C M tr PARTS MANUAL 2543 MODEL 55 A Articulated TRACTOR SHOVEL Information contained herein pertains to Machine Serial Numbers listed below: 55:A G.M. 46A0 and After Record Your Machine Serial Number Here CLARK COMPANY Construction Machinery Division M703 B297SPR496 Printed in U.S.A.
AIR CLEANER TAIL PIPE BOOM BELLCRANK BUCKET CYLINDER BOOM COCKPIT CYLINDER HEADLAMP MUFFLER ENGINE COMPART- MENT HOOD FRONT FRAME REAR FRAME FUEL TANK REAR AXLE FRONT AXLE BUCKET MODEL 55 TEE A TRACTOR SHOVEL TS-9576-P
CU IRK michigan WHEN ORDERING REPAIR PARTS To assure the best results and to maintain the original quality built into the machine it is important that only Clark-Approved s be used when new parts are required. IMPORTANT: Always furnish the distributor with the machine serial number when ordering parts. Order through your nearest Clark Distributor, for THE MICHIGAN LINE. Always give serial number of machine. Furnish: Quantity, Number and. WHEN PARTS ARE RECEIVED Check immediately for quantity, correctness and condition. Advise your Michigan Distributor of any error. Claims for damages, during shipment, should be made to the carrier immediately. INDEX MODEL 55 III A Page A Page Accelerator Pedal and Linkage Brake Head Assembly L.H. 44 Accelerator Rods 2 Brake Head Assembly -- R.H. 45 Brake Assembly, Parking 27 Accessories, Engine Air Brake Pedals 50 Brake Controls, Parking 48 Air Brake Valve 50 Brake Lever Assembly, Parking 49 Air Breather Check Valve, Torque Converter 33 Brake Pedals 50 Air Breather, Torque Converter 29 Brake Valve, Air 50 Air Breather, Transmission 9 Brake Valve and Controls 50 Air Cleaner Assembly 8 Brake Torque Torque Plate Assembly 44, 45 Air Cleaner Connections 8 Breather, Torque Converter Air 3 Air Cleaner, Element 8 Bucket Assembly Data 6 Bucket and Boom Hydraulic Pump 62 Air Compressor Air Lines, Brake 53 Bucket and Boom Hydraulic System 65 Air Pressure Gauge 75 Bucket Cutting Edges 6 Air Pressure Sender Unit 53 Bucket Cylinder Assembly 66 Air Reservoir 53 Bucket Leveler 5 Air Valve Assembly, Bucket Leveler 7 Bucket, Leveler, Boom, Bellcranks and Pushrods 5 Bucket Leveler Piping 5 Alternator Bucket Leveler Valve 7 Alternator Belt Ammeter 75 Bucket Pushrods 5 Axle Assembly Front Drive 37 Bucket, Seat 69 Axle Assembly Rear Drive 4 Bucket Seat Assembly 69 Button, Starter 75 Back Rest Cushion 69 C Back-Up Lamp Assembly 3 Cab Assembly 79, 8 Battery, Battery Hold Down and Cables 63 Cab Head Lamp 79,8 Battery Box 63 Cab Wiring Harness 79, 8 Battery Cables 83 Cables, Battery 83 Battery Hold Down 63 Cap, Fuel Tank 4 Bearing Assembly, Mid Mount 34 Bel!cranks, Boom and Push Rod 5 Cap, Oil Reservoir 5 Belts Cap, Radiator 9 Boom 5 Cap, Steering Gear Filler 55 Boom Cylinder Assembly 67 Case, Transmission 9 Brake Air Lines 53 Cartridge Kit, Transmission and Converter Filter 33 PM 2543 [ A ]
CL RK michigaii Page Charging Pump, Converter 29 Filler Cap, Oil Reservoir 5 Cleaner, Air 8 Fiiier Cap, Steering Gear 55 Clips, Wiring, Pipe and Hose 82 Filter Assembly, Hydraulic Reservoir Oil 5 Clutch Group, Forward and Second 24 Filter Assembly, Transmission and Converter Oil 33 Clutch Group, Reverse and Third 25 Filter Element, Hydraulic Reservoir Oil 5 Cluster Assembly Power 47 Filter Elements, Engine Clutch Group High, Reverse 25 Forward, Second and Low Clutch Group 24 Cockpit 76 Foot Switch, Horn 76 Cockpit Wiring Harness 83 Foot Valve, Brake 50 Column Assembly, Steering 55 Frame, Front and Rear 3 Compressor, Air Front Cover Assembly 9 Connections, Muffler, Tailpipe and Air Cleaner 8 Front Drive Axle Assembly 37 Connections, Radiator 9 Front Drive Differential and Carrier Assembly 39 Control Valve Assembly Transmission 26 Front Drive Planet Carrier Assembly 46 Control Valve Assembly Main 7, 73 Fuel Lines 4 Converter Assembly, Torque 29 Fuel Tank 4 Converter Charging Pump 29 Fuel Tank Cap 4 Converter Pressure Regulating Valve 29 Fuel Tank Dipstick 4 Converter to Transmission Prop Shaft 35 Fuel Tank Inspection Plate 4 Cover Assembly, Front 9 Fuel Tank Strainer 4 Cushion, Back Rest 69 Fuse.75 Amp 75 Cushion, Seat 69 Fuse 20 Amp 75 Cutting Edges, Main 6 Fuse, Lighter 75 Cutting Edges, Side 6 Cylinder Assembly, Boom 67 Cylinder Assembly, Bucket 66 Cylinder Assembly, Steering 58 Page G Gauge, Air Pressure 75 Gauge, Engine Oil Pressure 75 Gauge, Engine Temperature 75 D Gauge, Torque Converter Temperature 75 Dash Lamp 75 Gear Assembly, Steering 55 Decals and Name Plates 83 Gear and Shaft Group 2, 23 De-Clutch Valve, Transmission 26 Glass Pattern Kit 79, 8 Diagram, Cockpit Wiring 84 Grille 2 Diagram, Engine Wiring 84 Group, Seat and Support 69 Differential and Carrier Assembly Front Drive 39 Group, Steering Gear Mounting 56 Differential and Carrier Assembly Rear Drive 4 Dipstick, Fuel Tank 4 Dipstick, Oil Reservoir 5 Drag Link Assembly 57 Drawbar Pin 3 H Hand Brake 27 Hand Rails 3 Harness, Cab Wiring 79, 83 Harness, Cockpit Wiring 83 E Harness, Instrument Panel Wiring 75, 83 Element, Air Cleaner 8 Harness, Main Wiring 83 Element, Hydraulic Reservoir Filter F, 5 Harness, Tail Light Wiring 83 Element, Lighter 75 Head Lamp Assembly Cab 75 Engine and Accessories Head Lamp Assembly Standard 3 Engine Filter Elements High Clutch Group 25 Engine Hourmeter Hood, Hand Rail, Cover and Grille 3 Engine Oil Pressure Gauge 75 Horn and Foot Switch 76 Engine Support s Hourmeter, Engine Engine Temperature Gauge 75 Hydraulic Oil Reservoir 5 Hydraulic Pump Bucket and Boom 62 F Hydraulic Pump Steering 62 Fan F Hydraulic Reservoir Filter Assembly 5 Fan Belt F Hydraulic System Bucket and Boom 65 [ B PM 2543
CUIRK MICHIGAll i Page Page Hydraulic System Steering 6 Pedal, Accelerator Hydraulic System Transmission and Torque Converter 33 Pedals, Brake 50 Ignition Switch 75 Pitman Arm, Steering Gear 55 Inspection Plate, Fuel Tank 4 Planet Carrier Assembly Front and Rear 46 Inspection Plate, Oil Reservoir 5 Plate, Lubrication Instruction 83 Instrument Panel Assembly 75 Plate, Michigan Name 3 Instrument Wiring Harness 75, 83 Plate, Oil Reservoir Inspection 5 Plate, Patent 83 K Plate, Shift Quadrant 7 Kit, Brake Lining Parking Brake 27 Plates, Cockpit Inspection 76 Kit, Glass Pattern 8 Power Cluster Assembly 47 Kit, Transmission and Converter Oil Filter Cartridge 33 Pressure Regulating Valve Assembly 29 Pressure Relief Valve Steering System 59 L Propeller Shaft Assemblies 35 Lamp Assembly, Back-Up 3 Pushrods, Bellcrank to Bucket 5 Lamp Assembly, Cab Head 79, 8 Pump, Bucket and Boom Hydraulic 62 Lamp Assembly, Head Standard 3 Pump, Converter Charging 29 Lamp Assembly, Tail and Stop 3 Pump, Main and Steering Hydraulic 62 Lamp, Dash 75 Levers, Transmission Control 7 Q Levers, Valve Control 68 Quadrant, Shift 7 Light Switch 75 Lighter Element 75 R Lighter Fuse 75 Radiator Assembly 9 Lighter Receptacle 75 Radiator Cap 9 Lines, Fuel 4 Radiator and Connections 9 Link, Drag 57 Rail, Hand 3 Linkage, Accelerator Pedal Rear Drive Axle Assembly 4 Linkage Group, Steering 56 Rear Drive Differential and Carrier Assembly 43 Linkage, Transmission Control Levers 7 Rear Drive Planet Carrier Assembly 46 Linkage, Valve Control Levers 68 Rear Frame 3 Lubrication Instruction Plate 83 Regulator, Voltage Reservoir, Air 53 Main Control Valve M Reservoir, Hydraulic Oil 5 7, 73 Rods, Accelerator Main Cutting Edges 6 Rods, Shift 7 Main Wiring Harness 83 Rods, Valve Control 68 Michigan Name Plate 2 Mid-Mount Bearing Assembly 34 s Mounts, Engine Seat Assembly, Bucket 69 Mounts, Transmission 3 Seat Bucket 69 Muffler, Tailpipe and Air Cleaner Connections 8 Seat Cushion 69 N Neutral Start Switch 26 Seat Support Seat and Support Group Sender Unit, Air Pressure 0 Sender Unit, Engine Oil Pressure Oil Reservoir Cap 5 Sender Unit, Engine Temperature Oil Reservoir Dipstick 5 Sender Unit, Torque Converter Temperature 3 Oil Reservoir, Hydraulic 5 Shaft Assemblies, Propeller 35 Oil Reservoir Inspection Plate 5 Shaft and Gear Group 2l,23 Shift Levers 7 P Shift Quadrant 7 Parking Brake Assembly 27 Shift Quadrant Plate 7 Parking Brake Controls 48 Shift Rods 7 Parking Brake Lever Assembly 49 Side Cutting Edges 6 PM 2543 [ C ] 69 69 53
