant 43B 8D-6 t NUT, Shift Quadrant 44 567977 PLATE, High-Low 45 567947 PLATE, Forward-Reverse 46 6C-65 SCREW, Plate to Quadrant 6 47 59772 KNOB, Shift Lever 2 48 533875 LEVER, High & Low 49 58846 SUPPORT, Shift Lever (Inc. 3) 5 8D-5 NUT, Lever Support 2 5 8D-5 NUT, Ball Joint Jam 52 66D-5 NUT, Ball Joint 53 336 BALL JOINT, Control Rod 54 66D-5 NUT, Ball Joint 55 8D-5 NUT, Lever Support 2 56 58846 SUPPORT, Shift Lever (Inc. 29) 57 336 BALL JOINT, Control Rod 58 8D-5 NUT, Ball Joint Jam 59 53663 ROD, Control (Inc. 5, 57, 58, 72) 6 F-38 COTTER, Clevis Pin 6 4F-66 PIN, Clevis 62 53672 ROD, High-Low-Lower 63 9855 WASHER, Clevis Pin 2 64 743878 LINK, Connecting 2 65 4F-66 PIN, Clevis 2 66 F-38 COTTER, Clevis Pin 2 67 4F-66 PIN, Clevis 68 F-38 COTTER, Clevis Pin 69 52229 BELLCRANK, High & Low 7 52226 BRACKET, Bellcrank 7 23C-724 BOLT, Bracket to Trans. 2 72 8D-5 NUT, Ball Joint Jam 2 73 2H-5 FITTING, Bellcrank Grease _ 74 F-3 COTTER, Clevis Pin 75 4F-66 PIN, Clevis 76 F-3 COTTER, Clevis Pin 77 2H-5 FITTING, Bellcrank Grease 78 52222 ROD, Bellcrank to Control Valve 79 4F-66 PIN, Clevis 8 F-3 COTTER, Clevis Pin 8 4F-66 PIN, Clevis 82 F-3 COTTER, Clevis Pin tnot Illustrated PM 2447 [ 2 ]
2 3 4 5.6 7.8.9 2 2 8 7L7L 22 2.3 24 25 26 2 28 4.) 29 3 3 32 33 88 8 86 85 84 83 82 8 8 5 5 49 48 4 46 45 44 52 53 55 56 5 43 42 4 4 39 38 37 34 35 36 -< 65 66 6 79 8 76 5 74 73 a TRANSMISSION ASSEMBLY TS-6988-P
CUIRK TRANSMISSION ASSEMBLY MICHICAll A 2829 C-82 2 5E-8 3 225823 4 22796 5 2556 TRANSMISSION ASSY (242H-2) (Inc. thru 88) BOLT, Bearing Cap LKWSHR, Bearing Cap 4 SEAL, Bearing Cap Oil CAP, Bearing t SHIM, Cap.4" 2 2544 GASKET, Cover to Case 2 254 COVER ASSY, Trans. (Inc. 9, 44, 44A) 22 225824 BEARING, Shaft Locating 23 945374 RING, Brg. Retaining 4 24 25K-436 -RING, Bearing Cap 25 2598 CAP, Input Brg. (Inc. 3) 5A 2557 $SHIM, Cap.7" 5B 2558 $SHIM, Cap." 6 25K-4524 -RING, Bearing Cap 7 227945 SPACER, Brake Flange 8 25757 PLUG, Drain 9 8363 CASE, Transmission 9A 28353 t BORE PLUG, Case 9B 4F-2 t PLUG, Dipstick Hole 65965 RING, Brg. Retaining 24295 PIN, Case Dowel 2 22578 BEARING, Input Shaft 3 2566 GEAR, Input Shaft (26T) 4 2566 SCREW, Shift Fork Lock 5 2546 FORK, Range Shift 6 2565 SHAFT, Input 7 22575 SEAL, Shift Rail Oil 8 -- CLUTCH GROUP Forward, Reverse & Low See Index 3 9 2543 PLATE, Oil Circuit 26 -- BEARING CAP See 38 27 4E-7 LKWSHR, Bearing Cap 3 28 C-78 BOLT, Bearing Cap 3 29 -- OMIT, Not Used 3 -- OMIT, Not Used 3 26864 SEAL, Input Shaft Oil 32 F-428 COTTER, Flange Nut 33 295 NUT, Input Flange 34 2745 WASHER, Flange Nut 35 25K-42 -RING, Input Flange 36 228859 FLANGE, Input (6-C) 37 C-78 BOLT, Bearing Cap 2 37A 4E-7 LKWSHR, Bearing Cap 2 38 2563 CAP, Bearing 4 39 6F-2 PLUG, Brg. Cap Pipe 4 4 25K-36 -RING, Bearing Cap 4 4 2564 GASKET, Bearing Cap 4 42 C-78 BOLT, Cover to Case 2 43 4E-7 LKWSHR, Cover to Case 2 tas Required tnot Illustrated PM 2447 [ 23 ]
2 3 4 5.6..8 9 2 2 22 23 24 25 2.6 2 28 29 3 3 32 33 88 8 86 85 5 5 49 48 47 52 53 ) 54 55 56 5 58 43 42 4 4 39 38 3' 34 35 36 rn 84 83 82 8 8 62 63 64 65 66 67 In 73 72 7 7 69 68 a TRANSMISSION ASSEMBLY TS-6988-P 3:
CUIRK TRANSMISSION ASSEMBLY (Continued) michigan 44 C-64 BOLT, Plate to Cover 5 66 22279 WASHER, Flange Nut 44A 5E-6 LKWSHR, Plate to Cover 5 67 F-436 COTTER, Flange Nut 45 ---- CLUTCH GROUP, High See Index 46 2545 RAIL, Range Shift 47 228943 PLATE, Baffle 48 4K-4 PLUG, Detent Spring 49 259 SPRING, Detent 5 J-2 BALL, Detent 5 4K-4 PLUG, Oil Level 2 52 2525 SCREEN, Suction 68 25928 NUT, Output Flange 69 25K-66 -RING, Output Flange 7 222233 FLANGE, Output (7-C) 7 C-82 BOLT, Bearing Cap 4 72 5E-8 LKWSHR, Bearing Cap 4 73 25K-4524 -RING, Bearing Cap 74 6672 CUP, Shaft Bearing 75 227947 WASHER, Thrust 53 29373 GASKET, Plug 76 22869 GEAR, High (34T) 54 2937 PLUG, Suction Screen 55 6672 CUP, Output Bearing 56 227947 WASHER, Thrust 57 22868 GEAR, Low (6T) 58 2549 HUB, Output Shaft Shift 59 228887 SHAFT, Output 6 227944 BEARING, High Gear 2 6 227946 CONE, Shaft Bearing 62 227945 SPACER, Brake Flange 63 22796 CAP, Output Bearing 64 225823 SEAL, Bearing Cap Oil 77 227944 BEARING, Low Gear 78 227944 BEARING, Low Gear 79 227946 CONE, Shaft Bearing 8 ---- BRAKE ASSY, Parking See Index 8 228234 FLANGE, Brake (7-C) 82 256 DRUM, Brake 83 25K-66 -RING, Flange 84 4E-6 LKWSHR, Drum to Flange 6 85 2C-62 BOLT, Drum to Flange 6 86 22279 WASHER, Flange Nut 87 25928 NUT, Flange 65 -- CONTROL VALVE See Index 88 F-436 COTTER, Flange Nut PM 2447 [ 25 ]
CLeIRK michican CLUTCH GROUP - FORWARD, REVERSE AND LOW (This Group used 3 times in Transmission Quantities listed below are for Clutch Group) 2284 DISC, Clutch Inner 6 228245 BEARING, Clutch Shaft 2 224772 DISC, Clutch Outer 5 (Inc. 2) 3 22576 BEARING, Clutch Disc Hub 2 945374 RING, Bearing Retaining 4 65463 RING, Return Spring Ret. 3 65965 RING, Bearing Retaining 5 66848 4 2583 RING, Clutch Shaft Seal 2 WASHER, Spring Ret. 5 224774 PLATE, Clutch Disc End 6 2579 SPRING, Piston Return 6 259 RING, End Plate Ret. 7 2577 PISTON, Clutch 7 22577 RING, Hub Oil Baffle 8 22477 RING, Piston Outer Seal 8 258 GEAR & HUB ASSY (28T) 9 22385 RING, Piston Inner Seal 9 2582 SPACER, Hub Bearing 227955 DRUM ASSY, Clutch (Inc. 2 22576 BEARING, Disc Hub A, B) (4T) 2 22578 BEARING, Clutch Shaft A 2576 t SEAT, Bleed Valve Ball 22 65965 RING, Bearing Ret. B J-6 t BALL, Bleed Valve 23 228223 CLUTCH ASSY (Inc. thru 22) -- Not Illustrated [ 26 ] PM 2447
CUIRK CONSTRUCTION MACHINERY DIVISION michican CLUTCH GROUP HIGH 2284 DISC, Clutch Inner 6 5 2583 RING, Clutch Shaft Sealing 2 2 224772 DISC, Clutch Outer 5 6 22385 RING, Piston Inner Sealing 3 224774 PLATE, Clutch Disc End 7 2577 PISTON, Clutch 4 259 RING, End Plate Ret. 5 22577 RING, Hub Oil Baffle 6 2579 SPRING, Piston Return 8 22477 RING, Piston Outer Sealing 9 2584 SHAFT, Clutch 2 227952 DRUM & GEAR ASSY, Clutch (Inc. 2A, 2B) (53T) 7 66848 WASHER, Spring Ret. 2A 2576 t SEAT, Bleed Valve Ball 8 65463 RING, Return Spring Ret. 2B J-6 t BALL, Bleed Valve 9 22576 BEARING, Disc Hub 2 228246 BEARING, High Gear 22795 HUB & GEAR, Clutch Disc 22 57688 RING, Bearing Retaining (4T) 23 2566 GEAR, High Clutch Shaft 227959 SPACER, Hub Bearing (26T) 2 22576 BEARING, Disc Hub 24 227949 SPACER, Gear 3 228245 BEARING, Clutch Shaft 25 65965 RING, Retaining 4 65965 RING, Bearing Retaining 26 228222 CLUTCH ASSY (Inc. thru 25) tnot Illustrated PM 2447 [ 27 ]
CUIRK CONTROL VALVE TRANSMISSION MICHIGAll ASSEMBLE VALVE WITH LETTER ON SPOOL END IN THIS POSITION C: 2 5 s 2 4 3 5 6 TS-8332-P A 2355 CONTROL VALVE ASSY (Inc. thru 3) 27928 PLUG, Stop 2 9F-8 -RING, Stop Plug 3 227672 SEAL, Piston Outer 4 25K-32 -RING, Piston 5 227674 PISTON 6 29342 VALVE, De-Clutch (Inc. thru 5, 7, 8, 9) 7 22435 SEAL, Oil 8 22893 SEAL, Band 9 25K-322 -RING ---- * VALVE, De-Clutch Control See "A" 29344 SPRING, Control Valve 2 2433 BREATHER 3 22575 SEAL, Manual Control Valve Oil 4 VALVE, Manual Control See "A" 5 --- VALVE, Manual Control See "A" 6 22575 SEAL, Manual Control Valve Oil 7 ---- HOUSING, Control Valve See "A" 8 6F- PLUG 9 6F- PLUG 2 C-78 BOLT, Housing to Trans. 4 2 4E-7 LKWSHR, Housing to Trans. 4 22 47K-3 PLUG, Detent 'I 23 222 SPRING, Detent 24 229 PIN, Detent 25 J-2 BALL, Detent 26 22462 SWITCH, Neutral Start 27 J-2 BALL, Detent 28 2594 PIN, Detent Stop 29 2547 SPRING, Detent 3 2299 GASKET, Housing to Trans. Not Sold Separately *NOTE: For correct operation of the de-clutch feature for this application must be installed with the letter "R" in the upright position. [ 28 ] PM 2447
CUIRK michican PARKING BRAKE ASSEMBLY A 2559 BRAKE ASSY (Inc. thru 3) 43D-6 NUT, Pawl to Plate 2 2 827 PLATE ASSY, Brake Backing (Inc., 3, 4, 5) 3 823 PAWL KIT, Brake (Inc., 4, 5) 2 4 88678 BOLT, Pawl to Plate 2 5 825 ROLLER, Brake Actuating 6 826 LEVER, Operating Cam 7 SHOE, Brake See 8 824 LINING KIT, Brake (Inc. 9) 9 23H-54 RIVET, Lining to Shoe - 2 893 SPRING, Shoe Return 2 892 SHOE ASSY, Brake (Inc. 7, 8, 9) 2 2 C-96 BOLT, Brake Mounting 4 3 4E-9 LKWSHR, Brake Mounting 4 Not Sold Separately PM 2447 [ 29 ]
CU IRK MICHICIM PARKING BRAKE CONTROLS No ---- HAND BRAKE LEVER ASSY 8 24C-528 BOLT, Cable Clamp to Lever 2 See Index 9 5366 CABLE, Parking Brake 2 8D-6 NUT, Lever Mounting 2 8D-5 NUT, Clamp 2 2A 5456 tspacer, Lever Mounting 64592 LINK, Cable Clamp 3 5455 SPACER, Lever Mounting 2 2 F-32 COTTER, Clevis Pin 4 8D-5 NUT, Cable Mounting 2 3 4F-66 PIN, Cable Clevis 4A 5456 tspacer, Lever Mounting 4 54452 CLAMP, Cable 5 5456 SPACER, Cable Mounting 2 5 24C-52 BOLT, Cable Clamp to Lug 2 6 54452 CLAMP, Cable 6 24C-644 BOLT, Lever Mounting 2 7 64592 LINK, Cable Clamp 7 5366 tbracket t Not Illustrated [ 3 ] PM 2447
CUIRK michigim PARKING BRAKE LEVER ASSEMBLY A 544998 LEVER ASSY (Inc. thru 2) 862655 SPACER, Pivot Bracket 866349 SCREW, Adjusting 862653 BRACKET, Pivot 2 94227 CAP, Adjusting Knob 2 862656 SPACER, Pivot Bracket 3 94226 BASE, Adjusting Knob 3 F-32 COTTER, Link Pivot Pin 4 25K-32 -RING 4 64595 SPACER, Mounting Bracket 2 5 866348 BODY, Brake Lever 5 944969 BRACKET, Lever Mounting 2 6 6924 WASHER, Body to Bracket 2 6 699 WASHER, Link Pivot Pin 7 862738 PIN, Adjusting Screw Link 7 94454 RIVET, Pivot Bracket Pivot 8 862652 LINK, Adjusting Screw 8 862656 SPACER, Pivot Bracket 9 94238 PIN, Link to Tube 9 862653 BRACKET, Pivot 2 944968 TUBE, Adjusting Screw PM 2447 [ 3
CUIRK mlchlgan 9 93 9 / 96 97 95 N TORQUE CONVERTER ASSEMBLY TS-88 - P [ 32 ] PM 2447
CUIRK MICHIGAll TORQUE CONVERTER ASSEMBLY A 2 3 4 5 6 7 8 9 2 3 4 5 6 7 8 9 2 2 22 23 24 25 26 27 28 28A 29 3 3 32 33 34 35 36 37 38 39 4 4 42 43 44 45 46 47 48 49 5 5 52 53 54 55 2829 3F-6 7298 2493 8546 3F-6 24949 25K-44 22232 22238 24946 4K-2 4K-2 24943 25K-38 22983 6678 4E-6 C-66 6678 2298 22982 ---- 25K-38 22983 3F-6 24936 2493 24956 24954 22439 7386 2496 5596 4523 8D-6 4E-6 27647 24929 24928 C-628 4E-6 6F-8 4K-2 74256 24937 743439 24945 4E-7 C-72 26864 25K-42 295 F-424 2745 24985 8D-7 CONVERTER ASSY, Torque (C273T-53) (Inc. thru 97,,, 2) PLUG, Pipe RING, Gear Retaining GEAR, Pump Drive (38T) HOUSING, Converter PLUG, Pipe GASKET, Regulating Valve to Converter -RING, Regulating Valve to Converter SPRING, Safety Valve PLUNGER, Safety Valve SEAT, Safety Valve PLUG, Valve Housing PLUG, Valve Housing VALVE ASSY, Pressure Regulating (Inc., 4, 5, 6, 9 thru 24) -RING, Piston Stop STOP, Piston PIN, Piston Stop LKWSHR, Valve to Converter BOLT, Valve to Converter PIN, Piston Stop SPRING, Valve Outer SPRING, Valve Inner PISTON, Valve See 3 -RING, Piston Stop STOP, Piston PLUG, Pipe BEARING, Pump Drive Shaft SPACER, Pump Drive Shaft BEARING, Pump Drive Shaft t RING, Bearing Retaining RING, Bearing Retaining RING, Washer Retaining SLEEVE, Pump Drive Adapter GASKET, Pump to Converter * PUMP, Converter Charging NUT, Pump Mounting LKWSHR, Pump Mounting STUD, Pump Mounting WASHER, Pump Drive Shaft SHAFT, Pump Drive BOLT, Baffle to Housing LKWSHR, Baffle to Housing PLUG, Pipe PLUG, Pipe BEARING, Output Shaft Front SHAFT, Output BEARING, Output Shaft Rear RETAINER & SEAL, Bearing (Inc. 49) LKWSHR, Bearing Ret. BOLT, Bearing Retainer SEAL, Oil -RING, Flange NUT, Output Shaft PIN, Cotter WASHER, Output Shaft FLANGE, Companion (6- C) NUT, Bearing Retainer, 3 3 2 4 4 3 3 3 3 3 3 6 6 6 3 3 3 3 2 3 3 2 Not Sold Separately t Not Illustrated *NOTE: When Converter Charging Pump replacement is required, only a new factory built and tested pump should be used. Proper operation of converter and transmission is dependent on an efficient charging pump. Damage possible by use of a field rebuilt pump can result in repair cost exceeding cost of a new pump alone. PM 2447 [ 33 ]
CUIRK MICHIGIM 5 36 4 46 I it 48 49 52 74 77 92 9 /- 93 8 9 96 95 94 82 98 89 99 I I + 88 83 84 TORQUE CONVERTER ASSEMBLY TS-88-P [34 ] PM 2447