CLARK ICHIGIIfl Starter Page Transmission to Front Axle Prop Shaft Starter Button 75 Transmission to Rear Axle Prop Shaft 35 Steering Column Assembly 55 Transmission and Torque Converter Hydraulic System 33 Steering Cylinder Assembly 58 Steering Gear Assembly 55 U Steering Gear Mounting Group 56 Unit, Air Pressure Sender 53 Steering Hydraulic System 6 Unit, Engine Oil Pressure Sender Steering Pressure Relief Valve Assembly 59 Unit, Engine Temperature Sender Steering System Hydraulic Pump 62 Unit, Torque Converter Temperature Sender 3 Steering Wheel 55 Stop Lamp Assembly 3 V Support, Seat 69 Valve Assembly, Air Brake 50 Supports, Engine Valve Assembly, Control 7, 73 Switch, Horn Foot 76 Valve Assembly, Foot 50 Switch, Ignition 75 Valve Assembly, Pressure Regulating 29 Switch, Light 75 Valve Assembly, Steering Gear 55 Switch, Neutral Start 75 Valve Assembly, Steering Pressure Relief 59 Valve Assembly, Transmission De-Clutch 26 T Valve Assembly, Transmission Control 26 Tail Light Wiring Harness 83 Valve Control Levers and Linkage 68 Tailpipe 8 Valve, Torque Converter Air Breather Check 33 Tailpipe Connections 8 Voltage Regulator Tail and Stop Lamp Assembly 3 Tank, Fuel 4 Tank, Oil Reservoir 5 Water Pump Belt Tire Data 77 Wheel Brake Head 44, 45 Torque Converter Air Breather 3 Wheel, Steering 56 Torque Converter Air Breather Check Valve 3 Wheel and Tire Data 77 Torque Converter Assembly 29 Wiring 83 Torque Converter Temperature Gauge 75 Wiring Diagram Cockpit 84 Transmission Assembly 9 Wiring Diagram Engine 84 Transmission Case 9 Wiring Harness, Cab 8, 83 Transmission Control Valve Assembly 26 Wiring Harness, Cockpit 83 Transmission Control Levers and Linkage 7 Wiring Harness, Instrument Panel 75, 83 Transmission and Converter Oil Filter 33 Wiring Harness, Main 83 Transmission De-Clutch Valve Assembly 26 Wiring Harness, Tail Light 83 Transmission Mounts 3 Wiring, Pipe and Hose Clips 82 Page 35 NOTES [D] PM 2543
CUIRK MICHIG NOTES PM 2543 I E l
CMRK MICHIG ENGINE AND ACCESSORIES G.M. All orders for engine assembly or components thereof should be placed with the nearest G.M. Diesel Distributor. To obtain proper items, it is necessary to provide your engine model, serial number and necessary group type number for the equipment required. This data is stamped on the options and accessories plate on the rocker cover of engine. ENGINE ACCESSORIES *ALTERNATOR (G.M. #007) 2 *STARTER ASSY (G.M. #3089) 3 *VOLTAGE REGULATOR (D.R. #953) 4 *AIR COMPRESSOR (G.M. #5352) 5 *OIL FILTER ASSY Full Flow 6 *FAN, Radiator (G.M. #5903) *NOTE: The above listed accessory items are serviced by the engine manufacturer. Specifications on these items are subject to change without notice. It is, therefore, recommended that complete model, specifications and serial number of the engine be provided to your G.M. Engine Distributor when ordering these parts. ALTERNATOR, COMPRESSOR, AND FAN BELTS 7 367824 BELT, Alternator Drive (2 Belt Set) 8 367895 BELT, Compressor (2 Belt Set) REPLACEMENT FILTER ELEMENTS 9 94833 ELEMENT, Air Cleaner 0 945444 ELEMENT, Fuel Filter Strainer Primary 945443 ELEMENT, Fuel Filter Strainer Secondary 2 25502 ELEMENT, Engine Oil Filter 3 25502 ELEMENT, Trans. & Converter Hyd. System Filter 4 530600 ELEMENT, Hydraulic Reservoir Return Filter PM 2543 [F ]
CUIRK MICHIGAll 5 )4, 6 37 si 36-4) 35--- \(i \ I I 34 33 27 26 2 5 t I \ I 24 23 22 2 4-20 32 3 28 29 30 TS-9538-P ENGINE AUXILIARY AND SUPPORT PARTS 55323 SENDER, Engine Temperature 8 635682 WASHER, Mount to Frame 4 2 4E-0 LKWSHR, Temperature 9 635682 WASHER, Mount to Frame 4 Sender 20 8D-08 NUT, Mount to Frame 4 3 4D-0 NUT, Temperature Sender 2 8C-824 BOLT, Mount to Engine 8 4 85G-608 SCREW, Hourmeter Mounting 3 22 4D-0 NUT, Oil Sender 3 5 2E-6 LKWSHR, Hourmeter 23 4E-0 LKWSHR, Oil Sender 3 Mounting 3 24 68574 SENDER, Engine Oil Pressure 6 508624 HOURMETER (Inc. 4, 5) 25 75F- COUPLING, Sender to Engine 7 2E-6 LKWSHR, Dampener 26 5K-06 NIPPLE, Sender to Engine Mounting 3 27 525497 BRACKET, Rear Engine 8 24C-42 BOLT, Regulator Mounting 2 Mounting 9 336290 *REGULATOR, Voltage 28 56745 MOUNT, Vibration Rubber 0 584092 WASHER, Regulator 29 520449 WASHER, Engine Mount 8D-04 Mounting 2 to Frame NUT, Regulator Mounting 2 30 24C-852 BOLT, Engine Mount to Frame 2 558960 WIRE, Hourmeter Ground 3 4E-06 LKWSHR, Mount to Engine 2 3 5525 DAMPENER, Hourmeter 32 23C-656 BOLT, Mount to Engine 2 Vibration 33 23C-720 BOLT, Mount to Engine 2 4 85G-608 SCREW, Dampener Mounting 3 34 4E-07 LKWSHR, Mount to Engine 2 5 ENGINE (See G.M. Engine 35 525490 SLEEVE, Engine Mount s Manual) 36 56773 WASHER, Engine Mount 6 525059 MOUNT, Engine to Frame 2 to Frame 7 24C-832 BOLT, Mount to Frame 4 37 8D-08 NUT, Engine Mount to Frame *NOTE: When replacement is necessory for Voltage Regulator ( 9) one () 893379 Shock Mount Kit must also be used. PM 2543 [ ]
0 H 70 0 n rn 0 z a =
CUIRK MICHIGAI FRONT AND REAR FRAME AND CRADLE No F-252 2 50688 3 508628 4 24C-296 5 8D-2 6 509864 7 23C-228 8 4E-2 9 508529 0 24C-252 508527 2 24C-252 3 508530 4 585972 5 68D-2 6 508530 7 68D-2 8 24C-820 9 4E-08 20 53297 2 508570 2A 0H-25 22 522035 23 70943 24 669896 25 508663 26 24C-660 27 24C-820 28 4E-08 29 53297 30 508569 3 508670 32 0H-25 33 34 7D-08 35 52220 36 652448 37 547529 37A 944907 38 0H-25 39 540233 40 24C-020 4 4E-0 42 560594 43 544003 44 24C-872 45 508595 46 0H-25 47 8D-08 Not Illustrated As Required COTTER, Drawbar Pin 48 540234 BUSHING, Bucket Cylinder PIN, Drawbar to Frame 2 FRAME, Rear (Inc. 6, 22, 49 0H-35 FITTING, Boom Cylinder 25, 3, 6, 95) Grease 4 BOLT, Counterweight 2 50 508565 BOLT, Tapped 4 WASHER, Counterweight 2 5 24C-856 BOLT, Anchor Cap 8 BUSHING, Roll Bar Mtg. 52 4E-08 LKWSHR, Anchor Cap 8 BOLT, Bracket to Trans. 8 53 508559 BUSHING, Bucket Cylinder LKWSHR, Bracket to Trans. 8 to Frame 4 BRACKET, Trans. Mtg. 54 508568 CAP, Boom Cylinder Anchor 4 R.H. Rear 55 ---- AXLE ASSY, Front Drive BOLT, Bracket to Frame 2 See Index BRACKET, Trans. Mtg. L.H. Rear 56 50884 FRAME, Front (Inc. 39, 48, 5, 52, 54) BOLT, Bracket to Frame 2 57 24C-86 BOLT, Lock Plate 4 BRACKET, Trans. Mtg. 58 4E-08 LKWSHR, Lock Plate 4 L.H. Front 59 53297 LOCK PLATE, Pin Retaining 2 WASHER, Bracket to Frame 2 60 508556 PIN, Steer Cyl. to Frame 2 NUT, Bracket to Frame 2 6 522035 BUSHING, Lower Hinge BRACKET, Trans. Mtg. Lower R.H. Front 62 508564 SPACER, Hinge Bushing NUT, Bracket to Frame 2 63 657099 SEAL, Lower Hinge BOLT, Lock Plate 2 Lower LKWSHR, Lock Plate 2 64 540500 BUSHING, Hinge Pin LOCK PLATE, Pin Lower PIN, Upper Hinge 65 540499 fshim, Bushing Ret. tfitting, Grease 66 540499 $ SHIM, Bushing Ret. BUSHING, Upper Hinge 67 54050 CAP, Bushing Ret. Top Plate 68 24C-832 BOLT, Cap to Frame 4 RING, Bushing Retainer 69 657097 SEAL, Lower Hinge Upper BUSHING, Upper Hinge 70 506853 PLATE, Bushing Retainer BUSHING, Upper Hinge 7 589596 WASHER, Nut to Plate Bottom Plate 72 68D-6 NUT, Lower Hinge Pin BOLT, Pin Retaining 73 540257 LINK, Safety 2 BOLT, Lock Plate 2 74 F-540 COTTER, Safety Link Pin 2 LKWSHR, Lock Plate 2 75 358640 PIN, Safety Link 2 LOCK PLATE, Pin Retaining 76 508705 CRADLE ASSY (Inc. 80) PIN, Lower Hinge 77 AXLE ASSY Rear Drive BUSHING, Lower Hinge See Index FITTING, Pin Grease 78 55347 $WASHER, Cradle Shim OMIT, Not Used 79 55348 twasher, Cradle Shim lii6" This Application 80 538585 BUSHING, Cradle NUT, Lamp to Clamp 8 55348 t WASHER, Cradle Shim /2" CLAMP, Lamp Mounting 82 55347 t WASHER, Cradle Shim 3/46" SPACER, Head Light to 83 50947 PIN, Cradle to Frame 2 Clamp 2 84 H-5 FITTING, Cradle Pin Grease 2 LAMP, Head (Inc. 37A) 2 85 4E-08 LKWSHR, Lock Plate 4 SEALED UNIT 2 86 24C-820 BOLT, Lock Plate 4 FITTING, Pin Grease 2 87 506753 WASHER, Counterweight 2 BUSHING, Boom Pivot 2 88 8D-2 NUT, Counterweight 2 BOLT, Lock Plate 8 89 568259 LOCK PLATE, Pin Retaining 2 LKWSHR, Lock Plate 8 90 53297 LOCK PLATE, Pin Retaining 2 LOCK PLATE, Pin Retaining._ 4 9 508556 PIN, Boom to Frame 2 PIN, Steer Cyl. to Frame 2 BOLT, Pin Retaining 2 92 4E-08 LKWSHR, Lock Plate 4 PIN, Bucket Cylinder 2 93 24C-86 BOLT, Lock Plate 4 FITTING, Pin Grease 2 94 540687 COUNTERWEIGHT NUT, Pin Retaining 2 95 509864 BUSHING, Roll Bar Mtg. I 96 A-ise 9 0 ki2a-) mit - I?7, X27-/ u TCA PM 2543 [3 ]
2 25 28 29 7a., 30 36 3 0 8 22 9 4//2 20 23 24 :46 --- L,i 5 2 - a---- l' /4-4-3 \ i 9 0 N 4.y 8i - 7;t 4 '<vg,: \,7 7, 2) t + y 7 y 7t I I 67 66 q 68 T-3-32 33 34 I I r- II 38 39 o' 40 42 4 43 44 6 / i / A% 46 45 ----,,.. -v.., 5 t 6059 58 b 52 t 56 t 55 54 53 y ( 48 --,,,,,, T4---49 ---,,i,_ E-50 -----, 0... t 5 0 z n In 69 65 64 62 0 z a BOOM, BELLCRANKS, PUSHROD, BUCKET LEVELER PIPING TS-9543 87 3:
CLeIRK michiga BOOM, BELLCRANKS, PUSHROD, BUCKET LEVELER AND PIPING It ---- BRAKE VALVE (See Index) 2 3F-2 ADAPTER UNION 3 540700 HOSE, Brake Valve to Leveler 4 30H-46 CLIP, Hose Mtg. 2 5 4E-06 LKWSHR, Clip to Frame 2 6 24C-62 BOLT, Clip to Frame 2 7 3H-42 CLIP, Hose Mtg. 5 8 4E-06 LKWSHR, Clip to Frame 5 9 24C-62 BOLT, Clip to Frame 5 0 36F-2 ADAPTER UNION AIR VALVE ASSY, Bucket Leveler (See Index) 2 29F- ELBOW, Adapter to Valve 3 33F-2 ADAPTER UNION 4 4E-06 LKWSHR, Cam to Bracket _ 2 5 24C-66 BOLT, Cam to Bracket 2 6 656672 WASHER, Cam to Bracket 2 7 540684 BRACKET, Cam 8 540697 CAM, Leveler 9 24C-66 BOLT, Bracket Mtg. 2 20 4E-06 LKWSHR, Bracket Mtg. 2 2 656672 WASHER, Bracket Mtg. 2 22 24C-652 BOLT, Pin Retaining 2 23 508273 PIN, Bellcrank to Pushrod 2 24 8D-06 NUT, Pin Retaining 2 25 24C-664 BOLT, Pin Retaining 2 26 508274 PIN, Cylinder to Bellcrank 2 27 8D-06 NUT, Pin Retaining 2 28 543424 BELLCRANK ASSY (Inc. 30) 2 29 0H-25 FITTING, Bellcrank Grease 2 30 540238 BUSHING, Bellcrank Pivot 2 3 570850 EYE ASSY, Pushrod Adjusting (Inc. 33) 2 32 0H-25 FITTING, Pushrod Grease 2 33 587908 BUSHING, Pushrod Eye 2 34 8D-24 NUT, Eye Jam 2 35 507964 PUSHROD ASSY (Inc. 37) 2 36 0H-25 FITTING, Pushrod Grease 2 37 587908 BUSHING, Pushrod Eye 2 38 BUCKET ASSY (See Index) 39 50873 BUSHING, Bucket Assy 2 40 0H-25 FITTING, Bucket Assy Grease 2 4 50873 BUSHING, Bucket Assy 2 42 508857 SPACER, Bucket Assy 2 43 508856 SPACER, Bucket Assy 2 44 4E-06 LKWSHR, Bucket Assy 4 45 24C-628 BOLT, Bucket Assy 4 46 508858 STOP, Bucket 2 47 508857 SPACER, Bucket Assy 2 48 508856 SPACER, Bucket Assy 2 49 24C-672 BOLT, Pin to Pushrod 2 50 508273 PIN, Pushrod to Bucket 2 5 8D-06 NUT, Pushrod to Bucket 2 52 507920 LOCK PLATE, Pin to Boom 2 53 543086 PIN, Boom to Bucket 2 54 507920 LOCK PLATE, Pin to Boom 2 55 4E-08 LKWSHR, Pin to Lock Plate 8 56 24C-820 BOLT, Lock Plate to Pin 8 57 560594 LOCK PLATE, Pin to Boom 2 58 543087 PIN, Boom to Bellcrank 2 59 560594 LOCK PLATE, Pin to Boom 2 60 4E-0 LKWSHR, Pin to Lock Plate 8 6 24C-024 BOLT, Lock Plate to Pin 8 62 8D-07 NUT, Pin Retaining 2 63 543088 PIN, Boom Cyl. to Boom 2 64 24C-780 BOLT, Pin Retaining 2 65 54300 BOOM ASSY 66 86G-00 SCREW, Air Valve Mtg. 4 67 2E-0 LKWSHR, Air Valve Mtg. 4 68 BUCKET CYLINDER (See Index) 69 540700 HOSE ASSY 70 ---- CONTROL VALVE (See Index) 7 9F-5 0-RING, Adapter Union 72 30042 ADAPTER UNION, Control Valve 73 24K-5 t PLUG, Pipe 73A 9F-5 0-RING, Control Valve f Not Illustrated PM 2543 [ 5 ]
CUIRK MICHIGAll BUCKET ASSEMBLY DATA BUCKET MAIN CUTTING EDGE SIDE CUTTING EDGE Width S.A.E. Heaped Capacity Size Approx. Weight R.H. L.H. Size Approx. Weight 95/4 2 cu. yd. 50872 50874 x 9 x 97 28 508739 508738 3/4 x 6 x 42% 42 95/4 2/2 cu. yd. 540286 55765 x 9 x 97 28 570240 570240 3/4 x 6 x 46/4 46 /2 3/2 cu. yd. 540497 545602 x 9 x 2/4 250 535657 535599 3/4 x 6 x 47/2 50 [ 6 ] PM 2543
CLARK CONSTRUCTION MACHINERY' DIVISION MICHIGAll 7 AIR VALVE ASSEMBLY - BUCKET LEVELER A 504697 AIR VALVE ASSY (Inc. thru 20) B 895683 SEAL REPAIR KIT (Inc. 6, 8, 9, 3, 4, 6) 94778 ROLLER, Air Valve Lever 2 94775 LEVER, Air Valve 3 5G-46 SCREW, Adjusting 4 42G-008 SCREW, Cover Bracket Attaching 4 5 94776 BRACKET, Top Cover 6 94777 BUTTON ASSY (Inc. 6) 7 30339 RING, Retaining 8 25K-2002 0-RING, Stem 9 94765 BUTTON & STEM ASSY (Inc. 6 & 6) 0 BODY See "A" 947226 CLOSED END CAP 2 30339 RING, Retaining 3 889239 DIAPHRAGM 4 889239 DIAPHRAGM 5 947225 OPEN END CAP 6 889242 SPRING 7 94779 PIVOT PIN 8 4E-04 LKWSHR, Adjusting Screw 9 D-04 NUT, Adjusting Screw Lock 20 94779 PIVOT PIN Not Sold Separately PM 2543 [ 7 ]
CLeiRK MICHIGAll MUFFLER, TAILPIPES, AIR CLEANER AND CONNECTIONS 660738 CLAMP, Tailpipe 20 508680 EXTENSION, Cap to 2 547585 PIPE, Tail Air Cleaner 3 568806 MUFFLER 2 503862 CLAMP, Hose to Tube 4 23C-56 BOLT, Flange to Engine 4 22 53808 HOSE, Tube to Air Cleaner 5 4E-05 LKWSHR, Engine to Flange _ 4 23 503862 CLAMP, Hose to Air Cleaner 6 527095 FLANGE ASSY 24 24C-66 BOLT, Air Cleaner Mtg. 4 7 23C-620 BOLT, Muffler to Engine 4 25 420945 BAND, Air Cleaner Mtg. 2 8 4E-06 LKWSHR, Engine to Muffler _ 4 26 503857 AIR CLEANER ASSY 9 656672 WASHER, Engine to Muffler_ 4 (Inc. 27 thru 34) 0 509303 GASKET, Muffler to Engine _ 27 94833 CARTRIDGE, Air Cleaner 527096 GASKET, Flange to Engine 28 946860 VALVE, Vacuator 2 8D-06 NUT, Air Cleaner Mtg. 4 29 895982 0-RING, Cup to Body 3 529625 INDICATOR, Service 30 886526 WING NUT, Cartridge 4 583270 CLAMP, Extension to Retaining Air Cleaner 30A 886527 ]'GASKET, Wing Nut 5 539042 CLAMP, Hose to Flange 2 6 55425 HOSE, Tube to Flange 3 947242 CLAMP, Air Cleaner to Cup 7 539042 CLAMP, Hose to Tube 32 886526 WING NUT, Baffle to Cup 8 508679 TUBE, Air Intake 33 894653 BAFFLE, Cup 9 642530 CAP, Air Cleaner 34 886569 CUP, Air Cleaner t Not Illustrated [ 8 ] PM 2543
CMRK MICHIGIM RADIATOR AND CONNECTIONS 508365 la 945460 2 35495 3 540266 4 555979 5 540266 6 50850 7 540266 8 564005 9 540266 0 54008 M-6020 2 54008 3 4 54008 5 M-6030 6 54008 7 539647 8 54008 RADIATOR ASSY (Inc. A, 2) CHOSE, Overflow CAP, Radiator CLAMP, Hose to Radiator HOSE, Upper CLAMP, Tube to Hose TUBE, Upper CLAMP, Tube to Hose HOSE, Engine to Tube CLAMP, Hose to Engine CLAMP, Tube to Hose HOSE, Tube to Engine CLAMP, Hose to Engine TUBE, Furnished with Engine CLAMP, Hose to Tube HOSE, Tube to Tube CLAMP, Hose to Tube TUBE, Lower CLAMP, Hose to Tube 9 20 2 22 23 24 25 26 27 28 29 30 3 32 33 34 M-6030 54008 72F-02 58450 584502 8D-08 8D-08 584502 58450 24C-836 24C-836 24C-840 584502 58450 584502 8D-08 HOSE, Tube to Radiator CLAMP, Hose to Radiator DRAIN COCK DAMPENER, Vib., Radiator to Frame WASHER, Rad. to Frame NUT, Rad. to Frame NUT, Rad. to Frame WASHER, Rad. to Frame DAMPENER, Vib., Rad. to Frame BOLT, Rad. to Frame BOLT, Rad. to Frame BOLT, Rad. to Frame WASHER, Rad. to Frame DAMPENER, Vib., Rad. to Frame WASHER, Rad. to Frame NUT, Rad. to Frame 2 3 2 2 3 2 2 2 2 2 2 2 2 tnot Illustrated PM 2543 [ 9 ]
n O z n 0 z 0 rn O a "6 c. 43
CUIRK ACCELERATOR PEDAL AND LINKAGE 52320 CONNECTOR, Cable 2 86G-008 SCREW, Cable Connector 3 OMIT, Not Used This Application 4 52320 CONNECTOR, Cable 5 86G-806 SCREW, Cable Connector 6 569389 PLATE, Emergency Stop 7 6C-605 SCREW, Plate to Cockpit 2 8 52093 CABLE, Emergency Stop 9 52090 CABLE, Engine Stop 0 F-36 COTTER, Pedal Pin 623829 PEDAL, Accelerator 2 24C-444 BOLT, Pedal Stop 3 54585 STOP, Accelerator Pedal 4 8D-04 NUT, Stop to Floor 5 F-208 COTTER, Clevis Pin 6 4F-0405 PIN, Clevis 7 55069 ROD, Pedal to Bellcrank 8 8D-04 NUT, Clevis Jam 9 2J-4200 CLEVIS, Rod to Bellcrank 20 F-208 COTTER, Clevis Pin 2 4F-0405 PIN, Clevis 22 543696 BELLCRANK ASSY 23 F-22 COTTER, Clevis Pin 24 4F-0606 PIN, Clevis 25 537366 ANCHOR, Spring Return 26 4E-05 LKWSHR, Bracket to Cockpit 27 24C-54 BOLT, Bracket to Cockpit 28 623760 BRACKET, Rod Support 29 8D-06 NUT, Ball Joint 30 300247 BALL JOINT, Rod to Bellcrank 3 8D-05 NUT, Ball Joint Jam 32 5504 SPRING, Return 33 543698 ROD, Accelerator 34 8D-04 NUT, Bellcrank Mounting 35 24C-46 BOLT, Bellcrank Mounting 35A 6908 WASHER, Bellcrank Mounting i 36 623760 BRACKET, Accelerator Pedal 37 8D-04 NUT, Bracket to Floorboard 2 38 24C-46 BOLT, Bracket to Floorboard 2 39 623762 PIN, Pedal to Bracket PM 2543 [ ]
20 0 z 22 0 z H 0 z 40 a HOOD, SHROUDS, GRILLE AND SIDE PANELS TS-9582
CLARK HIICHIGA HOODS, SHROUDS, GRILLE AND SIDE PANELS 54692 LAMP, Back-Up (Inc. A, B) 2 A 946389 tretainer 2 B 55245 tsealed UNIT 2 2 50D-0 NUT, Back-Up Lamp to Grille 6 3 8D-06 NUT, Hood Mounting 4 4 6902 WASHER, Hood Mounting 2 5 568276 DAMPENER, Hood Mounting 2 6 6902 WASHER, Hood Mounting 2 7 6902 WASHER, Hood Mounting 2 8 24C-632 BOLT, Hood Mounting 2 9 508694 HOOD 0 542400 PLATE, Deck L.H. 24C-624 BOLT, Hood Mounting 2 2 6902 WASHER, Hood Mounting 2 3 6902 WASHER, Hood Mounting 2 4 6902 WASHER, Hood Mounting 2 5 8D-06 NUT, Hood Mounting 2 6 542399 PLATE, Deck R.H. 7 52678 HAND RAIL L.H. 8 23C-66 BOLT, Hand Rail to Cockpit 2 9 4E-06 LKWSHR, Hand Rail to Cockpit 2 20 4E-06 LKWSHR, Hand Rail to Cockpit 2 2 23C-66 BOLT, Hand Rail to Cockpit 2 22 52677 HAND RAIL R.H. 23 23C-62 BOLT, Cover Plate to Cockpit 4 24 4E-06 LKWSHR, Cover Plate to Cockpit 4 25 5402 PLATE, Cover 2 26 50905 PLATE, Cover R.H. 26A 50906 f PLATE, Cover L.H. 27 656672 WASHER, Plate Cover 8 28 4E-06 LKWSHR, Plate Cover 8 29 24C-62 BOLT, Plate Cover to Upper Support 8 30 508690 PLATE, Side Cover 2 3 656672 WASHER, Plate Side Cover 6 32 4E-06 LKWSHR, Plate Side Cover 6 33 24C-66 BOLT, Side Plate to Frame 6 34 540740 PLATE, Cockpit Side 4 35 587989 CATCH, Side Panel 4 36 85G-84 SCREW, Bumper Mounting 4 37 55434 BUMPER 4 38 50D-8 NUT, Bumper Mounting 4 39 508693 GRILLE 40 5640 NAMEPLATE, Grille 4 8E-04 LKWSHR, Grille Mounting 4 42 43G-48 SCREW, Grille Mounting 4 43 540002 LIGHT, Tail & Stop 2 43A 942746 BULB, Stop & Tail Light 2 44 24C-824 BOLT, Grille Mounting 4 45 4E-08 LKWSHR, Grille Mounting 4 46 635682 WASHER, Grille Mounting 4 tnot Illustrated PM 2543 [ 3 ]