CL/RK minion TORQUE CONVERTER ASSEMBLY (Continued) No: 56 4E-7 LKWSHR, Bearing Ret. ' 2 57 25K-452 -RING, Bearing Ret. 58 2473 STUD, Bearing Retainer 2 59 2239 RING, Bearing Retaining 6 24938 GEAR, Output Shaft (27T) 6 24935 GEAR, Turbine Shaft (28T) 62 24955 RING, Bearing Retaining 63 7422 BEARING, Turbine Shaft 64 24933 SHAFT, Turbine 65 24932 STATOR SUPPORT ASSY 66 22653 RING, Sealing 67 2495 GEAR, Impeller Hub 68 2249 RING, Gear Retaining 69 C-82 BOLT, Support to Hsg. 6 7 7E-8 LKWSHR, Support to Hsg. 6 7 22279 RING, Turbine Shaft Sealing 72 24953 RING, Bearing Retaining 73 22426 RING, Gear Retaining 74 24939 -RING, Oil Baffle 75 4C-74 BOLT, Hub to Impeller 8 75A ---- ttl-ockwire, Impeller Hub Bolt (8 ga.) 76 6925 WASHER, Hub to Impeller 8 77 25K-466 -RING, Impeller Hub 78 24596 BEARING, Impeller Hub 79 24934 SPACER, Reaction Member 8 74335 RING, Reaction Member Retaining 8 24924 **HUB, Turbine 82 6923 WASHER, Turbine Hub 8 83 2933 BOLT, Turbine Hub 8 83A ---- ttl-ockwire, Turbine Hub Bolt (8 ga.) 84 65965 RING, Turbine Hub Ret. 85 223833 **TURBINE 86 65965 RING, Turbine Hub Ret. 87 868 MEMBER, Reaction 87A 658244 tpin, Member to Spacer Lock 88 24953 RING, Bearing Retaining 89 24958 HUB, Impeller 9 24959 IMPELLER 9 24925 BAFFLE, Oil 92 2494 SEAL, Oil Baffle 93 24939 -RING, Impeller to Cover 94 666542 RING, Bearing Retaining 95 24988 BEARING, Impeller Cover 96 24922 COVER, Impeller 97 2226 SLEEVE, Impeller Cover 98 224795 BOLT, Gear to Flywheel 8 98A ---- f LOCKWIRE, Impeller Bolt (8 ga. 2" lg.) 4 99 2599 WASHER, Gear to Flywheel 8 25264 GEAR, Converter Drive C-66 BOLT, Impeller to Cover 24 2 4E-6 LKWSHR, Impeller to Cover 24 3 23C-62 t BOLT, Converter to Flywheel Housing 2 4 4E-6 t LKWSHR, Converter to Flywheel Housing 2 tnot Illustrated As Required **NOTE: Machine Serial 4A8 thru 4A, 4A3 thru 4A23 received a one piece Turbine Assembly. If replacement becomes necessary, service with items 8 thru 86. PM 2447 [ 35 ]
. - - - - 7(. - - ' > - - - - - - --.--- -, / -.-, -i. / I ', -,...--,, If i - // l id II, / k ( / I il \, - A-- I I i I, I ---' 4, ) I L,,:t-_)- ond", / 3 I (i<.2 @----4.r V 33 36 4 \ \kl CID 34,43 Nkial 5 I IC 5 4-4 t-32 3 ----- "4 --. / I /A --,,, i ---- - ----, / // 29.--;;F:N- /---'' ir -4--3 _. -- I ".. l 287 -. _ -'-- ) ) " / 7 / /77 27 / J t- / t./. 44 :,4k:;;- ''4Y-..,,. 8 I (/ 7 4, la,/. / A 45 2 22 23 24 r< N,.,(25 2,,, :,:t 58 N. / -`-, 46 59.,6...-_, 'r 56 _)- I / i --,.,,,,), 47 / 54, ') ( 7 I /../ 48 53 55 l'c, P.< I :-) I, -, j 49 --- L---- n 3 23 rn n PZI in. < ta a HYDRAULIC SYSTEM TRANSMISSION AND TORQUE CONVERTER 5 TS-959-P
CLIIRK HYDRAULIC SYSTEM - TRANSMISSION AND TORQUE CONVERTER MICHICAll RADIATOR ASSY See Index 2 529949 ELBOW, Hose to Radiator 3 529949 ELBOW, Hose to Radiator 4 4K-2 PLUG, Elbow 2 5 8D-6 NUT, Filter Mounting 4 6 53364 FILTER, Trans. & Converter (Inc. 6A) 6A 2552 tcartridge KIT, Filter 7 9F-8 -RING, Elbow 8 7K-8 ELBOW, Hose to Filter (Inc. 7) 9 5349 HOSE, Filter to Converter 559453 HOSE, Pipe to Radiator A 36F-5 t ADAPTER, Hose to Strainer _ 4K-6 PLUG, Strainer 2 53289 STRAINER, Oil (Inc. 2A) 2A 946943 tscreen, Strainer 3 32F-6 ELBOW, Hose to Pump 4 5K-828 NIPPLE, Pipe 5 ---- TORQUE CONVERTER ASSY See Index 5A 2433 tbreather, Torque Converter 5B 227265 tvalve, Breather Check 6 9F-8 -RING, Elbow 7 9F-6 -RING, Adapter 8 69279 ADAPTER, Hose to Converter (Inc. 7) 9 543 CLAMP, Hose to Nipple 2 524878 HOSE, Control Valve to Converter 2 543 CLAMP, Hose to Tube 22 529979 HOSE, Tube to Nipple 23 543 CLAMP, Hose to Nipple 24 667289 NIPPLE, Hose to Trans. 25 57429 ADAPTER, Hose to Valve (Inc. 26) 26 9F-6 -RING, Adapter 27 9F-8 -RING, Elbow 28 7K-8 ELBOW, Tube to Trans. (Inc. 27) 29 55323 SENDER, Converter Temperature t Not Illustrated 3 5343 3 8K-8 32 5349 33 53286 33A 24C-62 33B 6924 33C 4E-6 34 4E- 35 4D- 36 543 37 56887 38 568824 39 54638 4 5664 4 23C-66 42 4E-6 43 54636 44 52874 45 743563 46 52874 47 29F-5 48 666865 49 35668 5 54635 5 666846 52 53853 53 543 54 529979 55 53395 56 5283 57 29F-4 58 666846 59 526676 6 24C-624 6 9F-8 62 7K-8 63 534 64 4K-2 HOSE, Trans. to Converter ELBOW, Hose to Converter _ HOSE, Pipe to Converter PIPE, Cooler Inlet t BOLT, Pipe to Frame 2 twasher, Pipe to Frame 2 t LKWSHR, Pipe to Frame 2 LKWSHR, Sender Unit NUT, Sender Unit CLAMP, Hose 2 FILLER PLATE PLUG, Filler DIPSTICK, Oil Level GROMMET, Dipstick Tube BOLT, Filler Plate 2 LKWSHR, Filler Plate 2 TUBE, Dipstick CLAMP, Hose to Tube HOSE, Tube to Nipple (3ig.), CLAMP, Hose to Nipple ELBOW, Hose to Trans. NIPPLE, Hose BUSHING, Reducing HOSE, Filler NIPPLE, Filler Hose TUBE, Converter Drain CLAMP, Hose to Tube HOSE, Tube to Nipple TUBE, Cooler Return HOSE, Converter to Filter ELBOW, Hose to Pump NIPPLE, Hose ELBOW, Hose to Converter (Inc. 6) BOLT, Filter Mounting 4 -RING, Elbow ELBOW, Hose to Filter (Inc. 6) HOSE, Tube to Radiator PLUG, Elbow 2 PM 2447 [ 37 ]
CUIRK MICHIGAll MID-MOUNT BEARING ASSEMBLY A 23553 BEARING ASSY, Mid-Mount 7 23529 HOUSING, Bearing (Inc. thru 4, 7 thru 33) 8 2433 BREATHER, Bearing F-436 COTTER, Flange Pin 9 6544 CONE, Bearing 2 25928 NUT, Flange 2 85625 CUP, Bearing 3 22279 WASHER, Flange 2 225823 SEAL, Brg. Cap 4 25K-66 -RING, Flange 22 25K-438 -RING, Brg. Cap 5 222233 FLANGE 23 27566 $SHIM, Brg. Cap (.4) 6 2369 CAP, Bearing 23A 27567 tshim, Brg. Cap (.7) 7 27566 $SHIM, Brg. Cap (.4) 23B 27568 $SHIM, Brg. Cap (.) 7A 27567 SHIM, Brg. Cap (.7) 24 27565 CAP, Bearing 7B 27568 $SHIM, Brg. Cap (.) 25 222233 FLANGE 8 25K-438 -RING, Brg. Cap 26 25K-66 -RING, Flange 9 2 225823 85625 6544 2854 As Required SEAL, Brg. Cap CUP, Bearing CONE, Bearing SHAFT, Mid-Mt. Brg. 27 28 29 22279 25928 F-436 WASHER, Flange NUT, Flange COTTER, Flange Pin 3 4E-7 LKWSHR, Cap to Hsg. 4 3 C-722 BOLT, Cap to Hsg. 4 4 C-722 BOLT, Cap to Hsg. 4 3 4E-7 LKWSHR, Cap to Hsg. 4 5 23C-4 BOLT, Brg. to Frame 4 32 3F-2 PLUG 6 4E- LKWSHR, Brg. to Frame 4 33 25757 PLUG, Drain [ 38 ] PM 2447.
CLARK MICHIGAN PROPELLER SHAFT ASSEMBLIES Transmission to Rear Axle Converter to Transmission Mid Mount Bearing to Front Axle Transmission to Mid Mount Bearing A PROPELLER SHAFT ASSY (Inc. thru 6) 5494 53474 53928 53928 BOLT, Spider & Bearing to Tube 94229 9489 94229 94229 4 2 SPIDER & BEARING ASSY 942735 944862 942735 942735 3 TUBE 94574 94557 946 946 4 NUT, Spider & Bearing to Tube 8D-8 8D-6 8D-8 8D-8 4 5 RETAINER, Felt 9425 949 9425 9425 6 WASHER, Felt Retainer 9425 949 9425 9425 2 7 SLIP YOKE (Inc. 2) 942734 9493 942734 942734 8 NUT, Spider & Bearing to Slip Yoke 8D-8 8D-6 8D-8 8D-8 4 9 SPIDER & BEARING ASSY 942735 944862 942735 942735 BOLT, Spider & Bearing to Slip Yoke 94229 9489 94229 94229 4 FITTING, Spider & Bearing Grease 944688 H-35 H-35 H-35 2 FITTING, Slip Yoke Grease H-25 H-25 H-25 H-25 3 FELT WASHER 942749 9492 942749 942749 4 BOLT, Spider & Bearing Attaching 94229 9489 94229 94229 8 5 FITTING, Spider & Bearing Grease 944688 H-35 H-35 H-35 6 NUT, Spider & Bearing Attaching 8D-8 8D-6 8D-8 8D-8 8 PM 2447 [ 39
2 3 4 5 6 V n 77 4. 76 5 4 73 72 7 7 2 22 23 24 25 26 2 28 29 3 3 32 O Its 69 68 7 62 6 42 4 39 38 37 36 a V3 AXLE ASSEMBLY FRONT DRIVE TS-7726-P =I
CUIRK AXLE ASSEMBLY - FRONT DRIVE MICHIG A 953 77425 2 77424 3 9369 4 262 5 8383 6 228 7 3522 8 742262 9 742263 6234 4C-82 2 ---- 3 4E-8 4 924 5 923 6 92 7 559 8 8786 9 559 2 ---- 2 6547 22 7225 23 3E-9 24 C-98 25 7448 26 22423 27 3292 28 6457 29 85565 3 F-2 3 2278 32 C-72 33 242 34 7445 35 885 36 36A 939 36B 94 37 442 38 838 39 ---- 4 7735 4 8349 42 965 43 ---- 44 25K-624 AXLE ASSY (Inc. thru 47, 49, 52 thru 77) CONE, Inner Hub Bearing 2 CUP, Inner Hub Bearing 2 PLUG, Hub Filler 2 NUT, Wheel Stud 2 HUB ASSY (Inc. 2, 8) 2 STUD, Wheel 2 NUT, Wheel 2 CUP, Outer Hub Bearing 2 CONE, Outer Hub Bearing _ 2 SHAFT, Axle 2 BOLT, Hub to Gear 24 LOCKWIRE 8 Gauge LKWSHR, Hub to Gear 24 PLATE, Hub to Gear Ret. 2 HUB, Internal Gear 2 GEAR, Internal Ring 2 NUT, Spindle 2 LOCK, Spindle Nut 2 NUT, Spindle 2 PLANET CARRIER See Index WASHER, Carrier to Hub 4 BOLT, Carrier to Hub 4 LKWSHR, Planet Puller Hole 6 BOLT, Planet Puller Hole 6 GEAR, Sun 2 RING, Sun Gear Retaining 2 -RING, Thrust Cap 2 WASHER, Sun Gear Thrust _ 2 KIT, Sun Gear Thrust Cap (Inc. 27, 28, 3, 3) 2 PLUG, Thrust Cap 2 LKWSHR, Thrust Cap 2 BOLT, Thrust Cap 2 SEAL, Hub Oil 2 CATCHER, Oil 2 DRUM, Brake 2 CAM SHAFT, Brake RIGHT HAND - I - LEFT HAND WASHER, Drum to Hub 24 BOLT, Drum to Hub 24 LOCKWIRE, 8 Gauge WASHER, Cam Shaft Thrust _ 2 BOLT, Brake & Spindle to Housing 2 SPRING, Brake Shoe Return _ 2 BRAKE ASSY, Front See Index -RING, Cam Shaft 2 45 7739 46 E-35 47 2H-5 48 84 48A 2695 49 9853 5 4E-6 5 8C-62 5A 8C-66 52 264 53 94 54 7736 55 6656 56 289 57 H-25 58 7247 59 7 6 659764 6 6A 7632 6B 763 62 7697 62A 94623 63 C-56 64 4E- 65 6547 66 7C-928 66A 7C-932 66B 7C-94 67 ---- 67A ---- 68 64D-9 69 6547 7 2295 7 442 72 6998 73 9469 74 2294 75 267 75A 2F-24 76 F-2 77 6656 BUSHING, Brake Spider 2 RETAINER, Cam Shaft Grease 2 FITTING, Brake Spider Grease 2 *COVER, Brake Dust 4 t*plate, Dust Cover 2 RING, Sun Gear Thrust 2 *LKWSHR, Dust Cover 8 * BOLT, Dust Cover 4 * BOLT, Dust Cover 4 SPINDLE 2 SPACER, Air Chamber Brk. 4 WASHER, Cam Shaft 2 RING, Bushing Retaining 2 BUSHING, Air Chamber Brk. 2 FITTING, Air Chamber Brk. _ 2 **ADJUSTER, Slack B.W. #222485 2 WASHER, Slack Adjuster 2 RING, Slack Adjuster Ret. 2 BRACKET ASSY, Air Chamber (Inc. 56) RIGHT HAND - LEFT HAND **CHAMBER, Air B.W. #27957 (Inc. 62A) t DIAPHRAGM, Air Chamber B.W. #23499 2 BOLT, Bracket to Housing 4 LKWSHR, Bracket to Hsg. 4 WASHER, Carrier to Hsg. BOLT, Carrier to Housing 7 BOLT, Carrier to Housing 2 BOLT, Carrier to Housing 2 DIFF. & CARRIER ASSY See Index PERMATEX #2 Diff. & Carrier to Housing NUT, Carrier to Housing 3 WASHER, Carrier to Housing 3 DOWEL, Carrier to Stud 3 WASHER, Brake & Spindle to Housing 2 NUT, Brake & Spindle to Housing 2 PLUG, Housing Drain STUD, Carrier to Housing 3 HOUSING, Axle PLUG, Housing Expansion PLUG, Housing Filler BREATHER, Housing tnot Illustrated tas Required *NOTE: Optional Equipment Not furnished with machine. **NOTE: Your Bendix-Westinghouse Distributor is equipped to service components of these parts. PM 2447 [ 4 ]
3 4 5 5 n Z tn m C n Z 3 x:. n Z rrt Pa "< 35 36 3 38 39 4 4 42 tf)... Z DIFFERENTIAL AND CARRIER ASSEMBLY REAR DRIVE TS-2649-P a F3 = C, =I=
CUIRK DIFFERENTIAL AND CARRIER ASSEMBLY - FRONT DRIVE A 8959 DIFF. & CARRIER ASSY (Inc. 26A 29 SHIM, Bearing Cage thru 46) Medium 94 LOCK, Adjusting Nut 2 26B 22 ttshim, Bearing Cage Thick 2 4E-6 LKWSHR, Adjusting Nut Lock 2 27 2 CAGE, Outer Pinion Brg. (Inc. 24, 28) 3 3C-64 BOLT, Adjusting Nut Lock 2 28 675259 CUP, Outer Pinion Bearing _ 4 675252 CUP, Differential Bearing 2 29 67526 CONE, Outer Pinion Bearing 5 675254 CONE, Differential Bearing _ 2 3 72 SEAL, Pinion Shaft Oil 6 8479 BOLT, Differential Case 8 3 27 GASKET, Pinion Shaft Oil 7 468 NUT, Ring Gear 2 Seal 8 DIFFERENTIAL CASE, Flange Half See 5 32 4E- LKWSHR, Oil Seal Retainer _ 7 33 C-32 BOLT, Oil Seal Retainer 9 RING GEAR See 49 _ 7 34 222 DEFLECTOR, Pinion Dust 96 BOLT, Ring Gear 2 35 223 NUT, Pinion Shaft 8478 WASHER, Side Gear Thrust _ 2 36 F-74 COTTER, Pinion Shaft Nut 2 24 WASHER, Differential Pinion Thrust 4 37 224 WASHER, Pinion Shaft 3 85746 PINION KIT, Differential 38 887 FLANGE, Companion 4 75 SPIDER, Differential 39 C-828 BOLT, Oil Seal Retainer Locating 5 626 GEAR, Differential Side 2 6 ---- 4 4E-8 LKWSHR, Oil Seal Retainer DIFFERENTIAL CASE, Plain Locating Half See 5 4 24 7 523 NUT, Differential Case 8 RETAINER, Oil Seal 42 7483 8 675265 BEARING, Inner Pinion GASKET, Oil Seal Retainer _ 43 224 9 ---- PINION See 49 SCREW, Differential Thrust _ 2 2 BOLT, Carrier Cap 4 44 OMIT Not Used 2A 658 twasher, Carrier Cap 4 45 2242 NUT, Differential Thrust Screw 2 ---- CAP, Differential Carrier 46 23 NUT, Differential Adjusting _ 2 See 22 2 47 2243 T DIFFERENTIAL ASSY (Inc. 22 8552 CARRIER ASSY, Differential 6 thru 7, 9) (Inc. 2, 2A, 2) 48 2237 tdifferential BODY SUB- 23 675263 CONE, Center Pinion Bearing ASSY (Inc. 6, 8, thru 7) 24 675262 CUP, Center Pinion Bearing 49 7693 tgear & PINION SET (Inc. 9, 9) 25 852 SPACER KIT, Pinion Bearing _ 5 85737 tdifferential CASE KIT (Inc. 26 28 SHIM, Bearing Cage Thin _ 6, 8,, 2, 6, 7) Not Sold Separately tnot Illustrated tas Required *NOTE: 8552 Differential and Carrier Assembly also includes 226 Thrust Screw, t227 Thrust Screw Lock, 8D-8 Thrust Screw Nut, 3 64D-9 Stud Nut, 7 7C-928 Carrier Bolt, 2 7C-932 Carrier Bolt, 2 7C-94 Carrier Bolt, 3 2294 Carrier Stud, 3 2295 Taper Dowel and 4 6547 Carrier Washer. PM 2447 [ 43 ]