CLARK MICHIGAll FUEL TANK AND LINES 508888 TANK, Fuel 2 558644 CAP, Filler (Inc. 2A, 2B) 2A 946953 tgasket, Fuel Cap 2B 946954 tplate, Gasket Back-Up 3 540708 DIPSTICK, Fuel Tank 4 943957 SCREEN 5 24C-252 BOLT, Tank Mounting 3 6 66809 WASHER, Tank Mounting 3 7 66809 WASHER, Tank Mounting 3 8 8D-2 NUT, Tank Mounting 3 9 525293 MAGNET, Fuel Tank 0 25K-40428 0-RING, Cover 4E-06 LKWSHR, Cover to Tank 6 2 24C-62 BOLT, Cover to Tank 6 3 40K-6 PLUG, Cover 4 58763 COVER, Inspection 5 29F- ELBOW, Valve to Filter 6 53792 VALVE, Check 6A 36F-2 (UNION ADAPTER, Hose to Valve 7 5475 HOSE, Fuel Supply 8 537502 HOSE, Fuel Return 9 59F-5 UNION, Hose to Bushing 20 9F-3 BUSHING, Reducing 2 9F-5 BUSHING, Reducing 22 36F-2 UNION, Hose to Bushing t Not Illustrated PM 2543 [ 4
MARK MICHIGIM HYDRAULIC OIL RESERVOIR AND FILTER 54083 TUBE, Overflow 9 8D-2 NUT, Reservoir Mtg. 3 2 52874 CLAMP, Hose to Tube 20 66809 WASHER, Reservoir Mtg. 3 3 743563 HOSE, Overflow 2 530600 FILTER, Return 4 4E-06 I.KWSHR, Filler Neck 6 22 66809 WASHER, Reservoir Mtg. 3 5 24C-62 3OLT, Filler Neck 6 23 24C-252 BOLT, Reservoir Mtg. 3 6 52875 DIPSTICK, Reservoir 24 530903 ROD, Guide 7 554843 CAP, Filler 25 25K-40428 0-RING, Inspection Cover _ 8 508290 RESERVOIR, Hydraulic Oil 26 58763 COVER, Inspection 9 25K-40624 0-RING, Filler Neck 27 40K-6 PLUG, Drain 0 25K-40808 0-RING, Cover Plate 28 24C-62 BOLT, Cover 6 24C-66 BOLT, Cover Plate 6 29 4E-06 LKWSHR, Cover 6 2 4E-06 LKWSHR, Cover Plate 6 30 525293 MAGNET 3 529896 PLATE, Cover 3 532444 FILTER, Suction 4 543238 SPRING 32 567742 NECK, Filler Assy 5 8D-06 NUT, Guide Rod 33 52874 CLAMP, Hose to Filler Neck 6 529704 WASHER, Guide Rod 34 30H-3 CLIP, Hose to Frame 7 530598 SPRING 35 4E-06 LKWSHR, Tube Mtg. 8 529679 RETAINER, Filter 36 24C-62 BOLT, Tube Mtg. PM 2543 [ 5 ]
CLARK MICHIGAIll 24 I L. 7 27 4,<20 / 28 29 8 6 30 4 _04 6 le i io ) 2 3 33 32 «, it 5 56 55 \ I 47 46 4 I \2 " \ 38 flt 5 50 49 48 \ \39 40 444 4 64t\ 43 42 TRANSMISSION CONTROL LEVERS AND LINKAGE TS-9584 [ 6 ] PM 2543
CLq Rid TRANSMISSION CONTROL LEVERS AND LINKAGE MICHIGAll 3036 BALL JOINT, Control Rod 2 8D-08 NUT, Bellcrank to Bracket 3 66795 WASHER, Bellcrank Assy 4 585596 SLEEVE, Bellcrank 5 585597 BUSHING, Bellcrank 6 2H-5 FITTING, Bellcrank Grease 2 7 8D-05 NUT, Jam Control Rod 8 65246 WASHER, Bellcrank to Bracket 9 8D-08 NUT, Bracket to Bellcrank 0 65246 WASHER, Bellcrank to Bracket 66D-05 NUT, Control Rod to Bellcrank 2 3036 BALL JOINT, Control Rod 3 50908 ROD, Control Assy (F & R) (Inc., 7, 32 & 33) 4 54034 ROD, Control Assy (3 Speed) (Inc. 2, 6, 7, 34) 5 66D-05 NUT, Control Rod 6 8D-05 NUT, Control Rod 7 3036 BALL JOINT, Control Rod 8 543882 LEVER, Control Trans. (Hi-Lo) 9 24C-536 BOLT, Lever Support 4 20 508846 SUPPORT, Shift Lever 2 2 8D-06 NUT, Quadrant Shift 2 22 540823 QUADRANT SHIFT 23 24C-620 BOLT, Quadrant 2 24 6C-605 SCREW, Plate to Quadrant 6 25 53738 PLATE, Hi-Lo 26 567947 PLATE, Forward & Reverse 27 509772 KNOB, Shift Lever 2 28 508846 SUPPORT, Shift Lever 2 29 8D-05 NUT, Lever Support 4 30 543883 LEVER, Control Trans. (Forward & Reverse) 3 66D-05 NUT, Ball Joint 32 3036 BALL JOINT, Control Rod 33 8D-05 NUT, Ball Joint Jam 34 8D-05 NUT, Clevis Jam 35 585597 BUSHING, Bellcrank 36 65246 WASHER, Bolt to Bellcrank 37 24C-840 BOLT, Bellcrank to Bracket 38 585596 SLEEVE, Bellcrank 39 3036 BALL JOINT, Control Rod to Bellcrank 40 8D-05 NUT, Control Rod 4 509082 ROD, Control Bellcrank to Trans. (Inc. 40, 44, 52, 53, 55 & 57) 42 3036 BALL JOINT, Control Rod to Trans. 43 66D-05 NUT, Ball Joint 44 8D-05 NUT, Control Rod 45 585500 BELLCRANK, Hi & Lo 46 66D-05 NUT, Bellcrank to Ball Joint 47 24C-840 BOLT, Bellcrank to Bracket 48 BRACKET, of Frame 49 66D-05 NUT, Bellcrank to Ball Joint 50 66D-05 NUT, Bellcrank to Ball Joint 5 585500 BELLCRANK, Forward & Reverse 52 3036 BALL JOINT, Control Rod to Bellcrank 53 8D-05 NUT, Control Rod 54 509082 ROD, Control (Inc. 40, 44, 52, 53, 55 & 57) 55 8D-05 NUT, Control Rod 56 66D-05 NUT, Ball Joint 57 3036 BALL JOINT, Control Rod PM 2543 [ 7]
CUIRK michigafl 25.,- 2 22 23 24 \ \ iti 4 4' \ 26 27 r -,- \...7 D 29 20 9 30 C 3 4 32 3 / 8 I T 5 --- t 6 I - A \ B 36 35 34.. 33 78 74 / 73 72 69 6 68 \ \ \ V 5L 7 70 / - 39 40 4 42 43 \ 4I 46 45 64 62 63 6 49 \, 50 5 L 56 55 60 59 58 54 TRANSMISSION ASSEMBLY AND CLUTCH COVER TS-9650 [ 8 ] PM 2543
CLARK MICHIGAll TRANSMISSION ASSEMBLY AND CLUTCH COVER ) ) A 28354 TRANSMISSION ASSY (28320-4) (Inc. thru 80 and all s listed on pages 2 thru 28) F-428 COTTER, Flange Nut 2 2095 NUT, Flange 3 02745 WASHER, Flange Nut 4 25K-402 0-RING, Flange 5 24985 FLANGE, Input 6 23798 SEAL, Input Shaft Oil 7 22390 RING, Bearing Retainer 8 225603 BEARING, Input Shaft 9 22390 RING, Bearing Retainer 0 C-720 BOLT, Cover to Case 5 4E-07 LKWSHR, Cover to Case 5 2 3F-6 PLUG, Pipe 3 23626 COVER ASSY (Inc. 4 thru 28, 33 thru 37) 4 2433 BREATHER, Trans. 5 23056 SLEEVE, Front Cover 6 23085 LOCK, Sleeve to Cover 7 4E-05 LKWSHR, Sleeve to Cover 8 C-50 BOLT, Sleeve to Cover 9 25K-3002 0-RING, Reverse Tube 20 23628 TUBE, Reverse Speed 2 25K-3002 0-RING, Third Tube 22 23629 TUBE, Third Speed 23 23048 CLIP, Tube Retaining 24 4E-05 LKWSHR, Tube Retaining 25 C-50 BOLT, Tube Retaining 26 C-50 BOLT, Tube Retaining 27 4E-05 LKWSHR, Tube Retaining 28 23048 CLIP, Tube Retaining 29 224026 RING, Gear Retaining 30 24935 GEAR, Input Shaft 3 23058 BEARING, Input Shaft 32 23782 SHAFT, Input 33 C-50 BOLT, Sleeve to Cover 34 4E-05 LKWSHR, Sleeve to Cover 35 23085 LOCK, Sleeve to Cover 36 23056 SLEEVE, Front Cover 37 222067 SLEEVE, Tube 2 38 23247 SPRING, Detent 2 39 248 PIN, Case to Cover Dowel 2 40 2378 GASKET, Cover to Case 4 2392 COVER, Rear 42 4E-07 LKWSHR, Cover to Case 3 43 C-720 BOLT, Cover to Case 3 44 6F-02 PLUG, Rear Cover Pipe 45 62D-07 NUT, Cover to Case 2 46 4E-07 LKWSHR, Cover to Case 2 47 25K-40026 0-RING, Pressure Tube 48 222067 SLEEVE, Pressure Tube 49 226862 STUD, Cover to Case 2 50 C-520 BOLT, Front Cover to Case _ 5 5 4E-07 LKWSHR, Front Cover to Case 5 52 25757 PLUG, Drain Magnetic 53 40K-04 PLUG, Oil Level 2 54 23390 SCREEN, Suction 55 29373 GASKET, Screen 56 236 CASE ASSY (Inc. 48, 60, 6 thru 63, 68, 69) 57 2F-02 PLUG, Trans. Case 58 6908 WASHER, Clip 59 6H-36 CLIP, Tube Retaining 60 2362 TUBE, Suction 6 4C-54 BOLT, Washer Retaining 2 62 23092 WASHER, Tube Retaining 63 25K-4004 0-RING, Washer to Tube _ 64 23606 GASKET, Cover to Case 65 24295 PIN, Case to Cover Dowel _ 66 H-48 RIVET, Suction Tube to Clip _ 67 25K-40026 0-RING, Pressure Tube 68 222067 SLEEVE, Pressure Tube 69 230900 TUBE, Pressure 70 C-632 BOLT, Valve to Cover 9 7 4E-06 LKWSHR, Valve to Cover 9 72 CONTROL VALVE ASSY (See Index) 73 236 GASKET, Valve to Cover 74 0J-2 BALL, Detent 2 75 4E-07 WASHER, Cover to Case 4 76 C-728 BOLT, Cover to Case 4 77 29370 PLUG, Cover 78 29373 GASKET, Plug 79 C-744 BOLT, Cover to Case 4 80 4E-07 LKWSHR, Cover to Case 4 ) PM 2543 [ 9 ]
CUIRK MICHIGIM [20] PM 2543
CMRK GEAR AND SHAFT GROUP - TRANSMISSION MICHIG 2583 RING, Clutch Shaft Seal 3 3 230822 SPRING, Piston Return 2 224083 RING, Bearing Retainer 3 225603 BEARING, Clutch Shaft 4 224083 RING, Bearing Retainer 5 230829 BEARING, Disc Hub 6 223877 RING, Bearing Retainer 7 23097 GEAR & HUB ASSY (30T) 8 7360 RING, Hub Oil Baffle 9 223877 RING, Bearing Retainer 0 230829 BEARING, Disc Hub 65463 RING, Return Spring Ret. 2 232089 WASHER, Spring Ret. 3 230822 SPRING, Piston Return 4 CLUTCH ASSY, Rev. & Third (See Index) 5 230822 SPRING, Piston Return 6 232089 WASHER, Spring Ret. 7 65463 RING, Return Spring Ret. 8 230860 BEARING, Disc. Hub 9 223874 RING, Bearing Retainer 20 7360 RING, Hub Oil Baffle 2 23098 GEAR & HUB ASSY (60T) 22 230906 SPACER, Hub Bearing 23 223874 RING, Bearing Ret. 24 230860 BEARING, Disc Hub 25 658038 BEARING, Clutch Shaft 26 2398 GEAR & HUB ASSY (22T) 27 7360 RING, Hub Oil Baffle 28 65463 RING, Hub & Gear Retainer 29 65463 RING, Return Spring Ret. 30 232089 WASHER, Spring Ret. 32 33 -- 230822 CLUTCH & DRUM Forward & Third (See Index) SPRING, Piston Return 34 232089 WASHER, Spring Ret. 35 65463 RING, Return Spring Ret. 36 230829 BEARING, Clutch Shaft 37 223877 RING, Bearing Retainer 38 7360 RING, Hub Oil Baffle 39 23097 GEAR & HUB ASSY (30T) 40 223877 RING, Bearing Retainer 4 230829 GEAR & HUB ASSY 42 224083 RING, Bearing Ret. 43 230889 RING, Bearing Retainer 44 223349 BEARING, Clutch Shaft 45 224083 RING, Bearing Retainer 46 2583 RING, Clutch Shaft Seal 3 47 230886 BEARING, Pilot 48 23554 BEARING, Clutch Shaft 49 230888 RING, Bearing Retainer 50 230885 BEARING, Disc Hub 5 223964 RING, Bearing Retainer 52 23229 GEAR & HUB ASSY (53T) 53 7360 RING, Hub Oil Baffle 54 223964 RING, Bearing Retaining 55 230885 BEARING, Disc Hub. 56 230888 RING, Bearing Retaining 57 65463 RING, Return Spring Ret. 58 232089 WASHER, Return Spring Ret. 59 230822 SPRING, Piston Return 60 232088 WASHER, Return Spring Ret. PM 2543 [ 2 ]