2 3 4 5 6 77 (et 76 75 74 3 72 7 7 -. 53 52 5 5 49 48 67 66 65 64 63 V-C 47 46 45 44 43 ( #/J N 62 6 57 56 55 54 42 4 4 39 38 37 36 34 33 a AXLE ASSEMBLY - REAR DRIVE TS-7726-P 87
CUIRK AXLE ASSEMBLY - REAR DRIVE mann A 9533 AXLE ASSY (Inc. thru 47, 44 25K-624 -RING, Cam Shaft 2 49, 52 thru 77) 45 7739 BUSHING, Brake Spider 2 77425 CONE, Inner Hub Bearing 2 46 E-35 RETAINER, Cam Shaft Grease 2 2 77424 CUP, Inner Hub Bearing 2 47 2H-5 FITTING, Brake Spider 3 9369 PLUG, Hub Filler 2 Grease 2 4 262 NUT, Wheel Stud 2 48 84 *COVER, Brake Dust 4 5 8383 HUB ASSY (Inc. 2, 8) 2 48A 2695 t*plate, Dust Cover 2 6 228 STUD, Wheel 2 49 9853 RING, Sun Gear Thrust 2 7 3522 NUT, Wheel 2 5 4E-6 *LKWSHR, Dust Cover 8 8 742262 CUP, Outer Hub Bearing 2 5 8C-62 * BOLT, Dust Cover 4 9 742263 CONE, Outer Hub Bearing _ 2 5A 8C-66 * BOLT, Dust Cover 4 6234 SHAFT, Axle 2 52 264 SPINDLE 2 4C-82 BOLT, Hub to Gear 24 53 94 SPACER, Air Chamber Brk. _ 4 2 ---- LOCKWIRE 8 Gauge 54 7736 WASHER, Cam Shaft 2 3 4E-8 LKWSHR, Hub to Gear 24 55 6656 RING, Bushing Retaining 2 4 924 PLATE, Hub to Gear Ret. 2 56 289 BUSHING, Air Chamber Brk. 2 5 923 HUB, Internal Gear 2 57 H-25 FITTING, Air Chamber Brk. _ 2 6 92 GEAR, Internal Ring 2 58 7247 **ADJUSTER, Slack B.W. 7 559 NUT, Spindle 2 #222485 2 8 8786 LOCK, Spindle Nut 2 59 7 WASHER, Slack Adjuster 2 9 559 NUT, Spindle 2 6 659764 RING, Slack Adjuster Ret. 2 2 PLANET CARRIER See Index 6 BRACKET ASSY, Air Chamber 2 6547 WASHER, Carrier to Hub 4 (Inc. 56) 22 7225 BOLT, Carrier to Hub 4 6A 7632 LEFT HAND 23 3E-9 LKWSHR, Planet Puller Hole 6 6B 763 RIGHT HAND 24 C-98 BOLT, Planet Puller Hole 6 25 7448 GEAR, Sun 2 62 7697 **CHAMBER, Air B.W. 26 22423 RING, Sun Gear Retaining _ 2 #27957 (Inc. 62A) 2 27 3292 -RING, Thrust Cap 2 62A 9462. 3 t DIAPHRAGM, Air Chamber _ 2 28 6457 WASHER, Sun Gear Thrust _ 2 63 C-56 BOLT, Bracket to Housing 4 29 85565 KIT, Sun Gear Thrust Cap 64 4E- LKWSHR, Bracket to Hsg. 4 (Inc. 27, 28, 3, 3) 2 65 6547 WASHER, Carrier to Hsg. 3 F-2 PLUG, Thrust Cap 2 66 7C-928 BOLT, Carrier to Housing 7 3 2278 LKWSHR, Thrust Cap 2 66A 7C-932 BOLT, Carrier to Housing 2 32 C-72 BOLT, Thrust Cap 2 66B 7C-94 BOLT, Carrier to Housing 2 33 242 SEAL, Hub Oil 2 67 ---- DIFF. & CARRIER ASSY 34 7445 CATCHER, Oil 2 See Index 35 885 DRUM, Brake 2 67A ---- tt PERMATEX #2 Diff. & Carrier to Housing 36 CAM SHAFT, Brake 68 64D-9 NUT, Carrier to Housing 3 36A 939 LEFT HAND 69 6547 WASHER, Carrier to Housing 3 36B 94 t RIGHT HAND 7 2295 DOWEL, Carrier to Stud 3 7 442 WASHER, Brake & Spindle 37 442 WASHER, Drum to Hub 24 to Housing 2 38 838 BOLT, Drum to Hub 24 72 6998 NUT, Brake & Spindle to 39 ---- $LOCKWIRE, 8 Gauge Housing 2 4 7735 WASHER, Cam Shaft Thrust 2 73 9469 PLUG, Housing Drain 4 8349 BOLT, Brake & Spindle to 74 2294 STUD, Carrier to Housing 3 Housing 2 75 267 HOUSING, Axle 42 965 SPRING, Brake Shoe Return 2 75A 2F-24 t PLUG, Housing Expansion 43 ---- BRAKE ASSY, Rear See 76 F-2 PLUG, Housing Filler Index 77 6656 BREATHER, Housing t Not Illustrated Not Sold Separately tas Required *NOTE: Optional Equipment Not furnished with machine. **NOTE: Your Bendix-Westinghouse Distributor is equipped to service components of these parts. PM 2447 [45 ]
5 6 n n 42 3 38 39 4 4 B DIFFERENTIAL AND CARRIER ASSEMBLY REAR DRIVE TS-2649-P C3 =I
CUIRK michigan DIFFERENTIAL AND CARRIER ASSEMBLY - REAR DRIVE A 85 DIFF. & CARRIER ASSY (Inc. 26 435 SHIM, Brg. Cage Thin thru 46) 26A 4352 tt SHIM, Brg. Cage Medium 94 LOCK, Adjusting Nut 2 26B 4353 tt SHIM, Brg. Cage Thick 2 4E-6 LKWSHR, Adjusting Nut 2 27 2 CAGE, Outer Pinion Brg. 3 3C-64 BOLT, Adjusting Nut Lock 2 (Inc. 24, 28) 4 675252 CUP, Differential Bearing 2 28 675259 CUP, Outer Pinion Brg. 5 675254 CONE, Differential Bearing 2 29 67526 CONE, Outer Pinion Brg. 6 8479 BOLT, Differential Case 8 3 72 SEAL, Pinion Shaft Oil 7 468 NUT, Ring Gear 2 3 27 GASKET, Pinion Oil Seal 8 DIFFERENTIAL CASE, Flange 32 4E- LKWSHR, Seal Retainer 7 Half See 5 33 C-32 BOLT, Oil Seal Retainer 7 9 RING GEAR See 49 34 222 DEFLECTOR, Pinion Dust 96 BOLT, Ring Gear 2 8478 WASHER, Side Gear Thrust 2 35 223 NUT, Pinion Shaft 2 24 WASHER, Diff. Pinion Thrust 4 36 F-74 COTTER, Pinion Shaft Nut 3 85746 PINION KIT, Differential 37 224 WASHER, Pinion Shaft 4 75 SPIDER, Differential 38 887 FLANGE, Companion 5 626 GEAR, Differential Side 2 39 C-828 BOLT, Oil Seal Retainer 6 DIFFERENTIAL CASE, Plain 4 4E-8 LKWSHR, Oil Seal Retainer Half See 5 4 24 RETAINER, Oil Seal 7 523 NUT, Differential Case 42 7483 GASKET, Oil Seal Retainer 8 675265 BEARING, Inner Pinion 43 226 SCREW, Differential Thrust 9 PINION See 49 44 227 LOCK, Diff. Thrust Screw 2 2 BOLT, Carrier Cap 4 45 8D-8 NUT, Diff. Thrust Screw 2A 658 "[WASHER, Carrier Cap 4 46 23 NUT, Diff. Adjusting 2 2 ---- CAP, Differential Carrier See 22 22 8552 * CARRIER ASSY, Differential (Inc. 2, 2A, 2) 47 855 t DIFFERENTIAL ASSY (Inc. 6 thru 7, 9) 48 854 "[DIFFERENTIAL BODY SUB- ASSY (Inc. 6, 8, thru 7) 23 675263 CONE, Center Pinion Brg. 49 6632 t GEAR & PINION SET (Inc. 9, 9) 24 675262 CUP, Center Pinion Brg. 5 85737 "[DIFFERENTIAL CASE KIT (Inc. 25 852 SPACER KIT, Pinion Brg. 6, 8,, 2, 6, 7) Not Sold Separately Not Illustrated As Required *NOTE: 8552 Carrier Assembly also includes 226 Thrust Screw, 227 Thrust Screw Lock, 8D-8 Thrust Screw Nut, 3 64D-9 Stud Nut, 7 7C-928 Carrier Bolt, 2 7C-932 Carrier Bolt, 2 7C-94 Carrier Bolt, 3 2294 Carrier Stud, 3 2295 Taper Dowel and 4 6547 Carrier Washer. PM 2447 [ 47 ]
CLeiRK MICHICAll PLANET CARRIER ASSEMBLY - FRONT AND REAR A 92 CARRIER ASSY (Inc. thru 9) 4 NOTE: Two Carriers are used on axle Quantities listed below are for () Carrier. 6357 WASHER, Pinion Thrust 3 2 6358 ROLLER, Pinion 75 3 6359 SPACER, Pinion Roller 3 4 6584 PINION 3 5 6358 ROLLER, Pinion 75 6 6357 WASHER, Pinion Thrust 3 7 J-2 BALL, Pinion Shaft Lock 3 8 6355 SHAFT, Pinion 3 9 755 CARRIER, Planet [ 48 ] PM 2447