CUIRK micmcnn [22] PM 2543
CMRK GEAR AND SHAFT GROUP TRANSMISSION (Continued) michigafl!tern!tern 6 -- CLUTCH & DRUM Low 90 742240 CUP, Output Shaft Brg. (See Index) 9 35447 CONE, Output Shaft Brg. _ 62 C-68 BOLT, Bearing Cap 5 92 23095 GEAR, Output (53T) 63 4E-06 LKWSHR, Bearing Cap 5 93 ---- CASE ASSY See Index 64 230957 PLUG, Cover 94 23406 SHAFT, Output 65 22406 RING, Gear Retainer 95 23405 SPACER, Output Shaft 66 23087 GEAR, Low (28T) 96 3473 CONE, Output Shaft Brg. _ 67 23095 GEAR, Idler Shaft (53T) 97 666697 CUP, Output Shaft Brg. 68 230968 BEARING, Clutch Shaft 98 25K-40424 0-RING, Bearing Cap 69 23208 RING, Bearing Retainer 99 23848 SHIM, Bearing Cap.004 70 220079 RING, Clutch Shaft Seal 99A 23849 ft SHIM, Bearing Cap.007 _ 7 220079 RING, Clutch Shaft Seal 99B 23850 t$shim, Bearing Cap.00 _ 72 2393 GASKET, Bearing Cap 99C 2385 tt SHIM, Bearing Cap.020 _ 73 25K-3006 0-RING, Bearing Cap 00 2388 CAP, Output Shaft Brg. 74 2376 CAP, Distributor Bearing 0 4E-09 LKWSHR, Bearing Cap 4 75 6F-02 PLUG, Bearing Cap Pipe 02 C-920 BOLT, Bearing Cap 4 76 C-920 BOLT, Bearing Cap 4 03 222960 NUT, Flange 77 4E-09 LKWSHR, Bearing Cap 4 04 22279 WASHER, Flange 78 0J-5 LOCK BALL, Bearing 05 25K-606 0-RING, Flange 79 23646 BEARING, Idler Shaft 06 2336 FLANGE, Output 80 230952 RING, Bearing Retainer 07 230954 SEAL, Bearing Cap Oil 8 25634 NUT, Idler Shaft 08 224083 RING, Bearing Ret. 82 23098 GASKET, Bearing Cap 09 743439 BEARING, Idler Shaft 83 2342 CAP, Distributor Bearing 0 234 SHAFT, Idler 84 225823 SEAL, Bearing Cap Oil 224065 RING, Gear Retainer 85 25K-30026 0-RING, Bearing Cap 2 222960 NUT, Flange 86 C-920 BOLT, Bearing Cap 4 87 4E-09 LKWSHR, Bearing Cap 4 3 222960 WASHER, Flange 88 2387 CAP, Output Shaft Bearing 4 25K-606 0-RING, Flange 89 25K-40424 0-RING, Bearing Cap 5 ---- FLANGE, Parking (See Index) tnot Illustrated As Required PM 2543 [ 23 ]
CMRK MICHIGIII CLUTCH GROUP - LOW 2590 RING, End Plate Retainer 2 224774 PLATE, Clutch Disc End 3 2309 DISC, Clutch Inner 9 4 224772 DISC, Clutch Outer 9 5 230850 PISTON, Clutch 6 22477 RING, Piston Outer Seal 7 230857 RING, Piston Inner Seal 8 2394 CLUTCH DRUM & SHAFT ASSY CLUTCH GROUP - FORWARD AND SECOND 2590 RING, End Plate Retainer 2 2 224774 PLATE, Clutch Disc End 2 3 2284 DISC, Clutch Inner 2 4 224772 DISC, Clutch Outer 2 5 230850 PISTON, Clutch 2 6 22477 RING, Piston Outer Seal 2 7 230857 RING, Piston Inner Seal 2 8 23090 CLUTCH DRUM & SHAFT ASSY [ 24 ] PM 2543
CLARK MICHIGN CLUTCH GROUP - REVERSE AND THIRD 2590 RING, End Plate Retainer 2 2 224774 PLATE, Clutch Disc End 2 3 2284 DISC, Clutch Inner 2 4 224774 DISC, Clutch Outer 2 5 230850 PISTON, '2utch 2 6 22477 RING, Piston Outer Seal 2 7 230857 RING, Piston Inner Seal 2 8 23085 CLUTCH DRUM & SHAFT ASSY PM 2543 [ 25 ]
CUIRK MICHIGAll CONTROL VALVE - TRANSMISSION I tern A 23803 CONTROL VALVE ASSY (Inc. thru 26) 27928 PLUG, Stop 2 9F-8 0-RING, Plug Stop 3 25K-30020 0-RING, Piston 4 227672 SEAL, Piston Outer 5 227674 PISTON 6 29342 VALVE, De-Clutch Control (Inc. thru 5,, 26 & 27) 7 225856 SEAL, Oil 8 66440 RING, Seal Retainer 9 27657 WASHER, Seal Retainer 0 23840 SPACER, Overshift 25K-30022 0-RING 2 VALVE, Manual Control See "A" 3 VALVE, De-Clutch Control See "A" 4 6F-0 PLUG, Spool Selector 5 2364 SPRING, Control Valve 6 HOUSING, Control Valve See "A" 7 23839 SPACER, Overshaft 8 9F-7 0-RING, Housing Plug 9 24K-7 PLUG, Valve Housing 20 0J-2 BALL, Detent 2 229729 SWITCH, Neutral 22 VALVE, Manual Control See "A" 23 27657 WASHER, Seal Retainer 24 66440 RING, Seal Retainer 25 225856 SEAL, Oil 26 22893 SEAL, Band Felt 27 22435 SEAL, Oil Not Sold Separately [ 26 ] PM 2543
CMRK michigaii PARKING BRAKE ASSEMBLY A 230863 BRAKE ASSY (Inc. thru ) 8075 PLATE, Backing 2 8026 LEVER, Actuating 3 8092 SHOE ASSY, Brake (Inc. 9 thru ) 2 4 228234 FLANGE, Brake 5 2560 DRUM, Parking Brake 6 4E-06 LKWSHR, Drum to Flange 6 7 2C-62 BOLT, Drum to Flange 6 8 8093 SPRING, Shoe Return 2 9 SHOE, Brake See 3 0 8024 LINING KIT, Brake Shoe (Inc. ) 23H-504 RIVET, Lining to Shoe 20 2 C-96 BOLT, Brake Mounting 4 3 5E-09 LKWSHR, Brake Mounting 4 Not Sold Separately PM 2543 [ 27 ]
CUIRK MICHIG 32 29 30 3 25 38 52 54 76 75 6 7 69 0 79 78 9 93 90 96 95 94 89 i 98 99 I 97 00 TORQUE CONVERTER ASSEMBLY TS-808-P [ 28 ] PM 2543
CUIRK MICHIGIM TORQUE CONVERTER ASSEMBLY ) ) A 28355 CONVERTER ASSY, Torque (C272-50) (Inc. thru 97, 00, 0, 02) 3F-6 PLUG, Pipe 2 7298 RING, Gear Retaining 3 3 2493 GEAR, Pump Drive (38T) 3 4 80546 HOUSING, Converter 5 3F-6 PLUG, Pipe 2 6 24949 GASKET, Regulating Valve to Converter 7 25K-4004 0-RING, Regulating Valve to Converter 8 22232 SPRING, Safety Valve 9 22238 PLUNGER, Safety Valve 0 24946 SEAT, Safety Valve 40K-02 PLUG, Valve Housing 2 40K-02 PLUG, Valve Housing 3 24943 VALVE ASSY, Pressure Regulating (Inc. 0, 4, 5, 6, 9 thru 24) 4 25K-3008 0-RING, Piston Stop 5 220983 STOP, Piston 6 66078 PIN, Piston Stop 7 4E-06 LKWSHR, Valve to Converter 4 8 5C-66 BOLT, Valve to Converter 4 9 66078 PIN, Piston Stop 20 224368 SPRING, Valve Outer 2 224369 SPRING, Valve Inner 22 PISTON, Valve See 3 23 25K-3008 0-RING, Piston Stop 24 220983 STOP, Piston 25 3F-6 PLUG, Pipe 26 24936 BEARING, Pump Drive Shaft 3 27 24930 SPACER, Pump Drive Shaft 3 28 24956 BEARING, Pump Drive Shaft 3 28A 24954 t RING, Bearing Retaining 3 29 224039 RING, Bearing Retaining 3 30 7386 RING, Washer Retaining 3 3 2496 SLEEVE, Pump Drive Adapter 32 55906 GASKET, Pump to Converter 33 450230 * PUMP, Converter Charging 34 8D-06 NUT, Pump Mounting 6 35 4E-06 LKWSHR, Pump Mounting 6 36 207647 STUD, Pump Mounting 6 37 24929 WASHER, Pump Drive Shaft 3 38 24928 SHAFT, Pump Drive 3 39 C-628 BOLT, Baffle to Housing 3 40 4E-06 LKWSHR, Baffle to Housing 3 4 6F-08 PLUG, Pipe 42 40K-02 PLUG, Pipe 2 43 742056 BEARING, Output Shaft Front 44 24937 SHAFT, Output 45 743439 BEARING, Output Shaft Rear 46 24945 RETAINER & SEAL, Bearing (Inc. 49) 47 4E-07 LKWSHR, Bearing Ret. 3 48 C-720 BOLT, Bearing Retainer 3 49 206864 SEAL, Oil 50 25K-402 0-RING, Flange 5 2095 NUT, Output Shaft 52 F-424 PIN, Cotter 53 02745 WASHER, Output Shaft 54 24985 FLANGE, Companion (6-C) 55 8D-07 NUT, Bearing Retainer 2 Not Sold Separately t Not Illustrated *NOTE: When Converter Charging Pump replacement is required, only a new factory built and tested pump should be used. Proper operation of converter and transmission is dependent on an efficient charging pump. Damage possible by use of a field rebuilt pump can result in repair cost exceeding cost of a new pump alone. PM 2543 [29 ]
CLARK MICHICAll [ 30 ] PM 2543
CUIRK TORQUE CONVERTER ASSEMBLY (Continued) MICHIGAN 56 4E-07 LKWSHR, Bearing Ret. 2 57 25K-4052 0-RING, Bearing Ret. 58 24730 STUD, Bearing Retainer 2 59 22390 RING, Bearing Retaining 60 24938 GEAR, Output Shaft (27T) 6 24935 GEAR, Turbine Shaft (28T) 62 24955 RING, Bearing Retaining 63 742002 BEARING, Turbine Shaft 64 24933 SHAFT, Turbine 65 24932 STATOR SUPPORT ASSY 66 22653 X RING, Sealing 67 2495 GEAR, Impeller Hub 68 224009 RING, Gear Retaining 69 C-820 BOLT, Support to Hsg. 6 70 7E-08 LKWSHR, Support to Hsg. 6 7 222079 RING, Turbine Shaft Sealing 72 24953 RING, Bearing Retaining 73 224026 RING, Gear Retaining 74 24939 0-RING, Oil Baffle 75 4C-74 BOLT, Hub to Impeller 8 75A ---- f$lockwire, Impeller Hub Bolt (8 ga.) 76 69025 WASHER, Hub to Impeller 8 77 25K-4066 0-RING, Impeller Hub 78 24596 BEARING, Impeller Hub 79 24934 SPACER, Reaction Member 80 743035 RING, Reaction Member Retaining 8 24924 **HUB, Turbine 82 69023 WASHER, Turbine Hub 8 83 20933 BOLT, Turbine Hub 8 83A ---- ttlockwire, Turbine Hub Bolt (8 ga.) 84 659065 RING, Turbine Hub Ret. 85 223833 **TURBINE 86 659065 RING, Turbine Hub Ret. 87 2492 MEMBER, Reaction 87A 658244 ]'PIN, Member to Spacer Lock 88 24953 RING, Bearing Retaining 89 24958 HUB, Impeller 90 24959 IMPELLER 9 24925 BAFFLE, Oil 92 2494 SEAL, Oil Baffle 93 24939 0-RING, Impeller to Cover 94 666542 RING, Bearing Retaining 95 24988 BEARING, Impeller Cover 96 24922 COVER, Impeller 97 222006 SLEEVE, Impeller Cover 98 224795 BOLT, Gear to Flywheel 8 98A ---- t LOCKWIRE, Impeller Bolt (8 ga. 20" lg.) 4 99 25909 WASHER, Gear to Flywheel 8 00 25264 GEAR, Converter Drive 0 5C-66 BOLT, Impeller to Cover 24 02 4E-06 LKWSHR, Impeller to Cover 24 03 23C-620 f BOLT, Converter to Flywheel Housing 2 04 4E-06 tlkwshr, Converter to Flywheel Housing 2 04A 55323 tsender, Temperature Converter 05 2433 t BREATHER 06 227265 tvalve, Check tnot Illustrated tas Required **NOTE: Machine Serial 40A08 thru 40A, 40A3 thru 40A23 received a one piece Turbine Assembly. If replacement becomes necessary, service with items 8 thru 86. PM 2543 [ 3 ]
-E..-) \ ---' ---, ----- \ 323 z / / L '',- / 8 22 23 2 V j, we, 7 24 25 60 62 58 6 57 56 / 55 / 54 5 4 3 \ 2\ //,,----, / / f',v // /, ' ( '--,, ( -Olkee.:.',,, I II / 0 )) II 6 i / 9 \ ',.T/ -.- 44 t i 8 \44..' i'f5p I -6,,,,,,, 53 '%((---- 52 45 20 9 42 \ 40 4 ' 26 5 / 9, //;- // 46 38 /( 37 33 a HYDRAULIC SYSTEM TRANSMISSION AND TORQUE CONVERTER TS-9523-P
CLARK HYDRAULIC SYSTEM - TRANSMISSION AND TORQUE CONVERTER MICHIGIM ------ RADIATOR ASSY (See Index) 2 9F-8 0-RING, Hose to Radiator _ 3 54290 HOSE, Pipe to Radiator (Inc. 2) 4 3F-04 PLUG, Tube TORQUE CONVERTER ASSY 5 ---- (See Index) 6 9F-8 0-RING, Elbow to Converter 7 9F-6 0-RING, Elbow to Converter 8 8K-6 ELBOW, Hose to Converter (Inc. 7) 9 89F-8 ADAPTER, Hose to Pump 0 OMIT, Not Used This Application OMIT, Not Used This Application 2 83F-0 ADAPTER, Hose to Pump 3 9F-8 0-RING, Elbow 4 8K-8 ELBOW, Hose to Converter (Inc. 3) 5 508764 TUBE, Radiator to Trans. (Inc. 4) 6 ---- HOSE (See 3) 7 3F-04 PLUG, Tube 8 508763 TUBE, Cooler to Radiator (Inc. 7) 9 530546 HOSE, Filler 20 54586 CLAMP, Hose to Tube 2 4E-06 LKWSHR, Plate to Cockpit 2 22 23C-66 BOLT, Plate to Cockpit 2 23 568824 PLUG, Filler 24 509750 DIPSTICK, Transmission 25 560640 GROMMET, Dipstick Tube 26 568807 PLATE, Filler 27 54595 TUBE, Dipstick 28 7K-8 ELBOW, Tube to Trans. (Inc. 29) 29 9F-8 0-RING, Elbow to Trans. 30 TRANSMISSION (See Index) 3 35668 BUSHING, Reducing. 32 83F-6 ELBOW, Hose to Bushing t Not Illustrated 33 667289 34 54586 35 529979 36 54586 37 9F-0 38 7K-0 39 9F-6 40 7K-6 4 667289 42 54586 43 540073 44 ---- 45 540078 46 5096 47 54586 48 529979 49 54586 50 666846 5 540072 52 7K-8 53 54007 54 545204 55 9F-8 56 53364 56A 25502 57 24C-624 57A 4E-06 58 59 9F-8 60 7K-8 6 54290 62 9F-8 NIPPLE, Hose to Trans. CLAMP, Hose to Nipple HOSE, Tube to Nipple CLAMP, Hose to Nipple 0-RING, Elbow to Trans. ELBOW, Hose to Trans. (Inc. 37) 0-RING, Elbow to Trans. ELBOW, Hose to Trans. (Inc. 39) NIPPLE, Hose to Trans. CLAMP, Hose to Nipple HOSE, Pump Suction PUMP, Converter Charging (See Index) HOSE, Reg. Valve to Trans. _ TUBE, Converter Drain CLAMP, Hose to Drain Tube _ HOSE, Clamp to Drain Tube CLAMP, Hose to Drain Tube _ NIPPLE, Hose to Converter HOSE, Filter to Converter ELBOW, Hose to Converter (Inc. 6) HOSE, Filter to Converter ADAPTER, Hose to Filter (Inc. 55) 0-RING, Adapter FILTER, Converter & Transmission (Inc. 56A) CARTRIDGE KIT, Filter BOLT, Filter Mtg. 4 LKWSHR, Filter Mtg. 4 OMIT, Not Used This Application 0-RING, Elbow ELBOW, Hose to Filter (Inc. 59) HOSE, Tube to Radiator (Inc. 62) 0-RING, Hose to Radiator PM 2543 [ 33 ]
CUIRK michigpii MID-MOUNT BEARING ASSEMBLY A 230527 BEARING ASSY, Mid-Mount 4 22279 (Inc. thru 26) 5 205928 222233 FLANGE, Input 6 F-436 2 22279 WASHER, Flange 7 222029 3 C-722 BOLT, Cap to Housing 8 8 25K-606 4 4E-07 LKWSHR, Cap to Housing 8 9 225823 5 25K-40308 0-RING, Bearing Cap 20 856250 6 856250 CUP, Bearing 2 25757 7 6544 CONE, Bearing 22 225823 8 230529 HOUSING, Bearing 23 230690 8A 3F-2 t PLUG, Filler 23A 27566 9 28504 0 6544 2433 2 25K-40308 SHAFT, Bearing CONE, Bearing BREATHER, Housing 0-RING, Bearing Cap 23B 27567 23C 27568 24 25K-606 3 27565 CAP, Bearing 25 205928 3A 27566 if SHIM, Bearing Cap (.004) 26 F-436 3B 27567 SHIM, Bearing Cap (.007) 27 23C-028 3C 27568 if SHIM, Bearing Cap (.00) _ 28 4E-0 WASHER, Flange NUT, Flange COTTER, Flange Nut FLANGE, Output 0-RING, Flange SEAL, Bearing Cap CUP, Bearing PLUG, Drain SEAL, Bearing Cap CAP, Bearing if SHIM, Bearing Cap (.004) if SHIM, Bearing Cap (.007) if SHIM, Bearing Cap (.00) 0-RING, Flange NUT, Flange COTTER, Flange Nut t BOLT, Bearing Mtg. 4 t LKWSHR, Bearing Mtg. 4 - Not Illustrated tas Required [ 34 ] PM 2543
CLeIRK MICHIG PROPELLER SHAFT ASSEMBLIES Transmission to Rear Axle Mid-Mount Brg. to Front Axle Transmission to Mid-Mount Transmission to Converter A 940562 504774 508467 562694 PROP SHAFT ASSY (Inc. thru 6) B 948363 KIT, Dust Cap (Inc. 5, 6, 3) 940089 940089 89285 940089 BOLT, Spider & Bearing to Tube 4 la 4E-07 t I-KWSHR, Spider & Bearing to Tube _ 4 2 944862 944862 94836 944862 SPIDER & BEARING ASSY (Inc. 5) 3 943238 948279 948364 94609 TUBE 4 8D-06 8D-06 OMIT 8D-06 NUT, Spider & Bearing to Tube 4 5 940090 940090 See B 940090 RETAINER, Felt 6 94009 94009 See B OMIT WASHER, Felt Retainer 2 7 940093 942660 948362 9460 SLIP YOKE (Inc. 2) 8 8D-06 8D-06 OMIT 8D-06 NUT, Spider & Bearing to Slip Yoke _ 4 9 94572 944862 94836 944862 SPIDER & BEARING ASSY (Inc. ) 0 940089 940089 89285 940089 BOLT, Spider & Bearing to Slip Yoke _ 4 0A 4E-07 t LKWSHR, Spider & Bearing to Slip Yoke 4 0H-35 0H-25 0H-25 0H-35 FITTING, Spider & Bearing Grease 2 0H-25 0H-25 0H-25 0H-25 FITTING, Slip Yoke Grease 3 940092 940092 See B 940092 FELT WASHER 4 940089 940089 940089 BOLT, Spider & Bearing Attaching 8 5 0H-35 0H-35 0H-25 0H-35 FITTING, Spider & Bearing Grease 6 8D-06 8D-06 8D-08 8D-06 NUT, Spider & Bearing Attaching 8 tnot Illustrated PM 2543 [ 35 ]
CLeIRK MICHIGN [36] PM 2543
CLARK AXLE ASSEMBLY - FRONT DRIVE MICHIG A 9084 AXLE ASSY (Inc. thru 44) FD-7700 0894 BOLT, Disc to Hub 32 2 0442 WASHER, Disc to Hub 32 3 9469 PLUG, Hub Filler 2 4 2803 GEAR & HUB ASSY, Internal 2 23 2808 STUD, Wheel 24 24 672004 CUP, Inner Hub Bearing 2 25 79593 CONE, Inner Hub Bearing 2 26 202 SEAL, Hub Oil 2 27 269 SLEEVE, Wear 2 ) 5 203 NUT, Spindle 2 28 2776 DISC, Brake 2 ) 6 204 LOCK, Spindle Nut 2 29 5756 HOUSING, Axle 7 203 NUT, Spindle 2 30 F-2 PLUG, Housing Filler 8 205 SLEEVE, Sun Gear Thrust 2 3 06656 BREATHER, Housing 9 224028 RING, Sun Gear Retainer 2 32 0305 BOLT, Brake Head Attaching 2 0 2804 GEAR, Sun 2 07348 0-RING, Planet Carrier 2 2 -- PLANET CARRIER (See Index) 3 06762 WASHER, Planet Carrier to Hub 24 4 00970 BOLT, Planet Carrier to Hub 24 5 F-04 PLUG, Oil Level 2 6 F-02 PLUG, Thrust Cap 2 7 C-808 BOLT, Puller 4 8 3E-08 LKWSHR, Puller 4 9 2806 SHAFT, Axle 2 33 656 WASHER, Brake Head Attaching 2 34 2782 PLATE, Brake Adapter 2 35 8C-032 BOLT, Plate to Housing 6 36 -- BRAKE HEAD ASSY (See Index) 37 0442 WASHER, Plate to Housing _ 6 38 06998 NUT, Plate to Housing 6 39 9469 PLUG, Housing Drain 40 9270 STUD, Carrier to Housing 4 4 -- DIFF. & CARRIER ASSY (See Index) 20 67526 CONE, Outer Hub Bearing _ 2 42 0326 DOWEL, Carrier to Housing _ 3 2 668553 CUP, Outer Hub Bearing 2 43 2278 WASHER, Carrier to Housing 4 22 2785 HUB ASSY (Inc. 2, 24) 2 44 64D-07 NUT, Carrier to Housing 4 PM 2543 [ 37 ]
C _ z 0 n 0 z rn 0 z 30 a DIFFERENTIAL AND CARRIER ASSEMBLY TS-9655
CUIRK MICHIGAIll DIFFERENTIAL AND CARRIER ASSEMBLY - FRONT DRIVE A 20235 DIFF. & CARRIER ASSY 24A 2355 ttshim, Bearing Cage Med. (Inc. thru 44) 24B 2354 ]'$ SHIM, Bearing Cage Thin _ 0074 BOLT, Differential Case 8 25 2350 CAGE ASSY, Pinion Bearing 2 0482 NUT, Ring Gear Bolt 2 (Inc. 26) 3 DIFF. CASE Flange Half 26 675257 CUP, Pinion Bearing See 46 27 70288 CONE, Outer Pinion Bearing 4 RING, Gear See 47 _ 28 4E-08 LKWSHR, Seal Retainer 5 0076 BOLT, Ring Gear 2 29 C-828 BOLT, Seal Retainer 6 0073 WASHER, Side Gear Thrust _ 2 30 0608 FLANGE, Companion 7 85744 KIT, Differential Pinion 3 00950 NUT, Pinion Shaft 8 007 SPIDER, Differential 32 F-428 COTTER, Pinion Shaft Nut 9 0070 GEAR, Differential Side 2 33 0095 WASHER, Pinion Shaft Nut 0 DIFF. CASE, PLAIN HALF See 48 34 720 SEAL, Pinion Oil 0482 NUT, Differential Case 2 35 C-928 BOLT, Seal Retainer 5 2 0072 WASHER, Differential Pinion 36 4E-09 LKWSHR, Seal Retainer 5 Thrust 4 37 2352 RETAINER, Seal 3 675536 BEARING, Inner Pinion 38 2353 GASKET, Seal Retainer 4 ---- PINION, Differential See 47 39 00953 SCREW, Thrust 5 3C-64 BOLT, Nut Lock 2 40 00954 LOCK, Thrust Screw 6 4E-06 LKWSHR, Adj. Nut Lock 2 4 8D-4 NUT, Thrust Screw 7 0094 LOCK, Diff. Adj. 2 42 85784 CARRIER ASSY (Inc. 43, 44)_ 8 00940 NUT, Differential Adj. 2 43 00937 BOLT, Diff. Carrier Cap 4 9 675249 CUP, Differential Brg. 2 44 656 WASHER, Diff. Carrier Cap_ 4 20 675248 CONE, Differential Brg. 2 45 06039 t DIFF. ASSY (Inc. thru ) 2 667277 CONE, Center Pinion Brg. 46 0060 t DIFF. BODY SUB ASSY (Inc., 3, 6 thru 2) 22 667278 CUP, Center Pinion Brg. 47 027 t GEAR & PINION SET (Inc. 4, 4) 23 00952 SPACER, Pinion Brg. 48 85033 t DIFF. CASE KIT (Inc., 24 2356 tshim, Bearing Cage Thick 3, 0 & ) Not Sold Separately t Not Illustrated tas Required PM 2543 [ 39 ]