CLARK MICHIGAN BRAKE ASSEMBLY - FRONT AND REAR A 265 BRAKE ASSY (Inc. thru 3, 6 thru 22) NOTE: Four Brakes are used on machine Quantities listed below are for Brake. 4299 SHOE ASSY, Brake (Inc. 3 thru 6, 9 thru 2, 6 thru 8) 2 348 SPIDER, Brake 3 22 ROLLER, Brake Cam 4 22 PIN, Brake Cam Roller 5 F-38 COTTER, Roller Pin Lock 6 855 PIN, Cam Roller Pin Lock 7 62D-6 NUT, Spring Anchor Pin 8 4E-6 LKWSHR, Spring Anchor Pin 9 3249 PLUG, Brake Lining 4 2 2 2 2 2 2 2 32 439 A 43 B 432 2 3 226 4 6927 5 F-42 6 222 7 24E-6 8 62D-6 9 C-82 2 4E-8 2 223 22 9597 BOLT, Lining to Shoe LINING, Brake Shoe STANDARD OVERSIZE (Ye) SHOE, Brake See PIN, Spring Anchor WASHER, Spring Anchor Pin COTTER, Spring Anchor Pin BUSHING, Brake Shoe LKWSHR, Lining to Shoe NUT, Lining to Shoe BOLT, Puller Hole Plug LKWSHR, Puller Hole Plug PIN, Anchor SCREW, Anchor Pin Set 32 4 4 2 2 2 2 2 32 32 2 2 2 2 Not Sold Separately PM 2447 [ 49 ]
CUIRK MICHIG NOTES [5] PM 2447
CMRK MICHIG BRAKE VALVE AND CONTROLS 24C-664 BOLT, Pedal to Bearing 2 568659 PEDAL ASSY, Air Brake 3 875766 PIN, Pedal to Roller 4 F-32 COTTER, Pedal Pin 5 F-32 COTTER, Pedal Pin 6 875767 PIN, Pedal to Valve 7 58259 ROLLER, Pedal 8 24C-52 BOLT, Valve Mounting 3 9 8D-5 NUT, Valve Mounting 3 945996 *VALVE, Air Brake B.W. #277472 66D-6 NUT, Bearing Mounting 2 8D-6 NUT, Bearing Jam 3 66D-6 NUT, Pedal to Bearing 4 52589 BEARING, Spherical *NOTE: Your local authoried Bendix-Westinghouse Distributor is equipped to service components of these parts. PM 2447 [ 5 ]
24 j 25.or 2 4 43 44 4 (a).., 47 48 3 4 r 49 5 Al 5 52 3 32 /33 3, 36 55 53 54 56 57 58 In cj 5 4 t t3 2 7 7-8 -CV:4/9/ At, 63 62 6 6 6t4 V ) a BRAKE AIR LINES TS-979-P 7
CLARK BRAKE AIR LINES MICHIG 53435 SENDER, Air Pressure la 2E- t LKWSHR, Sender Unit B 4D- t NUT, Sender Unit 2 9F-4 BUSHING, Reducing 3 28F-3 TEE, Hose & Sender to Res. 4 5K-49 NIPPLE, Pipe 5 9F-4 BUSHING, Reducing 6 3F- ADAPTER, Hose to Tee 7 26F-4 ELBOW, Hose to Res. 8 59337 VALVE, Check 9 53984 HOSE, Compressor to Res. 23C-544 BOLT, Governor to Comp. 2 4E-5 LKWSHR, Governor to Comp. 2 2 5436 *GOVERNOR (B.W. #2752) 3 942646 GASKET, Governor 4 COMPRESSOR Furnished with Engine 5 54888 INLET, Compressor 6 8752 GASKET, Inlet to Comp. 7 549243 HOSE, Tube to Inlet 8 543 CLAMP, Hose 2 9 4E-5 LKWSHR, Inlet to Comp. 2 2 23C-532 BOLT, Inlet to Comp. 2 2 95948 GASKET, Flange to Comp. 22 522846 FLANGE, Discharge 23 4E-5 LKWSHR, Discharge Flange 2 24 23C-528 BOLT, Discharge Flange 2 25 53854 TUBE, Air Intake 26 543 CLAMP, Hose 2 27 549243 HOSE, Intake Tube 28 85F-7 ELBOW, Flange to Hose 29 3F- ADAPTER, Hose to Governor 3 59436 HOSE, Governor to Res. 3 24C-62 BOLT, Bracket to Frame 4 32 5785 VALVE, Safety 33 9F-5 BUSHING, Reducing 34 53857 TUBE, Hose to Reservoir 35 57882 HOSE, Tube to Tube 36 5385 TUBE, Rear Cross 37 AIR CHAMBER L.H. Rear See Index 38 25F-2 ELBOW, Hose to Chamber 39 53982 HOSE, Tube to Chamber 4 53856 TUBE, Reservoir to Valve Feed 4 5495 HOSE, Cross to Trans. 42 3F- ADAPTER, Hose to Cross 43 9F-4 BUSHING, Reducing 44 63626 SWITCH, Stop Light 45 9F-4 BUSHING, Reducing 46 2F-4 CROSS 47 38F- CONNECTOR, Tube to Cross 48 5692 HOSE, Cross to Tee 49 36699 CONNECTOR, Tee 5 53983 HOSE, Tube to Tube 5 5385 TUBE, Hose to Tee 52 56858 TUBE, Reservoir to Valve Feed 53 3F-8 PLUG, Pipe 4 54 3F-4 PLUG, Pipe 55 BRAKE FOOT VALVE See Index 56 5K-42 NIPPLE, Pipe 57 26F-4 ELBOW, Hose to Valve 58 43F-8 ELBOW, Tube to Valve 59 53855 TUBE, Cross to Valve 6 56854 HOSE, Air Chamber Connecting 6 38F-7 ADAPTER, Hose to Chamber 62 4K-4 PLUG, Air Chamber 63 ---- AIR CHAMBER, Front See Index 2 64 57695 HOSE, Tube to Valve 65 38F-7 ADAPTER, Hose to Chamber 66 524657 ELBOW, Tube to Air Chamber 67 53873 TUBE, Hose to Air Chamber 68 52825 HOSE, Tube Connecting 69 HOSE See 4 7 62588 ELBOW, Hose to Trans. 7 53982 HOSE, Tube to Chamber 72 25F-2 ELBOW, Hose to Chamber 73 AIR CHAMBER, R.H. Rear See Index 74 42F-9 ELBOW, Tube to Tee 75 7F-4 TEE, Connecting 76 8D-6 NUT, Bracket to Frame 4 77 9483 *BRACKET, Reservoir Mounting (B.W. #22399) 2 78 54977 RESERVOIR, Air 79 72F-4 DRAIN COCK, Reservoir t Not Illustrated *NOTE: Your local authoried Bendix-Westinghouse Distributor is equipped to service components of these parts. PM 2447 [53
2 22 In C n th n 25 26 27 28 29 3 3 32 43 42 4 4 39 38 37 36 35 34 33 49 48 47 46 45 44 a STEERING GEAR ASSEMBLY TS-4787-P
CUIRK michican STEERING GEAR ASSEMBLY A 566434 GEAR ASSY (Inc. thru, 3 thru 2, 24 thru 49, 5, 52, 53) 25 J-9 25A 853526 BALL tguide, Ball Return 6 4 85756 NUT, Pitman Arm 26 853525 NUT, Ball 2 4E-8 LKWSHR, Pitman Arm 27 2E-6 LKWSHR, Side Cover 3 3 85339 SEAL, Pitman Shaft Grease 28 C-62 BOLT, Side Cover 3 4 853357 BUSHING, Pitman Shaft 29 85382 COVER, Hsg. Side (Inc. 33) 5 945334 VALVE ASSY (Inc. 42, 43, 44) 3 85387 SHIM KIT, Lash Adjuster 6 73G-732 BOLT, Adapter to Housing 4 3 8D-7 NUT, Lash Adjuster 6A 4E-7 t -(WSHR, Adapter to Hsg. 4 32 8577 ADJUSTER, Lash 7 943426 ADAPTER, Valve to Hsg. 33 BUSHING, Side Cover (Inc. 36, 37) 34 85756 GASKET, Side Cover 8 88685 -RING, Spacer to Adapter _ 35 94 GEAR, Pitman Shaft 9 85338 GASKET, Adapter to Housing 36 8674 BEARING, Adapter 85762 BOLT & WASHER ASSY, Clamp 37 25K-48 -RING, Adapter 853527 CLAMP, Ball Return Guide _ 38 86997 BEARING, Worm Thrust 2 *ELBOW, Filler 39 943438 WASHER, Worm Thrust 3 7343 BEARING, Needle 4 36626 -RING, Valve to Spacer 4 94638 HOUSING ASSY (Inc. 4, 3) 4 94344 SPACER, Valve 5 5K-432 NIPPLE, Filler 42 SPOOL, Valve See 5 6 22F-4 CAP, Filler 43 943437 SPRING, Valve 4 7 94639 SHAFT ASSY (Inc.,, 25, 44 943436 PLUNGER, Valve 8 25A, 26) 45 943438 WASHER, Bearing Thrust 8 857729 BEARING ASSY, Upper 9 86768 WASHER, Upper Bearing 2 853395 SPRING, Upper Bearing 46 36626 RING, Valve to Spacer 47 86997 BEARING, Worm Thrust 48 3E-8 LKWSHR, End Cover 6 2 5833 WHEEL, Steering 49 C-888 BOLT, End Cover 6 22 54874 PLATE, Operating Precaution 5 566433 ARM, Pitman 22A 65G-46. SCREW, Plate Attaching 4 5 87325 NUT, Worm Bearing Lock 23 64834 NUT, Steering Wheel 52 943439 COVER, Valve End 24 853384 KEY, Steering Wheel 53 943429 SPRING, Valve Spool Preload Not Sold Separately t Not Illustrated *NOTE: This item is not used on this machine. PM 2447 [ 55 ]
CUIRK MICHIGAII STEERING GEAR MOUNTING GROUP 8D-6 NUT, "U" Bolt 2 2 5744 "U" BOLT, Steering Gear to Cockpit 3 STEERING GEAR ASSY See Index 4 54594 "U" BOLT, Steering Gear to Cockpit 5 8D-8 NUT, Steering Gear Clamp 2 6 PITMAN ARM See Index 7 DRAG LINK See Index 8 24C-836 BOLT, Steering Gear Clamp 2 9 5544 CLAMP, Steering Gear 4K-2 PLUG, Steering Valve 8D-8 NUT, "U" Bolt 2 [ 56 ] PM 2447
CLeiRK MICHIGAIll STEERING DRAG LINK A 5687 DRAG LINK ASSY (Inc. 2, 3, 5 thru, 2 thru 5) F-432 COTTER 2 876575 NUT, Adjusting 3 865965 SEAT, Ball Stud 4 2H-5 FITTING, Grease 5 865965 SEAT, Ball Stud 6 86596 SPRING 7 66269 SEAT, Spring 8 865963 SEAT 9 865963 SEAT 865965 SEAT, Ball Stud H-25 FITTING, Grease 2 865965 SEAT, Ball Stud 3 86596 SPRING 4 66269 SEAT, Spring 5 876575 NUT, Adjusting 6 F-432 COTTER PM 2447 [ 57 ]