CLeIRK michigan [ 40] PM 2543
CLIIRK AXLE ASSEMBLY - REAR DRIVE MICHIGAII item A 90842 AXLE ASSY (Inc. thru 44) RD-7700 0894 BOLT, Disc to Hub 32 2 0442 WASHER, Disc to Hub 32 3 9469 PLUG, Hub Filler 2 4 2803 GEAR & HUB ASSY, Internal 2 5 203 NUT, Spindle 2 23 2808 STUD, Wheel 24 24 672004 CUP, Inner Hub Bearing 2 25 79593 CONE, Inner Hub Bearing 2 26 202 SEAL, Hub Oil 2 27 269 SLEEVE, Wear 2 28 2776 DISC, Brake 6 204 LOCK, Spindle Nut 2 29 5756 HOUSING, Axle 7 203 NUT, Spindle 2 30 F-2 PLUG, Housing Filler 8 205 SLEEVE, Sun Gear Thrust 2 3 06656 BREATHER, Housing 9 224028 RING, Sun Gear Retainer 32 0305 BOLT, Brake Head Attaching 2 -) 0 2804 GEAR, Sun 2 07348 0-RING, Planet Carrier 2 2 -- PLANET CARRIER (See Index) 3 06762 WASHER, Planet Carrier to Hub 24 4 00970 BOLT, Planet Carrier to Hub 24 5 F-04 PLUG, Oil Level 2 6 F-02 PLUG, Thrust Cap 2 7 C-808 BOLT, Puller 4 8 3E-08 LKWSHR, Puller 4 9 2806 SHAFT, Axle 2 20 67526 CONE, Outer Hub Bearing _ 2 33 656 WASHER, Brake Head Attaching 2 34 2782 PLATE, Brake Adapter 2 35 8C-032 BOLT, Plate to Housing 6 36 -- BRAKE HEAD ASSY (See Index) 37 0442 WASHER, Plate to Housing _ 6 38 06998 NUT, Plate to Housing 6 39 9469 PLUG, Housing Drain 40 9270 STUD, Carrier to Housing 4 4 -- DIFF. & CARRIER ASSY (See Index) 42 0326 DOWEL, Carrier to Housing _ 3 2 668553 CUP, Outer Hub Bearing 2 43 2278 WASHER, Carrier to Housing 4 22 2785 HUB ASSY (Inc. 2, 24) 2 44 64D-07 NUT, Carrier to Housing 4 PM 2543 [ 4 ]
n 0 Z N -4 Pa C n...i... 0 Z 3 zt. n Z Z m -I ts N... 0 Z DIFFERENTIAL AND CARRIER ASSEMBLY a = cl = =
CMRK michignfl DIFFERENTIAL AND CARRIER ASSEMBLY - REAR DRIVE A 2080 DIFF. & CARRIER ASSY 24A 2355 t$shim, Bearing Cage Med. (Inc. thru 44) 24B 2354 ftshim, Bearing Cage Thin_ 0074 BOLT, Differential Case 8 25 2350 CAGE ASSY, Pinion Bearing 2 0482 NUT, Ring Gear Bolt 2 (Inc. 26) 3 DIFF. CASE, Flange Half 26 675257 CUP, Pinion Brg. See 46 27 70288 CONE, Outer Pinion Bearing 4 -- RING GEAR See 47 _ 28 4E-08 LKWSHR, Seal Retainer 5 0076 BOLT, Ring Gear 2 29 C-828 BOLT, Seal Retainer 6 0073 WASHER, Side Gear Thrust 2 7 85744 KIT, Differential Pinion 8 007 SPIDER, Differential 9 0070 GEAR, Differential Side 2 30 0608 FLANGE, Companion 3 00950 NUT, Pinion Shaft 32 F-428 COTTER, Pinion Shaft Nut 33 0095 WASHER, Pinion Shaft Nut _ 0 ---- DIFF. CASE, Plain Half 34 720 SEAL Pinion Oil See 48 35 C-928 BOLT, Seal Retainer 5 0482 NUT, Differential Case 2 36 4E-09 LKWSHR, Seal Retainer 5 2 0072 WASHER, Differential Pinion Thrust 4 37 2352 RETAINER, Seal 3 675536 BEARING, Inner Pinion 38 2353 GASKET, Seal Retainer 4 ---- PINION, Differential 39 00953 SCREW, Thrust See 47 40 00954 LOCK, Thrust Screw 5 3C-64 BOLT, Nut Lock 6 4E-06 LKWSHR, Adj. Nut Lock 2 7 0094 LOCK, Diff. Adj. 2 8 00940 NUT, Differential Adj. 2 9 675249 CUP, Differential Brg. 2 20 675248 CONE, Differential Brg. 2 2 667277 CONE, Center Pinion Brg._ 4 8D-4 NUT, Thrust Screw 42 85784 CARRIER ASSY (Inc. 43,44) 43 00937 BOLT, Diff. Carrier Cap 4 44 656 WASHER, Diff. Carrier Cap 4 45 994 t DIFF. ASSY (Inc. thru ) 46 0060 t DIFF. BODY SUB ASSY (Inc., 3, 6 thru 2) 22 667278 CUP, Center Pinion Brg. 47 850 t GEAR & PINION SET (Inc. 4, 4) 23 00952 SPACER, Pinion Brg. 48 85033 t DIFF. CASE KIT (Inc., 24 2356 t SHIM, Bearing Cage Thick 3, 0 & ) Not Sold Separately t Not Illustrated *As Required PM 2543 [ 43 ]
CLARK MICHIG BRAKE HEAD ASSEMBLY - L.H. A 2777 *BRAKE HEAD ASSY, L.H. (Inc. thru 5) 947926 TUBE & NUT ASSY 2 947927 VALVE, Hydraulic Bleeder 3 947928 VALVE, Hydraulic Bleeder 4 947930 BOLT, Self Locking 4 5 94793 PIN, Carrier & Lining Retaining 4 6 947932 CARRIER & LINING ASSY 2 7 C-620 BOLT, Cap Mounting 8 8 03293 WASHER, Flat 8 9 947933 CAP, Inlet 0 947934 CAP PACKING, See 6 2 2 947935 PISTON 4 3 BOOT, See 6 4 4 PACKING, See 6 4 5 947938 TORQUE PLATE ASSY 6 947939 REPAIR KIT (Inc., 3, 4) 7 2776 t BRAKE DISC tnot Illustrated Not Sold Separately *NOTE: 55 III A uses two 2777 Brake Head Assemblies; Quantities listed for s thru 5 are per assembly. [ 44 ] PM 2543
CUIRK MICHIG BRAKE HEAD ASSEMBLY - R.H. A 2778 *BRAKE HEAD ASSY, R.H. (Inc. thru 5) 947926 TUBE & NUT ASSY 2 947927 VALVE, Hydraulic Bleeder 3 947928 VALVE, Hydraulic Bleeder 4 947930 BOLT, Self Locking 4 5 94793 PIN, Carrier & Lining Retaining 4 6 947932 CARRIER & LINING ASSY 2 7 C-620 BOLT, Cap Mounting 8 8 03293 WASHER, Flat 8 9 947934 CAP 0 947933 CAP, Inlet PACKING, See 6 2 2 947935 PISTON 4 3 BOOT, See 6 4 4 PACKING, See 6 4 5 947940 TORQUE PLATE ASSY 6 947939 t REPAIR KIT (Inc., 3, 4) 7 2776 t BRAKE DISC finot Illustrated Not Sold Separately *NOTE: 55 III A uses two 2778 Brake Head Assemblies; Quantities listed for s thru 5 are per assembly. PM 2543 [ 45 ]
CLeiRK MICHIGAll PLANET CARRIER ASSEMBLY - FRONT AND REAR A 2788 CARRIER ASSY, Planet (Inc. thru ) NOTE: Four (4) Planet Carrier Assemblies used per machine. Quantities listed below are for Planet Carrier. 06350 WASHER, Pinion Thrust 3 2 2792 ROLLER, Pinion 87 3 06352 SPACER, Roller 3 4 2790 PINION, Planet 3 5 2792 ROLLER, Pinion 87 6 06352 SPACER, Roller 3 7 279 SHAFT, Pinion 3 8 79553 0-RING, Pinion Shaft 3 9 2789 SPIDER, Planet 0 266 WASHER, Thrust 65484 PIN, Roll 3 4.) [ 46 ] PM 2543
CUIRK MICHIGIM 9 0 ) 32 3 3 4 5 6 8 30 29 28 2 26 25 24 23 TS-3227-P POWER CLUSTER ASSEMBLY A 540555 POWER CLUSTER ASSY 8 2C-74 BOLT, Cylinder to Brk. 2 (Inc. thru 32A) 9 4E-07 LKWSHR, Cylinder to Brk. 2 945033 SHELL, Air Cylinder 20 ---- VALVE, Check See 33 2 ---- CUP, Piston See 33 2 945026 SPRING, Check Valve 3 ---- WIPER, Piston See 33 22 945042 RETAINER, Spring 4 945032 PISTON, Air Cylinder 23 87400 SPRING, Piston Return 5 ---- BOOT, Piston See 33 24 ---- CUP, Piston See 33 6 94503 SPRING, Piston Return 25 PISTON, Master Cylinder 7 945028 HEAD ASSY, Air Cylinder See 33 (Inc. 8 thru ) 26 874003 PLATE, Piston Stop 8 945029 SCREEN, Filtering 27 874028 RING, Stop Plate Lock 9 945044 HAIR, Filtering 28 945030 0 945029 INDICATOR, Stroke SCREEN, Filtering 945043 RING, Filter Retaining 29 945023 BAND, Sealing 2 2C-74 BOLT, Cylinder to Brk. 2 30 945024 BRACKET, Cyl. Support 2A 4E-07 LKWSHR, Cylinder to Brk. 2 3 C-66 BOLT, Brk. to Head 3 3 860205 CAP, Filler 3A 4E-06 LKWSHR, Brk. to Head 4 4 850287 GASKET, Filler Cap 32 C-50 BOLT, Head to Cyl. 8 5 85806 SCREW, Cylinder Bleeder 32A 6E-05 LKWSHR, Head to Cyl. 8 6 945800 CASTING, Master Cylinder 33 945025 REPAIR KIT (Inc. 2, 3, 5, 20, 7 0E-02 PLUG, Master Cylinder 24, 25) Not Sold Separately PM 2543 [ 47 ]
CUIRK MICHIGAI ) ) ) PARKING BRAKE CONTROLS 545005 SPACER, Lever Mounting 2 2 8D-05 NUT, Cable Mounting 2 3 OMIT, Not Used on This Application 4 545006 SPACER, Cable Mounting 2 5 54452 CLAMP, Cable 6 645092 LINK, Cable Clamp 7 53660 CABLE, Parking Brake 8 8D-06 NUT, Clamp 2 9 OMIT, Not Used on This Application 0 645092 LINK, Cable Clamp 4F-0606 PIN, Cable Clevis 2 F-32 COTTER, Clevis Pin 3 54452 CLAMP, Cable 4 24C-620 BOLT, Cable Clamp 2 5 24C-528 BOLT, Cable Clamp 2 6 24C-644 BOLT, Lever Mounting 2 7 PARKING BRAKE LEVER ASSY See Index 8 545006 SPACER, Lever Mounting 2 9 8D-06 NUT, Lever Mounting 2 ) [ 48 ] PM 2543
CUIRK MICHIGAll 2 TS-3240-P PARKING BRAKE LEVER ASSEMBLY A 2 3 4 5 6 7 8 9 0 544998 866349 94227 94226 94663 866348 69024 862738 862656 862653 862655 LEVER ASSY (Inc. thru 20) SCREW, Adjusting CAP, Adjusting Knob BASE, Adjusting Knob WASHER, Base to Body BODY, Brake Lever WASHER, Body to Brk. PIN, Adj. Screw Link Pivot SPACER, Pivot Bracket BRACKET, Pivot SPACER, Pivot Bracket 2 2 3-4 5 6 7 8 9 20 862653 862656 F-32 645095 944969 6909 944054 862652 94238 944968 BRACKET, Pivot SPACER, Pivot Bracket COTTER, Link Pivot Pin SPACER, Mounting Brk. BRACKET, Lever Mtg. WASHER, Link Pivot Pin RIVET, Pivot Bracket LINK, Adjusting Screw PIN, Link to Tube TUBE, Adjusting Screw 2 2 PM 2543 [ 49 ] PM 2429
CLeiRK MICHIG BRAKE VALVE AND CONTROLS. F-320 COTTER, Pedal to Pin 2 53930 PEDAL ASSY, Air Brake 3 58259 ROLLER, Pedal 4 F-32 COTTER, Pedal to Pin 5 875766 PIN, Pedal to Roller 6 F-320 COTTER, Pedal to Pin 7 53930 PEDAL ASSY, Air Brake 8 58259 ROLLER, Pedal 9 F-32 COTTER, Pedal to Pin 0 875766 PIN, Pedal to Roller 875767 PIN, Pedal to Valve 2 945996 *VALVE, Air Brake (B.W. 277472) 3 8D-05 NUT,Valve Mounting 3 4 24C-520 BOLT, Valve Mounting 3 5 875767 PIN, Pedal to Valve 6 945996 *VALVE, Air Brake (B.W. 277472) 7 8D-05 NUT,Valve Mounting 3 8 24C-520 BOLT, Valve Mounting 3 *NOTE: Your local authorized Bendix -Westinghouse Distributor is equipped to service components of these parts. [ 50 ] PM 2543
CUIRK MICHIG NOTES PM 2543 [5]
44 atl's 2 20 9 8.4445 i 0 )5 440 28 22" 23/.4 or 24 25/ 26 27 6 30 29 c,a; ' 332 33 34 42 / 4 40 35 36 (ft //23 39 3 30 /I / V -7 a 45 ftt, 47 48 0 z 70 n 0 z 86 8 90 89 88 ye* 85 % 84 6 83 (rfic 8 2 54 79 80 55 70 NA. t 82 8 2 76 f (0 (* 5 4 68 A 67 66 65 *ri 63 3 56 62 4,40 6 4 60 59 57 5 53 52 49 5 / 50 7: N 0 z a C7 BRAKE AIR LINES TS-9555-P
CLeiRK MICHIGAll BRAKE AIR LINES 8D-06 NUT, Bracket to Frame 4 46 2 9483 *BRACKET (B.W. #22399) 2 47 3 24C-620 BOLT, Bracket to Frame 4 48 4 28F-3 TEE, Hose to Reservoir 49 5 526090 HOSE, Tube to Reservoir 50 6 5K-409 NIPPLE, Tee to Reservoir 5 7 9F-4 BUSHING, Reducing 52 8 3F- ADAPTER, Hose to Reservoir 53 9 540607 TUBE, Hose to Power Cluster 54 0 87F-4 CONNECTOR, Tube to Power Cluster 55 87F-4 CONNECTOR, Tube to Power Cluster 56 2 63750 WASHER, Connector to 57 Power Cluster 2 58 3 874007 PLUG, Master Cylinder 59 4 24C-74 BOLT, Power Cluster Mtg. 2 60 5 24C-78 BOLT, Power Cluster Mtg. 3 6 5K-308 NIPPLE, Valve to Cluster 6 7 532592 *VALVE, Check (B.W. 62 # 22894) 8 9F-6 BUSHING, Reducing 63 9 ---- POWER CLUSTER (See Index) 64 20 24C-74 BOLT, Power Cluster Mtg. 2 56858 TUBE, Hose to Hose 65 22 26F-2 ELBOW, Sender to Valve 66 23 9F- BUSHING, Reducing 67 24 53435 SENDER, Air Pressure 68 (Inc. 25, 26) 69 25 2E-0 LKWSHR, Sender Unit 26 4D-0 NUT, Sender Unit 70 27 593484 HOSE, Valve to Valve 28 3F-4 ADAPTER UNION 7 29 9F-4 BUSHING, Reducing 30 ---- OMIT, Not Used This 72 Application 73 3 OMIT, Not Used This 74 Application 75 32 636260 SWITCH, Pressure 76 33 356609 ADAPTER UNION 77 34 42F-4 CONNECTOR, Tube to Valve 35 9F-4 0-RING, Connector 78 36 5K-4 CONNECTOR, Tube to 79 Cylinder (Inc. 35) 37 592742 HOSE, Valve to Valve 80 38 ---- BRAKE FOOT VALVE 8 R.H. See Index 82 39 3F-04 PLUG, Brake Valve 2 83 40 3F-08 PLUG, Brake Valve 8 84 4 592742 HOSE, Valve to Valve 85 42 ---- BRAKE FOOT VALVE 86 L.H. (See Index) 87 43 3F-4 ADAPTER UNION, Hose to 88 Valve 89 44 57695 HOSE, Tube to Valve 45 26F-4 ELBOW, Hose to Valve 90 45A 25F-4 ELBOW, Hose to Valve 9 30E-3 TEE, Hose to Valve 53996 TUBE, Cylinder to Tee L.H. 0K-4 TEE, Tube to Tube 539958 TUBE, Cylinder to Tee R.H. 9F-4 0-RING, Connector 5K-4 CONNECTOR (Inc. 50) 54034 TUBE, Hose to Tee 50868 TUBE, Compressor Intake 23C-544 BOLT, Governor to Compressor 2 4E-05 LKWSHR, Governor to Compressor 2 3F- ADAPTER UNION 54586 CLAMP, Hose to Tube 2 529979 HOSE, Tube to Elbow 23C-532 BOLT, Elbow to Compressor 4E-05 LKWSHR, Elbow to Compressor 540888 ELBOW, Inlet to Compressor 87502 GASKET, Elbow to Compressor 23C-56 BOLT, Flange to Compressor 2 4E-05 LKWSHR, Flange to Compressor 2 32F-4 ADAPTER, Hose to Nipple 5K-42 NIPPLE, Flange to Adapter 50452 FLANGE, Discharge 95948 GASKET, Flange Discharge 54557 HOSE, Reservoir to Compressor 942646 GASKET, Governor to Compressor 540306 *GOVERNOR, Compressor (B.W. #275200) 593435 HOSE, Governor to Reservoir 540322 HOSE, Tube to Tube 38F-3 CONNECTOR, Tube to Trans. 545846 TUBE, Valve to Trans. 540606 TUBE, Hose to Cluster 593370 *VALVE, Check (B.W. #22894) 29F-3 ELBOW, Hose to Valve 53842 *RESERVOIR, Air (B.W. #22790)...7--2K4 IL F - lia DRAIN COCK 9F-4. 0-RING, Connector 5K-4 CR.4 V CONNECTOR (Inc. 8) 539960 TUBE, Tee to Brake R.H. 540696 HOSE, Tube to Tee 539959 TUBE, Tee to Brake L.H. 9F-4 0-RING, Connector 5K-4 CONNECTOR (Inc. 86) 0K-4 TEE, Tube to Tube 50785 *VALVE, Safety (B.W. 9F-5 26F-3 t Not I llustrated "NOTE: Your local authorized Bendix-Westinghouse Distributor is equipped to service components of these parts. #20505) BUSHING, Tee to Reservoir f ELBOW, Compressor Drain _ PM 2543 [ 53 ]
n 0 Z tn " 73 C n -4... 0 Z 0 4. 3 I:. n Z Z rn M CI IA... 0 Z 3 " UI A 43 a = CI =
CUIRK STEERING GEAR ASSEMBLY MICHIGIIM A 566434 GEAR ASSY (Inc. thru, 3 thru 20, 24 thru 49, 5, 52, 53) 25 0J-09 25A 853526 BALL 06 tguide, Ball Return 4 850756 NUT, Pitman Arm 26 853525 NUT, Ball 2 4E-8 LKWSHR, Pitman Arm 27 2E-06 LKWSHR, Side Cover 3 3 85339 SEAL, Pitman Shaft Grease 28 C-62 BOLT, Side Cover 3 4 853357 BUSHING, Pitman Shaft 29 85382 COVER, Hsg. Side (Inc. 33) 5 945334 VALVE ASSY (Inc. 42, 43, 44) 30 85387 SHIM KIT, Lash Adjuster 6 73G-732 BOLT, Adapter to Housing 4 3 8D-07 NUT, Lash Adjuster 6A 4E-07 t LKWSHR, Adapter to Hsg. 4 32 85770 ADJUSTER, Lash 7 943426 8 88685 9 853380 0 85762 ADAPTER, Valve to Hsg. (Inc. 36, 37) 0-RING, Spacer to Adapter GASKET, Adapter to Housing BOLT & WASHER ASSY, Clamp 33 34 85756 35 940 36 8674 37 25K-4008 BUSHING, Side Cover GASKET, Side Cover GEAR, Pitman Shaft BEARING, Adapter 0-RING, Adapter 853527 CLAMP, Ball Return Guide 38 860997 BEARING, Worm Thrust 2 *ELBOW, Filler 39 943438 WASHER, Worm Thrust 3 73043 BEARING, Needle 40 306626 0-RING, Valve to Spacer 4 94638 HOUSING ASSY (Inc. 4, 3) 4 943440 SPACER, Valve 5 5K-432 NIPPLE, Filler 42 SPOOL, Valve See 5 6 22F-4 CAP, Filler 43 943437 SPRING, Valve 4 7 94639 8 857729 9 86768 SHAFT ASSY (Inc. 0,, 25, 25A, 26) BEARING ASSY, Upper WASHER, Upper Bearing 44 943436 45 943438 46 306626 47 860997 PLUNGER, Valve 8 WASHER, Bearing Thrust 0-RING, Valve to Spacer BEARING, Worm Thrust 20 853395 SPRING, Upper Bearing 48 3E-08 LKWSHR, End Cover 6 2 5833 WHEEL, Steering 49 C-888 BOLT, End Cover 6 22 548074 PLATE, Operating Precaution 50 566433 ARM, Pitman 22A 65G-406 t SCREW, Plate Attaching 4 5 873250 NUT, Worm Bearing Lock 23 648304 NUT, Steering Wheel 52 943439 COVER, Valve End 24 853384 KEY, Steering Wheel 53 943429 SPRING, Valve Spool Preload Not Sold Separately t Not Illustrated *NOTE: This item is not used on this machine. PM 2543 [ 55 ]
CUIRK MICHIG STEERING GEAR MOUNTING GROUP 8D-06 NUT, "U" Bolt 2 2 5744 "U" BOLT, Steering Gear to Cockpit 3 STEERING GEAR ASSY See Index 4 54594 "U" BOLT, Steering Gear to Cockpit 5 8D-08 NUT, Steering Gear Clamp 2 6 PITMAN ARM See Index 7 DRAG LINK See Index 8 8C-836 BOLT, Steering Gear Clamp 2 9 550044 CLAMP, Steering Gear 0 40K-02 PLUG, Steering Valve 8D-08 NUT, "U" Bolt 2 [ 56 ] PM 2543
CUIRK mini um STEERING DRAG LINK A 568070 DRAG LINK ASSY (Inc. 2, 3, 5 thru 0, 2 thru 5) F-432 COTTER 2 876575 NUT, Adjusting 3 865965 SEAT, Ball Stud 4 2H-5 FITTING, Grease 5 865965 SEAT, Ball Stud 6 86596 SPRING 7 66269 SEAT, Spring 8 865963 SEAT 9 865963 SEAT 0 865965 SEAT, Ball Stud 0H-25 FITTING, Grease 2 865965 SEAT, Ball Stud 3 86596 SPRING 4 66269 SEAT, Spring 5 876575 NUT, Adjusting 6 F-432 COTTER PM 2543 [ 57 ]
CLARK MICHIGAll STEERING CYLINDER ASSEMBLY 5" A 508904 CYLINDER ASSY (Inc. thru 3, 6 thru 20 and 22) 2 NOTE: Two (2) Cylinders used on machine Quantities listed below are for one () Cylinder 23C-56 BOLT, Seal Retainer 3 2 4E-05 LKWSHR, Seal Retainer 3 3 508905 CYLINDER 4 7348 BUSHING, Cylinder 5 2H-5 FITTING, Grease 6 50375 NUT, Piston Rod 7 F-640 COTTER, Piston Rod Nut 8 530264 RING, Piston Wear 9 50363 RING, Piston Outer Seal 0 503629 RING, Piston Inner Seal 503639 PISTON 2 530264 RING, Piston Wear 3 25K-4004 0-RING, Piston Rod 4 73678 0-RING, Cylinder Cap 5 53027 CAP, Cylinder 6 530266 WIPER, Piston Rod 7 25K-40308 0-RING, Cylinder Cap 8 53297 RING, Back-Up 9 530263 RING, Snap 20 530268 RETAINER, Plate 2 0H-25 FITTING, Grease 22 5089 PISTON ROD (Inc. 3) 23 7348 BUSHING, Piston Rod [ 58] PM 2543
CLARK michican PRESSURE RELIEF VALVE - STEERING SYSTEM A 536539 VALVE ASSY (Inc. thru 7) 47D-05 NUT, Acorn 2 730396 WASHER, Stat-O-Seal 2 3 944467 CAP, Valve 4 883734 PLUNGER, Pilot 5 899039 0-RING 6 944469 SEAT, Pilot 7 944646 SPRING 8 944645 SEAT, Poppet 9 BODY, Valve Order "A" 0 SCREEN, Poppet Order 944643 POPPET ASSY (Inc. 0) 2 899038 RING, Back-Up 3 94447 SPRING, Pilot 4 9F-6 0-RING, Valve Cap 5 8D-05 NUT, Jam 6 33G-54 SCREW, Adjusting Set 7 40K-02 -[PLUG 2 Not Sold Separately f Not Illustrated PM 2543 [ 59 ]