CLARK MICHICAll PRESSURE RELIEF VALVE - STEERING SYSTEM A 536539 VALVE ASSY (Inc. thru 7) 2 NOTE: Two (2) Valves used per machine Quantities listed below are for one () Valve. 47D-5 NUT, Acorn 2 663792 WASHER, Stat-O-Seal 2 3 944467 CAP, Valve 4 883734 PLUNGER, Pilot 5 89939 -RING 6 944469 SEAT, Pilot 7 944646 SPRING 8 944645 SEAT, Poppet 9 BODY, Valve Order "A" SCREEN, Poppet Order 944643 POPPET ASSY (Inc. ) 2 89938 RING, Back-Up 3 94447 SPRING, Pilot 4 9F-6 -RING, Valve Cap 5 8D-5 NUT, Jam 6 33G-54 SCREW, Adjusting Set 7 4K-2 t PLUG 2 Not Sold Separately -tnot Illustrated [ 58 ] PM 2447
CUIRK minion STEERING CYLINDER ASSEMBLY 3 /2" ' A 5395 STEERING CYLINDER ASSY 2 53264 RING, Piston Wear (Inc., 2, 5 thru 23, 25, 26) 2 3 25K-438 -RING, Cylinder Cap NOTE: Two (2) Cylinders used per machine Quantities 4 53297 RING, Back-Up listed below are for one () Cylinder. 5 56238 CAP, Cylinder 8D-7 NUT, Cylinder Cap 4 6 524 ADAPTER, Male 2 2 53949 CYLINDER 7 53868 PACKING ASSY 3 H-5 FITTING, Cylinder Grease 8 52399 ADAPTER, Female 2 4 7348 BUSHING, Cylinder 9 52645 GLAND, Packing 5 5375 NUT, Piston Rod 2 94568 SEAL, Piston Rod 2 52797 RETAINER, Seal 6 F-64 COTTER, Piston Rod Nut 22 LOCKWIRE (6 ga. x 2" lg.) 2 7 25K-44 -RING, Piston Rod 23 4C-62 BOLT, Seal Retainer 4 8 53264 RING, Piston Wear 24 53942 ROD, Piston 9 5363 RING, Piston Outer Seal 25 H-5 FITTING, Piston Rod Grease 53629 RING, Piston Inner Seal 26 7348 BUSHING, Piston Rod 53639 PISTON 27 24C-748 BOLT, Cylinder Cap 4 PM 2447 [ 59 ]
n In " XI C n 3,:. n m...... In ft.. Z -p ts3 A `,. a IR = =CI =
CUIRK MICHIGAll HYDRAULIC SYSTEM - STEERING 53784 PLATE, Steering Tube Mtg. _ 2 6975 HOSE, Tube to Cylinder 3 53929 HOSE, Tube to Cylinder 4 5273 HOSE, Tube to Steering Gear 5 53927 TUBE, Lower Front 6 656672 WASHER, Tube to Plate 2 7 24C-624 BOLT, Tube to Plate 2 8 5275 HOSE, Pump to Tee 9 29F-3 ELBOW, Hose to Cylinder STEERING CYLINDER See Index 4K-8 PLUG, Cylinder 2 2 29F-3 ELBOW, Hose to Cylinder 3 K- TEE, Connecting 4 568372 HOSE, Tee to Relief Valve 5 5274 HOSE, Tube to Steering Gear 6 568339 TUBE, Relief Valve to Steering Gear 7 656672 WASHER, Tube Mounting 2 8 4E-6 LKWSHR, Tube Mounting 2 9 24C-62 BOLT, Tube Mounting 2 2 568372 HOSE, Tube to Gear 2 73793 CONNECTOR (Inc. 22) 22 9F-7 -RING, Connector 23 73793 CONNECTOR (Inc. 29) 24 9F-7 -RING, Connector 25 53684 ADAPTER UNION (Inc. 26) _ 26 9F-7 -RING, Adapter Union 27 STEERING GEAR ASSY See Index 28 9F-7 -RING, Elbow 29 573576 ELBOW, Hose to Gear (Inc. 28) 3 56837 HOSE, Gear to Cross 3 6467 HOSE, Tube to Cylinder 32 8F-3 ELBOW, Hose to Cylinder 33 4K-8 PLUG, Cylinder 2 34 STEERING CYLINDER See Index 35 8F-3 ELBOW, Hose to Cylinder 36 6975 HOSE, Tube to Cylinder 37 89F-8 CONNECTOR, Hose to Cross 38 5K-624 NIPPLE, Cross to Reservoir 39 24K-7 PLUG, Relief Valve (Inc. 4) _ 4 9F-7 -RING, Plug 4 STEERING RELIEF VALVE See Index 42 5K-6 NIPPLE, Valve to Cross 43 2F-5 CROSS, Connecting 44 5K-6 NIPPLE, Valve to Cross 45 24K-7 PLUG, Relief Valve (Inc. 46) _ 46 9F-7 -RING, Plug 47 53684 ADAPTER UNION (Inc. 48) _ 48 9F- -RING, Adapter Union 49 STEERING RELIEF VALVE 5 8K- ELBOW, Hose to Pump (Inc. 5) 5 9F- -RING, Elbow 52 56487 ELBOW, Hose to Pump (Inc. 56) 53 5429 CLAMP, Hose 54 585884 HOSE 55 5429 CLAMP, Hose 56 9F- -RING, Elbow 57 STEERING HYDRAULIC PUMP See Index 58 24C-62 BOLT, Tube Mtg. 2 59 4E-6 LKWSHR, Tube Mtg. 2 6 656672 WASHER, Tube Mtg. 2 6 53928 TUBE, Upper Rear 62 8D-6 NUT, Plate to Frame 4 63 656672 WASHER, Plate to Frame 4 64 656672 WASHER, Plate to Frame 4 65 24C-624 BOLT, Plate to Frame 4 66 656672 WASHER, Tube Mtg. 2 67 8D-6 NUT, Tube Mtg. 2 PM 2447 [ 6 ]
CLARK MICHIGAll < 4 8 2 3 4 5 6 7 89 2 2 22 ma Ng limml GlirE Seals shown in place as viewed from shaft end 34 33 32 3 3 29 28 27 26 25 24 23 TS-6675-P HYDRAULIC PUMP - STEERING A 57497 *PUMP ASSY (Inc. thru 34) 2 WASHER, Cover Mounting 4 B 946372 SEAL KIT, Minor (Inc., 2, 3, 2 LKWSHR, Cover Mounting 4 9, 3, 3 thru 34) 22 BOLT, Cover Mounting 4 -RING 23 SHAFT, Driven 2 RING, Back-Up 24 BUSHING, Shaft 3 RING, Back-Up 25 RING, Retaining 4 SHAFT, Drive 26 GEAR, Driven 5 ADAPTER, Pump 27 RING, Retaining 6 BUSHING, Shaft 28 HOUSING, Pump 7 PLATE, Wear 29 DOWEL, Adapter & Cover 8 DOWEL, Adapter & Cover 3 BUSHING, Shaft 9 -RING 3 SEAL, Shaft RING, Retaining 32 SEAL, Shaft GEAR, Drive 33 SEAL 2 DOWEL 34 -RING 3 -RING 35 5596 t GASKET, Pump Mounting 4 RING, Retaining 36 24962 -SLEEVE, Pump Drive 5 COVER, Pump 6 BUSHING, Shaft 37 27647 t STUD, Pump Mounting 3 7 WASHER, Cover Mounting 4 38 4E-6 t LKWSHR, Pump Mounting 3 8' LKWSHR, Cover Mounting 4 39 8D-6 t NUT, Pump Mounting 3 9 BOLT, Cover Mounting 4 4 6923 t WASHER, Pump Mounting 3 tnot Illustrated Not Sold Separately *NOTE: The above listed pump, with the exception of seal kit listed, is not considered rebuildable in the field. Due to extremely close tolerances involved and extensive break-in test required, the cost of equipment needed and parts plus labor would exceed cost of replacement pump. Order replacement pump by part number listed. [ 62 ] PM 2447
CUIRK MICHIGAIll HYDRAULIC PUMP - BUCKET AND BOOM A 573924 PUMP ASSY (Inc. thru 22) B 946257 SEAL KIT (Inc., 2, 3, 5, 6, 7, 2, 3, 4, 2) C 946258 REPAIR KIT, Major (Inc., 2, 3, 5 thru 4, 6 thru 22) 94699 SEAL, Oil See "B" or "C" 2 94625 SPACER, Oil Seal 3 94699 SEAL, Oil 4 94626 FLANGE, Cover 5 RETAINER, Ring See "B" or "C" 6 -RING See "B" or "C" 7 RING, Back-Up See "B" or "C" 8 PLATE, Isolation See "C" 9 PLATE, Pressure See "C" GEAR, Drive See "C" PLATE, Pressure See "C" 2 RETAINER, Ring See "B" or "C" 3 -RING See "B" or "C" 4 RING, Back-Up See "B" or "C" 5 946259 BODY 6 946 PIN, Body 2 7 PLATE, Isolation See "C" 8 GEAR, Driven See "C" 9 RING, Spacer See "C" 2 2 -RING See "B" or "C" 2 94627 WASHER 8 22 23C-82 BOLT, Flange 8 23 575 t STUD, Pump Mtg. 4 24 62D-8 t NUT, Pump Mtg. 4 25 4E-8 t LKWSHR, Pump Mtg. 4 26 5526 t GASKET, Pump Mtg. 27 2943 t SLEEVE, Pump Drive Not Sold Separately NOTE: Pump is equipped with bushing type bearings. Bearings are machine finished after pressing in place and therefore are not replaceable service items. PM 2447 [ 63 ]
CLARK michiciid CYLINDER ASSEMBLY - BUCKET 4/2" A 5983 CYLINDER ASSY (Inc. A, 2, 2 25K-448 -RING, Cylinder Cap 4 thru 22, 24 thru 27) 2 3 548577 RING, Back-Up NOTE: Two (2) Cylinders used on machine Quantities 4 567996 CAP, Cylinder listed below are for one () Cylinder. 5 5957 ADAPTER, Male Packing 2 5338 *STUD, Cylinder Cap. 4 6 5363 PACKING ASSY la 59548 BOLT, Cylinder Cap 4 7 ---- OMIT, Not Used 2 5982 **CYLINDER 8 8D- NUT, Cylinder Cap 4 3 2H-5 FITTING, Cylinder Grease 9 ---- LOCKWIRE (6 ga. x 5" lg.) 2 4 53527 NUT, Piston Rod 2 4C-66 BOLT, Seal Retainer 4 5 F-848 COTTER, Piston Rod Nut 2 567989 ROD, Piston (Inc. 22) 6 523263 RING, Piston Wear 22 567994 BUSHING, Piston Rod 7 53673 RING, Piston Outer Seal 23 2H-5 FITTING, Piston Rod Grease _ 8 53464 RING, Piston Inner Seal 24 5627 RETAINER, Seal 9 5326 PISTON 25 59525 SEAL, Piston Rod 523263 RING, Piston Wear 26 5627 GLAND, Packing 25K-42 -RING, Piston Rod 27 5956 ADAPTER, Female Packing 2 *NOTE: Stud not used on all cylinders. For replacement of studs use 4 #59548 Bolts and follow replacement procedure below. **NOTE: When replacing Cylinder on machines equipped with studs, 4 #59548 Bolts will also be required. Follow steps 4 and 5 of Procedure below. PROCEDURE Remove Nuts, Washers and Studs. 2 Drill out tapped collar holes to A 6" Dia. 3 Grind Weld (Collar to Tube) away from Collar Holes to allow bolt head to rest flat on collar. 4 Insert Bolts #59548 through Collar, then Cap. 5 Using same nuts and washers, Torque to 28 ft. lbs. [64] PM 2447
CU IRK MICHIGAll BOOM CYLINDER ASSEMBLY - 6" A 52853 BOOM CYLINDER ASSY 25K-856 -RING, Cylinder Cap L.H. (Inc. thru 22, 24, 25) 2 532563 RING, Cylinder Cap Back-Up B 52854 BOOM CYLINDER ASSY R.H. (Inc. thru 22, 24, 25) 3 565934 CAP, Cylinder NOTE: Two (2) Cylinders used per machine Quantities listed below are for one () Cylinder. 4 527496 ADAPTER, Male 2 5 53854 PACKING ASSY 53777 BUSHING, Cylinder 2 6 527497 ADAPTER, Female 2 2 5285 CYLINDER (Inc. ) 7 529 GLAND, Packing 3 5293 NUT, Piston Rod 8 5545 SEAL, Piston Rod 4 F-852 COTTER, Piston Rod Nut. 9 52267 RETAINER, Seal 5 533 RING, Piston Wear 2 LOCKWIRE (6 ga. x 3" lg.) 2 6 52845 RING, Piston Outer Seal 2 3C-88 BOLT, Seal Retainer 4 7 53467 RING, Piston Inner Seal 22 52848 ROD, Piston (Inc. 24) 8 52846 PISTON 23 H-25 FITTING, Piston Rod Grease_ 9 533 RING, Piston Wear 24 5566 BUSHING, Piston Rod 25K-62 -RING, Piston Rod 25 24C-56 BOLT, Cylinder Cap 4 PM 2447 [ 65 ]
CLARK MICHIGAll GROUP Flange Half -Ring Bolt Lkwshr Sie Per Connection 2 4 4 A 66392 79553 23C-62 4E-6 3/4" B 66393 36622 23C-62 4E-6 " C 66394 36623 23C-724 4E-7 /4" D 66396 36625 23C-824 4E-8 2" [ 66 ] PM 2447
CUIRK MICHIGAll HYDRAULIC SYSTEM - BUCKET AND BOOM 547 CLAMP, Hose to Tube 22 6929 WASHER, Tubes to Frame 4 2 53339 HOSE, Tube to Tube 23 -- HOSE, Bucket Cylinder See 35 3 547 CLAMP, Hose to Tube 24 -- HOSE, Bucket Cylinder 4 53283 HOSE, Pump to Valve See 36 5 -- CONTROL VALVE ASSY 25 24C-828 BOLT, Tube Mounting 2 See Index 6 36622 -RING, Tee to Valve 7 548 TEE, Hoses to Valve 7A 23C-624 t BOLT, Tee to Valve 4 26 635682 WASHER, Tube Mounting 2 27 8D-8 NUT, Tube Mounting 2 28 52987 TUBE, Bucket Cylinder Rod End 7B 4E-6 t LKWSHR, Tee to Valve 8 526676 ELBOW, Hose to Tee 9 53854 TUBE, Suction 29 5299 TUBE, Bucket Cylinder Base End 3 56856 SPACER; Tube Mounting 2 ---- BUCKET AND BOOM 3 52996 CLAMP, Tube Mounting 2 HYDRAULIC PUMP See Index 32 656672 WASHER, Tube Mounting 2 538 STEM, Suction 33 4E-6 LKWSHR, Tube Mounting 2 2 546 CLAMP, Hose to Stem 34 24C-624 BOLT, Tube Mounting 2 3 585887 HOSE, Stem to Tube 35 536854 HOSE, Bucket Cylinder Rod End 2 4 546 CLAMP, Hose to Tube 5 536556 HOSE, Tee to Tube 6 536556 HOSE, Valve to Tube 36 536855 HOSE, Bucket Cylinder Base End r'r 2 37 52656 GUIDE, Bucket Cylinder Hose 4 38 4E-6 LKWSHR, Hose Guide 4 7 59432 HOSE, Tee to Pressure Relief Valve 39 24C-66 BOLT, Hose Guide 4 8 534894 ELBOW, Hose to Relief Valve 4 ---- BUCKET CYLINDER (Inc. 8A) See Index 2 8A 9F-7 to-ring, Elbow 4 56747 BRACKET, Tube to Frame 2 9 53938 TUBE, Boom Feeder 42 635682 WASHER, Bracket to Frame _ 2 2 24C-82 BOLT, Tubes to Frame 4 43 635682 WASHER, Tube to Bracket 2 2 4E-8 LKWSHR, Tubes to Frame 4 44 8D-8 NUT, Tube to Bracket 2 t Not Illustrated NOTE: To determine part number of flange halves refer to letter designation on illustration, and then to Chart. PM 2447 [ 67 ]
CUIRK MICHIG GROUP Flange Half -Ring Bolt Lkwshr Sie Per Connection 2 4 4 A 66392 79553 23C-62 4E-6 3/4,, B 66393 36622 23C-62 4E-6 C 66394 36623 23C-724 4E-8 /4 ff D 66396 36625 23C-824 4E-7 2",/' [ 68 ] PM 2447
CLeiRK MICHIGAll HYDRAULIC SYSTEM BUCKET AND BOOM (Continued) 45 4E-8 LKWSHR, Bracket to Frame _ 2 6 52645 HOSE, Boom Cylinder Rod End 2 46 24C-82 BOLT, Bracket to Frame 2 6 52983 TUBE, Boom Cylinder 47 56855 BRACKET, Tube to Frame Rod End 47A 24C-828 t BOLT, Bracket to Frame 62 52978 TUBE, Boom Cylinder Base End 47B 635682 f WASHER, Bracket to Frame _ 2 63 24C-828 BOLT, Tube to Frame 2 47C 8D-8 NUT, Bracket to Frame 64 635682 WASHER, Tube to Frame 2 48 52976 TUBE, Pivot Hose to Run Around Valve 65 635682 WASHER, Tube to Frame 2 49 635682 WASHER, Tube to Bracket 2 66 8D-8 NUT, Tube to Frame 2 5 24C-828 BOLT, Tube to Bracket 2 5 5298 TUBE, Boom Cylinder Rod End 67 52976 TUBE, Pivot Hose to Run- Around Valve 68 635682 WASHER, Tube to Bracket 2 52 52979 TUBE, Boom Cylinder Base End 69 8D-8 NUT, Tube to Bracket 2 53 ---- HOSE, Boom Cylinder 7 5348 HOSE, Center Pivot See 6 7 5348 HOSE, Center Pivot 54 -- HOSE, Boom Cylinder See 58 72 5348 HOSE, Center Pivot 55' 24C-828 BOLT, Tube to Bracket 2 73 5348 HOSE, Center Pivot 56 635682 WASHER, Tube to Bracket 2 57 --- RUN-AROUND VALVE See Index 57A 24C-788 "[BOLT, Valve Mounting 2 57B 8D-7 t NUT, Valve Mounting 2 74 53937 TUBE, Bucket Feeder 75 547 CLAMP, Hose to Reservoir 76 53339 HOSE, Tube to Reservoir 77 547 CLAMP, Hose to Tube. 58 536947 HOSE, Boom Cylinder 78 5383 TUBE, Suction Base End 2 79 56767 HOSE, Valve to Tube 59 BOOM CYLINDER See Index 2 8 525629 HOSE, Valve to Tube t Not Illustrated NOTE: To determine part number of flange halves refer to letter designation on illustration, and then to Chart. NOTES PM 2447 [ 69 ]
CLARK MICHIGAI RUN AROUND VALVE A 5257 VALVE ASSY, Run Around (Inc. thru ) C-82 BOLT, Cover to Housing 4 2 4E-8 LKWSHR, Cover to Housing 4 3 947835 COVER, Housing 4 25K-424 -RING, Cover 5 947836 SPRING 6 HOUSING See "A" 7 PLUNGER See "A" 8 25K-424 -RING, Cover 9 947835 COVER, Housing 4E-8 LKWSHR, Cover to Housing 4 C-82 BOLT, Cover to Housing 4 Not Sold Separately [ 7 ] PM 2447